‘NORMALS-1 CHALLENGER 604 REV 103, Nov 28/16 NORMAL PROCEDURES CONTENTS PAGE ‘+ Normal Power-Up Check NORMALS-2 * Systems Check. se sssssenusese NORMALS-3 + Before Start Check. NORMALS-5 * Start Check seottnniesnsennsess NORMALS-5 + APU Assisted — Engine Start NORMALS-6 * Failure to Start... se sssssenusess NORMALS-6 ‘+ After Engine Start Check NORMALS-7 * Taxi Check ssssssnusesss NORMALS-7 + Stabilizer Tim Setting for Take-Off NORMALS-8 * Take-Off Check... se sssssnmsese NORMALS-9 + After Take-Off Check NORMALS-9 + Climb Check. sssssenusesss NORMALS-9 ‘+ Cruise Check. NORMALS-9 * Descent Check... se ssossennses NORMALS=10 + In Range Check NORMALS-10 # Before Landing Check... ssssennses NORMALS=10 + Go-Around. NORMALS-11 # After Landing CheCk....sses ssssnsee NORMALS=11 + Shutdown Check. NORMALS-12 * Securing Check. ssssensses NORMALS=12 + Battery/Extemal Air - Engine Start NORMALS-13 * Cross-Bleed ~ Engine Statt...ncm:ssnemenen NORMALS-13 + External Air/AC Power - Engine Start NORMALS-14 GENERAL [Associated procedure or step is only required on the first flight of the day. The Normal Power-Up Check and the Systems Check must be accomplished in its entirety on the first flight of the day. ‘On subsequent flights, if the airplane is powered-down (or if the flight crew is replaced), the above checks are accomplished with the exception of those items suffixed with [. FZ Associated procedure or step is only required on the last flight of the day, QUICK REFERENCE HANDBOOK BaP OO TS NORMAL PROCEDURESNORMALS-2 REV 89, Jul 08/13 CHALVENGER 604 NORMAL POWER-UP CHECK] (1) Airplane and Flight Pubs ON BOARD (2) Circuit breakers wn... ons CLOSED (3) Emergency equipment CHECK (4) Hydraulic PUMPS....nenarnnennnnnnasnnnnsensne OFF (6) NOSE STEER OFF (6) LOG GEAR lever...... ssennnnasenniesnsnnnsnaseesaees DN (7) FLIGHT SPOILER lever RETRACTED (8) FLAPS leveriposition... se CHECK/MATCHED (9) Weather radar OFF (10) ADG manual release. vente -STOWED (11) BATT MASTER ON (12) DC electrical page . CHECK 22 VDC MINIMUM (13) Firex monitor system test {71 COMPLETE (14) Fire detection systems test TH ...semnnssnneee COMPLETE, (15) NAV lights. ON (16) APU (if required)... START After APU indications stabilize, solect APU GEN to ON. IF APU and AC external power are not available: (16) Battery/External Air - Engine Start COMPLETE * Proceed to step (23). (17) AC & DC electrics. ESTABLISHED (18) Lamp test DD... seosansnstnnsenseeees COMPLETE (19) Bleed leak detection test. COMPLETE (20) APU LCV... onaennsenninnanenannns OPEN (21) 10TH STAGE ISOL OPEN (22) PACKs.. os ON (23) IRS NAV (24) AIL FMS... POS INIT QUICK REFERENCE HANDBOOK Der OFT NORMAL PROCEDURES| nema e res | GhatteniceReoa Le. [SYSTEMS CHECK| (1) Seat & hamess ADJUST (2) Rudder pedals. ADJUST When nosewheel area REV 103, Nov 26/16 confirmed clear: (8) Hydraulic PUMP 3A .nsnsnnnsnniennnnnesunsnasenseces ON (4) Nosewheel door CLOSED (5) Oxygen system CHECK .nnsnnnsnnniensen COMPLETE (6) Audio warning, GUARDED/OFF (7) CVRassnnstnnnennnnnnnnannnnnnnnnanannanes TEST, (8) Electrical power panel! CHECK (9) APU .sininnnnennnnnnnannennnannnnnnanenneAS REQUIRED (10) Hydraulic panel CHECK/AUTO/ON (11) Lights... seeinnnennnnnnnn AS REQUIRED (12) Starvignition panel CHECK (13) Fuel panel. sonnnsnnsenasnnnnnnnsenseen CHECK (14) Air-conditioning panel CHECK (15) ELT sce sonnenseunnesensesnseeARM (16) Cabin pressurization panel CHECK (17) Bleed air panel .snnmnasnennninatsnnsnnsnnne CHECK (18) Anti-ice panel. CHECK | On airplanes with Supplemental Ground Wing Anti-Icing: | (19) Wing anti-ice switch test 0 -COMPLETE | (20) Ice detector test _ Tn COMPLETE (21) PASS SIGNS On (22) Emergenoy light [1 ...nnnnnnnennnenennn CHECK/ARM @3) Standby compass. CHECK (24) Glareshield eotnnnnnniesennnnnseeseees CHECK @5) GPWS check (if installed) "77 COMPLETE (26) GPWS TERR INHB (if install€d).....00ennneAS REQUIRED (27) Side panels. CHECK/SET | (28) SUPP GND WING ANTIICE. T panels {if installed) ....snsssnmnnauennnnsnnnnasen CHECK @ EFIS CHECK (30) Standby instruMeNts....nunsssnnnnnnnannsseenenn CHECK (31) EICAS CHECK (32) Landing gear HORN. soseenesnseenenns GUARDED (33) ANTI-SKID. ARMED (34) MLG overheat detection system CHECK Tan COMPLETE (@5) Aural warning system chock ft COMPLETE (36) Stall protection system check 1 COMPLETE 1 NORMAL PROCEDURES | | QUICK REFERENCE HANDBOOK 1 | PSP 604-15 |NORMALS-4 CHALVENGER 604 REV 103, Nov 28/16 [SYSTEMS CHECK (CONT'D) (87) Overspeed warning system check IT COMPLETE (38) PITCH and ROLL DISC.... INSTOWED (39) GND SPOILERS AUTO (40) Thrust reversers one ARMED (41) FLIGHT SPOILER lever RETRACTED (42) Thrust levers... sven SHUT OFF (43) GPWS FLAP OVRD (i installed). “"NORM/GUARDED (44) FLAPS... CHECK (45) Engine vibration test IT. COMPLETE (46) ENG SPEED .. sevseneessees ON (47) EICAS control pane! AS REQUIRED (48) Display control... sone AS REQUIRED (49) RTUs "SETINO MESSAGES (50) TCAS check (if installed) [1 COMPLETE (61) Air data reference panels SET (52) Radio altimeter check [... COMPLETE (63) Flight control trim systems check IT COMPLETE (54) Yaw dampers .. ENGAGE (65) AFCS and ATC selectors. SET (56) RTU and FMS inhibit switches «0.0.0 OFF (67) Reversionary selectors NORM (68) IRS selectors... NAV (69) IRS reversionary selectors (if installed) AS REQUIRED (60) FMS 3 selector (if installed). AS REQUIRED (61) Landing gear manual release STOWED (62) ADG handle. seve STOWED (63) ADG AUTO DEPLOY CONTROL LAMP QUICK REFERENCE HANDBOOK PSP 604-15 NORMAL PROCEDURES| nema e res | GhatteniceReoa Le. BEFORE START CHECK] (1) Gravity crossfiow check. COMPLETE (2) Windshield/window heat test COMPLETE (3) Wing overheat detection system test COMPLETE (4) Pressurization..iununnnnnnnnnnnnnnnanennnenn SET (5) Altimeters SET (8) EFIS .csennennnnnnnnnnneneSET FOR DEPARTURE (7) CAS CHECK (8) Brakes and anti skid system CHECK a santnnnennennnenansnnnnninnnnsnasenseness COMPLETE, (9) FMS. SET (10) FMS messages w.nnnnasnennsnnsnasnnnssenene CHECK (11) Radios/Navaids SET FOR DEPARTURE (12) Take-Off data .snsnnnnunnnnnnannnasnannaensnnnn SET (13) Take-off briefing COMPLETE [START CHECK| (1) Passenger d00% ....nsnnasnnsnnnnnnsnne CHECK CLOSED (2) Fuel quantity and balance CHECK (8) BEACON (if installed) ....sssnnsnnennnnssnnsenaseneces ON (4) L&R BOOST PUMPs. ON (6) BLEED AIR. sonneunseueiennnene SET FOR START (6)_ IGNITION A (B) ARM | QUICK REFERENCE HANDBOOK 1 | PSP 604-15 |NORMALS-6 REV 103, Nov 28/16 CHALVENGER 604 [APU ASSISTED - ENGINE START] With APU operating: (1) APULCV.. sosentenennnnenennneneieneieneneess OPEN (2)_L(R) ENG START. PRESS When N; reaches 20% RPM and ITT is below 120°C: (3) Left or right thrust lever IDLE (4) Engine instruments -. MONITOR (5) Fuel system check valve operation [77 VERIFY When operating with one engine, select inoperative engine boost pump to INOP. If other engine is to be started using APU bleed air: (6) Thrust lever of operating engine... soseeneneeeeel DLE (7) Bleed air pressure CHECK (8)_L(R) ENG START sonnei » PRESS. When Nz reaches 20% RPM and ITT is below 120°C: (9) Thrust lever of starting engine... IDLE (10) Engine instruments. MONITOR (11) APU EGT CHECK (12) Idle speed CHECK FAILURE TO START| (‘Thrust lever SHUT OFF (2) IGNITION OFF If one engine is operating: (8) Inoperative engine BOOST PUMP. OFF (4) Dry Motor, ACCOMPLISH Until ITT is reduced below 120°C (maximum 90 seconds). (QUICK REFERENCE HANDBOOK Der OFT NORMAL PROCEDURES| nema e res | GhatteniceReoa Le. [AFTER ENGINE START CHECK ()_ GEN 1 & GEN2 ON | (2) STBY INSTR cb (1P9) () AC and DC electrical pages . (4) APU GEN | @)_APU GEN... OFFIRESET | (5) APU.. onan TILNAS REQUIRED | (8) Ignition DISARM (7) PACKS... sesnnnnnnneennnnnnnsenenes ON (8) 14TH stage valve check.. COMPLETE (9) Wing anti-ice check... COMPLETE (10) Wing ant-icerisolation valve check COMPLETE (11) Anti-ice cowl check 1... COMPLETE (12) Supplemental ground wing anti-ice check (if installed) COMPLETE (13) Wing and Cowl anti-ice ...nsnnennnnnnnnnenneAS REQUIRED (14) Flight controls, CHECK (15) Ground spoilers Check TH ees COMPLETE (16) Flight spoilers check {17 COMPLETE (17) NOSE STEER ssnsnnnnnninnsnnnnsnnnnsenseeARMED (18) APR check. COMPLETE (19) ADG AUTO DEPLOY CONTROL .. UNIT [TAXI CHECK] (1) ATC SELITCAS. AS REQUIRED (2) BrAKOS casenmnesnennnnnasnnninaisnninasnnnnnssnnene CHECK (3) FLAPS 20° (4) Thrust reversers Check [17 ....nssnnsnasennenane COMPLETE, (5) Aileron and rudder trims NEUTRAL (6) Stabilizer thiM...snnensnneenenn SET FOR TAKE-OFF (7) Flight instruments CHECK & SET (8) FU! balance .nsnsnannaunnnnninnnnsnnsen CHECK (9) Wing and cowl ar AS REQUIRED | QUICK REFERENCE HANDBOOK 1 | PSP 604-15 |NORMALS-8 CHALVENGER 604 REV 103, Nov 28/16 [STABILIZER TRIM SETTING FOR TAKE-OFF] €.G. Range (%MAC) Trim Setting 160-162 72 163-172 70 173-183 68 184-193 66 194-203, 64 20.4 - 21.5, 62 21e~ 22.4 60 22.5- 23.4 58 235-244 56 26.5 - 255 54 256-265 52 266-275 50 278-285 48 286-296 46 297-306 44 307-316 42 317-326 40 32.7 -337 38 338-347 36 348-965 34 36.6 - 38.0 32 NOTE Trim data from the FMS should be rounded down to the next lowest multiple of 0.2 trim units. (QUICK REFERENCE HANDBOOK Der OFT NORMAL PROCEDURESCHALVENGER 604 NORMALS-9 REV 106, Jun 16/17 [TAKE-OFF CHECK] (1) Correct runway (2) IgMItON arene (3) Wing and cowl anti-ice (4) L&R WSHLDWIND.. (6) PROBES (8) CABIN essere (7) Cockpit lighting (8) External lights.. (9) CAS (10) Take-off data (V4, Vis Vo & distance) nnn (11) SUPP GND WING ANTI-ICE panels (if installed) (12) Weather radar... (13) ATC SELTCAS. [AFTER TAKE-OFF CHECK] (1) LOG GEAR lever...... (2) FLAPS (3) Thrust reversers....... (4) CAS (6) Ignition... 6) [CLIMB CHECK| (1) Pressurization.. (2) PACKs. (3) Climb thrust (4) APU GEN (6) APU.. (6) GPWS TERR INHB (if installed). (7) PASS SIGNS.. (8) External lights. At transition level: (9) Altimeters [CRUISE CHECK| (1) Wing and cow! anti-ice ....... (2) Cruise thrust (3) Pressurization.. (4) Fuel CONFIRM AS REQUIRED AS REQUIRED -oHl or LOW ON seenseeesnee ADVISE AS REQUIRED soneAS REQUIRED CHECK & CLEAR .. CHECK DISPLAYED CHECK su ON SET uP. o sesvnnsnenesesens OFF CHECK & CLEAR AS REQUIRED AS REQUIRED vse CHECK TRANSFER TO ENGINE BLEED eeveeeene SET OFF/RESET SHUTDOWN OFF AS REQUIRED AS REQUIRED SET AS REQUIRED SET vse CHECK MONITOR QUICK REFERENCE HANDBOOK PSP 604-15 NORMAL PROCEDURESNORMALS-10 CHALLENGER 604 REV 106, Jun 16/17 DESCENT CHECK (1) ATIS copy (2) CAS nrsnennense sonnnseineeu CHECK & CLEAR (3) GPWS TERR INHIB (if installed). AS REQUIRED (4) Landing data....snsnnnnnnnnnnnnnnanennnnennen SET (6) Approach briefing COMPLETE (6) Shoulder harness....... vente sone SECURE (7) Pressurization. CHECK & SET (8) Wing and cowl anti-ice ...nnmenennnnnnneneeAS REQUIRED (9) _L & RWSHLD/WIND. Hl or LOW (10) Fuel quantity & balance... ssn CHECK At transition level: (11) Altimeters .. - SET/CROSS-CHECK IN RANGE CHECK| (1) APU (if required). START After APU indications stabilize, select APU GEN as required. If APU is available: (2) PACKS wv rsesnenmntenentetnentnne: TRANSFER TO APU BLEED (3) External lights. AS REQUIRED (4) PASS SIGNS... AS REQUIRED BEFORE LANDING CHECK| (1) Ignition. AS REQUIRED (2) Wing and cowl anti-ice snneenmenennnennarnneneAS REQUIRED (3) Cabin ADVISE (4) PASS SIGNS.....ccsnsntsnennnnnnunnnatinesnsnnenasenes ON (6) LDG GEAR lever. DN/INDICATING (6) Brake and anti skid system check...... see COMPLETE, (7) Thrust reversers ARMED (8) FLAPS... AS REQUIRED (QUICK REFERENCE HANDBOOK Der OFT NORMAL PROCEDURESNORMALS-11 CHALVENGER 604 REV 104, Feb 23/17 [GO-AROUND| If unreliable airspeed is suspected disregard all reference to TOGA. Do not use TOGA. (1) Thrust levers/TOGA (2) FLIGHT SPOILER lever (ifextended) (3) Airplane (4) Pitch attitude (5) FLAPS When a positive rate of climb is achieved: (6) LOG GEAR lever...... Ata safe altitude (not below 400 feet AGL): (7) FLAPS (8) Thrust reversers [AFTER LANDING CHECK] @) FLAPS (2) FLIGHT SPOILER lever (3) ATC SELITCAS. (4) PROBES (6) Wing and cowl anti-ice (6) Windshield/window heat (7). Ignition (8) External lights. (9) Landing lights (10) Weather radar (11) Trims ADVANCE/PRESS, RETRACT ROTATE ADJUST 20° uP. o OFF AS REQUIRED RETRACTED AS REQUIRED OFF AS REQUIRED AS REQUIRED OFF AS REQUIRED OFF OFF RESET QUICK REFERENCE HANDBOOK PSP 604-15 NORMAL PROCEDURES| oma meee | GhaleNaeR aoa te [SHUTDOWN CHECK] (1) Parking brake AS REQUIRED (2) Thrust reversers ..ncretneenmnnemnnennareesnsenee STOW (3) Wing and cow! anti-ice OFF (4) L&R WSHLDMWIND.. sosntentintenennenetnseneesees OFF. (6) APU START After APU indications stabilize, select APU GEN to ON. (6) GEN 1 & GEN 2 OFF/RESET (7) Engine that started first .....casosssennarsensene SHUTDOWN (8) L&R BOOST PUMPs PRESS OUT (9) Fuel system check valve operation [ .. COMPLETE (10) Other engine. SHUTDOWN (11) Fuel system crossflow valve operation B) vensannnasnnnnnasnnnnasnnnnsne CHECK (12) PASS SIGNS. OFF (13) BEACON (if installed) ....cneinennnnnasnnnennnsnsene OFF (14) NOSE STEER OFF (15) ATC SELITCAS...... . STBY [SECURING CHECK (1) Parking brake AS REQUIRED (2) IRS Se1eCIO1S wnssesnnnnanenniniiennenasnnnnnsnnne OFF (3) Thrust reversers OFF (4) Standby Attitude Indicator ..cssnnsennenesen CAGE (6) External lights. OFF (6) EMER LTS sonneunennainnennnnnasnesees OFF (7) Hydraulic pumps. OFF (8) APU GEN. soneianensnnasennennnness OFFIRESET (9) APU SHUTDOWN (10) PACKS .sssnsseinnnnnnnasnnninainnnnnasnnnnnnsns OFF (11) APULCV CLOSE (12) 10TH STAGE ISOL.... snnmininnnnnnenasens CLOSE (13) BATT MASTER OFF (14) MISC LTS. | On airplanes 5301 to 5487 without SB 604-72-00; | (15) Oil master chip detector I indicators '2 | QUICK REFERENCE HANDBOOK | | NORMAL PROCEDURES | I PSP 604-15| geneween || CHALLENGER 60a BATTERY/EXTERNAL AIR — ENGINE START, (1) Normal Power-Up Check. AS INSTRUCTED (2) APULCV.... sassnnenennenenennenennenenenes CLOSE (3) External air CONNECTED (4) External cart 45 PSI MIN | On airplanes 5301 to 5330 without SB 604-21-002: | | (6) PACKs (6) _R BOOST PUMP. PRESS IN (7) IGNITION B sotninaesesnnaienienasnnsinasensenes ON (8) RENG START PRESS When No reaches 20% RPM and ITT is below 120°C: (9) Right thrust lever IDLE (10) Engine instruments.....esenneesnnsnasnnnsenneMONITOR (11) GEN 2. ON (12) AC and DC electrical pages sntnsnasenaensens CHECK (13) Lamp test "7 COMPLETE (14) Fuel system check valve operation 1 soe VERIFY, When operating with one engine, select inoperative engine boost pump to INOP. (15) External air DISCONNECT (16) Bleed leak detection test [7 COMPLETE (17) R 10TH STAGE bleed OPEN (18) R PACK ON (19) Normal Power-Up Check COMPLETE [CROSS-BLEED — ENGINE START| (1) APULCV CLOSE (2) 10TH STAGE bleed of operating engine OPEN (8) Thrust lever of operating engine. ADVANCE (4) Bleed air pressure 60 PSI MIN (6) L(R) ENG START PRESS When Np reaches 20% RPM and ITT is below 120°C: (6) Thrust lever of starting engine IDLE (7) Engine instruments. MONITOR (8) Thrust lever of first engine IDLE (9) Idle speed CHECK (10) L & R 10TH STAGE bleeds OPEN | QUICK REFERENCE HANDBOOK 1 | PSP 604-15 |NORMALS-14 REV 106, Jun 16/17 CHALVENGER 604 EXTERNAL AIR/AC POWER - ENGINE START (1) APULCV CLOSE (2) External air svtstntnitntenenensenesteset CONNECTED (3) Bleed air pressure 45 PSI MIN (4) L(R) ENG START. . PRESS. When N, reaches 20% RPM and ITT is below 120°C: (5) Left or right thrust IeVEr ....cneneannnennaennenennnenensenDLE (6) Engine instruments MONITOR (7) Fuel system check valve operation FD wenn : oe VERIFY When operating with one engine, select inoperative engine boost pump to INOP. (8) Other engine START NOTE When starting the other engine using cross-bleed, accomplish steps (9) to (11) first (9) Applicable GEN ON (10) External AC power (if connected). DISCONNECT (11) External air DISCONNECT QUICK REFERENCE HANDBOOK Der OFT NORMAL PROCEDURES