Product ID : 072671972
Individual product safety information captured in this document
SDS
Hardening Bath 1719-2000
These SDS pertain to other individual products
These SDS may supersede those previously received depending on the date
of manufacture.
SDS Product
N/A
These SDS pertain to individual products contained in other kits (a.k.a. product groups, packages)
These SDS may supersede those previously received depending on the date
of manufacture.
SDS Product
N/A
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 1 of 7
SECTION 1: Identification of the substance/mixture and of the company/undertaking
Product identifier
Hardening Bath 1719-2000
Relevant identified uses of the substance or mixture and uses advised against
Use of the substance/mixture
Self-hardening plastic solution for plaster models, dies etc.
Details of the supplier of the safety data sheet
Company name: Renfert GmbH
Street: Untere Giesswiesen 2
Place: D-78247 Hilzingen
Telephone: +49 7731 8208-0 Telefax: +49 7731 8208-70
e-mail: info@renfert.com
Contact person: Frau Andris Telephone: +49 7731 8208-927
Internet: www.renfert.com
Emergency telephone: Vergiftungs-Zentrale Freiburg
+49 761 19 240
SECTION 2: Hazards identification
Classification of the substance or mixture
Indications of danger : Highly flammable, Irritant
R-phrases:
Highly flammable.
Irritating to eyes.
Repeated exposure may cause skin dryness or cracking.
Vapours may cause drowsiness and dizziness.
Label elements
Danger symbols: F - Highly flammable; Xi - Irritant
F - Highly flammable Xi - Irritant
R phrases
11 Highly flammable.
36 Irritating to eyes.
66 Repeated exposure may cause skin dryness or cracking.
67 Vapours may cause drowsiness and dizziness.
S phrases
07/09 Keep container tightly closed and in a well-ventilated place.
16 Keep away from sources of ignition - No smoking.
24 Avoid contact with skin.
26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
51 Use only in well-ventilated areas.
Additional advice on labelling
The R and S phrases can be omitted if the pack contains no more than 0,125 litres.
SECTION 3: Composition/information on ingredients
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 2 of 7
Mixtures
Chemical characterization
Surface hardener (resin solution)
Hazardous components
EC No Chemical name Quantity
CAS No Classification
Index No GHS classification
REACH No
200-662-2 acetone; propan-2-one; propanone > 70 %
67-64-1 F, Xi R11-36-66-67
606-001-00-8 Flam. Liq. 2, Eye Irrit. 2, STOT SE 3; H225 H319 H336
Full text of R- and H-phrases: see section 16.
SECTION 4: First aid measures
Description of first aid measures
General information
Change contaminated clothing.
After inhalation
Provide fresh air.
After contact with skin
After contact with skin, wash immediately with plenty of water and soap. In case of skin irritation, seek
medical treatment.
After contact with eyes
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
After ingestion
Rinse mouth immediately and drink large quantities of water. Do not induce vomiting. Immediately get
medical attention.
Most important symptoms and effects, both acute and delayed
Following symptoms can occur:
Vapours may cause drowsiness and dizziness. Process vapours can irritate airways, skin and eyes.
Repeated exposure may cause skin dryness or cracking.
Indication of any immediate medical attention and special treatment needed
Treat symptomatically.
SECTION 5: Firefighting measures
Extinguishing media
Suitable extinguishing media
Extinguishing powder. Carbon dioxide (CO2). alcohol resistant foam. Water spray.
Extinguishing media which must not be used for safety reasons
High power water jet.
Special hazards arising from the substance or mixture
Vapours may form explosive mixtures with air.
Advice for firefighters
In case of fire and/or explosion do not breathe fumes.
In case of fire: Wear self-contained breathing apparatus.
SECTION 6: Accidental release measures
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 3 of 7
Personal precautions, protective equipment and emergency procedures
Provide adequate ventilation.
Wear personal protection equipment.
Remove all sources of ignition.
Environmental precautions
Do not empty into drains or the aquatic environment.
Methods and material for containment and cleaning up
Absorb with liquid-binding material (e.g. sand, diatomaceous earth, acid- or universal binding agents).
Collect in closed containers for disposal.
Reference to other sections
See protective measures under point 7 and 8.
SECTION 7: Handling and storage
Precautions for safe handling
Advice on safe handling
Use only in well-ventilated areas.
Avoid contact with skin and eyes.
Advice on protection against fire and explosion
Vapours may form explosive mixtures with air. Keep away from sources of ignition - No smoking.
Further information on handling
In case of open handling, use devices with built-in suction where possible.
Conditions for safe storage, including any incompatibilities
Requirements for storage rooms and vessels
Keep container tightly closed in a cool, well-ventilated place.
SECTION 8: Exposure controls/personal protection
Control parameters
Exposure limits (EH40)
CAS No Chemical name ml/m mg/m F/ml Category Origin
67-64-1 Acetone 500 1210 TWA (8 h) WEL
1500 3620 STEL (15 min) WEL
Exposure controls
Occupational exposure controls
refer to chapter 7. No further action is necessary.
Protective and hygiene measures
Do not breathe vapour.
Avoid contact with skin, eye and clothing.
Wash hands before breaks and at the end of work.
Respiratory protection
Respiratory protection required in case of: insufficient ventilation.
Hand protection
Tested protective gloves are to be worn: Suitable material: Butyl rubber.
In the cases of special applications, it is recommended to check the chemical resistance with the
manufacturer of the gloves.
Eye protection
Tightly sealed safety glasses.
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 4 of 7
Environmental exposure controls
Do not empty into drains or the aquatic environment.
SECTION 9: Physical and chemical properties
Information on basic physical and chemical properties
Physical state: liquid
Colour: colourless
Odour: characteristic
Test method
pH-Value: not applicable
Changes in the physical state
Boiling point: 54 C
Flash point: - 16 C DIN 51755 (cc)
Explosive properties
not explosive.
Vapours may form explosive mixtures with air.
Lower explosion limits: 2,1 * vol. %
Upper explosion limits: 13,0 * vol. %
Density (at 20 C): 0,84 - 0,86 g/cm
Water solubility: miscible.
Viscosity / dynamic: product has not been tested.
Other information
* Data apply to the principal component.
SECTION 10: Stability and reactivity
Reactivity
Vapours may form explosive mixtures with air.
Chemical stability
See chapter 7. No further action is necessary.
Possibility of hazardous reactions
Vapours may form explosive mixtures with air.
Conditions to avoid
Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
Incompatible materials
Reacts with : Oxidizing agents, strong.
Hazardous decomposition products
Thermal decomposition can lead to the escape of irritating gases and vapors.
SECTION 11: Toxicological information
Information on toxicological effects
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 5 of 7
Acute toxicity
CAS No Chemical name
Exposure routes Method Dose Species Source
67-64-1 acetone; propan-2-one; propanone
oral LD50 5800 mg/kg Rat RTECS
dermal LD50 20000 Rabbit IUCLID
mg/kg
inhalative (4 h) LC50 76 mg/l Rat
Irritation and corrosivity
Irritant effect on the skin: Not an irritant.
Irritant effect on the eye: irritant.
Sensitising effects
no danger of sensitization.
Empirical data on effects on humans
Repeated exposure may cause skin dryness or cracking.
Vapours may cause drowsiness and dizziness.
Has de-greasing effect on the skin.
Further information
product has not been tested. The statement is derived form the properties of the components.
SECTION 12: Ecological information
Toxicity
CAS No Chemical name
Aquatic toxicity Method Dose h Species Source
67-64-1 acetone; propan-2-one; propanone
Acute fish toxicity LC50 5540 mg/l 96 Onchorhynchus mykiss
Acute crustacea toxicity EC50 6100 mg/l 48 Daphnia magna
Persistence and degradability
There are no data available on the mixture itself.
Bioaccumulative potential
Partition coefficient n-octanol/water
CAS No Chemical name Log Pow
67-64-1 acetone; propan-2-one; propanone -0,24
Mobility in soil
There are no data available on the mixture itself.
Results of PBT and vPvB assessment
The components in this formulation do not meet the criteria for classification as PBT or vPvB.
Further information
product has not been tested. The statement is derived form the properties of the components.
Do not allow uncontrolled leakage of product into the environment.
SECTION 13: Disposal considerations
Waste treatment methods
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 6 of 7
Advice on disposal
Carry out a burning of harzardous waste according to official regulations.
Waste disposal number of waste from residues/unused products
080111 WASTES FROM THE MANUFACTURE, FORMULATION, SUPPLY AND USE (MFSU) OF COATINGS
(PAINTS, VARNISHES AND VITREOUS ENAMELS), ADHESIVES, SEALANTS AND PRINTING INKS;
wastes from MFSU and removal of paint and varnish; waste paint and varnish containing organic
solvents or other dangerous substances
Classified as hazardous waste.
Contaminated packaging
Handle contaminated packaging in the same way as the substance itself.
SECTION 14: Transport information
Land transport (ADR/RID)
UN number: 1866
UN proper shipping name: HARZLSUNG, entzndbar
Transport hazard class(es): 3
Packing group: II
Marine transport
UN number: 1866
UN proper shipping name: RESIN SOLUTION flammable
Transport hazard class(es): 3
Packing group: II
Marine pollutant: no
Air transport
UN/ID number: 1866
UN proper shipping name: RESIN SOLUTION flammable
Transport hazard class(es): 3
Packing group: II
SECTION 15: Regulatory information
Safety, health and environmental regulations/legislation specific for the substance or mixture
EU regulatory information
1999/13/EC (VOC): 79,88 % (679 g/l)
National regulatory information
Water contaminating class (D): 1 - slightly water contaminating
SECTION 16: Other information
Full text of R-phrases referred to under sections 2 and 3
11 Highly flammable.
36 Irritating to eyes.
66 Repeated exposure may cause skin dryness or cracking.
67 Vapours may cause drowsiness and dizziness.
Full text of H-Statements referred to under sections 2 and 3
H225 Highly flammable liquid and vapour.
H319 Causes serious eye irritation.
H336 May cause drowsiness or dizziness.
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
Renfert GmbH
Safety Data Sheet
according to Regulation (EC) No 1907/2006
Hardening Bath 1719-2000
Print date: 13.12.2012 Product code: 1719-2000 Page 7 of 7
Further Information
The above information describes exclusively the safety requirements of the product and is based on
our present-day knowledge. The information is intended to give you advice about the safe handling of
the product named in this safety data sheet, for storage, processing, transport and disposal. The
information cannot be transferred to other products. In the case of mixing the product with other
products or in the case of processing, the information on this safety data sheet is not necessarily valid
for the new made-up material.
Reserved for industrial and professional use.
(The data for the hazardous ingredients were taken respectively from the last version of the sub-contractor's safety
data sheet.)
Revision No: 1,10 GB - EN Revision date: 12.12.2012
Obtained by Global Safety Management, Inc. www.globalsafetynet.com (Tel: 1-813-435-5161)
