MAINTENANCE SCHEDULE
2003-2005 RANGE ROVER
Owner's Name:______________________________________________________________________
Date: ____________________ Mileage ________________________ RO#: ___________________
MAINTENANCE TYPE Oil #1 Oil #2 Oil #1 Oil #2
INTERVAL AND TIME (Months) 12 24 36 48 60 72 84 96
TYPE Nominal MILES (Thousands) 15 30 45 60 75 90 105 120
Nominal KILOMETERS (Thousands) 24 48 72 96 120 144 168 192
1 INSIDE VEHICLE
1.1 Reset the Service Interval Indicator
1.2 Check parking brake operation
1.3 Check operation of all lights, warning indicators and horn
1.4 Check operation of front/rear wiper washer systems
1.5 Check condition and security of seats and seat belts
2 OUTSIDE VEHICLE
2.1 Check condition of wiper blades
2.2 Lubricate top 'flip seal with Carbaflo XTR5 (LRNXRT5) on each door.
3 UNDER HOOD
3.1 Clean battery and terminals
3.2 Replace pollen filter
3.3 Inspect serpentine drive belt
3.4 Check and top-up brake PAS and windshield washer fluid
3.5 Change brake fluid
3.6 Check coolant level
3.7 Change engine coolant
3.8 X Replace spark plugs
3.9 X Replace air-cleaner element
4 UNDER VEHICLE
4.1 X Change engine oil and replace filter
4.2 Remove road wheels
4.3 Inspect brake pads and calipers for leaks and wear
4.4 Check tire pressures are set to recommended levels
4.5 Check tires for damage and tread depth
4.6 Inspect for under vehicle fluid leaks
4.7 Inspect steering components for wear
4.8 Check suspension bolts and fasteners
4.9 Inspect brake, fuel lines for leaks, corrosion or damage
4.10 Inspect PAS hoses for leaks, corrosion or damage
4.11 Inspect air suspension pipes & connectors/fittings for leaks or damage
4.12 Lubricate wheel centers and install road wheels on same axle opposite side
unless directional tires are fitted
5 ANTI-CORROSION CHECK (NOTE: Small blister in the underbody sealer are acceptable if metal is NOT exposed.)
5.1 Perform under body corrosion warranty inspection
• Sills and wheel arches
• Main floor
• Subframe
• Areas next to mounting and fuel tank fasteners
• Exterior paint
• Leading edge of hood
• Hood seams
• Lower body and doors
• Visible flanges in engine and luggage compartments
6 REMEDIAL WORK REQUIRED:
• YES
• NO
7 ROAD TEST
7.1 Road test vehicle
7.2 Record performance of Service in Passport to Service booklet
“Nominal” distance values for normal driving. See Passport to Service for additional information.
X REQUIRED EMISSION MAINTENANCE
SUPPLEMENTARY RESTRAINT SYSTEM (SRS): The AIR BAGS and SEAT BELT TENSIONERS must be replaced EVERY 15 YEARS
LRNA 6/6/2005
CAUTION: Do not perform two wheel roller tests.
Loaded I/M testing of permanent four wheel drive or traction
control equipped vehicles must be conducted on a four
wheel drive synchronized dynamometer. Otherwise a non-
loaded test procedure must be followed.
NOTE: Some items do not need to be carried out at every
service. All required steps in a specific service are
identified in the column headed by the mileage/month by a
check box -
IMPORTANT
VEHICLES FITTED WITH SUPPLEMENTARY RESTRAINT SYSTEMS
• Seatbelt pre-tensioners and air bags must be replaced every FIFTEEN
YEARS
IT IS RECOMMENDED THAT:
• If a vehicle is used extensively in arduous/ off road conditions, the road wheel
speed sensors, brake pads and calipers should be checked for abrasive wear
every 1000 miles (1500 kilometers).
• When the vehicle is used in dusty or off road conditions, or is subjected to
deep wading, frequent replacement of the air cleaner may be required .
For full details regarding the operations contained in this maintenance
check sheet, please refer to the Workshop Manual.
LRNA 6/6/2005
