MAINTENANCE INFORMATION / FLUID SPECS AND CAPACITIES
MODEL IDENTIFICATION – Example of 1997 Ford/Mercury 2.0L
http://www.autorepairinmesa.com
VIN LOCATION-
The Vehicle Identification Number (VIN) is located on the left side of the dash
panel at the base of the windshield. The VIN chart explains the code characters.
VIN CODE ID EXPLANATION-
Numbers preceding the explanation in the legend below refer to the sequence
of characters as listed on the VIN identification label. See VIN examples below.
(VIN) 1 F A B P 1 0 J 2 M A 1 0 0 0 0 1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
1- Manufacturer
1. Ford Motor Company, USA
3. Ford Motor Company, Mexico
2- Make
F. Ford
M. Mercury
3- Type
A. Ford Passenger Car
E. Mercury Passenger Car
4- Restraint System
L. Active Belts (All Positions) & Driver, & Passenger Air Bags
B. Active Seat Belts (Front and Rear)
5- Manufacturer Specification Code
P. Ford
M. Mercury
6 – 7 Body Type
10. Escort 4-Door Sedan
10. Tracer GS 4-Door Sedan
13. Escort LX 4-Door Sedan
13. Tracer LS 4-Door Sedan
15. Escort LX 4-Door Sedan
15. Tracer LS 4-Door Sedan
MAINTENANCE INFORMATION / FLUID SPECS AND CAPACITIES
8- Engine Type
P. 2.0L EFI 4-Cylinder SOHC
9- VIN Check Digit
0. Constant for All Models
10- Vehicle Model Year
V. 1997
11- Assembly Plant Code
R. Hermosillo, Mexico
W. Wayne, Michigan
12 – 17 Production Sequence
100,001 - 599,999- Ford Division
600,001 – 999,999- Mercury Division
MAINTENANCE SERVICE INFORMATION
SEVERE AND NORMAL SERVICE DEFINITIONS
Service is recommended at mileage intervals based on vehicle operation.
Service Schedules are based on the following primary operation conditions:
Normal Service
• Driven more than 10 miles daily.
• No operating conditions from severe service schedule.
Severe Service
NOTE: Use the severe service schedule if the vehicle to be serviced is operated
under ANY (one or more) of these conditions:
• Towing a trailer or using a car-top carrier.
• Operating in severe dust conditions.
• Extensive idling, such as police, taxi, or door-to-door delivery service.
• Short trips of less than 10 miles (16 km) when outside temperatures remain
below 0 (-18C)
MAINTENANCE INFORMATION / FLUID SPECS AND CAPACITIES
1997 Ford Escort
LUBRICATION SPECIFICATIONS
Lubrication Specifications Table
Material Conditions Specifications
Engine Oil (1) All SAE 5W-30
Engine Coolant All 50/50 Mixture Distilled Water
Ethylene Glycol
Brake Fluid All DOT 3
Automatic All Mercon Multi Purpose AFT
Transmission Fluid
Manual All Mercon Multi Purpose AFT
Transmission Fluid
Hinges and Latches All Multi- Purpose Grease Spay
(Aerosol)
Wheel Bearings All Premium Long-Life Grease
Rear Ford Specifications ESA
M1C75-B
Power Steering All Premium Power Steering Fluid
Fluid Ford Specifications EWS
M2C33-F
Starburst Symbol.
FLUID CAPACITIES
Fluid Capacities Table
Item Condition Specification (1)
Engine Oil Drained, with filter 4.0 Qts. (3.80L)
Drained 3.5 Qts. (3.30L)
Engine Coolant Drained Automatic Trans. 6.3 Qts. (6.00L)
Drained Manual Trans. 5.3 Qts. (5.00L)
Automatic Full Torque Converter 4.1 Qts. (3.90L)
Transmission Fluid
Empty Torque Converter 6.7 Qts (6.30L)
Manual Capacity 3.55 Qts. (3.35L)
Transmission Fluid
Fuel Tank Capacity 12.7 Gal. (48.0L)
(if available) to
measure level.
MAINTENANCE INFORMATION / FLUID SPECS AND CAPACITIES
WHEEL AND TIRE SPECIFICATIONS
Tire Replacement
Replace tires when the wear band is visible through the tire threads.
CAUTION: When replacing full size tires, never mix radial, bias belted or bias-type
tires. Use only the tire sizes that are listed on the tire pressure decal.
TIRE INFLATION
Inflation pressure can be found on decal attached to right door pillar.
Item Action Time (1)
Tire Pressure Inspect Once a Month
Engine Coolant Level Inspect Once a Month
Operation of all Exterior Inspect Once a Month
Lamps: Brakelamps, Turn
Signal, Hazards
Radiator, Heater & air- Inspect Every 6 Month
conditioning Hoses
Power Steering Fluid Level Inspect Every 6 Month
Wiper Blades & Spray Inspect Every 6 Month
Pattern
Worn Tires or Loose Lug Inspect Every 6 Month
Nuts
Underbody Components Inspect Every 6 Month
Lap-Shoulder Belts Inspect Every 6 Month
Parking Brake System Inspect Every 6 Month
Brake Fluid Inspect Every 6 Month
Seatback Latches Inspect Every 6 Month
Clean Body Water Drain Service Every 6 Month
Holes
Headlamp Alignment Inspect Every 6 Month
Air Pressure In Spare Tire Inspect Every 6 Month
Brake Master Cylinder Inspect Every 6 Month
Flush underside of Vehicle Service Every 6 Month
Engine Cooling System, Inspect Every 12 Months
Hoses, Clamps & Coolant
Strength
Air Conditioning System Inspect Every 12 Months
Lubricate All Hinges Service Every 12 Months
Checks, Latches & Locks
3,000 MILE (5,000 KM) SEVERE DUTY SERVICE
3,000 Mile (5,000 KM) Severe Duty Service
Replace
Engine Oil & Filter
Lubrication Specifications
Material Condition Specification
Engine Oil (1) All Climate Conditions SAE 5W-30
Down to -15 F (-25 C)
(Starburst Symbol)
Fluid Capacities
Items Condition Specifications (1)
Engine Oil Drained, with filter 5.0 QTS. (4.70L)
(if available) to measure
level.
