TECHNICAL SPECIFICATION COVER SHEET REVISED SHEETS

THIS PAGE IS A RECORD OF ALL SPECIFICATION REVISIONS. NORMALLY, REVISED SHEETS ONLY ATTACHED
EACH TIME THE SPECIFICATION IS CHANGED ONLY THE NEW OR REVISED ENTIRE SPECIFICATION RE-ISSUED
PAGES ARE ISSUED. ENTIRE SPECIFICATION REVISED

THE NATURE OF THE REVISION IS BRIEFLY NOTED UNDER REMARKS BUT

ISSUED FOR
THESE REMARKS ARE NOT A PART OF THE SPECIFICATION. THE REVISED
PAGES BECOME PART OF THE ORIGINAL SPECIFICATION AND SHALL BE REVIEW/COMMENTS
COMPLETED WITHIN THEIR ENTIRELY. TENDER/QUOTATION X
PURCHASE
CONSTRUCTION
X
REV. DATE PREPARED REVIEWED APPROVED PAGES REMARKS
NO. BY BY BY x
0 March 2022 A.A. 5 ISSUED FOR TENDER
X

SPECIFICATION REV.
ECG ENGINEERING CONSULTANTS GROUP S.A. TABLE OF CONTENT
CAIRO - EGYPT 000010 - 2874 0

ECG Form No. E409 Rev. 5/03 Sheet 0 of 5

 URBANIUM NEW ADMINISTRATIVE BUILDING

CONTENTS

VOLUME I

GENERAL REQUIREMENTS

VOLUME II

METHOD OF MEASUREMENT, BILL OF QUANTITIES & LIST OF MANUFACTURERS

DIVISION 0: INFORMATION

000010 Table of Contents

DIVISION 1: GENERAL REQUIREMENTS

012700 Method of Measurement

012750 Bill of Quantities
012950 List of Manufacturers

VOLUME III

TECHNICAL SPECIFICATIONS – PART A

Divisions 03 Concrete

033000 Cast In Place Concrete

033316 Lightweight concrete
034800 Precast Concrete Parking Bumpers
035440 Cement-Based Screeds

Divisions 04 Masonry

042000 Unit Masonry

044200 Exterior Stone Cladding

Divisions 05 Metals

051200 Structural Steel

055000 Metal Fabrications
055213 Pipe And Tube Railings
057300 Decorative Metal Railings

Divisions 06 Wood, Plastics, and Composites

064200 Wood Paneling

Table of Contents Section 000010

Urbanium New Administrative Building (Prj. 2874) Page 1 of 5
Division 07 Thermal and Moisture Protection

071113 Bituminous Damp-Proofing

071340 Polyethylene Sheet
071416 Cold Fluid-Applied Waterproofing
071613 Polymer Modified Cement Waterproofing
071616 Crystalline Waterproofing
071800 Traffic Coatings
074213 Metal Panels
075213 Atactic-Polypropylene (APP) Modified Bituminous Membrane Roofing
075216 Styrene-Butadiene-Styrene (SBS) Modified Bituminous Membrane
075323 Ethylene-Propylene-Diene-Monomer (EPDM) Roofing
078413 Penetration Firestopping
079200 Joint Sealants

Divisions 08 Openings

081113 Hollow Metal Doors and Frames

081416 Flush Wood Doors
083113 Access Doors and Frames
084113 Aluminum-Framed Entrances and Storefronts
084423 Structural-Sealant-Glazed Curtain Walls
085113 Aluminum Windows
087100 Door Hardware
088000 Glazing
088300 Mirrored Glass
089000 Louvers and Vents

Divisions 09 Finishes

092400 Cement Plaster

092900 Gypsum Board Assemblies
093000 Tiling
095423 Linear Metal Ceilings
095427 Suspended Wood Ceilings
096340 Stone Flooring
096516 Resilient Sheet Flooring
096536 Static Control Resilient Floor Coverings
096600 Precast Terrazzo
096723 Resinous Flooring
096900 Access Flooring
097500 Stone Facing
099100 Painting

Division 10 Specialties

101405 Signage
101453 Traffic Signage
102113 Toilet Compartments
102600 Wall And Door Protection
102800 Toilet and Bath Accessories

Table of Contents Section 000010

Urbanium New Administrative Building (Prj. 2874) Page 2 of 5
104413 Fire Cabinets
104416 Fire Extinguishers
107113.43 Fixed Sun Screen

Divisions 11 Equipment

111500 Parking Control Equipments

Division 13 Special Construction

131200 Fabric Shades

131500 Reinforced Concrete Water Structures

Division 14 Conveying Equipment

142100 Electric Traction Elevators

149100 Facility Chutes

VOLUME III

TECHNICAL SPECIFICATIONS – PART B

Division 21 Fire Suppression

210548 Vibration And Seismic Controls For Fire-Suppression Piping And Equipment
211000 Water-Based Fire-Suppression Systems
211339 Foam-Water Systems
212100 Carbon Dioxide Fire Extinguishing Systems
212200 Clean-Agent Fire Extinguishing Systems
213113 Electrical-Drive, Centrifugal Fire Pumps
213400 Pressure-Maintenance Pumps

Division 22 Plumbing

220513 Common Motor Requirements for Plumbing Equipment

220523 General-Duty Valves for Plumbing Piping
220529 Hangers And Supports for Plumbing Piping and Equipment
220553 Identification for Plumbing Piping and Equipment
220719 Plumbing Piping Insulation
221116 Domestic Water Piping
221119 Domestic Water Piping Specialtie
221123.13 Domestic-Water Packaged Booster Pumps
221316 Sanitary Waste And Vent Piping
221319 Sanitary Waste Piping Specialties
221429 Sump Pumps
223300 Electric Domestic Water Heaters
224000 Plumbing Fixtures

Division 23 Heating Ventilating and Air Conditioning

230500 Common Work Results for Hvac

Table of Contents Section 000010

Urbanium New Administrative Building (Prj. 2874) Page 3 of 5
230513 Common Motor Requirements for Hvac Equipment
230516 Expansion Fittings And Loops for Hvac Piping
230519 Meters And Gages for Hvac Piping
230523 General-Duty Valves for Hvac Piping
230529 Hangers And Supports for Hvac Piping And Equipment
230548 Vibration And Seismic Controls for Hvac Piping And Equipment
230553 Identification For Hvac Piping and Equipment
230593 Testing, Adjusting, And Balancing for Hvac
230700 Hvac Insulation
230800 Commissioning Of Hvac
230900 Instrumentation And Control For Hvac
232113 Hydronic Piping
232123 Hydronic Pumps
232300 Refrigerant Piping
232500 Hvac Water Treatment
233113 Metal Ducts
233300 Air Duct Accessories
233423 HVAC Power Ventilators
233713 Diffusers, Registers, and Grilles
236426 Rotary-Screw Water Chillers
237313 Modular Indoor Central-Station Air-Handling Units
238123 Computer-Room Air-Conditioners
238126 Split-System Air-Conditioners
238129 Variable Refrigerant Air-Conditioners Units
238219 Fan Coil Units

Division 25 Building Management System

250000 Integrated Automation Systems

VOLUME III

TECHNICAL SPECIFICATIONS – PART C

Division 26 Electrical

260500 Conmen Work Result For Electrical Work

260513 Medium-Voltage Cables
260519 Low-Voltage Electrical Power Conductors And Cables
260526 Grounding and Bonding for Electrical Systems
260533 Raceway And Boxes for Electrical Systems
260536 Cable Trays for Electrical Systems
260553 Identification for Electrical Systems
261202 Medium-Voltage Dry Type Transformer
261301 Ring Main Unit
262413 Switchboards
262416 Panelboards
262419 Motor Control Centers

Table of Contents Section 000010

Urbanium New Administrative Building (Prj. 2874) Page 4 of 5
262500 Enclosed Bus Assemblies
262726 Wiring Devices
263213 Engine Generators
263353 Static Uninterruptible Power Supply
263533 Power Factor Correction Equipment
263600 Transfer Switches
264113 Lightning Protection for Structures
265100 Interior Lighting
265600 Exterior Lighting

Division 27 Communications

271000 Structured Cabling System

272000 Data Network Active Equipment
274133 Master Antenna Television System MATV
275116 Public Address System

Division 28 Electronic Safety and Security

281300 Access Control System

281303 Parking Management System
282300 Video Surveillance System
283100 Fire-Alarm System
283101 Disabled Persons Emergency Alarm System
283600 Liquids Leak Detection System

Division 31 Earthwork

312000 Earth Moving

Division 32 Exterior Improvements

321123 Aggregate Base Courses

321400 Unit Paving
321613 Concrete Curbs and Gutter
321723 Pavement Markings

Division 33 Utilities

331000 Water Supply And Firefighting Networks

333000 Sewage Collection Networks

Division 41 Material Processing And Handling Equipment

412215.10 Overhead Electrical Cranes

Table of Contents Section 000010

Urbanium New Administrative Building (Prj. 2874) Page 5 of 5
 TECHNICAL SPECIFICATION COVER SHEET REVISED SHEETS
THIS PAGE IS A RECORD OF ALL SPECIFICATION REVISIONS. NORMALLY, REVISED SHEETS ONLY ATTACHED
EACH TIME THE SPECIFICATION IS CHANGED ONLY THE NEW OR REVISED ENTIRE SPECIFICATION RE-ISSUED
PAGES ARE ISSUED. ENTIRE SPECIFICATION REVISED

THE NATURE OF THE REVISION IS BRIEFLY NOTED UNDER REMARKS BUT

ISSUED FOR
THESE REMARKS ARE NOT A PART OF THE SPECIFICATION. THE REVISED
PAGES BECOME PART OF THE ORIGINAL SPECIFICATION AND SHALL BE REVIEW/COMMENTS
COMPLETED WITHIN THEIR ENTIRELY. TENDER/QUOTATION X
PURCHASE
CONSTRUCTION
X
REV. DATE PREPARED REVIEWED APPROVED PAGES REMARKS
NO. BY BY BY x
0 March 2022 A.A. 74 ISSUED FOR TENDER
X

SPECIFICATION REV.
ECG ENGINEERING CONSULTANTS GROUP S.A. METHOD OF MEASUREMENT
CAIRO - EGYPT 012700 - 2874 0

ECG Form No. E409 Rev. 5/03 Sheet 0 of 74

 SECTION 012700

METHOD OF MEASUREMENT

STANDARD NOTES ON MEASUREMENT

1. These notes are intended as a guide only to the method adopted in the preparation of the
Bill of Quantities and the measurement of the Works. Contractors must note that rates
for items must include furnishing and everything necessary for the proper execution,
erection, completion and maintenance of each item and that all auxiliary work is included
unless specifically otherwise stated, measured or excluded in writing by the Engineer.

2. All items are measured net as fixed in position.

3. Rates must include work at all levels, furnishing, transportation and installation, materials
and goods, scaffolding and testing where applicable. Each item includes also, unless
otherwise specifically stated, all labor in making, materials, goods and all costs in
connection therewith (e.g. conveyance, delivery, unloading, storing, unpacking, returning
packing, handling, hoisting, lowering and the like), fitting, setting and fixing materials and
goods in position, all square raking and curved cutting, waste of and laps in materials, use
of plant, temporary works, patterns, models, templates, samples and establishment and
overhead charges and profit.

4. Quantities are billed to the nearest whole unit. Fractions of a unit less than half are
disregarded and all other fractions are regarded as whole units.

5. All quantities are quoted in metric (S.I.) units of measurement.

6. All rates shall be quoted in Egyptian Currency.

7. Attention is also directed to the Specifications and Drawings, which contain further notes
on all work, required and which are deemed to be included in rates quoted in attached
Bills of Quantities.

8. Rates include supplies, transportation, installation, dismantling and removal of materials,

temporary facilities, and machineries, hand tools, which are provided by the Contractor
at the site.

9. Rates include cost of removal of rubbish and debris from the site.

11. Rates for all equipment include testing at manufacturer’s premises and all spare parts
needed.

12. Rates shall represent full compensation for all plant, materials, transport, labor,
equipment, temporary works, establishment, overhead, profit, and tax charges required
to complete the work described in this sub-section of the specification and/or on the
drawings.

13. Rates shall include all facilities and equipment for testing and inspection by the Employer's
representatives.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 1 of 74
 DIVISION 3

CONCRETE

Section Unit Description

033000 Cast-In-Place Concrete

131500 Reinforced Concrete Water Structures

m3/m2 Classified according to concrete grade and thickness of the cast

elements.

Rates shall include the following:

 Furnishing concrete, all equipment necessary for transferring, depositing

and discharging concrete, all types of forms as required complete with all
ties, struts, bracing, scaffolding or staging and accessories, form oils, tapes,
steel reinforcement, steel beams, tying wire, spacers, bolsters, chairs,
spacing blocks, toggles, all types of additives, joint filers, joint sealants,
water-stops, curing compounds and sleeves for embedded articles.
 Design and erection of formwork, strutting, fixing at various levels, boxing
out, forming construction joints, and the like, chamfering of exposed
corners and edges, fixing sleeves for all embedded articles, fixing of water-
stops, forming holes blocking, boxing, ribs, props, fillets, cleaning and
everything necessary for fixing and removal of forms.
 Making and testing concrete cubes.
 Transferring and casting concrete, compaction, grading, trowelling, forming
channels, grooves, chases, rebates, construction and control joints and the
like, all kinds of grouting, working around obstructions and curing.
 Curing of different cast elements.
 Testing of all ingredient materials of concrete, and testing of concrete.
 Removal of forms and finishing of concrete surfaces.
 Testing of concrete elements including, but not limited to core testing.
 Steel Reinforcement cutting reinforcing bars and steel mesh to length,
bending, splicing, cleaning, placing in position fixing of all spacers and
accessories and tying of wire.
 No reduction from the measurement shall be made in respect of:
 Any purpose made hole or opening which has an average cross-section
area less than 0.2 m2.
 Volume occupied by any reinforcement, and the like embedded into
concrete.
Concrete Slabs-on-grade

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 2 of 74
 m2/m3 Classified according to thickness of slab.

Measured in sq m for concrete layers up to 200 mm thick and in cu m for

concrete over 200 mm thick.

Rates shall include the following:

 Items stated above.

 Plain concrete 50 mm thickness beneath R.C slab on grade.
 Furnishing materials, casting, construction of joints and saw-cut joints as
shown in drawing in addition to materials and work described in the above
item.

Plain Concrete

m2/m3 Classified according to thickness of slab.

Measured in sq m for concrete layers up to 200 mm thick and in cu m for

concrete over 200 mm thick.

Rates shall include the following:

 Items stated above.

 Surface preparation and work described in concrete.

033316 Non-Structural Lightweight Concrete

m2 Rates shall include the following:

 Concrete materials, aggregate, water, mixing, additives, grading and

trowelling.
 Pouring.
 Formwork.
 Furnishing base surface preparation, slopes, joints,..etc.

034800 Concrete Bumpers

NO Classified according to type.

Rates shall include the following:

 Furnishing all required field tests, survey works and design documents
and submit for engineer’s approval.
 Furnishing moulds, casting..etc.
 Construction requirements of handling, concreting, testing, cutting, ,
storing, transporting, , ..etc.
 Furnishing connections, bolts, welds, grout materials, fabrication,

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 3 of 74
 transferring and installation units, leveling, pads, joining, testing of cast
units pads.

035440 Cement-Based Screed

m2 For cement screed for roof.

Works include the following:

 Furnishing and installing materials.

 Concrete materials, aggregate, water, mixing, additives, grading and
trowelling.
 Reinforcement.
 Substrate preparation.
 Protection covering and cleaning.
 Repairing of defective screed.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 4 of 74
 DIVISION 4

MASONRY

Section Unit Description

042000 Unit Masonry

m2 Classified according to type, thickness, and fire rating period.

Measurements shall be for net areas; areas less than 0.25 sq.m will not be
deducted.

Rates shall include the following:

 Furnishing all required materials, vertical and horizontal reinforcement,

lintels, anchors, dowels, ties, inserts, metal expansion strips, expanded
metals, mortar, grouting, scaffolding and necessary tools, fire barrier.
 Building-in, cutting, bedding, bonding, plumbing angles, forming reveals,
grooves, chases, holes mortises, making good, and the like.
 Curing and cleaning faces.
 Partition top anchors.
 Through penetration fire stop systems.
 Sheet metal flashing and trim
 Concrete beams and posts acting as stiffening elements as required.
 All other necessary accessories to comply with specifications and
performance requirements.

044200 Exterior Stone Cladding

Classified according to type, thickness and method of fixation

m2 For Stone cladding.

m For Stone Base.

Rates shall include the following:

 Furnishing of all materials, which include but are not limited to stone,
special pieces, end and corner units.
 Setting materials, grout and sealants.
 Anchors, fasteners.
 Grinding, mitering, and beveling.
 Fixing in position and scaffolding.
 Stone accessories.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 5 of 74
  Bituminous Damp-Proofing.
 Cleaning, protection and repairing.
 All other requirements necessary to comply with specifications and
performance requirements.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 6 of 74
 DIVISION 5

METALS
Section Unit Description

051200 Structural Steel Framing

Ton Classified according to the type of steel sections, measured by weight of

furnishing, installing and erection and fire rating period of structural steel
sections.

Rates shall include the followings:

 Furnishing all materials according to detailed sections indicated in

Drawings and approved shop drawings.
 Bolts, nuts, washers, inserts, base plates and cutting works, bending,
welding, shaping, drilling, riveting, anchors, fixing in positions, grouting.
 Joisting.
 Hoisting.
 Shop priming.
 Fireproofing coating for fireproofed steel elements.
 Field finish coating for non-fireproofed steel elements.
 Touch-up painting.
 Repairing and replacing damaged elements.
 Testing.
 Any other required items as per Drawings and Specifications.

Ton Purlins Classified according to the type of purlin sections, measured by weight
of furnishing, installing, erection and coating.

Rates shall include the followings:

 Furnishing all materials according to detailed sections indicated in

Drawings and approved shop drawings.
 Bolts, nuts, washers, inserts, base plates and cutting works, bending,
welding, shaping, drilling, riveting, anchors, fixing in positions, grouting.
 Shop priming.
 Repairing and replacing damaged elements.
 Testing.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 7 of 74
055000 Metal Fabrications

 Classified according to material and height

Rates shall include the following:

 Furnishing of approved sections and dimensions materials, frames, anchors

and fasteners, hardware, and accessories.
 Fabrication process, shop painting and priming, installation and fixation,
field painting, and final finish.
 Required Grout materials.
 All necessary bending, welding, drilling, lugs, strap anchors, base plates and
anchor bolts, bracing, cutting and trimming, embedding into concrete,
pointing, bolting, sleeves, and repair of damaged galvanizing or coating.

055213 Pipe and Tube Railings

&
057300 Decorative Metal Railings

m Classified according to material, finish, type, and height.

Rates shall include the following:

 Design according to loads as per specifications.

 Furnishing and installing of required railing & handrails.
 All necessary bending, welding, drilling, lugs, strap anchors, base plates and
anchor bolts, bracing, cutting and trimming, embedding into concrete,
pointing, bolting, sleeves, and repair of damaged coating.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 8 of 74
 DIVISION 6

WOOD, PLASTICS, AND COMPOSITES

Section Unit Description

064200 Wood Paneling

m2 Classified according to type, size and finish.

Rates shall include the following:

 Furnishing and installing materials.

 Woods or plastic laminate veneers.
 Sealant and adhesive.
 Cutting, splicing, jointing, fittings, molding, beads, furring, fastening, kiln
drying, anchors.
 Fixing and grouting.
 Painting system including primer and finish coat.
 Replacing of damaged surface.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 9 of 74
 DIVISION 7

THERNMAL AND MOISTURE PROTECTION

Section Unit Description

071113 Bituminous Damp-Proofing

m2 Rates shall include the following:

 Furnishing materials, preparing substrates, cleaning, flushing brick joints

with mortar, and stirring.
 Applying bituminous damp-proofing.
 Protection of completed work.

071613 Polymer Modified Cement Waterproofing

m2 Rates shall include the following:

 Furnishing of waterproofing materials and additives.

 Preparation, cleaning and wetting the substrates.
 Applying, smoothing, making good and curing.
 Testing.
 Any other required items as per Drawings and Specifications

071340 Polyethylene Sheet

m2 Classified according to thickness.

Rates shall include the following:

 Furnishing materials including sheets.

 Preparing substrates, spreading and installing sheets, overlaps,
 Protection of completed work.
 Any other required items as per Drawings and Specifications.

071416 Cold Fluid-Applied Waterproofing

m2 Classified according to type and thickness.

Rates shall include the following:

 Furnishing waterproofing materials including, protection mat, sealants and

sheet flashing.
 Preparation of substrates.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 10 of 74
  Testing.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

074123 Metal Wall Panels

m2 Classified according to type of panel, material and finish.

Rates shall include the followings:

 Furnishing and installing materials.

 Insulation board, vapor retarder and any other underlayment materials.
 Expansion joints, primer, sealants, fixing materials, thermal spacers, and all
required accessories.
 Coating and finishing.
 Metal framing and furring.
 Rain water gutter.
 Translucent vision roof panels.
 Smoke ventilation.
 Roof anchor system for roof maintenance and cleaning.
 Metal Flashing.
 Replacing of damaged panels.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

071616 Crystalline Waterproofing

m2 Rates shall include the following:

 Furnishing of waterproofing materials and additives.

 Preparation, cleaning and wetting the substrates
 Applying, smoothing, making good and curing.
 Testing.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications

075216 Styrene-Butadiene-Styrene (SBS) Modified Bituminous Sheet

Waterproofing

m2 Classified according to type and thickness.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 11 of 74
 Rates shall include the following:

 Furnishing waterproofing materials including, protection mat, sealants and

sheet flashing.
 Preparation of substrates.
 Cutting, rounding, intersections, prime coat, and side overlapping to
vertical surfaces, reglets and bending free edge in grooving.
 Testing.
 Replacing of damaged membrane.
 Protection, covering and cleaning.
 Protection Board.
 Any other required items as per Drawings and Specifications.

075323 Ethylene-Propylene-Diene-Monomer (EPDM) Roofing

&
075213 Atactic-Polypropylene (APP) Modified Bituminous Membrane Roofing

m2 Rates shall include the following:

 Furnishing waterproofing materials including, protection mat, sealants and
sheet flashing.
 Preparation of substrates.
 Cutting, rounding, intersections, prime coat, and side overlapping to vertical
surfaces, reglets and bending free edge in grooving.
 Testing.
 Replacing of damaged membrane.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

m2 Thermal insulation:

Rates shall include the following:

 Furnishing and installing materials.

 Joint sealants.
 Protection layer.
 Preparation of substrates, cutting to sizes.
 Replacing of damaged board.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 12 of 74
071800 Traffic Coating

m2 Classified according to base of coating system, thickness and location.

Rates shall include the followings:

 Furnishing and installing materials.

 Surface preparation, primers, basecoat, intermediate coat, aggregate and
top coat, etc.
 Removing paint splashes, spots and stains, and leaving the whole of the
work perfect on completion.
 Joint Sealants, reinforcing strip.
 Traffic marker.
 Testing.
 Replacing of damaged surface.
 Protection, covering and cleaning.
 Any other required items as per Drawings and Specifications.

078413 Penetration Fire-stopping

 Through-penetration fire stop systems and related accessories shall not be

measured separately for payment and shall be paid as part of the Contract
unit price for the associated work requiring through-penetration fire stop
systems.

079200 Joint Sealants

 Joint sealant systems and related accessories shall not be measured

separately for payment and shall be paid as part of the Contract unit price
for the associated work requiring through joint sealant systems.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 13 of 74
 DIVISION 8

OPENINGS

Section Unit Description

081113 Hollow Metal Doors and Frames

No. Classified according to type, finish, and size, fire rating period as per Drawings
& Door Schedules.

Rates shall include the following:

 Frames and architrave.

 Accessories, fasteners, inserts, anchors, weather stripping, sealants, and
gaskets.
 Hardware.
 Mullions and transom bars.
 Cutting, fabrication, and welding.
 Hardware reinforcement in doors and frames.
 Filling frame with grout.
 Louvers & vision panel glazing where indicated.
 Finishing, and repairing.
 Testing, adjusting and cleaning.
 Furnishing and installing materials.
 Any other required items as per Drawings and Specifications.

083113 Access Doors and Frames

No. Classified according to type, material, finish, size and fire rating period as per
Drawings.

Rates Shall Include the Following:

 Furnishing & installing materials.

 Frames, accessories, fasteners, and sealants.
 Hardware.
 Metal flashing.
 Fabrication and welding.
 Finishing, and repairing.
 Testing, adjusting and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 14 of 74
081416 Flush Wood Doors

No. Classified according to type, size, finish, frame type, and fire rating period as
per Drawings & Door Schedules.

Rates shall include the followings:

 Furnishing and installation of doors frame, sub frame, and architrave.

 Hardware according to hardware schedule.
 Accessories, fasteners, inserts, anchors, weather stripping, and sealants.
 Louvers & vision panel where indicated.
 Testing, adjusting and cleaning.
 Painting, veneers, or staining.
 Transom and side panels.
 Repairing, and protection.
 Any other required items as per Drawings and Specifications.

084113 Aluminum-Framed Entrances and Storefronts

No. Classified according to type, size, and finish as per Drawings & elevation
Schedules.

Rates shall include the following:

 Furnishing & installing materials.

 Fasteners, anchors, clips, accessories, weather-stripping.
 Glazing, sealants.
 Doors as indicated on elevations type Drawings.
 Hardware.
 Vapor barrier, and thermal insulation.
 Metal flashing.
 Plugging, screwing, cutting, seals.
 Finishing, and repairing.
 Demonstration.
 Testing, adjusting and cleaning.
 Any other required items as per Drawings and Specifications.

084423 Structural-Sealant-Glazed Curtain Walls

No. Classified according to type, finish, and size as per Drawings & elevation
Schedules.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 15 of 74
 Rates shall include the following:

 Furnishing, reinforcement and installing materials.

 Steel supporting system.
 Glazing.
 Structural and weather sealants.
 Operable units to include windows and doors as indicated on elevations type
Drawings.
 Hardware.
 Thermal insulation.
 Perimeter fire-containment systems.
 Aluminum box for spandrel panel.
 Metal flashing.
 Finishing, and repairing.
 Adjusting, cleaning, and protection.
 Testing.
 Any other required items as per Drawings and Specifications.

085113 Aluminum Windows

No. Classified according to type, finish and size as per Drawings & windows
Schedules.

Rates Shall Include the Following:

 Furnishing & installing materials.

 Glazing.
 Insect screen (if indicated).
 Sealants.
 weatherstripping.
 Finishing, and repairing.
 Hardware.
 Adjusting, cleaning, and protection.
 Any other required items as per Drawings and Specifications.

087100 Door Hardware

No. Classified according to hardware set as per Door hardware set Schedule.

Rates Shall Include the Following:

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 16 of 74
  Components of hardware sets as indicated Door hardware set Schedule
 Furnishing & installing materials.
 Adjusting, cleaning, and protection.
 Any other required items as per Drawings and Specifications.

088000 Glazing

Glazing shall not be measured separately for payment and shall be paid as part of
the Contract unit price for the associated work requiring glazing and to include the
following:

 Manufacturing, processing, cutting, edging.

 Any other required items as per Drawings and Specifications.

088300 Mirrors

No. Classified according to size and type.

Rates shall include the following:

 Furnishing & installing materials.

 Clips and installing wood furring, nails, screws, sealant and all necessary items
for fixing wood furring and mirror.
 Cutting, edging.
 Any other required items as per Drawings and Specifications.

089000 Louvers and Vents

No/m/m2. Classified according to type, height and finish.

Rates shall include the followings:

 Fixing in position, adjusting, plugging and screwing.

 All accessories and fittings required.
 Bitumen damp proofing
 Insect screen
 Grouting, finishing, and cleaning.
 Framing and sub-framing.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 17 of 74
 DIVISION 9

FINISHES

Section Unit Description

092400 Portland Cement Plastering

m2 Classified according to the type, thickness and location.

m2 Metal lath suspended ceiling.

Rates shall include the followings:

 Furnishing and installing materials.

 Scaffolding where required, spatter dash, forming key, floating, dubbing out,
arises.
 Plaster accessories.
 Sealants.
 Cleaning.
 Suspension system for metal lath suspended ceiling.
 Finishing to the required texture and repairing of damaged plaster coat.
 Any other required items as per Drawings and Specifications.

092900 Gypsum Board

Classified according to type, thickness, and fire rating period.

m2 Gypsum board ceiling.

Rates shall include the followings:

 Furnishing and installing materials.

 Suspension system.
 Anchors and fasteners.
 Joints treatment.
 Insulation with required thickness to achieve required performance.
 Access doors and hatches.
 Sealants.
 Cleaning and replacing of damaged finished board.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 18 of 74
093000 Tiling

Floor Tiling

m2 Classified according to type and size.

Rates shall include the followings:

 Furnishing and installing materials.

 Setting materials, grouting and sealants.
 Thresholds, trim units, and special tiles and fittings.
 Metal edging strips.
 Replacing of damaged tiles.
 Protection covering and cleaning.
 Any other required items as per Drawings and Specifications.

Wall Tiling

m2 Classified according to type and size.

Rates shall include the followings:

 Furnishing and setting tiles.

 Setting materials, grouting and sealants.
 Trim units and all special tiles and fittings.
 Accessories.
 Grouting and sealants.
 Replacing of damaged tiles.
 Protection covering and cleaning.
 Any other required items as per Drawings and Specifications.

Ceramic Skirting

m Classified according to type and height.

Rate shall include the followings:

 Furnishing and setting tiles.

 Setting materials, grouting and sealants.
 Replacing of damaged parts.
 Protection covering and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 19 of 74
095423 Linear Metal Ceilings

m2 Classified according to material, finish and size.

Rates shall include the followings:

 Furnishing and installing materials.

 Suspension system.
 Anchors, fasteners, sealants fixing in position and joints treatment.
 Access panels.
 Sound absorbent fabric layer.
 Sound absorptive pads.
 Finishing, cleaning and replacing of damaged board.
 Any other required items as per Drawings and Specifications.
 Extra materials.

095427 Wood Ceilings

m2 Classified according to type, finish and size.

Rates shall include the followings:

 Furnishing and installing materials.

 Suspension system.
 Anchors, fasteners, cutting, fixing in position and joints treatment.
 Access doors and hatches.
 Sealants, cleaning and replacing of damaged board.
 Sound absorbent fabric layer.
 Finishing, as indicated on Drawings.
 Any other required items as per Drawings and Specifications.

096600 Terrazzo Flooring

m2 Classified according to size and thickness.

Rates shall include the followings:

 Furnishing and setting tiles.

 Mortar, grouting and sealants.
 Replacing of damaged tiles.
 Cutting.
 Protection covering and cleaning.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 20 of 74
  Any other required items as per Drawings and Specifications.

Terrazzo base

m Classified according to height and thickness.

Rates shall include the followings:

 Furnishing and setting tiles.

 Mortar, grouting and sealants.
 Repairing of damaged tiles.
 Cutting.
 Protection covering and cleaning.
 Any other required items as per Drawings and Specifications.

096340 Stone Flooring

Classified according to type of stone, size, thickness and finish.

m2 For flooring and landing.

m Threshold and base.

Rates shall include the followings:

 Furnishing and installing materials.

 Setting material, grouting and sealants.
 Spacers.
 Divider strips and edging.
 Cork joint filler.
 Floor sealer.
 Finishing.
 Replacing of damaged parts.
 Protection covering and cleaning.
 Any other required items as per Drawings and Specifications.

096723 Resinous Flooring

m2 Classified according to material, system, location and thickness.

Rates shall include the followings:

 Furnishing and installing materials.

 Coating system including primer, intermediate, top coats and aggregate.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 21 of 74
  Substrate preparation.
 Patching and fill material.
 Sealants.
 Replacing of damaged flooring.
 Protection and cleaning.
 Any other required items as per Drawings and Specifications.

096900 Access Flooring

m2 Classified according to type, panel covering and cavity height.

Rates shall include the followings:

 Furnishing and installation of access flooring system.

 All other material, panel covering, accessories, fasteners.
 Fixing in position complete, cutout, grounding, ramps, railing and all other
work as specified.
 Testing.

097500 Stone Facing

Classified according to type of stone, thickness and method of fixation.

m2 For stone cladding.

m For stone base.

m Vanity top.

Rates shall include the followings:

 Furnishing and installing materials.

 Setting materials, grouting and sealants.
 Wire tie backs.
 Anchors.
 Stone accessories.
 Finishing.
 Replacing of damaged parts.
 Cutting.
 Protection and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 22 of 74
096516 Resilient Sheet Flooring

Classified according to type and thickness.

m2 For sheet flooring.

m For skirting.

Rates shall include the followings:

 Furnishing and installing materials.

 Substrate preparation.
 Fixing in position.
 Metal edge strips.
 Replacing of damaged flooring.
 Protection and cleaning.
 Any other required items as per Drawings and Specifications.

099100 Painting

m2 Painting is classified according to type, location and substrates.

Rates shall include the followings:

 Furnishing and applying the paint system including primer, intermediate, top
coats, preparing surfaces, rubbing down between each coat, stopping,
knotting.
 Covering of floors, with sheets while painting is being executed, removing paint
splashes, spots, and stains and completion of work to perfection.
 Painting on other items such as metal and wood shall not be measured
separately for payment and shall be paid as part of the item.
 Repairing of damaged parts.
 Cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 23 of 74
 DIVISION 10

SPECIALTIES

Section Unit Description

101400 Interior Signage

No. Classified according to type, material and size.

Rates shall include the following:

 Supplying signs, all necessary fasteners and accessories, paint, fixing in

position, wiring, electrical requirements, backup framing and other necessary
works.

10 14 53 Traffic Signs (No.)

The rates shall be full compensation for all plant, materials, transport, labor,
equipment, temporary works, establishment charges, overheads and profit
required to complete the works described in this Section of the Specification
and/or shown on the Drawings.

Rates shall further include for:

 Excavation, backfilling, disposal of surplus excavated material and trimming

bottoms of excavation, Concrete, reinforcement and formwork, Finish
painting/coating and Protection of works.

102113 Toilet Compartments

m Classified according to type, thickness, and height.

Rates shall include the followings:

 Pilasters.
 Doors.
 Hardware.
 Supplying all necessary materials, fabrication to detailed Drawings.
 Fixing in place, supplying and installing all required hardware and accessories,
finishing, cleaning, etc.

102600 Wall and Door Protection

m Classified according to type, finish and size.

Rates shall include the followings:

 Furnishing and installing, accessories, fasteners.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 24 of 74
  All anchoring devices.

102800 Toilet, Bath and Laundry Accessories

No. Classified according to type and finish.

Rates shall include the following:

 Supplying accessories complete with all necessary fasteners.

 Fixing in position, and other necessary works.
 Any other materials required as per Specification and Drawings.

104413 Fire Extinguisher Cabinets

No. Fire Cabinets

Classified according to type.

Rates shall include the following:

 Furnishing and installation.

 Cabinets complete with trims, doors hardware, fasteners, fittings,
identification, cleaning and protection.
 Fire Hose Reel, Fire Hose, hose nozzle, hose rack, Pressure restricting valve,
fire extinguisher.

104416 Fire Extinguishers

In addition to the rates described for the different components of fire

protection systems, the cost of testing and measuring of completed fire
protection systems is included.

No. Fire Extinguishers

Classified according to type.

Rates shall include the following:

 Furnishing and installation.

 Extinguishers complete with charge, pressure gauge and brackets where
required.

107113.43 Fixed Sun Screen

L.S Classified according to material, finish and size.

Rates shall include the following:

 Design, fabrications, furnishing, installation, and testing.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 25 of 74
  Supply and installing of glass, fitting, supporting system, and all other
accessories.
 Supporting system.
 Fixations anchors & materials.
 Gaskets.
 Protection and cleaning, finish and touchup.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 26 of 74
 DIVISION 11

EQUIPMENT

Section Unit Description

111500 Parking Control Equipment

No Speed Hump

No Rising Arm

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and operation, and protections.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 27 of 74
 DIVISION 13

SPECIAL CONSTRUCTION

Section Unit Description

133100 Fabric Structure

No. Classified according to size and type.

Rates shall include the Followings:

 Design and engineering of structure system.

 Furnishing, installation.
 Fixing in position.
 Structural members, cables, and plates.
 Fabric.
 Accessories complete with all necessary fasteners, fixing in position.
 Replacing of damaged surface.
 Protection and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 28 of 74
 DIVISION 14

CONVEYING SYSTEMS

Section Unit Description

142100 Electric Traction Elevators

No. Classified according to type, rated loads, speed, operation system, number of
stops, opening, and finishes.
Rates shall include the following:

 Issuing all security permits needed from related authorities for this labor
and staff and to comply with working hours determined by the related
authorities.
 All necessary engineering drawings, tools, labor, calculations, equipment,
power, control and material required for installation and erection and
operation.
 Fixing in position with necessary inserts, beams, fasteners, and scaffolding.
 Furnishing, installation of elevator.
 Fire protection, and demonstration to building municipalities.
 Civil works related to building (hoist way and pit) special services, systems
and interface such as detectors, BMS, paging, lighting, earthing, vibration
and noise dampers, warning signs, … etc. as per specification.
 Adjusting, testing, devices, acceptance and operation so as to be ready for
handing over to the employer, and authority bodies.
 Maintenance and training.
 Safety features required for personal life and building.

149100 Facility Chutes

No. Classified to type, material, and height.

Rates Shall Include the Following:

 Furnishing and installation.

 Intake and discharge doors.
 Smoke vent.
 Sprinklers.
 Sanitizing unit.
 Fixing in position.
 Replacing of damaged chutes.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 29 of 74
  Protection and cleaning.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 30 of 74
 DIVISION 21

FIRE SUPPRESSION

Section Unit Description

211000 Water- Based Fire-Suppression Systems

m Piping

Classified by material and diameter.

Rates shall include the following:

 Furnishing and installation.

 Pipes, fittings, accessories, flexible couplings, flange adaptors, flexible
connections, joints, jointing materials, welding materials, expansion joints,
sleeves, mechanical coupling, hangers, supports, pipe sleepers,
identification.
 Painting and any other accessory or fittings necessary for complete
installation of piping system.
 Equipment, instruments and personnel necessary for installation of piping
system.
 Testing and commissioning.

No. Valves

Classified according to type and size.

Rates shall include the following:

 Furnishing and installation.

 All accessories including tamper switches, padlock and chains, actuators,
identification and any attachments to valves.
 Testing and commissioning.

No. Alarm Check Valve Sets

Classified according to size.

Rates shall include the following:

 Furnishing and installation.

 Valve, valve trim, pressure switch, motor gong, retarding chamber,
connections to the system and to the fire alarm system.
 Testing and commissioning.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 31 of 74
 No. Fire Department Connections

Classified according to type and size.

Rates shall include the following:

 Furnishing and installation.

 Cover sleeve, identification plate, caps and chains.

No. Sprinklers

 Classified according to type, finish and size.

Rates shall include the following:

 Furnishing, escutcheons, and installation.

No. Water Flow Switches

Classified according to size of pipe.

Rates shall include the following:

 Furnishing and installation.

 Electric connection to the fire alarm system.
 Testing and commissioning.

No. Pressure Gauges

Rates shall include the following:

 Furnishing and installation.

No. Test and Drain Units

Classified according to size.

Rates shall include the following:

 Furnishing and installation.

 Testing and commissioning.

No. Automatic air vents

Classified according to size.

Rates shall include the following:

 Furnishing and installation.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 32 of 74
 No. Zone Control Stations

Classified according to size.

 Furnishing and installation.

 Indicating type valves, check valves, tamper switches, pressure gauges,
water flow switches, test and drain unit, connection to the system and to
the fire alarm system.
 Testing and commissioning.

No. Spare Sprinklers Cabinets

 Classified according to capacity and sprinkler type.

Rates shall include the following:

 Furnishing and installation.

 Cabinets complete with spare sprinklers and sprinklers wrench.

211339 Fire Extinguishing Foam Systems

No. Foam Bladder Tanks

Classified according to type and size.

Rates shall include the following:

 Furnishing and installation.

 Bladder tank, trimming valves and accessories.
 Tank concrete base.
 Inspection, testing and commissioning.

Foam Concentrate

Classified according to type and concentration percentage.

Rates shall include the following:

 Supply of foam.

Foam proportioners

Classified according to the flow range.

Rates shall include the following:

 Furnishing and installation.

 Testing and commissioning.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 33 of 74
 Hydraulic concentrate control valves

Classified according to size.

Rates shall include the following:

 Furnishing and installation.

 Valve hydraulic actuator and water regulator.
 Testing and commissioning.

Foam concentrate valves

Classified according to type and size.

Rates shall include the following:

 Furnishing and installation.

 All accessories including identification and any attachments to valves.
 Testing and commissioning.

Foam/water spray nozzles

Classified according to type and size.

Rates shall include the following:

Furnishing and installation.

212100 Carbon Dioxide Fire Extinguishing System

L.S CO2 Cylinders Sets

Rates shall include the following:

 Furnishing and installation.

 Cylinders, manifolds, pressure relief valves, hose connections, cylinder
valves, weighing devices, solenoid actuators, limit switches, supports,
painting, valves, wiring to control panels and accessories as specified and
required for operation.
 Initial gas fills.
 Testing and commissioning.

Control Panels

Classified according to No. of extinguishing areas.

Rates shall include the following:

 Furnishing and installation.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 34 of 74
  Factory assembled control panel and hook up site wiring, touch up painting,
and identification.
 Testing and commissioning.

Horn/Strobe Units

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Alarm Bells

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Strobe lights

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Manual release stations

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Discharge Nozzles

Rates shall include the following:

 Furnishing of nozzles and connections to piping

Optical Smoke Detectors, Flame Detectors or Heat Detectors

Rates shall include the following:

 Furnishing and installation.

 Wiring to control panel.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 35 of 74
  Testing and commissioning.

Warning signs

Rates shall include the following:

 Furnishing and installing.

Piping Network

Classified by material.

Rates shall include the following:

 Furnishing and installation.

 Pipes, fittings, accessories, flexible couplings, flange adaptors, flexible
connections, joints, jointing materials, welding materials, expansion joints,
sleeves, mechanical coupling, hangers, supports, identification, earthing of
network, painting and all other accessory and fittings necessary for
complete installation of piping system.
 Equipment, instruments and personnel necessary for installation of piping
system.
 Testing and commissioning.

212200 Clean-Agent Fire Extinguishing Systems

L.S Clean Agent Cylinders Sets

Rates shall include the following:

 Furnishing and installation.

 Cylinders, manifolds, hose connections, cylinder valves, pressure release
flaps, pressure switches, solenoid actuators, pressure gauges, supports,
painting, wiring to control panels and accessories as specified and required
for operation.
 Initial gas fills.
 Testing and commissioning.

Control Panels

Classified according to No. of extinguishing areas.

Rates shall include the following:

 Furnishing and installation.

 Factory assembled control panel and hook up site wiring, touch up painting,
and identification.
 Testing and commissioning.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 36 of 74
 Horn/Strobe Units

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Alarm Bells

Rates shall include the following:

 Furnishing and installation

 Wiring between unit and control panel
 Testing and commissioning.

Strobe lights

Rates shall include the following:

 Furnishing and installation

 Wiring between unit and control panel.
 Testing and commissioning.

Manual release stations

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Abort switches

Rates shall include the following:

 Furnishing and installation.

 Wiring between unit and control panel.
 Testing and commissioning.

Discharge Nozzles

Rates shall include the following:

 Furnishing of nozzles and connections to piping.

Optical Smoke Detectors

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 37 of 74
 Rates shall include the following:

 Furnishing and installation.

 Wiring to control panel.
 Testing and commissioning.

Warning signs

Rates shall include the following:

 Furnishing and installing.

Piping Network

Classified by size.

Rates shall include the following:

 Furnishing and installation.

 Pipes, fittings, accessories, flexible couplings, flange adaptors, flexible
connections, joints, jointing materials, welding materials, expansion joints,
sleeves, mechanical coupling, hangers, supports, identification, earthing of
network, painting and all other accessory and fittings necessary for
complete installation of piping system.
 Equipment, instruments and personnel necessary for installation of piping
system.
 Testing and commissioning.

213113 Electric-Drive, Centrifugal Fire Pumps

&
213400 Pressure-Maintenance Pumps

Fire Pump Sets

Set Electrically Driven Pump Sets

Classified according to type and tag number.

Rates shall include the following:

 Furnishing and installation.

 Pump sets complete with all accessories, fittings, fasteners, gaskets, bolts and
manufacturer’s furnish wiring, prefabricated bedplates, foundation blocks,
connecting flanges complete with tapings, motors, castings, impellers,
couplings, bearings and seals, glands, starters, transfer switches – for electric-
drive fire pumps - control devices, control cables, and pump controller.
 Testing, connecting to piping and power cables, commissioning and putting
into service.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 38 of 74
 No. Flow Meters

Classified according to flow rates.

Rates shall include the following:

 Furnishing, testing and installations.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 39 of 74
 DIVISION 22

PLUMBING

Section Unit Description

Piping

This method of measurements is applicable for all types of piping, unless

otherwise indicated

m Classified by material and diameter.

Rates shall include the following:

 Furnishing and installing of pipes, fittings, accessories, flexible couplings

and flange adaptors, joints and jointing materials, welding materials,
expansion joints, sleeves, wall cleanout, rocker pipes.
 Mechanical coupling, hangers, supports and braces.
 Mechanical insulation and wrapping.
 Painting and coatings, Identification.
 All other accessories and fittings necessary for complete installation of
piping systems.
 Excavation, shoring, bracing, dewatering and backfilling, furnishing all
material, thrust blocks and tie rods, equipment, instruments
 Labors necessary for installation of piping system.
 Flushing of systems and disinfection of water pipe systems.
 Testing on site.

Valves

This method is applicable for all types of valves, unless otherwise indicated

No Classified according to type, material and size.

Rates shall include the following:

 Furnishing and installing of valves, flanges, tie-rods, supporting, bolts,

operating lever, handle and gears.
 Testing on site.

221116 Domestic Water Piping

No. Water Meters

Classified according to type, and sizes.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 40 of 74
 Rates shall include the following:

 Installation including Valves and all necessary accessories.

 testing, and putting in service.

221119 Domestic Water Piping Specialties

No. Classified according to type and material.

Rates shall include the following:

 Furnishing specialties complete with accessories and materials required for

specified installation.
 Civil works, installation, identification and connections.
 Testing, putting into services.
 Finishing of surfaces.

No. Water Pressure Regulators

Classified according to type and size.

Rates shall include the following:

 Furnishing and installing water pressure regulators with, accessories,

fittings, and strainer.
 Supports, fixation, connection with piping.
 Testing and putting into service.

No. Hose Bibs

Classified according to type and size.

Rates shall include the following:

 Furnishing and installing hose bibs with hose connection, vacuum breaker,
accessories, fittings, supports, fixation, operating handle and keys, and
putting into service.

221319 Sanitary Waste Piping Specialties

No. Classified according to type and material.

Rates shall include the following:

 Furnishing specialties complete with accessories and materials required for

specified installation.
 Civil works, installation, identification and connections.
 Testing, putting into services.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 41 of 74
  Finishing of surfaces.

No. Floor Drains

Classified according to type and size.

Rates shall include the following:

 Furnishing floor drains complete with grating, sediment bucket, seepage

flange, clamp, funnel, trap, and special pieces.
 Connection with related piping.
 Installation, fixation, and leveling.

No. Roof Drains

Classified according to type and size.

Rates shall include the following:

 Furnishing roof drain complete with doom, flashing ring, gravel stop,
extension callers under-deck clamp and sump receiver, and special pieces.
 Installation and fixation.
 Commissioning.

No. Trench Grates

Classified according to type, width and material.

Rates shall include the following:

 Furnishing, trench grate, frame and coating.

 Installation, fixation, and leveling.
 Commissioning.

No. Planter Drains

Classified according to type and size.

Rates shall include the following:

 Furnishing planter drain complete with membrane clamp, adjustable collar,

perforated stand pipe, dome, and wire mesh.
 Installation, leveling, and fixation.

221329 Sump & Sewage Pumps

No. Electrically Driven Pumps

Classified according to type and capacity.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 42 of 74
 Rates shall include the following:

 Supply of pump sets complete with electric control panels, all accessories,
strainers, pressure switches, fittings, fasteners, supports, bracing, gaskets,
and bolts.
 All necessary wiring, power cables, vibration isolators prefabricated
bedplates, connecting flanges complete with tapping, motors, casings,
impellers, couplings, bearings and seals, casing, air release valves, pressure
regulators, pressure gauges, pressure switches, glands, starters, control
and remote devices, control cables, control valves.
 Seals, bearings, delivery, bends, guide rails, float switches, lifting chains
with identification tags.
 All special pieces for installation and operation.
 Foundation blocks, spare parts, Installation.
 Connection to piping.
 Commissioning and putting into service.

No. Sump & Sewage Pits

Classified according to type and dimensions.

Rates shall include the following:

 Furnishing materials and necessary equipment, tools, and labors,

excavation, dewatering, shoring, backfilling, reinforced and plain concrete
and concrete inserts.
 Exterior and interior damp-proofing, plastering, connection of surrounding
pipes, covers and frames.
 Pipes sleeves, inlet control cables rod, steps.
 Loading and unloading fixed parts, puddle flanges, adjacent valve chamber
of indicated sump and sewage pump sets.
 All accessories required for installation, testing, putting in service.

221123.13 Domestic Water Package Booster Pumps

No. Electrically Driven Pumps

Classified according to type and capacity.

Rates shall include the following:

 Supply of pump sets complete with electric control panels, all accessories,
strainers, pressure switches, fittings, fasteners, supports, bracing, gaskets,
and bolts

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 43 of 74
  All necessary wiring, power cables, vibration isolators prefabricated
bedplates, connecting flanges complete with tapping, motors, casings,
impellers, couplings, bearings and seals, casing, air release valves, pressure
regulators, pressure gauges, pressure switches, glands, starters, control
and remote devices, control cables, control valves.
 Pressure vessels and accessories.
 Variable speed drives with its attachments, monitoring and control devices
and connections
 Foundation blocks, spare parts, Installation.
 Connection to piping.
 Commissioning and putting into service.

223300 Electrical Water Heater

No. Classified according to type and capacity.

Rates shall include the following:

 Installation of water heater including supports , fixation , Valves ,

connecting unions and flexible connection and all necessary accessories
and fitting .
 Connection to piping.
 Testing on site, commissioning and putting into services.

224000 Plumbing Fixtures

No. Plumbing fixtures are classified according to type and material.

Rates shall include the following:

 Furnishing of plumbing fixtures, chrome plated plumbing fittings, valves,

related accessories, flexible connections, hoses.
 Complementary pieces required for complete installation and operation
including carriers, fasteners, flushing and ablution devices, installation, and
connection with related piping.
 Testing and putting into services.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 44 of 74
 DIVISION 23

HEATING VENTILATING AND AIR CONDITIONING

Section Unit Description

232113 HVAC
To
238400 General

Work is measured net as fixed in position.

Contractors must note that rates of items include everything necessary for the
proper supply, installation, execution, completion, start-up and maintenance
of each item that all auxiliary work is included unless specifically otherwise
stated, measured or excluded in writing by the Engineer.

Rates shall be fully inclusive of all that is necessary to fulfill the liability and
obligations and shall include:

 Labor and all associated costs.

 Materials, goods and all associated costs.
 Temporary works.
 Coordination with other installations.
 Identification, which shall include plates, discs, labels, charts and color
coding.
 Cutting or forming holes, chases, mortises or the like and building in
brackets, supports or the like including making good finishing.
 Protective and decorative painting.
 All required testing, commissioning, balancing, handing over and
maintenance as specified and shall include provision of fuel and power.
 Tools and spare parts, which shall include loose keys and consumable items.
 Documents, which shall include: shop working and as-built drawings,
operating instructions and maintenance manuals and other submittals
required in the specifications such as materials approvals, samples and
samples of work.
 Al builders work necessary for HVAC works.
 All civil works, including excavation, backfilling, etc.
 Establishment charges, overheads and profit.
 Miscellaneous items to complete the work as per specifications and
Drawings.

No. Valves, etc.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 45 of 74
 Network valves (solenoid, expansion, isolating, commissioning valves), filter
drier, sight glass, strainers, expansion joints, oil separators or the like (related
to network and not equipment) are classified by type and size.

Rates shall include the following:

 Furnishing.
 Insulation.
 Installing and testing at manufacturer’s premises and on the site.
Sheet Metal Duct Work

Rates shall include the following:

 plenums, joints, fittings, bends, elbows, flexible connections, connections,

sleeves, stiffeners, access and inspection doors
 Wrapping with dense tap, measuring points or the like.
 Air Duct Accessories such as Fire/smoke dampers, manual volume control
dampers and sound Attenuators or the like .

Ducts shall be classified as follows:

Ton Rectangular ductwork is measured by weight (based on the area and

calculated as the length along the center line over all fittings, times the
nominal net width). No deductions shall be made for intersections or openings
and no additions shall be made for the extra weight of seams, stiffeners, fixings
or the like. Ductwork shall be as indicated on the drawings. The rates shall also
include metal cladding as specified.

m Circular, oval and flexible ductwork are measured by length along the
centerline over all fittings and are classified by diameter. Ductwork shall be as
indicated on the drawings.

m Piping

Classified by materials and size.

Rates shall include the following:

 Furnishing of pipes fittings, joints, connections, welding, soldering , vents .

 Supports, hangers, anchors, fixings, brackets, channels, sleeves, making
good around holes in floors, shafts and walls.
 Wrapping in dense tape
 Bases for sensing devices or the like.

No. Insulation for duct and pipe work:

Insulation shall be measured in meter square.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 46 of 74
 Rates shall include the following:

- Supply and install insulation for duct and pipe works according to the
specification and as shown on drawings.
- Complete with fasteners, vapor barriers, adhesives, cladding, cloth
wrapping, painting, coating, tags, flow indicators, labels and color code or
the like.

No. Air Outlets, etc.

Motorized Dampers, registers, grilles, diffusers, louvers or the like are

classified according to type and size. Linear diffusers shall be measured in
linear meters.

Rates shall include the following:

 Frames, plenums, fixing devices, paint, supports or the like

 Fitting and making good around wall and ceiling finishes.
No. Equipment

Chillers, pumps, fans or the like are classified according to type.

Rates shall include the following:

 Valves, fittings, bases, control, vibration isolators, sound lining, all required
joints, accessories, and the like.

No. Automatic Controls

Automatic control systems shall be as items for each control panel common to
each system on installation.

Rates shall include the following:

 Control instrumentation, sensing or activating devices (for example

thermostats, humidistat, controller, alarm lamps, smoke detector) control
panels receivers, wiring, isolators, starters, relays or the like items
associated with automatic controls.
Motor Control Centers

Refer to Division 26 Section “Motor Control Centers”.

Civil Works of HVAC Services

Civil works of HVAC system shall not be measured separately and shall be
included in rates of other items of HVAC works.

L.S. Miscellaneous Items

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 47 of 74
 Contractor to provide breakdown for this item to facilitate continued
evaluation of Application for Payment. This breakdown should include priced
items that are necessary to complete HVAC works as per Specifications and
Drawings and not included in the "Bill of Quantities/Method of
Measurements". All general and supplementary conditions and other
Contract requirements to be applied to this item. Contractor to provide this
breakdown within two months from date of Awarding of the Contract.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 48 of 74
 DIVISION 25

INTEGRATED AUTOMATION

Section Unit Description

250000 Building Management System

Include the following:

 Furnishing, installation and testing all equipment, software, interfaces,
materials of equipment including all necessary equipment and material
required for installation and erection, and all other components and
devices and connection between controllers and instrumentation devices
and I/O points, adjusting, operation and protection.
 Demonstration.
 Training.
L.S Main BMS Redundant Hot Standby Servers

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over including protocol interfaces, communication
interfaces including third parties integration by system integrator for all
light current systems & MEP systems
 All necessary accessories software, hardware, Interfaces, raceways,
conduits, cables, terminations, and labeling.

No. Computer Workstation

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over including software, windows based and suitable for
PC station, CPU, mouse, keyboard, power cords, communication cords, LCD
screen, raceways, cables, terminations, labeling.
 All necessary accessories required to complete the work.

No. Dot Matrix Printer and A4 Laser Printer

Rates shall include the following:

 Supply, install, test, commission, start-up and hand-over & compatible with
all other system elements including, power cables, communication cables,
interface software, terminations, labeling.
 All necessary accessories required to complete the work.

No. Hand held operator unit allowing accessing the whole network controllers
from any place on the network

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 49 of 74
 Rates shall include the following:

 Supply, install, test, commission, start-up and hand-over & compatible with
all other system elements including, power cables, communication cables,
interface software, terminations, labeling.
 All necessary accessories required to complete the work.

L.S. Direct Digital Controller (DDC), Local Control Panel (LCP) and Integration
Automation Controller (IAC)

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over & compatible with all other system elements
including interfaces to BACnet/TCP/IP protocols to cover all required areas
as per input/output points schedule, software, hardware, Interfaces,
raceways, conduits, cables, wiring between controllers and
instrumentation/field devices, I/O points terminations, labeling.

 All necessary accessories.

L.S. Gateway with Integration Protocols

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over including Communication & integration devices
(routers, modems, switches and Gateway c/w integration protocols (BAC
net/TCP-IP)(LON/TCP-IP) with required points as per input/output points
schedule, software, hardware, Interfaces, raceways, conduits, cables,
terminations, labeling
 All necessary accessories required to complete the work.

L.S. Integration/Interface with Third Party Systems

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over & compatible with all other system elements
including software, hardware, Interfaces, raceways, conduits, cables,
terminations, labeling
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 50 of 74
 DIVISION 26

ELECTRICAL

Section Unit Description

260513 Medium Voltage Cables

M Classified according to type, voltage, number of cores and size.

Rates include the following:

 Material supply complete with fittings and cable termination accessories,
installation and testing.
 Supply and installation of necessary joints, lugs, terminals, and accessories,
cable ducts, cable trenches, either indoor or outdoor.
 Manholes, sleeves, complete with all necessary grounding taps, as well as
layout shop drawings and as-built drawings with full data/feeder schedule,
as specified and shown on drawings.
 And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.
260519 Low Voltage Electrical Power Conductors and Cables
260536 Cable tray

M Classified according to type, voltage, number of cores and size.

Rates include the following:

 Material supply, complete with fittings, cable termination accessories, and

installation in raceways, and testing.
 Supply and installation of necessary joints, lugs, terminals and accessories,
conduits, cable tray, cable tray cover as indicated in the drawings, cable
tray accessories, cable ducts, either indoor or outdoor.
 Manholes, sleeves, pull and junction boxes complete with all necessary
grounding taps.
 And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

260519 Low Voltage Electrical Power Conductors and Cables

260533 Raceways and Boxes
262726 Wiring Devices

Wiring for Lighting, Convenience and Power Socket Outlets

No. Classified according to number of outlets.

Rates include the following:

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 51 of 74
  Material supply, installation, testing, connection, grounding taps and
testing of wires, conduits with all accessories, outlets boxes, necessary pull
and junction boxes.
 All other materials necessary for a complete wiring system from outlet
termination up to panel boards.

Outlets Fittings

No. Classified according to type, number of poles and ampere rating.

Rates include the following:

- Cover fittings as “isolators, load-break switches, lighting switches and all

types of socket outlets”.
- Supply, installation, covers plates, supports, screws and all other associated
accessories.
- Assembly, connection, grounding tapes.
- Testing of the complete system.

Desk/Floor Sockets Box

No. Classified according to the number and type of sockets it comprises.

Rates include the following:

- Material supply, erection, assembly, accessories, grounding and coordination

with other fittings in the desk/partition or floor.

260526 Grounding and Bonding

L.S. Classified according to requirements to achieve the specified earth resistance.

Rates include the following:

 Material supply, fabrication, supply, installation, testing and commissioning

the complete system.
 Grounding pits, electrodes, equi-potential bars, main and branch grounding
conductor, test links, grounding taps to mechanical equipment and motors,
and thermo welds.
 All other necessary fittings to achieve complete grounding for all necessary
and indicated equipment.
 Associated civil works relevant to fixation and installation.
 And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

261202 Dry Type Distribution Transformers

No. Classified according to type, voltage and rating.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 52 of 74
 Rates include the following:

 Supply, install, connect, test, delivery, put into operation The Dry type
transformer with all accessories mwntion the specifications.
 Supply, installation, termination for M.V. and L.V.
 Installation, connection, grounding tapes, enclosure, ventilation fans, PTC
sensors, thermal controller unit and tranfered with the BMS.
 Testing and commissioning.
 Associated civil work relevant to fixation and installation, catalogues

261301 Ring Main Unit

No. Classified according to type, voltage and rating.

Rates include the following:

 Supply, install, testing, commissioning, warranty, handover, Delivery, Put

into operation, Detailing, fabrication, assembly of Ring main unit, include
bushings, terminations, glands, grounding taps/links, battery, earth fault
indicator (EFI) and Voltage Presence Indicators (VPI).
 Supply, install, Factory testing, delivery, and installation.
 Testing before connection, and testing of the entire system.
 Spare parts.
 Associated civil work relevant to fixation and installation.
 Metering cell ready to install meters required by Electrical Distribution
Company (EDC).
 Any requirements of electrical distribution company (EDC)
 All other materials necessary for a complete system refer to the drawings
and specifications.

262413 Switchboards
263533 Power Factor Correction Capacitors

No. Classified according to type, voltage, and ratings.

Rates include the following:

 Supply, install and Detailing, fabrication, assembly, bushings, terminations,

digtal power meters, Surge protection device SPD, SIM to be ready
Interface with BMS with the points according to BMS Schedule, glands,
grounding taps/links.

 Supply and Install Power Factor correction according to the project

documents.
 Factory testing, delivery and installation.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 53 of 74
  Testing before connection, testing of the entire system, and all necessary
accessories to complete the work according to the technical specifications
and the other contract documents.

262416 Panel boards

No. Classified according to type, voltage, and ratings.

Rates include the following:

 Supply, install and Detailing, fabrication, assembly, bushings, terminations,

glands, Isolated power panel and grounding taps/links.
 Factory testing, delivery and installation.
 Testing before connection, testing of the entire system, and any and all
necessary accessories to complete the work according to the technical
specifications and the other contract documents.

262419 Motor Control Center

No Supply, install, connect test, commissioning, and handover.

 Motor control centers include motor starter, protection, control,

measuring, indicating lamps and interface devices with BMS or Fire alarm
control panel FACP (as indicating in the drawings) and cable glands for
incoming and outgoing cables/wires.
- All other materials necessary for a complete system refer to the drawings
and specifications.

262500 Enclosed Bus Assemblies

M Classified according to type, voltage, degree of protection and current rating.

Rates include the following:

- Supply, installations, connection, testing, grounding tapes and testing

complete.
- Fire sealant where passing through fire rated wall or floor.
- Cable end box, MDB flange connection, transformer flange connections
with flexible copper braid link, generator flange connection with flexible
copper braid link and vibration, as indicated in the drawings.
- Thermal expansion joints as required and Engineer approval.
- All necessary fittings and accessories required for the installation.
- And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 54 of 74
262726 Wiring Devices

Outlets Fittings

No. Classified according to type, number of poles and ampere rating.

Rates include the following:

 Cover fittings as “isolators, load-break switches, lighting switches and all

types of socket outlets”.
 Supply, installation, cover plates, supports, screws and all other associated
accessories.
 Assembly, connection, grounding tapes.

263213 Engine Generators

No. Classified according to type, rating and voltage.

Rates include the following:

- Supply, installation, testing and commissioning of the unit with control panel,
Sound Attenuator, Silncer, muffler, Exhaust system with insulation, fuel oil
system, daily tank, monthly tank, electric pump, manual pump, pipes, valves
and accesories.
- Provision of connections between fuel storage tank and daily tank and
solenoid valve required, cooling, set of pumps, exhaust system, lubrication
system, grounding tapes, noise suppressors, vibration suppressors, ventilation
works, concrete base and louvers.
- Spare Parts
- All associated civil work relevant to fixation and installation.
- Detailing, fabrication, delivery, assembly, installation of all accessories.
- Testing before shipping and on site after installation of the complete
system, spare parts, catalogues and manuals.
- And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

263353 Uninterruptible Power Supply (UPS)

No. Classified by rating, voltage, type and minimum duration of back-up supply.

Rates include the following:

- Detailing, fabrication, assembly, delivery, batteries, installation,

connections, testing, commissioning of the entire system including the
control panel and grounding taps.
- Any associated civil work relevant to fixation and installation
- Alert software between UPS’s and server

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 55 of 74
 - All other materials necessary for a complete system refer to the drawings
and specifications.

263600 Automatic Transfer Switches

No. Classified according to type, voltage and ratings.

Rates include the following:

- Supply, install and Detailing, fabrication, assembly, complete with
equipment, furnishing all materials, testing.
- All associated civil works relevant to fixation and installation.
- And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

264113 Lightning Protection System for Structures

L.S. Classified according to requirements of local statutory authority, project
specification, to achieve the specified earth resistance and ensure a low
impedance path for the lightning strike.

Rates include the following:

- Detailing, material supply, installation, and connections of the complete

system.
- All bonding, common earthing reference, earthing rods, earth cables,
termination bus bars, clamps, proprietary earth pits, copper tape network,
dedicated down conductors, test clamp, strike pads to form a full and
complete system.
- All other materials necessary for a complete system refer to the drawings
and specifications.
265100 Interior Lighting
265600 Exterior Lighting

No. Classified according to type designation.

Rates include the following:

 Material supply, installation, testing, complete with control gear, safety LV

transformer and power factor corrector (wherever necessary), lamps,
internal wiring including battery charging wires from panel to lighting
fixtures, mounting brackets, foundation and accessories, complete
assembly, installation, grounding taps connection to lighting outlets and
testing.
 And all necessary accessories to complete the work according to the
technical specifications and the other contract documents.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 56 of 74
 DIVISION 27

COMMUNICATIONS

Section Unit Description

271000 Structured Cabling System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and operation, and protections.
 Demonstration.
 Coordination with telecom service provider
 Training.

No. RJ54 Cat (6A) Patch Panel (6A) Port, Fiber Optic Patch Panels (LC), (SC/APC)
Type, Management panel (mounted in TCs).

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including horizontal cable organizers, termination accessories, connectors,
termination tools, conduits, boxes, raceways, cables, labeling
 All necessary accessories required to complete the work.

No. RJ 45 (F/UTP) CAT (6A) Outlets

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including boxes, back boxes, faceplates, sockets, conduits, raceways
(trunks, wire basket,…etc), cables, labeling and
 All necessary accessories required to complete the work.

No. Patch cord (F/UTP) Cat (6A) - (X) meter for rack patching/work area and Fiber
optic duplex patch cord LC, SC/APC (Single) / (Multi) Mode (X) meter,
(connector types according to supplied switch types).

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including jacks, sockets, conduits, raceways (trunks, wire basket,…etc),
cables, labeling
 All necessary accessories required to complete the work.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 57 of 74
 m (Single) Mode fiber optic cables (x) core LSZH (Indoor) type

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including conduits, boxes, raceways (trunks, wire basket,…etc.), and
labeling.
 All necessary accessories required to complete the work.

m (OM4 Multi-Mode) fiber optic cables (x) core LSZH (Indoor) type

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including conduits, boxes, raceways (trunks, wire basket,…etc), and
labeling.
 All necessary accessories required to complete the work.

No. Rack/Cabinets, Fiber terminal box (FTB) & Optical distribution frame (ODF)

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including conduits, boxes, raceways, vertical cable organizers, cables,
terminations, labeling, blank plates, brackets, shelves, earthing bar, fans,
power strips,
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

272000 Data Network Active Equipment

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and operation.
 Protections
 Demonstration.
 Coordination with telecom service provider
 Training.

L.S Core switch, HOT redundant Core switch, Firewall, Wide Area Networking
Internet Routers, and Network Management Software

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 58 of 74
 Rates shall include the following:

 Supply, install, programming, configuration of software, Data Entry, testing,

commission, start-up and handover including system interfaces,
connections internal cables between servers and systems according to the
specification, labeling
 All necessary accessories required to complete the work.

No. Edge Switch,

Rates shall include the following:

 Supply, install, programming, configuration of software, Data Entry, testing,

commission, start-up and handover including system interfaces,
connections internal cables between servers and systems according to the
specification, labeling
 All necessary accessories required to complete the work.

No. IP PBX [(X) external / (X) Internal]

Rates shall include the following:

 Supply, install, programming, configuration of software, Data Entry, testing,

commission, start-up and handover including system interfaces,
connections internal cables between servers and systems according to the
specification, labeling
 All necessary accessories required to complete the work.

L.S. Internal cabling and Racks

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up and handover

including conduits, boxes, raceways, vertical cable organizers, cables,
terminations, labeling, blank plates, brackets, shelves, earthing bar, fans,
power strips
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 59 of 74
274133 MATV System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and operation, and protection.
 Demonstration.
 Training.

No. Satellite dish antenna, VHF/UHF antenna, Quattro LNB, IF multi-Switches, TV

boxes

Rates shall include the following:

 Supply, install, test, programming, Data Entry, commission, start-up and

hand-over including power supply, software, power cords, communication
cords, raceways, RG6 coaxial cables, terminations, and labeling.
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

275116 Public Address System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and acceptance and operation so as to be ready for handing over to the
Employer, and protection.
 Demonstration.
 Training.
 Interface with fire alarm, A/V system and all other related systems as
specified.

No. Audio Matrix

Rates shall include the following:

 Supply, install, programming, test, commission, start-up and handover &

compatible with all other system elements including mounting brackets,
raceways, cables, connectors, terminations, labeling.
 All necessary accessories required to complete the work.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 60 of 74
 No. Power Amplifier with feedback suppressor, Monitor Panel, CD/DVD Player
with AM/FM Tuner, Digital Message Recorder, Sound processor and
Surveillance & automatic changeover Module.

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over &

compatible with all other system elements including conduits, boxes,
raceways, cables, terminations, mounting plates, and labeling.
 All necessary accessories required to complete the work.

No. Speakers (Fire rated Ceiling Speakers, column speakers & outdoor horn
speakers)

Rates shall include the following:

 Supply, install, test, commission, start-up and handover & compatible with
all other system elements including matching transformers, mounting
brackets/plates, fire rated back boxes, conduits, boxes, raceways, flame
retardant cables, connectors, terminations, and labeling.
 All necessary accessories required to complete the work.

No. Paging Microphones with Zone Selectors

 Supply, install, test, commission, start-up and handover & compatible with
all other system elements including mounting brackets, stands, boxes,
conduits, raceways, cables, connectors/jacks, terminations, and labeling.
 All necessary accessories required to complete the work.

No. Volume Control

Rates shall include the following:

 Supply, install, test, commission, start-up and handover & compatible with
all other system elements including override relay, boxes, back boxes,
conduits, raceways, cables, connectors, terminations, and labeling.
 All necessary accessories required to complete the work.

No. Racks

Rates shall include the following:

 Supply, install, commission, start-up and handover including frames, cable

managers, fans, brackets, blank plates, shelves, conduits, mounting bases,
boxes, raceways, cables, terminations, and labeling.
 All necessary accessories required to complete the work.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 61 of 74
 L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 62 of 74
 DIVISION 28

ELECTRONIC SAFETY AND SECURITY

Section Unit Description

281300 Access Control System

Rates shall include the following:

 Furnishing, installation all equipment, materials of equipment

 All necessary equipment and material required for installation and
erection, connection with ground and all other components and devices,
adjusting and operation.
 Demonstration.

L.S. (Access Control Server, Main access control equipment).

Rates shall include the following:

 Supply, install, programming, drawings

 Data Entry, test, commission, start-up and handover
 Graphics software, emergency power supply & sealed back-up batteries
suitable to energize all relevant loads during emergency, charger, PC
interface, system interface, conduits, boxes, raceways, cables,
terminations, labeling and all necessary accessories.
 Software, hardware and all required for interface with (CCTV, Fire alarm,
BMS and all other related systems).

No. Access Control Workstation c/w Software and Hardware.

Rates shall include the following:

 Supply, install, test, programming, drawings.

 Data Entry, commission, start-up and hand-over.
 Access control software, windows based and suitable for PC station,
including all access control & (time management) features, CPU, mouse,
keyboard, power cords, communication cords, LCD screen, raceways,
cables, terminations, labeling.
 All necessary accessories required to complete the work.

No. Card Issuing Printer c/w Digital Video Capture Camera and Fingerprint
enrolment unit

Rates shall include the following:

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 63 of 74
  Rates shall include supply, install, programming and Data Entry, test,
commission, start-up and handover including card design software, PC
interface, system interface, conduits, boxes, raceways, cables,
terminations, labeling
 All necessary accessories required to complete the work.

No. A4 Report Printer

Rates shall include the following:

 Rates shall include supply, install, test, commission, start-up and hand-over
including, power cables, communication cables, interface software,
terminations, labeling
 All necessary accessories required to complete the work.

No. Door Controller and Network Controller

Rates shall include the following:

 Supply, install, programming, test, commission, start-up and handover

including power supply & sealed back-up batteries suitable to energize all
relevant loads during emergency & compatible with all other system,
relays, I/O Board, conduits, boxes, raceways, cables, terminations, labeling.
 All necessary accessories required to complete the work.

No. Proximity Readers, fingerprint reader with keypad, Door Sensors, Door Locks,
Request to exit buttons, Security Break Glass and Security Buzzer.

Rates shall include the following:

 Rates shall include supply, install, test, commission, programming, start-up

and hand-over & compatible with all other system elements including
conduits, boxes, raceways, cables, terminations, mounting plates, labeling
 All necessary accessories required to complete the work.

No. (Printable) Proximity Card

Rates shall include the following:

 Rates shall include supply, print, programming, test, commission, start-up

and handover including software, printing accessories adequate to print all
the quantity of cards provided with the system
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 64 of 74
281303 Parking Management / Guidance System

Rates shall include the following:

 Furnishing, installation all equipment, materials of equipment

 All necessary equipment and material required for installation and
erection, connection with ground and all other components and devices,
adjusting and operation.
 Demonstration.

L.S Parking Management Server

Rates shall include the following:

 Supply, install, programming, drawings and Data Entry, test, commission,

start-up and handover including software, emergency power supply &
sealed back-up batteries suitable to energize all relevant loads during
emergency, charger, PC interface, system interface, conduits, boxes,
raceways, cables, terminations, labeling
 All necessary accessories required to complete the work.
 Software, hardware and all required for interface with (CCTV, BMS and all
other related systems).

No. Enter/Exit terminal unit, directional ultrasonic sensor, outdoor parking main
display

 Supply, install, test, commission, programming, start-up and hand-over &

compatible with all other system elements including conduits, boxes,
raceways, cables, terminations, mounting plates, labeling
 All necessary accessories required to complete the work.

No. Parking Controller to interface with the car barrier, Raising Arm barrier (x m)
length c/w underground loop detector & manual reset switch

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over &

compatible with all other system elements including (Ticket / Card Reader
, intercom unit, ground loop coils), control panels and interface with
entrance card reader as indicated on drawings, conduits, boxes, raceways,
cables, terminations, mounting plates, labeling.
 All necessary accessories required to complete the work.

No. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 65 of 74
282300 Video Surveillance System (IP-CCTV)

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting,
operation, and protections
 Demonstration.
 Training.
 Interface with (fire alarm, Access control, BMS, etc) and all other related
systems as specified.

L.S. Main CCTV Management Servers

Rates shall include the following:

 Supply, install, programming, test, commission, start-up and hand-over,

including (video analytics software modules, for car plate recognition,
people and vehicle counting if required), integration with ISMS servers,
emergency power supply, conduits, boxes, raceways, cables, terminations,
and labeling.
 All necessary accessories required to complete the work.
 Hardware, software and all required for interface between (CCTV, fire
alarm, access control, etc) and all other related systems.

L.S. Network Video Storage system (X) days for all cameras & Video wall Array [N
row x N column] c/w video wall controllers, decoders, software & all hardware
modules

Rates shall include the following:

 Software, supply, install, programming, test, commission, start-up and

hand-over, including hard desk(s), emergency power supply, conduits,
boxes, raceways, internal cables, terminations, and labeling.
 All necessary accessories required to complete the work.

No. Workstation

Rates shall include the following:

 Supply, install, test, programming, drawings and Data Entry, commission,

start-up and hand-over including software, windows based and suitable for
PC station, CPU, mouse, keyboard, power cords, communication cords, LCD
screen, raceways, cables, terminations, and labeling.
 All necessary accessories required to complete the work.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 66 of 74
 No. Printer

Rates shall include the following:

 Supply, install, test, commission, start-up and hand-over including, power

cables, communication cables, interface software, terminations, and
labeling.
 All necessary accessories required to complete the work.

No. Keypad Controller (c/w Joystick)

Rates shall include the following:

 Supply, install, programming, commission, start-up and handover &

compatible with all other system elements including conduits, boxes,
raceways, cables, terminations, labeling.
 All necessary accessories required to complete the work.

No. Indoor/Outdoor IP Fixed Dome 2MP Camera, Outdoor IP fixed wall 2MP
Cameras & Outdoor PTZ dome 2MP camera

Rates shall include the following:

 Supply, install, commission, start-up and handover & compatible with all
other system elements including housing, power supply, IR illuminator for
outdoor cameras, mounting brackets, conduits, boxes, raceways, cables,
terminations, and labeling.
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

283100 Fire Alarm System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment.
 All necessary equipment and material required for installation and
erection, and all other components and devices, adjusting and acceptance
and operation.

L.S. (Addressable) Fire Alarm Control Panels & Satellite Panels

Rates shall include the following:

 Supply, install, programming, connection software and hardware and all

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 67 of 74
 required for interface with (CCTV, Public Address, Electrical, Access control,
HVAC, A/V system...etc).
 Testing, commission, start-up and hand-over.
 Emergency Power Supply (EPS), batteries, charger, conduits, boxes,
raceways, cables, communication cables with other fire alarm control
panels including, terminations, connection with earthing, and labeling.
 All necessary accessories required to complete the work.
 [Master audio unit C/W audio amplifiers ,fire telephone, digital message
recorder and fire microphone ]

No. Repeater Panel.

Rates shall include the following:

 Supply, install, test, commission, start-up and hand-over.

 Conduits, boxes, raceways, cables, terminations, and labeling.
 All necessary accessories required to complete the work.

L.S. High Sensitive Smoke Detection system (HSSD)

Rates shall include the following:

 Supply, install, test, commission, start-up, programming, and hand-over

 Pipe networks, sampling holes, conduits, boxes, raceways, cables,
terminations, labeling.
 All necessary accessories required to complete the work.

No. Initiating Devices (Heat Detector, Multi sensor detectors, Manual Station,
Linear heat detector, Beam detector, etc.)

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over

 Conduits, boxes, raceways, fire resistances cables, terminations, labeling
 All necessary accessories required to complete the work.

No. Notification Appliances (Alarm sirens, Strobe lights, etc.)

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over

 Conduits, boxes, raceways, fire resistances cables, terminations, labeling
 All necessary accessories required to complete the work.

No. Interfacing Devices (Control modules, Monitor modules,…etc) & Fire alarm
interface unit (IFU)

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 68 of 74
 Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over

 Conduits, boxes, raceways, fire resistances cables, terminations, labeling
 All necessary accessories required to complete the work.

No. Fault Isolation Module

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over

 Conduits, boxes, raceways, fire resistances cables, terminations, labeling
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

283101 Disabled Toilet Alarm System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment.
 All necessary equipment and material required for installation and
erection, and all other components and devices, adjusting and acceptance
and operation.

No. Disabled alarm control panel [x] zone.

Rates shall include the following:

 Supply, install, test, commission, start-up and hand-over.

 Conduits, boxes, raceways, cables, terminations, and labeling.
 All necessary accessories required to complete the work.

No. Pull Cord, Reset Unit and Dome lamp

Rates shall include the following:

 Supply, install, test, commission, programming, start-up and hand-over

 Conduits, boxes, raceways, fire resistances cables, terminations, labeling
 All necessary accessories required to complete the work.

L.S. Spare Parts

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 69 of 74
 Rates shall include the following:

 Supply the spare parts.

283600 Water Leakage Detection System

Rates shall include the following:

 Furnishing, installation and testing all equipment, software, materials of

equipment including all necessary equipment and material required for
installation and erection, and all other components and devices, adjusting
and operation, protections
 Demonstration.

L.S. Water Leakage Control Panel

Rates shall include the following:

 Supply water leakage control panel c/w with alarm modules, enclosure,
audible alarms, I/O modules and communication interfaces, install,
programming, connection software and hardware and all required for
interface with (fire alarm system), testing, commission, start-up and hand-
over, including Power Supply, batteries, conduits, boxes, raceways, cables,
communication cables with other fire alarm control panels including,
terminations, connection with earthing, labeling.
 All necessary accessories required to complete the work.

No. Water Leakage Leader Cable, Water Leakage Sensor Cable, WLD siren with
strobe, End Termination Kit and Remote Alarm.

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up, put into operation

and handover including, conduits, boxes, raceways, cables, labeling
 All necessary accessories required to complete the work.

L.S. Hold down clip & Branching Connectors

Rates shall include the following:

 Supply, install, terminate, test, commission, start-up, put into operation

and handover
 Labeling
 All necessary accessories required to complete the work.

L.S. Spare Parts

Rates shall include the following:

 Supply the spare parts.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 70 of 74
 DIVISION 31

EARTHWORK

Section Description

312000 Earth Moving

Excavation m3

Excavation shall be measured geometrically from the actual surface of existing

soil to the required excavation levels shown on Drawings

Rates shall include the Following:

 Survey works, surfaces trimming, including taking corrective works to reach

bottom level, as approved by the Engineer.
 Excavation in any material likely to be encountered including boulders,
paved areas, old foundations (if any), etc.
 Selecting, setting aside and preserving any material suitable for backfilling.
 Transporting of excavated materials within the site and disposal of
unsuitable material off the site to public dumping areas as instructed by the
Engineer.
 All labor, equipment, temporary works, and all other works required to
complete the work as per project specification.

Backfilling m3

Classified according to the type of backfilling. Filling shall be measured

geometrically to net compacted volume.

Rates shall Include the Following:

 Survey works, compaction, and testing, as approved by the Engineer

 All materials, transportation, labor, equipment, temporary works,
dewateing, shoring and all other works required to complete the work as
per project specification

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 71 of 74
 DIVISION 32

EXTERIOR IMPROVEMENTS

Section Unit Description

32 11 23 Crushed Aggregate Base Course (m2 )

The unit of measurement of the Graded Crushed Aggregate Base Course shall
be the square meter (m2)
The quantity shall be computed from the theoretical values indicated on the
Drawings, flat on plan. Thickness shall be that shown on the Drawings.
The rates shall be full compensation for all plant, materials, transport, labor,
equipment, temporary works, establishment charges, overheads, profits and
taxes required to complete the work described in this Section of the
Specification and/or shown on the Drawings.

The rates shall further include for:

- Delivery to site
- Taking from stockpiles
- Loading and hauling
- Producing, crushing and screening
- Multiple handling
- Depositing, spreading and compacting
- Maintenance / repair work
- Side and end waste
- Testing

321400 Unit Paving

m2 Interlocking concrete paving blocks, classified according to type of tile paving,

size and thickness.

Rates shall include the following:

 Furnishing materials.
 Substrate preparation.
 Setting and grouting materials.
 Sand bedding, compaction of soil, leveling, and jointing.
 Geotextile fabric.
 Any other required items as per Drawings and Specifications.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 72 of 74
32 16 13 Cement Concrete Curbs (m)

Work under this Section shall be measured according to the item classifications
and units contained in the Bills of Quantities (BOQ). Unless classified otherwise,
Curbstone and Gutters shall be measured in linear meter (m).

Quantities shall be computed from dimensions on the Drawings.

The rates shall be full compensation for all plant, materials, transport, labor,
equipment, temporary works, establishment charges, overheads, profit, and
taxes required to complete the work described in this Specification and/or
shown on the Drawings.
Rates for the Curbstones and Gutters shall further include for:
- Concrete foundations including all excavation, disposal, concrete,
reinforcement and formwork
- Bedding, jointing and pointing in cement mortar
- Concrete backing and steel dowel bar reinforcement to curbs
- Specially manufactured shaped curbs at all crossovers, intersections,
ramps, radiused bends and curves
- Providing curbstones and gutters as in-situ concrete, if so approved by
the Engineer

32 17 23 Road Markings Paints (m2 )

The units of measurement of the pavement markings shall be the square meter (m2).

The quantity shall be computed as the finished area of permanent painting

from the dimensions indicated on the Drawings.

The rates shall be full compensation for all plant, materials, labor, equipment,
transport, temporary works, establishment charges, overhead, profit and
taxes required to complete the work described in this Section of the
Specification and/or shown on the Drawings.

Rates shall further include for:

- Shapes, letters, figures or patterns

- Curved work
- Any primer required
- Wastage
- Retouching and refinishing overlaps at joints
- Preparing and applying new pavement markings at the end of the Defects
Liability Period to all areas which have been damaged or worn away,
including any area damaged by Maintenance operations (de-rubberizing).

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 73 of 74
 DIVISION 41

CRANES AND HOISTS

Section Unit Description

41 22 13.10 Overhead Traveling Crane System

No. Cranes

Are classified according to lifting capacity. Rates shall include supply and
installation of all necessary girders, traveling rails and beams, wheels, and
carriage limit switches, control panel of control devices safety devices, cables,
festoon, steel fabrication fasteners, crane trolley, chains and all accessories
required for proper operation testing and putting into services.

Method of Measurement Section 012700

Urbanium New Administrative Building (Prj. 2874) Page 74 of 74
 TECHNICAL SPECIFICATION COVER SHEET REVISED SHEETS
THIS PAGE IS A RECORD OF ALL SPECIFICATION REVISIONS. NORMALLY, REVISED SHEETS ONLY ATTACHED
EACH TIME THE SPECIFICATION IS CHANGED ONLY THE NEW OR ENTIRE SPECIFICATION RE-ISSUED
REVISED PAGES ARE ISSUED. ENTIRE SPECIFICATION REVISED

THE NATURE OF THE REVISION IS BRIEFLY NOTED UNDER REMARKS BUT

ISSUED FOR
THESE REMARKS ARE NOT A PART OF THE SPECIFICATION. THE REVISED
PAGES BECOME PART OF THE ORIGINAL SPECIFICATION AND SHALL BE REVIEW/COMMENTS
COMPLETED WITHIN THEIR ENTIRELY. TENDER/QUOTATION X
PURCHASE
CONSTRUCTION

REV. DATE PREPARED REVIEWED APPROVED PAGES REMARKS

NO. BY BY BY

0 March 2022 ISSUED FOR TENDER

SPECIFICATION REV.
ECG ENGINEERING CONSULTANTS GROUP S.A. BILL OF QUANTITIES
CAIRO - EGYPT 012750 – 2874 0

ECG Form No. E409 Rev. 5/03 Sheet 0 of

 TECHNICAL SPECIFICATION COVER SHEET REVISED SHEETS
THIS PAGE IS A RECORD OF ALL SPECIFICATION REVISIONS. REVISED SHEETS ONLY ATTACHED
NORMALLY, EACH TIME THE SPECIFICATION IS CHANGED ONLY THE ENTIRE SPECIFICATION RE-ISSUED
NEW OR REVISED PAGES ARE ISSUED. ENTIRE SPECIFICATION REVISED

THE NATURE OF THE REVISION IS BRIEFLY NOTED UNDER REMARKS

ISSUED FOR
BUT THESE REMARKS ARE NOT A PART OF THE SPECIFICATION. THE
REVISED PAGES BECOME PART OF THE ORIGINAL SPECIFICATION AND REVIEW/COMMENTS
SHALL BE COMPLETED WITHIN THEIR ENTIRELY. TENDER/QUOTATION X
PURCHASE
CONSTRUCTION

REV. DATE PREPARED REVIEWED APPROVED PAGES REMARKS

NO. BY BY BY

0 March 2022 A.A. 17 ISSUED FOR TENDER

SPECIFICATION REV.
ECG ENGINEERING CONSULTANTS GROUP S.A. LIST OF MANUFACTURERS
CAIRO - EGYPT 012950 – 2874 0

ECG Form No. E409 Rev. 5/03 Sheet 0 of 17

 LIST OF MANUFACTURERS

1. Contractor should abide by the manufacturers listed below OR equal approved by the
Engineer, comply with the Project Specifications, obtain accredited Test Reports along
with approved record of similar successful interventions in projects.

2. Contractor shall submit the following:

a. A letter from the Mother Company listed in the LOM certifying that the submitted
product is manufactured in that factory in such location under the Company
quality control protocol and supervision, and stating that the factory is one of the
Company’s accredited factories.
b. In case of any deviation from Specifications and specified performance
requirements, Engineer has the right to request further testing in an approved
independent laboratory accepted by the Engineer on Contractor's Expense to
demonstrate compliance of the product with the Project specifications.

SECTION
PRODUCT MANUFACTURER
No.
033000 Steel Reinforcement Steel Ezz – Dekheila
131500 Reinforced Concrete Water Structures Steel Bishai
Egyptian Steel
Solb Misr
El Attal
Cast in Place Concrete Decom
Cemex
Ready Mix Beton
Lafarge
Unimex
Reliance
034800 Precast Concrete Parking Bumpers Samcrete
Arab Contractor
Premco
Modern Concrete
CPD
033316 Light Weight Concrete Cemex
Lafarge
035440 Cement Screeds Cemex
Lafarge
042000 Concrete Unit Masonry Arab Contractors
Egyptian American Co.
CPD
Samcrete
Toblat
Cementa
ESG-Egyptian Stones Group
Masonry Accessories Metal X
Unitech
Bridg Egypt
044200 Exterior Stone Cladding MK ‫ممدوح كساب‬
096340 Stone flooring Modern Marble
097500 Stone Facing HAZ Marble
Kiro Marble
Marmonil
Diamond

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 1 of 17
 SECTION
PRODUCT MANUFACTURER
No.
El Prince
MEC
Galala Treasures
055000 Metal Fabrications Guardian
055213 Pipe and Tube Railings Directions
057300 Decorative Metal Railings Basco Industrial
Star Light
Arco Group
064200 Paneling Woodek
095427 Suspended wood Ceilings Sphinx
Deyar
Araek
Wood Masters
Doortech
Fiorito
071113 Bituminous Damp-proofing CMB
Novocheme
Modern
Insutech
Bitunil
074213 Metal Wall Panels Icon
Alex-Panel
075323 Ethylene-Propylene-Diene-Monomer (EPDM) Carlisle
Roofing Firestone
075213 APP Modified Bituminous Membrane Insutech
Bitunil
Insumat
Rockal
Thermal Insulation Advechems
Modern
Delta Foam
CMB
Insutech
Chema foam
Egypt Foam
071613 Polymer Modified Cementitious Waterproofing Sika
BASF
Prokem
X-Calibur
Eamic
071340 Polyethylene Sheet Waterproofing Shuman
Hema blast
GSE
Arasya
071416 Cold Fluid-applied Waterproofing BASF
Sika
CMB
Prokem
X-Calibur
Eamic
Novochem
075216 Styrene-Butadiene-Styrene (SBS) Modified Insutech
Bituminous Membrane Bitunil
Insumat

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 2 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Rockal
071616 Crystalline Waterproofing Xypex
Vandex
Velosite
BASF
071800 Traffic Coating Jotun
SIKA
BASF
Mapei
079200 Joint Sealant Eamic
Sika
Basf
X-Calibur
CMB
081113 Hollow Metal Doors and Frames France Metal
Prometal - ASSA ABLOY
Hormann
Maryt & Scott
Lexa
Dimak
081416 Flush Wood Doors Woodek
Sphinx
ITA
Deyar
Araek
Wood Masters
Doortech
Fiorito
084113 Aluminium-Framed Entrances And Storefronts Alumil
084423 Structural Sealant Glazed Curtain Wall System
Egybel
Aluprof
(System Provider) Alu-K
Powder Coating Akzonobel
Jotun
087100 Door Hardware Consort
Stanley
TESA
Cal-Royal
Hagar
Vektr
Locks for non-fire rated Doors Al Ahram
088000 Glazing Guardian
Saint-Gobain
Sphinx
Glasstorch
AGC
Emirates Glass
088300 Mirrors New Cairo
Smart Glass
ProGlass
Dr. Greich
Saint-Gobain

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 3 of 17
 SECTION
PRODUCT MANUFACTURER
No.
089000 Louvers Alico
Alunile
System
New Cairo
Eagle
092900 Gypsum Board Assemblies Knauf
Saint-Gobain –Gyproc
USG-Boral
Ecobat
093000 Ceramic Tile Gemma
Royal
Cleopatra
Pharos
096723 Resinous Flooring Basf
Sika
X-Calibur
Jotun
Mapei
096516 Resilient Sheet Flooring Gerfloor
096536 Static-Control Resilient Floor Coverings Tarkette
Forbo Flooring System
Polyfloor
096600 Terrazzo Tiles Toblat
EL-Soufi
Harmouch
El Nahr
El Nile
096900 Access Flooring Newfloor
Lindner
Weiss
Nesite
Petral
099000 Painting and Coating Jotun
Terraco
Scib
GLC
101405 Signage Graphilex
Unilex
Cladex
Reklam
102113 Toilet Compartments Gibca
Formica
102800 Toilet and Bath Accessories Genwec
Nofer
Bisk
G Style
104413 Fire Cabinets
Naffco
Bavaria
Bristol
Sffeco
Morx
Melton

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 4 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Kirmary
Genco
Masry Group
LIFECO
104416 Fire Extinguishers Naffco
Bavaria
Bristol
Sffeco
107113.43 Fixed Sun Screen Guardian
Directions
Basco Industrial
Star Light
Composite Wall Panel Technobond
AGF
Alcobond
Stacbond
Wellbond
111500 Parking Control Equipment Flexline
Baramki
Speed hump. Wabo-BASF
Al-Kuhaimi Metal Industries
FADINI
Faac
131200 Fabric Shades Ferrimax
Mehler Texnologies
Serigo Ferrari
149100 Facility Chute Wilkinson Chutes
SFSP-IKK
142100 Electric traction elevators Otis
Mitsubishi
Volkslift
Diao
Kone
Thyssen
21000 Grooved Couplings & Fittings Victaulic
Gruvlok
Smith - Copper
Grinnell
Shur Joint
Fire King
ERW Steel Pipes UTP
Saudi Steel Pipe
El Jazeera
Surya Pipes
Linda Industries
Mech
JASCO
Welded Fittings HM
ERNE
OMR
BKL
Vallourec & Mannesmann
Benken

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 5 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Threaded Fittings Crane
Siam
BIS
Flanges ULMA
Geldbach
Kids
Sprinklers, Alarm Check Valves, Deluge
Valves Preaction Valves, Spray Nozzles Reliable
Victaulic
Tyco
Viking
Flexible Sprinkler Connections Victaulic
Reliable
Tyco
Viking
Valves (Gate, Check, Butterfly & Ball) Kennedy
Nibco
Victaulic
Muller
Supervisory Switches, Flow Switches, System Sensor
Pressure Switches Potter Electric
Fire Department Connections, Hose Potter Roemer
Valves, Hoses, Hose Nozzles Powhatan
Giacomini
Elkhart
Hyflo
Fire Hose Reels Noha
Macron Fire
Kidde
Bavaria
Naffco
Firekill
Ezula
Pressure Reducing Valves Cla-val
Watts
Singer Valve
Wilkins
Pressure Gauges AGF
Winters
Weiss
Watts
Automatic Air Vents Taco
Watts
Val – Matic
Cla-Val
Test and Drain Units AGF
Triple - R
Victaulic
Giacomini
Guardian
Globe

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 6 of 17
 SECTION
PRODUCT MANUFACTURER
No.
211339 Concentrate, Tanks, Monitors, Proportioners, Ansul
Discharge Devices, Concentrate Control Valves,Chemguard
Nozzels National Foam
Viking
Tyco
Angus
212200 Clean - Agent Fire Extingushing Systems Fike
Cylinders, Nozzels, Manifolds, Hoses, Pyrochem
Actuators Chemetron
Tyco
Firetrace
Siemens
Kidde
LPG
Hygood
SIEX
Detectors, Control Panels, Alarm Simplex grinnell
Devices, Manual Release Devices. System Sensor
Siemens
Notifire
Potter
Tyco
213113 Electric - Drive, Centrifugal Fire Pumps Patterson
& Diesel - Driven Centrifugal Fire Pumps Peerless
213116 Fairbanks
SPP
A-C Pump
Aurora
ISS
Ruhrpumpen
Fire Pump Set and Accessories Tornatech
Pump Controllers Firetrol
Metron
Master
Pumps Diesel Engine Clarke
Caterpillar
Cummins
Pump Flow Meters Gerand
Globe Vision
SPP
Victaluic
213400 Jockey Pump Set A - C Pumps
Paco
Grundfos
Taco
KSB
220523 General-Duty Valves For Plumbing Piping Kids
Genebre
Crane
Kenndey
Watts
220529 Hangers And Supports For Plumping Piping And Fischer
Equipment Inka

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 7 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Fastening And Hanging Diamond Walravern
El-Noor
Hydro
220719 Plumbing Piping Insulation Kimmico
Afico
Rockal
Izokam
221116 Polypropylene Pipes & Fittings El-Sherief (El-Amal)
Banninger
Aqua Flow
Kalde
Vesbo
Concept
Raktherm
Cosmoplast
Metitherm
Q-therm
221119 Plumbing Works
Automatic Air Vents Taco Armatoran DG
Watts Regulator Co.
Protective Wrapping Winn & Coales (Denso)
Water Tank Air-Vent Guest &Chrimes Ltd.
Level Floats Flygt
Back Pressure Check Valve Jordan
Level indicator BestobellMobrey Ltd.
Angle stop valve Grohe
Ideal Standard
Embedded valve Grohe
Ideal Standard
221123 Domestic water booster pumps KSB
Armstrong Pump Inc.
Grundfos Pump Cop
Wilo
Biral
Goulds
Ebara
Lowara
221316 UPVC Pipes and Fittings For Drainage and PPP
Pressurized system Misr el hegaz
El-Sherief (El-Amal)
Misr el nour
MMP
Lasheen
GM
Nassar
Aquaflow
Fitting:
EEPCO
Comer
Cepex
Pimtas
BT

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 8 of 17
 SECTION
PRODUCT MANUFACTURER
No.
221316 HDPE Pipes & Fittings For PE 100 MMP
GM
Wavin
Hamza
Misr El Hegaz
Hebeish
221319 Plumbing Specialties
Floor Drains, Roof Drain , Cleanouts & Hose Bibbs Zurn
( cast Iron ) Wade
Jossam
Watts
Mifab
Hydro
Wilson
Tawakol
Plastic Floor drains and cleanout Kessel
Viega
Dallmar
Watts
MCH
Hamza under license Wavin
Hose bibs Zurn
Water Meters Watts
221429 Sanitary Sewage Pumps ABS /Sulzer
Homa
Grundfos
Flygt AB
KSB
Salmson
Tsurumi
Ebara
Shinmaywa
Pentair - Jung
223300 Electric Water Heater Olymbic Electric
GMC
Toshiba
Atlantic
Ariston
224000 Plumbing Fixtures Duravit
Ideal Standard
Mixers Hans Grohe
Grohe
Ideal Standard
Ramon Soler
Kludi Rak
230513 Common motors requirements for Hvac equipment Duchi Motor
Siemens
Brook Hansen
ABB
AEG
Westinghouse
230516 Expansion Fittings And Loops Expansion Joint Systems, Inc.
For Hvac Piping (Expansion Joints and Others as
Spec.)

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 9 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Proco Products, Inc.
Adsco Manufacturing, LLC.
Expansion Joint Systems, Inc.
Manson Insulation Inc.
Viking Johnson
230519 Meters And Gages For Hvac
Piping Trerice, H. O. Co.
Weiss
Weksler
Aschroft
Winters
230523 General-Duty Valves For Hvac Crane
Piping Kitz
Nibco.
Victaulic Company.
Danfos
Oventrop
Stockham
VAG
Herz
Pressure Independent Valves Belimo
Frese
TA
Oventrop
Danfos
Pettinaroli
Flowcon
230529 Hangers And Supports For Hvac Piping Empire Industries, Inc.
And Equipment Fischer
Inka
Erico
Diamond
El nor
Hydro
230548 Vibration And Seismic Controls Mason.
For Hvac Piping And Equipment VMC
B-Line
Empire Industries, Inc.
230593 / Testing, Adjusting, And Tab
230800 Balancing For HVAC Delta
Target
Epc
CMD
230700 HVAC Insulation Johns Manville.
Knauf Insulation
Owens Corning.
Izocam
Izotoprak
ODE
Kimmco
Lapinus
Arabian Fiberglass Insulation
Co. Ltd. (Afico)
Rockal

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 10 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Armacell
Adhesive Foster
Fevicol
230900 Instrumentation And Control For Hvac Johnson Controls, Inc.;
Controls Group.
Sauter Controls Corporation.
Siemens Building
Technologies, Inc.
Honeywell
Automated Logic
Schneider (BIMCO)
232113 / Hydronic Piping JSC ( Dnepropetrovsk tube
232500/ work ) size (0.5” up to 6” )
230500 Interpipe size (1” up to 16” )
Chelpipe size (0.5” up to8” )
Aurohill
TMK size (4” up to16” )
Vallourec & Mannesmann
From 18” and larger Valcovny TRUB size(18” up
to24” )
Threaded Fitting Crane
Siam
Welded Fittings HM
ERNE size (0.5” up to40” )
OMR
BKL
Vallourec & Mannesmann
(0.5” up to 30” )
Benken
Flanges ULMA
Geldbach
Grooved Coupling Victaulic
Gruvlok
Grinnell
Pre Insulated pipe Perma-Pipe Inc.
Eco Direct Limited
Transition and Dielectric Fittings and Others as Spec. Capitol Manufacturing Co.
NibcoINC.
Watts
Advance Products & Systems,
Inc.
Pipeline Seal and Insulator,
Inc.
HM
TTU
BIS
Expansion Tank Xylem
Armstrong
Taco
Reflex
Water treatment and cleaning system System Technique
C-Water
Metito
AQUA Nile.
Nalco chemical co.
Water flow
232123 Hydronic Pumps Armstrong Pumps Inc.

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 11 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Aurora Pump.
Xylem (Bell & Gossett; Div. of
ITT Industries).
Grundfos Pumps
Corporation.
Peerless
PacoPumps.
Taco, Inc.
KSB Pumps
Crane
Wilo
232300 Refrigerant Piping Muller Brass Co.
Yorkshire
Kembila
Flowflex
Crane
233113 Metal Ducts
Galvametal
Kama
Al Ghurair
Sheet metal duct fabrication Techno-metal
Zamzam
2-wire
Expert
233300 Air Duct Accessories (Dampers, Fire Dampers,
Smoke Dampers and Others as Spec.)
Fire and smoke dampers Ruskin Company.
Manual dampers Kbe
Trox
Ruskin Company.
Kbe
BCI
Duct Silencers Trox
Ruskin Company.
Kbe
Tuttle & Bailey
233423 HVAC Power Ventilators Greenheck.
Loren Cook Company.
Helios
TLT
Prollrichdlk
Fabresse
S&P
Woods
Casals
SODECA
CBI – Hammam
Ferrari
For Fan Section Only DCM
Trane
York
Carrier
Primacool
Saiver Egypt
Daikin
Tanta motors
Egat
233433 Air Curtains Daikin

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 12 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Toshiba
National
Trox.
233713 Diffusers, Registers, And BCI
Grilles Kbe
Special items (perforated, Swirl and Zamzam
disc , etc. …) Al sharqa
Egat
Titus
Titus
Trox.
Brofer
234100 / Air Filtration AAF International.
234133 / Filtration Group.
234200 Camfil
Trox
General filters
Flow Air
236426 Rotary-Screw Water Chillers Carrier
Trane
York
Daikin
236500 Cooling Towers Marly.
Evapco.
Baltmore.
237313 Modular Central-Station Air-Handling Units Carrier
Trane
York International
Corporation.
Daikin
DCM
Saiver Egypt
238219 Fan Coil Units Carrier
Trane
YORK
International
Primacool
Century
250000 Building Management System Honeywell
Schneider
Distech controles
BMS Cables Belden
Paige
B3
MESC
260513 Medium Voltage Cable Egytec (El Sewedy)
Giza cables Industries (GC3)
Electro cable Egypt (ECE)
Energya Cable
International Cables(ICC)
260519 Low Voltage Electrical EGYTEC (El Sewedy)
Electrical Power Cables Giza Cables Industries (GC3)
General Cables- BICC
Electro cable Egypt (ECE)

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 13 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Energya Cable
International Cables(ICC)
Fire Resistance Cable (option) El Sewedy
Prysmian
Pirelli
Draka
Nexans
260526 Grounding and Bonding For ABB (Furse)
Electrical Systems Kingsmill
Wallis
Erico
260533 Raceway and Boxes Engineering Home
Egy.con
Decoduct
EL Rehab
PSG
Galvanized Steel Conduits and Boxes Allied
Wheatland
Burn
Smart tube
Steel city (for steel box)
Thomas and Betts (for Steel
Box)
Underground UPVC Conduits El Sherif
Misr ElHegaz
Misr El Nour
Flexible Conduits Flexicon
Kopex
Dielectrix
AFC
260536 Cable Trays For Electrical Systems Egy-tray
Novo
Emeco
NTT- Tawakol
Elsewedy Industrial EIG
261202 Medium Voltage Dry transformer ABB
Approved products from Electrical Distribution El Sewedy
Company) Egytrafo
Schneider-Trihal
261301 Ring Main Unit-AIS Schneider Electric
ABB Arab
262413& LV Switchboard & Schneider Elec.
263533& Power Factor Correction & ABB Arab
262416 Panel boards Siemens-EMAS
Siemens-DCS
Gila- Schneider
Memico- Schneider
Tepco- Schneider
Smart Group – ABB
Inco-tech – ABB
SEI-ELSEWEDY for
Engineering Industries
262419 MCC Schneider Electric
ABB Arab

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 14 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Siemens-EMAS
Advansys - Schneider Electric
PertoKima-Siemens
Smart Group – ABB
Variable Speed Drives ABB
Siemens
ABB(GE)
Schneider
262500 Enclosed Bus Assembly Schneider
GE
LS-Cable
EAE
Powerbar
Lectro
262726 Wiring Devices Legrand
Bticino
Schneider
ABB
Gewiss
Industrial Sockets ABB
Clipsal
Legrand
Eaton
Gewiss
Schneider
Load break switches ABB (GE)
Socomec
Schneider
ABB
Eaton
Gewiss
Bticino
KATKO
Floor Box Marshall Tufflex
Ackerman
Cimabox
Legrand
EAE
263213 Engine Generators Caterpillar
Cummins
Mitsubishi
MTU
SDMO
FG Wilson
263353 Static Uninterruptible Power Supply APC-Schneider
Socomec
Liebert - Vertiv
ABB (GE)
ABB (PowerWave)
Centiel
Lead- acid Batteries Exide
Yuassa
Hoppecke

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 15 of 17
 SECTION
PRODUCT MANUFACTURER
No.
263600 Automatic Transfer Switches Schneider-Electric
ABB
Siemens-EMAS
264113 Lightning Protection System for Structures Furse
Kingsmill
Wallis
Erico
265100 Interior Lighting Refer To the Lighting Fixture
( Refer To the Lighting Fixture Schedule Drawing) Schedule Drawing or
approved equal
265600 Exterior Lighting Refer To the Lighting Fixture
(Refer To the Lighting Fixture Schedule Drawing) Schedule Drawing or
approved equal
271000 Structured Cabling System Commscope
Panduit
R&M
LEONI
ACTASSI -Schneider
Datwyler
Leviton
IT racks HiteKNOFAL
Horizon for industry
GTE
True steel
272000 Data Network Active Components Fortinet
Switches/WIFI HPE
Huawei
IP-PBX Avaya
Mitel
Huawei
NEC
Firewalls Juniper
Fortinet
Palo Alto
274133 Wisi
MATV [IF System] Grundig
Triax
275116 RCF
Public Addresss & Voice Evacuation System TOA
Bouyer
281300 PACOM
HID
Access Control System TYCO (softwarehouse)
281303 FAAC
CIRCONTROL
Parking Management System Came
ArmaKontrol
282300 Video Surveillance System (IPCCTV)
Panasonic
Bosch
Pelco
GANZ
Mobotix

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 16 of 17
 SECTION
PRODUCT MANUFACTURER
No.
Milestone (VMS)
Genetec (VMS & storage)
TYCO/American Dynamics
Promise (Storage)
DELL-EMC (Storage)
Huawei (Storage)
LED Screens Samsung
LG
Philips
Sharp
283100 Fire Alarm System Siemens
Mircom
Esser by Honeywell
System cables Datwyler
Mesc
Italcond
283101 Disabled Toilet Alarm System C-Tec
Baldwin Boxall
Notifier By Honeywell
283600 Water Leakage Detection System RLE Technologies
TTK
Trace Tek
321400 UNIT PAVING The Arab Contractors
Samcrete Egypt
Orascom
Modern Concrete
Egyptian Italian Company
412215 Overhead Crane Yale
Dresser
Hadef
Kuhnezug
Stahl

END OF SECTION 012950

List of Manufacturers Section 012950

Urbanium New Administrative Building (Prj. 2874) Page 17 of 17