DEPARTMENT OF AUTOMOBILE AND MECHANICAL ENGINEERING
IOE, THAPATHALI CAMPUS
              TURBO MACHINE
                   CHAPTER 1
         INTRODUCTION TO TURBO MACHINE
  1     Instructor : Achyut Paudel
               Email: apaudel@ioe.edu.np
               Ph: 9841263367
DEFINITION
 “A turbo machine is a device in which energy transfer
  occurs between a flowing fluid and a rotating element
  due to dynamic action, and results in a change in
  pressure and momentum of the fluid.”
 Mechanical energy transfer occurs inside or outside of
  the turbo machine, usually in a steady-flow process
 Types:
    Energy Extracting: Expands fluid to lower pressure
     or head.
       Eg. Gas turbines, steam turbines, windmills,
       water wheels, and hydraulic turbines
    Energy Delivering : Increase fluid pressure or head.
       Eg. centrifugal pumps, centrifugal and axial flow 2
       compressors, fans, blowers, exhauster
 PARTS OF A TURBO MACHINE
 (i) A rotating element carrying vanes operating in
         a stream of fluid: (rotor, runner, impeller)
 (ii) A stationary element or elements which
         generally act as guide vanes or passages for the
         proper control of flow direction and the
         energy conversion process: (guide vane, nozzle)
 (iii) an input and/or an output shaft, and
 (iv) a housing: (Enclosed, Extended)
Fig: Schematic cross-sectional
view of a turbine showing the                               3
principal parts of the turbo
machine.
 CLASSIFICATION OF TURBINE
General classification headings:
1. Direction of fluid flow: axial, radial, mixed
2. Energy: Impulse, Reaction, Impulse – Reaction
3. Type of fluid: Steam turbine, gas turbine, hydraulic
   turbine
4. Specific speed(Ns) : High >250
                        : Meduim 50-250
                        : Low <50
                                                          4
POSITIVE DISPLACEMENT MACHINES
               VS
         TURBO MACHINE
                                 5
6
7
BASIC LAWS AND GOVERNING EQUATIONS
Continuity Equation:
“For a steady flow through control volume, the mass
flow rate remains constant.”
                                                      8
STEADY FLOW ENERGY EQUATION
1ST LAW OF THERMODYNAMICS APPLIED TO A TURBOMACHINE
                                                      9
STATIC AND STAGNATION PROPERTIES
 Static enthalpy(h) = u + pV
 The stagnation state is defined as the terminal state of
  a fictitious, isentropic, work-free and steady-flow
  process during which the macroscopic kinetic and
  potential energies of the fluid particle are reduced to
  zero.
 Stagnation enthalpy (h0)= h + V2/2+ gz
 For an adiabatic process, Q = 0 and if z1=z2, energy
  steady state energy eqn. reduces to
                    P = w = h01-h02= - ∆h0
 For power generating machine, w is +ve, so ∆h0 is –ve,
  i.e. total enthalpy of flowing fluid decreases from inlet
  to exit.
 For power absorbing machine, w is –ve, so ∆h0 is +ve, 10
  so stagnation enthalpy increases from inlet to exit
2ND LAW OF THERMODYNAMICS AND ENTROPY
   “For a fluid undergoing a reversible adiabatic process,
    the entropy change is zero” . Otherwise entropy change
    has some definite value.
    Combining first
    and second law
                                                              11
EFFICIENCY
The performance of a real machine is inferior to that of a
frictionless and loss-free ideal machine. A measure of its
performance is the efficiency.
Mechanical Efficiency
 Causes/losses: Bearing friction, windage, unsteady flow,
   friction between the blade and the fluid, etc. There are other
   losses like leakage across blades, labyrinth leakage, etc. in
   addition to the above losses which are covered under fluid-
   rotor losses. For power generating(pg) and power
   absorbing(pa), mechanical efficiency is given by,
                                                                12
    ISENTROPIC EFFICIENCY
   For power generating( turbines/expansion devices) and
    power absorbing (compressors/ compression) machines,
    isentropic efficiency is given respectively by,
                                                        13
Isentropic efficiency for turbine/expansion process
                                                      14
Isentropic efficiency for compression process
                                                15
    TOTAL EFFICIENCY
Total Efficiency(η)= mechanical * isentropic efficiency
                    = ηm ηi
For power generating and power absorbing machine, η
                                                           16
DIMENSIONAL ANALYSIS
BUCKINGHAM   PI THEOREM FOR FLUID FLOW PROBLEM
                                                 17
    SIGNIFICANCE OF         TERMS
   Capacity/ flow/ discharge coefficient or Specific Capacity
                                                            18
19
   Head Coefficient/ Specific Head
   Head coefficient is the ratio of kinetic energy of fluid (due
    to H) to the kinetic energy of the fluid running at the
    rotor tangential speed, OR simply head coefficient is the
    ratio of fluid head to kinetic energy of the rotor.
                                                              20
   Power Coefficient/ Specific Power
   The specific power of both the model and the prototype
    will remain the same if their efficiency is same.
                                                             21
   Reynold’s Number
   It is the ratio of inertial force to the viscous force of
    fluid.
                                                                22
EFFECT OF REYNOLD’S NUMBER
                             23
SPECIFIC SPEED(FOR PUMP AND TURBINE)
                                       24
SPECIFIC SPEED DEFINITIONS
   Specific Speed for Turbine: The specific-speed of a
    turbine may be defined as the rotational speed of a
    geometrically similar turbine operating under a head of
    1 m and producing 1 kW of power.
   Specific Speed for Pump: The specific-speed of a pump
    may be defined as the speed in RPM of a geometrically
    similar pump, discharging 1 m3/s of water against a
    head of 1 m.
Pump and turbines specific-speeds defined this way
range between 20 and 300
                                                          25
SP. SPEEDS FOR DIFFERENT TURBOMACHINES
                                         26
SP. SPEED AND EFFICIENCY
                           27
  MODEL AND PROTOTYPE
Geometric Similarity: similarity in shape, i.e. all length
dimensions in the model are λ times shorter than of its real-
world prototype (λ = LP/LM)
Kinematic Similarity: geometric similarity and similarity of
motion between model and prototype particles
Dynamic Similarity: requires geometric and kinematic
similarity and in addition that all force ratios in the two systems
are identical
 A   model satisfying these three conditions is called
  “Homologous” model. Specific speeds, head coefficients flow
  coefficient and power coefficient will be identical between the
  model and the large machine called prototype. It is also
  possible from these experiments to predict part load
  performance and operation at different head, speed and flow
  conditions.
 The ratio between linear dimensions is called scale. For
  example a one eight scale model means that the linear
  dimensions of the model is 1/8 of the linear dimensions of
  prototype. For kinematic and dynamic similarity the flow       28
  directions and the blade angles should be equal.
DERIVABLE EQUATIONS (MODEL & PROTOTYPE)
   Power Ratio:
   Head Coefficient and Flow Coefficient:
   Elimination N/Nm from above eqns. we get,
   Finally, eliminating Q/Qm from the first and above eqn.
                                                          29
NUMERICAL EXAMPLES
   A quarter scale turbine model is tested under a head of 10 m. The full scale
    turbine is required to work under a head of 28.5 m and 415 rpm.a) At what
    speed the model must be run if it develops 94 kW and uses 0.96 m3/s at this
    speed? b) what power will be obtained from the full scale turbine? c) Name
    the type of turbine. (536.11, 7236.3 kW, Kaplan)
                                                                             30
31