SAFETY DATA SHEET

XY-12

Section: 1. PRODUCT AND COMPANY IDENTIFICATION

Product name : XY-12

Other means of identification : Not applicable.

Recommended use : Sanitizer

Product dilution information : 0.1 % - 10.0 %

Company : ECOLAB PTY LTD

2 Drake Avenue
Macquarie Park, NSW Australia 2113
1 800 022 002

Emergency telephone : 1800 205 506, +64 7 958 2372

number

Issuing date : 04.09.2019

Section: 2. HAZARDS IDENTIFICATION

GHS Classification
Product AS SOLD
Skin corrosion/irritation : Category 1B
Serious eye damage/eye : Category 1
irritation

Product AT USE DILUTION

Not a hazardous substance or mixture.

GHS Label element

Product AS SOLD
Hazard pictograms :

Signal Word : Danger

Hazard Statements : Causes severe skin burns and eye damage.

Precautionary Statements : Prevention:

Do not breathe dusts or mists. Wash skin thoroughly after handling.
Wear protective gloves/ protective clothing/ eye protection/ face
protection.
Response:
IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN
(or hair): Remove/ Take off immediately all contaminated clothing.
Rinse skin with water/ shower. IF INHALED: Remove victim to fresh
air and keep at rest in a position comfortable for breathing.
Immediately call a POISON CENTER or doctor/ physician. IF IN
EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. Wash
contaminated clothing before reuse.
Storage:

902684-14 1 / 10
SAFETY DATA SHEET
XY-12

Store locked up.

Disposal:
Dispose of contents/ container to an approved waste disposal plant.

Product AT USE DILUTION

Precautionary Statements : Prevention:
Wash hands thoroughly after handling.
Response:
Get medical advice/ attention if you feel unwell.
Storage:
Store in accordance with local regulations.

Product AS SOLD
Other hazards : Mixing this product with acid or ammonia releases chlorine gas.

Product AT USE DILUTION

Other hazards : Mixing this product with acid or ammonia releases chlorine gas.

Section: 3. COMPOSITION/INFORMATION ON INGREDIENTS

Product AS SOLD
Pure substance/mixture : Mixture

Chemical Name CAS-No. Concentration: (%)

sodium hypochlorite 7681-52-9 10 - 30

Product AT USE DILUTION

No hazardous ingredients

Section: 4. FIRST AID MEASURES

Product AS SOLD
In case of eye contact : Rinse immediately with plenty of water, also under the eyelids, for at
least 15 minutes. Remove contact lenses, if present and easy to do.
Continue rinsing. Get medical attention immediately.

In case of skin contact : Wash off immediately with plenty of water for at least 15 minutes. Use
a mild soap if available. Wash clothing before reuse. Thoroughly clean
shoes before reuse. Get medical attention immediately.

If swallowed : Rinse mouth with water. Do NOT induce vomiting. Never give
anything by mouth to an unconscious person. Get medical attention
immediately.

Contact the Poison's Information Centre (eg Australia 13 1126; New

Zealand 0800 764 766).

If inhaled : Remove to fresh air. Treat symptomatically. Get medical attention if

symptoms occur.

Protection of first-aiders : If potential for exposure exists refer to Section 8 for specific personal
protective equipment.

Notes to physician : Treat symptomatically.

Most important symptoms : See Section 11 for more detailed information on health effects and
and effects, both acute and symptoms.

902684-14 2 / 10
SAFETY DATA SHEET
XY-12

delayed

Product AT USE DILUTION

In case of eye contact : Rinse with plenty of water.

In case of skin contact : Rinse with plenty of water.

If swallowed : Rinse mouth. Get medical attention if symptoms occur.

Contact the Poison's Information Centre (eg Australia 13 1126; New

Zealand 0800 764 766).

If inhaled : Get medical attention if symptoms occur.

Section: 5. FIREFIGHTING MEASURES

Product AS SOLD
Suitable extinguishing media : Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.

Unsuitable extinguishing : None known.

media

Specific hazards during : Exposure to decomposition products may be a hazard to health.

firefighting

Hazardous combustion : Decomposition products may include the following materials:

products metal oxides
Halogenated compounds

Special protective equipment : Use personal protective equipment.

for firefighters

Specific extinguishing : Collect contaminated fire extinguishing water separately. This must
methods not be discharged into drains. Fire residues and contaminated fire
extinguishing water must be disposed of in accordance with local
regulations. In the event of fire and/or explosion do not breathe fumes.

Hazchem Code : 2X

Section: 6. ACCIDENTAL RELEASE MEASURES

Product AS SOLD
Personal precautions, : Ensure adequate ventilation. Keep people away from and upwind of
protective equipment and spill/leak. Avoid inhalation, ingestion and contact with skin and eyes.
emergency procedures When workers are facing concentrations above the exposure limit they
must use appropriate certified respirators. Ensure clean-up is
conducted by trained personnel only. Refer to protective measures
listed in sections 7 and 8.

Environmental precautions : Do not allow contact with soil, surface or ground water.

Methods and materials for : Stop leak if safe to do so. Contain spillage, and then collect with non-
containment and cleaning up combustible absorbent material, (e.g. sand, earth, diatomaceous
earth, vermiculite) and place in container for disposal according to
local / national regulations (see section 13). Flush away traces with
water. For large spills, dike spilled material or otherwise contain
material to ensure runoff does not reach a waterway.

902684-14 3 / 10
SAFETY DATA SHEET
XY-12

Product AT USE DILUTION

Personal precautions, : Ensure clean-up is conducted by trained personnel only. Refer to
protective equipment and protective measures listed in sections 7 and 8.
emergency procedures

Environmental precautions : Do not allow contact with soil, surface or ground water.

Methods and materials for : Stop leak if safe to do so. Contain spillage, and then collect with non-
containment and cleaning up combustible absorbent material, (e.g. sand, earth, diatomaceous
earth, vermiculite) and place in container for disposal according to
local / national regulations (see section 13). Flush away traces with
water. For large spills, dike spilled material or otherwise contain
material to ensure runoff does not reach a waterway.

Section: 7. HANDLING AND STORAGE

Product AS SOLD
Advice on safe handling : Do not ingest. Do not breathe dust/fume/gas/mist/vapours/spray. Use
only with adequate ventilation. Wash hands thoroughly after handling.
Do not get in eyes, on skin, or on clothing. Mixing this product with
acid or ammonia releases chlorine gas. In case of mechanical
malfunction, or if in contact with unknown dilution of product, wear full
Personal Protective Equipment (PPE).

Conditions for safe storage : Do not store near acids. Keep out of reach of children. Keep container
tightly closed. Store in suitable labeled containers.

Storage temperature : 0 °C to 40 °C

Product AT USE DILUTION

Advice on safe handling : Avoid contact with skin and eyes. Wash hands thoroughly after
handling. Mixing this product with acid or ammonia releases chlorine
gas. In case of mechanical malfunction, or if in contact with unknown
dilution of product, wear full Personal Protective Equipment (PPE).

Conditions for safe storage : Keep out of reach of children. Keep container tightly closed. Store in
suitable labeled containers.

Section: 8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Product AS SOLD
Components with workplace control parameters
Contains no substances with occupational exposure limit values.

Engineering measures : Effective exhaust ventilation system. Maintain air concentrations

below occupational exposure standards.

Personal protective equipment

Eye protection : Safety goggles

Face-shield

Hand protection : Wear the following personal protective equipment:

Standard glove type.
Neoprene gloves
Nitrile
Natural rubber

902684-14 4 / 10
SAFETY DATA SHEET
XY-12

PVC
Gloves should be discarded and replaced if there is any indication of
degradation or chemical breakthrough.

Skin protection : Personal protective equipment comprising: suitable protective gloves,

safety goggles and protective clothing

Respiratory protection : When workers are facing concentrations above the exposure limit they
must use appropriate certified respirators.

Refer to AS/NZS 1715 and AS/NZS 1716 for selection, use and
maintenance of respiratory protective equipment as applicable.

Hygiene measures : Handle in accordance with good industrial hygiene and safety
practice. Remove and wash contaminated clothing before re-use.
Wash face, hands and any exposed skin thoroughly after handling.
Provide suitable facilities for quick drenching or flushing of the eyes
and body in case of contact or splash hazard.

Product AT USE DILUTION

Engineering measures : Good general ventilation should be sufficient to control worker
exposure to airborne contaminants.

Personal protective equipment

Eye protection : No special protective equipment required.

Hand protection : No special protective equipment required.

Skin protection : No special protective equipment required.

Respiratory protection : No personal respiratory protective equipment normally required.

Refer to AS/NZS 1715 and AS/NZS 1716 for selection, use and
maintenance of respiratory protective equipment as applicable.

Section: 9. PHYSICAL AND CHEMICAL PROPERTIES

Product AS SOLD Product AT USE DILUTION

Appearance : liquid liquid
Colour : light yellow colourless
Odour : Chlorine Chlorine
pH : 12.0 - 14.0, (100 %) 10.0 - 12.0
Flash point : Not applicable., Does not sustain combustion.
Odour Threshold : no data available
Melting point/freezing point : no data available
Initial boiling point and : 100 °C
boiling range
Evaporation rate : no data available
Flammability (solid, gas) : no data available
Upper explosion limit : no data available
Lower explosion limit : no data available
Vapour pressure : no data available

902684-14 5 / 10
SAFETY DATA SHEET
XY-12

Relative vapour density : no data available

Relative density : 1.17 - 1.235
Water solubility : soluble
Solubility in other solvents : no data available
Partition coefficient: n- : no data available
octanol/water
Auto-ignition temperature : no data available
Thermal decomposition : no data available
Viscosity, kinematic : no data available
Explosive properties : no data available
Oxidizing properties : no data available
Molecular weight : no data available
VOC : no data available

Section: 10. STABILITY AND REACTIVITY

Product AS SOLD
Reactivity : No dangerous reaction known under conditions of normal use.

Chemical stability : Stable under normal conditions.

Possibility of hazardous : Mixing this product with acid or ammonia releases chlorine gas.
reactions

Conditions to avoid : None known.

Incompatible materials : Metals

Acids
Organic materials

Hazardous decomposition : In case of fire hazardous decomposition products may be produced

products such as:
metal oxides
Halogenated compounds

Section: 11. TOXICOLOGICAL INFORMATION

Information on likely routes of : Inhalation, Eye contact, Skin contact

exposure

Potential Health Effects

Product AS SOLD
Eyes : Causes serious eye damage.

Skin : Causes severe skin burns.

Ingestion : Causes digestive tract burns.

Inhalation : May cause nose, throat, and lung irritation.

Chronic Exposure : Health injuries are not known or expected under normal use.

902684-14 6 / 10
SAFETY DATA SHEET
XY-12

Product AT USE DILUTION

Eyes : Health injuries are not known or expected under normal use.

Skin : Health injuries are not known or expected under normal use.

Ingestion : Health injuries are not known or expected under normal use.

Inhalation : Health injuries are not known or expected under normal use.

Chronic Exposure : Health injuries are not known or expected under normal use.

Experience with human exposure

Product AS SOLD
Eye contact : Redness, Pain, Corrosion

Skin contact : Redness, Pain, Corrosion

Ingestion : Corrosion, Abdominal pain

Inhalation : Respiratory irritation, Cough

Product AT USE DILUTION

Eye contact : No symptoms known or expected.

Skin contact : No symptoms known or expected.

Ingestion : No symptoms known or expected.

Inhalation : No symptoms known or expected.

Toxicity

Product AS SOLD
Product
Acute oral toxicity : no data available
Acute inhalation toxicity : no data available
Acute dermal toxicity : no data available
Skin corrosion/irritation : no data available
Serious eye damage/eye : no data available
irritation
Respiratory or skin : no data available
sensitization
Carcinogenicity : no data available
Reproductive effects : no data available
Germ cell mutagenicity : no data available
Teratogenicity : no data available
STOT - single exposure : no data available
STOT - repeated exposure : no data available
Aspiration toxicity : no data available
Components
Acute oral toxicity : sodium hypochlorite

902684-14 7 / 10
SAFETY DATA SHEET
XY-12

LD50 rat: 5,230 mg/kg

Components
Acute dermal toxicity : sodium hypochlorite
LD50 rabbit: > 10,000 mg/kg

Section: 12. ECOLOGICAL INFORMATION

Product AS SOLD
Ecotoxicity
Environmental Effects : Very toxic to aquatic life.

Product
Toxicity to fish : no data available
Toxicity to daphnia and other : no data available
aquatic invertebrates
Toxicity to algae : no data available
Components
Toxicity to fish : sodium hypochlorite
96 h EC50: 0.14 mg/l

Components
Toxicity to daphnia and other : sodium hypochlorite
aquatic invertebrates 48 h EC50: 0.071 mg/l

Persistence and degradability

Product AS SOLD
Not applicable - inorganic

Bioaccumulative potential
no data available

Mobility in soil
no data available

Other adverse effects

no data available

Section: 13. DISPOSAL CONSIDERATIONS

Product AS SOLD
Disposal methods : The product should not be allowed to enter drains, water courses or
the soil. Where possible recycling is preferred to disposal or
incineration. If recycling is not practicable, dispose of in compliance
with local regulations. Dispose of wastes in an approved waste
disposal facility.

Disposal considerations : Dispose of as unused product. Empty containers should be taken to

an approved waste handling site for recycling or disposal. Do not re-
use empty containers. Dispose of in accordance with local, state, and
federal regulations.

902684-14 8 / 10
SAFETY DATA SHEET
XY-12

Product AT USE DILUTION

Disposal methods : The product should not be allowed to enter drains, water courses or
the soil. Where possible recycling is preferred to disposal or
incineration. If recycling is not practicable, dispose of in compliance
with local regulations. Dispose of wastes in an approved waste
disposal facility.

Disposal considerations : Dispose of as unused product. Empty containers should be taken to

an approved waste handling site for recycling or disposal. Do not re-
use empty containers. Dispose of in accordance with local, state, and
federal regulations.

Section: 14. TRANSPORT INFORMATION

Product AS SOLD

The shipper/consignor/sender is responsible to ensure that the packaging, labeling, and markings are
in compliance with the selected mode of transport.

Land transport (ADG)

UN number : 1791
Description of the goods : HYPOCHLORITE SOLUTION
Class : 8
Packing group : III
Hazchem Code : 2X
Environmentally hazardous : Yes

Air transport (IATA)

UN number : 1791
Description of the goods : Hypochlorite solution
Class : 8
Packing group : III
Environmentally hazardous : Yes

Sea transport (IMDG/IMO)

UN number : 1791
Description of the goods : HYPOCHLORITE SOLUTION
Class : 8
Packing group : III
Marine pollutant : Yes

Section: 15. REGULATORY INFORMATION

National regulatory information

Standard for the Uniform : Schedule 5

Scheduling of Medicines and
Poisons

The components of this product are reported in the following inventories:

United States TSCA Inventory :

All substances listed as active on the TSCA inventory

902684-14 9 / 10
SAFETY DATA SHEET
XY-12

Canadian Domestic Substances List (DSL) :

All components of this product are on the Canadian DSL.

Australia. Industrial Chemical (Notification and Assessment) Act :

On the inventory, or in compliance with the inventory

New Zealand. Inventory of Chemicals (NZIoC), as published by ERMA New Zealand :

On the inventory, or in compliance with the inventory

Japan. ENCS - Existing and New Chemical Substances Inventory :

On the inventory, or in compliance with the inventory

Korea. Korean Existing Chemicals Inventory (KECI) :

On the inventory, or in compliance with the inventory

Philippines Inventory of Chemicals and Chemical Substances (PICCS) :

On the inventory, or in compliance with the inventory

China Inventory of Existing Chemical Substances :

On the inventory, or in compliance with the inventory

Taiwan Chemical Substance Inventory :

On the inventory, or in compliance with the inventory

Section: 16. OTHER INFORMATION

Sources of key data used to compile the Safety Data Sheet

Globally Harmonized System of Classification and Labelling of Chemicals (GHS)
IARC: (International Agency for Research on Cancer)
US. National Toxicology Program (NTP) Report on Carcinogens
ECHA List of Publishable Substances Registered
EU HPVCs (High Production Volume Chemicals)

Issuing date : 04.09.2019

Date of first issue : 15.12.2015
Version : 1.1
Prepared by : Regulatory Affairs

REVISED INFORMATION: Significant changes to regulatory or health information for this revision is
indicated by a bar in the left-hand margin of the SDS.

The information provided in this Safety Data Sheet is correct to the best of our knowledge,
information and belief at the date of its publication. The information given is designed only as a
guidance for safe handling, use, processing, storage, transportation, disposal and release and is
not to be considered a warranty or quality specification. The information relates only to the specific
material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.

902684-14 10 / 10