NISSAN JUKE
1.6ℓ TURBO PETROL ENGINE
PERIODIC MAINTENANCE
The following tables show the normal maintenance schedule.
Depending upon weather and atmospheric conditions, varying road surfaces,
individual driving habits and vehicle usage, additional or more frequent maintenance may be required.
Periodic maintenance beyond the last period shown on the tables, requires similar maintenance.
ENGINE AND EMISSION CONTROL MAINTENANCE (HR16DE PETROL ENGINES)
Abbreviations: R = Replace, I = Inspect and correct or replace as necessary, [ ] = At the specified mileage only
MAINTENANCE OPERATION MAINTENANCE INTERVAL
km x 1,000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
Perform at kilometres (miles) or months intervals,
(miles x 1,000) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90)
whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156 170 182
Intake & exhaust valve clearance See NOTE (1)
Drive belt(s) See NOTE (2) I I I I I I I
Engine oil (use recommended oil) ★ R R R R R R R R R R R R R R R
Engine oil filter (use Genuine NISSAN Engine Oil
R R R R R R R R R R R R R R R
Filter or equivalent) ★
Engine coolant See NOTE (3)
Cooling system I I I I I I I
Fuel lines I I I I I I I
EVAP vapor lines (with carbon canister) I I I I I I I
Air cleaner filter (viscous paper type) ★ Replace every 40,000km (24,000 miles) or 24 months
Fuel filter (in-tank type) See NOTE (4)
Spark plugs (iridium/platinum-tipped type) [R]
Maintenance items with a ★ should be performed more frequently according to ‘Maintenance under severe driving conditions’
NOTE:
(1) Periodic maintenance is not required. However, if valve noise increases, check valve clearance.
(2) Replace the drive belt if found damaged or if the auto belt tensioner reading reaches the maximum limit. Obtain customer authorisation to replace the damaged part.
(3) Use Genuine NISSAN Engine Coolant (Blue) or equivalent in its quality, in order to avoid possible aluminium corrosion within the engine cooling system caused by the use of non-genuine engine coolant.
Check and correct the engine coolant mixture ratio every 40,000km (24,000 miles) or 24 months. First replacement interval is 160,000km (96,000 miles) or 96 months. After first replacement, replace every
80,000km (48,000 miles) or 48 months.
(4) Fuel filter is maintenance-free. For service procedures, refer to FL section.
NISSAN JUKE
1.6ℓ TURBO PETROL ENGINE
CHASSIS AND BODY MAINTENANCE
The following tables show the normal maintenance schedule.
Depending upon weather and atmospheric conditions, varying road surfaces,
individual driving habits and vehicle usage, additional or more frequent maintenance may be required.
Abbreviations: R = Replace, I = Inspect and correct or replace as necessary, L = Lubricate
MAINTENANCE OPERATION MAINTENANCE INTERVAL
km x 1,000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
Perform at kilometres (miles) or months intervals,
(miles x 1,000) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90)
whichever comes first
Months 12 24 36 48 60 72 84 96 108 120 132 144 156 170 182
Brake & clutch fluids (for level and leaks) I I I I I I I I I I I I I I I
Brake fluid ★ R R R R R R R
Brake booster vacuum hoses, connections & check valve I I I I I I I
CVT fluid (for level & leaks) See NOTE (1) I I I I I I I I I I I I I I I
Manual transaxle gear oil (for level & leaks) I I I I I I I I I I I I I I I
Steering gear & linkage, axle & suspension parts,
I I I I I I I
& front drive shafts ★
Transfer oil (for level and leaks) I I I I I I I
Differential gear oil (for level and leaks) ★ I I I I I I I
Wheel alignment (if necessary, rotate & balance wheels) I I I I I I I I I I I I I I I
Brake & clutch system I I I I I I I I I I I I I I I
Exhaust system I I I I I I I
Brake pads, rotors & other brake components ★ I I I I I I I I I I I I I I I
Locks, hinges & hood latch ★ L L L L L L L L L L L L L L L
Foot brake, parking brake & clutch (for free play,
I I I I I I I I I I I I I I I
stroke & operation)
Alloy wheel inserts See NOTE (2) <I> <I> <I> <I> <I> <I> <I> <I> <I> <I> <I> <I> <I>
Air conditioner filter ★ See NOTE (3) R R R R R R R
Seat belts, buckles, retractors, anchors & adjusters I I I I I I I I I I I I I I I
Maintenance items with a ★ should be performed more frequently according to ‘Maintenance under severe driving conditions’
NOTE:
(1) Use only Genuine NISSAN CVT Fluid. If towing a trailer, using a camper or a car-top carrier, or driving on rough or muddy roads, inspect CVT fluid deterioration at NISSAN dealers every 90,000km
(54,000 miles), then change CVT fluid if necessary. And if the inspection is not performed, change (not just inspect) CVT fluid every 90,000km (54,000 miles). Using transmission fluid other than
Genuine NISSAN CVT Fluid will damage the CVT, which is not covered by the warranty.
(2) Replace if found damaged. Obtain customer authorisation to replace the damaged part.
(3) Even if it is before the replacement interval, if the amount of air conditioner or heater coming out of the vent is drastically low or if the windows fog up easily, please replace the air conditioner filter.
NISSAN JUKE
1.6ℓ TURBO PETROL ENGINE
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
The maintenance intervals shown on the preceding pages are for normal operating conditions.
If the vehicle is mainly operated under severe driving conditions as shown below,
more frequent maintenance must be performed on the following items as shown in the table.
Severe driving conditions
A- Driving under dusty conditions
B- Driving repeatedly short distances
C- Towing a trailer or caravan
D- Extensive idling
E- Driving in extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or extremely high
F- Driving in high-humidity areas or in mountainous areas
G- Driving in areas using salt or other corrosive materials
H- Driving on rough and/or muddy roads, or in the desert
I - Driving with frequent use of braking or in mountainous areas
J - Frequent off-road use or driving in water
K- For models without Euro-OBD system
L - Sustained high-speed driving
Maintenance operation: Inspect = Inspect and correct or replace as necessary
DRIVING CONDITION MAINTENANCE ITEM MAINTENANCE OPERATION MAINTENANCE INTERVAL
A . . . . . . . . . . . Air cleaner filter Replace More frequently
A B C D . . . . . . . . Engine oil & engine oil filter Replace Every 5,000km (3,000 miles) or 6 months
. . . . . F . . . . . . Brake fluid Replace Every 10,000km (6,000 miles) or 12 months
. . . . . . G H . . . . Steering gear & linkage, axle & suspension parts, & front drive shafts Inspect Every 10,000km (6,000 miles) or 12 months
. . C . . . . H . . . . Differential gear oil (for level & leaks) Replace Every 40,000km (24,000 miles) or 24 months
A . C . . . G H I . . . Brake pads, rotors & other brake components Inspect Every 5,000km (3,000 miles) or 6 months
. . . . . . G . . . . . Locks, hinges & hood latch Lubricate Every 5,000km (3,000 miles) or 6 months
A . . . . . . . . . . . Air conditioner filter Replace Every 10,000 km (6,000 miles) or 12 months
More frequently = Less than half the interval of that for normal driving conditions
