BMW R1200GS Motorcycle (W348)

Customer Service Guide

MMXV © Copyright Rollplay

1

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

Contents

I) Check Battery …………………………............................................. 3

II) Check Wiring Condition ……………………………..………………………. 6

III) Windshield Replacement ……………………………………………..….…. 9

IV) Gearbox Replacement ……………………………………………………… 10

V) Warning Stickers ……………………………………………..…….………… 14

VI) Schematic diagram ……………..…………….…..….………..…………. 17

VII) Exploded View ………………………....…....….……….……..……..… 18

CAUTION :
Disconnect the battery before proceeding
with the following steps.

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

I) Check Battery
Operation: Use a Flat head screwdriver to unlock and remove the seat. Locate the
battery harness, unplug the connector, and then use a volt-meter to check the
condition of the battery.

Step (1)

Turn and unlock this plastic knob

Step (2)

Unlock position

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

I) Check Battery

Step (3)

Lift up the seat cover from the rear end

Step (4)

Unplug the battery connector underneath the seat

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

I) Check Battery

Step
(5)

Reading Judgment: 6.0 V ~ 6.5 V – Good condition

5.6 V ~ 5.9 V – Recharge battery
5.5 V – Recharge battery. If after the stipulated
recharging time the voltage has not
increased, then replace the battery.
Below 5.5 V – Replace the battery.

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

II) Check Wiring Connection

Operation: There are two wiring connections that should be checked.

A. Motor/Gearbox : Turn over the vehicle and locate the Gearbox harness at the
bottom.

Step (1)

The motor harness is near the rear wheel

Step (2)

Check the white connectors. Disconnect, then reconnect these connectors.

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

II) Check Wiring Connection

B. Handlebar/Sounds : Disassemble the windshield and check the two

connections per the below procedures.

Use a flat screwdriver to remove the bracket next to the windshield

Step (1)

Release the latch at the front

Step (2)

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

II) Check Wiring Connection

Step (3)

Lift up the whole windshield

Check for any loose connections on the handlebars.

Step (4)

Reverse the above procedures to reassemble the vehicle.

8

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

III) Windshield Replacement

Operation: Follow the procedure (IIb) to detach the windshield, and then unplug the two
connectors to remove it completely for replacing.

Replace the Handlebar sub-assembly with a new one.

Reverse above procedures to re-assemble the vehicle

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

IV) Gearbox Replacement

Operation: Follow below steps to replace the gearbox.

Use the two plastic wrenches to remove the nuts at both sides

Step (1)

Step (2)

Unscrew the motor cover on the left side of rear wheel.

10

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

IV) Gearbox Replacement

Step (3)

Hold and pull out the motor cover as shown.

There are two latches help to hold the cover in place

Step (4)

11

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

IV) Gearbox Replacement

Slide the rear axle out from the opposite side of the
gearbox. There is no need to remove it completely, just
enough to release the gearbox.

Step (5)

Step (6)

Remove the gearbox from the rear wheel assembly.

12

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

IV) Gearbox Replacement

Unplug the motor connector (white)

Step (7)

Replace the gearbox

with a new/good one

Step (8)

Reverse above procedures to re-assemble the vehicle 13

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

V) Warning Stickers

Operation: Check and re-put the damaged warning stickers after repairing.
(1) Bottom side of car body (underneath of rear fender)

14

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

V) Warning Stickers

(2) Bottom side of Seat

15

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

V) Warning Stickers

(3) Battery harness

16

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

VI) Wiring Schematic

17

Downloaded from www.Manualslib.com manuals search engine

 Customer Service Guide

VII) Exploded View

18

Downloaded from www.Manualslib.com manuals search engine