GROUP 5 CONNECTORS

1. CONNECTOR DESTINATION
Connector No. of Connector part No.
Type Destination
number pin Female Male
CN-1 58 2 I/conn(Frame harness-Main harness) S813-030200 S813-130200
CN-2 SWP 12 I/conn(Frame harness-Main harness) S814-012000 S814-112000
CN-3 SWP 12 I/conn(Frame harness-Main harness) S814-012000 S814-112000
CN-4 SWP 12 I/conn(Front harness-Engine harness) S814-012000 S814-112000
CN-5 SWP 8 I/conn(Cab harness-Main harness) S814-008000 S814-108000
CN-6 SWP 12 I/conn(Gauge harness-Main harness) S814-012000 S814-112000
CN-7 SWP 14 I/conn(Gauge harness-Main harness) S814-014000 S814-114000
CN-8 SWP 14 I/conn(Front harness-Main harness) S814-014000 S814-114000
CN-10 SWP 8 I/conn(Front harness-Main harness) S814-008000 S814-108000
CN-12 SWP 12 AC AVA assembly S814-012000 -
CN-13 SWP 8 AC AVA assembly S814-008202 -
CN-15 Circular 10 I/conn(Main harness-T/M harness) 6029199086 6029199085
CN-16 Circular 10 I/conn(Main harness-T/M harness) 6029199086 6029199085
CN-20 Molex 2 Horn 35215-0200 -
CN-21 HW090
Sealed 6 Front wiper motor 6189-0133 -
CN-22 SWP 2 Front washer tank S814-002000 -
CN-23 Shur 1 Speaker(LH) S822-014000 S822-114004
CN-24 Shur 1 Speaker(RH) S822-014000 S822-114004
CN-25 Molex 2 Horn 35215-0200 -
CN-26 250 2 Warning buzzer S810-002202 -
CN-27 PA 9 Cassette and radio S811-009003 -
CN-28 56 series 2 Compressor(Air conditioner) 0297-3407 -
CN-29 Grommet - Receiver drier 21L7-12000 -
CN-30 PA 13 Air conditioner controller S811-013002 -
CN-36 - - Fuse box 24L1-04100 -
CN-45 Ring term - Starter S820-414000 S820-304000
CN-48 250 2 Hour meter S810-002202 -
Econoseal
CN-58 III 36 Check unit 344111-1 -
CN-60 58 2 Fusible link - S813-130200
CN-65 Shur 1 Back up buzzer S822-014000 -
CN-71 J 2 Parking solenoid S816-002001 -
CN-74 Ring term - Alternator S820-406000 S820-104000
Weather
CN-79 pack 3 Fuel cut off solenoid S818-020311 -
CN-83 MWP 2 Air conditioner fan PH805-02028 -
CN-100 J 3 Boom kick out S816-003001 -
CN-101 J 3 Bucket leveler S816-003001 -

7-42
Connector No. of Connector part No.
Type Destination
number pin Female Male
HW090
CN-102 Sealed 6 Rear wiper motor 6189-0133 -
CN-103 SWP 2 Rear washer tank S814-002000 -
CN-104 Ring term 1 Volt meter S824-025213 -
CN-107 Ring term 1 Fuel gauge S824-025213 -
CN-114 J 8 Joy stick S816-008002 -
CN-117 Ring term 1 Water temp S824-025213 -
CN-119 Ring term 1 Transmission temp S824-025213 -
CN-127 - 8 Speed meter - 1630070
CN-136 JPT 2 Ride control valve 85202-1 -
CN-137 JPT 2 Ride control solenoid 85202-1 -
Relay
CR-1 Ring term - Battery relay - S820-104000
CR-2 250 4 Horn relay S810-004202 -
CR-4 250 6 Wiper relay Hi S810-006202 -
CR-5 250 4 Safety relay S810-004202 -
CR-7 250 4 Air-con relay S810-004202 -
CR-11 250 3 Flasher unit S810-003702 -
CR-23 J 2 Start relay S816-002003 -
CR-26 250 6 Wiper relay Lo S810-006202 -
CR-30 250 4 Back up relay S810-004202 -
CR-35 250 6 Ride control relay S810-006202 -
CR-39 250 4 Display illumination S810-004202 -
Switch
CS-2 SWP 6 Start key switch S814-006000 -
CS-3 SWF 10 Rear wiper switch 593757 -
CS-5 Shur 1 Horn switch S822-014000 -
CS-11 SWP 8 Multi function switch S814-008000 -
CS-12 SWP 6 Multi function switch S814-006000 -
CS-17 SWF 10 Parking switch 593757 -
CS-20 SWF 10 Rear work lamp switch 593757 -
CS-21 SWF 10 Front work lamp switch 593757 -
CS-23 SWF 10 Beacon switch 593757 -
CS-34 SWF 10 Buzzer stop switch 593757 -
CS-39 SWF 10 Illumination and head lamp switch 593757 -
CS-41 SWF 10 Hazard switch 593757 -
CS-42 SWF 10 Clutch cut off switch 593757 -
CS-50 SWF 10 Ride control 593757 -
CS-51 SWF 10 Full automatic switch 593757 -

7-43
Connector No. of Connector part No.
Type Destination
number pin Female Male
CS-52 SWF 10 Attachment lock switch 593757 -
CS-53 SWF 10 Attachment unlock switch 593757 -
CS-54 SWF 10 Air conditioner switch 593757 -
CS-55 SWF 10 Pump motor 593757 -
CS-58 250 6 Blower switch S810-006202 -
Light
CL-1 - 2 Room lamp MG610392 -
CL-2 250 3 Cigar lighter S810-003202 -
CL-3 SWP 4 Head light(LH) S814-004000 -
CL-4 SWP 4 Head light(RH) S814-004000 -
CL-5 SWP 2 Work light(LH) S814-002000 -
CL-6 SWP 2 Work light(RH) S814-002000 -
CL-7 250 1 Beacon lamp S810-001202 -
CL-15 SWP 4 Combi lamp(RR, LH) S814-004000 -
CL-16 SWP 4 Combi lamp(RR, RH) S814-004000 -
CL-21 SWP 2 Numberplate lamp S814-002000 -
CL-22 SWP 2 Work light(LH) S814-002000 -
CL-23 SWP 2 Work light(RH) S814-002000 -
CL-24 SWP 2 Turn lamp(LH) S814-002000 -
CL-25 SWP 2 Turn lamp(RH) S814-002000 -
CL-41 SWF 2 Hi beam lamp(Dash board) 913328 -
CL-42 SWF 2 Turn lamp(LH, Dash board) 913328 -
CL-43 SWF 2 Turn lamp(RH, Dash board) 913328 -
CL-44 SWF 2 Parking lamp(Dash board) 913328 -
CL-45 SWF 2 Brake fail lamp(Dash board) 913328 -
CL-46 SWF 2 Charge lamp(Dash board) 913328 -
CL-47 SWF 2 Hydraulic oil lamp(Dash board) 913328 -
CL-48 SWF 2 Over heat lamp(Dash board) 913328 -
CL-49 SWF 2 Engine oil lamp(Dash board) 913328 -
CL-50 SWF 2 Transmission error 913328 -
CL-51 SWF 2 Transmission oil lamp(Dash board) 913328 -
CL-53 SWF 2 Steering pressure lamp 913328 -
CL-54 SWF 2 Steering pump pressure lamp 913328 -

7-44
Connector No. of Connector part No.
Type Destination
number pin Female Male
Sensor, sender
CD-1 PLC(Mark II) 1 Hyduaulic oil temp switch S819-010122 -
CD-2 SWP 2 Fuel sendor S814-002000 -
CD-3 Rubber cap - Brake fail pressure switch 21EA-00310 -
CD-4 Rubber cap - Stop lamp pressure switch 21EA-00310 -
CD-5 Rubber cap - Clutch cut off pressure switch 21EA-00310 -
CD-8 Ring term - Water temp sendor - S820-104000
CD-9 Dust cap 1 Over heat switch 101-701506A -
CD-18 Ring term - Engine oil pressure switch - S820-406000
CD-25 Rubber cap - Transmission oil pressure switch 21EA-00310 -
CD-26 Rubber cap - Parking oil pressure switch 21EA-00310 -
CD-29 Ring term - Transmission temp sendor - S821-105000
CD-39 PLC(Mark II) 2 Steering pressure switch S819-010122 -
CD-40 PLC(Mark II) 2 Steering pump pressure switch S819-010122 -

7-45
2. CONNECTION TABLE FOR CONNECTORS
1) 58-L TYPE CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

1 1

S813-030100 S813-130100

1 2 1 2

S813-030200 S813-130200

7-46
2) PA TYPE CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

2 5 1 3

1 3 2 5
S811-005002 S811-105002

3 7 1 4

1 4 3 7

S811-007002 S811-107002

4 9 1 5

1 5 4 9
S811-009002 S811-109002

5 11 1 6

11

1 6 5 11

S811-011002 S811-111002

7-47
No. of
Receptacle connector(Female) Plug connector(Male)
pin

6 13 1 7

13

1 7 6 13
S811-013002 S811-113002

8 17 1 9

17

1 9 8 17
S811-017002 S811-117002

10 21 1 11

21

1 11 10 21
S811-021002 S811-121002

7-48
3) J TYPE CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

1 21

2 12
S816-002001 S816-102001

2 3 1

3 1 2
S816-003001 S816-103001

7-49
4) SWP TYPE CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

1 1

S814-001000 S814-101000

2 1

1 2
S814-002000 S814-102000

3 1

2 1 23
S814-003000 S814-103000

2 4 1 3

1 3 2 4
S814-004000 S814-104000

7-50
No. of
Receptacle connector(Female) Plug connector(Male)
pin

3 6
1 4

1 4 3 6
S814-006000 S814-106000

4 8
1 5

1 5 4 8
S814-008000 S814-108000

4 12 1 9

12

4 12
1 9
S814-012000 S814-112000

3 14 1 11

14

1 11 3 14
S814-014000 S814-114000

7-51
5) CN TYPE CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

1 1

S810-001202 S810-101202

2 2

1 1

S810-002202 S810-102202

3 2

1 2 1 3
S810-003202 S810-103202

2 4 1 4

1 3 2 3
S810-004202 S810-104202

7-52
No. of
Receptacle connector(Female) Plug connector(Male)
pin

3 6 1 4

1 4 3 6
S810-006202 S810-106202

4 8 1 5

1 5 4 8
S810-008202 S810-108202

7-53
6) MOLEX 2CKTS CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

1 2

35215-0200

7) ITT SWF CONNECTOR

2
10

1 10

SWF593757

8) SWF CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

2
2

SWF913328

7-54
9) HW090 SEALED CONNECTOR
No. of
Receptacle connector(Female) Plug connector(Male)
pin

6 3

4
6

6189-0133

10) MWP02F-B CONNECTOR

2 1

2
PH805-02028

11) AMP ECONOSEAL CONNECTOR

1
12

1 13
24
36
36 25 12
13
24
25 36
344111-1 344108-1

7-55