Sedimentation
Sedimentation theory
Different types of settling mechanisms
Ideal sedimentation basin and departure
from ideality
Sediment tank innovations
Factors affecting sedimentation
Sedimentation tank design criteria, case
study
Floatation process
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Sedimentation theory
For a discrete spherical particle, settling velocity/terminal
velocity is obtained when
Gravitational force (F) = Frictional Drag force (FD)
( S W ) gV C D AC W vS2 / 2
vS
vS
FD
2 gV S W
C D W AC
vS
4 g S W d
3C D W
V = volume of particle = d /6
AC = X-sectional area of particle
= d2/4
vS = settling velocity
CD = drag coefficient
3
CE6301: Theory of Water Treatment
Water density,
Density,
Dr. Tanvir Ahmed
Determination of Drag coefficient, CD
C D 24 / R
R 1
C D 24 / R 3 / R 0.34
C D 0 .4
10 4 R 105
CE6301: Theory of Water Treatment
Typical Reynolds number for
particles in water treatment
1 R 10 4
g S W d 2
vS
18
Dr. Tanvir Ahmed
Settling of Particles in a
Clarifier
Type I: Horizontal, discrete, or free settling. Examples are
plain settling in water treatment plants and grit settling
in wastewater treatment plants.
Type II: Settling of flocculent particles in a dilute
suspension:
Examples are settling of flocs after coagulation and
flocculation in water and wastewater treatment plants
and grit primary settling in wastewater treatment plants.
Type III: Zone settling or hindered settling. This occurs in the
secondary clarifiers at wastewater treatment plants.
Type IV: Compression settling where the particles are too
close that settling can occur by compaction. This occurs in
secondary clarifiers in wastewater treatment plants when the
solids at the bottom are thickened.
CE 6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Settling of Particles in a
Clarifier
CE 6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Different settling types
Type I: discrete settling
Type II: Flocculent settling
Type III: Zone settling (hindered and compression
settling)
Flocculent settling
Time
CE6301: Theory of Water Treatment
Hindered settling
Depth
Depth
Depth
Discrete settling
Time
Compression settling
Time
Dr. Tanvir Ahmed
Ideal Sedimentation Basin: assumptions
Inlet Zone
Outlet Zone
vO
hO
h
L
Particles and velocity vectors are uniformly
distributed across the tank cross-section
Liquid moves as an ideal slug down the length of
the tank
Any particle hitting the bottom are removed
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Ideal Sedimentation Basin
Inlet Zone
Outlet Zone
vO
h
vS
hO
v
v
L
Overflow rate:
vO hO / tO hO Q / V Q / A
Overflow rate identifies the smallest settling velocity
attributable to the class of particles which experience
complete removal
For vS < vO , the removal percentage will be 100(vS /vO)
because
h / hO vS / vO
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Removal efficiency from settling velocity
characteristics
Fraction of particles
having < stated
velocity
xO
dx
vx
vO
Settling
velocity
Total particle fraction that will be removed:
1
(1 xO )
vO
xO
v x dx
CE6301: Theory of Water Treatment
Applicable only for ideal settling
Dr. Tanvir Ahmed
Problem: discrete settling
The settling characteristics of a suspension at 2 ft
depth are as follows:
Time (min)
Suspended Solids (mg/l)
0
300
5
210
10
156
20
90
40
50
60
40
Compute the removal efficiency of the basin when Q
= 1.5 cfs and A = 360 ft2. Assume ideal settling.
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Ideal settling and departure from ideality
Ideal
tank
Remova
l
Very large n: best performance
n=1: worst case scenario
Reasons for
departure:
surface currents,
convection currents,
eddy currents
Hazen estimated the settling performance if a settling basin
is subdivided into n number of hypothetical basins connected
in series.
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Removal efficiency in non-ideal cases
vo
y
1 1
y0
n
(
Q
/
A
)
How to improve
performance:
Reducing the
surface overflow
rate
Covers for the
basins
Baffle walls at the
inlet and outlet
Larger height of
tank (avoid scour)
Tracer tests are used to
estimate n
t mean
n
t mean t mod e
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Flocculent suspensions
The density variation of small
flocs may be expressed by:
S kd
Flocculent settling
Depth
Particles will agglomerate while
settling, resulting in an
increase in particle size.
Time
0.7
S = density of the floc
= density of water
d = the diameter of the particle
k = a coefficient dependent upon
the
characteristics of the water
and the
CE6301:chemicals
Theory of Water
Treatment
involved
vS
g S d 2
18
Will cause an increase
in settling velocity
Dr. Tanvir Ahmed
Flocculent settling (Type II
settling)
The design of these settling tanks
usually requires a batch laboratory test
using a column with a depth similar to
that in the treatment plant (> 3m) and
a diameter of 130-205 mm.
samples are taken at different depths
for different times.
The samples are tested for suspended
solids and the results are reported as
percentage of the initial suspended
solids.
Lines of equal percentage of
suspended solids are then drawn as
shown in the figure below.
CE 6301: Theory of Water Treatment
13-20.5 cm
>3m
Sampling
ports
Dr. Tanvir Ahmed
Problem: Flocculent settling
Suspended Solids at different time and depths are shown in
the table. The initial SS concentration is 300 mg/L.
Time
(min)
10
20
30
40
50
60
Depth
(ft)
1
204
150
126
96
75
60
213
180
150
129
99
81
216
189
165
144
120
99
219
195
171
156
135
105
225
210
177
165
144
120
Calculate the efficiency of flocculent settling basin of depth
5 ft when the detention time is (a) 40 min and (b) 30 min.
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Estimating removal efficiency for
flocculent
settling
Settling analyses
are peformed in columns equal in depth to
the proposed clarifier
Total particle fraction that will be removed:
Xr
Z1 R1 R2 Z 2 R2 R3 Z 3 R3 R4 Z 4 R4 R5
Z6
2
Z6
2
Z6
2
Z6
2
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Zone settling
Hindered settling
Depth
Displacement of water by the
settling of one particle affects the
relative velocities of its
neighbours.
Compression settling
The hindered settling4.65velocity:
vh v 1 C v
Time
v = the free settling velocity
Cv = the volume of the particles divided
by the total volume of the suspension
Typically does not happen in
sedimentation tanks, but occurs in
sludge thickeners and at the bottom
of secondary clarifiers in biological
treatment systems
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Design Principles for High-rate
settlers
The design principles for rectangular sedimentation tank
also applies
Flow Pattern: In Practice the countercurrent pattern is the
one most commonly employed because cocurrent designs
often have trouble with resuspended sludge and crosscurrent
designs have trouble with flow distribution.
Co-current
Cross-current
Counter-current
CE 6315: Water Supply Engineering and Design
Dr. Tanvir Ahmed
High Rate Settlers
Counter-current
CE6301: Theory of Water Treatment
Co-current
Cross-current
Dr. Tanvir Ahmed
Problem: High Rate Settlers
Problem: A sedimentation basin has been retrofitted with 2.0-m
(6.6-ft) square inclined plates spaced 50mm (2.0 in.) apart. The
angle of inclination of the plates can be altered from 0 to 80.
Assuming that the sedimentation basin can be used for
countercurrent, co-current, or cross-flow sedimentation, determine
which flow pattern is the most efficient for particle removal
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Sedimentation Basin Innovations
Increases the plan area (A)
for the same flowrate (Q)
and reduces the effective
SOR
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Rectangular and Circular sedimentation
tanks
Rectangular tank
L:W = 4:1
W = 10 m is
common
Circular tank
Max. 60 m
diameter
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Factors affecting sedimentation and
design
Factors criteria
Size, shape and weight of the particles
Viscosity and temperature of water
Surface overflow rate (SOR = Q/BL)
Inlet and outlet arrangements
Detention period (t =V/Q) and actual time of flow
Effective depth of settling basin (3m 5m)
Design Criteria
SOR = 450-800 litres/hr/m2 (900-1200 litres/hr/m2
for sedimentation with coagulation-flocculation)
Detention time = 1 10 hrs, hor. velocity = 15
cm/min (max)
Eckenfelder recommends a scale up factor of 0.65 for
SOR and 1.75 for detention time
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Case study: Keranigonj SWTP
Flocculant Settling column test results for the Padma
River water (Aluminum sulfate used as a coagulant)
Expected SS removal = 93%
Required detention time, t = 17-20
min
Actual t ~ 30 min (using 1.75 scale
up factor)
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Case study: Keranigonj SWTP
Flocculant Settling column test results for the Padma
River water (Aluminum sulfate used as a coagulant)
SOR for 93% turbidity removal =
140 m/day
Actual design SOR = 91 m/day
(considering a 0.65 scale up factor)
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed
Flotation
A solid-liquid separation process that transfers solids to the
liquid surface through attachment of bubbles to solid
particles
Process Variables
Design
Operational
Physcial
Hydraulic
loading
Solids
loading
Chemical
Recycled flow
Coagulant
Operating
dose
pressure air
pH
quantity
Influent solids
Solids removal
concentration
frequency
Flotation systems:
1) Dissolved air flotation
2) Dispersed air flotation
3) Electrolytic flotation
CE6301: Theory of Water Treatment
Dr. Tanvir Ahmed