This handbock refers to the compete range of control panels availabfe from Lig LED Battery Chndfti~nIndicaior

Electronics Ltd.
Providing similar infarmation to ihg panel meter the red httery Im LED .sset to
THE CONTROL PANEL: come on when the bsttery voltage is below 11 volts, above Lb the green w If glow.
Provides switched anb?or fused outlets each with their own clearly marke5 function. Ammelsr
Those marked auxiliary allow for a choice of equipment to be connected during -
installation. (Pebr to manufacturers instructims far aliocatfoo). Theammeter measuresthe amountof curwntdrawil bythesystematanyonetime it
does nolshc~whow much current is being wed by the battery for charging.
Thessitchesand fuses isolateand protect their allocated 12Vaccessoriesand allow you
to choose the equipment you wish to use at any one time. NB. The currentdrawn by thecaravans accessortes should mtexceedthe maximum
rated output of the battery charger or power supply.
CARCARAVAN BATTERY SWITCH
Water Level Meter
Battery power ;electim is sourwd viathe carhravan batterychangeoverswlch. Use of
the car battery to power the internal accessorjes will provide longer periods between The water tank contents can be seen at any one time by pushing the button marked
charging. careshould however be taken not toflatten !he car battery so far as t3 disable it read. The tanks probe assembly will be m t in such a way that when the meter reads
from slarting [he engine. Canwrsely lhisswi6h will allow you to he independentof ihe emply there *ill enough water in reserve to use prtor ta the next fill.
car by using the auxiliary baftsry only.
Each time thetank is filled an adjustment czn be madeto txtmpensaie for ciffering
12V UNlOFF MASTER SWITCH water conditionsi.e. acidity, sofinesa. This c m bedone by hclding in :he push button
for a short length of time whilst ths tank is full, and setting the needle with the
This issometimes incorporated in the centre position of the cartcaravan banery switch calibrationscrew marked se:, to fuil.The caC bratior screw should not be.allered as
and serves to isolate the on board accessories and the control panel. the water level reduces.
PANEL METER, INDlCATORS
Many d the cmtrol panels contain either one or all three of the following meters: WATER PUMP RUNMING INDICATOR
Battery CondiFian Water Level The pump running LED will glow wheneverthe water pump is in cperalionwhetheror not
Wafkl {Fraction) the system contains water. It prowid- a warning should the pump be running when the
water syslem is empty. This is usually ori!y associated with pressudsed systems.

FUSES
Most pands are fitled with easy access fuseholders either removable by ?and or with the
aid of a suitable tool. The fuse caps are soft and $add no1 he over tightened when
replaced.
Thefusesusedar?1,25"glass qukk blow.If afuse blows the causeshwldbe investigated
and repairedpriorlo replzcemenl. Only fusesof the samesize,vabeand ratingshould be
fitted. All other circuits w IIcontinue to function correctlr,in the event of afault with any
one fuse.
1. Battery Candltbn Meter (Applies to L.f .a. Indicatorselso)
CARVER CASCADE INDICATORS
Ths statecf the battery is conslantly monltosed and show-ion the batteryindicator.
The indicator is provided as a gui-leto show the battery requirescharging or if the Somemr,trol panetscontainLEDindicatorsto sh~wthe aperationof the Carver Cascade
battery is fully charged and the chargershould be switched off. A true reading is only system. This is anfy a repeater system, and the rnanu'actuwrr; handbook shautd be
available when all the accessories are switched off and the batlery is not being referred to for the correcl operatbn of the water heater.
charged. The indicator may flicker as accessori~sare switched an and off this is
normal as the voltage difkrs as accessories are used. WASTETANK INDICATORS
The waste tank ~LI!
indicsl~rs
will glow when thetank is iull. It is mommended that the
Th3 batlerlr should not bea!Ionedlofall below 11volts and if sornust bcharged. A - . float assembly fie fEKeb say onequarter of the tanks depth Tram the to3 sr, thzt if the
baltery is fufly charged at approximately '4 volts. injicator glows the waste system can stil be used prlor to emptying.
 GUARANTEE
Zig Products are fully guaranteed fora periodof 1year from the d a t of
~ first prchass
against fau[ty workmmship or materials.
I
Zig Electronics Lidwill repah any such ttemsfree of charge providedthey havebeen
installed and used in emordance witn our irstructions.
In the event of a fault the product should be returned to the plam of purchase for
repair or replacementunder tCle terms of this guarante. -
This guarantee does not in any way affect your stetufory rights under the Sale of
3 s 1979.
- 3 ~ ~Act,

WARNING: This document is copyright, it may not be reproduced

in any form, copied, or in any way retrieved for any purpclse
whatsoever-exceptwith the written consent DI the publishers. The
manufacturersreservethe right toalter this pub[icationat any time.

COPYRIGHT, Zig Electronics Ltd. 1994

CONTROL PANEL HANDBOOK

(REFERS TO ALL ZIG CONTROL PANELS)