16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

CONNECTOR INFORMATION FOR: J152

L P20-1314-11110 ,BLACK,(21 CAVITIES)
CONNECTOR INFORMATION FOR: P001
P20-1301-001 , BLACK, (46 CAVITIES)
CONNECTOR INFORMATION FOR: J155 CONNECTOR INFORMATION FOR: P241 L
P20-6185, BLACK, (14 CAVITIES) P20-6137, BLACK, (14 CAVITIES)
LABEL: J152, MPDC #1 LABEL: P001, mPDC P1 LABEL: J155, HEADLAMP HARN LABEL: P241, CHASSIS HARNESS
CONNECTOR INFORMATION FOR: P002 GENERAL NOTES:
21 19 P20-1301-002, GREY, (46 CAVITIES) 7 14
14 7
LABEL: P002, mPDC P2 1) USE ON NGP CHASSIS WITH 12-12V ELECTRICAL AND NAMUX 4
CONNECTOR INFORMATION FOR: P003 INSTRUMENTATION AND 2010 EMMISSION ENGINES.
P20-1301-003, BROWN, (46 CAVITIES)
LABEL: P003, mPDC P3 2) HOW TO USE THIS DIAGRAM:
EACH CONNECTOR HAS A DISTINCT ALPHANUMERIC
CONNECTOR INFORMATION FOR: P004
"REFERENCE DESIGNATOR" OR "REF_DES" ASSOCIATED
P20-1301-004, GREEN, (46 CAVITIES)
WITH IT. USE THIS REF_DES TO FIND CONNECTOR
K 3 1 LABEL: P004, mPDC P4
8 8 1 INFORMATION IN THE CONNECTOR TABLE.
K
1
CONNECTOR INFORMATION FOR: P381 MATING VIEW
P20-1301-001, BLACK, (46 CAVITIES) MATING VIEW 3) EMISSIONS RELATED PART CODE: [N] SEE CPS0369 FOR REQUIREMENTS.
LABEL: P381, SLPR PDC
MATING VIEW 4) FOR HARNESS ROUTING INFORMATION REFER TO THE FOLLOWING ROUTING DWGS:
CONNECTOR INFORMATION FOR: J088 KW DOOR
CONNECTOR INFORMATION FOR: J050 P20-6041, BLACK, (8 CAVITIES) PB DOOR
P20-1183-2209 ,WHITE,(9 CAVITIES) LABEL: J088, LH DOOR SIGNALS KW DASH
LABEL: J050, CECU 5 (E) A1 A9
CONNECTOR INFORMATION FOR: P791 CONNECTOR INFORMATION FOR: J014 PB DASH
1 3 P20-6040, BLACK, (8 CAVITIES) P20-6041, BLACK, (8 CAVITIES) KW 76" SLPR
LABEL: P791, DOOR #1 LABEL: J014, RH DOOR SIGNALS PB 63" SLPR
B1 B31
J CHASSIS J
KW HOOD
A H H A
PB HOOD
B G G B
C F F C 5) KW DOOR CONTROL SYSTEM DIAGRAM SEE SHT 2
9 D E E D PB DOOR CONTROL SYSTEM DIAGRAM SEE SHT 3
7
TROUBLE SHOOTING AND DIAGNOSTIC CODES SEE SHT 4
MATING VIEW MATING VIEW MATING VIEW SPLICE CONTAINS MORE CIRCUITS THAN SHOWN.
B6 B36 6

CONNECTOR INFORMATION FOR: J030

P20-1172-1240 ,BLACK,(40 CAVITIES) A10 CONNECTOR INFORMATION FOR: J010
I LABEL: J030, CECU 4 (D) A2 K333-549-104 , BLACK, (4 CAVITIES) I
21 11 LABEL: J010, RH DOOR-LOW PWR
MATING VIEW
31 1 CONNECTOR INFORMATION FOR: P792 CONNECTOR INFORMATION FOR: JO1X
K333-549-204 , BLACK, (4 CAVITIES) K333-549-104, BLACK , (4 CAVITIES)
31

21

11

CONNECTOR INFORMATION FOR: P795 LABEL: P792, DOOR #2 LABEL: JO1X, LH DOOR-LOW PWR
P20-1132-1518 , GREY, (18 CAVITIES)
LABEL: P795, DOOR SWITCH MODULE

16 1
B A
A B
40

30
20

10

H 40 10 D C H
30 20 C D
MATING VIEW MATING VIEW MATING VIEW
3
18
MATING VIEW CONNECTOR INFORMATION FOR DIAGRAM: P94-1864
CONNECTOR INFORMATION FOR: J505
P20-1191-3, BLACK, (10 CAVITIES) CONNECTOR INFORMATION FOR: P065 CONNECTOR INFORMATION FOR: J381 NUMBER OF ON PART
LABEL: J505, DOOR LOCK SW REF_DES DESCRIPTION LOCATION OF CONNECTOR
P20-1355-130 , BLACK, (30 CAVITIES) P20-1355-230 , BLACK, (30 CAVITIES) CAVITIES SHEET NUMBER
CONNECTOR INFORMATION FOR: J796
P20-1348, BLACK, (6 CAVITIES) LABEL: P065, SLPR HARNESS SIGNAL LABEL: J381, IP HARNESS J001 2 2 K333-587-102 BLACK, DELPHI, METRI-PACK 480 SERIES, UNDSEALED PASSENGER SIDE KICK PANEL
LABEL: J796, DOOR LATCH CONNECTOR INFORMATION FOR: J502 CONNECTOR INFORMATION FOR: P383 J010 4 1 K333-549-104 BLACK, DELPHI, METRI-PACK 280 SERIES, UNSEALED PASSENGER SIDE KICK PANEL
7 9 P20-1355-130, BLACK, (30 CAVITIES) P20-1355-230, BLACK, (30 CAVITIES)
G 4 1 LABEL: J502, SLPR HARNESS LABEL: P383, SLPR CNTRL HARNESS
J014 8 2 P20-6041 BLACK, DELPHI, METRI-PACK 150 SERIES, UNSEALED PASSENGER SIDE KICK PANEL G
J030 40 2 P20-1172-1240 BLACK, AMP MQS 40-WAY, UNSEALED AT CECU HOTEL, IN DASH
6 3
J050 9 2 P20-1183-2209 WHITE, AMP JPT 9-WAY, UNSEALED AT CECU HOTEL, IN DASH
5B 2B A1 A15 A1
A15 J088 8 2 P20-6041 BLACK, DELPHI, METRI-PACK 150 SERIES, UNSEALED DRIVER SIDE KICK PANEL
6 3 J155 14 2 P20-6185 BLACK, FRAMATONE, APEX, SEALED FRONT RADIATOR XMEMBER - LH SIDE
4 1
8 10 J159 2 2 K333-550-102 BLACK, METRI-PACK 280 2-WAY, SEALED LH FRAME - FWD BACK OF CAB XMEMBER
J381 30 2 P20-1355-230 BLACK, PACKARD, GT SERIES, UNSEALED LH BEHIND DRIVER AT SLPR CAB JOINT
B1 B15 B15 B1
MATING VIEW MATING VIEW MATING VIEW J502 30 2 P20-1355-130 BLACK, PACKARD, GT SERIES, UNSEALED 30-WAY BEHIND SLPR CONTROL PANEL
MATING VIEW
J505 10 2 P20-1191-3 BLACK, EATON SWITCH, UNSEALED BEHIND SLPR CONTROL PANEL
SCALE 2:1

F J796 6 2 P20-1348 BLACK, TYCO, JPT SERIES, SEALED INSIDE DRIVER/PASSENGER DOOR F
J01X 4 1 K333-549-104 BLACK, DELPHI, METRI-PACK 280 SERIES, UNSEALED DRIVER SIDE KICK PANEL
J01Z 2 2 K333-587-102 BLACK, DELPHI, METRI-PACK 480 SERIES, UNDSEALED DRIVER SIDE KICK PANEL
P001 46 2 P20-1301-001 BLACK, A-POLE mPDC (ALCOA) AT PDC ON FIREWALL
P002 46 2 P20-1301-002 GRAY, B-POLE mPDC (ALCOA) AT PDC ON FIREWALL
P003 46 2 P20-1301-003 BLUE, E-POLE mPDC (ALCOA) AT PDC ON FIREWALL
P004 46 2 P20-1301-004 DARK GREEN, D-POLE mPDC (ALCOA) AT PDC ON FIREWALL
P040 8 2 P20-1236-1208N BLACK, AMP AMPSEAL, SEALED INSIDE DRIVER COWL COVER
P042 8 2 P20-1236-1208N BLACK, AMP AMPSEAL, SEALED INSIDE PASSENGER COWL COVER
E P065 30 2 P20-1355-130 BLACK, PACKARD, GT SERIES, UNSEALED LH BEHIND DRIVER AT SLPR CAB JOINT E
P152 21 2 P20-1314-11110 BLACK, CONNECTOR AMP 21 WAY MCP, SEALED AT PDC ON FIREWALL
RH DOOR SLPR CNTRL
SLEEPER HARNESS P177 4 2 K333-550-202 BLACK, METRI-PACK 280 2-WAY, SEALED LH FRAME - FWD BACK OF CAB XMEMBER
HARNESS PANEL HARNESS P241 14 2 P20-6137 BLACK, FRAMATONE, APEX 280 SERIES, SEALED FRONT RADIATOR XMEMBER - LH SIDE
P246 2 2 P20-1236-1202N BLACK, TYCO, AMPSEAL 16 SERIES, SEALED LH SIDE OF HOOD
P247 2 2 P20-1236-1202N BLACK, TYCO, AMPSEAL 16 SERIES, SEALED RH SIDE OF HOOD
P381 46 2 P20-1301-001 BLACK, A-POLE mPDC (ALCOA) AT PDC IN LH SLEEPER TOOL BOX
SLPR PDC P383 30 2 P20-1355-230 BLACK, PACKARD, GT SERIES, UNSEALED BEHIND SLPR CONTROL PANEL
P791 8 2 P20-6040 BLACK, PACKARD, METRI-PACK 150 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL
D D
P792 4 1 K333-549-204 BLACK, PACKARD, METRI-PACK 280 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL
P793 2 2 K333-587-202 BLACK, PACKARD, METRI-PACK 480 SERIES, UNSEALED DRIVER OR PASSENGER SIDE KICK PANEL
P795 18 2 P20-1132-1518 GREY, TYCO, MCP SERIES, UNSEALED INSIDE DRIVER/PASSENGER DOOR UNDER TOP DOOR PAD
IP HARNESS CAB PDC CHASSIS HARNESS P796 2 2 P20-1170 BLACK, PACKARD, METRI-PACK 280 SERIES, SEALED INSIDE DRIVER/PASSENGER DOOR
P799 8 1 P20-1236-6208N BLACK, TYCO, AMPSEAL16, SEALED INSIDE DRIVER/PASSENGER SIDE DOOR
T001 1 2 K333-46-22 RING TERMINAL (1/4") FIREWALL GND, CAB SIDE
T151 1 2 K333-46-44 RING, TERMINAL, (1/4") FIREWALL GND, ENG SIDE

C C
HOOD HARNESS

LH DOOR DOOR CONTROL SYSTEM BLOCK DIAGRAM

HARNESS THIS SIMPLIFIED BLOCK DIAGRAM SHOWS HARNESSES
INVOLVED IN THE DOOR CONTROLS SYSTEM DIAGRAM.
LINES REPRESENT HARNESS TO HARNESS & HARNESS
TO POWER DISTRIBUTION CENTER CONNECTIONS.
B B

QTY ITEM PART NUMBER PRODUCT DESCRIPTION MATERIAL/SUPPLIER

1. THIS DRAWING AND THE INFORMATION CONTAINED HEREIN
TOLERANCES THIRD ANGLE PROJECTION
ARE PROPRIETARY TO PACCAR INC UNLESS OTHERWISE NOTED DRAWING REV
AND SHALL NOT BE REPRODUCED, COPIED OR DISCLOSED, UNLESS OTHERWISE SPECIFIED
IN WHOLE OR IN PART, OR USED FOR MANUFACTURE OR FOR
ANGLE = 1

P94-1864 A
OTHER PURPOSE WITHOUT THE WRITTEN PERMISSION OF
PACCAR INC. (X) = 1
2. DIMENSIONING AND TOLERANCING PER PACCAR CS0108. (X.X) = 0.5 DO NOT SCALE DRAWING DIMENSION UNITS MILLIMETERS
3. REMOVE ALL BURRS. BREAK SHARP EDGES.
4. PART IDENTIFICATION AND TRACEABILITY REQUIREMENTS TITLE

A A
TO COMPLY WITH PACCAR CPS0098.

DIAG-NGP DOOR CONTROLS

5. THIS DRAWING/SPECIFICATION USES SYMBOLS TO CLASSIFY
CHARACTERISTICS. THESE SYMBOLS ARE DEFINED IN THE
PACCAR SUPPLIER QUALITY STANDARD. SCALE DRAWING SCALE
6. EMISSION-RELATED PART. CODE: N DWG
SEE PACCAR CPS0374 FOR REQUIREMENTS. DRAWING VERSION A.4 SHEET 1 OF 4 SIZE

A0
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
KW HOOD-MNTD MIRROR (OPT)
DETAIL B FIREWALL GND
T151 J159 P177 CHASSIS HOOD P247
L W/OPTIONAL RH AND/OR LH ENGINE SIDE 161 174 HARNESS HARNESS L
HOOD MNTD MIRROR HEAT WHT1517-151 , 19.0 WHT1500-152 , 5.0 WHT1500-153 , 2.0 B B 2 2
RH
KW DOOR 6 6 WHT1500-154 , 2.0 A A WHT5921-152 , 2.0 8 8 WHT5921-245, 2.0
241
WHT5921-242, 2.0 1 1
HEAT DIAGRAM SHOWS BOTH RH & LH

SYSTEM YEL5921-151 , 2.0 YEL5921-151 , 2.0 13 13 YEL5921-242, 2.0 OPTIONAL HOOD MOUNTED MIRRORS.
KW HOOD-MNTD MIRROR (OPT) WHEN ONLY LH MIRROR INSTALLED,
YEL5921-152 , 2.0 YEL5921-152 , 2.0 14 14 YEL5921-241, 2.0 P246 GND WIRE ID IS:WHT5921-243.
DIAGRAM J155 P241 WHT5921-241, 2.0 1 1
HEAT WHEN ONLY RH MIRROR INSTALLED,
GND WIRE ID IS: WHT5921-244.
LH
2 2
K CHASSIS K
HARNESS 15 6 P152

CAB 15 6 J152 T001 J01Z P793

FIREWALL GND 005 006
PDC CAB SIDE WHT1515-012 32.0 WHT1515-028 13.0
6
WHT1521-001 5.0 A A WHT1521-791 , 3.0

BATT BUS 6 WHT1515-023 8.0 RED1150-002 5.0 B B YEL1150-791 , 3.0

IGN BUS DRIVER DOOR CNTRL MODULE

792
IP DRIVER
"BATTERY PWR #2" 1 YEL1150-795, 3.0 P796

J-CASE 30 AMP
J-CASE 30 AMP
GAUGE CL/RKE
HARNESS DOOR
J J

LH DOOR
RH DOOR
HARNESS
"BATTERY PWR #1" 4 M

5 AMP
YEL1150-794 , 3.0 B B

C_H5
C_B3

C_F5

791
C_N9
"GROUND #1" 18 WHT1521-794, 3.0 A A
J3 P003
"GROUND #2" 15 WHT1521-795, 3.0
A4 A4 RED1150-002 5.0
c 86 62 "WINDOW UP" 2 YEL6911-796 2.0
85 WINDOW LIFT MOTOR
"WINDOW DOWN" 3 YEL6912-796 2.0 J796

87 30 J4 P004
"DOOR UNLOCK" 5 YEL6715-795, 0.5 2 2 C DOOR LOCK
I 87A
ACTUATOR I
MIRROR A5 A5 RED1150-001 5.0 "DOOR LOCK" 6 YEL6711-795 , 0.5 3 3
HEAT
B19 B19 RED6711-001 0.5 "DOOR AJAR SENSOR" 10 BLU6720-795, 0.5 4 4
C_P19 "MIRROR CTRL VERT" 12 YEL5923-791 0.5 6 6
LH MIRROR
63 AJAR SWITCH
"MIRROR CTRL COMMON" 14 YEL5924-791 0.5

RED6711-791, 0.5
J1 P001 DOOR LATCH
70 15 AMP
"MIRROR CTRL HORIZ" 13 YEL5922-791 0.5 SHOWN IN DOOR CLOSED
C_Q12 A4 A4 YEL5921-003 1.0 POSITION.
RH MIRROR
"CECU WAKEUP" 17 BLU3112-794 0.5 SWITCH CLOSED IN THE
H B31 B31 YEL5921-004 1.0 DOOR OPEN OR AJAR H
"C-CAN J1939 (-)" 9 GRN0821-794 0.75 POSITION.
15 AMP 64
"C-CAN J1939 (+)" 8 YEL0821-794 0.75 DRIVER DOOR
J2 P002
D E F A C B H P791 IP HARNESS
B21 B21 P795
D E F A C B H J088 P040

GRA5921-001 0.5
* ALL RELAYS & FUSES ARE ON CAB SIDE OF THE CAB PDC YEL0821-002 0.75 YEL5923-001 0.8 4 4 RED
SEE J1939
SYS DIAG M U/D
G GRN0821-002 0.75 YEL5924-001 1.0 2 2 ORN G
053 M L/R
BLU3112-002 0.5 BLU3112-002 0.5 YEL5922-001 0.8 3 3 BRN
CECU J050

GRA3112-002 0.5
CECU 5 (E) 050
RED6711-003 0.5 1 1
"CECU MIRROR HT CTRL" 9 6 HEAT
WHT5921-001 1.0 8 8

YEL5921-003 1.0 6 6
J030 J001 P793 SEE ENG SYS DIAG
CECU 4 (D) 5 5
015
"LH/RH DOOR W/U" 2 WHT1521-002 5.0 A A WHT1521-791 , 3.0 OAT SENSOR
F 6 F
RED1150-001 5.0 B B YEL1150-791 , 3.0 DRIVER-SIDE MIRROR

PSGR DOOR CNTRL MODULE

792
"BATTERY PWR #2" 1 YEL1150-795, 3.0 P796
IP PASSENGER
HARNESS DOOR
M

WHT5921-002 1.0
"BATTERY PWR #1" 4 YEL1150-794 , 3.0 B B
HARNESS

791
"GROUND #1" 18 WHT1521-794, 3.0 A A

"GROUND #2" 15 WHT1521-795, 3.0

BLU3112-001 0.5
E "WINDOW UP" 2 YEL6911-796 2.0 E
WINDOW LIFT MOTOR
"WINDOW DOWN" 3 YEL6912-796 2.0 J796

"DOOR UNLOCK" 5 YEL6715-795, 0.5 5 5 C DOOR LOCK

ACTUATOR
"DOOR LOCK" 6 YEL6711-795, 0.5 6 6

DETAIL A "DOOR AJAR SENSOR" 10 BLU6720-795, 0.5 1 1

W/OPTIONAL SLEEPER BATT BUS "MIRROR CTRL VERT" 12 YEL5923-791 0.5 3 3
D AJAR SWITCH D
"MIRROR CTRL COMMON" 14

RED6711-791 , 0.5
YEL5924-791 0.5
DOOR LATCH
"MIRROR CTRL HORIZ" 13 YEL5922-791 0.5 SHOWN IN DOOR CLOSED
RSA/CLOCK

POSITION.
5 AMP
F14

"CECU WAKEUP" 17 BLU3112-794 0.5 SWITCH CLOSED IN THE

SLPR "C-CAN J1939 (-)" 9 GRN0821-794 0.75
DOOR OPEN OR AJAR
POSITION.
PDC "C-CAN J1939 (+)" 8 YEL0821-794 0.75
(LH SLPR TOOL BOX FWD WALL) B15 J382
"EXTERNAL LOCK SIGNAL" 7 BLU6717-791 0.5 PASSENGER DOOR
C B15 P381 C
P795 G D E F A C B H P791 IP HARNESS
DRIVER DOOR CNTRL MODULE P795
G D E F A C B H J014 P042
RED4922-381 , 0.5

"EXTERNAL LOCK SIGNAL" 7

SEE J1939 YEL0821-003 0.75 YEL5923-002 0.8 4 4 RED
RED6713-501, 0.5 SYS DIAG M U/D
GRN0821-003 0.75 YEL5924-002 1.0 2 2 ORN
SLPR CONTROL M L/R
HARNESS BLU3112-001 0.5 YEL5922-002 0.8 3 3 BRN
J505 S1 SLEEPER IP DRIVER DOOR
505 HARNESS HARNESS HARNESS RED6711-002 0.5 1 1
B 7 7
BL
9 9 6 RED4922-501 , 0.5 A10 A10 HEAT B
WHT5921-002 1.0 8 8
3 3 GRA6713-501, 0.5 A1 A1 GRA6713-381 , 0.5 A12 A12 GRA6713-001 0.5 G G BLU6717-791 0.5
2B
2B YEL5921-004 1.0
1 PASSENGER-SIDE MIRROR
1 J502 P383 J381 P065 J088 P791
6
5B UNLESS OTHERWISE NOTED TITLE
DOOR LOCK SWITCH
DIAG-NGP DOOR CONTROLS
THIS DRAWING AND THE
4 INFORMATION CONTAINED
(MOMENTARY) HEREIN ARE PROPRIETARY
TO PACCAR INC.

8 10 IT SHALL NOT BE
REPRODUCED, COPIED OR DRAWING REV

A P94-1864 A A
DISCLOSED, IN WHOLE OR
IN PART, OR USED FOR
MANUFACTURE OR FOR
OTHER PURPOSE WITHOUT
THE WRITTEN PERMISSION DWG
OF PACCAR INC. SCALE DRAWING SCALE DRAWING VERSION A.4 SHEET 2 OF 4 SIZE

A0
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

DETAIL B PB HOOD-MNTD MIRROR (OPT)

L W/OPTIONAL RH AND/OR LH T151 J159 P177 CHASSIS HOOD P247 L
HOOD MNTD MIRROR HEAT FIREWALL GND HARNESS HARNESS
161 174
PB DOOR
WHT1517-151, 19.0 WHT1500-152 , 5.0 WHT1500-153 , 2.0 B B YEL5921-242, 2.0 2 2 RH
ENGINE SIDE
6 6 241
WHT1500-154 , 2.0 A A WHT5921-152, 2.0 8 8 WHT5921-245, 2.0 WHT5921-242, 2.0 1 1
SYSTEM YEL5921-151 , 2.0 YEL5921-151 , 2.0 13 13 YEL5921-242 , 2.0
HEAT DIAGRAM SHOWS BOTH RH & LH
OPTIONAL HOOD MOUNTED MIRRORS.

DIAGRAM PB HOOD-MNTD MIRROR (OPT) WHEN ONLY LH MIRROR INSTALLED,

YEL5921-152 , 2.0 YEL5921-152 , 2.0 14 14 YEL5921-241, 2.0 P246 GND WIRE ID IS:WHT5921-243.
HEAT WHEN ONLY RH MIRROR INSTALLED,
P241 WHT5921-241, 2.0 1 1 GND WIRE ID IS: WHT5921-244.
J155
LH
K YEL5921-241, 2.0 2 2 K
15 6 P152

CAB 15 6 J152
FIREWALL GND
T001 J01Z P793
P796
005 006
PDC CAB SIDE WHT1515-012 32.0 WHT1515-028 13.0 WHT1521-001 5.0 A A WHT1521-791, 3.0
YEL6911-796, 3.0 B B M
BATT BUS 6 WHT1515-023 8.0 6 RED1150-002 5.0 B B YEL1150-791 , 3.0
YEL6912-796, 3.0 A A
IGN BUS DRIVER DOOR CNTRL MODULE

792
IP DRIVER
J "BATTERY PWR #2" 1 YEL1150-795 , 2.0 J

J-CASE 30 AMP
J-CASE 30 AMP
GAUGE CL/RKE
HARNESS DOOR

LH DOOR
RH DOOR
HARNESS
"BATTERY PWR #1" 4

5 AMP
YEL1150-794 , 2.0

C_H5
C_B3

C_F5
WINDOW LIFT MOTOR

791
C_N9 J796
"GROUND #2" 18 WHT1521-794 , 2.0
J3 P003
"GROUND #1" 15 WHT1521-796 , 2.0 YEL6715-795, 0.5 2 2 C DOOR LOCK
A4 A4 RED1150-002 5.0 ACTUATOR
c 86 62
"WINDOW UP" 2 YEL6911-796 , 3.0 YEL6711-795, 0.5 3 3
85
"WINDOW DOWN" 3 YEL6912-796 , 3.0 BLU6720-795, 0.5 4 4
SHOWN IN DOOR CLOSED
I 87 30 J4 P004
"DOOR UNLOCK" 5 YEL6715-795 , 0.5 RED6711-791, 0.5 6 6 POSITION. I
87A SWITCH CLOSED IN THE
AJAR SWITCH
MIRROR A5 A5 RED1150-001 5.0 "DOOR LOCK" 6 YEL6711-795 , 0.5 DOOR OPEN OR AJAR
HEAT DOOR LATCH POSITION.
B19 B19 RED6711-001 0.5 "DOOR AJAR SENSOR" 10 BLU6720-795 , 0.5 P799

C_P19 "MIRR CTRL VERT" 12 YEL5923-797 , 0.5 YEL5923-797 , 0.5 4 4 RED

LH MIRROR
M U/D
63
"MIRR CTRL COMMON" 14 YEL5924-797 , 0.5 YEL5924-797 , 0.5 2 2 ORNG
J1 P001
15 AMP M L/R
70
"MIRR CTRL HORIZ" 13 YEL5922-797 , 0.5 YEL5922-797 , 0.5 3 3 BRN
C_Q12 A4 A4 YEL5921-003 1.0
H RH MIRROR
"CECU WAKEUP" 17 BLU3112-794 , 0.5 WHT5921-797 , 1.0 1 1
H
B31 B31 YEL5921-004 1.0 HEAT
15 AMP "C-CAN J1939 (-)" 9 GRN0821-794 , 0.75 YEL5921-797 , 1.0 8 8
64
"C-CAN J1939 (+)" 8 YEL0821-794 , 0.75 GRN4527-797 , 0.5 5 5
J2 P002

WHT1515-023 8.0

RED6711-001 0.5
BLU4527-797 , 0.5 6 6
B21 B21 P795 OAT SENSOR
DRIVER DOOR D E F B A P791 C B P792
GRA5921-001 0.5

* ALL RELAYS & FUSES ARE ON CAB SIDE OF THE CAB PDC DRIVER-SIDE MIRROR
D E F B A J088 C B J01X
G G
SEE J1939 YEL0821-002 0.75
SYS DIAG
GRN0821-002 0.75
CECU CECU 5 (E)
J050
053
BLU3112-002 0.5 BLU3112-002 0.5
"CECU MIRROR HT CTRL" 9
SEE ENG GRN4527-003 0.5
SYS DIAG
BLU4527-003 0.5
J030
CECU 4 (D)
6
F "LH/RH DOOR W/U" 2 GRA3112-002 0.5
050
RED6711-003 0.5 F
YEL5921-003 1.0
J001 P793
015 A A
WHT1521-002 5.0 WHT1521-791, 3.0
6
RED1150-001 5.0 B B YEL1150-791 , 3.0
P796
PSGR DOOR CNTRL MODULE
DETAIL A

792
BATT BUS IP PASSENGER

BLU3112-001 0.5
RED6711-002 0.5 "BATTERY PWR #2" 1 YEL1150-795 , 2.0 YEL6911-796, 3.0 B B M
W/OPTIONAL SLEEPER HARNESS DOOR
E HARNESS
"BATTERY PWR #1" 4 YEL1150-794 , 2.0 YEL6912-796, 3.0 A A E

791
"GROUND #2" 18 WHT1521-794 , 2.0 WHT5921-797 1.0
RSA/CLOCK

"GROUND #1" 15
5 AMP

WHT1521-796 , 2.0
F14

WINDOW LIFT MOTOR

SLPR "WINDOW UP" 2 YEL6911-796 , 3.0 J796

PDC "WINDOW DOWN" 3 YEL6912-796 , 3.0 YEL6715-796, 0.5 5 5 C DOOR LOCK

793 ACTUATOR
(LH SLPR TOOL BOX FWD WALL) B15 J382 DRIVER DOOR CNTRL MODULE "DOOR UNLOCK" 5 YEL6715-795 , 0.5 YEL6711-796 , 0.5 6 6
D P381 794 D
B15 "EXTERNAL LOCK SIGNAL" 7 "DOOR LOCK" 6 YEL6711-795 , 0.5 BLU6720-795, 0.5 1 1
SHOWN IN DOOR CLOSED
"DOOR AJAR SENSOR" 10 BLU6720-795, 0.5 RED6711-792, 0.5 3 3 POSITION.
BLU6717-791 , 0.5

P795 SWITCH CLOSED IN THE

RED4922-381 , 0.5

AJAR SWITCH DOOR OPEN OR AJAR

"MIRR CTRL VERT" 12 YEL5923-797 , 0.5
DOOR LATCH POSITION.
RED6713-501, 0.5 "MIRR CTRL COMMON" 14 YEL5924-797 , 0.5 P799

SLPR CONTROL IP DRIVER DOOR "MIRR CTRL HORIZ" 13 YEL5922-797 , 0.5 YEL5923-797 , 0.5 4 4 RED
HARNESS HARNESS HARNESS M U/D
J505 S1 "CECU WAKEUP" 17 BLU3112-794 , 0.5 YEL5924-797 , 0.5 2 2 ORNG
C 505
G G
M L/R C
7 7 9 9 RED4922-501 , 0.5 A10 A10 "C-CAN J1939 (-)" 9 GRN0821-794 , 0.75 YEL5922-797 , 0.5 3
BL 6 3 BRN
SLPR
IP
2B 3 3 GRA6713-501, 0.5 A1 A1 HARNESS
HARNESS "C-CAN J1939 (+)" 8 YEL0821-794 , 0.75 WHT5921-797 , 1.0 1 1
2B J088 P791 HEAT
1 J381 P065 "EXTERNAL LOCK SIGNAL" 7 BLU6717-791 , 0.5 YEL5921-797 , 1.0 8 8
1 J502 P383
6
5B GRA6713-381 , 0.5 A12 A12 GRA6713-001 0.5 P795_ PASSENGER DOOR G D E F B A P791_ C B P792 PASSENGER-SIDE MIRROR
4
DOOR LOCK SWITCH B12 B12 GRA6731-001 0.5 G D E F B A J014 C B J010
8 10 (MOMENTARY)
B B9 B9 GRA6711-001 0.5 SEE J1939 YEL0821-003 0.75 B
SLPR SLPR SYS DIAG
DOOR HARNESS GRN0821-003 0.75

BLU3112-001 0.5
SLPR
DOOR
C B B BLK-GRA808 , 1.0 B B GRA6731-381 , 0.8
GRA6731-001 0.5
LOCK A A GRA-BLK809 , 1.0 A A GRA6711-381 , 0.8 UNLESS OTHERWISE NOTED TITLE
ACT
DIAG-NGP DOOR CONTROLS
THIS DRAWING AND THE
GRA6711-001 0.5 INFORMATION CONTAINED
P1 P2 J387
HEREIN ARE PROPRIETARY
TO PACCAR INC.
IT SHALL NOT BE
RED6711-002 0.5 REPRODUCED, COPIED OR DRAWING REV

A P94-1864 A A
DISCLOSED, IN WHOLE OR
IN PART, OR USED FOR
MANUFACTURE OR FOR
YEL5921-004 1.0 OTHER PURPOSE WITHOUT
DWG
THE WRITTEN PERMISSION
OF PACCAR INC. SCALE DRAWING SCALE DRAWING VERSION A.4 SHEET 3 OF 4 SIZE

A0
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

L L
C-CAN DATA BUS CONTROLS DESCRIPTION ESA MONITOR TROUBLE SHOOTING INFORMATION

FROM DRIVER'S SIDE DOOR CONTROL MODULE TO PASSENGER SIDE DOOR CONTROL MODULE COMPONENT DETAILED DESCRIPTION

PASSENGER WINDOW UP COMMAND DRIVER DOOR AJAR

PASSENGER WINDOW DOWN COMMAND WITH DOOR IN OPEN POSITION YOU CAN MANIPULATE LATCH WITH SCREWDRIVER.
PASSENGER DOOR LOCK COMMAND OBSERVE POSITION CHANGE IN ESA. RESET LATCH BY OPENING THE DOOR.
PASSENGER DOOR UNLOCK COMMAND NOTE CAN DATABUS CONTROL.
PASSENGER DOOR AJAR
K PASSENGER MIRROR UP COMMAND K
PASSENGER MIRROR DOWN COMMAND
PASSENGER MIRROR RIGHT COMMAND
PASSENGER MIRROR LEFT COMMAND

FROM PASSENGER SIDE DOOR CONTROL MODULE TO DRIVER SIDE DOOR CONTROL MODULE

DRIVER DOOR LOCK COMMAND

DRIVER DOOR UNLOCK COMMAND

J J
CECU WAKE UP FEATURE

WHEN EITHER DRIVER OR PASSENGER DOOR IS OPEN THE RESPECTIVE DOOR CONTROL MODULE SENDS A "WAKE UP"
SIGNAL TO THE CECU. THE CECU NOTES THE C-CAN OPEN DOOR MESSAGE AND ACTIVATES THE DOME LAMP.

DOOR LOCK SOLENOID INFORMATION

WHEN LOCK COMMAND IS REQUESTED THE DOOR CONTROL MODULES ON BOTH SIDES
I POWER IS APPLIED TO P795 PIN 6 AND GROUND IS APPLIED TO P795 PIN 5. I
WHEN UNLOCK COMMAND IS REQUESTED THE DOOR CONTROL MODULES ON BOTH SIDES
POWER IS APPLIED TO P795 PIN 5 AND GROUND IS APPLIED TO P795 PIN 6.

H H

DOOR SYSTEM DIAGNOSTIC CODES

DTC BRIEF DESCRIPTION DETAILED DESCRIPTION
This DTC will be reported when the door control module detects above normal voltage on the window regulator
52427703 Driver-Side Window Regulator Voltage High motor circuits. This is possibly because of damage to the window regulator motor circuits causing a short to
voltage.
G This DTC will be reported when the door control module detects below normal voltage on the window regulator G
52427704 Driver-Side Window Regulator Voltage Low motor circuits. This is possibly because of damage to the window regulator motor circuits causing a short to
ground.
This DTC will be reported when the door control module detects excessive current draw on the window regulator
52427706 Driver-Side Window Regulator Current High motor circuits. Some possible causes for this is damage to the window regulator motor circuits causing a short
to ground, water in a connector, or window regulator motor failure.
This DTC will be reported when the door control module detects above normal voltage on the horizontal mirror
52428403 Driver-Side Horizontal Mirror Position Voltage High motor circuit. This is possibly because of damage to the horizontal mirror motor circuit causing a short to
voltage.
This DTC will be reported when the door control module detects below normal voltage on the horizontal mirror
F 52428404 Driver-Side Horizontal Mirror Position Voltage Low motor circuit. This is possibly because of damage to the horizontal mirror output circuit causing a short to F
ground.
This DTC will be reported when the door control module detects low current or an open circuit on the horizontal
52428405 Driver-Side Horizontal Mirror Position Open Circuit mirror motor output circuit. Some possible causes for this DTC are an open mirror output circuit, corroded or
disconnected connector, or mirror motor failure.
This DTC will be reported when the door control module detects excessive current draw on the horizontal mirror
52428406 Driver-Side Horizontal Mirror Position Current High motor circuit. Some possible causes for this is damage to the horizontal mirror motor circuit causing a short
to ground, water in a connector, or mirror motor failure.
This DTC will be reported when the door control module detects above normal voltage on the vertical mirror
52428503 Driver-Side Vertical Mirror Position Voltage High motor circuit. This is possibly because of damage to the mirror motor circuit causing a short to voltage.

E This DTC will be reported when the door control module detects below normal voltage on the vertical mirror E
52428504 Driver-Side Vertical Mirror Position Voltage Low motor circuit. This is possibly because of damage to the vertical mirror motor circuit causing a short to
ground.
This DTC will be reported when the door control module detects low current or an open circuit on the vertical
52428505 Driver-Side Vertical Mirror Position Open Circuit mirror motor circuit. Some possible causes for this DTC are an open mirror motor circuit, corroded or
disconnected connector, or mirror motor failure.
This DTC will be reported when the door control module detects excessive current draw on the vertical mirror
52428506 Driver-Side Vertical Mirror Position Current High motor circuit. Some possible causes for this is damage to the vertical mirror motor circuit causing a short to
ground, water in a connector, or mirror motor failure.
This DTC will be reported when the door control module detects above normal voltage on the window regulator
D 52427803 Passenger-Side Window Regulator Voltage High motor circuits. This is possibly because of damage to the window regulator motor circuits causing a short to D
voltage.
This DTC will be reported when the door control module detects below normal voltage on the window regulator
52427804 Passenger-Side Window Regulator Voltage Low motor circuits. This is possibly because of damage to the window regulator motor circuits causing a short to
ground.
This DTC will be reported when the door control module detects excessive current draw on the window regulator
52427806 Passenger-Side Window Regulator Current High motor circuits. Some possible causes for this is damage to the window regulator motor circuits causing a short
to ground, water in a connector, or window regulator motor failure.
This DTC will be reported when the door control module detects above normal voltage on the horizontal mirror
52428203 Passenger-Side Horizontal Mirror Position Voltage High motor circuit. This is possibly because of damage to the horizontal mirror motor circuit causing a short to
voltage.
C This DTC will be reported when the door control module detects below normal voltage on the horizontal mirror C
52428204 Passenger-Side Horizontal Mirror Position Voltage Low motor circuit. This is possibly because of damage to the horizontal mirror output circuit causing a short to
ground.
This DTC will be reported when the door control module detects low current or an open circuit on the horizontal
52428205 Passenger-Side Horizontal Mirror Position Open Circuit mirror motor output circuit. Some possible causes for this DTC are an open mirror output circuit, corroded or
disconnected connector, or mirror motor failure.
This DTC will be reported when the door control module detects excessive current draw on the horizontal mirror
52428206 Passenger-Side Horizontal Mirror Position Current High motor circuit. Some possible causes for this is damage to the horizontal mirror motor circuit causing a short
to ground, water in a connector, or mirror motor failure.
This DTC will be reported when the door control module detects above normal voltage on the vertical mirror
B 52428303 Passenger-Side Vertical Mirror Position Voltage High motor circuit. This is possibly because of damage to the mirror motor circuit causing a short to voltage. B
This DTC will be reported when the door control module detects below normal voltage on the vertical mirror
52428304 Passenger-Side Vertical Mirror Position Voltage Low motor circuit. This is possibly because of damage to the vertical mirror motor circuit causing a short to
ground.
This DTC will be reported when the door control module detects low current or an open circuit on the vertical
52428305 Passenger-Side Vertical Mirror Position Open Circuit mirror motor circuit. Some possible causes for this DTC are an open mirror motor circuit, corroded or
disconnected connector, or mirror motor failure. UNLESS OTHERWISE NOTED TITLE

DIAG-NGP DOOR CONTROLS

THIS DRAWING AND THE
This DTC will be reported when the door control module detects excessive current draw on the vertical mirror INFORMATION CONTAINED
HEREIN ARE PROPRIETARY
52428306 Passenger-Side Vertical Mirror Position Current High motor circuit. Some possible causes for this is damage to the vertical mirror motor circuit causing a short to TO PACCAR INC.
IT SHALL NOT BE
DRAWING REV
ground, water in a connector, or mirror motor failure. REPRODUCED, COPIED OR

A P94-1864 A A
DISCLOSED, IN WHOLE OR
IN PART, OR USED FOR
MANUFACTURE OR FOR
OTHER PURPOSE WITHOUT
THE WRITTEN PERMISSION DWG
OF PACCAR INC. SCALE DRAWING SCALE DRAWING VERSION A.4 SHEET 4 OF 4 SIZE

A0
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1