JOB CARD MPD-TASK: 200001-04

JAI - A330 AMM TASK : 24-92-00-210-804-A

24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
CARD: ZONE: 500, 600 INTERVAL:
SKILL: ACCESS: 523NB, 535AB, 575DB, 623NB, 635AB, 675DB

MECH. INSP.

** ON A/C ALL

TASK 24-92-00-210-804-A
General Visual Inspection of Elements Fitted on the Harness End Fittings from Wing Tip to Rib
39

WARNING: MAKE SURE THAT THE SAFETY DEVICES AND THE WARNING NOTICES
ARE IN POSITION BEFORE YOU START A TASK ON OR NEAR:
- THE FLIGHT CONTROLS
- THE FLIGHT CONTROL SURFACES
- THE LANDING GEAR AND THE RELATED DOORS
- COMPONENTS THAT MOVE.
MOVEMENT OF COMPONENTS CAN KILL OR CAUSE INJURY TO PERSONS
AND/OR CAN CAUSE DAMAGE TO THE EQUIPMENT.

WARNING: MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROL
SURFACES ARE CLEAR BEFORE YOU PRESSURIZE/DEPRESSURIZE A
HYDRAULIC SYSTEM. MOVEMENT OF THE FLIGHT CONTROL SURFACES
CAN BE DANGEROUS AND/OR CAUSE DAMAGE.

1. Reason for the Job

Refer to the MPD TASK: 200001-04
GENERAL VISUAL INSPECTION OF ELEMENTS FITTED ON THE FOLLOWING
HARNESSES END FITTINGS FROM WING TIP TO RIB 39:
- 7621VB, 7623VB, 7625VB, 7627VB, LH SIDE
- 7622VB, 7624VB, 7626VB, 7628VB, RH SIDE
Use this procedure to do a general visual inspection of the components installed on these
harness end fittings, from the wing tip to the rib 39:
· 7621VB, 7623VB, 7625VB, 7627VB, LH side,
· 7622VB, 7624VB, 7626VB, 7628VB, RH side.
2 Job Set-up Information
A. Fixtures, Tools, Test and Support Equipment

REFERENCE QTYDESIGNATION
No specific AR ACCESS PLATFORM 6M (20 FT)
No specific AR WARNING NOTICE(S)
(98D27803000000) 1 LOCKING TOOL-FLAP SLAT LEVER,INT. POSITION
(98D27903500000) 2 PIN-SIDE STICK LOCKING

B. Work Zones and Access Panels

ZONE/ACCESS ZONE DESCRIPTION

500 LEFT WING
JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 1 of 8
JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

ZONE/ACCESS ZONE DESCRIPTION

600 RIGHT WING
523NB, 535AB,
575DB, 623NB,
635AB, 675DB

C. Referenced Information

REFERENCE DESIGNATION
(Ref. 24-41-00-861-801-A). Energize the Aircraft Electrical Circuits from the External
Power A
(Ref. 24-41-00-861-801-A- Energize the Aircraft Electrical Circuits from the APU
01). (APU Started with APU BAT)
(Ref. 24-41-00-861-801-A- Energize the Aircraft Electrical Circuits from the External
03). Power A and B
(Ref. 24-41-00-861-801-A- Energize the Aircraft Electrical Circuits from the APU
04). (APU started with External power A)
(Ref. 24-41-00-861-801-A- Energize the Aircraft Electrical Circuits from the External
05). Power B
(Ref. 24-41-00-862-801-A). De-energize the Aircraft Electrical Circuits from the
External Power A
(Ref. 24-41-00-862-801-A- De-energize the Aircraft Electrical Circuits from the APU
01).
(Ref. 24-41-00-862-801-A- De-energize the Aircraft Electrical Circuits from the
03). External Power A and B
(Ref. 24-41-00-862-801-A- De-energize the Aircraft Electrical Circuits from the
04). External Power B
(Ref. 29-00-00-864-804-A). Put the Related Hydraulic System in the Depressurized
Configuration before Maintenance Action
(Ref. 57-37-11-000-801-A). Removal of the Winglet Access Panels
(Ref. 57-37-11-400-801-A). Installation of the Winglet Access Panels
(Ref. 57-42-37-000-801-A). Removal of the Access Panels and Covers
(Ref. 57-42-37-400-801-A). Installation of the Access Panels and Covers
(Ref. 57-52-37-000-801-A). Removal of Outer Wing Trailing Edge Panels
(Ref. 57-52-37-400-801-A). Installation of Outer Wing Trailing Edge Panels
Ref. ESPM 20-33-30
Ref. ESPM 20-53-32
Ref. ESPM 20-55-30
Access Panels and Harnesses End Fittings between the Wing Tip and the Rib 39

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 2 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

RIB1

RIB8

RIB23

RIB33

575DB
(675DB)
523NB
(623NB)

RIB39

535AB
(635AB)

F_MM_249200_6_AGNA_01_00

Figure 24-92-00-991-00600-00-B / SHEET 1/3 - Access Panels

and Harnesses End Fittings between the Wing Tip and the Rib 39
** ON A/C ALL

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 3 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

Z500 7623VB
7621VB

7013VN
7029VN
29CWA
33CWA 31QJ1A

33CWC
9CS1A

7019VN 12CS1B

9DL1A 35HF

9DL1B
7023VN
7019VN
7051VC 7055VC

7005VCA 7017VCA
7071VC
7003VCA 7013VCA

7057VN
7015VN
7059VN
29CWB
7011VN
33CWB
10CS1A
FWD 7047VN 4HF
12CS1A

7277VN
9DL1C

7059VC
7057VC

7035VCA
7033VCA
7625VB 7023VCA 7627VB
F_MM_249200_6_AGNA_02_00

Figure 24-92-00-991-00600-00-B / SHEET 2/3 - Access Panels

and Harnesses End Fittings between the Wing Tip and the Rib 39
** ON A/C ALL

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 4 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

Z600

7622VB
FWD
7624VB
34CWA

7024VN

70HF 30CWA
34CWC

7014VCA

9DL2A
9DL2B
7018VN 7012VN
7022VN 7052VC

7004VCA 7024VCA 7628VB

7006VCA 7034VCA
7036VCA
PRODUCTION

7626VB

7058VC
7062VC 7060VC
9DL2C
7278VN
12CS2B

12CS2A
7050VN
53HF
7010VN
9CS2A
34CWB
10CS2A
7096VN
31QJ2A 30CWB
7098VN
7014VN

7070VC IF INSTALLED
F_MM_249200_6_AGNA_03_00

Figure 24-92-00-991-00600-00-B / SHEET 3/3 - Access Panels

and Harnesses End Fittings between the Wing Tip and the Rib 39
** ON A/C ALL

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 5 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

3. Job Set-up
Subtask 24-92-00-861-053-A
A. Energize the aircraft electrical circuits
(Ref. AMM TASK 24-41-00-861-801) .
Subtask 24-92-00-941-053-A
B. Safety Precautions
(1) On the CAPT(F/O) side stick assy 19VU(18VU):
· install the PIN-SIDE STICK LOCKING (98D27903500000) on the CAPT and F/
O side sticks.
(2) Put a WARNING NOTICE(S) in position in the cockpit to tell persons not to
operate the flight controls.
(3) On the FLAPS control panel 114VU:
· put the LOCKING TOOL-FLAP SLAT LEVER,INT.
POSITION (98D27803000000) on the slat/flap control lever,
· put a WARNING NOTICE(S) in position on the slat/flap control lever to tell
persons not to operate the slats/flaps.
(4) Make sure that the hydraulic systems are depressurized and put them in the
maintenance configuration.
(Ref. AMM TASK 29-00-00-864-804) .
(5) On the FLT CTL control panel 241VU:
· make sure that the PRIM 1 and SEC 1 pushbutton switches are released (the
OFF/R legend of these pushbutton switches is on),
· put a WARNING NOTICE(S) in position to tell persons not to use these
pushbutton switches.
(6) On the FLT CTL section of the panel 212VU:
· make sure that the PRIM 2, PRIM 3 and SEC 2 pushbutton switches are
released (the OFF/R legend of these pushbutton switches is on),
· put a WARNING NOTICE(S) in position to tell persons not to use these
pushbutton switches.
Subtask 24-92-00-010-056-B
C. Get Access
(1) Put an ACCESS PLATFORM 6M (20 FT) in position.
(2) Remove this access panel from the left trailing edge wing:
· 575DB, (Ref. AMM TASK 57-52-37-000-801) .
(3) Remove these access panels from the left wing:
· 523NB, 535AB, (Ref. AMM TASK 57-42-37-000-801) and
(Ref. AMM TASK 57-37-11-000-801) ,
(4) Remove this access panel from the right trailing edge wing:
· 675DB, (Ref. AMM TASK 57-52-37-000-801) .
(5) Remove these access panels from the right wing:
· 623NB, 635AB, (Ref. AMM TASK 57-42-37-000-801) and
(Ref. AMM TASK 57-37-11-000-801) ,

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 6 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

4. Procedure
(Ref. Fig. Access Panels and Harnesses End Fittings between the Wing Tip and the Rib
39)
Subtask 24-92-00-210-053-A
A. General Visual Inspection of the Components Installed on the Harness End Fittings
from the Wing Tip to the Rib 39
(1) Do a general visual inspection of the components that follow:
· the bonding leads,
· the braided conduits,
· the clamps which attach the braided conduits,
· the electrical connectors at the end fittings of the braided conduits,
· the shield of the electrical connectors.
(2) Make sure there are no signs of contamination Ref. ESPM 20-55-30.
(3) Make sure that there are no signs of corrosion Ref. ESPM 20-53-32.
(4) Apply a temporary corrosion protection on the end fittings of electrical conduits
Ref. ESPM 20-33-30.
(5) Make sure that the screws are not loose or missing.
5. Close-up
Subtask 24-92-00-410-053-B
A. Close Access
(1) Make sure that the work area is clean and clear of tools and other items.
(2) Install this access panel on the left trailing edge wing:
· 575DB, (Ref. AMM TASK 57-52-37-400-801) .
(3) Install these access panels on the left wing:
· 523NB, 535AB, (Ref. AMM TASK 57-42-37-400-801) and
(Ref. AMM TASK 57-37-11-400-801) ,
(4) Install this access panel on the right trailing edge wing:
· 675DB, (Ref. AMM TASK 57-52-37-400-801) .
(5) Install these access panels on the right wing:
· 623NB, 635AB, (Ref. AMM TASK 57-42-37-400-801) and
(Ref. AMM TASK 57-37-11-400-801) ,
(6) On the CAPT(F/O) side stick assy 19VU(18VU):
· remove the PIN-SIDE STICK LOCKING (98D27903500000) from the CAPT
and F/O side sticks.
(7) On the FLAPS control panel 114VU:
· remove the LOCKING TOOL-FLAP SLAT LEVER,INT.
POSITION (98D27803000000) from the slat/flap control lever.
(8) Remove the warning notice(s).
(9) Remove the access platform(s).
Subtask 24-92-00-862-053-A
B. De-energize the aircraft electrical circuits
JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 7 of 8
JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE
 JOB CARD MPD-TASK: 200001-04
JAI - A330 AMM TASK : 24-92-00-210-804-A
24-92-00 PB 601

TITLE:
A/C Reg.: 24-92-00-210-804-A - General Visual Inspection of
VT-JWR Elements Fitted on the Harness End Fittings from W...
MECH. INSP.

(Ref. AMM TASK 24-41-00-862-801) .

*** END OF CARD ***

JCP Title: C-CHECK CERTIFICATE OF TASK / INSPECTION COMPLETION: Page 8 of 8

JCP Ref: C-CHECK DATABASE REV DATE: Apr 01/2017
CERTIFIES THAT THE TASK / INSPECTION HAS BEEN COMPLETED TO THE REQUIRED PRINT DATE: Apr 06/2017 09:19
STANDARD AND SUPPORTS THE FINAL MAINTENANCE RELEASE / CERTIFICATE OF RELEASE
TO SERVICE