UENR4825-00

SEPTEMBER 2014
Com ponent Modifier
CONN 24 48 104 64 CONN 25 Engine
RESISTOR, SENSOR, AND SOLENOID SPECIFICATIONS
61 18 58 4 8 5 Module Identifier (MID) No. 027
CID Pow er Train PART RESISTANCE
50 13 81 1 Injector Cylinder 1 CID Com ponent NO. (OHMS)
56

UENR4825-00 VOL 1 of 2
2 Injector Cylinder 2 70 Sw itch (Parking Brake)
186-9083 Parking Brake Solenoids 1 33
3 Injector Cylinder 3 127 Pressure Sensor (Transmission Oil)
4 Injector Cylinder 4 144 Backup Alarm Relay
186-9534 Parking Brake Solenoids 2 33
5 Injector Cylinder 5 168 Electrical System Voltage

(Dimensions: 48 inches x 35 inches)

6 Injector Cylinder 6 190 Engine Speed Sensor
254-3783 Main Relay/Start Relay Magnetic Sw. 53
41 8 V Dc Supply 248 Cat Data Link
74 91 Throttle Position Sensor 269 Sensor Pow er Supply
4P-5820 Secondary Steering Speed Sensor 142
90 94 Fuel Pressure Sensor 444 Magnetic Sw itch (Start Relay)
96 Fuel Level Sender 562 Caterpillar Monitoring System Control FULL - 0-3.5
138-0444 Fuel Level Sensor
68 100 Engine Oil Pressure Sensor 585 Trans. Output Speed Sensor 1 EMPTY - 92-99
102 Boost Pressure Sensor 590 Engine Control Module
193-2250 Transmission Output Speed Sensor 1 & 2 1075
110 Coolant Temp. Sensor 627 Parking Brake Oil Pressure Sensor
168 System Voltage 673 Trans. Output Speed Sensor 2
201-6617 Secondary Speed/Timing Sensor 1000 - 1200
172 Inlet Air Temp. Sensor 681 Parking Brake Solenoid 1
700 Trans. Gear Position Sensor
AD30 UAT
174 Fuel Temp. Sensor
190 Engine Speed Sensor 702 Shift Lever Position Sensor
214-2484 Primary Speed/Timing Sensor 110 - 200
Electrical System
261 Engine Timing Calibration 707 Upshift Solenoid
220-3629 Upshift/Downshift Solenoids 32.6 ± 1 Serial #:
262 5 V Dc Sensor Supply 708 Dow nshift Solenoid
267 Remote Shutdow n Inout 709 Lockup Clutch Solenoid GXR1-UP
193-8559 Lockup Clutch Solenoid 32.6 ± 1.6
268 Programmed Parameter 712 Retarder Indicator
274 Atmospheric Pressure Sensor 718 Trans. System
59 105 62 52 60 37 724 Hoist Proportioning (Raise/Eject) Solenoid Coil
6V-2197 Timing Calibration Transducer 212 - 287
275 Air Filter Restriction Sensor
296 Communication Betw een Engine Ecm & Pow er Train Ecm 725 Hoist Proportioning (Low er/Retract) Solenoid Coil
226-9622 Front/Rear Retarder Control Solenoids 10.5

36 Page,
RIGHT SIDE LEFT SIDE 342 Secondary Speed/Timimng Sensor 773 Hoist Control Position Sensor
457 Brake Oil Temp. Sensor 967 Machine Application
189-0189 Front/Rear Retarder Supply Solenoids 32.6 ± 1.6
826 Torque Convert Oil Temp. Sensor 1175 Body Position Sensor
The CID is a diagnostic code that indicates which 1227 Retarder Lever Sw itch
148-2350 Hoist Proportioning (Lower/Retract) Coil 5 ± 0.3
component is faulty. The MID is a diagnostic that 1236 Body Up/Tailgate Dow n Indicator
CONN 1 indicates which elecronic control module diagnosed 1272 Brake Accumulator Oil Pressure Sensor (Brake Application)
3E-1906 Compressor Clutch Solenoid 17.6 ± 0.6
32 35 1496 Residual Brake Oil/Stop Light Pressure Sw itch (Port 6)
1605 Front Retarder Supply Solenoid (Port S1)
257-3759 Pilot Oil Control Solenoid 31.4
1606 Rear Retarder Supply Solenoid (Port S2)
20 1607 Front Retarder Control Solenoid (Port C1)
97 102 94 257-3757 Auto. Lubrication Pilot Oil Supply Solenoid 31.4
1608 Rear Retarder Control Solenoid (Port C2)
1610 Parking Brake Solenoid 2
152-8346 Implement And Steering Solenoid 32.6 ± 1.6 Volume 1 of 2:
1640 Residual Brake Oil/Stop Light Pressure Sw itch (Port 5)
2177 Implement and Steering Solenoid Valve
239-9957 Coolant Level Sensor —40 ⁰ TO +125º
89 103 The CID is a diagnostic code that indicates w hich component is faulty. © 2012 Caterpillar, All Rights Reserved Printed in U.S.A.
The MID is a diagnostic code that indicates w hich electronic control
266-1466 Throttle Position Sensor 500Hz/72 DEG
module diagnosed the fault.
19
306-6875 Hydraulic Oil Level Sensor ~4000
Connector Location - Volume 1
22 Connector Schematic AT 25°C
39 Number Location
23 1 A-13 Harness And Wire Electrical Schematic Symbols
FAILURE MODE IDENTIFIERS (FMI)
2 F-12 Symbols
40 CONN 16
FMI
3 F-12 NO.
42 25 1 26 33 42 31 53 30 42 27 28 29 24
34 4 C-12 0 Data Valid But Above Normal Operational Range T

10 5 C-11 1 Data Valid But Below Normal Operational Range Pressure

Symbol
Temperature
Symbol
Level
Symbol
Flow
Symbol
Circuit Breaker
Symbol
6 C-11
REAR FRONT 7 C-11
2
3
Data Erratic, Intermittent, Or Incorrect
Voltage Above Normal Or Shorted To Battery
Symbols and Definitions
95 8 C-10 4 Voltage Below Normal Or Shorted Ground Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
9 B-10 5 Current Below Normal Or Open Circuit
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
10 C-9 6 Current Above Normal Or Grounded Circuit circle indicates that the component has screw terminals and a wire can be disconnected from it.

57 63 73 CONN 5 45 49 55 98 51 7 71 72 CONN 22 11 D-9 7 Mechanical System Not Responding Properly Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
43 21 12 D-9 8 Abnormal Frequency, Pulse Wodth, Or Period No circle indicates that the wire cannot be disconnected from the component.

13 E-9 9 Abnormal Update Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
LEFT REAR 14 H-9 10 Abnormal Rate Of Change
69 15 H-7 11 Failure Mode Not Identifiable
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
16 D-6 12 Bad Device Or Component
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
17 C-5 13 Out Of Calibration contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
CONN 9 18 F-5 14 Parameter Failures Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
50 19 H-5
17 15 Parameter Failures T
the gauge of the temperature or pressure.
20 H-5 16 Parameter Not Available
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
21 I-5 17 Module Not Responding It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
22 I-5 18 Sensor Supply Fault
23 E-4 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
19 Condition Not Met coil that makes an electromagnet when current flows through it. The electromagnet
24 G-3 20 Parameter Failures can open or close a valve or move a piece of metal that can do work.

25 H-2 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
The connectors shown in this chart Related Electrical Service Manuals
91 that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
are for harness to harness
Title Form Number
connectors. Connectors that join a Harness and Wire Symbols
harness to a component are Machine Electrical System RENR8534 Wire, Cable, or Harness Harness Identification Letter(s):
41 generally located at or near the Monitoring System RENR4731
Assembly Identification: Includes
Harness Identification Letters and
(A, B, C, ..., AA, AB, AC, ...)
Harness Connector Serialization Code:
Harness Connector Serialization
component. See the Component Vital Information Monitoring System (VIMS) UENR2750 Codes (see sample).
The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).
Location Chart. Payload Control System (PCS) RENR4725 AG-C4 L-C12 L-C12
111-7898 3E-5179 3E-5179
R134a Air Conditioning & Heating System SENR5664 Part Number: for Connector Plug 1
78 79 2
Part Number: for Connector Receptacle

Component Location - Volume 1 Schematic Machine Component Location - Volume 1 Schematic Machine Plug Receptacle
Pin or Socket Number
5A
99 Location Location Location Location 1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
Alarm - Backup A-14 1 Sensor - Brake Accumulator Oil Pressure C-9 54 2 sockets and the receptacle contains all pins.
325-AG135 PK-14
Alarm - Backup Relay G-9 2 Sensor - Brake Oil Temp B-13 55
70 75 86 1 Sure-Seal connector: Typical representation
of a Sure-Seal connector. The plug and receptacle
Harness identification code:
This example indicates wire group 325, Wire Gauge
CONN 6 CONN 17 CONN 12 Alarm - Hydraulic Oil Level C-7 3 Sensor - Cam Speed/Timing E-2 56 2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

Alternator I-11 4 Sensor - Coolant Level F-3 57

TOP VIEW 41 Arc Suppressor - Start Relay Magnetic Switch I-2 5 Sensor - Coolant Temperature E-3 58
Batteries I-2 6 Sensor - Crankshaft Speed /Timing E-2 59
Buffer - Fuel Level A-11 7 Sensor - Engine Oil Pressure C-7 60
Circuit Breaker - Alternator (105A) I-11 8 Sensor - Engine Speed E-3 61 SERVICE MODE
TRANS COMPARTMENT 9 88 15 6 Circuit Breaker - Main (80A) I-5 9 Sensor - Fuel Temperature E-3 62
OPERATOR SEQUENCE 0
Circuit Breakers D-14 10 Sensor - Hydraulic Oil Level D-3 63 MODULE IDENTIFIERS
CONN 11 CONN 10 CONN 13 Converter - 24V To 12V F-9 11 Sensor - Inlet Air Temperature E-3 64
HARNESS CODE 1 (MID) CHART
92 100 93 101 Ecm Mid:027 (Power Train) E-14 12 Sensor - Parking Brake Oil Pressure C-9 65
NUMERIC READOUT 2
MONITORING SYSTEM 30
LH FRONT Ecm Mid:036 (Engine) G-1 13 Sensor - Service Brake Oil Pressure G-13 66
SERVICE
TATTLETALE
3
4
ENGINE ECM 36
Flasher - Unit D-11 14 Sensor - Throttle Position F-8 67 POWER TRAIN ECM 27
CONN 8 UNITS 5
Fuse - 500A (Single Pole Battery Disconnect Sw.) I-2 15 Sensor - Torque Converter Oil Temperature H-1 68 PCS ECM 74
CALIBRATION 6
Fuse - Receptacle (12V Power Port) F-9 16 Sensor - Transmission Gear Position C-11 69 VIMS ECM 161
CONN 18 CONN 19 CONN 21 CONN 2 CONN 15 MAINTENANCE MODE 7
44 3 Horns B-3 17 Sensor - Transmission Oil Pressure C-9 70
Injectors D-3 18 Sensor - Transmission Output Speed 1 C-10 71
Lamp Panel - Indicator F-11 19 Sensor - Transmission Output Speed 2 C-10 72
Lamp Panel - Payload B-12 20 Sensor - Turbo Intake Pressure D-3 73
Light - Flood (Cab Lower) D-11 21 Sensor - Turbo Outlet Pressure D-3 74
Light - Lh (High Beam) C-4 22 Solenoid - Downshift C-10 75

CONN 24 CONN 14 Light - Lh (Low Beam) D-4 23 Solenoid - Front Retarder Control C-9 76
Light - Lh (Park/Turn) D-4 24 Solenoid - Front Retarder Supply C-9 77
Light - Lh (Rear Turn) C-14 25 Solenoid - Hoist Proportioning (Raise) B-10 78
PART NO. FUNCTION ACTUATE DEACTUATE CONTACT POSITION
Light - Lh (Rear) B-14 26 Solenoid - Hoist Proportioning (Lower) B-10 79
Front/Rear A-B NORMALLY OPEN
Light - Rh (High Beam) C-4 27 Solenoid - Implement & Steering B-9 80 230 ± 20 kPa
155-2269 Residual Brake Oil 295 kPa (43 psi) A-C NORMALLY
Light - Rh (Low Beam) C-4 28 Solenoid - Lockup Clutch I-1 81 (33 ± 3 psi)
Pressure Sw . CLOSED
CONN 20 12 Light - Rh (Park/Turn) C-4 29 Solenoid - Parking Brake 1 B-9 82
Fire Suppression
Light - Rh (Rear Turn) B-14 30 Solenoid - Parking Brake 2 B-9 83 A-B NORMALLY OPEN
84 76 85 77 3E-7808
(Foam Type)/Auto.
1100 kPa (160 psi)
860 ± 170 kPa
A-C NORMALLY
Light - Rh (Rear) B-14 31 Solenoid - Rear Retarder Control C-9 84 Lubrication Pilot Oil (125 ± 15 psi)
CLOSED
Light - Right Side B-12 32 Solenoid - Rear Retarder Supply C-9 85 Press. Sw .
83 54 CONN 23
Light (Stop/Tail) B-14 33 Solenoid - Upshift C-10 86 LOW 275 kPa (40 psi) LOW 170 ± 55 kPa
A/C Refrigerant
Module - Hydraulic Oil Level D-4 34 Suppressor Harness - Main Relay D-14 87 114-5333 HIGH (2800 ± 140 kPa (25 ± 8 psi ) 1-2 NORMALLY OPEN
Press. Sw .
Motor - Cab Pressurizer Fan D-5 35 Switch - Battery Disconnect I-1 88 406 ± 20 psi) HIGH 1750 ± 200
CONN 7 Motor - Front Window Wiper F-9 36 Switch - Battery Electrical Isolator D-8 89 Auto. Lubrication 16375 + 345 - 860 kPa 15168 ± 345 kPa
136-6997 1-2 NORMALLY OPEN
37 Motor - Starting I-1 37 Switch - Coolant Flow F-3 90 Press. Sw . (2374 + 50 - 125 psi) (2200 ± 50 psi)
Port - Service Tool E-12 38 Switch - Engine Shutdown E-4 91
Port - Et Service D-12 39 Switch - Front Residual Brake Oil/Stop Light Press. B-9 92
134-6504 Coolant Flow Sw . 4 GRAMS MAX. 1.5 GRAMS MIN. 1-2 NORMALLY OPEN
CONN 3 CONN 4 Pump - Fuel Priming E-4 40 Switch - Front Service Brake & Retarder Oil Press. B-9 93
Receptacle - Aux Start I-2 41 Switch - Horn D-11 94
Receptacle - Filter A-14 & B14 42 Switch - Light Dimmer E-11 95 Primary Steer Flow
3E-6429 4 GRAMS MAX. 1.5 GRAMS MIN. 1-2 NORMALLY OPEN
Receptacle - Loop (Battery Electrical Isolator) I-5 43 Switch - Main Relay Magnetic D-14 96 Sw .
Receptacle - Loop (Fire Suppression) F-12 44 Switch - Parking Brake F-11 97 A-B NORMALLY OPEN
Parking Brake Oil 248 ± 103 kPa
Receptacle - Loop (Primary Steering) C-12 45 Switch - Primary Steering Flow C-13 98 361-8400 2758 kPa (400 psi) A-C NORMALLY
Press. Snsr. (360 ± 15 psi)
Relay - High Beam G-9 46 Switch - Priming Pump E-4 99 CLOSED
87 Relay - Horn F-9 47 Switch - Rear Residual Brake Oil/Stop Light Press. B-9 100 Brake Accumulator
5857 ± 345 KpA 5168 ± 172 KpA
A-B NORMALLY OPEN
Resistor - Fuel Sensor D-2 48 Switch - Rear Service Brake & Retarder Oil Press. B-9 101 Oil Press. Snsr. A-C NORMALLY
(850 ± 50 PSI) (750 ± 25 PSI)
(Brake Application) CLOSED
14 46 67 2 47 66 16 11 96 Resistor Harness - Brake Oil Temperature B-13 49 Switch - Retarder Lever E-5 102 421-9097
A-B NORMALLY OPEN
Brake Accumulator
Resistor Harness - Can Data Link (1939) D-12 & G2 50 Switch - Signal/Hazard D-11 103 10700 KpA 9000 ± 540 KpA
80 82 65 Sender - Fuel Level A-11 51 Switch - Start Relay Magnetic I-1 104
Oil Press. Snsr.
(1550 PSI) (1300 ± 75 PSI)
A-C NORMALLY
(Alert Indicator) CLOSED
RH FRONT Sensor - Atmospheric Pressure D-3 52 Transducer - Timing Calibration E-3 105
Sensor - Body Position B-13 53
 14 13 12 11 10 9 8 7 6 5 4 3 2 1
UENR4825-00 VOL 1 of 2

J J
(Dimensions: 48 inches x 35 inches)

CBL-WK1 WH-6

H45 CBL-ER1 RD-6

CBL-ER02 WH-10

FUSE
216-9890
WG-T2 1S7251
CBL-WG1 BK-00_EPR_CPE 500A
WE-T1 1S7251 STARTING_MOTOR
CBL-WH1 RD-00-SGT WH-T2 CBL-ER02 WH-10 237-1962
CBL-CC1 WH-6 CBL-WK1 WH-6 1S7251 S G
CBL-ER1 RD-6
CBL-WH2 BK-00-SGT
BAT MTR
CBL-WK1 WH-6
2 1 WH-T1 CBL-WE1 BK-00_EPR_CPE
CONNECTS TO 1S7252
MOTOR
4N-6579 WH-C1
707-C104 PU-16 (PAYLOAD-REMOTE PRINT) CONN. (PH-C7) WF-T2 1S7252
LOC D-11 CBL-WC1 BK-00-SGT CBL-WF1 BK-00_EPR_CPE CBL-WA1 BK-00_EPR_CPE
WA-T1 1S7252 WA-T2 1S7251
TWISTED WIRES
VOLUME 2 OF 2 WG-T1 WC-T1 WF-T1 BATTERY_DISCONNECT_SW.
3S6049 6D1998 WC-T2 3S6050 7N-0718
CONNECTS TO POS NEG 1M4983 POS NEG

C533-C105 PU-16
290-C152 BK-16 A251-C106 BK-16
(PAYLOAD) CONN. (PH-C8)
12V_BATTERY 12V_BATTERY
291-C153 BK-16 C534-C107 YL-16 LOC D-11 9X-9370 9X-9370
307-C159 OR-16 VOLUME 2 OF 2
308-C158 YL-16
321-C163 BR-16 H45 H45

I 306-C132 GN-16
403-C130 GN-16
454-C156 GN-16
500-C173 BR-16
EL308-C108 YL-16
J905-C109 PU-16
CONNECTS TO (BATTERY ELECTRICAL E-C3
3E3364
CBL-ER1 RD-6 CBL-EF1 OR-6
I
307-C159 OR-16 501-C177 GN-16 J904-C110 GY-16 ISOLATOR) CONN. (KA-C1)
321-C183 BR-16 502-C178 OR-16 332-C111 BU-16 306-E64 GN-16 1
332-C111 BU-16 503-C171 BR-16
LOC C-6 K972-E72 BR-16 2
G740-C112 BU-16
454-C156 GN-16 504-C172 YL-16 E741-C113 YL-16 VOLUME 2 OF 2
703-C31 BU-16 506-C176 PU-16
704-C32 GY-16 507-C174 WH-16 CONN 22 WIRE-X1 WH-10 CBL-ER02 WH-10
705-C121 PK-16 605-C155 YL-16
706-C212 BR-16 606-C154 GY-16 TWISTED WIRES
707-C104 PU-16 608-C166 GN-16 200-C151 BK-16
710-C28 GN-16 611-C162 PU-16 H10 201-C150 BK-16 542-C175 BU-16 ALTERNATOR
721-C21 BR-16 612-C161 GY-16 200-C260 BK-16 197-8820
722-C22 WH-16 614-C157 PU-16 EL712-C45 PK-16 E-C16 E-C34 EA-C1
TWISTED WIRES 1552269 3E3364 3E3364
723-C23 OR-16 892-C148 BR-16 EL713-C46 YL-16 CONNECTS TO ALT
724-C24 YL-16 893-C149 GN-16 542-C175 BU-16 EL714-C43 BU-16 403-E63 GN-16 1 1 CBL-EA1 BK-16 R +
725-C25 GN-16 998-C170 BR-16 892-C148 BR-16 619-C144 GN-16 EL715-C44 PU-16
(PAYLOAD) CONN. (PH-C1) 2 2 EA-C2
H8
726-C26 BU-16 E790-C164 PK-16 893-C149 GN-16 EL350-C127 PU-16 635-C114 BU-16 LOC D-11 9D2828
892-C201 BR-16 EL623-C167 BU-16 201-C150 BK-16 EL619-C138 GN-16 636-C115 GN-16 VOLUME 2 OF 2
893-C200 GN-16 EL624-C168 GN-16 200-C151 BK-16 F717-C128 YL-16 J840-C116 WH-16 E-C8 ET-C1 ET-C5
H21
A958-C18 WH-16 EL619-C165 GN-16 290-C152 BK-16 J841-C117 YL-16 1552252 3E5179 1552269
E750-C36 PU-16 H430-C160 PU-16 291-C153 BK-16 EL722-C118 WH-16 705-E59 PK-16 1 705-ET1 PK-16 1
E790-C205 PK-16 K985-C169 BR-16 403-C130 GN-16 EL721-C119 YL-16 K972-E67 BR-16 K972-ET2 BR-16
E790-C206 PK-16 606-C154 GY-16 604-C2 OR-16
CONN 21 TWISTED WIRES A700-E68 OR-16
2
3 A700-ET3 OR-16
2

E900-C57 WH-16 102-C84 RD-16 605-C155 YL-16 EL456-C48 WH-16 998-E69 BR-16 4 998-ET4 BR-16 ET-C2
E901-C58 GN-16 150-C78 OR-16 604-C2 OR-16 EL608-C39 GN-16 TWISTED WIRES F704-E1 OR-16 5 F704-ET5 OR-16 TWISTED WIRES 1552269
E987-C29 WH-16 306-C132 GN-16 CONNECTS TO 454-C156 GN-16 6 L913-ET7 OR-16 1
36 Page,

EL494-C40 BR-16 332-C111 BU-16 EL456-C48 WH-16 150-C78 OR-16 150-EC23 OR-16 TWISTED WIRES 7 L912-ET6 WH-16 2
EL733-C47 PK-16 322-C143 GY-16 CONN. (GC-C28) 614-C157 PU-16 290-C152 BK-16 102-C84 RD-16 102-EC24 RD-16 L912-E66 WH-16 8 L912-ET6 WH-16
G704-C52 YL-16 705-C121 PK-16 LOC I-1 308-C158 YL-16 291-C153 BK-16 K972-C120 BR-16 K972-EC3 BR-16 L913-E65 OR-16 9 L913-ET7 OR-16
ET-C4
G705-C53 GN-16 707-C104 PU-16 307-C159 OR-16 307-C159 OR-16 705-C121 PK-16 705-EC4 PK-16 EL350-E60 PU-16 10 EL350-ET8 PU-16
G706-C60 BU-16 A251-C106 BK-16
VOLUME 2 OF 2 H430-C160 PU-16 308-C158 YL-16 892-C122 BR-16 892-EC5 BR-16 11 1552269
H9
G730-C17 PK-16 C533-C105 PU-16 612-C161 GY-16 321-C163 BR-16 893-C123 GN-16 893-EC6 GN-16 CONN 25 12 EL350-ET8 PU-16 1 SPARE
113-C95 OR-16 G756-C16 YL-16 C534-C107 YL-16 611-C162 PU-16 403-C130 GN-16 A700-C124 OR-16 A700-EC7 OR-16 200-ET9 BK-16 2
114-C87 GN-16 H430-C160 PU-16 EL308-C108 YL-16 321-C163 BR-16 454-C156 GN-16 998-C125 BR-16 998-EC8 BR-16 E-C18 E-C33
113-C96 OR-16 CONNECTS TO H762-C6 PU-16 EL721-C119 YL-16 CONN 15 E790-C164 PK-16 500-C173 BR-16 F702-C126 GN-16 F702-EC9 GN-16 1552269 3E3364
105-C83 BR-16 CONN. (GC-C27) J764-C20 BR-16 EL722-C118 WH-16 619-C144 GN-16 501-C177 GN-16 F703-C56 GY-16 F703-EC10 GY-16 519-E36 PK-16 1 CONNECTS TO
104-C81 BU-16 K744-C10 BU-16 F702-C126 GN-16 EL619-C165 GN-16 502-C178 OR-16 EL350-C127 PU-16 EL350-EC11 PU-16 513-E79 OR-16 2 (REFRIGERANT PRESS. SW.) ET-C3
104-C82 BU-16 LOC G-1 K985-C169 BR-16 L912-C133 WH-16 EL619-C138 GN-16 503-C171 BR-16 F717-C128 YL-16 F717-EC12 YL-16 1698670
102-C72 BU-16 K972-C210 BR-16 L913-C131 OR-16 608-C166 GN-16 504-C172 YL-16 519-C129 PK-16 519-EC13 PK-16
LOC B-7 VOLUME 2 OF 2 A700-ET3 OR-16 A
VOLUME 2 OF 2 H6
E-C19 E-C32
102-C73 BU-16 K988-C9 WH-16 CBL-CC1 WH-6 EL608-C39 GN-16 506-C176 PU-16 403-C267 GN-16 403-EC14 GN-16 998-ET4 BR-16 B
127-C100 OR-16 K989-C59 BU-16 EL623-C167 BU-16 507-C174 WH-16 L913-C131 OR-16 L913-EC15 OR-16 1552272 3E3376 F704-ET5 OR-16 C
EL110-C97 OR-16 K992-C8 PU-16 EL624-C168 GN-16 605-C155 YL-16 306-C132 GN-16 306-EC16 GN-16 1
CONNECTS TO
119-C76 PK-16 CONN 14 L912-C133 WH-16 126-C103 PK-16 K985-C169 BR-16 606-C154 GY-16 F713-C51 OR-16 F713-EC17 OR-16 2
138-C85 GN-16 L913-C131 OR-16 126-C184 PK-16 EL350-C127 PU-16 608-C166 GN-16 F719-C134 WH-16 496-C268 WH-16 496-EC27 WH-16 200-E80 BK-16 3 (COMPRESSOR SOLENOID)
X778-C12 PU-16 126-C271 PK-16 F717-C128 YL-16 611-C162 PU-16 4 LOC B-7 VOLUME 2 OF 2
102-C84 RD-16 X779-C11 GY-16 298-C203 BK-16 998-C170 BR-16 612-C161 GY-16 F720-C135 PU-16 L912-C133 WH-16 L912-EC18 WH-16
113-C49 OR-16 X730-C33 BR-16 321-C163 BR-16 503-C171 BR-16 614-C157 PU-16 F719-C134 WH-16 F719-EC19 WH-16
114-C37 GN-16 321-C182 BR-16 504-C172 YL-16 892-C148 BR-16 F720-C135 PU-16 F720-EC20 PU-16

H H
TWISTED WIRES
118-C7 GY-16 321-C183 BR-16 500-C173 BR-16 893-C149 GN-16 F719-C134 WH-16 F711-C263 GN-16 F711-EC21 GN-16 102-E75 RD-16
124-C62 GN-16 321-C163 BR-16 403-C130 GN-16 507-C174 WH-16 998-C170 BR-16 F712-C265 GY-16 F712-EC22 GY-16 G833-E76 PK-16
124-C63 GN-16 403-C130 GN-16 403-C266 GN-16 542-C175 BU-16 E790-C164 PK-16 F720-C135 PU-16 G833-E77 PK-16
126-C19 PK-16 506-C176 PU-16 496-C270 WH-16 EL619-C165 GN-16 CONN 20 FR-C1 TWISTED WIRES G833-E78 PK-16
126-C103 PK-16 507-C174 WH-16 506-C176 PU-16 506-C176 PU-16 EL623-C167 BU-16 1552252 K972-E73 BR-16
126-C184 PK-16 605-C155 YL-16 507-C174 WH-16 501-C177 GN-16 EL624-C168 GN-16 EL619-C138 GN-16 1 EL619-FR1 GN-16
126-C271 PK-16 606-C154 GY-16 605-C155 YL-16 H12 502-C178 OR-16 H430-C160 PU-16 611-C139 PU-16 2 611-FR2 PU-16 102-E75 RD-16
150-C78 OR-16 608-C166 GN-16 606-C154 GY-16 K985-C169 BR-16 605-C140 YL-16 3 605-FR3 YL-16 G833-E76 PK-16
290-C152 BK-16 611-C162 PU-16 608-C166 GN-16 200-C260 BK-16 614-C141 PU-16 4 614-FR4 PU-16 G833-E77 PK-16
291-C153 BK-16 612-C161 GY-16 611-C162 PU-16 G740-C142 BU-16 5 G740-FR5 BU-16 G833-E78 PK-16
298-C203 BK-16 614-C157 PU-16 611-C179 PU-16 322-C143 GY-16 6 322-FR6 GY-16 H1 K972-E73 BR-16
308-C158 YL-16 892-C148 BR-16 612-C161 GY-16 619-C144 GN-16 7 619-FR7 GN-16
321-C182 BR-16 893-C149 GN-16 612-C208 GY-16 290-C152 BK-16 606-C145 GY-16 8 606-FR8 GY-16
322-C143 GY-16 998-C170 BR-16 612-C209 GY-16 291-C153 BK-16 542-C175 BU-16 EL611-C146 PU-16 9 EL611-FR9 PU-16 998-E3 BR-16
403-C266 GN-16 E790-C164 PK-16 614-C157 PU-16 307-C159 OR-16 604-C2 OR-16 F720-C135 PU-16 10 F720-FR10 PU-16 998-E69 BR-16 A700-E2 OR-16
202-C227 BK-16 417-C30 GY-16 614-C190 PU-16 308-C158 YL-16 619-C144 GN-16 F719-C134 WH-16 11 F719-FR11 WH-16 A700-E2 OR-16 A700-E74 OR-16
426-C15 BR-16 H17 614-C191 PU-16 321-C163 BR-16 H8 EL350-C127 PU-16 998-C147 BR-16 12 998-FR12 BR-16 A700-E68 OR-16 A700-E70 OR-16
496-C270 WH-16 321-C163 BR-16 614-C192 PU-16 403-C130 GN-16 EL456-C48 WH-16 G828-E53 WH-16 A700-E68 OR-16
500-C173 BR-16 403-C130 GN-16 892-C148 BR-16 454-C156 GN-16 EL608-C39 GN-16 604-C2 OR-16 CONN 19 G829-E47 GN-16 998-E81 BR-16
501-C177 GN-16 506-C176 PU-16 892-C197 BR-16 500-C173 BR-16 EL619-C138 GN-16 EL456-C48 WH-16 F704-E1 OR-16 998-E69 BR-16
TWISTED WIRES 502-C178 OR-16 507-C174 WH-16 892-C199 BR-16 501-C177 GN-16 F717-C128 YL-16 EL608-C39 GN-16 998-E71 BR-16
611-C179 PU-16 605-C155 YL-16 892-C201 BR-16 502-C178 OR-16 998-E3 BR-16
164-C101 WH-16 612-C209 GY-16 606-C154 GY-16 893-C149 GN-16 503-C171 BR-16 102-C84 RD-16 604-C2 OR-16 998-E3 BR-16 E-C1 ENGINE_ECM_MID_036
L912-C133 WH-16 614-C190 PU-16 608-C166 GN-16 893-C194 GN-16 504-C172 YL-16 150-C78 OR-16 EL456-C48 WH-16 998-E69 BR-16 1607689 226-7475
L913-C131 OR-16 892-C199 BR-16 611-C162 PU-16 893-C196 GN-16 H10 H10 506-C176 PU-16 306-C132 GN-16 EL608-C39 GN-16 A700-E2 OR-16 F704-E1 OR-16 1 TORQUE CONVERTER OIL TEMP. SENSOR
893-C194 GN-16 612-C161 GY-16 893-C200 GN-16 507-C174 WH-16 322-C143 GY-16 A700-E68 OR-16 2
A251-C106 BK-16 614-C157 PU-16 998-C170 BR-16 605-C155 YL-16 332-C111 BU-16 G828-E53 WH-16 3
C455-C27 PU-16 892-C148 BR-16 998-C193 BR-16 606-C154 GY-16 705-C121 PK-16 G829-E47 GN-16 A700-E2 OR-16 4 DIGITAL SENSOR +8V
TWISTED WIRES
TWISTED WIRES C533-C105 PU-16 893-C149 GN-16 A700-C204 OR-16 608-C166 GN-16 707-C104 PU-16 F704-E1 OR-16 998-E3 BR-16 5 DIGITAL SENSOR RETURN
M411-C272 GN-16 C534-C107 YL-16 998-C170 BR-16 E790-C164 PK-16 611-C162 PU-16 A251-C106 BK-16 TWISTED WIRES 6
EL709-C228 YL-16 E790-C207 PK-16 E790-C164 PK-16 E790-C205 PK-16 612-C161 GY-16 C533-C105 PU-16 E-C31 E-C7 7
893-C200 GN-16 202-C227 BK-16 EL308-C108 YL-16 E790-C206 PK-16 614-C157 PU-16 C534-C107 YL-16 2128436 1698670 893-E4 GN-16 8 CAT DATA LINK +
EL716-C229 BR-16 F711-C136 GN-16 E790-C207 PK-16 892-C148 BR-16 H9 EL308-C108 YL-16 A K972-E72 BR-16 892-E5 BR-16 9 CAT DATA LINK -
704-C32 GY-16 F712-C137 GY-16 F711-C136 GN-16 893-C149 GN-16 EL721-C119 YL-16 G740-FR5 BU-16 B K972-E73 BR-16 10
202-C254 BK-16 F711-C262 GN-16 998-C170 BR-16 EL722-C118 WH-16 G740-FR13 BU-16 C K972-E67 BR-16 11
115-C89 RD-16 F712-C137 GY-16 E790-C164 PK-16 F702-C126 GN-16 G740-FR14 BU-16 12
E987-C29 WH-16 118-C86 GY-16 H16 H16 F712-C264 GY-16 EL619-C165 GN-16 L912-C133 WH-16 150-FR29 OR-16 13
710-C28 GN-16 306-C132 GN-16 119-C75 PK-16 K972-C210 BR-16 EL623-C167 BU-16 L913-C131 OR-16 150-FR30 OR-18 F703-E6 GY-16 14 BRAKE OIL TEMP. SENSOR
E901-C58 GN-16 307-C159 OR-16 592-C226 BU-16 EL624-C168 GN-16 CBL-CC1 WH-6 150-FR31 OR-16 TWISTED WIRES F714-E7 PK-16 15 AIR FILTER RESTRICTION PRESS. SENSOR
E900-C57 WH-16 321-C183 BR-16 A513-C233 PK-16 H430-C160 PU-16 496-FR32 WH-16 150-EC1 OR-16 150-E20 OR-16 16
332-C111 BU-16 K985-C169 BR-16 496-FR33 WH-18 102-EC2 RD-16 102-E75 RD-16 17
892-C201 BR-16 454-C156 GN-16 403-C267 GN-16 496-FR34 WH-18 306-EC16 GN-16 N944-E8 PU-16 18 SENSOR DIGITAL RETURN
703-C31 BU-16 496-C268 WH-16 403-EC14 GN-16 K972-EC3 BR-16 K972-E73 BR-16 19
704-C32 GY-16 102-C84 RD-16 H9 519-C129 PK-16 519-EC13 PK-16 705-EC4 PK-16 705-E59 PK-16 20
202-C255 BK-16 705-C121 PK-16 113-C49 OR-16 605-C140 YL-16 705-EC4 PK-16 892-EC5 BR-16 892-E5 BR-16 21
706-C212 BR-16 103-C88 YL-16 114-C37 GN-16 606-C145 GY-16 892-EC5 BR-16 893-EC6 GN-16 893-E4 GN-16 22
707-C104 PU-16 103-C213 YL-16 118-C7 GY-16 H12 H12 611-C139 PU-16 298-FR17 BK-16 893-EC6 GN-16 A700-EC7 OR-16 A700-E70 OR-16 23
710-C28 GN-16 103-C214 YL-16 124-C62 GN-16 614-C141 PU-16 200-FR22 BK-16 998-EC8 BR-16 998-EC8 BR-16 998-E81 BR-16 24
721-C21 BR-16 103-C215 YL-16 124-C63 GN-16 635-C114 BU-16 200-FR23 BK-16 A700-EC7 OR-16 F702-EC9 GN-16 F702-E18 GN-16 25
FR-M1

G 722-C22 WH-16
723-C23 OR-16
724-C24 YL-16 H21 H21
103-C216 YL-16
103-C217 YL-16
126-C19 PK-16
126-C19 PK-16
126-C103 PK-16
126-C184 PK-16 H13
636-C115 GN-16
892-C122 BR-16
893-C123 GN-16
3092088
200-FR24 BK-16 H6 EL350-EC11 PU-16
F702-EC9 GN-16
F703-EC10 GY-16
F703-EC10 GY-16 F703-E6 GY-16 26
27
28
G
101-C90 RD-16 725-C25 GN-16 126-C261 PK-16 126-C271 PK-16 998-C125 BR-16 F711-EC21 GN-16 EL350-EC11 PU-16 EL350-E60 PU-16 29
726-C26 BU-16 126-C271 PK-16 150-C78 OR-16 998-C147 BR-16 200-FR19 BK-16 F712-EC22 GY-16 E-C27 H-C1 30
EL709-C228 YL-16 892-C201 BR-16 126-C275 PK-16 290-C152 BK-16 CONNECTS TO (WINDSCREEN 126-C103 PK-16 A700-C124 OR-16 200-FR20 BK-16 F713-EC17 OR-16 1552269 3E3364 31
EL716-C229 BR-16 893-C200 GN-16 291-C153 BK-16 WASHER MOTORS) CONN. (VA-C1) 507-C174 WH-16 126-C184 PK-16 E741-C113 YL-16 200-FR21 BK-16 F717-EC12 YL-16 F711-EC21 GN-16 F711-E61 GN-16 1 F711-H1 GN-16 RESISTOR HARNESS 305-0691 32
711-C243 BR-16 A958-C18 WH-16 298-C203 BK-16 506-C176 PU-16 126-C271 PK-16 EL611-C146 PU-16 200-FR25 BK-16 F719-EC19 WH-16 F712-EC22 GY-16 F712-E62 GY-16 2 F712-H2 GY-16 120 33
FR-M2
E750-C36 PU-16 308-C158 YL-16 LOC C-7 298-C203 BK-16 F711-C263 GN-16
3092088
298-FR18 BK-16 F720-EC20 PU-16 519-EC13 PK-16 519-E36 PK-16 F712-H2 GY-16 34 CAN DATA LINK -
E790-C205 PK-16 321-C182 BR-16 321-C163 BR-16 F712-C265 GY-16 K972-EC3 BR-16 403-EC14 GN-16 403-E63 GN-16 35
E790-C206 PK-16 H20 322-C143 GY-16 VOLUME 2 OF 2 113-C49 OR-16 321-C182 BR-16 G740-C112 BU-16 L913-EC15 OR-16 36
101-C91 RD-16 E900-C57 WH-16 403-C266 GN-16 114-C37 GN-16 321-C183 BR-16 G740-C142 BU-16 L912-EC18 WH-16 306-EC16 GN-16 306-E64 GN-16 37
712-C249 WH-16 E901-C58 GN-16 417-C30 GY-16 118-C7 GY-16 403-C130 GN-16 J840-C116 WH-16 201-FR35 BK-18 L913-EC15 OR-16 L913-E65 OR-16 38
713-C248 OR-16 E987-C29 WH-16 101-C90 RD-16 H17 426-C15 BR-16 124-C62 GN-16 403-C266 GN-16 J841-C117 YL-16 201-FR36 BK-16 39
714-C247 YL-16 EL494-C40 BR-16 H22 101-C90 RD-16 101-C91 RD-16 102-C71 BU-16 496-C270 WH-16 124-C63 GN-16 496-C270 WH-16 J904-C110 GY-16 202-FR26 BK-16 40
715-C246 GN-16 EL733-C47 PK-16 101-C91 RD-16 102-C80 RD-16 H20 A608-C218 GY-16 500-C173 BR-16 126-C19 PK-16 506-C176 PU-16 J905-C109 PU-16 F713-EC17 OR-16 F713-E19 OR-16 F717-E9 YL-16 41 BACKUP THROTTLE
G704-C52 YL-16 164-C101 WH-16 119-C77 PK-16 200-C219 BK-16 501-C177 GN-16 417-C30 GY-16 507-C174 WH-16 K972-C120 BR-16 42
G705-C53 GN-16 127-C99 OR-16 611-C179 PU-16 502-C178 OR-16 113-C49 OR-16 426-C15 BR-16 605-C155 YL-16 43
G706-C60 BU-16 164-C101 WH-16 611-C179 PU-16 114-C37 GN-16 703-C31 BU-16 606-C154 GY-16 H12 604-C2 OR-16 F717-EC12 YL-16 F717-E9 YL-16 N943-E10 BR-16 44 COOLANT FLOW SW.
G730-C17 PK-16 612-C209 GY-16 118-C7 GY-16 704-C32 GY-16 608-C166 GN-16 EL456-C48 WH-16 102-FR28 RD-16 F715-E11 WH-16 45 COOLANT LEVEL SENSOR
K989-C59 BU-16 G756-C16 YL-16 102-C80 RD-16 614-C190 PU-16 124-C63 GN-16 706-C212 BR-16 611-C162 PU-16 EL608-C39 GN-16 329-FR27 YL-16 F720-E12 PU-16 46 ENGINE SHUTDOWN SW. N.O.
G706-C60 BU-16 H430-C160 PU-16 119-C77 PK-16 102-C72 BU-16 892-C199 BR-16 124-C62 GN-16 710-C28 GN-16 611-C179 PU-16 EL712-C45 PK-16 614-FR15 PU-16 F719-E13 WH-16 47 ENGINE SHUTDOWN SW. N.C.
E790-C205 PK-16 H762-C6 PU-16 127-C99 OR-16 102-C73 BU-16 893-C194 GN-16 126-C19 PK-16 721-C21 BR-16 612-C161 GY-16 EL713-C46 YL-16 614-FR16 PU-16 L912-EC18 WH-16 L912-E66 WH-16 102-E14 RD-16 48 +24V BATTERY (UNSWITCHED)
G704-C52 YL-16 J764-C20 BR-16 102-C84 RD-16 120-C98 YL-16 A251-C106 BK-16 426-C15 BR-16 722-C22 WH-16 612-C208 GY-16 EL714-C43 BU-16 X744-FR37 YL-18 49
G705-C53 GN-16 K744-C10 BU-16 126-C184 PK-16 104-C81 BU-16 321-C182 BR-16 C455-C27 PU-16 417-C30 GY-16 723-C23 OR-16 612-C209 GY-16 EL715-C44 PU-16 102-EC2 RD-16 F711-H1 GN-16 50 CAN DATA LINK +
K972-C210 BR-16 298-C203 BK-16 104-C82 BU-16 E790-C207 PK-16 C533-C105 PU-16 703-C31 BU-16 724-C24 YL-16 614-C157 PU-16 F703-C56 GY-16 102-FR28 RD-16 150-EC1 OR-16 F719-EC19 WH-16 F719-E13 WH-16 51
K985-C169 BR-16 308-C158 YL-16 105-C83 BR-16 612-C209 GY-16 C534-C107 YL-16 704-C32 GY-16 725-C25 GN-16 614-C190 PU-16 F713-C51 OR-16 329-FR27 YL-16 102-E15 RD-16 52 +24V BATTERY (UNSWITCHED)
E790-C206 PK-16 K988-C9 WH-16 H24 403-C266 GN-16 113-C49 OR-16 E790-C207 PK-16 706-C212 BR-16 726-C26 BU-16 614-C191 PU-16 614-FR15 PU-16 F720-EC20 PU-16 F720-E12 PU-16 53
K989-C59 BU-16 417-C30 GY-16 113-C95 OR-16 EL308-C108 YL-16 710-C28 GN-16 A958-C18 WH-16 614-C192 PU-16 614-FR16 PU-16 102-EC24 RD-16 54
K992-C8 PU-16 426-C15 BR-16 113-C96 OR-16 F711-C136 GN-16 721-C21 BR-16 C455-C27 PU-16 892-C148 BR-16 X744-FR37 YL-18 496-EC27 WH-16 H43 55
L912-C133 WH-16 496-C270 WH-16 114-C37 GN-16 F712-C137 GY-16 722-C22 WH-16 E750-C36 PU-16 892-C197 BR-16 604-C2 OR-16 150-EC23 OR-16 56
705-C121 PK-16 L913-C131 OR-16 102-C80 RD-16 614-C190 PU-16 114-C87 GN-16 723-C23 OR-16 E901-C58 GN-16 892-C199 BR-16 EL456-C48 WH-16 CONN 24 57
K972-C210 BR-16 X778-C12 PU-16 EL308-C108 YL-16 CONNECTS TO C455-C27 PU-16 115-C89 RD-16 103-C213 YL-16 724-C24 YL-16 E987-C29 WH-16 892-C201 BR-16 EL608-C39 GN-16 58
G730-C17 PK-16 X779-C11 GY-16 200-C238 BK-16 CONN. (N-C1) EL308-C108 YL-16 118-C7 GY-16 103-C214 YL-16 725-C25 GN-16 EL494-C40 BR-16 893-C149 GN-16 EL712-C45 PK-16 519-C1 PK-16 102-EC26 RD-16 59
A958-C18 WH-16 X730-C33 BR-16 308-C158 YL-16 118-C86 GY-16 EL322-C220 GY-16 726-C26 BU-16 EL556-C69 OR-16 893-C194 GN-16 EL713-C46 YL-16 604-C2 OR-16 604-CR1 OR-16 150-EC25 OR-16 60
LOC C-11
716-C245 BU-16
EL710-C239 OR-16
709-C240 BU-16
CONN 2 VOLUME 2 OF 2
119-C75 PK-16
119-C76 PK-16
322-C143 GY-16 A700-C204 OR-16
998-C193 BR-16
A958-C18 WH-16
C455-C27 PU-16
EL557-C70 GN-16
EL559-C61 GY-16
893-C196 GN-16
893-C200 GN-16
EL714-C43 BU-16
EL715-C44 PU-16
E790-C3 PK-16
K972-C4 BR-16
E790-CR2 PK-16
K972-CR3 BR-16 102-EC26 RD-16
229-E16 BK-16 61
62
GROUND

124-C62 GN-16 F702-C126 GN-16 E750-C36 PU-16 EL566-C34 WH-16 998-C170 BR-16 F703-C56 GY-16 K972-C5 BR-16 K972-CR4 BR-16 150-EC25 OR-16 229-E17 BK-16 63 GROUND
(NOTE A) 124-C63 GN-16 E900-C57 WH-16 EL733-C47 PK-16 998-C193 BR-16 F713-C51 OR-16 H762-C6 PU-16 H762-CR5 PU-16 64
K988-C9 WH-16 101-C90 RD-16 126-C103 PK-16 E901-C58 GN-16 A700-C204 OR-16 403-C267 GN-16 118-C7 GY-16 118-CR6 GY-16
K744-C10 BU-16 101-C91 RD-16
(NOTE J) 126-C184 PK-16 503-C171 BR-16 E987-C29 WH-16
E900-C57 WH-16
G704-C52 YL-16 E790-C164 PK-16 496-C268 WH-16 K992-C8 PU-16 K992-CR7 PU-16 F702-E18 GN-16
65
66 THROTTLE
H22
M411-C272 GN-16 164-C101 WH-16 127-C100 OR-16 504-C172 YL-16 EL494-C40 BR-16 G705-C53 GN-16 E790-C205 PK-16 519-C129 PK-16 K988-C9 WH-16 K988-CR8 WH-16 67
138-C85 GN-16 501-C177 GN-16 612-C208 GY-16 EL556-C69 OR-16 G706-C60 BU-16 E790-C206 PK-16 605-C140 YL-16 K744-C10 BU-16 K744-CR9 BU-16 F713-E19 OR-16 68 FUEL LEVEL SENDER
150-C78 OR-16 614-C191 PU-16 EL557-C70 GN-16 G730-C17 PK-16 E790-C207 PK-16 606-C145 GY-16 X779-C11 GY-16 X779-CR10 GY-16 69
C976-C235 YL-16 290-C152 BK-16 200-C221 BK-16 614-C192 PU-16 EL559-C61 GY-16 G756-C16 YL-16 F711-C136 GN-16 611-C139 PU-16 113-C49 OR-16 X778-C12 PU-16 X778-CR11 PU-16 150-E20 OR-16 70 +24V BATTERY (SWITCHED)
COOLANT_FLOW_SW. E-C20
G764-C236 PK-16 291-C153 BK-16 119-C74 PK-16 892-C197 BR-16 EL566-C34 WH-16 H762-C6 PU-16 F711-C262 GN-16 614-C141 PU-16 114-C37 GN-16 608-C13 GN-16 608-CR12 GN-16
134-6054 1552269
307-C159 OR-16 202-C237 BK-16 298-C203 BK-16 500-C173 BR-16 893-C196 GN-16 EL733-C47 PK-16 J764-C20 BR-16 F712-C137 GY-16 635-C114 BU-16 118-C7 GY-16 608-C14 GN-16 608-CR13 GN-16 1
EL733-C47 PK-16 308-C158 YL-16 502-C178 OR-16 EL556-C69 OR-16 G704-C52 YL-16 K744-C10 BU-16 F712-C264 GY-16 636-C115 GN-16 124-C62 GN-16 426-C15 BR-16 426-CR14 BR-16 BK-18 1 N943-E10 BR-16 2
703-C31 BU-16 403-C266 GN-16 EL557-C70 GN-16 G705-C53 GN-16 K989-C59 BU-16 K972-C210 BR-16 892-C122 BR-16 124-C63 GN-16 G756-C16 YL-16 G756-CR15 YL-16 BK-18 2 N944-E8 PU-16 3
EL494-C40 BR-16 417-C30 GY-16 EL559-C61 GY-16 G706-C60 BU-16 K992-C8 PU-16 893-C123 GN-16 126-C19 PK-16 G730-C17 PK-16 G730-CR16 PK-16 4

F 321-C183 BR-16

306-C132 GN-16
126-C184 PK-16
614-C190 PU-16
(NOTE A) (NOTE B)
426-C15 BR-16
496-C270 WH-16
614-C190 PU-16 592-C225 BU-16
EL566-C34 WH-16
EL619-C165 GN-16
EL623-C167 BU-16
G730-C17 PK-16
G756-C16 YL-16
H762-C6 PU-16
K988-C9 WH-16
X730-C33 BR-16
X778-C12 PU-16
998-C125 BR-16
998-C147 BR-16
A700-C124 OR-16 H13
417-C30 GY-16
426-C15 BR-16
519-C1 PK-16
A958-C18 WH-16
126-C19 PK-16
J764-C20 BR-16
A958-CR17 WH-16
126-CR18 PK-16
J764-CR19 BR-16
COOLANT_LEVEL_SENSOR
239-9957
EG-C2
1698670
EG-C1
3E3370
E-C21
1698670
5
6
7
F
200-C241 BK-16 892-C199 BR-16 592-C226 BU-16 H15 EL624-C168 GN-16 J764-C20 BR-16 X779-C11 GY-16 E741-C113 YL-16 519-C64 PK-16 721-C21 BR-16 721-CR20 BR-16 VS RD-18 A A700-EG1 OR-16 A A700-E74 OR-16 8
J765-C242 BU-16 CONNECTS TO 893-C194 GN-16 EL721-C119 YL-16 K744-C10 BU-16 EL611-C146 PU-16 605-C42 YL-16 722-C22 WH-16 722-CR21 WH-16 GROUND BK-18 B 998-EG2 BR-16 B 998-E71 BR-16 9
711-C243 BR-16 101-C90 RD-16 A251-C106 BK-16 EL722-C118 WH-16 K989-C59 BU-16 F711-C263 GN-16 606-C41 GY-16 723-C23 OR-16 723-CR22 OR-16 ALARM GN-18 C F715-EG3 WH-16 C F715-E11 WH-16 10
CONN. (T-C1)
102-C80 RD-16
119-C77 PK-16
M997-C244 PU-16
716-C245 BU-16
CONN 3 LOC B-9
101-C91 RD-16
102-C72 BU-16
C533-C105 PU-16
C534-C107 YL-16
F711-C262 GN-16
F712-C264 GY-16
K992-C8 PU-16
K988-C9 WH-16
126-C68 PK-16
126-C103 PK-16
F712-C265 GY-16
G740-C112 BU-16
608-C13 GN-16
608-C14 GN-16
724-C24 YL-16
725-C25 GN-16
724-CR23 YL-16
725-CR24 GN-16
11
12
707-C104 PU-16 126-C184 PK-16 715-C246 GN-16 VOLUME 2 OF 2 102-C73 BU-16 C455-C27 PU-16 CBL-CC1 WH-6 X730-C33 BR-16 126-C184 PK-16 G740-C142 BU-16 612-C38 GY-16 726-C26 BU-16 726-CR25 BU-16
E-C28 E-C5
995-E21 BU-16 13 COOLANT TEMP. SENSOR
127-C99 OR-16 714-C247 YL-16 102-C80 RD-16 EL110-C97 OR-16 126-C102 PK-16 X778-C12 PU-16 298-C203 BK-16 J840-C116 WH-16 614-C35 PU-16 C455-C27 PU-16 C455-CR26 PU-16 14
TWISTED WIRES 2143898 3E3388
M997-C244 PU-16 298-C203 BK-16 713-C248 OR-16 EL308-C108 YL-16 200-C230 BK-16 A746-E22 PK-16
E750-C36 PU-16 308-C158 YL-16 712-C249 WH-16
102-C84 RD-16
104-C81 BU-16 F711-C136 GN-16 EL458-C231 OR-16
(NOTE G) 115-C89 RD-16
X779-C11 GY-16 321-C163 BR-16
321-C182 BR-16
J841-C117 YL-16
J904-C110 GY-16
635-C65 BU-16
636-C66 GN-16
710-C28 GN-16
E987-C29 WH-16
710-CR27 GN-16
E987-CR28 WH-16 1 102-E14 RD-16
15
16
BOOST PRESS. SENSOR

403-C266 GN-16 403-C266 GN-16 104-C82 BU-16 F712-C137 GY-16 118-C86 GY-16 H16 321-C183 BR-16 J905-C109 PU-16 703-C31 BU-16 417-C30 GY-16 417-CR29 GY-16 2 102-E15 RD-16 G829-E47 GN-16 17 ANALOG SENSOR COMMON
706-C212 BR-16 H24 417-C30 GY-16 105-C83 BR-16 119-C75 PK-16 605-C180 YL-16 519-C1 PK-16 K972-C120 BR-16 704-C32 GY-16 703-C31 BU-16 703-CR30 BU-16 3 102-E75 RD-16 18
454-C156 GN-16 426-C15 BR-16 113-C49 OR-16 592-C226 BU-16 606-C181 GY-16 519-C64 PK-16 710-C28 GN-16 704-C32 GY-16 704-CR31 GY-16 G740-FR5 BU-16 4 19
H430-C160 PU-16 496-C270 WH-16 113-C95 OR-16 126-C19 PK-16 A513-C233 PK-16 635-C185 BU-16 H14 519-C129 PK-16 721-C21 BR-16 X730-C33 BR-16 X730-CR32 BR-16 5 G833-E26 PK-16 20
C584-C250 WH-16 614-C190 PU-16 113-C96 OR-16 126-C271 PK-16 115-C92 RD-16 636-C186 GN-16 605-C42 YL-16 722-C22 WH-16 EL566-C34 WH-16 EL566-CR33 WH-16 H31 6 G833-E76 PK-16 21
J764-C20 BR-16 C455-C27 PU-16 201-C273 BK-16 114-C37 GN-16 321-C182 BR-16 118-C93 GY-16 J840-C189 WH-16 605-C140 YL-16 113-C49 OR-16 723-C23 OR-16 614-C35 PU-16 614-CR34 PU-16 7 G833-E77 PK-16 22
G756-C16 YL-16 EL308-C108 YL-16 114-C87 GN-16 322-C143 GY-16 200-C232 BK-16 J841-C188 YL-16 605-C180 YL-16 605-C155 YL-16 114-C37 GN-16 724-C24 YL-16 E750-C36 PU-16 E750-CR35 PU-16 G740-FR5 BU-16 150-EC1 OR-16 8 G833-E78 PK-16 23
X730-C33 BR-16 119-C77 PK-16 115-C89 RD-16 500-C173 BR-16 A513-C233 PK-16 503-C171 BR-16 606-C181 GY-16 H14 606-C41 GY-16 118-C7 GY-16 725-C25 GN-16 114-C37 GN-16 114-CR36 GN-16 150-EC25 OR-16 24
126-C275 PK-16 426-C15 BR-16 118-C7 GY-16 H26 501-C177 GN-16 592-C225 BU-16 504-C172 YL-16 635-C185 BU-16 606-C145 GY-16 126-C19 PK-16 726-C26 BU-16 612-C38 GY-16 612-CR37 GY-16 150-EC23 OR-16 E963-E23 BK-16 25 PRIMARY SPEED/TIMING SENSOR -
200-C256 BK-16 200-C230 BK-16 C584-C250 WH-16 H23 118-C86 GY-16 502-C178 OR-16 200-C234 BK-16 605-C180 YL-16 636-C186 GN-16 606-C154 GY-16 124-C62 GN-16 998-C50 BR-16 EL608-C39 GN-16 EL608-CR38 GN-16 102-EC2 RD-16 G856-E24 WH-16 26 TIMING CALIBRATION TRANSDUCER +
200-C257 BK-16 200-C256 BK-16 127-C251 OR-16 119-C75 PK-16 592-C226 BU-16 606-C181 GY-16 J840-C189 WH-16 H19 608-C13 GN-16 124-C63 GN-16 998-C55 BR-16 EL494-C40 BR-16 EL494-CR39 BR-16 102-EC26 RD-16 H43 27
C976-C235 YL-16 202-C254 BK-16 200-C257 BK-16 EL458-C231 OR-16 119-C77 PK-16 611-C179 PU-16 605-C180 YL-16 612-C208 GY-16 J841-C188 YL-16 608-C14 GN-16 126-C68 PK-16 A700-C54 OR-16 606-C41 GY-16 606-CR40 GY-16 102-EC24 RD-16 994-E25 GY-16 28 ENGINE OIL PRESS. SENSOR
G764-C236 PK-16 202-C255 BK-16 202-C254 BK-16 127-C99 OR-16 119-C76 PK-16 612-C209 GY-16 606-C181 GY-16 614-C191 PU-16 608-C166 GN-16 417-C30 GY-16 A958-C18 WH-16 605-C42 YL-16 605-CR41 YL-16 E-C17 29
H30 H30
721-C21 BR-16 709-C240 BU-16 202-C255 BK-16 126-C103 PK-16 A513-C233 PK-16 CBL-CC1 WH-6 614-C192 PU-16 606-C41 GY-16 611-C139 PU-16 426-C15 BR-16 C455-C27 PU-16 EL714-C43 BU-16 EL714-CR42 BU-16 1552269 G833-E26 PK-16 30 TEMP. SENSOR COMMON
722-C22 WH-16 711-C243 BR-16 709-C240 BU-16 126-C275 PK-16 127-C99 OR-16 E790-C207 PK-16 EL619-C165 GN-16 635-C185 BU-16 606-C145 GY-16 611-C162 PU-16 113-C49 OR-16 519-C1 PK-16 E750-C36 PU-16 EL715-C44 PU-16 EL715-CR43 PU-16 1 995-E21 BU-16 31
712-C249 WH-16 711-C243 BR-16 496-C270 WH-16 127-C100 OR-16 636-C186 GN-16 605-C42 YL-16 611-C179 PU-16 114-C37 GN-16 519-C64 PK-16 E790-C3 PK-16 EL712-C45 PK-16 EL712-CR44 PK-16 496-FR32 WH-16 496-EC27 WH-16 2 G833-E78 PK-16 32
713-C248 OR-16 712-C249 WH-16 124-C62 GN-16 892-C197 BR-16 605-C140 YL-16 635-C65 BU-16 118-C7 GY-16 605-C42 YL-16 E900-C57 WH-16 EL713-C46 YL-16 EL713-CR45 YL-16 150-FR29 OR-16 150-EC25 OR-16 33
714-C247 YL-16 713-C248 OR-16 124-C63 GN-16 103-C213 YL-16 893-C196 GN-16 611-C139 PU-16 636-C66 GN-16 124-C62 GN-16 608-C14 GN-16 E901-C58 GN-16 EL733-C47 PK-16 EL733-CR46 PK-16 102-FR28 RD-16 102-EC26 RD-16 E-C26 34
715-C246 GN-16 714-C247 YL-16 138-C85 GN-16 103-C214 YL-16 EL556-C69 OR-16 611-C162 PU-16 126-C68 PK-16 635-C114 BU-16 124-C63 GN-16 608-C13 GN-16 E987-C29 WH-16 EL456-C48 WH-16 EL456-CR47 WH-16 1552269 E964-E27 WH-16 35 PRIMARY SPEED/TIMING SENSOR +
723-C23 OR-16 716-C245 BU-16 715-C246 GN-16 417-C30 GY-16 150-C78 OR-16 592-C225 BU-16 115-C89 RD-16 EL557-C70 GN-16 611-C179 PU-16 126-C103 PK-16 636-C115 GN-16 126-C19 PK-16 606-C41 GY-16 EL494-C40 BR-16 113-C49 OR-16 113-CR48 OR-16 1 A751-E34 YL-16 G857-E28 YL-16 36 TIMING CALIBRATION TRANSDUCER -
724-C24 YL-16 C584-C250 WH-16 716-C245 BU-16 C455-C27 PU-16 164-C101 WH-16 118-C86 GY-16 EL559-C61 GY-16 H15 EL611-C146 PU-16 126-C184 PK-16 E741-C113 YL-16 126-C68 PK-16 612-C38 GY-16 EL556-C69 OR-16 998-C50 BR-16 998-CR49 BR-16 CONN 23 2 G833-E77 PK-16 37
725-C25 GN-16 C976-C235 YL-16 C584-C250 WH-16 290-C152 BK-16 119-C75 PK-16 EL566-C34 WH-16 605-C155 YL-16 321-C163 BR-16 EL611-C146 PU-16 403-C267 GN-16 614-C35 PU-16 EL557-C70 GN-16 F713-C51 OR-16 F713-CR50 OR-16 38
726-C26 BU-16 EL710-C239 OR-16 C976-C235 YL-16 291-C153 BK-16 503-C171 BR-16 EL619-C165 GN-16 605-C180 YL-16 321-C182 BR-16 G740-C202 BU-16 417-C30 GY-16 635-C65 BU-16 EL559-C61 GY-16 G704-C52 YL-16 G704-CR51 YL-16 E-C10 39
H29
G764-C236 PK-16 EL458-C231 OR-16 892-C199 BR-16 504-C172 YL-16 EL623-C167 BU-16 606-C154 GY-16 321-C183 BR-16 J840-C67 WH-16 426-C15 BR-16 636-C66 GN-16 EL566-C34 WH-16 G705-C53 GN-16 G705-CR52 GN-16 1552269 C991-E29 PK-16 40 FUEL SENSOR RESISTOR
J765-C242 BU-16 EL710-C239 OR-16 893-C194 GN-16 103-C213 YL-16 TWISTED C967-E32 BU-16
592-C226 BU-16 EL624-C168 GN-16 606-C181 GY-16 519-C1 PK-16 J840-C116 WH-16 496-C268 WH-16 703-C31 BU-16 EL733-C47 PK-16 A700-C54 OR-16 A700-CR53 OR-16 1 41
WIRES
M997-C244 PU-16 G764-C236 PK-16 A251-C106 BK-16 103-C214 YL-16 612-C208 GY-16 EL721-C119 YL-16 519-C64 PK-16 J841-C117 YL-16 519-C1 PK-16 704-C32 GY-16 G704-C52 YL-16 998-C55 BR-16 998-CR54 BR-16 2 G833-E76 PK-16 42
R985-C252 WH-16 J765-C242 BU-16 C533-C105 PU-16 592-C225 BU-16 614-C191 PU-16 EL722-C118 WH-16 519-C129 PK-16 J841-C187 YL-16 519-C64 PK-16 706-C212 BR-16 G705-C53 GN-16 F703-C56 GY-16 F703-CR55 GY-16 43
H762-C6 PU-16 R986-C253 BU-16 M997-C244 PU-16 127-C251 OR-16 C534-C107 YL-16 126-C271 PK-16 614-C192 PU-16 F711-C262 GN-16 605-C42 YL-16 J904-C110 GY-16 519-C129 PK-16 710-C28 GN-16 G706-C60 BU-16 E900-C57 WH-16 E900-CR56 WH-16 329-FR27 YL-16 44
K992-C8 PU-16 R985-C252 WH-16 R985-C252 WH-16 EL110-C97 OR-16 126-C19 PK-16 635-C185 BU-16 F712-C264 GY-16 605-C140 YL-16 J905-C109 PU-16 605-C140 YL-16 721-C21 BR-16 G730-C17 PK-16 E901-C58 GN-16 E901-CR57 GN-16 102-FR28 RD-16 45
R986-C253 BU-16 R986-C253 BU-16 (NOTE H) F711-C136 GN-16 321-C182 BR-16 636-C186 GN-16 J840-C189 WH-16 519-C64 PK-16 605-C155 YL-16 605-C42 YL-16 722-C22 WH-16 G756-C16 YL-16 K989-C59 BU-16 K989-CR58 BU-16 E966-E30 YL-16 46 SECONDARY SPEED/TIMING SENSOR +
C209-C274 BK-16 F712-C137 GY-16 322-C143 GY-16 892-C197 BR-16 J841-C188 YL-16 519-C1 PK-16 606-C41 GY-16 606-C41 GY-16 723-C23 OR-16 H762-C6 PU-16 G706-C60 BU-16 G706-CR59 BU-16 E965-E31 BU-16 47 SECONDARY SPEED/TIMING SENSOR -
126-C275 PK-16 H26 500-C173 BR-16 893-C196 GN-16 CBL-CC1 WH-6 519-C129 PK-16 606-C145 GY-16 606-C145 GY-16 724-C24 YL-16 J764-C20 BR-16 EL559-C61 GY-16 EL559-CR60 GY-16 48
200-C230 BK-16 127-C251 OR-16 501-C177 GN-16 A513-C233 PK-16 321-C163 BR-16 606-C154 GY-16 H19 608-C13 GN-16 725-C25 GN-16 J840-C67 WH-16 124-C62 GN-16 124-CR61 GN-16 49
EL458-C231 OR-16 201-C273 BK-16 502-C178 OR-16 EL556-C69 OR-16 321-C182 BR-16 608-C13 GN-16 608-C14 GN-16 726-C26 BU-16 J841-C187 YL-16 124-C63 GN-16 124-CR62 GN-16 E-M1 3092088 229-E16 BK-16 50
C209-C274 BK-16 201-C273 BK-16 592-C226 BU-16 EL557-C70 GN-16 321-C183 BR-16 608-C14 GN-16 611-C139 PU-16 998-C50 BR-16 K744-C10 BU-16 519-C64 PK-16 519-CR63 PK-16 229-E17 BK-16 51
K985-C169 BR-16 202-C254 BK-16 611-C179 PU-16 EL559-C61 GY-16 608-C13 GN-16 608-C166 GN-16 614-C35 PU-16 612-C38 GY-16 998-C55 BR-16 K972-C4 BR-16 635-C65 BU-16 635-CR64 BU-16 329-FR27 YL-16 52
MOTOR
202-C255 BK-16 612-C209 GY-16 EL566-C34 WH-16 608-C14 GN-16 611-C139 PU-16 614-C141 PU-16 614-C35 PU-16 A700-C54 OR-16 K972-C5 BR-16 636-C66 GN-16 636-CR65 GN-16 202-FR26 BK-16 53
RM-C20
E 127-C251 OR-16
201-C273 BK-16
298-C203 BK-16

200-C230 BK-16
A513-C233 PK-16
E790-C207 PK-16
EL623-C167 BU-16
EL624-C168 GN-16
F711-C262 GN-16 721-TR1 BR-16 1
7X6222
721-RM20 BR-16
608-C166 GN-16
126-C103 PK-16
126-C68 PK-16
611-C162 PU-16
611-C179 PU-16
635-C65 BU-16
614-C157 PU-16
614-C190 PU-16
614-C191 PU-16
614-C141 PU-16
635-C65 BU-16
635-C114 BU-16
A958-C18 WH-16
C455-C27 PU-16
E750-C36 PU-16
K988-C9 WH-16
K989-C59 BU-16
K992-C8 PU-16
J840-C67 WH-16
J841-C187 YL-16
EL556-C69 OR-16
J840-CR66 WH-16
J841-CR67 YL-16
EL556-CR68 OR-16
FR-C5 ENG_SHUTDOWN_SW.
E-C14
1552269
TWISTED WIRES
C967-E32 BU-16
54
55
56 INLET AIR TEMP. SENSOR
E
C209-C274 BK-16 200-C256 BK-16 F712-C264 GY-16 722-TR2 WH-16 2 722-RM21 WH-16 126-C184 PK-16 635-C114 BU-16 614-C192 PU-16 636-C66 GN-16 E790-C3 PK-16 X730-C33 BR-16 EL557-C70 GN-16 EL557-CR69 GN-16 1 E965-E31 BU-16 A747-E33 GY-16 57 ATMOSPHERIC PRESS. SENSOR
3E3370 197-9123
X779-C11 GY-16 200-C257 BK-16 126-C275 PK-16 126-C275 PK-16 EL721-C119 YL-16 723-TR3 OR-16 3 723-RM22 OR-16 636-C66 GN-16 636-C115 GN-16 E900-C57 WH-16 X778-C12 PU-16 2 E966-E30 YL-16 58
C209-C274 BK-16 H23 200-C230 BK-16 200-C230 BK-16 EL722-C118 WH-16 724-TR4 YL-16 4 724-RM23 YL-16 636-C115 GN-16 703-C31 BU-16 E901-C58 GN-16 X779-C11 GY-16 CONN 18 F720-FR10 PU-16 A
RD
BU 3 4 NO
CAM_SPEED/TIMING_SENSOR 59
X778-C12 PU-16 EL458-C231 OR-16 EL458-C231 OR-16 J840-C189 WH-16 725-TR5 GN-16 5 725-RM24 GN-16 EL611-C146 PU-16 704-C32 GY-16 E987-C29 WH-16 F719-FR11 WH-16 B 201-6617 60
TWISTED WIRES BK NC
R985-C252 WH-16 200-C238 BK-16 CBL-CC1 WH-6 CBL-CC1 WH-6 J841-C188 YL-16 726-TR6 BU-16 6 726-RM25 BU-16 J840-C67 WH-16 706-C212 BR-16 EL494-C40 BR-16 998-FR12 BR-16 C E-C23 TWISTED WIRES 61
1 2
R986-C253 BU-16 200-C241 BK-16 7 J840-C116 WH-16 710-C28 GN-16 EL556-C69 OR-16 1552269 A751-E34 YL-16 62 FUEL TEMP. SENSOR
J765-C242 BU-16 202-C237 BK-16 710-TR7 GN-16 8 710-RM29 GN-16 635-C65 BU-16 J841-C117 YL-16 998-C50 BR-16 721-C21 BR-16 EL557-C70 GN-16 1 E963-E23 BK-16 63
126-C275 PK-16 126-C275 PK-16 102-C71 BU-16 E987-TR8 WH-16 9 E987-RM28 WH-16 635-C185 BU-16 J841-C187 YL-16 722-C22 WH-16 EL559-C61 GY-16 126-C68 PK-16 126-CL1 PK-16 2 E964-E27 WH-16 64
200-C230 BK-16 H25 H25 200-C230 BK-16 103-C88 YL-16 10 635-C114 BU-16 998-C125 BR-16 723-C23 OR-16 EL566-C34 WH-16 202-C211 BK-16 202-CL2 BK-16 CRANK_SPEED_/TMG_SENSOR T725-E35 WH-16 65 FUEL SENSOR RESISTOR PLUG
EL458-C231 OR-16 EL458-C231 OR-16 115-C92 RD-16 H5 K972-TR9 BR-16 11 K972-RM87 BR-16 636-C66 GN-16 998-C147 BR-16 724-C24 YL-16 EL733-C47 PK-16 706-C212 BR-16 706-CL3 BR-16 214-2484 66
CBL-CC1 WH-6 H28 118-C93 GY-16 703-TR10 BU-16 12 703-RM30 BU-16 636-C115 GN-16 998-C170 BR-16 725-C25 GN-16 G704-C52 YL-16 67
119-C74 PK-16 704-TR11 GY-16 13 704-RM31 GY-16 636-C186 GN-16 998-C193 BR-16 726-C26 BU-16 G705-C53 GN-16 E-C13 TWISTED WIRES 68
120-C98 YL-16 14 J841-C187 YL-16 998-C55 BR-16 892-C122 BR-16 G706-C60 BU-16 1552269 69
126-C102 PK-16 K972-TR12 BR-16 15 K972-RM86 BR-16 J841-C188 YL-16 893-C123 GN-16 G730-C17 PK-16 G856-EH1 WH-16 1 G856-E24 WH-16 70
C533-C105 PU-16 201-C222 BK-16 126-C261 PK-16 E900-TR13 WH-16 16 E900-RM56 WH-16 J841-C117 YL-16 TWISTED WIRES 998-C50 BR-16 G756-C16 YL-16 G857-EH2 YL-16 2 G857-E28 YL-16 71
C534-C107 YL-16 201-C223 BK-16 E901-TR14 GN-16 17 E901-RM57 GN-16 J840-C189 WH-16 998-C55 BR-16 H762-C6 PU-16 G828-E53 WH-16 72 ANALOG SENSOR +5V
SERVICE 229-C224 BK-16 J764-TR15 BR-16 18 J764-RM19 BR-16 J840-C116 WH-16 998-C125 BR-16 J764-C20 BR-16 73
(NOTE D) TOOL A251-C106 BK-16 EL619-CF1 GN-16 EL619-C165 GN-16 126-TR16 PK-16 19 126-RM71 PK-16 J840-C67 WH-16 893-C194 GN-16 998-C147 BR-16 J840-C67 WH-16 74
FIRE SUPPRESSION PRESS. SW. 200-C256 BK-16 PORT 201-C222 BK-16 150-C79 OR-16 A608-CF2 GY-16 A608-C218 GY-16 20 893-C195 GN-16 A700-C54 OR-16 J841-C187 YL-16 ENGINE_OIL_PRESS_SENSOR E-C24 75
CONN TO 3E-7808(FOAM TYPE) 709-C240 BU-16 7X-6195 201-C223 BK-16 290-C152 BK-16
CONN 13 21 893-C196 GN-16 A700-C124 OR-16 K744-C10 BU-16 194-6725 3E3370 76
EL710-C239 OR-16 291-C153 BK-16 291-C153 BK-16 22 A958-C18 WH-16 K972-C4 BR-16 150-FR30 OR-18 +5 VOLTS OR-18 A G828-E54 WH-16 77
290-C152 BK-16 892-C199 BR-16 23 C455-C27 PU-16 K972-C5 BR-16 201-FR35 BK-18 GROUND YL-18 B G829-E48 GN-16 78
200-C257 BK-16 893-C194 GN-16 H27 24 892-C197 BR-16 E741-C113 YL-16 K988-C9 WH-16 X744-FR37 YL-18 SIGNAL GN-18 C 994-E25 GY-16 79
332-C111 BU-16 TWISTED WIRES A251-C106 BK-16 103-CW1 YL-16 103-C216 YL-16 892-C198 BR-16 E750-C36 PU-16 K989-C59 BU-16 496-FR33 WH-18 80
C533-C105 PU-16 200-CW2 BK-16 200-C258 BK-16 J904-C110 GY-16 892-C199 BR-16 E790-C3 PK-16 K992-C8 PU-16 ATMOSPHERIC_PRESS_SENSOR E-C25 81
150-C79 OR-16 C534-C107 YL-16 RM-C25 E741-C113 YL-16 E900-C57 WH-16 X730-C33 BR-16 163-8530 3E3370 82
229-C224 BK-16 1552252 J905-C109 PU-16 E901-C58 GN-16 X778-C12 PU-16 +5 VOLTS OR-18 A G828-E55 WH-16 N707-E37 PU-16 83 FUEL SENSOR RESISTOR PLUG
ET 200-C258 BK-16 608-CM1 GN-16 1 608-RM12 GN-16 G740-C202 BU-16 E987-C29 WH-16 X779-C11 GY-16 GROUND YL-18 B G829-E49 GN-16 84
SERVICE 893-C194 GN-16 635-CM2 BU-16 2 635-RM61 BU-16 893-C200 GN-16 EL494-C40 BR-16 496-FR34 WH-18 SIGNAL GN-18 C A747-E33 GY-16 85
PORT 892-C199 BR-16 636-CM3 GN-16 3 636-RM62 GN-16 298-C203 BK-16 893-C195 GN-16 EL556-C69 OR-16 86
9W-1951 J840-CM4 WH-16 4 J840-RM63 WH-16 893-C149 GN-16 EL557-C70 GN-16 CONNECTS TO TURBO_OUTLET_PRESS_SENSOR E-C15 87
F711-C136 GN-16 J841-CM5 YL-16 J841-RM64 YL-16 893-C123 GN-16 EL559-C61 GY-16 239-3478 1698670
H4 5
(AIR CONDITIONING) CONN. (EV-C2) 88
EL308-YF1 GY-16 F712-C137 GY-16 200-C221 BK-16 C455-CM6 PU-16 6 C455-RM26 PU-16 892-C122 BR-16 EL566-C34 WH-16 +5 VOLTS OR-18 A G828-E56 WH-16 89
200-CM7 BK-16 7 200-RM88 BK-16 892-C148 BR-16 EL611-C146 PU-16 LOC D-3 GROUND YL-18 B G829-E50 GN-16 90
TWISTED WIRES F703-CM8 GY-16 8 F703-RM55 GY-16 892-C198 BR-16 EL733-C47 PK-16 SIGNAL GN-18 C A746-E22 PK-16 91
200-YF2 GY-16 A700-CM9 OR-16 9 A700-RM53 OR-16 892-C201 BR-16 F711-C263 GN-16 VOLUME 2 OF 2 124-CR61 GN-16 92
CBL-CC1 WH-6 200-C219 BK-16 417-CM10 GY-16 10 417-RM27 GY-16 F712-C265 GY-16 124-CR62 GN-16 TURBO_INTAKE_PRESS_SENSOR E-C35 E-C9 93
(NOTE A) 200-C232 BK-16 998-CM11 BR-16 11 998-RM54 BR-16 G704-C52 YL-16 519-CR63 PK-16 150-FR31 OR-16 150-FH1 OR-16 163-8530 1698670 3E3370 94

(NOTE K) CBL-CA1 PU-6 CBL-CA2 BR-10 200-C234 BK-16

CONN 12 12 G705-C53 GN-16 CONN 16 520-CR70 WH-16 201-FR36 BK-16 201-FH2 BK-16 +5 VOLTS OR-18 A G828-E57 WH-16 95
CA-T1 3241965 CA-T2 2878915 290-C152 BK-16 A700-C124 OR-16 G706-C60 BU-16 X744-FR37 YL-18 X744-FH3 YL-16 GROUND YL-18 B G829-E51 GN-16 96
291-C153 BK-16 RM-C18 113-RM48 OR-16 A700-C204 OR-16 G730-C17 PK-16 SIGNAL GN-18 C F714-E7 PK-16 97
892-C199 BR-16 7X6222 114-RM36 GN-16 E790-C205 PK-16 G740-C112 BU-16 98
C.B_NO.1 E-C12
893-C194 GN-16 1 118-RM6 GY-16 E790-C206 PK-16 G740-C142 BU-16 T860-E38 OR-16 99 INJECTOR COMMON 5&6
6T-3643 FR-C4 FR-C16 1552273
101-CP22 RD-16 H27 A251-C106 BK-16 605-TU3 YL-16 608-HH1 GN-16 2 608-RM13 GN-16 113-RM48 OR-16 126-RM18 PK-16 E790-C3 PK-16 G756-C16 YL-16 100
101-CP23 RD-16 C533-C105 PU-16 606-TU2 GY-16 EL566-HH2 WH-16 3 EL566-RM33 WH-16 118-RM6 GY-16 417-RM27 GY-16 E790-C164 PK-16 H762-C6 PU-16 520-CR70 WH-16 1552269 3E3364 1 C991-E29 PK-16 101
15A
CP-M1 3241961 C534-C107 YL-16 614-HH3 PU-16 4 614-RM34 PU-16 126-RM18 PK-16 426-RM14 BR-16 E790-C207 PK-16 J764-C20 BR-16 200-CR71 BK-16 G740-FR14 BU-16 1 2 T725-E35 WH-16 102
C.B_NO.6 C.B_NO.11 SPARE 3.3K
113-CP27 OR-16 F711-C136 GN-16 E750-HH4 PU-16 5 E750-RM35 PU-16 604-RM1 OR-16 604-RM1 OR-16 A700-C54 OR-16 J840-C67 WH-16 298-FR17 BK-16 2 3 N707-E37 PU-16 103

D 6T-3643

15A
120-CP31 YL-16
EL110-CP30 OR-16
CP-M6 3241961
6T-3643

15A
113-CP28 OR-16
113-CP29 OR-16
CP-M11 3241961
C.B_NO.2
5H-6565
102-CP3 BU-16
102-CP2 BU-16
F712-C137 GY-16 118-HH5 GY-16
604-HH6 OR-16
612-HH7 GY-16
6
7
8
118-RM77 GY-16
604-RM74 OR-16
612-RM37 GY-16
E790-RM2 PK-16
K972-RM4 BR-16
K972-RM3 BR-16
605-RM41 YL-16
606-RM40 GY-16
608-RM12 GN-16
J840-C116 WH-16
J841-C117 YL-16
J841-C187 YL-16
FR-C6
1552269
FR-C17
3E3364
1.8K
4
5
6
G828-E58
G829-E52
WH-16
GN-16
T858-E39
T962-E40
T959-E41
GY-16
WH-16
BR-16
104
105
106
INJECTOR COMMON 1&2
INJECTOR 6
INJECTOR 3
D
30A
102-CP1 BU-16 150-C79 OR-16 537-CH3 GN-16 EL608-HH8 GN-16 9 EL608-RM38 GN-16 608-RM13 GN-16 J904-C110 GY-16 G740-FR13 BU-16 1
SPARE T961-E42 GN-16 107 INJECTOR 5
CP-M2 3241961 605-CH2 YL-16 EL565-HH9 YL-16 10 612-RM37 GY-16 612-C38 GY-16 J905-C109 PU-16 298-FR18 BK-16 2 FUEL_SENSOR_RESISTOR T960-E43 BU-16 108 INJECTOR 4
C.B_NO.7 C.B_NO.12 CP-C1 267-4011
101-C90 RD-16 606-CH4 GY-16 606-HH10 GY-16 11 606-RM40 GY-16 614-RM34 PU-16 612-C161 GY-16 K744-C10 BU-16 109
6T-3643 6T-3643 9X7147 RM-C1
127-CP35 OR-16 150-CP9 OR-16 101-C91 RD-16 605-HH11 YL-16 12 605-RM41 YL-16 113-RM48 OR-16 635-RM61 BU-16 612-C208 GY-16 K972-C4 BR-16 110
C.B_NO.3 9X4391
127-CP34 OR-16 150-CP8 OR-16 102-CP1 BU-16 1 102-C71 BU-16 102-C72 BU-16 EL714-HH12 BU-16 13 EL714-RM42 BU-16 118-RM6 GY-16 636-RM62 GN-16 612-C209 GY-16 K972-C5 BR-16 111
15A 15A 5H-6565 FR-C3 FR-C15
CP-M7 3241961 CP-M12 3241961 104-CP12 BU-16 102-CP2 BU-16 2 102-C72 BU-16 102-C73 BU-16 537-TU1 GN-16 EL322-CH1 GY-16 EL322-C220 GY-16 EL715-HH13 PU-16 14 EL715-RM43 PU-16 126-RM18 PK-16 703-RM30 BU-16 K972-C4 BR-16 K972-C120 BR-16 1 H1 112
104-CP11 BU-16 102-CP3 BU-16 3 102-C73 BU-16 102-C80 RD-16 605-CH2 YL-16 605-C180 YL-16 EL712-HH14 PK-16 15 EL712-RM44 PK-16 604-RM1 OR-16 704-RM31 GY-16 K972-C5 BR-16 K992-C8 PU-16 604-RM1 OR-16 2 604-CR1 OR-16 1698670 2128436 113
30A H3
119-CP7 PK-16 126-CP39 PK-16 CP-M3 3241961 119-CP4 PK-16 4 119-C74 PK-16 102-C84 RD-16 537-CH3 GN-16 537-C259 GN-16 EL713-HH15 YL-16 16 EL713-RM45 YL-16 E790-RM2 PK-16 710-RM29 GN-16 K972-C120 BR-16 K988-C9 WH-16 E790-RM2 PK-16 3 E790-CR2 PK-16 614-FR4 PU-16 A E-C11 114
C.B_NO.8 C.B_NO.13 1552252
119-CP6 PK-16 126-CP38 PK-16 119-CP5 PK-16 5 119-C75 PK-16 104-C81 BU-16 EL322-CH1 GY-16 606-CH4 GY-16 606-C181 GY-16 17 K972-RM4 BR-16 721-RM20 BR-16 K972-C210 BR-16 K989-C59 BU-16 K972-RM3 BR-16 4 K972-CR3 BR-16 614-FR15 PU-16 B T859-E44 WH-16 115 INJECTOR COMMON 3&4
6T-3643
119-CP5 PK-16
6T-3643
126-CP37 PK-16 119-CP6 PK-16 6 119-C76 PK-16 104-C82 BU-16 18 TWISTED WIRES K972-RM3 BR-16 722-RM21 WH-16 X730-C33 BR-16 K972-RM4 BR-16 5 K972-CR4 BR-16 614-FR16 PU-16 C (NOTE C) 1 T957-E45 PU-16 T957-E45 PU-16 116 INJECTOR 1
C.B_NO.4
119-CP4 PK-16 164-CP36 WH-16 102-CP14 RD-16 119-CP7 PK-16 7 119-C77 PK-16 105-C83 BR-16 19 723-RM22 OR-16 X778-C12 PU-16 H762-RM5 PU-16 6 H762-CR5 PU-16 2 T958-E46 YL-16 117
15A 15A 6T-3643
CP-M8 3241961 CP-M13 3241961 105-CP13 BR-16 150-CP8 OR-16 8 150-C78 OR-16 113-C49 OR-16 113-HH16 OR-16 20 113-RM68 OR-16 724-RM23 YL-16 X779-C11 GY-16 118-RM6 GY-16 7 118-CR6 GY-16 3 T959-E41 BR-16 T958-E46 YL-16 118 INJECTOR 2

15A
102-CP10 RD-16 150-CP9 OR-16 9 150-C79 OR-16 113-C95 OR-16 21 725-RM24 GN-16 K992-RM7 PU-16 8 K992-CR7 PU-16 4 T960-E43 BU-16 119
FR-C7 LH_PARK/TURN_LIGHT
CP-M4 3241961 102-CP10 RD-16 10 102-C80 RD-16 113-C96 OR-16 103-CU1 YL-16 103-C215 YL-16 EL559-HH17 GY-16 22 EL559-RM60 GY-16 113-RM67 OR-16 726-RM25 BU-16 K988-RM8 WH-16 9 K988-CR8 WH-16 5 T961-E42 GN-16 120
C.B_NO.9 C.B_NO.14 1698670 334-5409
104-CP11 BU-16 11 104-C81 BU-16 114-C37 GN-16 537-C259 GN-16 EL556-HH18 OR-16 23 EL556-RM65 OR-16 113-RM68 OR-16 998-RM49 BR-16 496-C269 WH-16 K744-RM9 BU-16 10 K744-CR9 BU-16 6 T962-E40 WH-16 E-C2
6N-9349 6T-3643
124-CP32 GN-16 104-CP12 BU-16 12 104-C82 BU-16 114-C87 GN-16 537-CU2 GN-16 EL557-HH19 GN-16 24 EL557-RM66 GN-16 118-RM77 GY-16 998-RM54 BR-16 G740-C142 BU-16 892-C198 BR-16 X779-RM10 GY-16 11 X779-CR10 GY-16 605-FR3 YL-16 A RD-18 T 7 T858-E39 GY-16 2645732
C.B_NO.5
124-CP33 GN-16 138-CP15 GN-16 103-CP20 YL-16 105-CP13 BR-16 13 105-C83 BR-16 115-C89 RD-16 126-RM71 PK-16 A700-RM53 OR-16 G740-C112 BU-16 893-C195 GN-16 X778-RM11 PU-16 12 X778-CR11 PU-16 200-FR19 BK-16 B BK-18 G 8 T859-E44 WH-16
15A
CP-M9 3241961
15A
CP-T14 3241959
6T-3643
115-CP21 RD-16 102-CP14 RD-16 14 102-C84 RD-16 118-C86 GY-16 CONN 11 200-RM88 BK-16 A958-RM17 WH-16 G740-C202 BU-16 G740-C202 BU-16 608-RM12 GN-16 13 608-CR12 GN-16 614-FR16 PU-16 C WH-18 P 9 T860-E38 OR-16 E-C4 E-C29
115-CP24 RD-16 138-CP15 GN-16 15 138-C85 GN-16 118-C7 GY-16 417-RM27 GY-16 C455-RM26 PU-16 608-RM13 GN-16 14 608-CR13 GN-16 10 1552252 2131434
15A
CP-M5 3241961 118-CP16 GY-16 16 118-C86 GY-16 119-C75 PK-16 SPARE 2 103-C217 YL-16 604-RM74 OR-16 E750-RM35 PU-16 426-RM14 BR-16 15 426-CR14 BR-16 FR-C8 11 G829-E47 GN-16 1
C.B_NO.10 C.B_NO.15 H23
114-CP26 GN-16 118-CP16 GY-16 118-CP17 GY-16 17 118-C7 GY-16 119-C77 PK-16 E790-RF1 PK-16 E790-RM79 PK-16 605-RM41 YL-16 E790-RM2 PK-16 496-C269 WH-16 G756-RM15 YL-16 16 G756-CR15 YL-16 1552269 12 G829-E48 GN-16 2
6T-3643 6T-3643
114-CP18 GN-16 118-CP17 GY-16 113-CP27 OR-16 114-CP18 GN-16 18 114-C37 GN-16 119-C76 PK-16 SPARE 1 EL721-C119 YL-16 G704-RF2 YL-16 G704-RM51 YL-16 606-RM40 GY-16 E900-RM56 WH-16 F711-C136 GN-16 892-C198 BR-16 G730-RM16 PK-16 17 G730-CR16 PK-16 G829-E49 GN-16 3
EL619-FR1 GN-16 1 WH-18
114-CP19 GN-16 118-CP25 GY-16 113-CP28 OR-16 114-CP19 GN-16 19 114-C87 GN-16 124-C62 GN-16 EL722-C118 WH-16 113-RF3 OR-16 113-RM67 OR-16 608-RM12 GN-16 E901-RM57 GN-16 F711-C262 GN-16 893-C195 GN-16 A958-RM17 WH-16 18 A958-CR17 WH-16 G829-E50 GN-16 4
15A 15A 200-FR20 BK-16 2 BK-18
CP-M10 3241961 CP-M15 3241961 113-CP29 OR-16 103-CP20 YL-16 20 103-C88 YL-16 124-C63 GN-16 998-RF4 BR-16 998-RM49 BR-16 608-RM13 GN-16 E987-RM28 WH-16 F711-C263 GN-16 G740-C202 BU-16 126-RM18 PK-16 19 126-CR18 PK-16 G829-E51 GN-16 5
114-CP18 GN-16 115-CP21 RD-16 21 115-C89 RD-16 126-C103 PK-16 TWISTED WIRES F713-RF5 OR-16 F713-RM50 OR-16 612-RM37 GY-16 EL494-RM39 BR-16 F712-C137 GY-16 J764-RM19 BR-16 20 J764-CR19 BR-16 G829-E52 GN-16 6
LH_LOW_BEAM_LIGHT
114-CP19 GN-16 101-CP22 RD-16 22 101-C90 RD-16 127-C99 OR-16 H2 614-RM34 PU-16 EL456-RM47 WH-16 F712-C264 GY-16 721-RM20 BR-16 21 721-CR20 BR-16 171-2066 G828-E53 WH-16 7
114-CP26 GN-16 101-CP23 RD-16 23 101-C91 RD-16 127-C100 OR-16 H29 H29 635-RM61 BU-16 EL556-RM65 OR-16 F712-C265 GY-16 722-RM21 WH-16 22 722-CR21 WH-16 G828-E54 WH-16 8
118-CP16 GY-16 24 138-C85 GN-16 636-RM62 GN-16 EL557-RM66 GN-16 403-C130 GN-16 723-RM22 OR-16 23 723-CR22 OR-16
FR-C9
(NOTE L) G828-E55 WH-16 9
114-CP18 GN-16 118-CP17 GY-16 115-CP24 RD-16 25 115-C92 RD-16 150-C78 OR-16 635-C185 BU-16 G705-RF6 GN-16 G705-RM52 GN-16 703-RM30 BU-16 EL559-RM60 GY-16 403-C266 GN-16 724-RM23 YL-16 24 724-CR23 YL-16 G828-E56 WH-16 10
114-CP19 GN-16 118-CP25 GY-16 118-CP25 GY-16 E790-RF7 PK-16 E790-RM78 PK-16 704-RM31 GY-16 EL566-RM33 WH-16 403-C267 GN-16 725-RM24 GN-16 725-CR24 GN-16 1552269 G828-E57 WH-16
26 118-C93 GY-16 164-C101 WH-16 636-C186 GN-16 25 11
114-CP26 GN-16 119-CP4 PK-16 114-CP26 GN-16 27 114-C94 GN-16 EL110-C97 OR-16 CONNECTS TO J840-C189 WH-16 710-RM29 GN-16 EL608-RM38 GN-16 496-C268 WH-16 202-C211 BK-16 726-RM25 BU-16 26 726-CR25 BU-16 EL611-FR9 PU-16 1 WH-18 G828-E58 WH-16 12
119-CP4 PK-16
119-CP5 PK-16
119-CP5 PK-16
119-CP6 PK-16
113-CP27 OR-16
113-CP28 OR-16
28
29
113-C49 OR-16
113-C95 OR-16
CONN.(PL-C1) J841-C188 YL-16
592-C226 BU-16 703-TR10 BU-16
CONN 10 721-RM20 BR-16
722-RM21 WH-16
EL712-RM44 PK-16
EL713-RM45 YL-16
496-C269 WH-16
496-C270 WH-16
C455-RM26 PU-16
417-RM27 GY-16
27
28
C455-CR26 PU-16
417-CR29 GY-16
200-FR21 BK-16 2 BK-18

119-CP6 PK-16 119-CP7 PK-16 113-CP29 OR-16 30 113-C96 OR-16 (ENCLOSED ROPS) 118-C86 GY-16 K972-TR9 BR-16 723-RM22 OR-16 EL714-RM42 BU-16 E987-RM28 WH-16 29 E987-CR28 WH-16 LH_HIGH_BEAM_LIGHT
119-CP7 PK-16 120-CP31 YL-16 EL110-CP30 OR-16 31 EL110-C97 OR-16 LOC H-9 115-C89 RD-16 724-RM23 YL-16 EL715-RM43 PU-16 710-RM29 GN-16 30 710-CR27 GN-16 171-2067
120-CP31 YL-16
124-CP32 GN-16
124-CP32 GN-16
124-CP33 GN-16
120-CP31 YL-16
124-CP32 GN-16
32
33
120-C98 YL-16
124-C62 GN-16
102-C71 BU-16
103-C88 YL-16
VOL 2 OF 2 612-C208 GY-16
614-C191 PU-16
126-RM90 PK-16
X778-RM11 PU-16
725-RM24 GN-16
726-RM25 BU-16
EL733-RM46 PK-16
F703-RM55 GY-16 126-C271 PK-16
703-RM30 BU-16
704-RM31 GY-16
31
32
703-CR30 BU-16
704-CR31 GY-16
(NOTE L)
124-CP33 GN-16 126-CP38 PK-16 124-CP33 GN-16 34 124-C63 GN-16 115-C92 RD-16 F711-C262 GN-16 202-RM89 BK-16 998-RM49 BR-16 F713-RM50 OR-16 496-C269 WH-16 X730-RM32 BR-16 33 X730-CR32 BR-16 FR-C13 RH_PARK/TURN_LIGHT
H31
127-CP34 OR-16 126-CP37 PK-16 127-CP34 OR-16 35 127-C99 OR-16 118-C93 GY-16 CONN 7 F712-C264 GY-16 704-TR11 GY-16
TWISTED WIRES
X779-RM10 GY-16 998-RM54 BR-16 G704-RM51 YL-16 EL566-RM33 WH-16 34 EL566-CR33 WH-16 1698670 334-5409
127-CP35 OR-16 126-CP39 PK-16 127-CP35 OR-16 36 127-C100 OR-16 119-C74 PK-16 H28 119-C75 PK-16 K972-TR12 BR-16 A700-RM53 OR-16 G705-RM52 GN-16 614-RM34 PU-16 35 614-CR34 PU-16 606-FR8 GY-16 A RD-18 T
EL110-CP30 OR-16 127-CP34 OR-16 164-CP36 WH-16 37 164-C101 WH-16 120-C98 YL-16 CONNECTS TO EL623-C167 BU-16 C455-RM26 PU-16 G706-RM59 BU-16 E750-RM35 PU-16 36 E750-CR35 PU-16 200-FR22 BK-16 B BK-18 G
127-CP35 OR-16 126-CP37 PK-16 38 126-C102 PK-16 126-C102 PK-16 EL624-C168 GN-16 RM-C9 E750-RM35 PU-16 G730-RM16 PK-16 114-RM36 GN-16 37 114-CR36 GN-16
CONN.(PR-C1) 614-FR15 PU-16 C WH-18 P
138-CP15 GN-16 126-CP38 PK-16 39 126-C261 PK-16 126-C261 PK-16 614-C192 PU-16 1552272 E790-RM78 PK-16 G756-RM15 YL-16 612-RM37 GY-16 38 612-CR37 GY-16
TWISTED WIRES
150-CP8 OR-16 126-CP39 PK-16 40 126-C103 PK-16 (OPEN ROPS) EL566-C34 WH-16 710-TR7 GN-16 1 113-RM69 OR-16 E790-RM79 PK-16 H762-RM5 PU-16 EL608-RM38 GN-16 39 EL608-CR38 GN-16
150-CP9 OR-16 A513-C233 PK-16 E987-TR8 WH-16 2 E900-RM56 WH-16 J764-RM19 BR-16 EL494-RM39 BR-16 40 EL494-CR39 BR-16 FR-C11
164-CP36 WH-16 CONN 4 CONNECTS TO LOC F-9 503-C171 BR-16 3 202-RM91 BK-16 E901-RM57 GN-16 J840-RM63 WH-16 606-RM40 GY-16 41 606-CR40 GY-16 1552269
VOL 2 OF 2
C EL110-CP30 OR-16
114-C94 GN-16
CONN.(AS-C1)
LOC C-10
504-C172 YL-16
892-C197 BR-16
893-C196 GN-16
4 G756-RM15 YL-16 E987-RM28 WH-16
EL556-RM65 OR-16
EL557-RM66 GN-16
J841-RM64 YL-16
K744-RM9 BU-16
K972-RM3 BR-16
605-RM41 YL-16
EL714-RM42 BU-16
EL715-RM43 PU-16
42
43
44
605-CR41 YL-16
EL714-CR42 BU-16
EL715-CR43 PU-16
611-FR2 PU-16
200-FR23 BK-16
1
2
WH-18
BK-18 C
EL559-C61 GY-16 E900-TR13 WH-16 EL559-RM60 GY-16 K972-RM4 BR-16 EL712-RM44 PK-16 45 EL712-CR44 PK-16 RH_HIGH_BEAM_LIGHT
VOL 2 OF 2 EL556-C69 OR-16 E901-TR14 GN-16 H5 126-RM70 PK-16 EL566-RM33 WH-16 K992-RM7 PU-16 EL713-RM45 YL-16 46 EL713-CR45 YL-16 171-2067
EL557-C70 GN-16 202-RM92 BK-16 EL608-RM38 GN-16 K988-RM8 WH-16 EL733-RM46 PK-16 47 EL733-CR46 PK-16
X730-RM32 BR-16 EL712-RM44 PK-16 K989-RM58 BU-16 EL456-RM47 WH-16 48 EL456-CR47 WH-16
FR-C12
(NOTE L)
EL713-RM45 YL-16 X730-RM32 BR-16 113-RM48 OR-16 49 113-CR48 OR-16
RM-C6 1552269
417-TE1 GY-16 417-CM10 GY-16 EL714-RM42 BU-16 X779-RM10 GY-16 998-RM49 BR-16 50 998-CR49 BR-16
15 619-FR7 GN-16
(NOTE A) F703-TE2 GY-16 F703-CM8 GY-16 725-A2 GN-16 721-A6 BR-16 721-TR1 BR-16 EL715-RM43 PU-16 X778-RM11 PU-16 F713-RM50 OR-16 51 F713-CR50 OR-16
200-FR24 BK-16
1
2
WH-18
BK-18
A700-TE3 OR-16 A700-CM9 OR-16 308-A7 YL-16 722-A5 WH-16 722-TR2 WH-16 (PORT C1) 1 K988-RM8 WH-16 F703-RM55 GY-16 G704-RM51 YL-16 52 G704-CR51 YL-16
998-TE4 BR-16 998-CM11 BR-16 721-A6 BR-16 723-A4 OR-16 723-TR3 OR-16 2 E790-RM81 PK-16 F713-RM50 OR-16 G705-RM52 GN-16 53 G705-CR52 GN-16
723-A4 OR-16 G704-RM51 YL-16 A700-RM53 OR-16 54 A700-CR53 OR-16 RH_LOW_BEAM_LIGHT
CONN 6 724-A3 YL-16 724-TR4 YL-16 G705-RM52 GN-16 998-RM54 BR-16 55 998-CR54 BR-16 171-2066
417-TE1 GY-16 726-A1 BU-16 725-A2 GN-16 725-TR5 GN-16 J764-RM19 BR-16 F703-RM55 GY-16 56 F703-CR55 GY-16 (NOTE L)
201-TE5 BK-16 724-A3 YL-16 231-A8 BK-16 J764-TR15 BR-16 (PORT C2) K744-RM9 BU-16 J840-RM63 WH-16 E900-RM56 WH-16 57 E900-CR56 WH-16
726-A1 BU-16 726-TR6 BU-16 E790-RM80 PK-16 J841-RM64 YL-16 E901-RM57 GN-16 58 E901-CR57 GN-16 200-FR25 BK-16
608-PJ1 GN-16 608-CM1 GN-16 722-A5 WH-16 K972-RM86 BR-16 K989-RM58 BU-16 59 K989-CR58 BU-16 322-FR6 GY-16
635-PJ2 BU-16 635-CM2 BU-16 231-A8 BK-16 308-A7 YL-16 126-TR16 PK-16 K972-RM87 BR-16 RM-C21 RM-C29 G706-RM59 BU-16 60 G706-CR59 BU-16 HR-C1 FR-C10
636-PJ3 GN-16 636-CM3 GN-16 113-RM48 OR-16 113-RM48 OR-16 1552264 2106311 EL559-RM60 GY-16 61 EL559-CR60 GY-16 3E3364 1552269
J840-PJ4 WH-16
J841-PJ5 YL-16
J840-CM4 WH-16
J841-CM5 YL-16
H4 CONN 8 H4 (PORT S1) K989-RM58 BU-16
E790-RM83 PK-16
113-RM67 OR-16
113-RM68 OR-16
113-RM67 OR-16
113-RM68 OR-16
113-RM48
113-RM67
OR-16
OR-16
1
2
62
63
322-HR1 GY-16 1 322-FR6 GY-16
200-HR6 BK-16 2 200-FR25 BK-16
C455-CM6 PU-16 118-RM6 GY-16 118-RM6 GY-16 113-RM68 OR-16 3 64
200-PJ6 BK-16 200-CM7 BK-16 118-RM77 GY-16 118-RM77 GY-16 113-RM69 OR-16 4 635-RM61 BU-16 65 635-CR64 BU-16
126-RM18 PK-16 126-RM18 PK-16 126-RM18 PK-16 5 636-RM62 GN-16 66 636-CR65 GN-16 HR-C3 HR-C2
A700-RT1 BU-16 A700-TE3 OR-16 (PORT S2) G706-RM59 BU-16 114-RM36 GN-16 126-RM71 PK-16 126-RM71 PK-16 126-RM70 PK-16 6 J840-RM63 WH-16 67 J840-CR66 WH-16 2131435 1552273
998-RT2 BU-16 998-TE4 BR-16 E790-RM82 PK-16 426-RM14 BR-16 200-RM88 BK-16 200-RM88 BK-16 126-RM71 PK-16 7 J841-RM64 YL-16 68 J841-CR67 YL-16 1 322-HR1 GY-16
F703-TE2 GY-16 A958-RM17 WH-16 604-RM1 OR-16 604-RM1 OR-16 126-RM90 PK-16 8 EL556-RM65 OR-16 69 EL556-CR68 OR-16 2 322-HR2 GY-16
F703-RT3 BU-16 EL494-RM39 BR-16 604-RM74 OR-16 604-RM74 OR-16 EL557-RM66 GN-16 70 EL557-CR69 GN-16 HR-C4 HORN_1
RESISTOR HARNESS 268-6074 CONN 5 EL456-RM47 WH-16 E790-RM2 PK-16 E790-RM2 PK-16 RM-C22 RM-C30
3
4
322-HR3
200-HR4
GY-16
BK-16 1552269 174-7875 SYMBOL DESCRIPTION
5.1K (PORT 5) 118-RM75 GY-16 EL733-RM46 PK-16 E790-RM78 PK-16 E790-RM78 PK-16 1552264 2106311 CONN 17 5 200-HR5 BK-16 322-HR3 GY-16 1 BK-18
604-RM72 OR-16 G706-RM59 BU-16 E790-RM79 PK-16 E790-RM79 PK-16 604-RM1 OR-16 1
608-TY2 GN-16 CONN 9 G730-RM16 PK-16 K972-RM3 BR-16 K972-RM3 BR-16 604-RM72 OR-16 2
6 200-HR6 BK-16 200-HR4 BK-16 2 BK-18
CIRCUIT CONNECTED
608-PJ1 GN-16 608-TY20 GN-16 G756-RM15 YL-16 K972-RM4 BR-16 K972-RM4 BR-16 604-RM73 OR-16 3
TWISTED WIRES HORN_2
200-PJ6 BK-16 608-TY21 GN-16 H762-RM5 PU-16 K972-RM86 BR-16 K972-RM86 BR-16 604-RM74 OR-16 4 HR-C5
614-TY4 PU-16 113-TY1 OR-16 113-HH16 OR-16 K744-RM9 BU-16 K972-RM87 BR-16 K972-RM87 BR-16 118-RM6 GY-16 5 1552269 174-7876 CIRCUIT NOT CONNECTED
(NOTE L) 614-TY22 PU-16 608-TY2 GN-16 608-HH1 GN-16 (PORT 6) 118-RM76 GY-16 K988-RM8 WH-16 118-RM75 GY-16 6
322-HR2 GY-16 1 BK-18
614-TY23 PU-16 EL566-TY3 WH-16 EL566-HH2 WH-16 604-RM73 OR-16 K989-RM58 BU-16 118-RM76 GY-16 7
200-HR5 BK-16 2 BK-18 ELECTRICAL CONNECTION TO
604-TY24 OR-16 614-TY4 PU-16 614-HH3 PU-16 K992-RM7 PU-16 118-RM77 GY-16 8
604-TY25 OR-16 E750-TY5 PU-16 E750-HH4 PU-16 X730-RM32 BR-16 MACHINE STRUCTURE
604-TY7 OR-16 118-TY6 GY-16 118-HH5 GY-16 X779-RM10 GY-16
EL608-TY26 GN-16 604-TY7 OR-16 604-HH6 OR-16 X778-RM11 PU-16 RM-C23 RM-C31 INTERNAL ELECTRICAL CONNECTION
635-PJ2 BU-16 EL608-TY27 GN-16 612-TY8 GY-16 612-HH7 GY-16 TWISTED WIRES 1552264 2106312 TO SURFACE OF COMPONENT
636-PJ3 GN-16 EL608-TY9 GN-16 EL608-TY9 GN-16 EL608-HH8 GN-16 (PORT 8) K992-RM7 PU-16 E790-RM78 PK-16 1
EL565-TY10 YL-16 EL565-HH9 YL-16 202-RM93 BK-16 113-RM69 OR-16 113-RM69 OR-16 E790-RM79 PK-16 2
CONNECTOR
EL608-TY9 GN-16 606-TY11 GY-16 606-HH10 GY-16 118-RM75 GY-16 118-RM75 GY-16 E790-RM2 PK-16 3
605-TY12 YL-16 605-HH11 YL-16 118-RM76 GY-16 118-RM76 GY-16 4
113-TY1 OR-16 EL714-TY13 BU-16 EL714-HH12 BU-16 H3 H3 126-RM70 PK-16 126-RM70 PK-16 E790-RM80 PK-16 5
H#
118-TY6 GY-16 EL715-TY14 PU-16 EL715-HH13 PU-16 126-RM90 PK-16 126-RM90 PK-16 E790-RM81 PK-16 6
CIRCUIT GROUPING DESIGNATION
J840-PJ4 WH-16 604-TY7 OR-16 EL712-TY15 PK-16 EL712-HH14 PK-16 (PORT 7) H762-RM5 PU-16 201-RM95 BK-16 201-RM95 BK-16 E790-RM82 PK-16 7

B J841-PJ5 YL-16 605-TY12 YL-16

606-TY11 GY-16
608-TY2 GN-16
EL713-TY16 YL-16 EL713-HH15 YL-16 202-RM94 BK-16 202-RM89 BK-16
202-RM91 BK-16
202-RM92 BK-16
202-RM89 BK-16
202-RM91 BK-16
202-RM92 BK-16
E790-RM83 PK-16

RM-C24
8

RM-C32
ATCH WIRE, CABLE, COMPONENT B
612-TY8 GY-16 202-RM93 BK-16 202-RM93 BK-16 1552264 2106312
614-TY4 PU-16 202-RM94 BK-16 202-RM94 BK-16 K972-RM84 BR-16 1 SPLICE
E750-TY5 PU-16 G730-RM16 PK-16 604-RM72 OR-16 604-RM72 OR-16 K972-RM85 BR-16 2
EL557-TY19 GN-16 EL559-TY17 GY-16 EL559-HH17 GY-16 K972-RM84 BR-16 604-RM73 OR-16 604-RM73 OR-16 K972-RM4 BR-16 3
BLADE, SPADE, RING OR SCREW
EL556-TY18 OR-16 EL556-TY18 OR-16 EL556-HH18 OR-16 E790-RM80 PK-16 E790-RM80 PK-16 K972-RM86 BR-16 4
EL559-TY17 GY-16 EL557-TY19 GN-16 EL557-HH19 GN-16 E790-RM82 PK-16 E790-RM81 PK-16 K972-RM87 BR-16 5
TERMINAL
200-RL12 BK-16
EL565-TY10 YL-16 E790-RM81 PK-16 E790-RM82 PK-16 K972-RM3 BR-16 6
200-RL13 BK-16
EL566-TY3 WH-16 E790-RM83 PK-16 E790-RM83 PK-16 7
200-RL14 BK-16
A958-RM17 WH-16 K972-RM84 BR-16 K972-RM84 BR-16 8
200-RL15 BK-16
K972-RM85 BR-16 K972-RM85 BR-16 K972-RM85 BR-16
200-RL16 BK-16
G704-RF2 YL-16 202-RM93 BK-16
(NOTE L) 200-RL17
200-RL18
BK-16
BK-16
604-TY7 OR-16
608-TY2 GN-16
E790-RF1 PK-16 202-RM94 BK-16
RM-M1
3092088 WIRE GROUP COLOR DESCRIPTIONS
EL714-TY13 BU-16
200-RL19 BK-16 614-TY4 PU-16
EL715-TY14 PU-16 SPARE 426-RM14 BR-16
202-RL20 BK-16
604-TY7 OR-16
PAYLOAD SPARES EL712-TY15 PK-16 201-RM95 BK-16 GROUND CIRCUIT
EL713-TY16 YL-16 G705-RF6 GN-16 200-RM88 BK-16
608-TY2 GN-16 RM-M2
614-TY4 PU-16
E790-RF7 PK-16 201-RM95 BK-16
3092088 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
H2 H2 EL733-RM46 PK-16 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
612-RL1 GY-16 612-TY8 GY-16
EL494-RM39 BR-16
202-RM89 BK-16 ABBREV COLOR VOLTAGE CONVERTER OUTPUT CIRCUIT
202-RM91 BK-16
606-RL2 GY-16 606-TY11 GY-16 RM-M3
605-RL3 YL-16 605-TY12 YL-16
447-RE1 PK-16
200-RE2 BK-16
113-RF3 OR-16
998-RF4 BR-16 CONNECTS TO EL456-RM47 WH-16
202-RM92 BK-16
3092088 RD RED STARTING & RUN CIRCUIT
604-RL4 OR-16 604-TY25 OR-16
F713-RF5 OR-16 CONN.(AL-C4) 114-RM36 GN-16
604-RL5 OR-16 604-TY24 OR-16
WH WHITE POWER TRAIN
EL608-RL6 GN-16 EL608-TY27 GN-16 (AUTO LUBE)
EL608-RL7 GN-16 EL608-TY26 GN-16
LOC C-8 MONITOR CIRCUIT
614-RL8 PU-16 614-TY22 PU-16
VOL 2 OF 2
OR ORANGE
614-RL9 PU-16 614-TY23 PU-16 ENGINE CONTROL CIRCUIT
608-RL10 GN-16 608-TY21 GN-16
608-RL11 GN-16 608-TY20 GN-16 YL YELLOW HEATER AND AIR CONDITIONER CIRCUIT
(NOTE L) CONN 1 PK PINK TURN SIGNAL / WIPER WASHER CIRCUIT
CAT DATA LINK
BK BLACK
CAN DATA LINK
GY GRAY PAYLOAD CONTROL CIRCUIT
113-TP1 OR-16
202-TP2 BK-16
113-TY1 OR-16
E750-TY5 PU-16
COMPONENTS ARE SHOWN INSTALLED ON A FULLY
E750-TP3 PU-16 CALLOUTS OPERABLE MACHINE WITH THE KEY AND ENGINE OFF. PU PURPLE ENGINE MASTER CIRCUIT
TRANSMISSION SHIFTER IN NEUTRAL AND WITH PARK BRAKE SET. BR BROWN OTHER COLOR DESCRIPTIONS
Callout Number Component SPEED SELECT SW IS SHOWN IN LOW SPEED MODE. GN GREEN HIGHWAYS
A 202-TP2 BK-16 (Machine Location from
Component Locations Table)
(52) VALVE GP - CONTROL Name
LOOPED PLUGS DETAILED ON THIS SCHEMATIC ARE BU BLUE
A
138-1234 Part Number USED (IN PLACES INDICATED ) WHEN OPTIONAL
SYSTEMS ARE NOT FITTED.
118-TY6 GY-16
EL565-TY10 YL-16 NOTES ALL WIRES ARE 16 GAUGE UNLESS OTHERWISE THIS SCHEMATIC IS FOR THE AD30 GXR1-UP UAT ELECTRICAL SYSTEM
A : STANDARD CONFIGURE. NOTED.
B : HARNESS IS FITTED WHEN PUSH TO ENGAGE OPTION IS FITTED.
COMPONENTS ARE SHOWN INSTALLED ON A FULLY MEDIA NUMBER: UENR4825
C : THIS SPLICE RECEPTACLE IS FITTED WHEN THE FRONT PARK LIGHTS ARE REQUIRED.
D : PRESSURIZE SYSTEM MAINTAINS THE SW. IN THE CLOSED POSITION. (FOAM TYPE) OPERABLE MACHINE WITH THE KEY AND ENGINE OFF. Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
CONNECTS TO E : THIS HARNESS IS FITTED WHEN FIRE SUPPRESSION SYSTEM (DRY POWDER TYPE) IS FITTED. in neutral and with parking brake set.
EL559-TY17 GY-16
(CAMERA BALUM) CONNECTOR EL556-TY18 OR-16 F : ELECTRONIC ACCESS MODULE (VIMS) HAS ONE 70 PIN PLUGS.
PART NUMBERS ON THIS SCHEMATIC ARE FOR
LOC B-13 EL557-TY19 GN-16
G : NO LONGER USED REFERENCE ONLY, USE RELEVANT PARTS BOOK FOR Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
EL566-TY3 WH-16
VOLUME 2 OF 2 H : NO LONGER USED ORDERING NEW PARTS. Note: Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
J : SPLICE RECEPTACLE REMOVED WHEN IDLE TIMER/FIRE SUPPRESSION (FOAM TYPE) IS INSTALLED
K : FIRE SUPPRESSION (DRY TYPE) HARNESS INTERCONNECTS
L : LED LIGHT OPTION

14 13 12 11 10 9 8 7 6 5 4 3 2 1
 UENR4825-00
SEPTEMBER 2014
Component - Volume 2 Schematic Machine Schematic Machine
Component - Volume 2
Location Location Location Location
Alarm - Action J-4 106 Pin - Payload Rh D-13 143
Antenna - Payload C-10 107 Pin - Payload Lh D-13 144

UENR4825-00 VOL 2 of 2
Batteries C-3 108 Plug - Harness Code I-7 145
Cable -Data Download B-8 NA Power Port - 12V G-10 146 131 143
Camera B-14 109 Receptacle - Aux Start C-3 147
Camera Balun B-13 110 Receptacle - Loop (Dash Dimmer) G-5 148

(Dimensions: 48 inches x 35 inches)

Control - Auto Lube System C-8 111 Relay - A/C D-5 149
Control - Fire Suppression (Dry Powder Type) E-14 112 Relay - Rear Light/Backup Light J-10 150
Control - Idle Timer/Fire Suppression (Foam Type) C-13 & B-13 113 Sensor - Hoist Control Position B-10 151
Display - Payload D-9 114 Sensor - Shift Lever Position A-10 152
Ecm Mid:030 (Monitoring System) I-8 115 Solenoid - A/C Compressor B-6 153
Ecm MID:0161 (Vims) H-13 116 Solenoid - Auto Lube Pilot Oil Control C-7 154
Fan Motor E-5 117 Solenoid - Auto Lube Pilot Oil Supply B-7 155 109
Fuse - 500A (Dual Pole Battery Disconnect Switch) C-2 118 Sonar - Fire Control B-12 156
Fuse - Receptacle (Cab Pressurizer) E-5 119 Suppressor - A/C Compressor B-6 157
Fuse - Receptacle (Payload) D-11 120 Suppressor - Arc (Cab Pressurizer) E-5 158 AD30 UAT
Isolator - Battery Electrical C-4 121 Suppressor - Arc (Start Relay Magnetic Switch) B-4 159
Lamp - Dash 1 F-6 122 Switch - A/C D-3 160 Electrical System
Lamp - Dash 2 F-6 123 Switch - Auto Lube (Pilot Oil) C-7 161
110 Serial #:
Lamp - Dome G-13 124 Switch - Auto Lube Pressure B-7 162
GXR1-UP
Lamp - Payload F-12 125 Switch - Auto Retarder Control H-5 163
Lamp Panel - Center Warning I-6 126 Switch - Battery Disconnect (Dual Pole) C-2 164
Lamp Panel - Side Warning H-7 127 Switch - Block Light/ Rear Cab Flood Light H-6 165
Light - Block F-12 128 Switch - Door (Dome Lamp) G-12 166
Light - Rear Cab F-12 129 Switch - Fan Speed E-3 167

36 Page,
Linear Cable - Detect Wire E-12 NA Switch - Fire Suppression (Dry Powder Type) E-12 168 111 162
Loadcell - Lh D-12 130 Switch - Head Light H-7 169 130 144
Loadcell - Rh D-12 131 Switch - Front Window Wiper/Washer F-4 170 154
Module - Gauge I-6 132 Switch - Key Start F-7 171
Module - Speed/Tacho J-6 133 Switch - Operator Mode Scroll H-4 172
Monitor - Balun J-10 134 Switch - Rear Light/Backup Light H-6 173
Monitor - Camera J-10 135 Switch - Rear Window Wiper/Washer G-6 174
Monitor - Power Harness J-10 136 Switch - Refrigerant Pressure G-7 175 168 138
Motor - Front Window Washer D-8 137 Switch - Start Relay Magnetic B-3 176 155
Motor - Gas (Dry Type) E-12 138 Switch - Tailgate A-14 177
Motor - Rear Window Washer D-8 139 Switch - Throttle Backup D-5 178
Motor - Rear Window Wiper G-12 140 Switch - Truck Payload G-4 179 161 Volume 2 of 2:
Motor - Starting B-3 141 Thermostat - A/C G-7 180
Motor - Suspension Seat C-9 142 Transmitter - Payload C-10 181
TOP VIEW © 2013 Caterpillar, All Rights Reserved Printed in U.S.A.

ACTUAL GEAR INDICATOR SW. LOGIC

124 134 135 136 151 152 140 128 176 159 Harness And Wire Electrical Schematic Symbols
LEVER SWITCH CONTACTS CIRCUIT
POSITION POSITION
Symbols
LOW NAME
106 CONN 21 CONN 15 145 CONN 28 150 CONN 14 3 GEAR 4
NOT USED A 2 GEAR 5 T

Pressure Temperature Level Flow Circuit Breaker

6 GEAR 3 Symbol Symbol Symbol Symbol Symbol
166 N B 2 GEAR 5
Symbols and Definitions
7 GEAR 2
Fuse: A component in an electrical circuit that will open the circuit if too much current flows
R C 2 GEAR 5
120 8 GEAR 1
through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
1st D 2 GEAR 5 circle indicates that the component has screw terminals and a wire can be disconnected from it.

6 GEAR 3 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
148 181 2nd E 3 GEAR 4
Ground (Wired): This indicates that the component is connected to a grounded wire. The
7 GEAR 2 grounded wire is fastened to the machine.
3rd F 3 GEAR 4
Ground (Case): This indicates that the component does not have a wire connected to ground.
8 GEAR 1 It is grounded by being fastened to the machine.
CONN 2 107 GEAR 4
4th G 3
141 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
7 GEAR 2
LEFT SIDE NOT USED H 6
8
GEAR 3
GEAR 1 T
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
CONN 7 NOT USED I 6 GEAR 3 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
8 GEAR 1 electromagnet can open or close the switch part of the relay.

NOT USED J 7 GEAR 2

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
129 can open or close a valve or move a piece of metal that can do work.
Connector Location - Volume 2
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
CONN 16 Schematic activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
Connector Number that make electromagnet when current flows through them. It also has an internal switch that places
CONN 26 Location the latch coil circuit open at the time the coil latches.

157 2 C-11 Harness and Wire Symbols

3 B-9
CONN 27 7 E-9 & H-9
Wire, Cable, or Harness
Assembly Identification: Includes
Harness Identification Letter(s):
(A, B, C, ..., AA, AB, AC, ...)
Harness Identification Letters and
Harness Connector Serialization Code:
Harness Connector Serialization
14 G-1 The "C" stands for "Connector" and the
153 15 I-1
Codes (see sample).

AG-C4 L-C12
number indicates which connector in the
harness (C1, C2, C3, ...).
L-C12
111-7898 3E-5179
CONN 3 113 16 D-3 Part Number: for Connector Plug 1
3E-5179

125 21 D-11 2
Part Number: for Connector Receptacle

22 C-6
156 112 146 26 E-10 & G-10
Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
27 H-11 of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123
Component
Part Number
2
CONN 22 116 142 175 28 I-4
sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
The connectors shown in this chart are of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2
FRONT VIEW TOP VIEW RIGHT SIDE for harness to harness connectors.
contain both pins and sockets. wire 135 in harness "AG". Wire Color

Connectors that join a harness to a

component are generally located at or
near the component. See the Component
Location Chart.

INTEGRATION MESSAGES ON CAT DATA

LINK
POWER TRAIN ECM TO ENGINE ECM
160 127 132 122 133 123 126 169 173 165 163 172 115
149 167 TRANS. GEAR STATUS
TRANS. OUTPUT SPEED STATUS
AUTO. RETARDER

POWER TRAIN ECM TO CATERPILLAR

MONITORING SYSTEM
PARKING BRAKE
ENGINE SPEED
TRANS. OUTPUT SPEED
ACTUAL GEAR
RETARDER
LOW BRAKE OIL PRESSURE
TRANS. OIL PRESSURE
BODY POSITION
DIAGNOSTICS

114 CATERPILLAR MONITORING SYSTEM TO

POWER TRAIN/CHASSIS ECM
HARNESS CODE
177
171 178 170 174 179
137 ENGINE ECM TO CATERPILLAR
MONITOIRNG SYSTEM
DASH EJECTOR ENGINE COOLANT TEMP.
139 ENGINE COOLANT LEVEL
ENGINE OIL PRESSURE
MAINTENANCE REQUIRED
AIR INLET RESTRICTION
FUEL LEVEL
COOLANT FLOW
BRAKE OIL TEMP.
TORQUE CONVERTER OIL TEMP.

119 158 180 117 ENGINE ECM TO POWER TRAIN ECM

ENGINE SPEED
164 121 108 118 147

FRONT HVAC
 14 13 12 11 10 9 8 7 6 5 4 3 2 1

201-GA31 BK-16

201-GA32 BK-16

201-GA31 BK-16

201-GA32 BK-16

CAMERA_MONITOR 113-GA1 OR-16

UENR4825-00 VOL 2 of 2

223-2666 201-GA2 BK-16

290-GA13 BK-16
MONITOR_POWER_HARN MK-C1 291-GA17 BK-16
227-3921 1552272 403-GA15 GN-16
RD 6A 1 CONNECTS TO CONN. PL-C4 410-GA4 WH-16

J 115-AM2 RD-16
BK
BU
2
3
4
LOC H-11
VOLUME 2 OF 2
892-GA8 BR-16
893-GA5 GN-16
C413-GA19 YL-16
H36 H36
J
115-AM27 RD-16 C414-GA9 BU-16
115-AM28 RD-16 E707-GA18 GN-16
118-AM1 GY-16 E708-GA14 PK-16 ACTION_ALARM
118-AM7 GY-16 E735-GA11 PU-16 GA-C10
MA-C2 MA-C1 1552269 3E-6328
201-GA33 BK-16
(Dimensions: 48 inches x 35 inches)

VIDEO 1552272 1552272 GA-C6

VIDEO 201-GA33 BK-16 SPEEDO/TACHO_MODULE 410-GA4 WH-16 1 PK-16
SHIELD 1552273
SHIELD 1 EL559-MA1 GY-16 1 125-6806 201-GA32 BK-16 2 BK-16
HTR/SHTR +12V
RD
2 EL556-MA2 OR-16 2
CONNECTS TO CONN. PL-19 201-GA33 BK-16 411-GA7 PK-16 E707-GA25 GN-16 1 OR-18 +V
115-AM2 RD-16 CAMERA +9.6V
YL
3 EL557-MA3 GN-16 3 LOC H-11 201-GA26 BK-16 2 BK-18 GND GA-C7 GA-C8
BK GA-C1 3E5179 2124332
115-AM27 RD-16 GROUND 4 EL566-MA4 WH-16 4 VOLUME 2 OF 2 E708-GA27 PK-16 3 GN-18 CLOCK
115-AM28 RD-16 8T9834 E708-GA22 PK-16 C413-GA28 YL-16 4 WH-18 DATA 201-GA31 BK-16 1
118-AM1 GY-16 MONITOR_BALUN TWISTED WIRES +24V BATTERY (SWITCHED) 1 113-GA1 OR-16 C413-GA28 YL-16 C414-GA29 BU-16 5 YL-18 LOAD 201-GA2 BK-16 2
118-AM7 GY-16 233-1855 GROUND 2 201-GA2 BK-16 C414-GA29 BU-16 6 BU-18 ADDRESS SELECT 201-GA30 BK-16 3
HARNESS CODE 1 3 271-GA3 BK-16 C413-GA23 YL-16 201-GA32 BK-16 4
ACTION ALARM 4 410-GA4 WH-16 201-GA26 BK-16 201-GA33 BK-16 5
CAT DATA LINK + 5 893-GA5 GN-16 201-GA30 BK-16 1 2 1 2

201-GA21 BK-16 6
6 E708-GA27 PK-16 GC-C15 GC-C14 201-GA26 BK-16 7 REAR_LIGHT/BACKUP_LIGHT_RELAY
AM-C6 7 201-GA21 BK-16 3T3158 3T3158 8 GC-C26 3E-5239
1607690 8 C414-GA24 BU-16 200-GC50 BK-16 9 9X1054
30
10BASE-T TX - 1 TXD2-AM4 OR-18 ATCH MONITOR AR-CAMERA 9 E707-GA20 GN-16 662-GC79 YL-16 H40 10 104-GC40 BU-16 1
86
10BASE-T TX + 2 TXD1-AM5 YL-18 10 E707-GA25 GN-16 11 321-GC19 BR-16 5
3 11 200-GC46 BK-16 12 E790-GC20 PK-16 2
85
4 HARNESS CODE 2 12 272-GA6 BK-16 661-GC80 GN-16 EL104-GC41 BU-16 4
87
5 ACTION LAMP 13 411-GA7 PK-16 TWISTED WIRES 3
87a
6 TWISTED WIRES CAT DATA LINK - 14 892-GA8 BR-16 GA-C11 GC-C1
7 AM-C4 AM-C5 MODULE LOAD 15 C414-GA9 BU-16 3E5179 1552252
CAT DATA LINK + 8 893-AM11 GN-16 1552264 3E3388 HARNESS CODE 4 16 274-GA10 BK-16 GA-C5 GAUGE_MODULE 113-GA1 OR-16 1 113-GC62 OR-16 105-GC60 BR-16
CAT DATA LINK - 9 892-AM10 BR-16 115-AM27 RD-16 1 17 1552273 166-6938 201-GA31 BK-16 2 201-GC77 BK-16 113-GC62 OR-16
10 201-AM26 BK-16 2 OPERATOR MODE SCROLL SW. 18 E735-GA11 PU-16 E707-GA20 GN-16 1 OR-18 +V 893-GA5 GN-16 3 893-GC2 GN-16 200-GC49 BK-16 GC-C28
11 3 19 201-GA21 BK-16 2 BK-18 GND 892-GA8 BR-16 4 892-GC1 BR-16 290-GC5 BK-16 8T9834
H36
12 TWISTED WIRES 4 TELEMETRY PORT #2 115-PL7 RD-16 20 E708-GA22 PK-16 3 GN-18 CLOCK E735-GA11 PU-16 5 E735-GC78 PU-16 291-GC6 BK-16 892-GC1 BR-16 1
H35 H35
13 R970-AM13 WH-16 5 118-PL6 GY-16 21 C413-GA23 YL-16 4 WH-18 DATA 290-GA13 BK-16 6 290-GC5 BK-16 403-GC7 GN-16 893-GC2 GN-16 2
10BASE-T RX - 14 RXD2-AM8 BU-18 6 118-PL26 GY-16 HARNESS CODE 3 22 273-GA12 BK-16 C414-GA24 BU-16 5 YL-18 LOAD 291-GA17 BK-16 7 291-GC6 BK-16 614-GC52 PU-16 201-GC3 BK-16 3
TWISTED WIRES
10BASE-T RX + 15 RXD1-AM12 WH-18 7 SERVICE 23 290-GA13 BK-16 6 BU-18 ADDRESS SELECT 403-GA15 GN-16 8 403-GC7 GN-16 663-GC59 GY-16 200-GC4 BK-16 4
16 R976-AM20 BU-16 8 24 9 614-GC52 PU-16 892-GC1 BR-16 290-GC5 BK-16 5
17 MODULE CLOCK 25 E708-GA14 PK-16 201-GA30 BK-16 H38 10 105-GC60 BR-16 893-GC2 GN-16 291-GC6 BK-16 6
CABLE_AS
18 115-PL7 RD-16 26 411-GA7 PK-16
CONN 28 11 663-GC59 GY-16 403-GC7 GN-16 7
1 2 1 2

19 3663913 118-PL6 GY-16 27 GC-C17 GC-C16 12 200-GC49 BK-16 201-GC77 BK-16 606-GC8 GY-16 8
20 TXD1-AM5 YL-18 1 118-PL26 GY-16 28 GA-C9 HARN_CODE_PLUG 3T3158 3T3158 E735-GC78 PU-16 605-GC9 YL-16 9
21 RXD1-AM12 WH-18 2 ETHERNET PORT 29 1552273 221-9787 200-GC47 BK-16 604-GC10 OR-16 10
22 TXD2-AM4 OR-18 3 ALTERNATOR 30 403-GA15 GN-16 201-GA33 BK-16 270-GA16 BK-16 1 663-GC57 GY-16 454-GC11 GN-16 11

I 23
24
RXD2-AM8 BU-18 4 HARNESS CODE 0 31
32
270-GA16 BK-16 270-GA16 BK-16
271-GA3 BK-16
271-GA3 BK-16
272-GA6 BK-16
2
3 200-GC45 BK-16
H39
EL456-GC12 WH-16
614-GC13 PU-16
12
13
I
25 CLEAR 33 291-GA17 BK-16 272-GA6 BK-16 273-GA12 BK-16 4 663-GC56 GY-16 GA-C3 GA-C4 308-GC14 YL-16 14
PL-C15 PL-C14 1552252 2124342 CONNECTS TO
26 MODULE +V 34 E707-GA18 GN-16 273-GA12 BK-16 274-GA10 BK-16 5 307-GC15 OR-16 15
RS-232 PORT 2 - TX - 27 875-AM3 BU-16 3E3376 1552272 MODULE DATA 35 C413-GA19 YL-16 274-GA10 BK-16 201-GA33 BK-16 6 C414-GA9 BU-16 1 H430-GC16 PU-16 16 CONN. (C-C4)
28 AM-C2 AM-C3 1 118-PL22 GY-16 36 C414-GA29 BU-16 2 612-GC17 GY-16 17 LOC H-7
29 1552273 3E3382 CONN TO ACCESSORIES 2 115-PL31 RD-16 37 C414-GA24 BU-16 3 611-GC18 PU-16 18 VOLUME 1 OF 2
30 118-AM1 GY-16 1 3 200-PL42 BK-16 38 E708-GA14 PK-16 4 321-GC19 BR-16 19
31 115-AM28 RD-16 2 4 614-PL9 PU-16 CONNECTS TO 39 CENTER_WARNING_LAMP E708-GA27 PK-16 5 E735-GC78 PU-16 E790-GC20 PK-16 20
32 875-AM3 BU-16 3 TELEMETRY PORT #1 PL-C21 CONN. TC-8 40 275-2658 E708-GA22 PK-16 6 201-GC77 BK-16 619-GC21 GN-16 21
J1939 DATA LINK 2 + 33 R970-AM13 WH-16 876-AM15 OR-16 4 3E3364 (MONITORING SYSTEM) GA-C2 E707-GA18 GN-16 7 EL619-GC22 GN-16 22
TWISTED WIRES MONITORING_ECM_MID:_030
J1939 DATA LINK 1 - 34 F712-AM14 GY-16 A251-AM21 BK-16 5 PL-C13 PL-C12 403-PL46 GN-16 1 1552269 E707-GA25 GN-16 8 EL619-GC23 GN-16 23
LOC B-10 252-4503 411-PK
876-AM15 OR-16 201-AM6 BK-16 3E3364 1552269 411-GA7 PK-16 E707-GA20 GN-16 608-GC24 GN-16
RS-232 PORT 2 - RX -
ANALOG IN #1 (ENABLE)
35
36 201-AM16 BK-16
6
1 512-PL38 GN-16
2
VOLUME 2 OF 2 ACTION LAMP 201-BK
1
2 201-GA30 BK-16
H38
C413-GA19 YL-16 10
9
102-GC67 BU-16 EL608-GC25 GN-16
24
25 CONN 15
ANALOG IN #2 (BIT 0) 37 201-AM17 BK-16 TO RIGHT SPEAKER 2 511-PL37 BR-16 C413-GA28 YL-16 11 102-GC68 BU-16 EL623-GC26 BU-16 26
ANALOG IN #3 (BIT 1) 38 201-AM18 BK-16 AM-C7 AM-C8 GC-C13 C413-GA23 YL-16 12 104-GC40 BU-16 EL624-GC27 GN-16 27
ANALOG IN #4 (BIT 2) 39 201-AM19 BK-16 1552264 2106311 PL-C6 PL-C7 1552264 104-GC65 BU-16 K985-GC28 BR-16 28
PW-C3 PW-C2 PW-C1 PL-C11 PL-C10 1552264 3E3388 113-OR
40 118-AM7 GY-16 1
RTD IND
1 113-GC75 OR-16 200-GC46 BK-16 104-GC66 BU-16 EL350-GC29 PU-16 29
3E3364 1552269 3E3364 3E3364 1552269 454-GN
J1939 DATA LINK 2 - 41 R976-AM20 BU-16 118-AM1 GY-16 2 509-PL32 WH-16 1 2 454-GC11 GN-16 H40 H40 200-GC50 BK-16 113-GC75 OR-16 F717-GC30 YL-16 30
606-GY
42 118-AM9 GY-16 3 1 508-PW1 PU-16 1 1 508-PL33 PU-16 508-PL33 PU-16 2
RH TURN IND
3 606-GC8 GY-16 113-GC76 OR-16 998-GC31 BR-16 31
EL456-WH
RS-232 PORT 2 - GND - 43 A251-AM21 BK-16 4 TO LEFT SPEAKER 2 509-PW2 WH-16 2 2 509-PL32 WH-16 200-PL34 BK-16 3 4 EL456-GC12 WH-16 661-GC80 GN-16 114-GC63 GN-16 503-GC32 BR-16 32
114-GN
44 115-AM2 RD-16 5 118-PL26 GY-16 4 CONNECTS TO RADIO 5 114-GC63 GN-16 662-GC79 YL-16 127-GC69 OR-16 504-GC33 YL-16 33
200-BK
45 115-AM27 RD-16 6 A513-PL35 PK-16 5 6 200-GC51 BK-16 200-GC45 BK-16 200-GC44 BK-16 500-GC34 BR-16 34
46 115-AM28 RD-16 7 PL-C9 PL-C8 TWISTED WIRES 135-PL36 BU-16 6 7 200-GC47 BK-16 200-GC45 BK-16 507-GC35 WH-16 35
36 Page,

AUTO LUB IND 604-OR H39 H39

47 115-AM23 RD-16 8 3E5179 1552252 511-PL37 BR-16 7 8 604-GC10 OR-16 200-GC46 BK-16 542-GC36 BU-16 36
48 1 118-PL24 GY-16 512-PL38 GN-16 8 663-GC56 GY-16 200-GC47 BK-16 37
49 2 115-PL27 RD-16 663-GC57 GY-16 200-GC48 BK-16 506-GC37 PU-16 38
J1939 DATA LINK 1 + 50 F711-AM22 GN-16 AM-C1 3 892-PL17 BR-16 SIDE_WARNING_LAMP 200-GC50 BK-16 501-GC38 GN-16 39
3E5179 RESIDUAL BK OIL PRESS IND
51 4 893-PL18 GN-16 275-2657 200-GC51 BK-16 502-GC39 OR-16 40
+24V BATTERY (UNSWITCHED) 52 115-AM23 RD-16 118-AM7 GY-16 1 CONNECTS TO CONN. AM-C1 5 F711-PL44 GN-16 201-GC3 BK-16
53 115-AM2 RD-16 2 6 F712-PL45 GY-16 PL-C16 PL-C17 113-GC75 OR-16 202-GC42 BK-16
(VIMS) 1552252 2131434 LH TURN IND
ALTERNATOR R-TERM 54 403-AM24 GN-16 892-AM10 BR-16 3 7 403-PL46 GN-16 GC-C24 113-GC75 OR-16 113-GC76 OR-16 454-GC11 GN-16
LOC H-12 1552264
55 TWISTED WIRES 893-AM11 GN-16 4
CONNECTS TO 8 118-PL22 GY-16 1 113-GC76 OR-16 114-GC63 GN-16 604-GC10 OR-16
56 F711-AM22 GN-16 5 VOLUME 2 OF 2 9 118-PL23 GY-16 2
200-BK
1 200-GC44 BK-16 114-GC63 GN-16 200-GC44 BK-16 605-GC9 YL-16 GC-C20 GC-C21
57 F712-AM14 GY-16 6 CONNS. PL-C8/PR-C4 10
TWISTED WIRES
118-PL24 GY-16 3
113-OR
2 113-GC76 OR-16 113-GC76 OR-16 200-GC44 BK-16 200-GC51 BK-16 606-GC8 GY-16 3E5179 2124332
BODY UP/TAIL GATE DOWN IND 605-YL
58 403-AM24 GN-16 7 (VIMS) 11 118-PL25 GY-16 4 3 605-GC9 YL-16 200-GC44 BK-16 200-GC51 BK-16 454-GC11 GN-16 608-GC24 GN-16 202-GC42 BK-16 1
H430-PU
59 8 LOCS H-10/F-10 12 118-PL26 GY-16 5
611-PU
4 H430-GC16 PU-16 202-GC82 BK-16 454-GC11 GN-16 H41 H41 604-GC10 OR-16 611-GC18 PU-16 200-GC43 BK-16 2
60 9
VOLUME 2 OF 2 118-PL6 GY-16 6 5 611-GC18 PU-16 605-GC9 YL-16 604-GC10 OR-16 605-GC9 YL-16 612-GC17 GY-16 200-GC44 BK-16 3
PL-C20 PL-C19 612-GY
61 10 115-PL7 RD-16 7 6 612-GC17 GY-16 611-GC18 PU-16 605-GC9 YL-16 606-GC8 GY-16 619-GC21 GN-16 200-GC45 BK-16 4
62
63
11
12
CONN 27 1552272
1
3E3376
EL559-PL19 GY-16
115-PL27 RD-16
115-PL28 RD-16
8
9
HIGH BEAM IND 202-BK
7
8 202-GC82 BK-16
612-GC17 GY-16
H430-GC16 PU-16
606-GC8 GY-16
611-GC18 PU-16
611-GC18 PU-16
612-GC17 GY-16
663-GC56 GY-16
663-GC57 GY-16
200-GC46 BK-16
200-GC47 BK-16
5
6
CONNECTS TO CONN. MA-C1
64 2 EL556-PL20 OR-16 115-PL29 RD-16 10 612-GC17 GY-16 H430-GC16 PU-16 H430-GC16 PU-16 200-GC48 BK-16 7
GROUND 65 201-AM25 BK-16 (CAMERA MONITOR) 3 EL557-PL21 GN-16 115-PL30 RD-16 11 H430-GC16 PU-16 EL456-GC12 WH-16 K985-GC28 BR-16 200-GC49 BK-16 8

H 66
67 201-AM19 BK-16
AM-M1
2878915
LOC J-10
VOLUME 2 OF 2
PL-C5
4

PL-C4
EL566-PL14 WH-16
TWISTED WIRES
115-PL31 RD-16 12
REVERSE IND
EL456-GC12 WH-16 EL104-GC41 BU-16
EL456-GC12 WH-16
200-GC50 BK-16
200-GC51 BK-16
9
10
H
68 201-AM25 BK-16 202-GC82 BK-16 EL608-GC25 GN-16 200-GC4 BK-16 11
69 1552272 3E3376 EL619-GC22 GN-16 12
+24V BATTERY (SWITCHED) 70 118-AM9 GY-16 1 118-PL23 GY-16 EL619-GC23 GN-16
VIMS A4:N4 ECM CONNECTS TO CONN. MK-C1 2 200-PL40 BK-16 EL623-GC26 BU-16 GC-C18 GC-C19
235-8282 201-AM16 BK-16 AM-M2 (CAMERA MONITOR) 3 612-PL8 GY-16 FRONT_LIGHT_SW REAR_LIGHT/BACKUP_LIGHT_SW BLOCK_LIGHT_REAR_CAB_LIGHT_SW AUTO_RETARDER_CONTROL_SW OPERATOR_MODE_SCROLL_SW EL624-GC27 GN-16 1552252 2124333
(NOTE F) 201-AM6 BK-16 201-AM17 BK-16 2878915 LOC J-10 4 614-PL13 PU-16 PL-C1 198-2974 GC-C11 198-2975 GC-C9 180-2558 GC-C7 170-1326 GC-C5 170-1307 GC-C3 200-GC94 BK-16 662-GC79 YL-16 614-GC52 PU-16 1
201-AM26 BK-16 201-AM18 BK-16 7X6222 3E7996 3E7996 EL104-GC41 BU-16 3E7996 3E7996 3E7996 614-GC93 PU-16 661-GC80 GN-16 614-GC53 PU-16 2
VOLUME 2 OF 2
AM-M3 635-PL1 BU-16 1 1 1 EL104-GC87 BU-16 1 127-GC92 OR-16 1 202-GC82 BK-16 1 105-GC54 BR-16 3
2878915 636-PL2 GN-16 2 2 104-GC65 BU-16 2 608-GC24 GN-16 2 127-GC69 OR-16 2 202-GC42 BK-16 2 E735-GC78 PU-16 105-GC55 BR-16 4
PL-C3 PL-C2 J840-PL3 WH-16 3 3 619-GC21 GN-16 3 104-GC40 BU-16 3 EL623-GC26 BU-16 3 K985-GC28 BR-16 3 201-GC77 BK-16 663-GC56 GY-16 5
ATCH VIMS HARNESS 3E3382 1552273 J841-PL4 YL-16 4 4 619-GC83 GN-16 4 104-GC66 BU-16 4 127-GC92 OR-16 4 4 201-GC3 BK-16 105-GC54 BR-16 663-GC57 GY-16 6

CONNECTS TO (24V to 12V 1 115-PL28 RD-16 592-PL5 BU-16 5 5 102-GC67 BU-16 5 EL104-GC87 BU-16 5 127-GC86 OR-16 5 5 614-GC93 PU-16 200-GC94 BK-16 113-GC64 OR-16 663-GC58 GY-16 7
2 118-PL25 GY-16 118-PL6 GY-16 6 6 EL619-GC22 GN-16 6 EL608-GC25 GN-16 6 EL624-GC27 GN-16 6 6 614-GC98 PU-16 614-GC93 PU-16 113-GC73 OR-16 663-GC59 GY-16 8
CONVERTER) 3 200-PL41 BK-16 115-PL7 RD-16 7 A EL619-GC23 GN-16 A 102-GC68 BU-16 A A 614-GC93 PU-16 A 200-GC94 BK-16 200-GC4 BK-16 105-GC60 BR-16 9
LOC F-9 4 A513-PL35 PK-16 612-PL8 GY-16 8 CONNECTS TO B 614-GC84 PU-16 B B B 200-GC94 BK-16 B 200-GC96 BK-16 200-GC43 BK-16 10
VOLUME 1 OF 2 5 135-PL36 BU-16 614-PL9 PU-16 9 CONN. (C-C84) C 614-GC85 PU-16 C 614-GC88 PU-16 C 614-GC90 PU-16 C C 614-GC98 PU-16 321-GC19 BR-16 614-GC13 PU-16 11
6 200-PL43 BK-16 F711-PL44 GN-16 10 D 200-GC48 BK-16 D 200-GC89 BK-16 D 200-GC91 BK-16 D D 614-GC95 PU-16 102-GC67 BU-16 614-GC13 PU-16 614-GC61 PU-16 12
F712-PL45 GY-16 11 LOC C-11 200-GC74 BK-16 200-GC96 BK-16 102-GC68 BU-16 614-GC53 PU-16
119-PL10 PK-16 12 200-GC97 BK-16 104-GC40 BU-16 663-GC58 GY-16
EL623-PL11 BU-16 13 VOLUME 1 OF 2 104-GC65 BU-16 E790-GC20 PK-16
EL624-PL12 GN-16 14 200-GC74 BK-16 200-GC89 BK-16 200-GC91 BK-16 104-GC66 BU-16
PU-C1
3E5179
PL-C18
1552252
614-PL13 PU-16
EL566-PL14 WH-16
15 CONN 7 127-GC69 OR-16 GC-C27
3E5179
16 614-GC84 PU-16 614-GC88 PU-16 614-GC90 PU-16 102-GC67 BU-16 200-GC48 BK-16
115-PU1 RD-16 1 115-PL29 RD-16 17 102-GC68 BU-16 201-GC3 BK-16 105-GC54 BR-16 113-GC62 OR-16 1
115-PU2 RD-16 2 115-PL30 RD-16 503-PL15 BR-16 18 102-GC67 BU-16 102-GC67 BU-16 104-GC40 BU-16 201-GC77 BK-16 113-GC64 OR-16 114-GC63 GN-16 2
635-PU3 BU-16 3 635-PL1 BU-16 504-PL16 YL-16 19 102-GC68 BU-16 102-GC68 BU-16 104-GC65 BU-16 202-GC42 BK-16 113-GC73 OR-16 113-GC64 OR-16 3 CONNECTS TO
636-PU4 GN-16 4 636-PL2 GN-16 892-PL17 BR-16 20 104-GC40 BU-16 104-GC40 BU-16 104-GC66 BU-16 608-GC24 GN-16 200-GC4 BK-16 105-GC54 BR-16 4
CONN. (C-C53)
J840-PU5 WH-16 5 J840-PL3 WH-16 893-PL18 GN-16 21 102-GC67 BU-16 104-GC65 BU-16 104-GC65 BU-16 127-GC69 OR-16 619-GC21 GN-16 200-GC43 BK-16 104-GC65 BU-16 5
J841-PU6 YL-16 6 J841-PL4 YL-16 EL559-PL19 GY-16 22 104-GC65 BU-16 104-GC66 BU-16 104-GC66 BU-16 200-GC48 BK-16 K985-GC28 BR-16 321-GC19 BR-16 104-GC66 BU-16 6
LOC H-9
119-PU7 PK-16 7 119-PL10 PK-16 EL556-PL20 OR-16 23 200-GC48 BK-16 200-GC48 BK-16 127-GC69 OR-16 200-GC94 BK-16 EL104-GC41 BU-16 614-GC13 PU-16 102-GC67 BU-16 7 VOLUME 1 OF 2
EL623-PU8 BU-16 8 EL623-PL11 BU-16 EL557-PL21 GN-16 24 619-GC21 GN-16 608-GC24 GN-16 200-GC48 BK-16 202-GC42 BK-16 EL608-GC25 GN-16 614-GC53 PU-16 102-GC68 BU-16 8
EL624-PU9 GN-16
503-PU10 BR-16
9
10
EL624-PL12 GN-16
503-PL15 BR-16 200-PL40 BK-16
EL619-GC22 GN-16
EL619-GC23 GN-16
619-GC21 GN-16
EL104-GC41 BU-16
608-GC24 GN-16
619-GC21 GN-16
608-GC24 GN-16
614-GC93 PU-16
EL619-GC22 GN-16
EL619-GC23 GN-16
663-GC58 GY-16
E790-GC20 PK-16
127-GC69 OR-16
EL110-GC70 OR-16
9
10
CONN 14
REAR_WINDOW_WIPER_MOTOR
504-PU11 YL-16 11 504-PL16 YL-16 PL-T3 3092088 EL619-GC22 GN-16 EL104-GC41 BU-16 619-GC21 GN-16 EL623-GC26 BU-16 119-GC71 PK-16 11
304-4506 12 EL619-GC23 GN-16 EL608-GC25 GN-16 K985-GC28 BR-16 EL624-GC27 GN-16 138-GC72 GN-16 12

L
0.47 F PU-C4
1552273
CONN 26 200-PL41 BK-16
EL608-GC25 GN-16 EL619-GC22 GN-16
EL619-GC23 GN-16
EL104-GC41 BU-16
EL608-GC25 GN-16
E735-GC78 PU-16
12 H
MOTOR GND 12V_POWER_PORT 592-PL5 BU-16 200-PL39 BK-16 EL623-GC26 BU-16 EL619-GC22 GN-16 200-GC97 BK-16 105-GC55 BR-16
H 1
245-2181 PL-T1 2878917 200-PL42 BK-16 EL624-GC27 GN-16 EL619-GC23 GN-16 614-GC95 PU-16 119-GC71 PK-16
T BK 2 200-PU12 BK-16 GC-C22 GC-C23
200-PL39 BK-16 200-PL43 BK-16 EL623-GC26 BU-16 138-GC72 GN-16
12 H
BR 3 503-PU10 BR-16 1552272 2124331
PL-T2 2878917 PL-M5 3092088 EL624-GC27 GN-16 307-GC15 OR-16

G P
B+
GN
OR
GY
4
5
6
504-PU11 YL-16

119-PU7 PK-16
PL-T4 2878915
200-PL34 BK-16 127-GC86 OR-16
GC-C12
1698670
A
LOOP_RECEPTACLE (DASH DIMMER)
212-4334
308-GC14 YL-16
500-GC34 BR-16
501-GC38 GN-16
113-GC64
113-GC73
113-GC75
OR-16
OR-16
OR-16
1
2
3
G
0.47 F
614-GC85 PU-16 B 502-GC39 OR-16 113-GC76 OR-16 4
619-GC83 GN-16 C 503-GC32 BR-16
504-GC33 YL-16
ATCH PILLAR HARNESS (ENCLOSED ROPS) 506-GC37 PU-16
507-GC35 WH-16 GC-C25 LOOP_RECPTACLE
THROTTLE_BACKUP_SW REAR_WINDOW_WIPER/WSHR_SW PAYLOAD_SW 542-GC36 BU-16 1552273 212-4335
115-PV1 RD-16 170-1302 GC-C10 198-2976 GC-C8 GC-C6 GC-C4 3E-8766 GC-C2 614-GC61 PU-16 200-GC43 BK-16 1
DOME_LAMP 3E7996 3E7996 3E7996 3E7996 3E7996 998-GC31 BR-16 113-GC73 OR-16 2
3E-6389 PV-C2 DOME_LAMP_DOOR_SW PV-C1 PU-C9 PU-C2 ATCH PILLAR HARNESS (OPEN ROPS) 1 1 503-GC32 BR-16 1 1 1 EL110-GC70 OR-16 614-GC53 PU-16 3
1698670 9D-4068 3E3364 3E3364 1552269 2 F717-GC30 YL-16 2 504-GC33 YL-16 2 EL110-GC70 OR-16 2 2 138-GC72 GN-16 EL350-GC29 PU-16 662-GC79 YL-16 4
RD-18 A PV-T2 2878917 PV-T1 2878917 1 1 115-PU1 RD-16 200-PU12 BK-16 3 998-GC31 BR-16 3 119-GC71 PK-16 3 EL350-GC29 PU-16 3 3 542-GC36 BU-16 F717-GC30 YL-16 661-GC80 GN-16 5
WH-18 C EL351-PV3 BR-16 115-PV2 RD-16 2 2 115-PU2 RD-16 PU-T1 3092088 4 4 119-GC103 PK-16 4 4 4 663-GC58 GY-16 6
BK-18 B 5 5 119-GC103 PK-16 SPARES 5 SPARES 5 5
PAYLOAD_LAMP 6 614-GC99 PU-16 6 119-GC81 PK-16 6 6 6
247-1632 PU-C10 PU-C7 200-PU13 BK-16 A 614-GC100 PU-16 A 507-GC35 WH-16 A 614-GC106 PU-16 A 614-GC108 PU-16 A 614-GC95 PU-16
3E3376 1552272 PU-T2 3092088 B 200-GC101 BK-16 B B 200-GC107 BK-16 B 200-GC109 BK-16 B 200-GC97 BK-16
RD
STOP + 1 635-PU3 BU-16 C 200-GC102 BK-16 C 614-GC104 PU-16 C C C
GN
GREEN + 2 636-PU4 GN-16 D D 200-GC105 BK-16 D D D
BR
TAIL + 3 200-PU14 BK-16
ORANGE + OR 4 PU-T3 3092088 PR-C13
3E3364
PU-C11 PU-C8 403-PR14 GN-16 1 200-GC102 BK-16 200-GC105 BK-16 200-GC107 BK-16 200-GC109 BK-16
1552272 3E3376 2 614-GC95 PU-16
WH
GREEN - 1 J840-PU5 WH-16 614-GC99 PU-16 614-GC104 PU-16 614-GC106 PU-16 614-GC108 PU-16 200-GC97 BK-16
STOP - BU 2 J841-PU6 YL-16 PR-C7 PR-C6 CONNECTS TO
ORANGE - PU 3 3E3376 1552272 CONN. T-C8 105-GC55 BR-16
4 1 118-PR7 GY-16 (MONITORING SYSTEM) 119-GC71 PK-16
CONNECTS TO 2 115-PR5 RD-16 LOC B-10 105-GC55 BR-16 105-GC55 BR-16 138-GC72 GN-16
PU-C5 ACCESSORIES 3 200-PR13 BK-16 105-GC55 BR-16 119-GC71 PK-16 119-GC71 PK-16 307-GC15 OR-16
1552269 VOLUME 2 OF 2
4 614-PR19 PU-16 307-GC15 OR-16 105-GC55 BR-16 307-GC15 OR-16 307-GC15 OR-16 308-GC14 YL-16
WH-18 1 EL624-PU9 GN-16 GC-C31 308-GC14 YL-16 119-GC71 PK-16 308-GC14 YL-16 308-GC14 YL-16 503-GC32 BR-16
R 1552272
BK-18 2 200-PU13 BK-16 998-GC31 BR-16 308-GC14 YL-16 503-GC32 BR-16 503-GC32 BR-16 504-GC33 YL-16
YL-16 1 308-GC14 YL-16 F717-GC30 YL-16 307-GC15 OR-16 504-GC33 YL-16 504-GC33 YL-16 507-GC35 WH-16
OFF C
REAR_CAB_LIGHT PR-C5 PR-C4 PU-16 2 503-GC32 BR-16 507-GC35 WH-16 507-GC35 WH-16 542-GC36 BU-16
3E5179 1552252 ON S
162-3294 OR-16 3 307-GC15 OR-16 504-GC33 YL-16 998-GC31 BR-16 998-GC31 BR-16 998-GC31 BR-16
ST B
3 8 3 - 8 6 3 4 (NOTE J) 1 118-PR9 GY-16 BR-16 4 105-GC55 BR-16 507-GC35 WH-16 F717-GC30 YL-16 F717-GC30 YL-16 F717-GC30 YL-16
2 115-PR1 RD-16 KEY_START 998-GC31 BR-16 EL110-GC70 OR-16 EL110-GC70 OR-16 EL110-GC70 OR-16
PU-C6 CONNECTS TO 3 892-PR23 BR-16 110-7887 F717-GC30 YL-16 EL350-GC29 PU-16 EL350-GC29 PU-16 EL350-GC29 PU-16
1552269 CONN. AM-C1 4 893-PR24 GN-16
5 F711-PR31 GN-16 119-GC81 PK-16
WH-18 1 EL623-PU8 BU-16 (VIMS)
F BK-18 2 200-PU14 BK-16 LOC H-12
VOLUME 2 OF 2
6
7
8
F712-PR32 GY-16
403-PR14 GN-16
118-PR7 GY-16
PR-C8
1552252
1
PR-C9
2131434 DASH_LAMP_1
163-6508
DASH_LAMP_2
163-6508
F
BLOCK_LIGHT
162-3294
9 118-PR8 GY-16 2 614-GC61 PU-16
TWISTED WIRES
3 8 3 - 8 6 3 4(NOTE 10 118-PR9 GY-16 3 1 2 1 2

J) 11 4 GC-C29 GC-C30
12 5 614-GC100 PU-16 1071984 1071984 FRONT_WINDOW_WIPER/WASHER_SW
118-PR6 GY-16 6 112-6174 119-GC81 PK-16
ATCH UPPER CAB HARNESS (ENCLOSED ROPS) PR-C12 PR-C11 115-PR4 RD-16 7 200-GC101 BK-16 614-GC61 PU-16
CONNECTS TO 1 5 5 2 2 7 2 3E3376 115-PR1 RD-16 8 200-GC110 BK-16
CONN. MA-C1 1 EL559-PR27 GY-16 9 GC-C33 GC-C32
B B H 3E3388 1552264
(CAMERA MONITOR) 2 EL556-PR25 OR-16 115-PR2 RD-16 10 614-GC111 PU-16
3 EL557-PR26 GN-16 115-PR3 RD-16 11 RD-16 1 119-GC81 PK-16
ATCH UPPER CAB HARNESS (OPEN ROPS) LOC J-10 4 EL566-PR28 WH-16 115-PR5 RD-16 12 RD-16 2 500-GC34 BR-16
VOLUME 2 OF 2 3 501-GC38 GN-16
PR-C3 PR-C2 WH-16 4 502-GC39 OR-16 502-GC39 OR-16
L
1552272 3E3376 P YL-16 5 501-GC38 GN-16 506-GC37 PU-16
W
CONNECTS TO 1 118-PR8 GY-16 BU-16 6 500-GC34 BR-16
CONN. MK-C1 2 200-PR11 BK-16 PR-C1 BR-16 7 506-GC37 PU-16
3 612-PR18 GY-16 7X6222 8
(CAMERA MONITOR)
4 614-PR20 PU-16 635-PR21 BU-16 1
LOC J-10
636-PR22 GN-16 2
VOLUME 2 OF 2 J840-PR33 WH-16 3
FA-C2 J841-PR34 YL-16 4
3E3376 115-PR4 RD-16 592-PR17 BU-16 5
EL308-FA9 YL-16 1 INTERCONNECTS TO PP-C7 PP-C2 118-PR6 GY-16 6
2 CONN. YF-C1 3E3364 1552269 118-PR6 GY-16 115-PR4 RD-16 7
3
LOC D-14 1 115-PP1 RD-16 115-PR4 RD-16 612-PR18 GY-16 8 ATCH PANEL GP-INSTRUMENT
E575-FA2 BU-16 4 2 115-PP2 RD-16 614-PR19 PU-16 9
VOLUME 1 OF 2 118-PR6 GY-16 F711-PR31 GN-16 10
FA-C3 F712-PR32 GY-16 11 CONNECTS TO
1552272 PP-C8 PP-C5 119-PR10 PK-16 12
3E3376 1552272 CONN. (C-C84)
EL308-FA9 YL-16 1 INTERCONNECTS TO EL623-PR29 BU-16 13
2 CONN. C-C51 1 635-PP5 BU-16 EL624-PR30 GN-16 14 LOC C-11
3 2 636-PP6 GN-16 PP-C1 PR-C10 614-PR20 PU-16 15 VOLUME 1 OF 2
LOC D-14
(NOTE E) 209-FA1 BK-16 4
VOLUME 1 OF 2
3 3E5179 1552252 EL566-PR28 WH-16 16
4 115-PP1 RD-16 1 115-PR2 RD-16 17
FIRE SUPPRESSION CONTROL
(DRY POWDER TYPE) HARNESS AS FA-C1 3E-7808 PP-C9 PP-C6
115-PP2 RD-16
635-PP5 BU-16
2
3
115-PR3 RD-16
635-PR21 BU-16
503-PR15 BR-16
504-PR16 YL-16
18
19
CONN 7
248-5572 223-9286 3E3388 1552272 3E3376
FIRE_SUPPRESSION 636-PP6 GN-16 4 636-PR22 GN-16 892-PR23 BR-16 20
SHUTDOWN NC 15 BK-16 1 209-FA1 BK-16 PRESS.SW. 1 J840-PP9 WH-16 J840-PP9 WH-16 5 J840-PR33 WH-16 893-PR24 GN-16 21
SHUTDOWN COMMON 16 BU-16 2 E575-FA2 BU-16 FC-C3 PF-C1 PF-C2 (DRY_POWDER_TYPE) 2 J841-PP10 YL-16 J841-PP10 YL-16 6 J841-PR34 YL-16 EL559-PR27 GY-16 22
+ MANUAL INPUT 5 BR-16 3 807-FA3 BR-16 1698670 3E3370 1698670 3 7 119-PR10 PK-16 EL556-PR25 OR-16 23
FA-C4 FC-C1 VV-C8
E - MANUAL INPUT
+ DETECTION INPUT
- DETECTION INPUT
6
3
4
PU-16
GY-16
GY-16
4
5
6
808-FA4 PU-16
806-FA5 GY-16
811-FA6 GY-16 806-FA5 GY-16
3E8969
1
1552252
806-FC1 GY-16
807-FC5 BR-16
808-FC6 PU-16
A
B
C
807-PF4 BR-16
4.7K
A
B
C
BK-18
BK-18
PP-C3
4 EL623-PP7 BU-16
EL624-PP8 GN-16
8
9
10
EL623-PR29 BU-16
EL624-PR30 GN-16
503-PR15 BR-16
EL557-PR26 GN-16 24 FAN MOTOR
378-7565
FIRST SPEED 1
6A5277
515-VV6 YL-16-GXL
FAN_SPEED_SWITCH
157-1361
E
+ RELEASE OUTPUT 7 GN-16 7 812-FA7 GN-16 811-FA6 GY-16 2 811-FC2 GY-16 808-PF5 PU-16 1552269 11 504-PR16 YL-16 SECOND SPEED 2 516-VV7 BU-16-GXL
VV-C9
- RELEASE OUTPUT 8 BK-16 8 209-FA8 BK-16 209-FA8
812-FA7
BK-16
GN-16
3
4
209-FC3
812-FC4
BK-16
GN-16 FC-C2
1
2
EL624-PP8 GN-16
200-PP3 BK-16 CONN 26 12 200-PR11 BK-16
PR-T4 3092088
THIRD SPEED
FOURTH SPEED
3
4
517-VV8 OR-16-GXL
518-VV9 RD-16-GXL 1552273 1

807-FA3 BR-16 5 807-FC5 BR-16 3E3364 4.7K GROUND 5 200-VV17 BK-16-GXL 124-VV10 GN-16-GXL 1 BK-14
6
808-FA4 PU-16 6 808-FC6 PU-16 806-FC1 GY-16 1 WH VV-T2 3241970 518-VV9 RD-16-GXL 6 WH-14
5
7 811-FC2 GY-16 2 BK 517-VV8 OR-16-GXL 5 GY-14 4
8 PP-C4 12V_POWER_PORT 592-PR17 BU-16 200-PR12 BK-16 VV-C5 516-VV7 BU-16-GXL 4 GN-14
LINEAR_CABLE 3
9 1552269 200-PP3 BK-16 245-2181 PR-T2 2878917 200-PR13 BK-16 1552269 515-VV6 YL-16-GXL 3 BU-14
10 FC-C4 1 EL623-PP7 BU-16 PP-T1 2878915 200-PR12 BK-16 PR-M1 3092088 ARC_SUPPRESSOR_RECEPTACLE 1 520-VV1 WH-16-GXL 567-VV2 WH-16-GXL 2 BR-14
1552269 2
11 2 200-PP4 BK-16 PR-T3 2878917 189-3158 2 569-VV4 PK-16-GXL
RD
12 812-FC4 GN-16 1
BK GAS MOTOR
209-FC3 BK-16 2
200-PP4 BK-16 VV-C6
PP-T2 2878915 FUSE_RECEPTACLE (CAB PRESSURISER) 1552269
308-3610 1 124-VV12 GN-16-GXL 124-VV11 GN-16-GXL
2 569-VV4 PK-16-GXL 124-VV12 GN-16-GXL
ATCH FIRE EXTINGUISHER HARNESS 200-VV17 BK-16-GXL
200-VV18 BK-16-GXL
A/C THERMOSTAT VV-C7 520-VV3 WH-16-GXL
378-7602 1552267 569-VV4 PK-16-GXL
+24 VOLTS BK A 567-VV2 WH-16-GXL
SIGNAL BK B 520-VV3 WH-16-GXL
FUSE_RECEPTACLE PH-C2 GROUND BK C 200-VV18 BK-16-GXL
346-2341 1552273 542-PH1 BU-16 124-VV11 GN-16-GXL
1A 1 635-PH14 BU-16 635-PH6 BU-16 124-VV12 GN-16-GXL
2 636-PH15 GN-16 636-PH7 GN-16 200-VV17 BK-16-GXL
1.5A 3 541-PH16 GN-16 200-VV18 BK-16-GXL
4 542-PH1 BU-16 542-PH1 BU-16 520-VV3 WH-16-GXL 520-VV3 WH-16-GXL
1A 5 636-PH7 GN-16 635-PH6 BU-16 569-VV4 PK-16-GXL
6 635-PH6 BU-16 636-PH7 GN-16

PH-C7 PH-C5 PH-C6 VV-C1 EV-C1 EV-C2

1552269 1552264 2106311 2 5 3E3376 1552272 3E3376 CONNECTS TO
CONNECTS TO CONN. (C-C72) 1 707-PH10 PU-16 J840-PH8 WH-16 1 VV-C3 124-VV14 GN-16-GXL 1 124-EV1 GN-16-GXL 1 CONN. (CR-C4)
85 86 9X1054
LOC I-5 2 J841-PH9 YL-16 2 124-VV13 GN-16-GXL 2 124-EV2 GN-16-GXL 2
LOC D-6
VOLUME 1 OF 2 200-PH2 BK-16 3 519-VV5 PK-16-GXL 3 519-EV3 PK-16-GXL 3
PH-C8 200-PH17 BK-16 4
4 87 30 1
124-VV11 GN-16-GXL 520-VV1 WH-16-GXL 4 520-EV4 WH-16-GXL 4
VOLUME 1 OF 2
1698670
PA-C1 PA-C3
CONNECTS TO CONN. (C-C42) A C533-PH11 PU-16
541-PH16 GN-16
541-PH18 GN-16
5
6
87A
A/C_RELAY
231-3930 A/C_SW
CONN 16
1552272 1552272 B A251-PH12 BK-16 541-PH19 GN-16 7 139-2118
LOC I-5 VV-C4
EXE POS RD EXE POS RD C534-PH13 YL-16 519-VV5 PK-16-GXL
D D
1 EXE POSITIVE LEFT_LOAD_PIN EXE POSITIVE 1 C 8
SIGNAL + WH 2 SIGNAL + 246-0048 SIGNAL + 2 SIGNAL + WH VOLUME 1 OF 2 200-VV19 BK-16-GXL 1552269
SIGNAL - GN 3 SIGNAL - RIGHT_LOAD CELL SIGNAL - 3 SIGNAL - GN 200-VV16 BK-16-GXL 1 RD-18
EXE NEG BK 4 EXE NEGATIVE 246-0051 EXE NEGATIVE 4 EXE NEG BK PH-C1 TWISTED WIRES PH-C4 PAYLOAD_DISPLAY VV-C10 VV-C2 200-VV19 BK-16-GXL 2 WH-18
3E5179 3E5179 247-2040 2131434 1552252
1 542-PH1 BU-16 541-PH18 GN-16 1 POSITIVE SUPPLY 1
REAR_WINDOW_WASHER_MOTOR
2 200-PH2 BK-16 200-PH17 BK-16 2 NEGATIVE SUPPLY 2
7T-8890
H34 3 EL712-PH3 PK-16 EL712-PH3 PK-16 3 LINE + VC-T4 VC-T5 3 200-VV18 BK-16-GXL VV-T1
CONNECTS TO CONN. (C-C5) 4 EL713-PH4 YL-16 EL713-PH4 YL-16 4 LINE SIGNAL 3241970 3241970 4 200-VV17 BK-16-GXL 8M0537_L
LOC I-5 5 EL714-PH5 BU-16 EL714-PH5 BU-16 5 LINE - 200-VC2 BK-16 MOTOR 507-VC3 WH-16 5 200-VV16 BK-16-GXL 200-VV15 BK-16-GXL
6 541-PH19 GN-16 6 LIMIT COMMON 6 200-VV15 BK-16-GXL
PA-C2 PA-C5 VOLUME 1 OF 2 7 635-PH6 BU-16 635-PH14 BU-16 7 LIMIT 1 N.O. VC-C1 VA-C2 VA-C1 7 124-VV10 GN-16-GXL
1552272 1552272 8 636-PH7 GN-16 636-PH15 GN-16 8 LIMIT 2 N.O. VC-M1 3E3364 1552269 3E3364 CONNECTS TO CONN. (C-C37) 8 124-VV11 GN-16-GXL
EXE POS RD 1 EXE POSITIVE RIGHT_LOAD_PIN EXE POSITIVE 1 EXE POS RD 9 J840-PH8 WH-16 9 3092088 1 507-VA1 WH-16 1
LOC G-7 9
SIGNAL + WH 2 SIGNAL + 246-0048 SIGNAL + 2 SIGNAL + WH 10 J841-PH9 YL-16 707-PH10 PU-16 10 REMOTE PRINT 2 506-VA2 PU-16 2 10 124-VV12 GN-16-GXL
FRONT_WINDOW_WASHER_MOTOR VOLUME 1 OF 2
SIGNAL - GN 3 SIGNAL - LEFT_LOAD CELL SIGNAL - 3 SIGNAL - GN 11 11 11 124-VV13 GN-16-GXL
EXE NEG BK 4 EXE NEGATIVE 246-0051 EXE NEGATIVE 4 EXE NEG BK CONN 21 12
200-PH17 BK-16
12 VC-T3
3241970
7T-8890
VC-T2
3241970
12 124-VV14 GN-16-GXL

541-PH18 GN-16 PH-C3 200-VC1 BK-16 MOTOR 506-VC4 PU-16

541-PH19 GN-16 3E3382 ATCH AIR CONDITIONING SYSTEM
TWISTED WIRES
1 RS422 +
200-PH17 BK-16 2 RS422 -
541-PH18 GN-16 C534-PH13 YL-16 3 RS232 IN
EXE POS RD 541-PH19 GN-16 A251-PH12 BK-16 4 RS232 -
ATCH WASHER BOTTLE HARNESS
EXE POS RD PA-S1 C533-PH11 PU-16 5 RS232 +
12
EXE POS RD EXE POS RD 6
EXE POS RD
SIGNAL + WH
SIGNAL + WH PA-S2 PA-C4 PC-C1 PC-C2 PE-C2 PE-C1
12 3E3376 2471629_CP01 2471629_CP02 2471630_CP02 1028804
EXE POS RD SIGNAL + WH SIGNAL + WH
RD
EXE POS RD SIGNAL + WH EXE POS RD 1 EXE POS RD EXE POS RD 1 EXE POS RD EXE POS RD 1 EXE POSITIVE
BK
H34 SIGNAL + WH SIGNAL - GN SIGNAL + WH 2 SIGNAL + WH SIGNAL + WH 2 SIGNAL + WH EXE NEG BK 2 EXE NEGATIVE
WH
SIGNAL + WH SIGNAL - GN PA-S3 SIGNAL - GN 3 SIGNAL - GN SIGNAL - GN 3 SIGNAL - GN SIGNAL + WH 3 SIGNAL +
12 GN
SIGNAL - GN SIGNAL - GN SIGNAL - GN EXE NEG BK 4 EXE NEG BK EXE NEG BK 4 EXE NEG BK SIGNAL - GN 4 SIGNAL -
SIGNAL - GN SIGNAL - GN
EXE NEG BK EXE NEG BK ANTENNA
EXE NEG BK EXE NEG BK PA-S4 247-1625
12
EXE NEG BK EXE NEG BK CBL-KC1 BK-00_EPR_CPE
EXE NEG BK TRANSMITTER PG-C2 PG-C1
247-1634 3004797 3E3370
BR
RF + A BR-16 A RF +
GN
RF - B GN-16 B RF - BATTERY_ELECTRICAL_ISOLATOR
BU
RG GND C BU-16 C RG GROUND 298-2129 FUSE
AL-C4 KG-C2 216-9890
C ATCH PAYLOAD SYSTEM
CONNECTS TO
CONN. RM-C19 1
1552269
EL456-AL1 WH-16
3004881
1
RECEPTACLE
255-0991 500A
C
LOC A-9 2 114-AL2 GN-16 G740-KG2 BU-18 2 KC-T1 1S7251
VOLUME 1 OF 2 3 KH-T1 3115176
KA-C1 KA-C2 KG-C1 4 CBL-KH1 BK-00_EPR_CPE
3E3382 1552273 3E3382 5
PK
1 EL308-KA1 YL-16 EL308-KA1 YL-16 1 1 EL308-KG1 YL-18 6 CBL-KC1 BK-00_EPR_CPE
AL-T1 CONNECTS TO 2 J905-KA2 PU-16 G740-KA5 BU-16 2 2 G740-KG2 BU-18 7 KC-T2 3115176
AL-C1 3092088 CONN. C-C39 3 J904-KA3 GY-16 J904-KA3 GY-16 3 3 J904-KG3 GY-18
1552252 200-AL10 BK-16 332-KA4 BU-16 364-KA7 BU-16 364-KG4 BU-18 KG-C3 BTRY_DISC_SW_DUAL_POLE
N-C2
LOC I-5 4 4 4
3004880
IDLE_TIMER/FIRE_SUPPR_CONT N-C1 1 A275-AL3 BK-16 5 G740-KA5 BU-16 E741-KA6 YL-16 5 5 E741-KG5 YL-18 KJ-T2 3115176 307-6402
(FOAM TYPE) 224-8721 1552264 3E3388 AS-C1 AS-C2 2 559-AL4 YL-16 AL-C3 VOLUME 1 OF 2 6 E741-KA6 YL-16 J905-KA2 PU-16 6 6 J905-KG6 PU-18 1 CBL-KJ1 BK-00_EPR_CPE
RD CONNECTS TO 3E3364 1552269 1698670
+24V BATTERY (UNSWITCHED) 1 102-N1 RD-16 102-N1 RD-16 1 MOTOR 3 A275-AL5 BK-16 LOOP_RECEPTACLE 2 KJ-T1 3115176
YL/BU CONN. (C-C56)
KEY START SW. ON
GROUND
BK
OR
2
3
EL308-N2 YL-16
200-N4 BK-16
EL308-N3 YL-16
200-N4 BK-16
2
3 CONNECTS TO
1
2
114-AS1 GN-16
200-AS2 BK-16
1
2
4
5
X773-AL6 WH-16
EL456-AL1 WH-16
114-AL9 GN-16
114-AL2 GN-16
A
B
BK
RD
AUTO.LUB
PILOT_OIL_PRESS_SW
CONN 22 305-0673 J904-KG3
E741-KG5
GY-18
YL-18
3
4 364-KE1 BU-16
CBL-KJ1 BK-00_EPR_CPE
332-KE2 BU-16
KEY START SW. ON 4 308-N5 YL-16 308-N5 YL-16 4 LOC C-12 SUSPENSION_GP 6 C BU 364-KG4 BU-18 5 KE-T2 3241960 KE-T1 3241960
GY CONN. (C-C76) 3E-7808
FIRE PRESS. SW. N.C. 5 EL710-N6 OR-16 EL710-N7 OR-16 5
LOC F-11 VOLUME 1 OF 2 AS-T1 348-2409 7 EL308-KG1 YL-18 6
BU
FIRE PRESS. SW. N.O. 6 709-N8 BU-16 709-N8 BU-16 6 3092088 8 J905-KG6 PU-18 7 POS NEG POS NEG

ALARM
GY
7 7
VOLUME 1 OF 2 9 C208-AL7 BK-16
8 8 10 802-AL8 YL-16 AL-C2 PILOT_OIL_CONT_SOLENOID
1552269 KA-C4 KE-C1 12V BATTERY
11 200-AL10 BK-16 257-3755
1552269 3E3364 9X-9730
FIRE_SUPPR_CONT EL308-N2 YL-16 SUSPENSION GP-SEAT(AIR) 12 114-AL9 GN-16 559-AL4 YL-16 1 BK-18
PK
(FOAM TYPE) 213-1479 SONAR EL308-N2 YL-16 A275-AL5 BK-16 2 BK-18 364-KA7 BU-16 1 1 364-KE1 BU-16
203-0427 N-M1 3241961 EL710-N6 OR-16 AUTO. LUBRICATION 332-KA4 BU-16 2 2 332-KE2 BU-16
YL/BU SYSTEM CONTROL UNIT AL-C5
KEY START SW. ON + EL308-N3 YL-16 AUTO_LUB_PILOT_OIL_SUPPLY_SOL LOOP_RECEPTACLE SYMBOL DESCRIPTION
BK - 239-8150 1552269
GROUND EL710-N7 OR-16 EL308-N2 YL-16 257-3757 186-8264
OR
KEY START SW. ON N-M2 3241961 EL710-N6 OR-16 X773-AL6 WH-16 1 BK-18 CBL-KH1 BK-00_EPR_CPE
GY
FIRE PRESS. SW. N.C. EL710-N6 OR-16 A275-AL3 BK-16 2 BK-18 CIRCUIT CONNECTED
BU
FIRE PRESS. SW. N.O.
GY
ALARM
AL-C6 AUTO_LUB_PRESS_SW E-C3 CIRCUIT NOT CONNECTED
ARC_SUPPRESSOR
1552269 273-4212 3E3364 316-2969 STARTING MOTOR
RD RD ELECTRICAL CONNECTION TO
IDLE_TIMER_CONT 802-AL8 YL-16 1 BK-18 BK-18 237-1962
BK BK
(FOAM TYPE) 224-8725
RD
C208-AL7 BK-16 2 BK-18 BK-18 START RELAY S G
MACHINE STRUCTURE
+24V BATTERY (UNSWITCHED) MAGNETIC SW
YL/BU CONNECTS TO T-C8 INTERNAL ELECTRICAL CONNECTION
KEY START SW. ON 254-3783
BK 1552269 BAT MTR TO SURFACE OF COMPONENT
GROUND
OR CONNS. PR-C13/PL-C21
KEY START SW. ON (MONITORING SYSTEM) 1 403-T16 GN-16 ATCH AUTO. LUBRICATION SYSTEM KH-T2 1S7251
2 CONNECTOR
LOCS F-9/I-9 MOTOR

VOLUME 2 OF 2
H# CIRCUIT GROUPING DESIGNATION
T-C7 T-C2

B CAMERA BALUN
ATCH FIRE CONT HARNESS 2131435
1
2
1552273
126-T1 PK-16
126-T12 PK-16 PD-C1 PD-C2
ATCH WIRE, CABLE, COMPONENT B
9W0847 3004774 REFRIGERANT_PRESS_SW
CAMERA 233-1949 233-1791 3 126-T13 PK-16 114-5333 SPLICE
4 J765-T4 BU-16 T-C1 A 1
VIDEO CONNECTS TO 1552252
VIDEO 5 J765-T14 BU-16 CONNECTS TO B C533-PD1 PU-16 2 CONNECTS TO CONN. E-C18 1 BK-16
SHIELD CONN. (TY-C7) 3 BLADE, SPADE, RING OR SCREW
SHIELD
RD
6 J765-T15 BU-16 126-T1 PK-16 1
CONN. (C-C44)
C C534-PD2 YL-16 3
LOC H-2 2 BK-16
2 ATCH WIRING BATTERY GP TERMINAL
HTR/SHTR +12V 614-T2 PU-16 2 D 4 1
YL LOC A-12 T-C3 CONNECTS TO (SERVICE TOOL PORT) CONNECTS TO PC VOLUME 1 OF 2 (NOTE D)
CAMERA +9.6V HOIST_CONTROL_POSITION_SENSOR 200-T3 BK-16 3 E A251-PD3 BK-16 5
BK 1698670
GROUND VOLUME 1 OF 2 266-1483 J765-T4 BU-16 4 CONN. C-C78 LOC E-12 F 6 SUPPRESSOR COMPRESSOR_SOL
+24V RD-18 A 126-T12 PK-16 711-T5 BR-16 5 VOLUME 1 OF 2 G 7 186-9488
LOC F-12 3E-1906
GROUND BK-18 B J765-T14 BU-16 M997-T6 PU-16 6 H 8 1
VOLUME 1 OF 2 CONNECTS TO CONN. E-C19
ATCH CAMERA
SIGNAL WH-18 C M997-T6 PU-16 716-T7 BU-16
715-T8 GN-16
7
8
J 9
LOC H-2
2
3
1
2
BK-18
BK-18
WIRE GROUP COLOR DESCRIPTIONS
T-C6 T-C4
714-T9 YL-16
713-T10 OR-16
9
10
CONN 3 PAYLOAD DATA DOWNLOAD CABLE
VOLUME 1 OF 2 4
GROUND CIRCUIT
3E3364 1552269 712-T11 WH-16 11
CONN TO 1 614-T2 PU-16 403-T16 GN-16 12 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
ILLUMINATION HARNESS 2 200-T3 BK-16
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
ATCH COMPRESSOR GP
ABBREV COLOR VOLTAGE CONVERTER OUTPUT CIRCUIT
TT-C2 CONNECTS TO SHIFT_LEVER_POSITION_SENSOR T-C5 126-T12 PK-16
TT-C1 3E3364 9W3089
1552269 1
CONN. (TY-C9) 126-7896
GROUND VERIFY 1 716-T7 BU-16
126-T13 PK-16
J765-T14 BU-16
RD RED STARTING & RUN CIRCUIT
E750-TT1 PU-16 LOC B-13 GROUND J765-T15 BU-16 J765-T15 BU-16 POWER TRAIN
1
2 202-TT2 BK-16
2
VOLUME 1 OF 2 LEVER 1
2
3 711-T5 BR-16
WH WHITE
LEVER 2 4 712-T11 WH-16 126-T12 PK-16 COMPONENTS ARE SHOWN INSTALLED ON A FULLY MONITOR CIRCUIT
TAILGATE_SW TT-T1 LEVER 3 5 713-T10 OR-16 126-T13 PK-16 OPERABLE MACHINE WITH THE KEY AND ENGINE OFF. OR ORANGE
228-4808 2878915 +24V BATTERY (SWITCHED) 6 126-T13 PK-16 J765-T14 BU-16 ENGINE CONTROL CIRCUIT
XMSN SHIFTER IN NEUTRAL AND WITH PARK BRAKE SET.
NEUTRAL 7 J765-T15 BU-16
SPEED SELECT SW ARE SHOWN IN LOW SPEED MODE.
YL YELLOW HEATER AND AIR CONDITIONER CIRCUIT
LEVER 4 8 714-T9 YL-16
LEVER 5
NEUTRAL
9
10
715-T8 GN-16
LOOPED PLUGS DETAILED ON THIS SCHEMATIC ARE
PK PINK TURN SIGNAL / WIPER WASHER CIRCUIT
CAT DATA LINK
USED (IN PLACES INDICATED ) WHEN OPTIONAL BK BLACK
SYSTEMS ARE NOT FITTED. CAN DATA LINK
ATCH XMSN SHIFT CONT HARNESS GY GRAY
ALL WIRES ARE 16 GAUGE UNLESS OTHERWISE PAYLOAD CONTROL CIRCUIT
ATCH TAILGATE SW HARNESS
NOTED. PU PURPLE ENGINE MASTER CIRCUIT
COMPONENTS ARE SHOWN INSTALLED ON A FULLY BR BROWN ETHERNET
OPERABLE MACHINE WITH THE KEY AND ENGINE OFF.
GN GREEN OTHER COLOR DESCRIPTIONS
A PART NUMBERS ON THIS SCHEMATIC ARE FOR
BU BLUE HIGHWAYS A
REFERENCE ONLY, USE RELEVANT PARTS BOOK FOR
ORDERING NEW PARTS.

THIS SCHEMATIC IS FOR THE AD30 GXR1-UP UAT ELECTRICAL SYSTEM

NOTES
A : STANDARD CONFIGURE. CALLOUTS MEDIA NUMBER: UENR4825
B : HARNESS IS FITTED WHEN PUSH TO ENGAGE OPTION IS FITTED. Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
C : THIS SPLICE RECEPTACLE IS FITTED WHEN THE FRONT PARK LIGHTS ARE REQUIRED. in neutral and with parking brake set.
D : PRESSURIZE SYSTEM MAINTAINS THE SW. IN THE CLOSED POSITION. Callout Number Component
E : THIS HARNESS IS FITTED WHEN FIRE SUPPRESSION SYSTEM (DRY POWDER TYPE) IS FITTED. (Machine Location from (52) VALVE GP - CONTROL Name Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
F : ELECTRONIC ACCESS MODULE (VIMS) HAS ONE 70 PIN PLUGS. Component Locations Table)
G : NO LONGER USED. 138-1234 Part Number Note: Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
H : NO LONGER USED.
J : LED LIGHT OPTION.

14 13 12 11 10 9 8 7 6 5 4 3 2 1