Power Electronics I
Lecture 2: Switches
Dr.-Ing. Moustafa Adly
Senior Automotive Development Engineer – Volkswagen AG
Senior Member – IEEE
Associate Editor – IET
 Thyristor                                                         Triggering
Thyristor triggering (turning ON):
    1) Forward voltage triggering
    2) Gate triggering
                           𝑑𝑣
    3) Voltage gradient         triggering
                           𝑑𝑡
    4) Light triggering (light/photons-activated,
       based on electron-hole pair generation in
       the pn-junctions)
    5) Temperature triggering (expensive &
       harmful)
  Dr.-Ing. Moustafa Adly                     Power Electronics I                2
 Thyristor                                                           Triggering
Thyristor triggering (turning ON):
1) Forward voltage triggering
    When 𝑉𝐴𝐾 exceeds the forward
    breakdown voltage 𝑉𝐵0 (avalanche
    breakdown). The conduction of current
    continues even if 𝑉𝐴𝐾 reduces below 𝑉𝐵0
    till thyristor current gets below the
    holding current. The gate current is not
    needed in this case.
    This technique has faster switching
    effect (than gate triggering) but is
    harmful for the device.
  Dr.-Ing. Moustafa Adly                       Power Electronics I                3
 Thyristor                                                          Triggering
Thyristor triggering (turning ON):
2) Gate triggering
    Turning ON the thyristor through controlling
    the gate current 𝑖𝐺 . This technique is reliable
    and efficient. In this technique, a positive
    gate voltage is applied (not permanently).
    The gate signal can be DC (disadvantage is
    power loss), AC, or pulse (short or long single
    pulse or train of pulses).
  Dr.-Ing. Moustafa Adly                      Power Electronics I                4
 Thyristor                                                         Triggering
Thyristor triggering (turning ON):
                           𝒅𝒗
3) Voltage gradient             triggering
                           𝒅𝒕
    When SCR is forward biased, J1 and J3
    are forward biased and J2 is reversed
    biased. So J2 behaves as an insulator
    between two conducting plates (junction
    capacitor). Increasing the rate of change
    of forward voltage (not magnitude), J2
    breaks and starts conducting. High
    values of changing current may damage
    the SCR. Therefore, this technique may
    destruct the device.
  Dr.-Ing. Moustafa Adly                     Power Electronics I                5
 Thyristor                                                      Commutation
Thyristor commutation (turning OFF):
   Thyristor cannot be turned off by applying
   negative gate current. In all commutation
   techniques, a reverse voltage is applied
   across the thyristor during the turn OFF
   process. There are two methods by which a
   thyristor can be turned OFF.
   1) Natural commutation
   2) Forced commutation
 Dr.-Ing. Moustafa Adly                   Power Electronics I             6
 Thyristor                                                       Commutation
Thyristor commutation (turning OFF):
1) Natural commutation
  No external circuit is required for this
  purpose. Natural commutation occurs when
  the current flowing in the thyristor circuit
  gets naturally below the holding current (as
  in traditional AC circuits).
2) Forced commutation
  An external “commutation circuit” is required
  to force the thyristor current to decrease
  below the holding current. This is intended to
  handle DC circuits with current always over
  the holding current.
 Dr.-Ing. Moustafa Adly                    Power Electronics I             7
 Thyristor Family                                                 Triac & GTO
Triac
  The Triac is composed of two back-to-back
  thyristors (therefore bidirectional) with one
  gate. Accordingly, the current can flow though
  it in both directions (as in AC circuits).
Gate Turn Off Thyristor (GTO)
  GTO behaves like a normal thyristor but is
  fully controlled. It can be turned on through
  positive gate current. Moreover, it can be
  turned off through a reverse gate current.
  However, turning off is difficult as it needs
  very large reverse gate current
   So far “Semi-controlled switches”
 Dr.-Ing. Moustafa Adly                     Power Electronics I                 8
 Fully-Controlled Switches                                      BJT-Transistor
Power NPN Transistor
  It is formed of 3 layers (n-p-n) and thus two
  junctions and has three terminals. The base
  current 𝐼𝐵 controls its operation and must be
  permanently available (non-latching switch as
  it turns off with zero 𝐼𝐵 ). Commonly used in
  the past, replaced by IGBTs and MOSFETs.
  ON-state: 𝒗𝑪𝑬 > 𝟎 & 𝒊𝑩 > 𝟎
  OFF-state: 𝒊𝑩 < 𝟎
 Dr.-Ing. Moustafa Adly                   Power Electronics I                9
 Fully-Controlled Switches                                        BJT-Transistor
                                                                     Quasi-saturation
I-V Characteristics                                  Saturation
                                                                                 Active region
      Operation region         Characteristics
                                                                                         Higher
     Cut-off region (𝑖𝐵 = 0)   Transistor is OFF
     Active region (𝑖𝐵 > 0)    Current amplifier
   Quasi-saturation region     Intermediate stage                    Cut-off region
  Saturation region (𝑖𝐵 > 0)     Power switch
  Dr.-Ing. Moustafa Adly                  Power Electronics I                           10
 Fully-Controlled Switches                                             MOSFET
                                                                  N-Channel MOSFET
MOSFET Transistor
  MOSFET is characterized by: ease of control through the
  gate, optimality for low-voltage operation at high
  switching frequencies, but on-state resistance is a concern
  at higher voltage ratings. It is controlled by the gate
  voltage 𝑣𝐺𝑆 in a non-latching form.
  Applying a positive voltage (higher than threshold) at the
  gate attracts the electrons of the p-region and creates an
  electrons channel between the two n-regions. Thus, it
  allows for current flow.
  ON-state:
  𝒗𝑮𝑺 > 𝒗𝑻𝒉 to build the channel & 𝒗𝑫𝑺 > 𝟎 to get 𝒊𝑫 > 𝟎
  OFF-state:
  𝒗𝑮𝑺 < 𝒗𝑻𝒉 so no channel and thus 𝒊𝑫 ≅ 𝟎
 Dr.-Ing. Moustafa Adly                     Power Electronics I                      11
 Fully-Controlled Switches                                                 MOSFET
                                                            Ohmic region
I-V Characteristics
                                                                                       Active region
       Operation region                  Characteristics
    Cut-off region (𝑣𝐺𝑆 < 𝑣𝑇ℎ )          MOSFET is OFF
                                                                                                  Higher
                                    Voltage controlled current
    Active region (𝑣𝐺𝑆 > 𝑣𝑇ℎ )
                                              source
                                   Power switch with a resistive
       Linear/ohmic region
                                  effect between drain and source           Cut-off region
           (𝑣𝐺𝑆 > 𝑣𝑇ℎ )
                                              (losses)
   So far “Fully-controllable switches”
  Dr.-Ing. Moustafa Adly                    Power Electronics I                              12
 Power Losses
Types of power losses in power electronic devices
      Loss type                             Discription                     Relevance / Comment
  Switching loss           During turning the switch ON and OFF            High (dominant)
  Conduction loss          During the conduction period                    High (dominant)
  Blocking loss            During the forward or reverse blocking states   Low
  Driving loss             Loss in the control circuit                     Negligible
  Leads loss               Loss in the terminals of the device             Negligible
  Dr.-Ing. Moustafa Adly                          Power Electronics I                             13
Power Losses                                   MOSFET
Dr.-Ing. Moustafa Adly   Power Electronics I            14
Power Losses                                                                                               BJT
                  Linear approximation
Turning on time          Conduction time         Turning off time   Blocking time                    𝑡𝑂𝑁
                                                                                    Duty cycle 𝐷 =    𝑇
                               1
             Periodic time =        : 𝑓𝑠 switching frequency
                               𝑓𝑠
Dr.-Ing. Moustafa Adly                                    Power Electronics I                                    15
Power Losses                                           Switching loss
Instantaneous power loss
during turning on
Energy loss during turning on
Instantaneous power loss
during turning off
Energy loss during turning off
Total energy loss during
switching
Average power loss during
switching
Dr.-Ing. Moustafa Adly           Power Electronics I               16
Power Losses                                          Cond. / Blocking Loss
Instantaneous power loss
during conduction
Energy loss during conduction
Average power loss during
conduction
Instantaneous power loss
during blocking
Total energy loss during
blocking
Average power loss during
blocking
Dr.-Ing. Moustafa Adly          Power Electronics I                   17
Power Losses                                                        Cond. / Blocking Loss
Average power loss during
conduction
Average power loss during                                                  They are all function of 𝑓𝑠 , so
blocking                                                                   which 𝑓𝑠 to use?
Average power loss during
switching
The switching frequency 𝑓𝑠 that causes 𝑷𝒔𝒘 = 𝑷𝑶𝑵 + 𝑷𝑶𝑭𝑭 (equal switching and conduction/blocking
losses) is called the corner frequency 𝒇𝒄
▪ At frequencies less than corner frequency (𝑓𝑠 < 𝑓𝑐 ),
  switching losses are less than conduction/blocking losses (𝑃𝑠𝑤 < 𝑃𝑂𝑁 + 𝑃𝑂𝐹𝐹 )
▪ At frequencies higher than corner frequency (𝑓𝑠 > 𝑓𝑐 ),
  switching losses are higher than conduction/blocking losses (𝑃𝑠𝑤 > 𝑃𝑂𝑁 + 𝑃𝑂𝐹𝐹 )
▪ Therefore, for larger device lifetime,
  it is recommended to reduce the switching losses through using (𝑓𝑠 < 𝑓𝑐 )
 Dr.-Ing. Moustafa Adly                    Power Electronics I                                      18
 Thermal Design
Power losses in the semiconductor devices must be removed to
limit temperature rise within the device. The reliability of
devices and their lifetime depend on the operating temperatures,
which should be well below their maximum allowed values. On
the other hand, letting them operate at a high temperature
decreases the cost and the size of the heat sinks required.
There are several cooling techniques, but for general-purpose
applications, circuits are often designed for cooling by
normal air convection, without the use of forced air or liquid.
Semiconductor devices come in a variety of packages (for e.g. with
heat sinks to improve heat transfer to the ambient and cool
them down), which differ in cost, ruggedness, and thermal
conduction.
  Dr.-Ing. Moustafa Adly                    Power Electronics I      19
 Thermal Design
A thermal circuit representation is employed to model
the heat flow from the device to the ambient is employed,
where 𝜃 represents the temperature in °C (as voltage in
electrical circuits), 𝑟 is the thermal resistance of the path
(junction – casing – heat sink – ambient) in °C/W, and 𝑃𝑑
is the total power loss in the device in W (switching,
conduction, and blocking)
In case of utilizing one heat sink for two devices, the
thermal circuit will have parallel paths as shown
  Dr.-Ing. Moustafa Adly                       Power Electronics I   20
Thank You
  Best wishes!