Version: 1.
1
Revision Date: 02-23-2016
SAFETY DATA SHEET
1. Identification
Product identifier: PETROLEUM ETHER
Other means of identification
Synonyms: Ligroine, Petroleum Naphtha, VM&P Naphtha
Product No.: 6128, H489, 4983, 4980, 9270, 4976, 9268, 4971, 9265
Recommended use and restriction on use
Recommended use: Not available.
Restrictions on use: For industrial use only.
Details of the supplier of the safety data sheet
Manufacturer
Company Name: Avantor Performance Materials, Inc.
Address: 3477 Corporate Parkway, Suite 200
Center Valley, PA 18034
Telephone: Customer Service: 855-282-6867
Fax: 610-573-2610
Contact Person: Environmental Health & Safety
E-mail: info@avantormaterials.com
Emergency telephone number:
CHEMTREC: 1-800-424-9300 within US and Canada
CHEMTREC: 1-703-527-3887 outside US and Canada
2. Hazard(s) identification
Hazard Classification
Physical Hazards
Flammable liquids Category 2
Health Hazards
Germ Cell Mutagenicity Category 1B
Carcinogenicity Category 1B
Aspiration Hazard Category 1
Label Elements
Hazard Symbol:
Signal Word: Danger
SDS_US - SDS000001091 1/10
Version: 1.1
Revision Date: 02-23-2016
Hazard Statement: Highly flammable liquid and vapor.
May be fatal if swallowed and enters airways.
May cause genetic defects.
May cause cancer.
Precautionary
Statement
Prevention: Obtain special instructions before use. Do not handle until all safety
precautions have been read and understood. Use personal protective
equipment as required. Keep away from heat, hot surfaces, sparks, open
flames and other ignition sources. No smoking.
Response: IF exposed or concerned: Get medical advice/attention. IF SWALLOWED:
Immediately call a POISON CENTER or doctor/physician. Do NOT induce
vomiting.
Storage: Store locked up. Store in a well-ventilated place. Keep container tightly
closed. Keep cool.
Disposal: Dispose of contents/container to an appropriate treatment and disposal
facility in accordance with applicable laws and regulations, and product
characteristics at time of disposal.
Other hazards which do not None.
result in GHS classification:
3. Composition/information on ingredients
Substances
Common name and
Chemical Identity CAS number Content in percent (%)*
synonyms
Petroleum Ether 8032-32-4 90 - 100%
* All concentrations are percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume.
4. First-aid measures
General information: Get medical advice/attention if you feel unwell. Show this safety data sheet
to the doctor in attendance.
Ingestion: If ingested, material may be aspirated into the lungs and cause chemical
pneumonitis. Treat appropriately. Do not induce vomiting. If vomiting
occurs, the head should be kept low so that stomach vomit doesn't enter
the lungs. Call a physician or poison control center immediately.
Inhalation: Move to fresh air. Get medical attention if symptoms persist.
Skin Contact: Immediately flush with plenty of water for at least 15 minutes while
removing contaminated clothing and shoes. Call a physician or poison
control center immediately. Wash contaminated clothing before reuse.
Destroy or thoroughly clean contaminated shoes.
Eye contact: Immediately flush with plenty of water for at least 15 minutes. If easy to do,
remove contact lenses. Get medical attention immediately.
Most important symptoms/effects, acute and delayed
Symptoms: Irritating to eyes, respiratory system and skin.
Hazards: Irritant.
SDS_US - SDS000001091 2/10
Version: 1.1
Revision Date: 02-23-2016
Indication of immediate medical attention and special treatment needed
Treatment: Treat symptomatically. Monitor all inhalations and ingestions for signs of
toxicity and development of pulmonary edema for at least 6 hours.
Symptoms may be delayed.
5. Fire-fighting measures
General Fire Hazards: Flammable liquid and vapor. Fire may produce irritating, corrosive and/or
toxic gases.
Suitable (and unsuitable) extinguishing media
Suitable extinguishing Foam, carbon dioxide or dry powder.
media:
Unsuitable extinguishing Water may be ineffective in fighting the fire.
media:
Specific hazards arising from Heat may cause the containers to explode. Vapors are flammable and
the chemical: heavier than air. Vapors may travel across the ground and reach remote
ignition sources causing a flashback fire danger.
Special protective equipment and precautions for firefighters
Special fire fighting Move containers from fire area if you can do so without risk. Use water
procedures: spray to keep fire-exposed containers cool. Cool containers exposed to
flames with water until well after the fire is out.
Special protective equipment Firefighters must use standard protective equipment including flame
for fire-fighters: retardant coat, helmet with face shield, gloves, rubber boots, and in
enclosed spaces, SCBA.
6. Accidental release measures
Personal precautions, Keep unauthorized personnel away. Keep upwind. ELIMINATE all ignition
protective equipment and sources (no smoking, flares, sparks or flames in immediate area). Ventilate
emergency procedures: closed spaces before entering them. Use personal protective equipment.
See Section 8 of the SDS for Personal Protective Equipment.
Methods and material for Eliminate all ignition sources if safe to do so. Use only non-sparking tools.
containment and cleaning Absorb spill with vermiculite or other inert material, then place in a container
up: for chemical waste. Clean surface thoroughly to remove residual
contamination. Dike far ahead of larger spill for later recovery and disposal.
Notification Procedures: Dike for later disposal. Prevent entry into waterways, sewer, basements or
confined areas. Stop the flow of material, if this is without risk. Inform
authorities if large amounts are involved.
Environmental Precautions: Prevent further leakage or spillage if safe to do so. Do not contaminate
water sources or sewer. Avoid discharge into drains, water courses or onto
the ground.
SDS_US - SDS000001091 3/10
Version: 1.1
Revision Date: 02-23-2016
7. Handling and storage
Precautions for safe handling: Do not handle until all safety precautions have been read and understood.
Obtain special instructions before use. Use personal protective equipment
as required. Do not eat, drink or smoke when using the product. Wash
hands thoroughly after handling. Avoid contact with eyes, skin, and
clothing.
Conditions for safe storage, Keep containers tightly closed. Store away from heat and light. Store in a
including any cool, dry place with adequate ventilation. Keep away from incompatible
incompatibilities: materials, open flames, and high temperatures.
8. Exposure controls/personal protection
Control Parameters
Occupational Exposure Limits
None of the components have assigned exposure limits.
Appropriate Engineering Provide adequate ventilation if fumes or vapors are generated. Explosion-
Controls proof general and local exhaust ventilation.
Individual protection measures, such as personal protective equipment
General information: Good general ventilation (typically 10 air changes per hour) should be used.
Ventilation rates should be matched to conditions. If applicable, use
process enclosures, local exhaust ventilation, or other engineering controls
to maintain airborne levels below recommended exposure limits. If
exposure limits have not been established, maintain airborne levels to an
acceptable level. An eye wash and safety shower must be available in the
immediate work area.
Eye/face protection: Wear safety glasses with side shields (or goggles).
Skin Protection
Hand Protection: Chemical resistant gloves
Other: Wear suitable protective clothing.
Respiratory Protection: In case of inadequate ventilation use suitable respirator. Chemical
respirator with organic vapor cartridge and full facepiece.
Hygiene measures: Provide eyewash station and safety shower. Always observe good personal
hygiene measures, such as washing after handling the material and before
eating, drinking, and/or smoking. Routinely wash work clothing and
protective equipment to remove contaminants. Avoid contact with eyes,
skin, and clothing.
9. Physical and chemical properties
Appearance
Physical state: liquid
Form: liquid
Color: Colorless
Odor: kerosene
Odor threshold: No data available.
pH: No data available.
Melting point/freezing point: < -73 °C
Initial boiling point and boiling range: 60 - 80 °C
Flash Point: -18 °C
SDS_US - SDS000001091 4/10
Version: 1.1
Revision Date: 02-23-2016
Evaporation rate: Approximate 10 (butyl acetate=1)
Flammability (solid, gas): No data available.
Upper/lower limit on flammability or explosive limits
Flammability limit - upper (%): 5.9 %(V)
Flammability limit - lower (%): 1.1 %(V)
Explosive limit - upper (%): No data available.
Explosive limit - lower (%): No data available.
Vapor pressure: 5.3 kPa
Vapor density: No data available.
Relative density: Approximate 0.68 (20 °C)
Solubility(ies)
Solubility in water: Insoluble in water
Solubility (other): No data available.
Partition coefficient (n-octanol/water): No data available.
Auto-ignition temperature: 550 °F
Decomposition temperature: No data available.
Viscosity: No data available.
10. Stability and reactivity
Reactivity: No dangerous reaction known under conditions of normal use.
Chemical Stability: Material is stable under normal conditions.
Possibility of hazardous Hazardous polymerization does not occur.
reactions:
Conditions to avoid: Heat, sparks, flames. Sunlight. Contact with incompatible materials.
Incompatible Materials: Strong oxidizing agents. May attack some plastics, rubber and coatings.
Hazardous Decomposition Oxides of Carbon.
Products:
11. Toxicological information
Information on likely routes of exposure
Ingestion: May irritate and cause stomach pain, vomiting and diarrhoea.
Inhalation: Mist or vapors may cause irritation.
Skin Contact: May cause irritation.
Eye contact: May irritate eyes.
Information on toxicological effects
Acute toxicity (list all possible routes of exposure)
Oral
Product: No data available.
Dermal
Product:
No data available.
Inhalation
Product: LC 50 (Rat, 4 h): 3,400 mg/l
SDS_US - SDS000001091 5/10
Version: 1.1
Revision Date: 02-23-2016
Repeated dose toxicity
Product: No data available.
Skin Corrosion/Irritation
Product: May cause skin irritation.
Serious Eye Damage/Eye Irritation
Product: Vapor or spray in the eyes may cause irritation and smarting.
Respiratory or Skin Sensitization
Product: Not a skin sensitizer.
Carcinogenicity
Product: May cause cancer.
IARC Monographs on the Evaluation of Carcinogenic Risks to Humans:
No carcinogenic components identified
US. National Toxicology Program (NTP) Report on Carcinogens:
No carcinogenic components identified
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050):
No carcinogenic components identified
Germ Cell Mutagenicity
In vitro
Product: No mutagenic components identified
In vivo
Product: May cause genetic defects.
Reproductive toxicity
Product: No components toxic to reproduction
Specific Target Organ Toxicity - Single Exposure
Product: None known.
Specific Target Organ Toxicity - Repeated Exposure
Product: None known.
Aspiration Hazard
Product: May be fatal if swallowed and enters airways.
Other effects: None known.
12. Ecological information
Ecotoxicity:
Acute hazards to the aquatic environment:
Fish
Product: No data available.
Aquatic Invertebrates
Product: No data available.
Chronic hazards to the aquatic environment:
Fish
SDS_US - SDS000001091 6/10
Version: 1.1
Revision Date: 02-23-2016
Product: No data available.
Aquatic Invertebrates
Product: No data available.
Toxicity to Aquatic Plants
Product: No data available.
Persistence and Degradability
Biodegradation
Product: There are no data on the degradability of this product.
BOD/COD Ratio
Product: No data available.
Bioaccumulative Potential
Bioconcentration Factor (BCF)
Product: No data available on bioaccumulation.
Partition Coefficient n-octanol / water (log Kow)
Product: No data available.
Mobility in Soil: The product is insoluble in water and will spread on the water surface.
Other Adverse Effects: There are no data on the ecotoxicity of this product.
13. Disposal considerations
Disposal instructions: Discharge, treatment, or disposal may be subject to national, state, or local
laws.
Contaminated Packaging: Since emptied containers retain product residue, follow label warnings even
after container is emptied.
14. Transport information
DOT
UN Number: UN 1268
UN Proper Shipping Name: Petroleum distillates, n.o.s.
Transport Hazard Class(es)
Class(es): 3
Label(s): 3
Packing Group: II
Marine Pollutant: Not a Marine Pollutant
Special precautions for user: –
IMDG
UN Number: UN 1268
UN Proper Shipping Name: PETROLEUM DISTILLATES, N.O.S.
Transport Hazard Class(es)
Class(es): 3
Label(s): 3
EmS No.: F-E, S-E
Packing Group: II
Marine Pollutant: Not a Marine Pollutant
Special precautions for user: –
SDS_US - SDS000001091 7/10
Version: 1.1
Revision Date: 02-23-2016
IATA
UN Number: UN 1268
Proper Shipping Name: Petroleum distillates, n.o.s.
Transport Hazard Class(es):
Class(es): 3
Label(s): 3
Marine Pollutant: Not a Marine Pollutant
Packing Group: II
Special precautions for user: –
15. Regulatory information
US Federal Regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
None present or none present in regulated quantities.
CERCLA Hazardous Substance List (40 CFR 302.4):
None present or none present in regulated quantities.
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Hazard categories
Acute (Immediate)
Chronic (Delayed)
Fire
SARA 302 Extremely Hazardous Substance
None present or none present in regulated quantities.
SARA 304 Emergency Release Notification
None present or none present in regulated quantities.
SARA 311/312 Hazardous Chemical
Chemical Identity Threshold Planning Quantity
Petroleum Ether 10000 lbs
SARA 313 (TRI Reporting)
None present or none present in regulated quantities.
Clean Water Act Section 311 Hazardous Substances (40 CFR 117.3)
None present or none present in regulated quantities.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130):
None present or none present in regulated quantities.
US State Regulations
US. California Proposition 65
No ingredient regulated by CA Prop 65 present.
US. New Jersey Worker and Community Right-to-Know Act
Chemical Identity
Petroleum Ether
US. Massachusetts RTK - Substance List
No ingredient regulated by MA Right-to-Know Law present.
US. Pennsylvania RTK - Hazardous Substances
Chemical Identity
Petroleum Ether
SDS_US - SDS000001091 8/10
Version: 1.1
Revision Date: 02-23-2016
US. Rhode Island RTK
No ingredient regulated by RI Right-to-Know Law present.
Inventory Status:
Australia AICS: On or in compliance with the inventory
Canada DSL Inventory List: On or in compliance with the inventory
EINECS, ELINCS or NLP: On or in compliance with the inventory
Japan (ENCS) List: Not in compliance with the inventory.
China Inv. Existing Chemical Substances: On or in compliance with the inventory
Korea Existing Chemicals Inv. (KECI): On or in compliance with the inventory
Canada NDSL Inventory: Not in compliance with the inventory.
Philippines PICCS: On or in compliance with the inventory
US TSCA Inventory: On or in compliance with the inventory
New Zealand Inventory of Chemicals: On or in compliance with the inventory
Japan ISHL Listing: Not in compliance with the inventory.
Japan Pharmacopoeia Listing: Not in compliance with the inventory.
16.Other information, including date of preparation or last revision
NFPA Hazard ID
4 Flammability
Health
2 0
Reactivity
Special hazard.
Hazard rating: 0 - Minimal; 1 - Slight; 2 - Moderate; 3 - Serious; 4 - Severe; RNP - Rating not possible
Issue Date: 02-23-2016
Revision Date: No data available.
Version #: 1.1
Further Information: No data available.
SDS_US - SDS000001091 9/10
Version: 1.1
Revision Date: 02-23-2016
Disclaimer: THE INFORMATION PRESENTED IN THIS MATERIAL SAFETY DATA
SHEET (MSDS/SDS) WAS PREPARED BY TECHNICAL PERSONNEL
BASED ON DATA THAT THEY BELIEVE IN THEIR GOOD FAITH
JUDGMENT IS ACCURATE. HOWEVER, THE INFORMATION PROVIDED
HEREIN IS PROVIDED “AS IS,” AND AVANTOR PERFORMANCE
MATERIALS MAKES AND GIVES NO REPRESENTATIONS OR
WARRANTIES WHATSOEVER, AND EXPRESSLY DISCLAIMS ALL
WARRANTIES REGARDING SUCH INFORMATION AND THE PRODUCT
TO WHICH IT RELATES, WHETHER EXPRESS, IMPLIED, OR
STATUTORY, INCLUDING WITHOUT LIMITATION, WARRANTIES OF
ACCURACY, COMPLETENESS, MERCHANTABILITY, NON-
INFRINGEMENT, PERFORMANCE, SAFETY, SUITABILITY, STABILITY,
AND FITNESS FOR A PARTICULAR PURPOSE, AND ANY WARRANTIES
ARISING FROM COURSE OF DEALING, COURSE OF PERFORMANCE,
OR USAGE OF TRADE. THIS MSDS/SDS IS INTENDED ONLY AS A
GUIDE TO THE APPROPRIATE PRECAUTIONARY HANDLING OF THE
MATERIAL BY A PROPERLY TRAINED PERSON USING THIS PRODUCT,
AND IS NOT INTENDED TO BE COMPREHENSIVE AS TO THE MANNER
AND CONDITIONS OF USE, HANDLING, STORAGE, OR DISPOSAL OF
THE PRODUCT. INDIVIDUALS RECEIVING THIS MSDS/SDS MUST
ALWAYS EXERCISE THEIR OWN INDEPENDENT JUDGMENT IN
DETERMINING THE APPROPRIATENESS OF SUCH ISSUES.
ACCORDINGLY, AVANTOR PERFORMANCE MATERIALS ASSUMES NO
LIABILITY WHATSOEVER FOR THE USE OF OR RELIANCE UPON THIS
INFORMATION. NO SUGGESTIONS FOR USE ARE INTENDED AS, AND
NOTHING HEREIN SHALL BE CONSTRUED AS, A RECOMMENDATION
TO INFRINGE ANY EXISTING PATENTS OR TO VIOLATE ANY FEDERAL,
STATE, LOCAL, OR FOREIGN LAWS. AVANTOR PERFORMANCE
MATERIALS REMINDS YOU THAT IT IS YOUR LEGAL DUTY TO MAKE
ALL INFORMATION IN THIS MSDS/SDS AVAILABLE TO YOUR
EMPLOYEES.
SDS_US - SDS000001091 10/10
