COSHH: Control of
Substances Hazardous to Health
Module 2
Health
& Safety
16-23 November 2013
Essentials
Registered charity number 207890
Hazardous substances
Objective:
In this component, you will learn where to find information to enable you to classify and
assess chemical risk.
Some Important Sources of Information on Chemical Hazards:
Labels on chemical containers
Your supervisor
Your University Health & Safety adviser/officer
Suppliers Safety Data Sheets (SDS)
Reference books
Safety Data Sheets (SDS) are produced by suppliers. They provide information on chemical products that help users
of those chemicals to assess risk. They describe the hazards of the substance or preparation (mixture) and give
information on handling, storage and emergency measures in case of an accident. An SDS is not a risk assessment!
How are hazardous substances identified?
All substances are poisonous; there is none which is not a poison. The right dose differentiates a poison and a
remedy Paracelsus, 1525
A substance hazardous to health is a substance or preparation (mixture) with the potential to cause harm if inhaled,
ingested, touched or absorbed through the skin. Such a substance is identified as dangerous for supply, and is
classified as either very toxic, toxic, harmful, corrosive or an irritant.
This includes:
substances identified as dangerous for supply and classified as very toxic, toxic (including sensitisers and
carcinogens), harmful, corrosive or an irritant
any substance that has an approved Workplace Exposure Limit (WEL)
any biological agent used at work (e.g., microorganisms)
any dust (e.g., wood dust). This is defined in terms of total airborne or respirable dust (i.e., >10mg/m3 TWA 8hr or >
4mg/m3 TWA 8hr).
any other substance that creates a risk to health because of its properties and the way it is used or is present in the
workplace
Health
& Safety
16-23 November 2013
Essentials
Registered charity number 207890
Substances of known toxicity
Substances hazardous to health as defined by the COSHH Regulations derive their hazard classifications from either
the Chemicals (Hazard Information and Packaging for Supply) Regulations (CHIP) 2002 or the European Regulations
(EC) No 1272/2008 on Classification, Labelling and Packaging of Substances and Mixtures Regulations (CLP).
From now until June 1st, 2015, there is a transition period from the requirements of CHIP to those of CLP; both
classification systems will remain in operation until 2015, after which only CLP will apply. Both classification systems
provide pictorial and descriptive information about hazards together with information on protecting yourself from the
hazards so described. The two systems have different requirements for substances and preparations.
Note that under the new Classification Labelling and Packaging regulation (CLP), Hazard statements (H) replace
the Risk (R) phrases of CHIP, and Precautionary statements (P) replace the Safety phrases (S) on labels and safety
data sheets.
Since 2009, the new international symbols have been gradually replacing the European symbols.
CHIP hazard pictograms (orange boxes) are very similar to the new CLP hazard symbols (red end-on squares, see
below), but there is no word or phrase describing the hazard.
Toxic or Very Toxic
Acute Toxicity
Severe
Irritant or Harmful
Irritant or Toxic or
STOT (Less Severe)
Corrosive
Corrosive
CMR or STOT or
Aspiration Hazard
CMR = carcinogenic, germ cell mutagenic, toxic to reproduction;
STOT = specific target organ toxicity
HSE COSHH Essentials assigns most substances to one of six toxic hazard categories:
A = low (e.g., R36 Irritating to eyes)
B = moderate (e.g., R20 Harmful by inhalation)
C = significant (e.g., R23 Toxic by inhalation)
D = high (e.g., R26 Very toxic by inhalation)
E = special, including substances of extreme hazard (e.g., R45 May cause cancer)
S = substances causing harm in contact with skin and eyes (often substances penetrate the skin, so there is almost
always a skin risk)
Health
& Safety
16-23 November 2013
Essentials
Registered charity number 207890
For substances and mixtures that do not have CHIP Risk Phrases, other sources of information should be used to
determine suitable hazard categories. These include:
in-house
and third party experience and data
advice from suppliers
technical and scientific literature (books, journals, etc.)
guidance from the UK Health & Safety Executive (HSE) and other authoritative bodies such as learned societies,
professional institutions and trade associations
specialist occupational health consultants
Substances of unknown toxicity
Novel and uncategorised substances of unknown toxicity require careful consideration. They should be treated as
high hazards.
Note that Hazardous Substances that have properties that classify them as flammable, oxidizing and explosive are
also covered by other regulations such as The Dangerous Substances and Explosive Atmospheres Regulations
(DSEAR2002) and explosives legislation in the UK.
Checklist for Identifying Chemical Hazards
Does
any chemical/mixture you use have a danger/warning label?
Is the substance harmful to breathe in?
Can the substance harm your skin?
Does your work produce gas, fumes, dust, mist or vapour?
Is it likely that harm could arise because of the way in which chemicals will be used?
Learning assessment 1
Are the statements below true or false?
true
1.
COSHH assessments need to be carried out for all hazardous substances (chemicals)
stored in the laboratory.
2.
COSHH assessments include potential damage to property.
3.
Substances that are classified as flammable must be included in COSHH assessments.
4.
Risk is a product of hazard likelihood, and the extent and consequences of exposure.
5.
OSHH only applies to hazardous substances, out of or in connection with work-related
C
activities within a workplace, such as a laboratory.
6.
I have just prepared a reagent containing Dichloromethane: Water 80:20. My label only
needs to say the chemical names.
7.
The SDS is all I need to compile the COSHH assessment.
false
Check your answers on the separate answer sheet.
Health
& Safety
16-23 November 2013
Essentials
Registered charity number 207890
