Y018787-EN.qxp 09.09.

2004 11:33 Seite 1

Product Catalogue

Service Kits
For Compressors

Note:
This Catalogue covers the Rationalised Service
Kits designed to be used on the range of
Knorr-Bremse compressors manufactured in its
Lisieux, France factory.
Details of Service Kits for other Knorr-Bremse
compressors made in its other factories can be
found on the Knorr-Bremse website:

www.Knorr-BremseSfN.com.

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 2

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 3

DISCLAIMER
The information contained herein is intended for the exclusive use of trained persons within the
commercial vehicle industry, and must not be passed on to any third party.

This information does not purport to be all-inclusive and no responsibility is assumed as a result
of its use. We cannot accept any liability nor offer any guarantee regarding data
accuracy, completeness or timeliness. The information does not represent any guarantee or ensu-
red characteristics of the Products or Systems described.

No liability can be accepted based on the information, its use, recommendations or advice provi-
ded. In no event may we be held liable for any damage or loss except in the case of wilful intent
or gross negligence on our part, or if any mandatory legal provisions apply.

Brand names mentioned in this information are not identified as such in all cases. We would
emphasise however that they are nevertheless subject to the provisions of trademark
legislation.

Any legal disputes arising from the use of this information shall be subject to German law.

Failure of any individual clause of this disclaimer to comply with current legal provisions does not
affect the validity of the remaining clauses.

The information, either in part or whole, may not be copied, reproduced or transmitted in any
form without the prior explicit permission of Knorr-Bremse Systems for Commercial Vehicles. Any
contravention will be liable for damages and prosecution. The contents of this document are also
protected under EU regulation 6/2002 and equivalent local legislation. All rights reserved.

This disclaimer is an English translation of a German text, which should be referred to for all legal
purposes.

KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 4

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite i

Service Kits for Compressors

Index

Section Page

1. Introduction 1

2. Service Instructions 7

3. Service Kits for Compressors 13

3.1 Listed by Compressor Type Number 15

3.2 Listed by Compressor Part Number 19

4. Service Kit Contents 23

-i- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite ii

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 1

1. Introduction

Thanks to the standardisation of the kit content, the number of service kits for the new generation
Knorr-Bremse Compressors has been reduced.

The content of each kit in this new range has been designed to ensure the efficiency and quality of any
service work.

This quality can only be optimised by the use of genuine Knorr-Bremse components.

NOTES - this Catalogue covers the Rationalised Service Kits designed to be used on the range of
Knorr-Bremse compressors manufactured in its Lisieux, France factory, as listed in the tables from pages 15 to 21.
Details of Service Kits for other Knorr-Bremse compressors made in its other factories can be found on the Knorr-
Bremse website - www.Knorr-BremseSfN.com.

The compressors serviced by the Rationalised Service Kits are used in various European countries and the inclusion
of a kit in this document does not necessarily imply its immediate availability in all countries.

-1- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 2

1. Introduction

Legend for Diagram on page 3

Piston Assembly (Standard)

Piston
Piston Rings
Gudgeon Pin
Circlips

Piston Assembly (+0.5mm Oversize)

Piston
Piston Rings
Gudgeon Pin
Circlips

Valve Plate

Valve Plate complete

Complete Kit

Gaskets
Inlet Reed
Delivery Reed
ESS components

Cylinder Head

Cylinder Head complete

Gasket Kit

Gaskets

KNORR-BREMSE
Systems for Commercial Vehicles
-2-
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 3

1. Introduction

Rationalised Service Kits - Single Cylinder Compressors

-3- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 4

1. Introduction

Legend for Diagram on page 5

Piston Assembly (Standard) (See Note)

Piston
Piston Rings
Gudgeon Pin
Circlips

Piston Assembly (+0.5mm Oversize) (See Note)

Piston
Piston Rings
Gudgeon Pin
Circlips

Valve Plate

Valve Plate complete

Complete Kit

Gaskets
Inlet Reed
Delivery Reed
ESS components

Cylinder Head

Cylinder Head complete

Gasket Kit

Gaskets

Note: The Kit contains 2 Piston Assemblies.

KNORR-BREMSE
Systems for Commercial Vehicles
-4-
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 5

1. Introduction

Rationalised Service Kits - Twin Cylinder Compressors

-5- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 6

KNORR-BREMSE
Systems for Commercial Vehicles
-6-
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 7

2. Service Instructions

1.General

For cleaning, a non-aggressive acid-free solvent with corrosion inhibitor must be used.
For lubrication of components, use clean motor oil unless otherwise stated.
These instructions are written for a single cylinder compressor. For twin cylinder
compressors, references to components should be read as plural and actions should be
duplicated as appropriate.

Note:
We draw your attention to the fact that, when a component is damaged during the
dismantling and/or assembly phases, Knorr-Bremse shall accept no liability and shall reject any
claim for warranty costs concerning the Compressor.

Any dismantling operation invalidates the compressor warranty.

2. Replacing a Cylinder Head or Head Gasket

Service Parts/Kits required: Cylinder Head complete, Gasket Kit.

When replacing a Cylinder Head, both the Cylinder Head-Valve Plate and Valve Plate-Crankcase
Gaskets must always be replaced.

Replacing a Cylinder Head (as a single part or as a pre-assembled part in the case of an energy
saving compressor) requires careful dismantling to overcome the adhesive force between the
Cylinder Head Gasket and the mating surfaces.

If the Cylinder Head or Valve Plate is not being replaced, clean the gasket contact area without
causing scratches that might cause leakage problems later.

Fit the new Cylinder Head Gasket and then the Cylinder Head.

Lubricate the Cylinder Head Bolts.

Insert the Cylinder Head Bolts and tighten them in two stages following the sequence shown
on the diagrams below. Firstly, tighten them to a torque of 15 to 20 Nm. Repeat the sequence,
tightening to a final torque of 30 to 33 Nm.

-7- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 8

2. Service Instructions

3. Replacing a Valve Plate

Service Parts/Kits required: Valve Plate complete, Gasket Kit.

Replacing a Valve Plate requires the prior removal of the Cylinder Head assembly (with the
Cooling Plate, if fitted), the Valve Plate-Cylinder Head Gasket (see Section 2) and, depending on
the version, the Valve Plate-Crankcase Gasket or the combined Inlet Reed Valve/Gasket. Take
care when overcoming the adhesive force between the Valve Plate Gasket and its mating
surfaces

Carefully clean the top face of the Crankcase in order to remove any contamination or metallic
burrs without causing scratches that might cause leakage problems later.

Clean the Piston Crown if the Piston is not being replaced.

Irrespective of their condition, the gaskets should be replaced.

Some models are equipped with a screw fixing the Valve Plate to the Crankcase and some with
a screw fixing the Valve Plate to the Cylinder Head. In these cases, clean the screw carefully,
lubricate the threaded area and tighten to a torque of 11.4 to 12.6 Nm.

Fit the new Valve Plate-Crankcase Gasket onto the Crankcase, then fit the Inlet Reed and any
Spacer, taking care that it is correctly located and that the Inlet Reed is not trapped. Then fit the
new Valve Plate and the Valve Plate-Cylinder Head Gasket.

Finally, re-fit the Cylinder Head (see Section 2).

4. Replacing a Piston

Service Parts/Kits required: Piston Assembly, Gasket Kit.

Replacing a Piston requires the disassembly of the Connecting Rod Cap in order to remove the
Piston/Connecting Rod assembly. The Connecting Rod Cap is accessed through the Sump Plate
opening (see Section 6) and before removing the cap it should be noted which way round it is
fitted with respect to the Connecting Rod.

Remove the Cylinder Head (see Section 2) and Valve Plate (see Section 3). The
Piston/Connecting Rod assembly can now be withdrawn through the top of the Crankcase.

Remove the Circlips holding the Gudgeon Pin in the Piston, then withdraw the Gudgeon Pin to
separate the Piston from the Connecting Rod.

Lubricate the Gudgeon Pin, fit the Connecting Rod into the new Piston and insert the Gudgeon
Pin.
Fit the Circlips retaining the Gudgeon Pin and make sure that they are correctly fitted into the

KNORR-BREMSE
Systems for Commercial Vehicles
-8-
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 9

2. Service Instructions

grooves of the Piston. Fit the Piston Rings to the Piston, if not already fitted.

Clean the Crankcase bore taking care to remove any contamination or metallic burrs.

Lightly lubricate the Piston Skirt as well as the Piston Rings.

Position each Piston Ring so that its gap is approximately 120 from the gap in the
adjacent ring. This is to ensure that the three gaps are not in alignment during
re-assembly.

Locate the Piston carefully in the Crankcase bore without scoring the aluminium skirt.

When the Piston Skirt is located, compress the Piston Rings in their respective grooves using a
Ring Compression Tool. Depending on the tool used, the Piston Rings may be compressed
successively, in which case the Piston is fitted into the Crankcase bore in three successive steps,
or the rings may be compressed all together in which case the complete Piston is fitted in one
operation.

The fitting of the Piston into the bore requires some force to be applied and so there is a need
to proceed cautiously as any impact on the lips of the Piston Rings could cause irreparable
damage and seriously harm the compressor performance.

Lubricate the Crankshaft and Connecting Rod bearing surfaces and threads. Finally
re-assemble the Connecting Rod Cap over the Crankshaft taking care to assemble the cap the
right way round. The tightening torque of the Connecting Rod Bolts is 13 to16 Nm.

Rotate the Crankshaft with the Connecting Rod/Piston assembly fitted to make sure that there
are no tight spots.

Fit a new Sump Plate Gasket and assemble the Sump Plate (see Section 6).

Fit the Valve Plate-Crankcase Gasket and the Valve Plate. Fit new Valve Plate-Cylinder Head
Gasket and Cylinder Head (see Sections 2 and 3).

Note: any scratch in the Crankcase bore or on one of the Piston Rings will lead to a
noticeable increase in the oil carry-over of the compressor

5. Replacing the Rear Bearing Cover Seal

Service Parts/Kits required: Gasket Kit.

Note - on a compressor with SAE through-drive it is not possible to remove the Bearing Cover
from the Crankshaft. In this case the Connecting Rod has to be detached from the Crankshaft
and the Crankshaft and Bearing Cover removed together.
After removal and cleaning of the Bearing Cover, make sure that there are no burrs or sharp
edges, which might cut the Seal during assembly.

-9- KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 10

2. Service Instructions

Lubricate the seal groove in the Bearing Cover and fit the new Seal.

Lightly lubricate the spigot (Bearing Cover to Crankcase) and fit the Bearing Cover in position.

Lubricate the 4 screws and tighten crosswise in one single step to a torque of 22 to 24 Nm.

Make sure that the Crankshaft rotates freely and has finite but minimal clearance in the axial
direction.

6. Replacing the Sump Plate Gasket:

Service Parts/Kits required: Gasket Kit

After removal of the Sump Plate and Gasket, carefully clean the mating faces of both the
Crankcase and Sump Plate.

Place the new Gasket on the cleaned surface of the Sump Plate (for a metallic gasket, place the
raised pre-formed side on the Sump Plate). Fit the Sump Plate and fasten crosswise the 4
screws in one step to a torque of 11 to 13 Nm.

7. Servicing the Energy Saving Systems (ESS):

Service Parts/Kits required: Complete Kit.

7.1. ESS in crankcase:

Remove the Cylinder Head (see Section 2), the Valve Plate (see Section 3) and the Inlet Reed
plus the associated ESS components on the top face of the Crankcase. Remove the Dowel Pin
from the ESS Piston. Clean the top face of the Crankcase and check that there are no burrs.

Check that the machined slot in the top face of the Crankcase is not damaged.

Remove the Plug/Cap holding the ESS Piston in the Crankcase and remove the Piston and
Spring.

After lubricating the parts, reassemble the new Spring and new ESS Piston with Anti-extrusion
Ring and O-ring in the Crankcase. Fit the Dowel Pin through the top face of the Crankcase into
its hole in the ESS Piston.

Manually operate the Piston to make sure that it returns fully under the load of the Spring to
the off-position (on-load condition).

Fit the ESS Bell Crank pressing it over the Dowel Pins and fit the Sliding Pin in the
machined slot in the Crankcase.

KNORR-BREMSE
Systems for Commercial Vehicles
- 10 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 11

2. Service Instructions

Position the Inlet Reed. It must be fitted within the profile of the new steel gasket. Make sure
that the Inlet Reed is not jammed under the steel gasket.

After reassembly of these parts, manually operate the ESS Piston again to make sure that the
Inlet Reed moves correctly without sticking and that the assembly returns fully to the
off-position (on-load condition).

Depending on the version, fit the Plug/Cap in the ESS Piston bore in the Crankcase:

- Bored hole: refit the Cap with its O-ring into the bored hole and secure in place with
the circular ring.

- Threaded hole: assemble the Plug with its flat gasket into the unused port and tighten
to a torque of 50 to 55 Nm.

Assemble the new Valve Plate-Crankcase Gasket, Valve Plate, new Valve Plate-Cylinder Head
Gasket and Cylinder Head (see Sections 2 and 3).

7.2. ESS in Cylinder Head

This work can be carried out without removing the Cylinder Head.

Remove the Cover and ESS Piston, clean the bore machined in the Cylinder Head. Check the
surface condition of the bore.

Grease all of the components and the bore in the Cylinder Head. Fit new O-Ring on the ESS
Piston and reassemble the Piston in the Cylinder Head. Position the new Cover Gasket and fit
the Cover (the breather hole must not be blocked or covered). Finally, secure the Cover with
both screws, tightening them to a torque of 5,5 to 8,5 Nm.

- 11 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 12

KNORR-BREMSE
Systems for Commercial Vehicles
- 12 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 13

3. Service Kits for Compressors

- 13 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 14

KNORR-BREMSE
Systems for Commercial Vehicles
- 14 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 15

3.1 Service Kits for Compressors

( Listed by Compressor Type Number )

Compressor Compressor Piston Piston

Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Type No. Part No. Standard * Oversize*

1013077000 SEB22537 SEB22538 SEB22535 SEB22536 SEB22579 10300004

1013078000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013080000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013081000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013083000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013084000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013085000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013099000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013278000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013281000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013283000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013284000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013285000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013378000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013383000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013387000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013391000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013393000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013395000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013397000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013398000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013491000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1194233 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194275 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194357 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194410 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
1194415 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01878004
1194421 SEB22547 SEB22548 SEB22571 SEB22550 SEB22578 SEB01879004
1194425 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194430 SEB22547 SEB22548 SEB22569 SEB22570 SEB22590 SEB01880004
1194454 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194455 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194456 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194458 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194487 SEB22547 SEB22548 SEB22571 SEB22550 SEB22588 SEB01879004
LK1554 SEB01149 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LK1555 SEB01150 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LK1567 SEB01686 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LK3830 II36423 SEB22517 II364230051 SEB22589 Y004640004
LK3833 SEB01586 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
LK3834 SEB01597 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
LK3835 SEB01599 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
LK3836 SEB01601 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3837 SEB01602 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3838 SEB01603 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3839 K000853 SEB22517 SEB22518 SEB01629004 SEB01649004
LK3839 SEB01604 SEB22517 SEB22518 SEB01629004 SEB01649004
LK3840 SEB01605 SEB22517 SEB22518 SEB01682004 SEB01649004
LK3840 SEB01689 SEB22517 SEB22518 SEB01682004 SEB01649004
LK3840 SEB01819 SEB22517 SEB22518 SEB01682004 SEB01649004
LK3841 SEB01606 SEB22517 SEB22518 SEB01745004 SEB01649004
LK3843 SEB01618 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
LK3845 II38683F SEB22517 SEB22518 SEB01786004 SEB01649004
LK3846 K000861 SEB22517 SEB22518 SEB01629004 SEB01649004
LK3846 SEB01817 SEB22517 SEB22518 SEB01629004 SEB01649004
LK3847 SEB01690 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
LK3847 SEB01718 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
LK3847 SEB01719 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
LK3850 SEB01768 SEB22517 SEB22518 SEB01820004 SEB01649004
LK3852 SEB01777 SEB22517 SEB22518 SEB01760004 SEB01649004
* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

- 15 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 16

3.1 Service Kits for Compressors

( Listed by Compressor Type Number )
Compressor Compressor Piston Piston
Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Type No. Part No. Standard * Oversize*

LK3853 SEB01759 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004

LK3854 SEB01816 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
LK3855 SEB01805 SEB22517 SEB22518 SEB01745004 SEB01649004
LK3857 SEB01813 SEB22517 SEB22519 SEB22518 SEB01814004 SEB01593004
LK3859 K000854 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3859 SEB01841 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3867 K001728 SEB22517 SEB22518 SEB01760004 SEB01649004
LK3976 K002580 SEB22530 SEB22532 SEB01891004 SEB01898004
LK3994 SEB01580 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004
LK3994 SEB01842 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004
LK4918 K000230 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4918 K001267 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4919 K000231 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4919 K002029 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4920 K000232 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LK4921 K000233 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4921 K001268 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4922 K000234 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
LK4922 K002030 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
LK4927 II39523F SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LK4935 K000839 SEB22547 SEB22550 SEB22588 SEB01879004
LK4935 K001207 SEB22547 SEB22548 SEB22549 SEB22550 SEB01873004 SEB01878004
LK4935 K002123 SEB22547 SEB22548 SEB22549 SEB22550 SEB01873004 SEB01878004
LK4936 K001126 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01878004
LK4937 K001127 SEB22547 SEB22548 SEB22571 SEB22550 SEB22578 SEB01879004
LK4938 K001935 SEB01889004 SEB22560 SEB22561 SEB01888004 SEB01033004
LK4941 K002072 SEB22555 SEB22560 SEB22561 SEB01895004 SEB01033004
LK4952 K002120 SEB22547 SEB22548 SEB22571 SEB22550 SEB22588 SEB01879004
LP1596 SEB00416 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LP1598 SEB00564 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LP1599 SEB00688 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
LP3832 SEB00348 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3833 SEB00354 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3843 SEB00356 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3852 SEB00650 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3857 SEB00796 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3860 SEB01151 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3861 SEB01152 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
LP3970 SEB01751 SEB22530 SEB22593 SEB22479 SEB01750004 SEB22575
LP3974 SEB01791 SEB22530 SEB015800052 SEB01894004 Y004552004
LP3977 K000855 SEB22530 SEB22532 SEB01881004 SEB01694004 SEB01728004
LP3977 SEB01795 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004
LP4812 I86909 SEB22539 SEB22540 SEB22541 SEB22542 SEB00421004 I81015004
LP4813 I90499 SEB22539 SEB22540 SEB22541 SEB22542 SEB00551004 I81015004
LP4814 I97492 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
LP4815 I97493 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
LP4818 SEB00820 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
LP4819 SEB00836 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4819 SEB01441 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01511004
LP4823 II15697 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
LP4823 II34840 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
LP4823 SEB01782 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
LP4825 II15993 SEB22539 SEB22540 SEB22545 SEB22546 SEB01080004 SEB01081004
LP4827 SEB01161 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4827 SEB01452 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4828 SEB01185 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4828 SEB01463 SEB22551 SEB22552 SEB22553 SEB22554 SEB22586 SEB01495004
LP4829 II18214 SEB22539 SEB22540 SEB22545 SEB22546 SEB01080004 SEB01081004
LP4830 II18599 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
LP4830 II34841 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
LP4830 SEB01781 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
LP4831 SEB01246 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4831 SEB01474 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4832 SEB01245 SEB22537 SEB22538 SEB22535 SEB22536 SEB22580 10300004
LP4833 SEB01250 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4833 SEB01485 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4838 SEB01297 SEB22551 SEB22552 SEB22553 SEB22554 Obsolete SEB01495004
LP4838 SEB01496 SEB22551 SEB22552 SEB22553 SEB22554 Obsolete SEB01495004
LP4840 SEB01392 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4840 SEB01472 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
LP4842 II30901 SEB22539 SEB22540 SEB22541 SEB22542 SEB01449 I81015004
LP4843 SEB01430 SEB22551 SEB22552 SEB22553 SEB22554 SEB22584 SEB01511004
LP4844 II32842 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
LP4845 SEB01455 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
LP4846 SEB01478 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4846 SEB01527 SEB22551 SEB22552 SEB22553 SEB22554 SEB22585 SEB01511004
* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

KNORR-BREMSE
Systems for Commercial Vehicles
- 16 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 17

3.1 Service Kits for Compressors

( Listed by Compressor Type Number )
Compressor Compressor Piston Piston
Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Type No. Part No. Standard * Oversize*

LP4848 SEB01479 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004

LP4849 SEB01480 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
LP4850 II35564 SEB22539 SEB22540 SEB22543 SEB22544 SEB01515004 SEB01000004
LP4851 SEB01545 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
LP4852 SEB01588 SEB22539 SEB22540 SEB22541 SEB22542 SEB22592 I81015004
LP4853 SEB01619 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
LP4855 SEB01747 SEB22551 SEB22552 SEB22553 SEB22554 SEB22584 SEB01511004
LP4857 K000821 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
LP4857 K002140 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
LP4858 K001095 SEB22547 SEB22548 SEB22569 SEB22570 SEB22576 SEB01880004
LP4930 II15698 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
LP4934 II15992 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
LP4934 II30895 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
LP4936 II16243 SEB22555 SEB22560 SEB22561 SEB01148004 SEB01033004
LP4939 SEB01154 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
LP4940 SEB01155 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
LP4941 SEB01156 SEB22528 SEB22529 SEB22526 SEB22527 SEB22580 10300004
LP4942 SEB01157 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
LP4943 SEB01158 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
LP4944 SEB01159 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
LP4945 SEB01160 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
LP4948 II19187 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
LP4949 II19191 SEB22555 SEB22562 SEB22563 SEB01052004 SEB01033004
LP4955 II31730 SEB22555 SEB22560 SEB22561 SEB01429004 SEB01033004
LP4957 II17395 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
LP4957 K002045 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
LP4957 K002975 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
LP4960 II30899 SEB22555 SEB22560 SEB22561 SEB01445004 SEB01033004
LP4960 K000237 SEB22555 SEB22560 SEB22561 SEB01445004 SEB01033004
LP4961 II30900 SEB22555 SEB22560 SEB22561 SEB01429004 SEB01033004
LP4962 II31955 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4963 II32686 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
LP4964 II32687 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4964 K002046 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4965 II32688 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4965 K002047 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4966 II32689 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
LP4967 II33164 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
LP4968 II33514 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
LP4969 II34404 SEB22555 SEB22556 SEB22557 SEB01655004 SEB01034004
LP4970 II34405 SEB22555 SEB22556 SEB22557 SEB01655004 SEB01034004
LP4974 II37214 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
LP4974 K000236 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
LP4977 II37369 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
LP4977 SEB01725 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
LP4979 II37435 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
LP4980 II37436 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
LP4981 II37437 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
LP4983 SEB01784 SEB22555 SEB22556 SEB22557 SEB01583004 SEB01034004
LP4984 SEB01783 SEB22555 SEB22556 SEB22557 SEB01583004 SEB01034004
LP4985 K000229 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4986 II37953 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LP4988 II37958 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4989 II38142F SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LP4990 II38145F SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
LP4991 II38776F SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4992 II38777F SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4992 K000235 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4993 II38779F SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LP4995 II38844F SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
LP4996 II38845F SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
LP4997 II38846F SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
LP4998 SEB01674 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
LP4999 SEB01676 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
LP4999 SEB01677 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
LP4999 SEB01678 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

- 17 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 18

KNORR-BREMSE
Systems for Commercial Vehicles
- 18 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 19

3.2 Service Kits for Compressors

( Listed by Compressor Part Number )

Compressor Compressor Piston Piston

Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Part No. Type No. Standard * Oversize*

1194233 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004

1194275 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194357 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194410 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
1194415 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01878004
1194421 SEB22547 SEB22548 SEB22571 SEB22550 SEB22578 SEB01879004
1194425 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194430 SEB22547 SEB22548 SEB22569 SEB22570 SEB22590 SEB01880004
1194454 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194455 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194456 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194458 SEB22547 SEB22548 SEB22569 SEB22570 SEB22577 SEB01880004
1194487 SEB22547 SEB22548 SEB22571 SEB22550 SEB22588 SEB01879004
1013077000 SEB22537 SEB22538 SEB22535 SEB22536 SEB22579 10300004
1013078000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013080000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013081000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013083000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013084000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013085000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013099000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013278000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013281000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013283000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013284000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013285000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22579 10300004
1013378000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013383000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013387000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013391000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013393000 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
1013395000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013397000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
1013398000 SEB22524 SEB22525 SEB22526 SEB22527 10300004
1013491000 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
I86909 LP4812 SEB22539 SEB22540 SEB22541 SEB22542 SEB00421004 I81015004
I90499 LP4813 SEB22539 SEB22540 SEB22541 SEB22542 SEB00551004 I81015004
I97492 LP4814 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
I97493 LP4815 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
II15697 LP4823 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
II15698 LP4930 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
II15992 LP4934 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
II15993 LP4825 SEB22539 SEB22540 SEB22545 SEB22546 SEB01080004 SEB01081004
II16243 LP4936 SEB22555 SEB22560 SEB22561 SEB01148004 SEB01033004
II17395 LP4957 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
II18214 LP4829 SEB22539 SEB22540 SEB22545 SEB22546 SEB01080004 SEB01081004
II18599 LP4830 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
II19187 LP4948 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
II19191 LP4949 SEB22555 SEB22562 SEB22563 SEB01052004 SEB01033004
II30895 LP4934 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
II30899 LP4960 SEB22555 SEB22560 SEB22561 SEB01445004 SEB01033004
II30900 LP4961 SEB22555 SEB22560 SEB22561 SEB01429004 SEB01033004
II30901 LP4842 SEB22539 SEB22540 SEB22541 SEB22542 SEB01449 I81015004
II31730 LP4955 SEB22555 SEB22560 SEB22561 SEB01429004 SEB01033004
II31955 LP4962 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
II32686 LP4963 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
II32687 LP4964 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
II32688 LP4965 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
II32689 LP4966 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
II32842 LP4844 SEB22539 SEB22540 SEB22541 SEB22542 SEB22587 I81015004
* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

- 19 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 20

3.2 Service Kits for Compressors

( Listed by Compressor Part Number )
Compressor Compressor Piston Piston
Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Part No. Type No. Standard * Oversize*
II33164 LP4967 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
II33514 LP4968 SEB22555 SEB22560 SEB22561 SEB01052004 SEB01033004
II34404 LP4969 SEB22555 SEB22556 SEB22557 SEB01655004 SEB01034004
II34405 LP4970 SEB22555 SEB22556 SEB22557 SEB01655004 SEB01034004
II34840 LP4823 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
II34841 LP4830 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
II35564 LP4850 SEB22539 SEB22540 SEB22543 SEB22544 SEB01515004 SEB01000004
II36423 LK3830 SEB22517 II364230051 SEB22589 Y004640004
II37214 LP4974 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
II37369 LP4977 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
II37435 LP4979 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
II37436 LP4980 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
II37437 LP4981 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
II37953 LP4986 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
II37958 LP4988 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
II38142F LP4989 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
II38145F LP4990 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
II38683F LK3845 SEB22517 SEB22518 SEB01786004 SEB01649004
II38776F LP4991 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
II38777F LP4992 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
II38779F LP4993 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
II38844F LP4995 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
II38845F LP4996 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
II38846F LP4997 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
II39523F LK4927 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K000229 LP4985 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
K000230 LK4918 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K000231 LK4919 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K000232 LK4920 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
K000233 LK4921 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K000234 LK4922 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
K000235 LP4992 SEB22555 SEB22556 SEB22557 SEB01549004 SEB01034004
K000236 LP4974 SEB22555 SEB22560 SEB22561 SEB01138004 SEB01033004
K000237 LP4960 SEB22555 SEB22560 SEB22561 SEB01445004 SEB01033004
K000821 LP4857 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
K000839 LK4935 SEB22547 SEB22550 SEB22588 SEB01879004
K000853 LK3839 SEB22517 SEB22518 SEB01629004 SEB01649004
K000854 LK3859 SEB22517 SEB22518 SEB01760004 SEB01649004
K000855 LP3977 SEB22530 SEB22532 SEB01881004 SEB01694004 SEB01728004
K000861 LK3846 SEB22517 SEB22518 SEB01629004 SEB01649004
K001095 LP4858 SEB22547 SEB22548 SEB22569 SEB22570 SEB22576 SEB01880004
K001126 LK4936 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01878004
K001127 LK4937 SEB22547 SEB22548 SEB22571 SEB22550 SEB22578 SEB01879004
K001207 LK4935 SEB22547 SEB22548 SEB22549 SEB22550 SEB01873004 SEB01878004
K001267 LK4918 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K001268 LK4921 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K001728 LK3867 SEB22517 SEB22518 SEB01760004 SEB01649004
K001935 LK4938 SEB01889004 SEB22560 SEB22561 SEB01888004 SEB01033004
K002029 LK4919 SEB22555 SEB22556 SEB22557 SEB01551004 SEB01034004
K002030 LK4922 SEB22555 SEB22558 SEB22559 SEB01551004 SEB01034004
K002045 LP4957 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
K002046 LP4964 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
K002047 LP4965 SEB22555 SEB22560 SEB22561 SEB01444004 SEB01033004
K002072 LK4941 SEB22555 SEB22560 SEB22561 SEB01895004 SEB01033004
K002120 LK4952 SEB22547 SEB22548 SEB22571 SEB22550 SEB22588 SEB01879004
K002123 LK4935 SEB22547 SEB22548 SEB22549 SEB22550 SEB01873004 SEB01878004
K002140 LP4857 SEB22547 SEB22548 SEB22549 SEB22550 SEB01851004 SEB01877004
K002580 LK3976 SEB22530 SEB22532 SEB01891004 SEB01898004
K002975 LP4957 SEB22555 SEB22560 SEB22561 SEB01106004 SEB01033004
SEB00348 LP3832 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB00354 LP3833 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB00356 LP3843 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB00416 LP1596 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB00564 LP1598 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB00650 LP3852 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB00688 LP1599 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB00796 LP3857 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB00820 LP4818 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
SEB00836 LP4819 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01149 LK1554 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB01150 LK1555 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB01151 LP3860 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB01152 LP3861 SEB22520 SEB22521 SEB22522 SEB22523 I74405004 SEB00465004
SEB01154 LP4939 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
SEB01155 LP4940 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
SEB01156 LP4941 SEB22528 SEB22529 SEB22526 SEB22527 SEB22580 10300004
* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

KNORR-BREMSE
Systems for Commercial Vehicles
- 20 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 21

3.2 Service Kits for Compressors

( Listed by Compressor Part Number )
Compressor Compressor Piston Piston
Assembly Assembly Complete Kit Gasket Kit Cylinder Head Valve Plate Cooling Plate
Part No. Type No. Standard * Oversize*
SEB01157 LP4942 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
SEB01158 LP4943 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
SEB01159 LP4944 SEB22533 SEB22534 SEB22535 SEB22536 SEB22591 10300004
SEB01160 LP4945 SEB22524 SEB22525 SEB22526 SEB22527 SEB22591 10300004
SEB01161 LP4827 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01185 LP4828 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01245 LP4832 SEB22537 SEB22538 SEB22535 SEB22536 SEB22580 10300004
SEB01246 LP4831 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01250 LP4833 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01297 LP4838 SEB22551 SEB22552 SEB22553 SEB22554 Obsolete SEB01495004
SEB01392 LP4840 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01430 LP4843 SEB22551 SEB22552 SEB22553 SEB22554 SEB22584 SEB01511004
SEB01441 LP4819 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01511004
SEB01452 LP4827 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01455 LP4845 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
SEB01463 LP4828 SEB22551 SEB22552 SEB22553 SEB22554 SEB22586 SEB01495004
SEB01472 LP4840 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
SEB01474 LP4831 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01478 LP4846 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01479 LP4848 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01480 LP4849 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01485 LP4833 SEB22551 SEB22552 SEB22553 SEB22554 SEB22582 SEB01495004
SEB01496 LP4838 SEB22551 SEB22552 SEB22553 SEB22554 Obsolete SEB01495004
SEB01527 LP4846 SEB22551 SEB22552 SEB22553 SEB22554 SEB22585 SEB01511004
SEB01545 LP4851 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
SEB01580 LK3994 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004
SEB01586 LK3833 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01588 LP4852 SEB22539 SEB22540 SEB22541 SEB22542 SEB22592 I81015004
SEB01597 LK3834 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
SEB01599 LK3835 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
SEB01601 LK3836 SEB22517 SEB22518 SEB01760004 SEB01649004
SEB01602 LK3837 SEB22517 SEB22518 SEB01760004 SEB01649004
SEB01603 LK3838 SEB22517 SEB22518 SEB01760004 SEB01649004
SEB01604 LK3839 SEB22517 SEB22518 SEB01629004 SEB01649004
SEB01605 LK3840 SEB22517 SEB22518 SEB01682004 SEB01649004
SEB01606 LK3841 SEB22517 SEB22518 SEB01745004 SEB01649004
SEB01618 LK3843 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01619 LP4853 SEB22551 SEB22552 SEB22553 SEB22554 SEB22583 SEB01511004
SEB01674 LP4998 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
SEB01676 LP4999 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
SEB01677 LP4999 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
SEB01678 LP4999 SEB22555 SEB22560 SEB22561 SEB01552004 SEB01033004
SEB01686 LK1567 SEB22514 SEB22515 SEB22516 II38602F004 SEB00460004
SEB01689 LK3840 SEB22517 SEB22518 SEB01682004 SEB01649004
SEB01690 LK3847 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01718 LK3847 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01719 LK3847 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01725 LP4977 SEB22555 SEB22560 SEB22561 SEB01566004 SEB01033004
SEB01747 LP4855 SEB22551 SEB22552 SEB22553 SEB22554 SEB22584 SEB01511004
SEB01751 LP3970 SEB22530 SEB22593 SEB22479 SEB01750004 SEB22575
SEB01759 LK3853 SEB22517 SEB22519 SEB22518 SEB01592004 SEB01593004
SEB01768 LK3850 SEB22517 SEB22518 SEB01820004 SEB01649004
SEB01777 LK3852 SEB22517 SEB22518 SEB01760004 SEB01649004
SEB01781 LP4830 SEB22539 SEB22540 SEB22543 SEB22544 SEB01261004 SEB01000004
SEB01782 LP4823 SEB22539 SEB22540 SEB22543 SEB22544 SEB01093004 SEB01000004
SEB01783 LP4984 SEB22555 SEB22556 SEB22557 SEB01583004 SEB01034004
SEB01784 LP4983 SEB22555 SEB22556 SEB22557 SEB01583004 SEB01034004
SEB01791 LP3974 SEB22530 SEB015800052 SEB01894004 Y004552004
SEB01795 LP3977 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004
SEB01805 LK3855 SEB22517 SEB22518 SEB01745004 SEB01649004
SEB01813 LK3857 SEB22517 SEB22519 SEB22518 SEB01814004 SEB01593004
SEB01816 LK3854 SEB22517 SEB22519 SEB22518 SEB01763004 SEB01593004
SEB01817 LK3846 SEB22517 SEB22518 SEB01629004 SEB01649004
SEB01819 LK3840 SEB22517 SEB22518 SEB01682004 SEB01649004
SEB01841 LK3859 SEB22517 SEB22518 SEB01760004 SEB01649004
SEB01842 LK3994 SEB22530 SEB22532 SEB01697004 SEB01694004 SEB01728004

* Kits for 2 Cylinder Compressors contain 2 Piston Assemblies.

- 21 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 22

KNORR-BREMSE
Systems for Commercial Vehicles
- 22 -
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 23

4. Service Kit Contents

- 23 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 24

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK1554-SEB01149
SEB22514 Piston Assembly - Standard Piston 75mm
LK1555-SEB01150
LK1567-SEB01686
LP1596-SEB00416
LP1598-SEB00564
LP1599-SEB00688

LK1554-SEB01149
SEB22515 Piston Assembly - Oversize Piston 75.5mm
LK1555-SEB01150
LK1567-SEB01686
LP1596-SEB00416
LP1598-SEB00564
LP1599-SEB00688

KNORR-BREMSE - 24 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 25

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK1554-SEB01149
SEB22516 Gasket Kit
LK1555-SEB01150
LK1567-SEB01686
LP1596-SEB00416
LP1598-SEB00564
LP1599-SEB00688

LK3833-SEB01586 LK3859-SEB01841
SEB22517 Piston Assembly- Standard Piston 80mm
LK3834 SEB01597 LK3867-K001728
LK3835-SEB01599
LK3836-SEB01601
LK3837-SEB01602
LK3838-SEB01603
LK3839-K000853
LK3839-SEB0604
LK3840-SEB01605
LK3840-SEB01819
LK3841-SEB01606
LK3843-SEB01618
LK3845-II38683F
LK3846-K000861
LK3846-SEB01817
LK3847-SEB01690
LK3847-SEB0171
LK3847-SEB01719
LK3850-SEB0176
LK3852-SEB01777
LK3853-SEB0175
LK3854-SEB01816
LK3855-SEB01805
LK3857-SEB01813
LK3959-K000854

- 25 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 26

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK3833-SEB01586 LK3859-SEB01841
SEB22518 Gasket Kit
LK3834-SEB01597 LK3867-K001728
LK3835-SEB01599
LK3836-SEB01601
LK3837-SEB01602
LK3838-SEB01603
LK3839-K000853
LK3839-SEB0604
LK3840-SEB01605
LK3840-SEB01819
LK3841-SEB01606
LK3843-SEB01618
LK3845-II38683F
LK3846-K000861
LK3846-SEB01817
LK3847-SEB01690
LK3847-SEB01718
LK3847-SEB0171
LK3850-SEB01768
LK3852-SEB01777
LK3853-SEB01759
LK3854-SEB01816
LK3855-SEB01805
LK3857-SEB01813
LK3959-K000854

LK3833-SEB01586
SEB22519 Complete Kit
LK3834-SEB01597
LK3835-SEB01599
LK3843-SEB01618
LK3847-SEB01690
LK3847-SEB01718
LK3847-SEB01719
LK3853-SEB01759
LK3854-SEB01816
LK3857-SEB01813

KNORR-BREMSE - 26 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 27

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP3832-SEB00348
SEB22520 Piston Assembly - Standard Piston 78mm
LP3833-SEB00354
LP3843-SEB00356
LP3852-SEB00650
LP3857-SEB00796
LP3860-SEB01151
LP3861-SEB01152

LP3832-SEB00348
SEB22521 Piston Assembly - Oversize Piston 78.5mm
LP3833-SEB00354
LP3843-SEB00356
LP3852-SEB00650
LP3857-SEB00796
LP3860-SEB01151
LP3861-SEB01152

- 27 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 28

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP3832 - SEB00348
SEB22522 Complete Kit
LP3833 - SEB00354
LP3843 - SEB00356
LP3852 - SEB00650
LP3857 - SEB00796
LP3860 - SEB01151
LP3861 - SEB01152

LP3832 - SEB00348
SEB22523 Gasket Kit
LP3833 - SEB00354
LP3843 - SEB00356
LP3852 - SEB00650
LP3857 - SEB00796
LP3860 - SEB01151
LP3861 - SEB01152

KNORR-BREMSE - 28 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 29

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1013078000
SEB22524 Piston Assembly - Standard Piston 65mm
1013080000
1013081000
1013083000
1013084000
1013085000
1013099000
1013278000
1013281000
1013283000
1013284000
1013285000
1013378000
1013383000
1013387000
1013393000
1013398000
LP4939-SEB01154
LP4943-SEB01158
LP4945-SEB01160

1013078000
SEB22525 Piston Assembly - Oversize Piston 65.5mm
1013080000
1013081000
1013083000
1013084000
1013085000
1013099000
1013278000
1013281000
1013283000
1013284000
1013285000
1013378000
1013383000
1013387000
1013393000
1013398000
LP4939-SEB01154
LP4943-SEB01158
LP4945-SEB01160

- 29 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 30

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1013078000
SEB22526 Complete Kit
1013080000
1013081000
1013083000
1013084000
1013085000
1013099000
1013278000
1013281000
1013283000
1013284000
1013285000
1013378000
1013383000
1013387000
1013393000
1013398000
LP4939-SEB01154
LP4941-SEB01156
LP4943-SEB01158
LP4945-SEB01160

1013078000
SEB22527 Gasket Kit
1013080000
1013081000
1013083000
1013084000
1013085000
1013099000
1013278000
1013281000
1013283000
1013284000
1013285000
1013378000
1013383000
1013387000
1013393000
1013398000
LP4939-SEB01154
LP4941-SEB01156
LP4943-SEB01158
LP4945-SEB01160

KNORR-BREMSE - 30 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 31

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4941-SEB01156
SEB22528 Piston Assembly - Standard Piston 65mm

LP4941-SEB01156
SEB22529 Piston Assembly - Oversize Piston 65.5mm

- 31 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 32

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK3994-SEB01580
SEB22530 Piston Assembly - Standard Piston 92mm
LK3994-SEB01842
LP3977-SEB01795
LP3977-K000855
LP3970-SEB01751

LK3994-SEB01580
SEB22532 Complete Kit
LK3994-SEB01842
LP3977-SEB01795
LP3977-K000855

KNORR-BREMSE - 32 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 33

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1013391000
SEB22533 Piston Assembly - Standard Piston 70mm
1013395000
1013397000
1013491000
LP4818-SEB00820
LP4940-SEB01155
LP4942-SEB01157
LP4944-SEB01159

1013391000
SEB22534 Piston Assembly - Oversize Piston 70.5mm
1013395000
1013397000
1013491000
LP4818-SEB00820
LP4940-SEB01155
LP4942-SEB01157
LP4944-SEB01159

- 33 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:33 Seite 34

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1013077000
SEB22535 Complete Kit
1013391000
1013395000
1013397000
1013491000
LP4818 - SEB00820
LP4832 - SEB01245
LP4940 - SEB01155
LP4942 - SEB01157
LP4944 - SEB01159

1013077000
SEB22536 Gasket Kit
1013391000
1013395000
1013397000
1013491000
LP4818 - SEB00820
LP4832 - SEB01245
LP4940 - SEB01155
LP4942 - SEB01157
LP4944 - SEB01159

KNORR-BREMSE - 34 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 35

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1013377000
SEB22537 Piston Assembly - Standard Piston 70mm
LP4832-SEB01245

1013377000
SEB22538 Piston Assembly - Oversize Piston 70.5mm
LP4832-SEB01245

- 35 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 36

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4812-I86909
SEB22539 Piston Assembly - Standard Piston 75mm
LP4813-I90499
LP4814-I97492
LP4815-I97493
LP4823-II15697
LP4823-II34840
LP4823-SEB01782
LP4825-II15993
LP4829-II18214
LP4830-II18599
LP4830-II34841
LP4830-SEB01781
LP4842-II30901
LP4844-II32842
LP4850-II35564
LP4852-SEB01588

LP4812-I86909
SEB22540 Piston Assembly - Oversize Piston 75.5mm
LP4813-I90499
LP4814-I97492
LP4815-I97493
LP4823-II15697
LP4823-II34840
LP4823-SEB01782
LP4825-II15993
LP4829-II18214
LP4830-II18599
LP4830-II34841
LP4830-SEB01781
LP4842-II30901
LP4844-II32842
LP4850-II35564
LP4852-SEB01588

KNORR-BREMSE - 36 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 37

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4812-I86909
SEB22541 Complete Kit
LP4813-I90499
LP4814-I97492
LP4815-I97493
LP4842-II30901
LP4844-II32842
LP4852-SEB01588

LP4812-I86909
SEB22542 Gasket Kit
LP4813-I90499
LP4814-I97492
LP4815-I97493
LP4842-II30901
LP4844-II32842
LP4852-SEB01588

- 37 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 38

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4823-II15697
SEB22543 Complete Kit
LP4823-II34840
LP4823-SEB01782
LP4830-II18599
LP4830-II34841
LP4830-SEB01781
LP4850-II35564

LP4823-II15697
SEB22544 Gasket Kit
LP4823-II34840
LP4823-SEB01782
LP4830-II18599
LP4830-II34841
LP4830-SEB01781
LP4850-II35564

KNORR-BREMSE - 38 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 39

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4825 - II15993
SEB22545 Complete Kit
LP4829 - II18214

LP4825 - II15993
SEB22546 Gasket Kit
LP4829 - II18214

- 39 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 40

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4857-K000821
SEB22547 Piston Assembly - Standard Piston 86mm

LP4857-K000821
SEB22548 Piston Assembly - Oversize Piston 86.5mm

KNORR-BREMSE - 40 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 41

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1194410
SEB22549 Complete Kit
1194415
LP4857-K000821
LP4857-K002140
LK4936-K001126
LK4935-K001207
LK4935-K002123

1194410
SEB22550 Gasket Kit
1194415
1194421
1194487
LK4857-K000821
LP4857-K002140
LK4936-K001126
LK4935-K001207
LK4935-K002123
LK4937-K001127
LK4952-K002120

- 41 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 42

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4819-SEB00836
SEB22551 Piston Assembly - Standard Piston 78mm
LP4819-SEB01441
LP4827-SEB01161
LP4827-SEB01452
LP4828-SEB01185
LP4828-SEB01463
LP4831-SEB01246
LP4831-SEB01474
LP4833-SEB01250
LP4833-SEB01485
LP4838-SEB01297
LP4838-SEB01496
LP4840-SEB01392
LP4840-SEB01472
LP4843-SEB01430
LP4845-SEB01455
LP4846-SEB01478
LP4846-SEB01527
LP4848-SEB01479
LP4849-SEB01480
LP4851-SEB01545
LP4853-SEB01619
LP4855-SEB01747

LP4819-SEB00836
SEB22552 Piston Assembly - Oversize Piston 78.5mm
LP4819-SEB01441
LP4827-SEB01161
LP4827-SEB01452
LP4828-SEB01185
LP4828-SEB01463
LP4831-SEB01246
LP4831-SEB01474
LP4833-SEB01250
LP4833-SEB01485
LP4838-SEB01297
LP4838-SEB01496
LP4840-SEB01392
LP4840-SEB01472
LP4843-SEB01430
LP4845-SEB01455
LP4846-SEB01478
LP4846-SEB01527
LP4848-SEB01479
LP4849-SEB01480
LP4851-SEB01545
LP4853-SEB01619
LP4855-SEB01747

KNORR-BREMSE - 42 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 43

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4819-SEB00836
SEB22553 Complete Kit
LP4819-SEB01441
LP4827-SEB01161
LP4827-SEB01452
LP4828-SEB01185
LP4828-SEB01463
LP4831-SEB01246
LP4831-SEB01474
LP4833-SEB01250
LP4833-SEB01485
LP4838-SEB01297
LP4838-SEB01496
LP4840-SEB01392
LP4840-SEB01472
LP4843-SEB01430
LP4845-SEB01455
LP4846-SEB01478
LP4846-SEB01527
LP4848-SEB01479
LP4849-SEB01480
LP4851-SEB01545
LP4853-SEB01619

LP4819-SEB00836
SEB22554 Gasket Kit
LP4819-SEB01441
LP4827-SEB01161
LP4827-SEB01452
LP4828-SEB01185
LP4828-SEB01463
LP4831-SEB01246
LP4831-SEB01474
LP4833-SEB01250
LP4833-SEB01485
LP4838-SEB01297
LP4838-SEB01496
LP4840-SEB01392
LP4840-SEB01472
LP4843-SEB01430
LP4845-SEB01455
LP4846-SEB01478
LP4846-SEB01527
LP4848-SEB01479
LP4849-SEB01480
LP4851-SEB01545
LP4853-SEB01619

- 43 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 44

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK4918-K001267 LP4970-II34405
SEB22555 Piston Assembly - Standard Piston 88mm
LK4919-K000231 LP4974-II37214
LK4920-K000232 LP4974-K000236
LK4921-K000233 LP4977-II37369
LK4921-K001268 LP4977-SEB01725
LK4922-K000234 LP4980-II47436
LK4927-II39253F LP4981-II37437
LP4930-II15698 LP4983-SEB01784
LP4934-II15992 LP4984-SEB01783
LP4934-II30895 LP4985-K000229
LP4936-II16243 LP4986-II37953
LP4948-II19187 LP4988-II37958
LP4949-II19191 LP4989-II37142F
LP4955-II31730 LP4990-II38145F
LP4957-II17395 LP4991-II38776F
LP4960-II30899 LP4992-II38777F
LP4960-K000237 LP4992-K000235
LP4961-II30900 LP4993-II38779F
LP4962-II31955 LP4995-II38844F
LP4963-II32686 LP4996-II38845F
LP4964-II32687 LP4997-II38846F
LP4965-II32688 LP4998-SEB01674
LP4966-II32689 LP4999-SEB01676
LP4967-II33164 LP4999-SEB01677
LP4968-II33514 LP4999-SEB01678
LP4969-II34404

LK4918-K000230
SEB22556 Complete Kit
LK4918-K001267
LK4919-K000231
LK4920-K000232
LK4921-K000233
LK4921-K001268
LK4927-II39253F
LP4969-II34404
LP4970-II34405
LP4983-SEB01784
LP4984-SEB01783
LP4985-K000229
LP4986-II37953
LP4988-II37958
LP4989-II37142F
LP4991-II38776F
LP4992-II38777F
LP4992-K000235
LP4993-II38779F
LP4995-II38844F
LP4996-II38845F

KNORR-BREMSE - 44 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 45

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK4918-K000230
SEB22557 Gasket Kit
LK4918-K001267
LK4919-K000231
LK4920-K000232
LK4921-K000233
LK4921-K001268
LK4927-II39253F
LP4969-II34404
LP4970-II34405
LP4983-SEB01784
LP4984-SEB01783
LP4985-K000229
LP4986-II37953
LP4988-II37958
LP4989-II37142F
LP4991-II38776F
LP4992-II38777F
LP4992-K000235
LP4993-II38779F
LP4995-II38844F
LP4996-II38845F

LK4922-K000234
SEB22558 Complete Kit
LP4990-II38145F
LP4997-II38846F

- 45 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 46

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LK4922-K000234
SEB22559 Gasket Kit
LP4990-II38145F
LP4997-II38846F

LP4930-II15698 LP4999-SEB01676
SEB22560 Complete Kit
LP4934-II15992 LP4999-SEB01677
LP4934-II30895 LP4999-SEB01678
LP4936-II16243
LP4948-II19187
LP4955-II31730
LP4957-II17395
LP4960-II30899
LP4960-K000237
LP4961-II30900
LP4962-II31955
LP4963-II32686
LP4964-II32687
LP4965-II32688
LP4966-II32689
LP4967-II33164
LP4968-II33514
LP4974-II37214
LP4974-K000236
LP4977-II37369
LP4977-SEB01725
LP4979-II19191
LP4980-II47436
LP4981-II37437
LP4998-SEB01674

KNORR-BREMSE - 46 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 47

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP49LP30-II15698 LP4999-SEB01676
SEB22561 Gasket Kit
LP4934-II15992 LP4999-SEB01677
LP4934-II30895 LP4999-SEB01678
LP4936-II16243
LP4948-II19187
LP4955-II31730
LP4957-II17395
LP4960-II30899
LP4960-K000237
LP4961-II30900
LP4962-II31955
LP4963-II32686
LP4964-II32687
LP4965-II32688
LP4966-II32689
LP4967-II33164
LP4968-II33514
LP4974-II37214
LP4974-K000236
LP4977-II37369
LP4977-SEB01725
LP4979-II19191
LP4980-II47436
LP4981-II37437
LP4998-SEB01674

LP4949-II19191
SEB22562 Complete Kit

- 47 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 48

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP4949-II19191
SEB22563 Gasket Kit

1194233
SEB22569 Complete Kit
1194275
1194357
1194425
1194430
1194454
1194455
1194456
1194458
LP4858-K001095

KNORR-BREMSE - 48 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 49

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

1194233
SEB22570 Gasket Kit
1194275
1194357
1194425
1194430
1194454
1194455
1194456
1194458
LP4858-K001095

1194421
SEB22571 Complete Kit
1194487
LK4937-K001127
LK4952-K002120

- 49 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 50

4. Service Kit Contents

Part No. Service Kit Suitable for Compressors:

LP3970-SEB01751
SEB22593 Complete Kit

KNORR-BREMSE - 50 -
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 51

Notes

- 51 - KNORR-BREMSE
Systems for Commercial Vehicles
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22

Y018787-EN.qxp 09.09.2004 11:34 Seite 52

The figurative mark K and the trademarks KNORR, KNORR-BREMSE are registered in the name of Knorr-Bremse AG.
Subject to alteration without notice. For specific application requirements and details on the use of our products we recommend that you request individual consultation and documentation. Reproduction, even extracts, is not permitted. Printed in Germany
Knorr-Bremse
Systeme fr Nutzfahrzeuge GmbH
Moosacher Strae 80
80809 Munich
Germany
Tel: +49 89 3547-0
Fax: +49 89 3547-2767

Knorr-Bremse Knorr-Bremse Knorr-Bremse

Australia Pty. Ltd. Systmes pour Vhicules Utilitaires France S.A. Systeme fr Nutzfahrzeuge GmbH
1/2D Factory Street BP 34178 Representation Office Russia
PO Box 180 RN 13, La Briqueterie 1 . Kasatschij Pereulok 5/2
Granville NSW 2142 Glos 119017 Moscow
Australia 14104 Lisieux Cedex Russian Federation
Tel: +61 1300 309-991 France Tel: +7 095 234-4995
Fax: +61 2 8863-6151 Tel: +33 2 3132-1200 Fax: +7 095 234-4996
Fax: +33 2 3132-1303
Knorr-Bremse GmbH Knorr-Bremse S.A. Pty. Ltd.
Systeme fr Nutzfahrzeuge Hasse & Wrede GmbH 3 Derrick Road
Beethovengasse 43-45 Georg-Knorr-Strae 4 (corner Chestnut Road)
2340 Mdling 12681 Berlin 1610 Kempton Park
Austria Germany South Africa
Tel: +43 2236 409-436 Tel: +49 30 9392-3101 Tel: +27 11 961-7800
Fax: +43 2236 409-434 Fax: +49 30 7009-0811 Fax: +27 11 975-8249
Knorr-Bremse Knorr-Bremse Bost Ibrica, S.L.
Benelux B.V.B.A. Fkrendszerek Kft. Avda. Letxunborro 58
Impulsstraat 11 Kecskemt Apdo. 363
Industriepark zone D Szegedi t 49 20303 Irun
2220 Heist-op-den-Berg 6000 Spain
Belgium Hungary Tel: +34 902 100 569
Tel: +32 1525-7900 Tel: +36 76 511-100 Fax: +34 943 614 063
Fax: +32 1524-9240 Fax: +36 76 481-100
Knorr-Bremse
Knorr-Bremse Knorr-Bremse System for Tunga Fordon AB
Sistemas para Veculos Comerciais Brasil Ltda. Systems for Commercial Vehicles India Private Ltd. P.O. Box 6029
Av. Engenheiro Eusbio Stevaux, 873 62 Buena Monte 200 11 Malmoe
Jurubatuba Survey No 37/3 Sweden
So Paulo - SP Pashan Tel: +46 40 680 5880
Cep: 04696-902 Pune 411 008 Fax: +46 40 937490
Brazil India
Tel: +55 11 5681-1104 Tel: +91 20 5621 4483-87 Knorr-Bremse
Fax: +55 11 5686-3905 Fax: +91 20 2589 8200 Systeme fr Nutzfahrzeuge GmbH
Office Switzerland
Knorr-Bremse Far East Ltd. Knorr-Bremse Zrichstrasse 46
Truck Brake Systems Division Sistemi per Autoveicoli Commerciali S.p.A. 8303 Bassersdorf
Suite 2901, 29/F., Central Plaza Via C. Battisti, 68 Switzerland
18 Harbour Road 20043 Arcore Tel: +41 1 888 77-55
Wanchai Italy Fax: +41 1 888 77-50
Hong Kong Tel: +39 039 6075-1
China Fax: +39 039 6075-435 Knorr-Bremse
Tel: +852 2861 2669 Systeme fr Nutzfahrzeuge GmbH
Fax: +852 2520 6259 Knorr-Bremse Liaison Office Istanbul
Commercial Vehicle Systems Japan Ltd. Meclisi Mebusan Cad. 139/A
Knorr-Bremse Brake Equipment (Shanghai) Co. Ltd. 3-1-15, Nishiikebukuro Atlantik Han Kat: 3
Truck Brake Systems Division Toshima-ku 80040 Findikli-Istanbul
Section A, Building 31 Tokyo 171 0021 Turkey
390 Aidu Road Japan Tel: +90 212 293-4742
Waigaoqiao Free Trade Zone Tel: +81 3 3971-8501 Fax: +90 212 293-4743
Shanghai, 200131 Fax: +81 3 3971-8579
China Knorr-Bremse
Tel: +86 21 5046-0776 Knorr-Bremse Korea Ltd. Systems for Commercial Vehicles Ltd.
Fax: +86 21 5046-3427 Truck Brake Division Century House, Folly Brook Road
6 FL, Bongwoo B/D, 31-7, 1-Ga Emerald Park, Emersons Green
Knorr-Bremse Jangchung-Dong, Jung-Gu Bristol
Systmy pro uzitkov vozidla, CR, s.r.o. Seoul 100-391 BS16 7FE
Petra Bezruce 399 Korea United Kingdom
463 62 Hejnice Tel: +82 2 2273-1182 Tel: +44 117 9846-100
Czech Republic Fax: +82 2 2273-1184 Fax: +44 117 9846-101
Tel: +420 482 363-611
Fax: +420 482 363-711 Knorr-Bremse Bendix Commercial Vehicle Systems LLC
Benelux B.V.B.A. 901 Cleveland Street
Rendementsweg 4N Elyria, OH 44035
3641 SK Mydrecht USA
Netherlands Tel: +1 440 329-9000
Tel: +31 297 239-330 Fax: +1 440 329-9203
Fax: +31 297 239-339

KNORR-BREMSE
Y018787-EN 08.2004

Systeme fr Nutzfahrzeuge
www.knorr-bremse.com www.knorr-bremsesfn.com

Y018787: EN: 000: MAX1: Released:Webmaster: 2008/02/27-19:27:22