REVISIONS

REV DESCRIPTION DATE APPROVED

R0 INITIAL RELEASE, UPDATED AV-60009 06/21/22 TK

HIC MODULE TO AV-60009-2, MINOR
CORRECTIONS, FIXED FILE PATH

CIRCUIT LETTER FUNCTION DRAWING KEY

WIRING HARNESS NUMBER IF APPLICABLE
LETTER CIRCUITS
ES-XXXXX WH-XXXXX C411J
CONNECTOR BODY
C CONTROL SURFACE
PART NUMBER
1 2 3 4 5 6 7 8 9 CONNECTOR
D INSTRUMENT IDENTIFICATION
11
NUMBER
E ENGINE INSTRUMENT
F FLIGHT INSTRUMENTS
BLUE: INDICATES PIN & PIN NUMBER BORDER COLOR CORRESPONDS TO
H HEATING VENTILATING BACKGROUND COLOR OF LABEL AND
WIRES SUPPLIED ALREADY
J IGNITION CONNECTED TO A MAX AMPERAGE PER PIN HEAT SHRINK COLOR. WHT AND BLACK
K ENGINE CONTROL CONNECTOR ARE INTERCHANGEABLE.
L LIGHTING
P POWER CONTROL GREEN: INDICATES SHIELD
WHT: 40V MAX WIRES TO BE INSERTED INTO STRIPE SHIELD
Q FUEL GRN: 100V MAX COLOR WIRE
A CONNECTOR BY BUILDER
R RADIO RED: 400V MAX WIRE
WIRE COLOR
RZ HEADPHONE BLUE DASHED: INDICATES GAUGE
PCB TRACE
T SPECIAL ELECTRONIC OPTIONAL WIRE
NAME
LENGTH
TC RADIO CONTROL MAX AMPERAGE (INCHES)

36
YXX XC:22S XX XXX/XXX

X.X
TD AIRBORNE ANNOUNCING RATING OF CIRCUIT EDC-10A GND SOLID THICK:
TP BEACON (NOTE CONNECTOR PIN
LENGTH OF WIRE (NOT COUNTING WIRES SUPPLIED
RATING MAY BE LESS)
TQ TRANSMITOR RECEIVER CONNECTORS) IN KIT
PIN NOMENCLATURE
W WARNING EMERGENCY BLUE: INDEPENDENT RATING DESCRIBES ITS FUNCTION TO THE SHIELDED BLUE DASHED:
DEVICE THE PIN IS CONNECTED TO X (NUMBER OF WIRES) MULTI CONDUCTOR WIRE OPTIONAL
YELLOW: DEPENDENT UPON RED: POWER WIRE NUMBER NOTE: IF NO WIRE COLOR WIRES
OTHER ITEMS ON CIRCUIT BLUE: AUDIO
IS STATED, WIRE COLOR
WHITE: DATA CIRCUIT FUNCTION LETTER
IS WHITE
ORANGE: MATCHED DATA PAIR D-SUB PIN NUMBER
GREEN: GROUND

ELECTRICAL SYSTEM NOTES ELECTRICAL SYSTEM BENCH TEST PROCEDURE

- USE M22759/16 OR M27500 TEFZEL AIRCRAFT WIRE. CONTACT VAN'S ABOUT USING OTHER EQUIV.
Avionics Group
- USE MIL-I-23053 HEATSHRINK. CONTACT VAN'S ABOUT USING OTHER EQUIV. 1.___Check PFD & MFD Power On
2.___SkyView Check PFD and MFD recognize a USB stick
- LABEL THE FLYING LEAD OF EACH WIRE WITH THE TRUNCATED NOMENCLATURE AND WIRE NUMBER.
3.___Install latest software and settings per the readme files (applicable portions) on the Van's Web Site
- CONNECT ALL 20-24 AWG WIRES TO D-SUBS USING ES-SA-1017 SOCKETS OR ES-SA-1018 PINS. PERMISSIBLE TO STRIP 18 AWG WIRE TO FIT a.___Setup X Pndr Hex Code
ES-SA01017 SOCKETS OR ES-SA-1018 PINS. ALL CRIMPS TO BE MADE PER MIL-C-22520F (1.2.2) USING A TYPE 1 TOOL. b.___Setup AP servos if installed
4.___Check PFD & MFD recognize all LRU's
- USE ONLY NOR-COMP BACKSHELLS ON D-SUB CONNECTORS (WITH THE EXCEPTION OF 50-PIN CONNECTORS)
5.___Check X pndr will transmit.
- HARNESS MUST BE TESTED WITH ALL AVIONICS IN ACCORDANCE WITH THE "ELECTRICAL SYSTEM BENCH TEST PROCEDURE". RESULTS ARE TO BE 6.___Check COM turns on.
SUPPLIED TO VAN'S FOR EACH HARNESS. 7.___Check PFD recognizes COM, and can push frequencies to COM radio

-CRIMPED MOLEX, TYCO, AND AMP TERMINALS ARE TO BE CRIMPED WITH THE MANUFACTURER'S RECOMMENDED CRIMPING TOOL. 8.___Check Backup Battery Function PFD
9.___If installed check AP Control Head function (knobs function for SkyView as well)
- CRIMPED TERMINALS ARE TO BE INDIVIDUALLY PULL TESTED.
Audio Group
-DO NOT COVER WIRES WITH WIRE NET.
1.___Configure COM radio in accordance with "GTR 200B Internal Presets" or "Trig TY96 Internal Presets"
- HARNESSES ARE TO BE BUNDLED WITH LACING CHORD, WITH THE EXCEPTION OF BLUE TIE-WRAPS USED AT BULKHEAD STATIONS. 2.___Check Pilot Headset Jack
3.___Check Pilot Mic Jack for Xmit
- ALL 3 CONDUCTOR JACKETED NON-SHIELDED WIRE MAY BE REPLACED WITH TWISTED WIRES OF THE SAME AWG SIZE AND THE SAME WIRE COLOR.
4.___Check Co-Pilot Headset Jack
- ADJUST SOLDER SPLICE / RING TERMINAL SIZE AS REQUIRED TO ACCOMMODATE DESIRED WIRE GAUGE(S). MAINTAIN RING TERMINAL STUD/TAB SIZE. 5.___Check Co-Pilot Mic Jack for Xmit
6.___If installed check XM music output to headset.

Cockpit Group
NOTE: If customer has selected the pre-wired stick option then use their control sticks
1.___Check Pilot TX Button
GTR 200B INTERNAL PRESETS TRIG TY96 INTERNAL PRESETS
2.___Check Pilot Trim Buttons (Both Directions)
"MENU" BUTTON OPTIONS INTERCOM VOLUME: a.___Verify proper trim direction movement on screen indicator and servo with input
- MUSIC VOL 75% 3.___Check Co-Pilot TX Button
- ICS VOL 80% AUX IN VOLUME:
- ICS SQLCH AUTO
- COM MUTE ON MUSIC IN VOLUME: 4.___Check Co-Pilot Trim Buttons (Both Directions)
- COM MUTE ICS OFF a.___Verify proper trim direction movement on screen indicator and servo with input
- ICS MUTE MUSIC OFF SIDETONE VOLUME: 5.___Check function of AP disconnect switch near throttle.
- MUTE LEVEL FULL
6.___Check Pilot AP Disconnect Switch
- COM 3D ON INTERCOM SQLCH:
- ICS 3D ON 7.___Check Co-Pilot AP Disconnect Switch
- COCKPIT NOISE NORMAL MIC 1 GAIN: 8.___Check Pilot COM Freq Swap
- MUSIC BASE BOOST OFF
9.___Check Co-Pilot Freq Swap
- MUSIC EQ OFF MIC 2 GAIN:
- KEY BEEP VOL 50% 10.___Check Dimmer (Note PCB portion will be checked during AV-60000 Check)
- CONTRAST +0 RADIO SQLCH: a.___Turn on all switches. Check that all lighted switches lights turn on and dim. (Ignore wires going to cabin light.)
11.___Check canopy latch switch
INTERNAL MENU SETTINGS TY96 PRESET NOTES:
- SIDETONE 05 -SET FREQUENCY STEP SIZE APPROPRIATE FOR 12.___Check flap motor function both directions
- MIC GAIN 05 REGION. 13.___Check for power output at USB connectors / Power Outlet
- RF SQLCH 00 - ALL SETTINGS NOT DEFINED BY THIS DRAWING
- MON SWAP ON ARE ACCEPTABLE AS CONFIGURED FROM
Wing Group
- INTERCOM ENABLE YES MANUFACTURER.
- RECIEVE OUT GAIN 100% 1.___Check Stall Warning
- AUX 1 SQLCH 30% 2.___Check NAV/Strobe Lights
- AUX 1 VOL 50% 3.___Check Landing Lights (Both if applicable)
- AUX 1 MUTE NO
- AUX 2 SQLCH 30% 4.___Check Wig Wag Function
- AUX 2 VOL 50%
- AUX 2 MUTE NO iS Engine Group
- PILOT RT NO
1.___Check Master Relay Switch grounds out wire going to master relay
SOFTKEY SETUP 2.___Check Key switch connects HIC connector start pins
-1 USER LISTS 3.___Check spar pin light comes on when spar pin switches are not grounded.
-2 TUNE EMERGENCY
4.___Check emergency switch provides power to Power X3 connector Pin 3
DISCRETE SETUP 5.___Check Emergency Li Bat Warn Wire turns on warning in EFIS when grounded. (NOTE Check this error)
-1 FREQ SWAP 6.___Check fuel pump A and B switches for function
-2 DISABLED

LIGHTING SOURCE 14V

GTR 200 PRESET NOTES:

- ALL SETTINGS NOT DEFINED BY THIS DRAWING
ARE ACCEPTABLE AS CONFIGURED FROM
MANUFACTURER.
- THE ABOVE SETTINGS CORRESPOND TO
SOFTWARE SYS 2.60.

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

ELECTRICAL SYSTEM
DATE DRAWN: 06/11/18
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 1 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

PFD

ANTENNA
XPNDR
GDU 460

1P4X02

5
36

36
SIGNAL GROUND R7214 22 3 GRN

BNC
MONO OUT AUDIO HI

1
WHT
R7183 WHT COM RADIO

19 18

19 18
MONO OUT AUDIO LO WHT/BLU

BLK
STEREO AUDIO OUT RIGHT
STEREO AUDIO OUT LEFT
3

40
STEREO AUDIO OUT LO
2

RG-58/U
33 50 17 49 16 32 15 31 43 10 27 28 45 46 37 47 48 14 30 29 13 40 41 24

33 50 17 49 16 32 15 31 43 10 27 28 45 46 37 47 48 14 30 29 13 40 41 24
(GPS UNUSED) RS-232 IN 5 WHT
R7254 WHT COM RADIO
(GPS UNUSED) RS-232 OUT 5 WHT/BLU

TQ-7244
(ELT) RS-232 OUT 4 TP7171 WHT ELT
(ADS-B) RS-232 OUT 3 WHT
TQ7169 WHT GDL 5XR ADS-B
(ADS-B) RS-232 IN 3 WHT/BLU

(GMC 307) RS-232 OUT 2

(GMC 307) RS-232 IN 2
(GSU 25) RS-232 OUT 1 WHT
F7166 WHT GSU 25 ADAHRS

BNC
(GSU 25) RS-232 IN 1 WHT/BLU

SIGNAL GND F7207 22 3 GRN

XPNDR
CAN BUS HI WHT GTX 35R
F7178 2C:22S 21 WHT GPS 20A
CAN BUS LO WHT/BLU WHT/BLU
WH-00134-1

ES-00019

CAN BUS TERMINATION F7179 22 2 WHT/BLU

CONNECT
SIGNAL GROUND TO
CDU SYSTEM ID PROGRAM* 1 F7208 22 2.5 WHT BACKSHELL

14V LIGHTING BUS HI L7048 22 27 PRP/YEL LIGHTING BUS SPLITPOINT

AIRCRAFT POWER 2 P7209 RED
BACKUP BATTERY
POWER GROUND

ES 31890 (#8)
P7210 BLK

AIRCRAFT POWER 1 F7075 RED

ES-00192 (MALE)
POWER MODULE

5
POWER GROUND F7076 BLK

CONFIG MODULE GROUND GND

1

011-00979-22 22 2.5 BLK

CONFIG MODULE POWER VCC

4

011-00979-22 22 2.5 RED

SHLD

(325-00238-01 SUPPLIED IN
CONFIG MODULE DATA DATA
3

011-00979-22 22 2.5 YEL

RECEPTACLE

24 45

24 45
CONNECTOR KIT)
GND BLK BLK USB GROUND
ES-00059

TYPE B
CONFIG MODULE CLOCK CLK
2

011-00979-22 22 2.5 WHT

USB
D- WHT WHT USB DATA LO
CONFIG MODULE + HARNESS
011-00979-22
D+ USB DATA HI

2
GRN GRN

44

44
VBUS RED RED USB VBUS POWER

EFIS BATTERY

TCW
TCW IBBS-12V-3AH

5
10 11 12 13 14 15

10 11 12 13 14 15
POWER OUTPUT P7154 18 85 RED SPLIT POINT 4
POWER OUTPUT P7209 18 30 RED PFD
POWER OUTPUT P7146 18 29 RED EMS

WH-00134-1
POWER OUTPUT P7175 18 22 RED GPS 20A
GROUND P7210 18 32 BLK PFD (POWER GROUND PIN 15)

GROUND P7212 18 2.5 BLK P7211 18 13 BLK

ES-00019

GROUND

9
P7213 18 15 BLK

WH-00134-1
POWER + PASS THRU INPUT

8
31

31
RS-232 IN 1 POWER + PASS THRU INPUT

7
WHT/BLU
GSU 25 F7165 WHT
RS-232 OUT 1 POWER + PASS THRU INPUT

6
ES 36154 (#10) ES 36154 (#10)

9
WHT

29

29
GPS 20A RS-232 IN 3 POWER + IN, CHARGE, SENSE POWER MODULE

5
TQ7176 22S 22 WHT WHT P7227 18 27 RED

4
21 42

21 42
AIRCRAFT POWER 1 LOW VOLT WARN

3
TQ7106 22 3 RED

ES-00061 (FEMALE)
AIRCRAFT POWER 1 BATTERY INFO EMS (Voltage 2)

2
TQ7104 RED TQ7108 22 3 RED P7141 22 30 WHT
ES-00019
ENABLE-BACKUP SWITCH EFIS BATTERY SWITCH

1
P7223 22 30 WHT
POWER MODULE

38 59

38 59
TQ7107 22 3 BLK POWER CONFIG
TQ7105 BLK TQ7109 22 3 BLK POWER CONTROL
MFD ES-00019

41 20

41 20
TQ7110 22 3 BLK POWER GROUND
GDU 460
2P4X02

POWER GND
5

TQ7111 22 5 BLK
29 13 45 46 15 31 16 32

29 13 45 46 15 31 16 32

AIRCRAFT POWER 1 F7087 RED

POWER MODULE
POWER GROUND F7088 BLK

AIRCRAFT POWER 2
WHT
POWER GROUND F7187 WHT COM RADIO
WHT/BLU
CAN BUS HI F7225 22 2 WHT WHT

P3251
ES-00019 F7271 WHT GMC 507 (AP MODULE)
WH-00134-1

CAN BUS LO F7226 22 2 WHT/BLU WHT/BLU

ES-00019
(ADS-B) RS-232 OUT 3 WHT
TQ7580 WHT GDL 5XR ADS-B/FIS-B/XM WEATHER
(ADS-B) RS-232 IN 3 WHT/BLU
ES-00059
43

43

14V LIGHTING BUS HI L7045 22 2 PRP/YEL LIGHTING BUS SPLITPOINT

USE GARMIN BACKSHELL

14401 NE KEIL RD. NE
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

ELECTRICAL SYSTEM
DATE DRAWN: 6/11/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 2 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

PILOT STICK GRIP CO-PILOT STICK GRIP

(PITCH TRIM DOWN) (PITCH TRIM DOWN)

1
C7117 RED R-AL 22 RED C7115 RED R-AL 22 RED
POWER MODULE (PITCH TRIM UP) POWER MODULE (PITCH TRIM UP)

2
C7118 GRN R-AL 22 GRN C7116 GRN R-AL 22 GRN

(AP DISC) (AP DISC)

AP DISCONNECT SPLITPOINT AP DISCONNECT BUTTON

3
C7127 22 5 BLU R-AL 22 BLU C7257 BLU R-AL 22 BLU

(FREQ FLOP) (FREQ FLOP)

RAY ALLEN G405

RAY ALLEN G405

COM RADIO COM RADIO

4
R7181 ORN R-AL 22 ORN R7180 ORN R-AL 22 ORN

WH-00134-1

WH-00134-1
(PTT) (PTT)
PILOT HEADSET JACKS CO-PILOT HEADSET JACKS

5
R7193 WHT/BRN R-AL 22 WHT R7192 BRN R-AL 22 WHT

(GND) (GND)

6
L7203 22 4 BLK R-AL 22 BLK L7201 22 4 BLK R-AL 22 BLK

LEFT WING CONNECTOR RIGHT WING CONNECTOR

7
L7204 BLK L7202 BLK

ES-00321 (FEMALE)

ES-00321 (FEMALE)
ES-00140 (MALE)

ES-00140 (MALE)
ES 36154 (#10) ES 36154 (#10)

8
9

9
5

5
LEFT WING CONNECTOR RIGHT WING CONNECTOR
PILOT CONTROL STICK CO-PILOT CONTROL STICK

RIGHT LEFT
WING WING

POWER POWER
MODULE MODULE
L7095
L7204

L7097

L7090

L7089

L7098

L7202

L7092

L7091
18
W7205
18

18

18

18

18

18
22

22
L7093

L7097

L7094

L7098

L7096
72
105

105
14

14

55

55
72

72

WHT/YEL
WHT/GRN

WHT/GRN

WHT/YEL
BRN/YEL

YEL/RED

YEL/RED
YEL/BLU

YEL/BLU
GRN

GRN
BLK

BLK
YEL

YEL
11 11

1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
ES-00077 WH-00134-1 ES-00078 WH-00134-1

ES-00078 WH-00032 ES-00077 WH-00033

1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8
11 11

B6312
L7514

WHT/ORN

WHT/ORN
W216

W218

WHT/BLU

WHT/BLU
B216

B214

B213
L214

L213

WHT

WHT
WHT

GRN
RED

RED
BLK

BLK
BLU

YEL

YEL
WING GND WING GND
L6310 GRN B6310 GRN
ES 31890 (#8) ES 31890 (#8)

B6310
L6310
WING GND

WING GND
ES 31890 (#8)

ES 31890 (#8)
3061056 3062055 3061056 3062055
WHT

WHT
L211 BLK 1 1 L211 BLK 1 1
ES 31890 (#8) ES 31890 (#8)

STALL WARN
WHT 2 2 WHT 2 2
MICRO WHT/BLU 3 3 WHT/BLU 3 3
WING

WING
SWITCH
TIP

TIP
WHT/ORN 4 4 WHT/ORN 4 4
5 5 5 5
GRN

GRN
RED

RED
BLK

BLK
YEL

YEL
W217 BLK
11 11 11 11
ES DV18-188-M
ES 31890 (#8)
6
6
6
6

6
6
6
6
L6309 BLK

L6309 BLK
22
22
22
22

22
22
22
22
ES 36152 (#6) ES 36152 (#6)
AEROLEDS PULSAR EXP AEROLEDS PULSAR EXP
3061055

3061056

3061055

3061056
ES 31890 (#8) ES 31890 (#8)
L215 BLK 1 1 BLK L215 BLK 1 1 BLK

2 2 GRN NAV STROBE POS 2 2 GRN NAV STROBE POS

LANDING

LANDING
3 3 BLU 3 3 BLU

4 4 YEL 4 4 YEL

5 5 RED 5 5 RED

6 6 6 6
5 5 5 5

THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE
WH-00134-1. SEE WH-00032 AND WH-00033 RV-12iS WING HARNESS DRAWINGS. WH-00134-1. SEE WH-00032 AND WH-00033 RV-12iS WING HARNESS DRAWINGS.

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

ELECTRICAL SYSTEM
DATE DRAWN: 6/11/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 3 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

USE GARMIN BACKSHELL

USE TRIG BACKSHELL

COM-RADIO -
1.
2.
TRIG TY-96 USED FOR INTERNATIONAL AVIONICS KIT ONLY
COVER UNUSED PINS WITH HEAT SHRINK AND SECURE TO COM RADIO - CO-PILOT HEADSET JACKS
HARNESS NEAR TY96 CONNECTOR
TRIG TY96 GTR 200B (HPHN R)

(HPHN L)
WHT/ORN

R7188 WHT WHT CO-PILOT HEADPHONE

(HPHN LO)
WHT/BLU
5

5
COM RADIO

27 21
X (MIC)
WHT
ID1 STRAP LO (PTT)
R7189 WHT WHT/ORN CO-PILOT MIC

BACKSHELL
ID1 STRAP INPUT

GARMIN
(MIC LO)
WHT/BLU
*TX INTERLOCK OUT

4
CO-PILOT STICK R7192 22 76 BRN
*TX INTERLOCK IN

5
AUDIO POWER FOR LEMO (IF INSTALLED)

22
R7180 22 47 ORN CO-PILOT STICK *DISCRETE INPUT 2 R7180 22 47 ORN CO-PILOT STICK POWER MODULE RZ7112 ORN/BLK
ES-00019 ES-00019 COVER WIRE END WITH HEAT SHRINK IF NOT USED
21

FREQ FLIP FLOP PILOT STICK TRIG BACKSHELL *DISCRETE INPUT 1 PILOT STICK

2
R7182 22 7 ORN R7181 22 47 ORN R7182 22 7 ORN R7181 22 47 ORN

MUSIC GND
4

WHT/BLU
R7183 2C:22S 34 WHT PFD (MONO OUT)

28
15 16

MUSIC 1 IN RT R7255 22 2 WHT WHT AUX 2 AUDIO IN LO WHT/BLU

R7183 2C:22S 34 WHT PFD (MONO OUT)
MUSIC 1 IN LEFT AUX 2 AUDIO IN HI

9
R7256 22 2 WHT WHT

PILOT HEADSET JACKS

37 18 19
MUSIC 1 IN LEFT WHT/BLU

THESE WIRES WILL MUSIC 1 IN RT WHT/ORN R7184 3C:22S 120 WHT GDL 52R
NEED TO BE ADDED MUSIC 1 IN LO WHT
(HPHN R)
WHT/ORN

(HPHN L)

WHT
R7190 WHT WHT PILOT HEADPHONE
(HPHN LO)
F7151 WHT GEA 24 (EMS) WHT/BLU
WHT/BLU
GND CAN HI COM RADIO
9

7
RZ6318 20 3 BLK F7185 22 2 WHT WHT
ES-00019 F7187 2C:22S 32 WHT GDU 465 (MFD)
(MIC)
22

INTERCOM KEY (GND FOR VOX) CAN LO

6
RZ6317 22 3 BLK F7186 22 2 WHT/BLU WHT/BLU WHT
ES-00019
(PTT)
R7191 WHT WHT/ORN PILOT MIC
LIGHTING BUS INPUT LIGHTING BUS SPLITPOINT LIGHTING BUS LIGHTING BUS SPLITPOINT
8

3
L7046 22 10 PRP/YEL L7046 22 10 PRP/YEL
(MIC LO)
WHT/BLU

PILOT STICK R7193 22 76 WHT/BRN

12 11

24 23
RS-232 OUT WHT RS-232 OUT WHT
AUDIO POWER FOR LEMO (IF INSTALLED)
R7254 2C:22S 34 WHT PFD (RS-232 PORT 5) R7254 2C:22S 34 WHT PFD (RS-232 PORT 5) POWER MODULE RZ7113 ORN/BLK
RS-232 IN RS-232 IN COVER WIRE END WITH HEAT SHRINK IF NOT USED

WH-00134-1
WHT/BLU WHT/BLU
WH-00138

(HPHN R) (HPHN R)

30 12 11
CO-PILOT HEADSET RT CO-PILOT HEADSET RT
6

WHT/BLU WHT/BLU

(HPHN L) CO-PILOT (HPHN L) CO-PILOT

CO-PILOT HEADSET LFT CO-PILOT HEADSET LFT
5

WHT R7188 3C:22S 62 WHT WHT R7188 3C:22S 62 WHT

HEADSET JACKS HEADSET JACKS
(HPHN LO) (HPHN LO) OPTIONAL AUDIO OUTPUT
WHT/ORN CO-PILOT HEADSET LO WHT/ORN
GRIP RZ6322 22 30 BRN COMPONENTS NOT INCLUDED WITH HARNESS
GRIP
(MIC) RZ6322 22 30 BRN SWITCH (MIC) RZ6323 22 30 BLK SWITCH PANEL PTT INSTALL ON CO-PILOT SIDE OF AIRCRAFT
W/ BOOT PANEL
24 19

34 15 16
W/ BOOT
CO-PILOT MIC HI WHT RZ6323 22 30 BLK CO-PILOT MIC HI WHT
(PTT) PTT (PHN GND)
WHT/BLU
CO-PILOT (PTT) CO-PILOT
*PTT COPILOT WHT/ORN R7189 3C:22S 62 WHT *PTT COPILOT WHT/ORN R7189 3C:22S 62 WHT
HEADPHONE
HEADSET JACKS HEADSET JACKS (HPHN L)
WHT JACK
(MIC LO) (MIC LO)
WHT/BLU CO-PILOT MIC LO WHT/BLU
(HPHN R)
1/4
WHT/ORN

(HPHN R) (HPHN R)

33 14 13
PILOT HEADSET RT PILOT HEADSET RT
3

WHT/BLU WHT/BLU RZ7194 22 6 WHT

RZ7195 22 6 WHT
(HPHN L) PILOT (HPHN L) PILOT
PILOT HEADSET LFT PILOT HEADSET LFT
2

WHT R7190 3C:22S 62 WHT WHT R7190 3C:22S 62 WHT

HEADSET JACKS HEADSET JACKS
(HPHN LO) (HPHN LO)
WHT/ORN PILOT HEADSET LO WHT/ORN

OPTIONAL
(MIC) (MIC)
23 18

26 25 10 29 36 35 17
PILOT MIC HI WHT PILOT MIC HI WHT AUXILIARY AUDIO
OUTPUT JACK
(PTT) PILOT (PTT) PILOT (FOR VIDEO CAMERA) ES RS 274-249
*PTT PILOT WHT/ORN R7191 3C:22S 62 WHT *PTT PILOT WHT/ORN R7191 3C:22S 62 WHT
STEREO JACK
HEADSET JACKS HEADSET JACKS
(MIC LO) (MIC LO) 47K ohm
WHT/BLU PILOT MIC LO WHT/BLU
10

RECEIVER AUDIO OUT LO

9
47K ohm
RECEIVER AUDIO OUT HI
CAN TERM B
CAN TERM A

OPTIONAL LEMO JACK

13 17

AIRCRAFT GND AIRCRAFT POWER

1
R7099 18 27 BLK R7099 18 27 RED
FOR PRODUCTION OF "WH-00134-1 LEMO". ADD JACKS TO BOTH PILOT AND CO-PILOT LOCATIONS.
THE LEMO JACK SHOULD BE INSTALLED INLINE WITH AND 1 INCH BEHIND THE MIC/HEADPHONE JACKS.

20
AIRCRAFT POWER R7100 18 27 RED AIRCRAFT GND R7100 18 27 BLK
ES-00060 (FEMALE)

ES-00057 (FEMALE)
POWER MODULE
POWER MODULE R7192 BRN
32 31
(STALL WARN) AUX 1 AUDIO IN LO
(MIC GND)
WHT/BLU
14

(STALL WARN) AUX 1 AUDIO IN HI W7103 22S 27 WHT (STALL WARN) AUX 1 AUDIO IN HI W7103 WHT
(PTT)
R7189 WHT WHT/ORN MIC
(MIC)
WHT

BNC TQ-7245 RG-58/U 85 BLK AV-00008

COM AV-00008 (PHN GND)
BNC TQ-7245 RG-58/U 86 BLK WHT/BLU
ANTENNA COM
ANTENNA (HPHN L)
R7188 WHT WHT HEADPHONE
(HPHN R)
WHT/ORN

AUDIO PWR

1
RZ7112 ORN/BLK .25

AUDIO GND

2
RZ7196 22 6 WHT X
LEMO JACK
HEADPHONE (L) 6 1

3
RZ7197 22 6 WHT X
5 2
HEADPHONE (R)

4
RZ7198 22 6 WHT X 4 3

MIC

5
RZ7199 22 6 WHT X

MIC GND

6
RZ7200 22 6 WHT X

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

ELECTRICAL SYSTEM
DATE DRAWN: 6/11/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 4 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

AUTOPILOT R0 SEE PAGE 1

PITCH SERVO
GARMIN GSA 28
WHT
GMC 507 (AP MODULE) TRIM MOTOR

ES-00061
C7274 2C:22S 72 WHT

5
WHT/BLU
CAN BUS HI

1
F7236 22 2 WHT WHT
ES-00019 F7083 WHT AP ROLL SERVO
CAN BUS LO

2
F7237 22 2 WHT/BLU WHT/BLU
ES-00019

CAN TERM 1

3
(PTRIM SERVO POS) GND

1
WHT/ORN ORN 5.5 26
CAN TERM 2

4
PTRIM SERVO POSITION

2
WHT/GRN GRN 5.5 26
ID STRAP 1

5
C7131 22 3 WHT
(TRIM SRVO) 5V EFIS POWER

3
WHT/BLU BLU 5.5 26
POWER

WH-P30-1
ID STRAP 2

6
WH-P30-1 WHT
ES 36154 (#10) MODULE
ID STRAP 3 PTRIM SERVO PWR R

4
7

7
C7232 18 12 BLK WHT WHT 5.5 26

WH-00134-1
ID STRAP 4 PTRIM SERVO PWR E

5
BLK BLK 5.5 26
ES-00019

ES-205203-3 (FEMALE)
AIRCRAFT GROUND AP ROLL SERVO
9

9
C7132 18 3 BLK C7129 RED

6
15 14 13 12 11 10

15 14 13 12 11 10
AIRCRAFT POWER C7133 18 10 RED C7054 RED

7
ES-00019

ES-00140 (MALE)
TRIM IN 1 C7122 WHT

8
TRIM IN 2 C7123 WHT/BLK POWER MODULE

9
C7233 22 3 GRN
TRIM OUT 1 WHT

5
C7043 WHT
TRIM OUT 2 WHT/BLU

AP DISCONNECT C7126 22 18 BLU AP DISCONNECT SPLIT POINT

THESE COMPONENTS NOT INCLUDED IN AVIONICS KIT, NOR PART OF THE WH-00136
AUTOPILOT
ROLL SERVO WHT

GARMIN GSA 28 AP PITCH SERVO AP DISCONNECT

ES-00061

F7083 2C:22S 72 WHT

5

WHT/BLU
CAN H
1

F7238 22 2 WHT WHT

ES-00019 F7084 2C:22S 27 WHT GSU 25 ADAHRS
CAN L
2

F7239 22 2 WHT/BLU WHT/BLU

ES-00019 CO-PILOT C7257 22 33 BLU
CAN TERM 1 CONTROL STICK
3

TWISTED
CAN TERM 2
4

L7033 YEL/GRN

ID STRAP 1
5

L7034 YEL/PRP
POWER
ID STRAP 2 MODULE
6

C7035 YEL
AUTOPILOT
DISCONNECT
ID STRAP 3/RS-232 OUT 1
7

C7036 GRN
WH-00134-1

ID STRAP 4/RS-232 IN 1
8

ES 36154 (#10)
AIRCRAFT GROUND
9

C7086 18 9 BLK
15 14 13 12 11 10

15 14 13 12 11 10

AIRCRAFT POWER C7129 18 72 RED AP PITCH SERVO

TRIM IN 1
TRIM IN 2
TRIM OUT 1
TRIM OUT 2
AP DISCONNECT C7128 22 70 BLU AP DISC. SPLIT POINT

AP MODULE
GMC 507

5
14 15

10 11 12 13 14 15
POWER MODULE C7059 22 31 BLK POWER GND

5
WAAS

10 11 12
POSITION MAGNETOMETER LIGHTING BUS SPLIT POINT L7047 22 18 PRP/YEL LIGHTING BUS HI
TO/GA DISCRETE IN

WH-00134-1
GMU 11 AIRCRAFT POWER 2

9
GPS 20A CAN BUS TERM 1

8
5

5
CAN BUS HI

1
WHT
GSU 25 (ADAHRS) POWER MODULE AIRCRAFT POWER 1

7
F7167 WHT C7056 RED
CAN BUS LO

2
WHT/BLU

ES-00326 (15 PIN HI DENSITY MALE)

CAN BUS TERM 2

6
UNIT ID

3
WHT/BLU

WH-00134-1
GDU 465 (MFD)

5
F7271 2C:22S 32 WHT
RESERVED

4
5

WHT
CAN BUS LO

4
WHT/BLU C7272 22 2 WHT/BLU
ES-00019
GROUND RESERVED AP PITCH SERVO
9

5
F7062 BLK C7274 WHT
POWER MODULE CAN BUS HI

3
WHT C7273 22 2 WHT
ES-00019
AIRCRAFT PWR 1 SIGNAL GROUND
7

6
F7063 RED F7168 22 3 GRN

ES-205203-3 FEMALE

2
BACKUP BATTERY AIRCRAFT PWR 2 AIRCRAFT POWER 1

7
F7175
8

RED F7155 RED

WH-00134-1

1
RS-232 GROUND SPLIT POINT 4 AIRCRAFT POWER 2
6

8
F7177 22 3 GRN F7157 RED

GTX 35R
TQ7176 RS-232 OUT 1 POWER GROUND
5

9
WHT F7156 BLK
(TRANSPONDER)
RS-232 IN 1
4

4
ES-205203-3 (FEMALE)

WHT GA 36
GDU 460 (PFD) BNC TQ7242 RG-400 42 CABLE TNC WAAS GPS
RS-232 OUT 2
3

F7178 WHT
ANTENNA
WHT/BLU
CAN HI
1

WHT F7152 22 2 WHT

GEA 24 (EMS) F7150 WHT ES-00019

CAN LO
2

WHT/BLU F7153 22 2 WHT/BLU

ES-00019
GA 37
WAAS GPS AND
TNC

XM ANTENNA
(OPTIONAL)

USE SUPPLIED CAN

TERMINATOR

GDL 52R TNC TQ7243 RG-400

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

ELECTRICAL SYSTEM
DATE DRAWN: 6/11/2018
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 5 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

POWER OUTLET SPLIT POINT 5 SPLIT POINT 1

TP7064 RED
USB DUAL PANEL JACK
ELT SPAR PIN SWITCH JUMPER WIRE W6075 22 204 BRN/BLU SPAR PIN SWITCH RIGHT
TP7065 BLK
POWER P6057 RED
MODULE ES 421-0108
ES 36154 (#10) ES-00019 EMS W7069 BRN/BLU
C6286 WHT 8 16 F7061 RED TQ7067 RED
ES 421-0108 POWER MODULE ES-00019 ADS-B IN (GDL 5XR)
F7060 BLK TQ7066 BLK

SPAR PIN SWITCH LEFT

GA 37 XM ANTENNA
C6286
LIGHTING BUS
BLK
FLAP MOTOR

ANTENNA
ADS-B
7
18
SPLIT

TNC
GDU 465 (MFD) L7045 PRP/YEL

BNC

INCLUDED WITH, BUT NOT BUNDLED TO HARNESS

FLAP
SWITCH COM RADIO L7046 PRP/YEL
C6287 BLK 3 18
6X ES 421-0108

CABLE

CABLE
2 4 ES-00019
GMC 507 (AP MODULE) L7047 PRP/YEL L7044 PRP/YEL POWER MODULE
POWER
MODULE
C6235 RED 1
C C

3 GDU 460 (PFD) L7048 PRP/YEL SPLIT POINT 4

135
MOM

32
K2AGPAAAAA

RG-400

RG-400
ES-00019
C6288 RED 3 18 F7079 RED F7155 18 70 RED
POWER MODULE ES-00019
F7080 BLK F7156 18 70 BLK GMU 11 MAGNETOMETER

WH-00137
BACKUP BATTERY

TQ7243
P7154 RED F7157 18 70 RED

BLK 23 18 FLAP PWR - F7158 18 10 RED

RED 23 18 FLAP PWR + AUTOPILOT DISC. F7159 18 10 BLK GSU 25 ADAHRS

BNC

TNC
(FLAP POS) GND
SPLIT POINT
BLU BLU 23 18 F7160 18 10 RED
ES 421-0108 ES 421-0107
EMS C7145 WHT ORN YEL 23 18 FLAP POSITION
ES 421-0108 ES 421-0107
WHT WHT 23 18 (FLAP POS) 5V EFIS POWER C7128 BLU AP ROLL SERVO
ES 421-0108 ES 421-0107 ES-00019

FLAP POSITION SENSOR POWER MODULE C7247 BLU C7127 BLU PILOT CONTROL STICK
ES-FA-PO-150-12-2
FLAP MOTOR
C7126 BLU AP PITCH SERVO ADS-B IN GDL 5XR

ADAHRS

10

10
TQ7067 22 32 RED AIRCRAFT POWER
SPLITPOINT 5
GROUND

9
TQ7066 22 32 BLK
P252

WH-00136
GSU 25
5
14

14

12 14 13 15

12 14 13 15
GROUND F7161 22 3 GRN WHT/ORN MUSIC OUT RIGHT
12V MAGNETOMETER POWER
EFIS BATTERY SWITCH GTR200 STEREO IN MUSIC OUT LEFT
6

WHT R7184 WHT

MAGNETOMETER GROUND STEREO AUDIO OUT LO

7

OTTO K1AABAAAAA WHT/BLU

ES-00061 (FEMALE)
13 12 15

13 12 15

RS-232 OUT 2 MASTER RELAY P7250 22 30 BLK 2 R7579 22 3 GRN SIGNAL GROUND
RS-485 A EFIS BATTERY P7223 WHT C
TX B (DATA OUT)

5
WHT/BLU
AIRFRAME GROUND MFD (ADS-B/XM WEATHER RS232 DATA)
WH-00134-1

P7251 22 14 BLK 1 TQ7580 2C:22S 140 WHT

RS-485 B ES 36154 (#10) RX B (DATA IN)

6
WHT

OAT POWER OAT PROBE (GTP 59) TX A (DATA OUT)

1

7
GRMN WHT WHT/BLU

ES-421-0108 PFD (ADS-B/XM WEATHER RS232 DATA) TQ7169 2C:22S 140 WHT
OAT HIGH RX A (DATA IN)
2

8
GRMN WHT/BLU GRMN 3C:22S 78 WHT WHT
3 PLACES
OAT LOW
3

GRMN WHT/ORN

RS-232 OUT 3
9

WHT/BLU
ES-00061

F7165 2C:22S 120 WHT XPNDR

10

10

RS-232 IN 3 WHT
P251

AIRCRAFT POWER 1
7

F7158 RED

ELT REMOTE POWER GROUND SPLIT POINT 4

6

F7159 BLK

AIRCRAFT POWER 2
8

F7160 RED
WH-00107

POWER GROUND
9

AV-00013
E-04.5
RS-232 OUT 1
5

WHT/BLU
PFD
RS-232 IN 1
F7166 2C:22S 127 WHT

912iS MAINT
4

WHT

CAN BUS HI
1

F7234 22 2 WHT WHT

PORT
ES-205203-3

ES-00019 F7084 WHT AP ROLL SERVO

CAN BUS LO
2

F7235 22 2 WHT/BLU WHT/BLU

ES-RJ11 ES-00019 WHT
TAB FACING DOWN F7167 2C:22S 81 WHT GMU 11 (MAGNETOMETER)

ES-00324 FEMALE
WHT/BLU

1
2
WHT/BLU

CABIN LIGHT & DIMMER

3
F7172

4 WH-00134-1
WH-00144 HIC CONNECTOR

5
(ES-00338 & LC ECL-02) E6023 2C:22S 23 WHT
MODULE
PHONE CABLE

RED

SPAR PIN

6
PINNED STRAIGHT THROUGH LUG REMOVED

POWER MODULE

7
L6028 YEL/PRP L7269 22 2 RED WHT

SWITCHES ES-00141 ES-00338

8
108

BLK
GPS RX ES-00141

9
L7270
INSTALLED
RIGHT LC ECL-02

ELT ES DV18-188-M BY

22
SPLIT POINT 1 W6075 BRN/BLU BUILDER OPTIONAL KIT INSTALLED BY BUILDER. NOT INCLUDED
ES E22-50K
IN AVIONICS KIT, NOR PART OF THE WH-00134-1

6
F6262 22 4 BLK
ES 31880 (#4)
ES DV18-188-M

BLK
14401 NE KEIL RD. NE
CANOPY SWITCH
INCLUDED WITH, BUT NOT BUNDLED TO HARNESS
ES-RJ11
TAB FACING DOWN AV-E-04
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA
PWR
1

1 TP7064 22 10 RED INCLUDED WITH, BUT NOT BUNDLED TO HARNESS INCLUDED WITH, BUT NOT BUNDLED TO HARNESS
ES 31880 (#4)
ES 31890 (#8) ES DV18-188-M
Q6300 22 27 BLK FUEL TANK SENDER GROUND
TEST TX SPLIT POINT 5 F6035 22 3 BLK ES E22-50K
ROTAX 912iS G3X
2

1 TP7259 22 5 WHT
1 2
W7069 BRN/BLU
E-04.7
ES E22-50K EMS F7139 22 175 WHT
SPLIT POINT 1 ES DV18-188-M
GND
ES DV18-188-M
ELECTRICAL SYSTEM
3

4 3 1 TP7065 22 10 BLK W6075 BRN/BLU

DATE DRAWN: 6/11/2018

LEFT INSTALLED BY
GPS RX PFD (ELT RS-232 OUT)
4

1 TP7171 22S 118 WHT

BUILDER CANOPY LATCH
ELT DIN PLUG
MICRO DRAWN BY: T. DE MAN
INCHES WH-00134-2
SWITCH TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 6 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

EMS
GEA 24

16 11 23 13 25
EGT 1 HI
LEFT
EGT 1 LO
EGT 2 HI
RIGHT
EGT 2 LO
CHT 1 +
LEFT
CHT 1 -

4
14
CHT 2 +
RIGHT
CHT 2 -
2

P244

5
28 40 41 42 43 19 17 33

28 40 41 42 43 19 17 33
CAN 2 LO (ROTAX FADEC) WHT/BLU
E7013 WHT HIC CONNECTOR MODULE
CAN 2 HI (ROTAX FADEC) WHT

POS 1 C7249 ORN POWER MODULE (PTRIM SERVO POS)

1N4148
DISCRETE 4 (EARTH X ERROR) W7144 WHT EARTH X BATTERY FAULT
DISCRETE 3 (CANOPY LATCH) CANOPY LATCH IGNITION MODULE
WH-00134-1

F7139 WHT W7070 22 22 BRN/BLU

DISCRETE 2 SPAR PINS) W7068 22 7 BRN/BLU

1N4148

1N4148
W7069 22 114 BRN/BLU SPLIT POINT 1 (LEFT SPAR PIN SWITCH) FUEL SENDER
DISCRETE 1 (STALL) W7114 BRN/YEL POWER MODULE
VOLTAGE 2 P7141 22 27 WHT BACKUP BATT (BATT INFO)
ES 36154 (#10)
CO DETECTOR
FUEL LEVEL 1 FUEL SENDER EMS
6

Q7142 22 137 BRN/ORN Q7142 ORN/BRN

ES-00019 OR
ES-00141 D7262 22 3 GRN D7261 & D7265
AITHRE SHIELD EX CO DETECTOR

ES-00140 (MALE)
25 11 12 15 31 32

25 11 12 15 31 32

POS 5 LO / GP 5 / GND D7263 22 3 BLK WHT/BLU BUNDLED WITH EMS WHT/RED 1 1 RED 5V POWER
SPAR PIN SWITCH Q6300 BLK IE F-385B SENSOR WIRING
POS 5 / GP 5 (O2 PRESSURE) WHT/GRN ES 421-0108 FUEL SENDER WHT 2 2 WHT CO SIGNAL OUT
RANGE
POS 4 / GP 4 (SPO2) WHT/ORN D7261 5C:22S 15 WHT CO DETECTOR 250 OHM - 40 OHM EMS D7261 WHT WHT/ORN 3 3 BLU SPO2 SIGNAL OUT (EX 3.0)

ES-00321 (FEMALE WITH CLINCH NUTS)

POS 3 / GP 3 (CO DETECTOR) WHT WHT/GRN 4 4 YEL O2 PRESSURE SIGNAL OUT (EX 3.0)

POS 3 HI / +5V WHT/RED WHT/BLU D7264 22 3 BLK 5 5 BLK GROUND

ES-00059

ES-00019 OR
(MAIN BATTERY) VOLTAGE 1 E7052 22 7 PRP ES 31890 (#8) ES-00141 6 6
D7265 22 3 BLK
7 7
8 8
9 9
P243

OPTIONAL KIT INSTALLED BY BUILDER. NOT INCLUDED

5

ES-00019 IN AVIONICS KIT, NOR PART OF THE WH-00134-1

35 34 37 36

35 34 37 36

SHUNT 1 LO E7051 22 7 PRP E7050 22 32 PRP

POWER MODULE (ALTERNATOR AMPS)
SHUNT 1 HI E7049 22 39 GRN

SHUNT 2 (BATTERY) LO E7252 22 39 PRP

POWER MODULE (BATTERY AMPS)
SHUNT 2 (BATTERY) HI E7253 22 39 GRN

FUEL PRESSURE
SENSOR
WH-00134-1

FUEL PRESS TRANSDUCER 12V

3

Fuel Pressure
23

23

FUEL FLOW (P244 PIN 36) PACKARD Kavlico P500-75-A-E4C

12065287 1/8-27 NPT
FUEL PRESSURE GROUND
1

BLU BLU KVLCO 3 BLK

ES-00019 75 PSI ABSOLUTE
FUEL PRESSURE FUEL PRESSURE SENSOR EMS
2

ORN Q7143 3C:22 132 WHT Q7143 WHT ORN KVLCO 3 GRN
ES-00019
ES-00019
FUEL PRESSURE POWER 5V
4

P7120 22 3 WHT WHT WHT KVLCO 3 RED

ES-00019
29 28 32 15

29 28 32 15

MANIFOLD PRESSURE PWR 5V P7119 22 3 WHT C7248 WHT POWER MODULE

OIL TEMP LO
GP7 LO BLU
ES-00057

FLAP POSITION SENSOR

GP7 HI ORN C7145 3C:22 58 WHT
(FLAP MOTOR)
WHT
P241

AIRCRAFT POWER 2 BACKUP BATTERY

8

P7146 RED

AIRCRAFT POWER 1 POWER MODULE

7

E7077 RED
WH-00134-1

POWER GROUND POWER MODULE

6

E7078 BLK

POWER GROUND
9

9
ES-205203-3

CAN BUS HI
1

F7148 22 2 WHT WHT

ES-00019 F7150 2C:22S 24 WHT GPS 20A
CAN BUS LO
2

F7149 22 2 WHT/BLU WHT/BLU

ES-00019 WHT
F7151 2C:22S 30 WHT GTR 200 (COM)
WHT/BLU

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

DATE DRAWN: 6/11/2018
ELECTRICAL SYSTEM
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 7 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1
AV-60000 POWER MODULE iS-ULS PCB V3.4
4X SCREW TERMINALS
ES-00169
ES-35107 (#6) R07

I OUT
STARTER SOLENOID BATTERY

I IN
K7125 WHT 30 SHUNT 4X ES-00191

47 46 37 38

47 46 37 38
AMPS A AMPS B

SCREW TERMINAL 1A 5 BATT AMPS BUS E7253 GRN

BACKUP BATTERY P7227 RED Keystone 8197-2 RED 1A EMS (BATT AMPS)
5 BATT AMPS BAT E7252 PRP
1A
5 GEN AMPS BUS E7049 GRN
1A EMS (ALTERNATOR AMPS)
5 GEN AMPS ENGINE E7050 PRP
ES-35107 (#6)
AMPS A AMPS B

I OUT
FUSE BOX GENERATOR (X3 PIN 3 )

I IN
K7124 10 60 WHT 30 SHUNT

SCREW TERMINAL ES-00169

35

35
R06 5 POWER OUTLET P6057 18 45 RED POWER OUTLET

BACKUP POWER

LANDING LIGHT
NAV & STROBE
Keystone 8197-5 BLUE

START / TRIM

PWR OUTLET
GENERATOR
22,000 µF

AUTO PILOT

GPS / ADSB
NAV / COM
+
25V

FLAP

COM
EFIS
7.5A

7.5A

7.5A

7.5A
30A

30A

ELT
10A
5A

5A

5A

3A

3A
(912ULS ONLY)

34

34
5 AUTOPILOT C7054 18 73 RED AP PITCH SERVO

40

40
320568 ES-35107 (#6) 5 FLAPS C6235 18 45 RED FLAP MOTOR
FIREWALL AIRFRAME GROUND K7562 10 18 WHT AIRCRAFT GND 30

SCREW TERMINAL

20 36

20 36
Keystone 8197-3 BLACK
5 TRIM C7056 22 38 RED
ES-00019 AP MODULE
K1ABBPCADA K2ABN(PP)CCFA
5 GND C7057 18 7 BLK C7059 BLK
SPST K2ABN(PP)CCFA DPDT
F7060 22 80 BLK
DPDT
SPLIT POINT 5

41

41
ES-35107 (#6) AVIONICS
SWITCH
NAV & STROBE
SWITCH
LANDING/PULSE
SWITCH
5 GPS/ADSB/ELT F7058 18 7 RED F7061 22 80 RED
BACKUP BATT SWITCH EMS BACKUP BATT POWER
BACKUP
K7126 12 6 WHT 30 ES-00019
2 4 2 4 2 4
SCREW TERMINAL
K7572 22 6 WHT/RED ES-00019
Keystone 8197-7 YELLOW C C C C C

19 45

19 45
5 EFIS (PFD) F7073 18 7 RED F7075 18 42 RED F7062 22 30 BLK

BATTERY
7 7
1 3 1 3 1 3 ES-00019 PFD GPS 20A
5 GND F7074 18 7 BLK F7076 18 42 BLK F7063 22 30 RED

E7077 18 42 RED
SWITCH

18 44

18 44
5 EFIS (MFD) F7087 18 45 RED GEA 24 (EMS)
MFD E7078 18 42 BLK
5 GND F7088 18 45 BLK
F7079 18 90 RED
SPLIT POINT 4 COVER EXPOSED CONTACTS
LANDING LIGHT PULSE LEFT WITH HEATSHRINK

3
5 L7089 YEL F7080 18 90 BLK
LEFT WING (7 PLACES)
LANDING LIGHT LEFT

5
5 L7090 YEL/BLU

ARDUINO VOLTAGE BACKUP

BATTERY SWITCH
TRIM, STALL WARNING, DIMMER REGULATION K2AAJNEADA
DPST
(REAR VIEW)

11

11
5 LNDING LIGHT PULSE RIGHT L7091 YEL
ARDUINO NANO RIGHT WING
POWER MODULE K7572 WHT/RED
ES-MFR-25-1-1K
5
KA7808ERTM YELLOW TERMINAL
ATMEGA328P LANDING LIGHT RIGHT 1K OHM

9
5 L7092 YEL/BLU 640905-1
8V

MICRO-CONTROLLER +12V INPUT

V IN V OUT +8V REGULATED

12

12
POWER

GND
POWER
5 NAV L7093 18 72 YEL/RED LEFT WING
5V - 16MHz JUMPER WIRE K7573 22 4 WHT/RED 5
640905-1

13

13
5 NAV L7094 18 55 YEL/RED RIGHT WING

50 PIN POWER MODULE

4X AMP
640907-1
POWER MODULE 8

15

15
5 STROBE L7095 18 72 WHT/YEL LEFT WING K7126 WHT EMS BACKUP BATT POWER 20 4 2
YELLOW TERMINAL
C C

14

14
5 STROBE L7096 18 55 WHT/YEL RIGHT WING K7028 WHT BACKUP POWER (X3 PIN 1 ) 20 3 1
7

FUSE BOX
K6282 WHT FUSE BOX REG A GND 20

32 16
5 COM (GTR200)
K6283 WHT FUSE BOX AIRCRAFT GND 20

32
5 COM (AUDIO POWER) R7099 RED
IC07 COM RADIO
N-CNL
VDD FLT 10K OHM
GND POWER MODULE COCKPIT LTS PWM -

1
MOSFET
5 R7100 BLK L7029 YEL/GRN 5
D R09
G AMP
BRK CS 640903-1
ARDUINO PTRIM -
1

C7122 22 72 WHT 5
S

17

17
PITCH AP SERVO (TRIM IN) SLP POLOLU
VMM 5 COM (XPNDR) TQ7104 18 27 RED
9 PIN PITCH TRIM

ARDUINO PTRIM + XPNDR

2

C7123 22 72 WHT/BLK 5 10K OHM

DRV8801 R08
DIR OUT+ GND

2
5 TQ7105 18 27 BLK
X
3

5 ES-00019
S CO-PILOT HEADSET JACKS (ONLY CONNECT IF

33

33
PWM OUT- IC05 5 COM (AUDIO POWER) RZ7260 22 2 ORN/BLK RZ7112 22 54 ORN/BLK
P-CNL THE OPTIONAL LEMO HEADSET JACKS ARE INSTALLED)
AP MODULE PTRIM -
9

WHT 5 G MOSFET
WH-P30-1

GND GND D PILOT HEADSET JACKS (ONLY CONNECT IF THE

AP MODULE PTRIM+
6

WHT/BLK 5 RZ7113 22 71 ORN/BLK

WH-00134-1
OPTIONAL LEMO HEADSET JACKS ARE INSTALLED)
IC02
TRIM MOTOR X
4

C7121 5C:22 219 WHT 5

48 49

48 49
5 COM (NAV)
GND
5

WHT/ORN 5
5 COM (NAV)
PSERVO POS
8

WHT/GRN 5

5V EFIS EMS POWER LEFT WING CONNECTOR

7

WHT/BLU 5 1N4148 W7205 22 65 BRN/YEL

MALE)

ES-00032
5

ES-00019

22 39

22 39
5 STALL WARN SWITCH W7206 22 3 BRN/YEL W7114 22 39 BRN/YEL EMS
D13 D12 D1
5 STALL WARN AUDIO W7103 22S 25 WHT COM RADIO
BUILDER POPULATES THESE PINS 3V3 D11~ R01

D10~ 10K OHM

REF

31 30

31 30
R02 5 CO-PILOT P-TRIM IN DOWN C7115 22 60 RED
A0 D9~ CO-PILOT CONTROL STICK
10K OHM 5 CO-PILOT P-TRIM IN UP C7116 22 60 GRN
A1 D8 R03

10K OHM
A2 D7

42 43

42 43
5 PILOT P-TRIM IN DOWN C7117 22 60 RED
A3 D6~ PILOT CONTROL STICK
5 PILOT P-TRIM IN UP C7118 22 60 GRN
A4 D5~ C7247 22 48 BLU AP DISCONNECT SPLIT POINT
A5 D4 R05

23

23
5 AP DCONN SWITCH C7042 22 7 YEL C7035 22 23 YEL
D3~ 5K OHM ES-00019
A6
AP DCONN SWITCH GND

7
5 C7036 22 30 GRN
A7 D2 ES-00019 AP DISCONNECT

29

29

TWISTED
5 COCKPIT LIGHTS + L7041 22 2 YEL/PRP L7034 22 27 YEL/PRP
5V GND ES-00019
COCKPIT LIGHTS PWM -

4
5 L7040 22 2 YEL/GRN L7033 22 27 YEL/GRN
RST RST
IC03
N-CNL
GND RX0 MOSFET
L6028 22 146 YEL/PRP CABIN LIGHT
D
G
VIN TX1
S
L7029 22 9 YEL/GRN BACKUP BATTERY SWITCH

IC04
L7030 22 42 YEL/GRN IGNITION MODULE

21

21
IC01 P-CHNL
5 FUSED START POWER K7228 22 3 ORN K7072 22 32 ORN HIC CONNECTOR MODULE
MOSFET
S
ES-00019 LEFT/RIGHT CPU FANS
LED PWM +PWR FUEL PUMP SWITCHES

6
5 L7019 22 9 PRP/GRN K6297 22 37 ORN
K6298 22 37 ORN
G
3 D 2X ES SA-1017
TRIM SPEED POT 10 K OHM
(FEMALE D-SUB CONTACT)
1K OHM

25

25
2 Bourns Inc. 3386F-1-102TLF R04
5 DIM REF LVL L7044 22 17 PRP/YEL LIGHTING BUS SPLITPOINT
1
.22 µF
DIM POTENTIOMETER LEG

8
VR01 C01 5 L7039 22 12 WHT
3
DIMMER POT

5K OHM
26 24

26 24
5 DIM POTENTIOMETER WIPER L7038 22 12 WHT
2 ES-00195
1
5 DIM POTENTIOMETER LEG L7037 22 12 WHT

50 10

50 10
5 AP MODULE PTRIM - WHT
PITCH AP SERVO
C7043 2C:22S 71 WHT
(TRIM OUTPUTS) 14401 NE KEIL RD. NE
5 AP MODULE PTRIM + WHT/BLU

VAN'S AIRCRAFT, INC. AURORA, OR

97002 USA

ROTAX 912iS G3X

27 28

27 28
5 5V EFIS EMS POWER C7248 22 39 WHT
EMS

ES-00059 (FEMALE)
5 PSERVO POS C7249 22 39 ORN

DATE DRAWN: 6/11/2018

ELECTRICAL SYSTEM

5
UNITS:
DRAWN BY: TONY KIRK
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 8 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

ES-60009-2 HIC CONNECTOR MODULE iS PCB V3.5 IC03

N-CNL
MOSFET
S
RGB LED
ES-FM-Z2727RGBA-SH
Diagnostic LED Color Codes when Installed in Aircraft G
========================================== D IC01
EXPECTED PRE-START CONDITION R P-CNL
SBB & FSP & Batt Bus Power (all high) = WHITE MOSFET
-------------------------------------------------------------------------- R6 D
EXPECTED POST-START CONDITION - After ~60 seconds G 365 OHM
with Engine Running & SBB "Start Computer" Timed Out
R2
FUEL PUMP SWITCHES

23
R3

ES-796859-8
FSP & Batt Bus Power (no SBB) = YELLOW 10K OHM G
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ B 365 OHM 20 START POWER POS 2 8 K7023 12 50 WHT EMS FUSE BOX X3 CONNECTOR PIN 2
POSSIBLE PRE-START FAULT COLOR CODES S
FSP Only (no SBB & no Batt Bus Power) = Red R4
SBB Only (no FSP & no Batt Bus Power) = Blue 62 OHM 20 START POWER POS 1 7 K7022 12 50 WHT EMS FUSE BOX X3 CONNECTOR PIN 3
FUEL PUMP 1 FUEL PUMP 2
Batt Bus Power Only (no SBB & no FSP) = Green SWITCH SWITCH
FSP & Batt Bus Power Only (no SBB) = Yellow S
20 START POWER GND 3 6 K6257 12 38 WHT EMS FUSE BOX REG A GND K1ABBPCADA K1ABBPCADA
SBB & Batt Bus Power (no FSP) = Teal SPST SPST
FSP + SBB (no Batt Bus Power) = Magenta
*************************************************************** R5 G 20 START POWER GND 4 5 K6256 12 38 WHT EMS FUSE BOX AIRFRAME GND

WH-00134-1
SWITCH SWITCH
Batt Bus Power = +12v from X3 Connector Pin3 1K OHM D (REAR VIEW) (REAR VIEW)
FSP = Fused Start Power, +12v from DB25 Pin 6 & 7 R1 IC02
10K OHM N-CNL
SBB = Start Button Bypass, +5v from DB25 Pin 3 4 2 4 2
MOSFET
640907-1
F7014 WHT 10 C C
10 SIG FUEL PUMP 1 4 F7014 14 32 WHT 3 1 3 1
FUEL PUMP 1 SWITCH 640903-1
10 GND FUEL PUMP 1 3 F7015 14 32 WHT L7018 22 4 WHT 5

HIC CONNECTOR 640907-1

10 SIG FUEL PUMP 2 2 F7016 14 32 WHT F7015 WHT 10
HIC CONNECTOR A FUEL PUMP 2 SWITCH MODULE
19428-0015 OR 19428-0031 10 GND FUEL PUMP 2 1 F7017 14 32 WHT 640907-1
ES-60013

F7016 WHT 10
1 LANE SEL SW A 1 18

640905-1
2 SUPP WARN LAMP A 18 L7258 22 4 WHT 5
640907-1
3 SIG FUEL PUMP 1 18 F7017 WHT 10

4 CAN GND 1 A 18
640903-1
POWER MODULE L7019 PRP/GRN 5
5 CAN LO 1 A CAN LO 912IS EMS

2
18 5 WHT/BLU
E7013 2C:22S 33 WHT GEA 24 (EMS) LED PWM +PWR
640903-1
WH-00124

6 CAN HI 1 A CAN HI 912IS EMS

1
18 5 WHT L7020 22 4 PRP/GRN 5

7 LANE SEL SW A 2 18

8 WARN LAMP A 18

9 GND FUEL PUMP 1 18

10 CAN GND 2 A 18

15 14
11 CAN LO 2 A 18 5 CAN LO 912IS MAINT WHT
E6023 WHT 912iS MAINT PORT
12 CAN HI 2 A 18 5 CAN HI 912IS MAINT WHT/BLU

HIC CONNECTOR B
19428-0016 OR 19428-0032
ES-60014

11 10
1 LANE SEL SW B 1 18 5 GND E7241 22 3 GRN

2 SUPP WARN LAMP B 18 5 GND

3 SIG FUEL PUMP 2 GND

5
18 5

4 CONN STARTER RELAY SW 18

5 X 18
FUSED START POWER POWER MODULE

6
5 K7072 ORN
6 CAN GND 1 B

WH-00134-1
18

7 CAN LO 1 B 18
WH-00124

FUSED START POWER

7
5 K7574 ORN
8 CAN HI 1 B 18

13
5 CONN STARTER RELAY SW K7011 22 35 WHT/RED
9 LANE SEL SW B 2 18
START BUTTON BYPASS

3
5 K7010 22 35 GRN/RED
10 WARN LAMP B 18

12
5 SUPP START SWITCH K7009 22 35 RED
11 GND FUEL PUMP 2 18
GND

4
5 K7008 22 35 BLK
12 SUPP START SWITCH 18

18 19 16 17 24 25 22 23
5 LANE SEL SW B 1 K7000 22 35 WHT
13 X 18
5 LANE SEL SW B 1 K7000 22 35 WHT
14 CAN GND 2 B 18
5 LANE SEL SW B 2 K7001 22 35 WHT/BLK
15 CAN LO 2 B 18
5 LANE SEL SW B 2 K7001 22 35 WHT/BLK
16 CAN HI 2 B 18 IGNITION MODULE
5 LANE SEL SW A 1 K7002 22 35 YEL

5 LANE SEL SW A 1 K7002 22 35 YEL

5 LANE SEL SW A 2 K7003 22 35 WHT/YEL

5 LANE SEL SW A 2 K7003 22 35 WHT/YEL

SUPP WARN LAMP B

21 9
5 K7004 22 35 BLU

5 WARN LAMP B K7005 22 35 WHT/BLU

SUPP WARN LAMP A

8
5 K7006 22 35 GRN

20
5 WARN LAMP A K7007 22 35 WHT/GRN

ES-205208-1 (MALE)

5
14401 NE KEIL RD. NE
VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

DATE DRAWN: 6/11/2018
ELECTRICAL SYSTEM
UNITS:
DRAWN BY: TONY KIRK
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 9 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

AV-60007 (ROTAX 912iS)

IGNITION & START MODULE
PCB ES-60007-V3.1

LANE A LANE B
SWITCH SWITCH
K1ABBPCADA K1ABBPCADA
SPST SPST

2 4 2 4

C C

ARDUINO VOLTAGE 1 3 1 3

REGULATION LANE SEL SW B 1

1
5 K7000 WHT

22 21 18 17 16 15 14
KA7808ERTM
MASTER
5 LANE SEL SW B 1 K7000 WHT
+8V REGULATED 8V +12V INPUT SWITCH
POWER POWER

V OUT V IN
K2ABHPCABA
DPST
5 LANE SEL SW B 2 K7001 WHT/BLK

GND 5 LANE SEL SW B 2 K7001 WHT/BLK

C C
7 5 LANE SEL SW A 1 K7002 YEL
1 3
5 LANE SEL SW A 1 K7002 YEL

5 LANE SEL SW A 2 K7003 WHT/YEL

5 LANE SEL SW A 2 K7003 WHT/YEL

D13 D12

3V3 D11~

REF D10~
10K

R4

A0 D9~
LANE B
WARN LAMP B HIC CONNECTOR MODULE

5
A1 D8 WARN LAMP 5 K7005 WHT/BLU
LANE A
A2 D7 WARN LAMP 1K OHM
R5
5K

SUPP WARN LAMP B

4
A3~ D6 5 K7004 BLU
A4
R2
D5

SUPP WARN LAMP A

6
A5~ D4
1K OHM 5 K7006 GRN
A6~ D3

10K

R3
R1

19
A7 D2 5 WARN LAMP A K7007 WHT/GRN
5V GND

RST RST

GND RX0

12 20 23 11 24
VIN TX1 5 MASTER RELAY K7021 22 31 WHT/ORN MASTER RELAY

WH-00134-1
IC01
ARDUINO NANO SPAR PIN
5 GND
WARNING LIGHT
OVERRIDE BUTTON
LP3F1G121R
5 GND K7008 BLK

5 CONN STARTER RELAY SW K7011 WHT/RED

10K

R7

DPDT 5A 5 SUPP START SWITCH K7009 RED

RELAY
V23079A1003B301 HIC CONNECTOR MODULE
START BUTTON BYPASS

8
5 K7010 GRN/RED
R6
5K

N.O.
1 C
2
8 - N.C. +
KEY MOM
START SWITCH
JD 7510A

25
5 FUSED START POWER K7574 22 32 ORN HIC CONNECTOR MODULE
1N4148
ES-00032
COCKPIT LIGHTS PWM - POWER MODULE

3
5 K7030 YEL/GRN

13
5 SPAR PINS W7070 BRN/BLU EMS

ES-00060 (FEMALE)

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

DATE DRAWN: 6/11/2018
ELECTRICAL SYSTEM
UNITS:
DRAWN BY: TONY KIRK
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 10 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL

 REVISIONS
REV DESCRIPTION DATE APPROVED

R0 SEE PAGE 1

CYL 2 CYL 1

CYL 4 CYL 3

GENERATOR STARTER
K7028 12 60 WHT BACKUP BATTERY SWITCH ES 324082 (1/4) ES 324043 (#10)
P151 8 10

P158
ES 324043 (#10)
K7023 WHT

8
HIC CONNECTOR MODULE

8.5
K7022 WHT

3X ES 324082 (1/4)
K7124 WHT POWER MODULE
1 2 3 POWER MODULE K7125 10 44 WHT

ROTAX
POWER X3 STARTER
POWER X1 POWER X2 FUSE BOX CONNECTOR SOLENOID

P154
LANE A LANE B 206037-2 MASTER
RELAY

8
ES 24115

7.5
ES 324044 (5/16) ES 324044 (5/16)
ES 324082 (1/4)

ES 36154 (#10)
P150 8 10

GENERATOR B RING TERM #10 (10-12 AWG)

ES-35109
ES DIODE
BRAKE RES. MASTER
GENERATOR A K6284 12 20 WHT
MOUNT SCREW
K7021 WHT/ORN IGNITION MODULE
ES-35110 (1/4)
ES ETX900
EARTH-X BATTERY P7250 WHT EFIS BATTERY SWITCH
BACKUP BATTERY SWITCH K6282 12 48 WHT K6283 12 48 WHT BACKUP BATTERY SWITCH
ES-35108 (#8) ES-35110 (1/4)
ROTAX 912iS FUSE BOX ES 421-0108 ES 421-0107
HIC CONNECTOR MODULE K6257 WHT K6256 WHT HIC CONNECTOR MODULE
ES-35108 (#8) ES-35110 (1/4) W7144 WHT EMS

P149 8 5.5

ES 324082 (1/4) ES 324043 (#10)

FUEL PUMP POWER

FUEL
PUMP 2
FUEL PUMP 2 (AUXILIARY)
Q7564 14 105 WHT

Q7565 14 105 WHT

TWISTED PAIR (2 PLACES)

Power Wire: A
Ground Wire: B
FUEL PUMP 1 Q7566 14 105 WHT

Q7567 14 105 WHT

DELPHI ASSEM: FUEL DELPHI ASSEM

1X 15339016 (HOUSING) PUMP 1 1x 12162017 (HOUSING)
2X 15344866-L (CONTACTS) (MAIN) 2x 12048086 (SEAL)
2X 15324973 (SEALS) 2x 12048074 (CONTACTS) -L for single min. order

14401 NE KEIL RD. NE

VAN'S AIRCRAFT, INC. AURORA, OR
97002 USA

ROTAX 912iS G3X

DATE DRAWN: 6/11/2018
ELECTRICAL SYSTEM
UNITS:
DRAWN BY: T. DE MAN
INCHES WH-00134-2
TOLERANCES: NONE
(UNLESS OTHERWISE SPECIFIED) SCALE: NONE PAGE: 11 OF 11

PATH\FILENAME: Q:\Components\Electrical\Wiring Harness\WH-00134\Electrical System 912iS G3X (WH-00134-2).DWG C-SIZE ORIGINAL