Component Identifiers (CID¹) Monitoring System Mode

Component Location
Module Identifier (MID²) Mode Of Operation Mode Number
Schematic Machine Schematic Machine
RENR3489-04 Harness And Wire Electrical Schematic Symbols
Power Train ECS Operator Sequence Mode 0 Component
Location Location
Component
Location Location
April 2013
(MID No. 027) Harness Code 1 Actuator - Water Valve A-5 20 Sensor - Turbo Inlet Pressure E-3 48
Symbols
CID Component Numeric Readout 2 Alarm - Action H-13 E Sensor - Turbo Boost Pressure H-1 48
Service 3 Alarm - Backup H-15 11 Sensor - Xmsn Out Speed A A-13 54
0041 Sensor Power Supply
Alternator E-2 12 Sensor - Xmsn Out Speed B A-13 54
0144 Backup Alarm Relay Tattletale 4 T
Battery - A E-1 13 Sensor - Xmsn T/C Output Speed C-13 48
0168 Electrical System Voltage Units 5 Battery - B A-2 14 Socket - 12V Power G-11 A
Pressure Temperature Level Flow Circuit Breaker
0177 Oil Temp Sensor Calibration (Transmission Control) 6 Breaker - ADEM H-11 E Socket - EEC Worklamp H-11 A Symbol Symbol Symbol Symbol Symbol
0190 Engine Speed Sensor Breaker - Alternator F-4 17 Solenoid - # 1 Xmsn Clutch B-13 47

0248 CAT Data Link

Breaker - Blower H-11 E Solenoid - # 2 Xmsn Clutch B-13 47 Symbols and Definitions
Breaker - Headlamp I-11 E Solenoid - # 3 Xmsn Clutch B-13 47
0420 Secondary Steering Relay Breaker - Hood F-4 18 Solenoid - # 4 Xmsn Clutch B-13 47 Fuse: A component in an electrical circuit that will open the circuit if too much current flows
0444 Start Relay Breaker - Key I-11 E Solenoid - # 5 Xmsn Clutch B-13 47 through it.
Related Electrical Service Manuals
0562 CAT Monitoring System Breaker - Main F-4 19 Solenoid - #1 Fuel Injector G-4 39
Title Form Number Coil - A/C Clutch E-3 46 Solenoid - #2 Fuel Injector G-4 39 Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
0585 Xmsn Out Speed Sensor (A) Alternator: 200-2232 Delco (34SI) SENR7508 Control - ABL Chassis G-15 1 Solenoid - #3 Fuel Injector G-4 39 circle indicates that the component has screw terminals and a wire can be disconnected from it.
0590 ADEM III ECM Starting Motor: 6V-0890 (50MT) Control - Board As A-6 20 Solenoid - #4 Fuel Injector G-3 39
SENR3860
0627 Parking Brake Pressure Switch CAT Monitoring System RENR3403
Control - CMS Dimmer B-8 C Solenoid - #5 Fuel Injector G-3 39 Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
0672 Xmsn T/C Output Speed Sensor Control - CMS Monitor C-6 A Solenoid - #6 Fuel Injector G-3 39 No circle indicates that the wire cannot be disconnected from the component.
ADEM III ECM RENR1285
Control - Engine I-3 E Solenoid - Crossaxle Diff Lock G-13 27
0673 Xmsn Out Speed Sensor (B) Power Train ECS RENR3442 Control - Hood Relay B-2 14 Solenoid - Hyd Fan A-14 33 Ground (Wired): This indicates that the component is connected to a grounded wire. The
0674 Xmsn Out Speed Sensor (A) Control - Int Wiper Delay Mod F-5 C Solenoid - Interaxle Diff Lock G-14 43 grounded wire is fastened to the machine.
0681 Parking Brake Solenoid Converter - 24V to 12V E-12 C Solenoid - Lock Up Clutch B-13 44
0702 Shift Lever Sensor Flasher H-5 C Solenoid - Lower Valve G-13 46 Ground (Case): This indicates that the component does not have a wire connected to ground.
Guage - Cat Monitor Quad D-6 A Solenoid - Park Brake B-15 46 It is grounded by being fastened to the machine.
0704 Service Brake Pressure Switch Machine Codes Guage - Cat Monitor Speed Tach E-6 A Solenoid - Raise Valve G-13 46
0709 Lockup Clutch Solenoid Sales Model Machine Code Horn - High Tone D-1 22 Solenoid - Retarder C-13 46 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
0724 Body Raise Solenoid 725 11 Horn - Low Tone D-1 23 Solenoid - Start Aid D-3 46 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
0725 Body Lower Solenoid 730 10 Lamps - Indicator E-5,F-5 A Solenoid - Xmsn Latch A-13 46

0739
0773
Diff Lock Indicator Lamp
Hoist Position Sensor
Lever - Shift/Hoist
Motor - Blower
E-11
A-5
B
20
Suppressor - Arc
Switch - A/C Select
E-3
D-5
46
A
725 and 730 Articulated Truck T
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
Motor - Front Washer I-7 C Switch - AC Pressure E-3 46 the gauge of the temperature or pressure.
0826
0967
T/C Temperature Sensor
Machine Application
Wire Wire
Description
Wire Description
Wire Wire
Description
Motor - Front Wiper
Motor - Hood Actuator
C-3
B-2
10
24
Switch - Battery Isolator
Switch - Clear
A-2
I-10
46
B
Electrical System Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
Number Color Number Color Motor - Rear Washer I-7 C Switch - CMS Operator B-6 A It has a coil that makes an electromagnet when current flows through it. The
0968 Xmsn Indicator Lamp Power Distribution Circuits Accessory Circuits (continued) Motor - Rear Wiper H-14 D Switch - Crossaxle Lock C-4 A electromagnet can open or close the switch part of the relay.
0971 Interaxle Diff Lock Solenoid 101 RD Motor (B+) Term A528 YL Water Valve Actuator Pot (+) Motor - Secondary Steer F-1 25 Switch - Diff Lock G-5 A
725: 730:
1100 Crossaxle Diff Lock Solenoid 102
103
BU
YL
Headlamp Pwr
Flasher
A529
A530
WH
OR
Water Valve Actuator
Water Valve Actuator Pot (-)
Motor - Starter F-2 30 Switch - Dome Lamp H-5 C AFX473-1097 AGF472-1010 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
1227 Retarder Lever Position Sensor Relay - Backup Alarm C-9 C Switch - Engine Shutdown E-4 46 coil that makes an electromagnet when current flows through it. The electromagnet
105 RD Keyswitch Pwr C542 GN Heated Mirror Power Relay - Headlamp C-8 C Switch - Fan Speed D-5 A can open or close a valve or move a piece of metal that can do work.
1233 Latch Pressure Sensor
108 BU Airseat Pwr C547 OR Blower Motor (Med-Low) Relay - Horn C-8 C Switch - Filter Bypass B-13 46
1235 Xmsn Latch Solenoid 109 OR Alt Output (+) Term E528 PU AC Sw to Fan Speed Sw Relay - INT Wiper C-9 C Switch - Hazard Flasher I-5 A Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
1248 Retarder Solenoid 110 GN Rear Wiper Pwr Lighting Circuits Relay - Main I-11 E Switch - Headlamp Tail H-6 A activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
1326 Location Code Incorrect 112 PU Main Power Relay Output (Switched B+) 602 WH Dome Lamp Relay - Secondary Steer C-9 C Switch - Heated Mirror I-5 A that make electromagnet when current flows through them. It also has an internal switch that places
113 OR CMS/Auto Sec Steer Pwr 604 OR Stop Lamp Relay - Secondary Steer F-1 42 Switch - Hood Locking B-2 46 the latch coil circuit open at the time the coil latches.
1401 Xmsn Clutch Solenoid #1
114 GN Horn Pwr 605 YL Turn Lamp (Left) Relay - Start F-3 26 Switch - Horn H-5 F
1402 Xmsn Clutch Solenoid #2 115 PK Radio/Domelamp Pwr 606 GY Turn Lamp (Right) Relay - Start Aid C-8 C Switch - Key Start E-4 A Harness and Wire Symbols
1403 Xmsn Clutch Solenoid #3 116 BR Rear Floodlamp Pwr 610 OR Head/Tail Lamp Sw Resistor A-6 10 Switch - Low Brake Oil Pressure A-14 46
118 GY Front Wiper Pwr 611 PU Head Lamp (Hi Beam) Resistor - A F-2 21 Switch - OTG Filter Bypass A-15 52 Wire, Cable, or Harness Harness Identification Letter(s):
1404 Xmsn Clutch Solenoid #4
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
121 YL Backup Alarm Pwr 612 GY Reverse Lamp Sender - Fuel Level B-2 29 Switch - OTG Low Oil Pressure A-15 52
1405 Xmsn Clutch Solenoid #5 Harness Identification Letters and
123 WH Diff lock/Heated Mirror Pwr 614 PU Park/Tail/Dash Lamp Sensor - Air Temp G-2 48 Switch - OTG Temp A-15 52 Harness Connector Serialization Code:
Harness Connector Serialization
1586 Retarder Indicator Lamp The "C" stands for "Connector" and the
124 GN HVAC Blower Motor Pwr 619 GN Head Lamp (Low Beam) Sensor - Atmospheric Pressure I-1 48 Switch - Park Brake D-11 C Codes (see sample).
number indicates which connector in the
Caterpillar Monitoring System 126 RD Xmsn Control 624 YL Rear Work Lamp Sensor - Cam Speed/Timing H-2 40 Switch - Park Brake Pressure C-15 46 AG-C4 L-C12 harness (C1, C2, C3, ...).
Sensor - Coolant Temp G-2 48 Switch - Rear Flood I-6 A L-C12
(MID No. 030) 129 BU Cigar Lighter Pwr 661 GN Tach Lamp 111-7898 3E-5179 3E-5179
136 GN Manual Sec Steer Pwr 662 YL Speedo Lamp Sensor - Crank Speed/Timing H-2 40 Switch - Rear Wiper I-6 A
CID Component Part Number: for Connector Plug 1
150 OR Engine Control Pwr 663 GY Gage Lamp Sensor - XMSN Engine Speed A-13 50 Switch - Retarder G-5 F Part Number: for Connector Receptacle
0096 Fuel Level Sender Sensor - Fuel Pressure H-1 49 Switch - Secondary Steer H-5 A
165 YL Start Aid Pwr Control Circuits 2
0100 Engine Oil Pressure Sensor 170 RD Product Link 705 PK Xmsn Lockup Clutch Solenoid Sensor - Fuel Temp G-2 49 Switch - Service I-10 B
0110 Engine Coolant Temperature Sensor 173 YL Stoplamp Pwr 708 YL Xmsn Hold Sw Sensor - Hoist Position E-11 B Switch - Service Brake Pressure C-3 E Plug Receptacle
175 PK Hood Motor Pwr 709 OR Sensor Pwr Sensor - XMSN Latch Pressure A-13 53 Switch - Start Aid H-6 A Pin or Socket Number
0177 Transmission Oil Temperature Sensor 5A
177 OR Main Breaker Power (Unswitched B+) 720 PU Service Brake Sw Sensor - Oil Pressure H-1 49 Switch - Steer Pressure G-4 28 Deutsch connector: Typical representation
0248 Data Link Sensor - XMSN Oil Temp A-13 55 Switch - Stop Lamp Pressure C-3 E
1 Component
Ground Circuits 727 GN Secondary Steering Motor Relay Coil of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
0263 Sensor Power Supply 200 BK Main Chassis Gnd 728 BU Secondary Steering Relay Coil Sensor - Shift Lever E-11 B Switch - Temp Selector C-5 A 2 sockets and the receptacle contains all pins.
0271 Action Alarm 201 BK CMS Gnd 751 GN Xmsn Shift Solenoid 1 Sensor - T/C Temp C-2 40 Switch - Temperature A-6 10 325-AG135 PK-14
Sensor - Throttle B-4 51 Switch - Wiper/Washer Turn G-5 F 1 Sure-Seal connector: Typical representation Harness identification code:
0324 Action Lamp 202 BK Xmsn Control Gnd 752 YL Xmsn Shift Solenoid 2 of a Sure-Seal connector. The plug and receptacle Wire Gauge
This example indicates wire group 325,
0819 Display Data Link
203 BK Chassis Diagnostic Gnd 754 BU Xmsn Shift Solenoid 3 Check Part Number in the Part Manual for your Specific Machine 2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
Machine locations are repeated for components located close together.
207 BK Starter Diagnostic Gnd 755 OR Xmsn Shift Solenoid 4
0821 Display Power Supply A = Components located in dash. D = Components located in the headliner.
270 BK CMS Ident Code 0 A700 OR Digital Sensor Pwr (+8V)
B = Components located in the right console area. E = Components located behind the operator seat.
ADEM III ECM 271 BK CMS Ident Code 1 A701 GY Fuel Injector 1
C = Components located in the left side of the cab. F = Components located on the steering column
(MID No. 036) 272 BK CMS Ident Code 2 A702 PU Fuel Injector 2
273 BK CMS Ident Code 3 A703 BR Fuel Injector 3 © 2013 Caterpillar, All Rights Reserved Printed in U.S.A.
CID Component
274 BK CMS Ident Code 4 A704 GN Fuel Injector 4
0001 Fuel Injector Solenoid #1
275 BK CMS Ident Code 5 A705 BU Fuel Injector 5
0002 Fuel Injector Solenoid #2 290 BK CMS Service A706 GY Fuel Injector 6
0003 Fuel Injector Solenoid #3 291 BK CMS Clear A745 WH Fuel Pressure
0004 Fuel Injector Solenoid #4 Basic Machine Circuits E707 GN CMS Cluster +V
301 BU Starter Motor Output E708 PK CMS Module Clock
0005 Fuel Injector Solenoid #5
302 OR Starter Resistor to Diagnostic E735 PU CMS Operator Sw In
0006 Fuel Injector Solenoid #6
304 WH Starter Motor Coil E737 PU OTG Temp Sw
0041 ECM 8V DC Supply 306 GN Start Relay Coil E789 PU Machine On/Off Drvr Returns 1-8
0091 Throttle Sensor 307 OR Key Switch Start E790 PK Machine Solenoid Drvr Returns 9-12
0094 Fuel Pressure Sensor 308 YL Main Power Relay Coil F702 GN Digital Sensor Pwr
310 PU Start Aid Switch F710 BR Start Aid Relay
0100 Oil Pressure Sensor
317 YL Start Aid Solenoid F715 PU Engine Shutdown (NO)
0110 Engine Coolant Temperature Sensor 320 OR Horn Relay Coil F716 WH Engine Shutdown (NC) Off Machine Switch Specification
38 42 18
0148 CAT Data Link communications 321 BR Backup Alarm Relay Coil G704 YL Body Raise Solenoid 17 Part No. Function Actuate Deactuate Contact Position
25 19 13 11 -1.1 ± 0.8°C 2.2 ± 0.8°C
0168 Electrical Power Supply 322 GY Horn Relay On G705 GN Body Lower Solenoid 3E-5464 Temperature Switch Normally Closed
(30 ± 1.4°F) (36 ± 1.4°F)
0172 Inlet Air Temperature Sensor
324 BU Diff lock Foot Switch G706 BU Retarder Solenoid (Low) 22
38 ±3°C 27 °C
368 OR Crossaxle Diff lock Solenoid G707 GN Retarder Solenoid (Med) 3E-6449 OTG Temperature Switch Normally Closed
0174 Fuel Temperature Sensor 28 21 34 36 (100.4 ± 37.4°F) (80.6 °F)
369 PU Crossaxle Lock Switch G708 GY Retarder Solenoid (Hi) 44 C
0253 Personality Module mismatch 374 PK Park Brake Switch G725 GN Hydraulic Fan Solenoid
47 15 37 1200 kPa 700 ± 100 kPa Contacts A-B (N.O.)
40 39 3E-6450 Steering Pressure Switch
Connector Location (174.05 psi) (101.5 ± 14.5 psi) Contacts A-C (N.C.)
0254 ADEM III ECM 397 OR Hood Motor (Lower) J700 BR Engine Retarder Solenoid (Med/Hi) A 49 30
51

(Dimensions: 39 inches x 24 inches)

E Schematic Machine 113 kPa 70 ± 20 kPa
0261 Engine Speed Sensor 398 BU Hood Motor (Raise) J701 GN Engine Retarder Solenoid (Low/Hi) F Connector Number 3E-7692 OTG Low Oil Pressure Switch Normally Open
Location Location (16.4 psi) (10.2 ± 2.9 psi)
A300 GN Hood Relay (Lower) J702 BK Engine Retarder Solenoid (Common) D
0262 5 Volt Sensor Supply 53 48 54 CONN 1 C-14 3 275 kPa¹ 170 ± 55 kPa
A301 WH Hood Relay (Raise) J764 BR Switch/Sensor Return Low
0267 Engine Shutdown Switch 8 9 B CONN 2 C-14 4 (39.9 psi) (24.6 ± 7.9 psi)
A323 GY IAD Actuate Solenoid K737 BR Engine Retarder Solenoid (Med/Hi)
3 5 4 6 114-5333 A/C Pressure Switch Normally Open²
0268 Check Programmable Parameters A324 PK Crossaxle Lock Switch Jumper K738 GN Engine Retarder Solenoid (Low/Hi) CONN 3 C-14 5 2800 ± 140 kPa 1750 ± 200 kPa
20
33 7 32 43 High

RENR3489-04
0273 Turbo Outlet Pressure Sensor Monitoring Circuits K739 BU Engine Retarder Solenoid (Common) 12 26 CONN 4 C-14 6 (406.1 ± 20.3 psi) (253.8 ± 29 psi)
52 31 16 1 50
403 GN Alternator (R) Term K742 OR Top Gear Sw (Up) 10 CONN 5 B-14 7 276 ± 28 kPa 179 kPa
0274 Atmospheric Pressure Sensor 27 24 35 116-9846 OTG Filter Bypass Switch Normally Closed
406 PU Torque Converter Temp Sensor K744 BU Xmsn Retarder Solenoid
11 46 29 23 CONN 6 C-13 8 (40 ± 4.1 psi) (26 psi)
0275 Turbo Inlet Pressure Sensor 410 WH CMS Action Alarm K746 PK IAD Pressure Solenoid 55 41 CONN 7 C-13 9 Stop Lamp Pressure Switch 200 ± 50 kPa 140 kPa
0283 Air Filter Indicator Lamp 411 PK CMS Action Lamp L730 OR Analog Sensor Pwr
14 172-7071 Normally Open
CONN 8 H-13 D Service Brake Pressure Switch (29 ± 7psi) (20.3 psi)
0296 Unable to communicate with Transmission ECM 417 GY Steering Press Sw R746 PK Turbo Outlet Pressure Sensor CONN 9 ET Connector I-12 B Park Brake Pressure Switch 13800 kPa MAX 12300 ± 345 kPa Normally Open A-B
419 YL Park Brake Press Sw R747 GY Atmospheric Pressure Sensor 213-6947
0320 Crankshaft Position Sensor CONN 10 Diagnostic Connector I-12 B Low Brake Oil Pressure Switch (2002 psi MAX) (1784 ±50psi) Normally Closed A-C
426 BR Filter Bypass Sw 892 BR Cat Data Link (-) CONN 11 I-12 D
0342 Camshaft Position Sensor ¹ With increasing pressure the closed condition can be maintained up to 2800 kPa (406 psi), with decreasing pressure the closed condition can be maintained
430 BU Air Filter Indicator Lamp 893 GN Cat Data Link (+) down to 170 kPa (25 psi).
CONN 12 H-12 D
0545 Start Aid Relay 432 PK Low Brake Oil Press Sw G828 WH Engine Pressure Sensor
CONN 13 B-12 15 ² Contact position at the contacts of the harness connector
1076 Hydraulic Fan Solenoid 447 PK Fuel Level Sender G829 GN Engine Pressure Sensor Common
CONN 14 C-11 16
¹ The CID is a diagnostic code that indicates which component is faulty. 454 GN Retarder Indicator Lamp G833 PK Engine Temp Sensor Common
CONN 15 I-10 E
498 WH Diff lock Indicator Lamp G834 PU Cooling Fan Speed +
² The MID is a diagnostic code that indicates which electronic control CONN 16 H-10 E
C413 YL CMS Display Data G835 OR Cooling Fan Speed -
module diagnosed the fault. C414 BU CMS Display Load G850 BU Engine Inlet Air Heater CONN 17 G-10 E
C452 GN Fuel Pressure Sw. G853 OR Engine Intake Manifold Air Temperature CONN 18 F-10 E Resistor, Sender and Solenoid Specifications
D Part No. Component Description Resistance (Ohms)¹
F400 GY Turbo Inlet Press Sensor G856 WH Engine TDC Probe (+) CONN 19 A-9 1
F421 YL Fuel Temperature G857 YL Engine TDC Probe (-) CONN 20 A-9 1 3E-6332 Solenoid: Start Aid 6
H420 PU Secondary Steering Indicator Lamp H805 BR Proportional Driver Return CONN 21 B-9 1 3E-7842 Resistor: Starter 150 ± 7.5
H421 GN Xmsn Hold Indicator Lamp J812 PK OTG Filter Bypass Sw CONN 22 H-8 10 A-C: 2 ± 0.1
Failure Mode Identifiers (FMI)¹ Accessory Circuits J823 YL Xmsn Latching Pressure Sensor CONN 23 F-8 10
FMI No. Failure Description F 125-9740 Resistor: Blower Motor Speed B-C: 1 ± 0.05
500 BR Front Wiper (Park) J832 YL Xmsn Latch Solenoid CONN 24 A-7 1
0 Data valid but above normal operational range. 501 GN Front Wiper (Low) 900 PU Xmsn Shift Solenoid 5 C-D: 0.36 ± 0.018
CONN 25 G-6 A
1 Data valid but below normal operational range. 502 OR Front Wiper (Hi) 921 WH Xmsn Solenoid Return 1 C A 18 127-4540 Potentiometer: Temperature Selector Switch 0 - 5000 ± 500
E B 17 CONN 26 C-6 A
2 Data erratic, intermittent, or incorrect. 503 BR Rear Wiper (Park) 922 BR Xmsn Solenoid Return 2 24 19 CONN 27 B-5 31 152-8340 Solenoid: Park Break 32.6 ±1.6
32 48
3 Voltage above normal or shorted high. 504 YL Rear Wiper (Low) 993 BR Analog Sensor Return 21 CONN 28 B-5 32 Interaxle Diff Lock
31 16 10 49 39 30 152-8385 Solenoid: 32.6 ±1.6

20 Page,
4 Voltage below normal or shorted low. 505 BU Rear Wiper (Hi) 994 GY OTG Low Oil Pressure Sw 1 54 Crossaxle Diff Lock
CONN 29 E-4 34
5 Current below normal or open circuit. 506 PU Front Washer 995 BU Coolant Temperature 33 20 51 12 Lockup Clutch
43 CONN 30 A-3 35 160-8408 Solenoid: 8.7 ±0.4
507 WH Rear Washer 998 BR Digital Sensor Return 38 53 40 26 22 Xmsn Clutch #1 - #5
6 Current above normal or grounded circuit. 44
508 PU Radio Speaker (Left) A958 WH Park Brake Solenoid
8 9 47 37 23 CONN 31 D-3 36
163-3318 Solenoid: Hydraulic Fan 41.9
7 Mechanical system not responding properly. 11 27 28 41 42 CONN 32 F-3 37
509 WH Radio Speaker (Left Common) E900 WH ECPC Xmsn Output Speed (+) 46 4 6 35 34 36 173-2056 Solenoid: Retarder 2.2 ±0.2
8 Abnormal frequency, pulse width, or period. CONN 33 F-3 38
511 BR Radio Speaker (Right) E901 GN ECPC Xmsn Output Speed (-) 3 5 52 7 15 14
9 Abnormal update. 55 29 191-3005 Solenoid: Fuel Injector #1 - #6 1.08 ± 0.07
512 GN Radio Speaker (Right Common) E906 OR ECPC Xmsn Output Speed Q (+) 13 11 CONN 34 H-3 39
10 Abnormal rate of change. Full 0
513 OR AC Press Sw E907 GY ECPC Xmsn Output Speed Q (-) 50 CONN 35 H-2 40 192-4315 Sender: Fuel Level
11 Failure mode not identifiable. Empty 95
515 GY Blower Motor (Hi) E963 BK Engine Speed/Timing (A-)
25 CONN 36 C-2 41
12 Bad device or component. 192-6443 Solenoid: Raise Valve 5.0 ± 0.3
516 GN Blower Motor (Medium) E964 WH Engine Speed/Timing (A+) CONN 37 Remote Start Receptacle F-1 42
13 Out of calibration. 196-2403 Solenoid: Lower Valve 5.0 ± 0.3
517 BU Blower Motor (Low) E965 BU Engine Speed/Timing (B-) CONN 38 A-5 31
14 Parameter failures. The connectors shown in this chart are for harness to harness connectors. 200-8215 Solenoid: Xmsn Latch 32.6 ± 1
522 WH AC Clutch to Thermostat Sw E966 YL Engine Speed/Timing (B+)
15 Parameter failures. 537 GN Turn Signal Sw E971 GN AC High Pressure Sw Connectors that join a harness to a component are generally located at or near the ¹ At room temperature unless otherwise noted.
16 Parameter not available. 575 YL Wiper Sw (Park) K952 BR Solenoid Return 3 component. See the Component Location Chart.
17 Module not responding. 590 GY Wiper Sw (Inter) K977 PK ECPC Xmsn Oil Temp Sensor
18 Sensor supply fault. 591 WH Wiper Delay Module (Gnd) L910 PK Torque Converter Output Speed (+)
19 Condition not met. 592 BU DC/DC Converter Output L911 YL Torque Converter Output Speed (-)
20 Parameter failures. A513 PK DC/DC Converter Memory L983 WH Injector Common 1 & 2
¹The FMI is a diagnostic code that indicates what type of failure has occurred. A523 PU Fan Speed (Sw Pos 1) L984 OR Injector Common 3 & 4
A524 BR Fan Speed (Sw Pos 2) L985 YL Injector Common 5 & 6
A525
A526
GN
PK
Fan Speed (Sw Pos 3)
Water Valve Actuator Motor
M996
M997
PK
PU
Hoist Lever Position
Shift Lever Position
Machine Harness Connector And Component Locations
A527 BU Water Valve Actuator Motor
 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
OPERATOR STATION OPERATOR STATION ADEM III
LH STOP TAIL TURN LAMP REAR WIPER SW 210-0849
149-5535 AC-C3 112-6174 HEATED MIRROR SW
BREAKER L-C8 165-5979

DIGITAL SENSOR RETURN

TURBO INLET PRES SNSR

FILTER LAMP

SHUTDOWN-NC

GND LEVEL SHUTDOWN-NO

TURBO OUTLET PRESSURE

1552272 3E7996
ROOF HARNESS

ANALOG SENSOR RETURN

DIGITAL SENSOR POWER

ATMOSPHERIC PRESSURE

INTAKE AIR TEMP SNSR

FUEL PRESSURE SENSOR

INJECTOR COMMON 1 &2

INJECTOR COMMON 3 &4
INJECTOR COMMON 5 &6
ANALOG SENSOR POWER

PRESSURE SENSOR +5V

PRESS SENSOR COMMON

RETARDER/IAH COMMON
RETARDER SOL MED/HI
RETARDER SOL LOW/HI

COOLANT TEMP SENSOR

S RD-16 1 604-AC9 OR-16 200-K46 BK-16 L-C5 L-C2 614-L48 PU-18 A

HYD DEMAND FAN SOL

TEMP SENSOR COMMON

TDC SERVICE PROBE+

TDC SERVICE PROBE-

INJECTOR 1 HI-SIDE
INJECTOR 2 HI-SIDE
INJECTOR 3 HI-SIDE
INJECTOR 4 HI-SIDE

INJECTOR 5 HI-SIDE
INJECTOR 6 HI-SIDE
H44 1698673 3E3387 H

HYDRAULIC FAN SOL

T WH-16 2 614-AC13 PU-16 308-K47 YL-16 B B 200-L47 BK-18 B

SWITCH

FUEL TEMP SENSOR

BR-16 605-AC10 YL-16 K-C10 110-L28 GN-16 200-L16 BK-18

CAT DATA LINK +

CAT DATA LINK -

RELAY

THROTTLE SENSOR
T 3 1 RD-16 1
3E3363 2
BK-16 4 200-AC6 BK-16 K-C5 2 RD-16 123-L50 WH-18 2
3
MAIN RELAY 308-K47 YL-16 123-L149 WH-18

OIL PRESSURE
9W1951 BK-16 1 3 3

SWITCHED B+
167-0138 BK-16 2 200-K46 BK-16 SERVICE SWITCH 505-L29 BU-16 4 WH-16 C542-L49 GN-18 4

CRANK S/T+
CRANK S/T-
CONN 9 126-K110 RD-16 E-C22 FRONT WASHER MOTOR L

INLET AIR
START AID
START AID
GND LEVEL

+ BATTERY

+ BATTERY

- BATTERY
- BATTERY
A 177-K57 RD-12 H47 6T-6066 7T-8891 504-L30 YL-16 5 YL-16 P W C542-L143 GN-18 5

CAM S/T+
CAM S/T-
B 202-K1 BK-16 H46 112-K56 PU-12 177-K58 RD-12 7T5957 503-L31 BR-16 6 BU-16 6
LEFT SPEAKER H45
+ 508-FA7 PU-18 C 112-K55 PU-12 177-K4 RD-4 506-E88 PU-16 506-E88 PU-16 1 507-L65 WH-16 7 BR-16 C542-L143 GN-18 C
124-6046 - 509-FA8 WH-18 H56 ET D 893-K2 GN-16 112-K31 PU-16 290-K32 BK-16 200-E162 BK-16 200-L16 BK-18
177-K20 RD-16 2 MOTOR 8 D
CONNECTOR
I REVERSE LAMP A(LH) E 892-K3 BR-16 112-K43 PU-14 506-E88 PU-16 I
172-9973 AC-C5 F 103-E22 RD-16 REAR FLOOD SW J1 J2

201-K45 BK-16
1552269 BEACON G 105-E85 RD-16 L-C4 123-5849 HAZARD FLASHER SW
H31 M-C1

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
WH-18 3E7996

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
1 612-AC17 GY-16 H TWISTED PAIR 201-K34 BK-16 109-E53 RD-16 155-2703
BK-18 200-AC5 BK-16 177-K6 RD-14 110-E18 GN-16 614-L51 PU-18 L-C9 C-C2 1607690
2 J H48 A
1607689
F-C7 F-C3 10A

GN-18

L983-M39 WH-18
L985-M35 YL-18
115-E83 RD-16 200-L64 BK-18 3E7996

BK-18
BR-18

L984-M37 OR-18
GY-18
PU-18
BR-18
GN-18

A705-M32 BU-18
A706-M33 GY-18
B

OR-16

F400-C58 GY-16

F716-C65 WH-16

G834-C69 PU-16

G828-M14 WH-18
G829-M19 GN-18

BU-18
R747-M24 GY-18
A745-M27 WH-18

PK-18

E964-M10 WH-18
E963-M11 BK-18

E966-M12 YL-18
E965-M13 BU-18
GN-18
BR-16
BR-16

892-C10 BR-16

F710-C4 BR-16

G833-M4 PK-18

994-M26 GY-18

F421-M5 YL-18
G856-M8 WH-18
G857-M9 YL-18

OR-18
3E3364 1552269

F715-C55 PU-16
893-C9 GN-16

995-M6 BU-18
200-C59 BK-14
177-K7 RD-14 116-E12 BR-16 200-L53 BK-18

430-C12 BU-18

150-C44 RD-14

150-C45 RD-14

200-C42 BK-14

A700-C3 OR-18
KEY BREAKER 1

G835-C75 OR-16
310-C6 PU-16

308-C14 YL-16
15A 2
1 116-F18 BR-16 6T-3642 CLEAR SWITCH 129-E72 RD-16 REAR WASHER MOTOR 116-L32 BR-16 2
3
A
2 200-F3 BK-16 K-C6 HEADLAMP BREAKER 6T-6066 136-E19 GN-16 E-C23 624-L33 YL-16 3 B
3T0204 3T-2662 7T5957 7T-8891 1

J701-M36
J702-M34
J700-M38
150-E160 RD-14

A701-M28
A702-M29
A703-M30
A704-M31
4 1

L730-C52

G850-M42

R746-M25
993-C47
F702-C1
998-C43

G853-M7
605-L43 YL-18 2
H57 CONN 10 1 177-K20 RD-16 170-E240 RD-16 507-E89 WH-16 1 5 2
3
2 302-K21 OR-16 291-K33 BK-16 173-E90 RD-16 200-E161 BK-16 2 MOTOR 6 537-L2 GN-18 3
4
REAR WORK LAMP 3 203-K22 BK-16 177-E82 RD-4 C 4
133-6335 F-C5 304-K23 WH-16 102-K36 RD-16 201-E232 BK-16 537-L44 614-L46
GN-18 PU-18
5

200-AC5 BK-16
4 D 5
1552269 CONN 11 6

200-AC6 BK-16
5 105-K24 RD-16 105-K37 RD-16 202-E245 BK-16 537-L44 GN-18 6

612-AC14 GY-16
612-AC15 GY-16
WH-18 1 624-F17 YL-16 DIAGNOSTIC 6 306-K25 GN-16 308-K61 YL-16 203-E171 BK-16 HEADLAMP TAIL SW 614-L48GY-18
PU-18 C

604-AC9 OR-16
F-C1 K-C3 606-L42 M-C9 ATMOS PRESS SNSR
BK-18 2 200-F4 BK-16 3E3381 1698672 CONNECTOR 7 207-K26 BK-16 207-E30 BK-16 3E-9317 D
197-8393
H42 CONN 15

J702-M34 BK-18

E963-M11 BK-18
E964-M10 WH-18
E965-M13 BU-18
E966-M12 YL-18

R747-M24 GY-18
R746-M25 PK-18
A745-M27 WH-18
G829-M19 GN-18
G828-M14 WH-18
L-C6 1552267

G856-M8 WH-18
G857-M9 YL-18
308-K48 YL-16 290-E50 BK-16

F421-M5 YL-18

994-M26 GY-18
8 CONN 22

G850-M42 BU-18

995-M6 BU-18
200-L47 BK-18

G853-M7 OR-18
J702-M41 BK-18

G833-M4 PK-18
116-F18 BR-16 1 116-K12 BR-16 9 109-K28 RD-16 291-E49 BK-16 3E7996 200-L45 BK-18 G828-M15 WH-18 A +5V

J702-M40 BK-18
A701-M28 GY-18
A702-M29 PU-18
A703-M30 BR-18
A704-M31 GN-18
A705-M32 BU-18
A706-M33 GY-18
L983-M39 WH-18
L984-M37 OR-18
L985-M35 YL-18
J700-M38 BR-18
J701-M36 GN-18
H57 K-C2 E-C17 E-C6 L-C3
624-F17 YL-16 2 624-K13 YL-16 10 310-K29 PU-16 177-K59 RD-14 150-K60 RD-14 302-E29 OR-16 614-L51 PU-18 G829-M23 GN-18 B GROUND

993-C47 BR-16
150-C44 RD-14
150-C45 RD-14
504-F19 YL-16 504-K14 YL-16 200-K30 BK-16
15A H49 1275483 1886210 304-E27 WH-16 1030213 9X4391 614-L52 PU-18
F-C6 3 11 A R747-M24 GY-18 C SIGNAL

998-C43 BR-16
F-C4 110-F20 GN-16 4 110-K15 GN-16 12 112-K31 PU-16 ADEM BREAKER 177-K4 RD-4 1 177-E82 RD-4 102-E11 RD-16 307-E141 OR-16 110-E18 GN-16 1 110-L28 GN-16 200-L53 BK-18 B L-C10 SEC STEER SW
BACKUP ALARM AC-C2
L
3E3381 1698672 1 M-C10 TURBO BOOST PRESS SENS
H58 503-F21 BR-16 5 503-K16 BR-16 13 6T-3643 103-E22 RD-16 308-E9 YL-16 504-E7 YL-16 2 504-L30 YL-16 102-L34 RD-16 1 3E7996 155-2702
123-6449 1552269 GND 2 3E3370 197-8395
614-AC13 PU-16 H MOTOR GN-16 4 504-F19 YL-16 505-F22 BU-16 6 505-K17 BU-16 14 105-E85 RD-16 308-E234 YL-16 503-E8 BR-16 3 503-L31 BR-16 102-L147 RD-18 2
3
614-L46 PU-18
BK-18 1 200-AC3 BK-16 1 200-F13 BK-16 15 308-K48 YL-16 112-K43 PU-14 124-K35 GN-14 109-E53 RD-16 308-E246 YL-16 505-E6 BU-16 4 505-L29 BU-16 610-L130 OR-16 3 4
614-L60 PU-18 A G828-M14 WH-18 G828-M16 WH-18 A +5V
BK-18 2 612-AC15 GY-16 T° BK-16 2 200-F5 BK-16 200-F14 BK-16 16
15A
CONN 16 110-E18 GN-16 317-E202 YL-16 507-E89 WH-16 5 507-L65 WH-16 614-L52 PU-18 4
5
200-L45 BK-18 B G829-M22 GN-18 B GROUND
P B+
GY-16 6 110-F20 GN-16 CONN 12 17 BLOWER BREAKER K-C1 113-E107 OR-16 320-E134 OR-18 624-E5 YL-16 6 624-L33 YL-16
H31
614-L54 PU-18 6
200-L38 BK-18 1
2
R746-M25 PK-18 C SIGNAL
BR-16 3 503-F21 BR-16 FA-C1 F-C8 18 6T-3643 9X0141 E-C8 115-E83 RD-16 322-E191 GY-16 116-E12 BR-16 7 116-L32 BR-16 103-L35 RD-16 5 136-L41 GN-18 2
OR-16 5 505-F22 BU-16 H56 1698673 3E3387 1 200-K108 BK-16 19 H45 9X1343 116-E12 BR-16 324-E207 BU-16 102-E194 RD-16 8 102-L34 RD-16 103-L1 RD-16 727-L40 GN-18 3
3 M-C11 OIL PRESS SNSR
508-FA7 PU-18 1 508-F7 PU-16 2 508-K8 PU-16 20 508-K8 PU-16 1 508-E15 PU-16 118-E102 GY-16 369-E140 PU-16 998-E20 BR-16 9 998-L36 BR-16 614-L54 PU-18 727-L39 GN-18 4 H30 1552267 197-8394
612-AC16 GY-16 REAR WIPER MOTOR 509-FA8 WH-18 2 509-F8 WH-16 3 509-K9 WH-16 509-K9 WH-16 2 509-E16 WH-16 123-E92 WH-16 406-E166 PU-16 310-E130 PU-16 10 310-L37 PU-16 614-L55 PU-18 6 H32 5 M-C8 M-C7 G828-M17 WH-18 A +5V
201-K39 BK-16

H44

PU-16
WH-16
GY-16
OR-16
168-8926 PU-18 BK-18C
200-L57 TDC 3E3364 1552269

BK-14
BK-14
200-AC2 BK-16 511-FA9 BR-18 3 511-F9 BR-16 4 511-K10 BR-16 308-K44 YL-16 511-K10 BR-16 3 511-E17 BR-16 124-E75 GN-14 410-E10 WH-18 103-E22 RD-16 11 103-L35 RD-16 614-L56 6 G829-M19 GN-18 G829-M21 GN-18 B GROUND

G834-C69 PU-16
G835-C75 OR-16

BK-18
FA-C3

308-C14 YL-16
H47

GY-18
SERVICE

WH-18
PU-18
BR-18
OR-18
GN-18
BU-18
YL-18
GY-18
BR-18
GN-18
430-C12 BU-18
892-C10 BR-16
A700-C3 OR-18
F710-C4 BR-16
F702-C1 GN-18
200-AC4 BK-16 H59 512-FA10 GN-18 4 512-F10 GN-16 5 512-K11 GN-16 200-K46 BK-16 512-K11 GN-16 4 512-E4 GN-16 126-E113 RD-14 417-E132 GY-16 614-E23 PU-16 12 614-L62 PU-18 614-L140 PU-18 D C 1 G856-M8 WH-18 994-M26 GY-18 C

310-C6 PU-16

893-C9 GN-16
SIGNAL
1698669 5 115-F11 RD-16 6 115-K18 RD-16 308-K47 YL-16 624-K13 YL-16 5 624-E5 YL-16 126-E115 RD-14 432-E2 PK-16 200-E138 BK-16 13 200-L63 BK-16 200-L38 BK-18 D PROBE 2 G857-M9 YL-18 FUEL PRESS SNSR

G833-M4 PK-18
604-AC8 OR-16 115-FA11 RD-16 602-F12 WH-16 602-K19 WH-16 505-K17 BU-16 505-E6 BU-16 129-E72 RD-16 454-E123 GN-18 START AID SW 200-L61 BK-18 CONN 35 M-C12
H
RD-18 A 6 7 6 14 FLASHER H

F715-C55
F716-C65
F400-C58
L730-C52
H51 H47 197-8394

200-C59
200-C42
614-AC12 PU-16 WH-18 C 602-FA1 WH-16 7 200-F13 BK-16 8 308-K61 YL-16 177-K57 RD-12 504-K14 YL-16 7 504-E7 YL-16 136-E19 GN-16 498-E80 WH-18 15 L-C7 3E-7160 M-C5 1552267

J702-M40
H41 8D-6946

A701-M28
L983-M39
A702-M29
A703-M30
L984-M37
A704-M31
A705-M32
L985-M35
A706-M33
J700-M38
J701-M36
606-AC18 GY-16 BK-18 B 200-FA3 BK-16 8 308-K27 YL-16 177-K58 RD-12 503-K16 BR-16 8 503-E8 BR-16 150-E160 RD-14 500-E74 BR-16 136-E19 GN-16 16 136-L41 GN-18 3E7996 1552269 G828-M18 WH-18 A +5V
F-C2 K-C4
112-K55 PU-12 410-K38 WH-16 9 410-E10 WH-18 170-E240 RD-16 503-E8 BR-16 727-E215 GN-16 17 727-L40 GN-18 A 103-R21 RD-16 1 E963-M11 BK-18 G829-M20 GN-18 B GROUND
605-AC10 YL-16

3E3387 1698673 H46

612-AC14 GY-16
606-AC18 GY-16
614-AC11 PU-16

RIGHT DOME LAMP CONN 8 112-K56 PU-12 602-K19 WH-16 10 602-E25 WH-16 173-E90 RD-16 504-E7 YL-16 123-E26 WH-16 18 123-L50 WH-18 B 2 E964-M10 WH-18 A745-M27 WH-18 C SIGNAL
200-AC1 BK-14
604-AC7 OR-16

3E-6389 200-K49 BK-14 308-K27 YL-16 11 308-E9 YL-16 177-E82 RD-4 505-E6 BU-16 C542-E239 GN-16 19 C542-L49 GN-18 1 537-R22 GN-18 CRANK S/T SENSOR
200-K108 BK-16 H43 200-K49 BK-14 12 200-E24 BK-14 200-E24 BK-14 508-E15 PU-16 611-E139 PU-16 20 611-L3 PU-16 H32 998-L36 BR-16 2
2
537-R1 GN-18 197-8396
M-C13

150-C11 RD-14
998-C16 BR-16

993-C13 BR-18
998-C57 BR-16

993-C56 BR-16
3 M-C6
RIGHT SPEAKER + 511-FA9 BR-18 410-K38 WH-16 H42 304-K23 WH-16 13 304-E27 WH-16 202-E148 BK-16 509-E16 WH-16 605-E33 YL-16 21 605-L4 YL-16 310-L37 PU-16 3
124-6046 H59 H42 H33 1552252 1552269
- 512-FA10 GN-18 503-K16 BR-16 308-K44 YL-16 14 308-E234 YL-16 203-E171 BK-16 511-E17 BR-16 22 4 602-R2 WH-16

12

10
CONN 34

11
1

2
3

4
5
8
6
504-K14 YL-16 306-K25 GN-16 15 306-E167 GN-16 207-E30 BK-16 512-E4 GN-16 606-E34 GY-16 23 606-L5 GY-16 5 DOME LAMP SWITCH 1 E965-M13 BU-18

9
7
N-C14
505-K17 BU-16 K-C14 207-K26 BK-16 16 207-E30 BK-16 290-E50 BK-16 515-E69 GY-14 H420-E149 PU-18 24 H420-L9 PU-18 614-L56 PU-18 6 9D-4068 2 E966-M12 YL-18

G853-M7 OR-18
3E7990

G833-M1 PK-18

G833-M2 PK-18
K-C12 509-K9 WH-16 7T5957 302-K21 OR-16 17 302-E29 OR-16 291-E49 BK-16 516-E70 GN-14 498-E80 WH-18 25 498-L10 WH-18 614-L58 PU-18 C CAM S/T SENSOR

L985-N13 YL-16
L983-N3 WH-16

L984-N8 OR-16

995-M6 BU-18
H11 BK-18 1
1698668
410-K38 WH-16
508-K8
511-K10
PU-16
BR-16
200-K102 BK-16
129-K5 RD-16
1 NEG
2 POS
EEC WORKLAMP SOCKET
9R-7941
310-K29 PU-16
109-K28 RD-16
18
19
310-E21 PU-16
109-E53 RD-16
302-E29 OR-16
304-E27 WH-16
517-E71 BU-14
522-E184 WH-14 H421-E125 GN-18
26
27 H421-L12 GN-18
200-L57 BK-18
200-L59 BK-18
D 115-R3 RD-16 197-8397
M-C14 ABBREV COLOR

F421-M5 YL-18
1552269

G833-M3 PK-18
BK-18 2 201-K39 BK-16 512-K11 GN-16 129-K87 RD-16 201-K39 BK-16 20 201-E120 BK-16 306-E167 GN-16 575-E106 YL-16 A525-E65 GN-14 28 A525-L6 GN-16 R-C1
H52 H11 HORN SW
602-K19 WH-16 K-C13 203-K22 BK-16 21 203-E171 BK-16 308-E9 YL-16 591-E110 WH-16 454-E123 GN-18 29 454-L13 GN-18 1698668 2T-3360 AIR HTR SW 1 G850-M42 BU-18 RD RED

K952-CA53 BR-16

E790-CA49 PK-16
ACTION ALARM 624-K13 YL-16 7T5957 103-K95 RD-16 22 103-E22 RD-16 308-E234 YL-16 592-E101 BU-16 430-E124 BU-18 30 430-L134 BU-18 614-L60 PU-18 2 J702-M41 BK-18
ABL CHASSIS CONTROL 3E-6328 200-K102 BK-16 113-K81 OR-16 23 113-E107 OR-16 308-E246 YL-16 602-E25 WH-16 A524-E66 BR-14 31 A524-L7 BR-16 1
161-2355 J1 E-C1 200-K54 BK-16 200-K54 BK-16 1 NEG 12V POWER SOCKET 123-K53 WH-16 24 123-E92 WH-16 310-E21 PU-16 604-E174 OR-16 A523-E129 PU-14 32 A523-L8 PU-16 200-L61 BK-18 320-R4 OR-18 2 M-C2 M-C3 WH WHITE
1471446 592-K101 BU-16 2 POS 117-2311 114-K93 RD-16 25 114-E112 RD-16 374-E137 PK-16 610-E13 OR-16 H805-E144 BR-18 33 H805-L124 BR-18 K739-N18 BU-16 1552269 1552269
1 116-K78 BR-16 26 116-E12 BR-16 410-E10 WH-18 624-E5 YL-16 369-E140 PU-16 34 369-L123 PU-18 H32 H1 H2
HOIST LEVER SENSOR OR ORANGE

1
2

1
2
2 M996-E76 PK-16 129-K87 RD-16 173-K92 RD-16 27 173-E90 RD-16 503-E8 BR-16 661-E51 GN-18 129-E72 RD-16 35 129-L111 RD-16 DIFF LOCK SWITCH K738-N17 GN-16 M-C4
PSR FEEDBACK #1 3 921-E233 WH-18 200-K51 BK-16 165-K83 YL-16 28 165-E227 YL-16 504-E7 YL-16 662-E52 YL-18 307-E141 OR-16 36 307-L102 OR-16 R-C5
H40 1698668 147-1380 1552269
PSR FEEDBACK #2 4 922-E238 BR-18 110-K15 GN-16
H50
118-K80 GY-16 29 118-E102 GY-16 505-E6 BU-16 663-E231 GY-18 105-E85 RD-16 37 105-L103 RD-16 K737-N16 BR-16 YL YELLOW
115-K18 RD-16 110-K85 GN-16 110-E18 GN-16 508-E15 PU-16 709-E220 OR-16 J764-E87 BR-18 J764-L129 BR-18 123-R33 WH-18

1
2
5 30 38 1 WH-16

K739-N20 BU-16

K737-N19 BR-16
537-R1 GN-18

K739-N21 BU-16
T° T°

K739-N22 BU-16
FUEL INJ SOL 1

K737-N23 BR-16
6 116-K12 BR-16 126-K90 RD-14 31 126-E113 RD-14 509-E16 WH-16 720-E168 PU-16 E971-E143 GN-16 39 E971-L110 GN-16 R-C9 324-R20 BU-18 2 GN-16 A701-N1 GY-16 A706-N15 GY-16 FUEL INJ SOL 6

K738-N17 GN-16
CAT DATA LINK - 7 892-E63 BR-18 H41 121-K94 RD-16 32 121-E114 RD-16 511-E17 BR-16 A513-E64 PK-16 308-E9 YL-16 40 308-L100 YL-16 L-C1 3E3387 R-C2
191-3005 L983-N2 WH-16 L985-N14 YL-16 191-3005 AIR TEMP SENSOR COOLANT TEMP SENSOR PK PINK
CAT DATA LINK + 8 893-E62 GN-18 K-C8 126-K91 RD-14 33 126-E115 RD-14 512-E4 GN-16 A523-E129 PU-14 516-E70 GN-14 41 516-L106 GN-14 1698673 197-8392 197-8391
1698672 T°
9 FUSE BLOCK 136-K41 GN-16 34 136-E19 GN-16 602-E25 WH-16 A524-E66 BR-14 517-E71 BU-14 42 517-L108 BU-14 103-L1 RD-16 1 103-R21 RD-16 BK BLACK

E790-CA55 PK-16
K952-CA57 BR-16

10 9W2035 116-K12 BR-16 115-K42 RD-16 35 115-E83 RD-16 614-E217 PU-16 A525-E65 GN-14 C547-E68 OR-14 43 C547-L107 OR-14 537-L2 GN-18 2 537-R22 GN-18 1
FUEL TEMP SENSOR

E790-CA54 PK-16
H33
A323-CA51 GY-16

+8V SENSOR SUPPLY 709-E219 OR-16 115-K18 RD-16 624-E5 YL-16 C547-E68 OR-14 200-E146 BK-16 200-L90 BK-16 G707-R8 GN-18 MED

G705-CA47 GN-16

G704-CA13 YL-16
11 36 44 3 2 197-8391
SENSOR GROUND RETURN 12 J764-E103 BR-16 5 FUSE 1 1 REAR FLOOD 116-K78 BR-16 37 708-E122 YL-16 E789-E81 PU-16 663-E231 GY-18 45 663-L95 GY-18 102-L147 RD-18 4 102-R12 RD-18 G708-R7 GY-18 3 HI RETARDER SWITCH FUEL INJ SOL 2
GY GRAY
112-K56 PU-12 116-K52 BR-16 116-K12 BR-16 110-K15 GN-16 H50 108-K40 BU-14 108-E126 BU-14 892-E128 BR-18 F710-E204 BR-16 661-E51 GN-18 661-L99 GN-18 123-L149 WH-18 123-R33 WH-18 G706-R6 BU-18 LO/MED/HI A702-N4 PU-16 A705-N12 BU-16 FUEL INJ SOL 5

K952-CA58 BR-16
13 38 46 5 4
10A
141-0275

200-L24 BK-18
H34 191-3005

614-L140 PU-18
662-E52 YL-18 662-L98 YL-18 611-R11 PU-18 GROUND 191-3005
368-CA52 OR-16
DIFF. LOCK/ HEATED MIRROR 129-K5 RD-16 129-E72 RD-16 893-E61 GN-18 G706-E84 BU-16 611-L3 PU-16 611-L137 PU-16 L983-N5 WH-16 L985-N11 YL-16

614-L101 PU-18
14 6 FUSE 2 2 39 47 6 5

200-L94 BK-18

200-L64 BK-18
PU PURPLE

200-L93 BK-18

OPERATOR STATION
614-L19 PU-18
15 10A 123-K53 WH-16 129-K87 RD-16 592-K101 BU-16 40 592-E116 BU-16 A513-E64 PK-16 G707-E99 GN-16 200-E147 BK-18 48 200-L21 BK-18 605-L4 YL-16 605-L138 YL-16 7 605-R17 YL-18 J764-R5 BR-18 6 COMMON
G 16 7 FUSE 3 3 FRONT WIPER 126-K110 RD-16 J764-E136 BR-16 G725-E241 GN-16 124-E67 GN-14 49 124-L104 GN-14 606-L5 GY-16 606-L139 GY-16 8 606-R18 GY-18 G
17
18
10A
FUSE 4
118-K80 GY-16
SEC STEER (MAN)
200-K51 BK-16 H45
126-K110 RD-16 K-C11 E-C9
TWISTED
PAIR
K742-E121 OR-16
M996-E76 PK-16
G708-E104 GY-16
H421-E125 GN-18
515-E69 GY-14
993-E91 BR-18
50
51
515-L105 GY-14
993-L135 BR-18 CONN 25
BR BROWN
8 4 7X6222 9X0145 R-C3 WIPE WASH TURN SW FUEL INJ SOL 3
19 CA-C3 10A 136-K41 GN-16 126-K110 RD-16 M997-E77 PU-16 H805-E144 BR-18 610-E13 OR-16 52 610-L130 OR-16 611-L11 PU-18 118-R19 GY-16 118-R23 GY-16 1698674 213-8477 A703-N6 BR-16 A704-N10 GN-16 FUEL INJ SOL 4 OPTIONAL
ECM LOCATION 0 20 202-E145 BK-16 202-K1 BK-16 1 202-E148 BK-16 592-E116 BU-16 J764-E87 BR-18 53 201-L125 BK-18 H28 605-L112 YL-18 118-R16 GY-18 191-3005 L984-N7 OR-16 L984-N9 OR-16 191-3005 RETARDER GN GREEN
1552269 CA-C5 CA-C6
21 1552269 1552269 K-C15 115-K42 RD-16 893-K2 GN-16 2 893-E61 GN-18 592-E117 BU-16 592-E101 BU-16 J764-E105 BR-18 54 606-L14 GY-18 115-R3 RD-16 502-R9 OR-18 1 WIPER HIGH SOLENOID
CONNECTIONS
1
2

22 FUSE BLOCK 136-K41 GN-16 892-K3 BR-16 3 892-E128 BR-18 J764-E175 BR-16 55 200-R28 BK-16 102-R12 RD-18 2 FLASH TO PASS BU BLUE

1
2

1
2
23 CA-C2 9W2035 113-K81 OR-16 K742-K109 OR-16 4 K742-E121 OR-16 114-E112 RD-16 J764-E206 BR-16 56 320-R4 OR-18 611-R11 PU-18 3 HI BEAM
GN-18
GN-18

24 1552269 126-K90 RD-14 614-K103 PU-16 5 614-E217 PU-16 121-E114 RD-16 57 H30 H29 324-R20 BU-18 619-R13 GN-18 4 HEADLAMP/TAIL
H16

WH-16
WH-16

WH-16
WH-16
25 5 FUSE 1 1 CMS/SEC STEER (AUTO) 121-K94 RD-16 A513-K104 PK-16 6 A513-E64 PK-16 165-E227 YL-16 102-E11 RD-16 58 501-R10 GN-18 501-R10 GN-18 5 WIPER LOW
SHIFT LEVER SENSOR
1
2

26 M997-E77 PU-16 112-K55 PU-12 10A 113-K81 OR-16 114-K93 RD-16 708-K105 YL-16 7 708-E122 YL-16 102-E193 RD-16 102-E194 RD-16 59 502-R9 OR-18 575-R14 YL-18 6 WIPER PARK
27 6 FUSE 2 2 START AID 165-K83 YL-16 116-K78 BR-16 J764-K100 BR-16 8 J764-E136 BR-16 60 506-R15 PU-18 506-R15 PU-18 7 WASH STEER PRESS SW C-C12 AH-C1
3E-6450 1552267
GN-18
GN-18

28 10A 165-K82 YL-16 165-K88 YL-16 118-K80 GY-16 592-K99 BU-16 9 592-E117 BU-16 108-E126 BU-14 432-E2 PK-16 61 432-L148 PK-16 508-R29 PU-18 118-R16 GY-18 8 WIPER B+ 1552269
AIR SEAT 103-K95 RD-16 H40 M996-K107 PK-16 M996-E76 PK-16 201-E120 BK-16 H17 113-E107 OR-16 113-E196 OR-16 403-E243 GN-16 403-L131 GN-18 509-R30 WH-18 605-R17 YL-18 417-C23 GY-16 1
29 INTERAXLE DIFF LOCK SOL 7 FUSE 3 3 10 62 9 LEFT TURN BK-16 A 727-AH2 GN-16
30 152-8385 RAISE SOL VALVE LOWER SOL VALVE 10A 108-K40 BU-14 173-K92 RD-16 M997-K106 PU-16 11 M997-E77 PU-16 201-E119 BK-16 113-E236 OR-16 447-E210 PK-16 63 447-L132 PK-18 511-R26 BR-18 537-R1 GN-18 10 TURN SW ANTENNA RD-16 B J764-C41 BR-16 200-SH1 BK-16 2
31 192-6443 196-2403 FUSE 4 REAR WIPER 110-K15 GN-16 123-K53 WH-16 374-K98 PK-16 12 374-E137 PK-16 113-E197 OR-16 410-E10 WH-18 64 410-L133 WH-18 512-R27 GN-18 606-R18 GY-18 11 RIGHT TURN 8E-1118 BU-16 C
CONV. OUTPUT SPEED + L910-E79 PK-16
8 4
110-K96 GN-16 110-K85 GN-16 165-K83 YL-16 201-K34 BK-16 201-E119 BK-16 113-E172 OR-16 291-E49 BK-16 291-L119 BK-18 H27 575-R14 YL-18 590-R24 GY-16 200-C50 BK-16 200-C50 BK-16 SEC STER SUP
32
H41
10A
H48
16 65
H35
12 INTER WIPE
CONV. OUTPUT SPEED - 33 L911-E78 YL-18 214-0662 VALVE GP 126-K91 RD-14 290-K32 BK-16 17 290-E50 BK-16 893-E180 GN-18 66 893-L122 GN-18 591-R25 WH-16 727-C19 GN-16 106-8704
CROSSAXLE DIFF LOCK SOL H6 H6
34 152-8385 K-C16 110-K85 GN-16 291-K33 BK-16 15 291-E49 BK-16 201-E179 BK-16 67 201-L88 BK-16 592-R31 BU-16 R-C10 INT WIPER DELAY MOD H1 H420-C20 PU-18
35 113-E236 OR-16 321-E188 BR-16 FUSE BLOCK 124-K35 GN-14 13 124-E75 GN-14 118-E102 GY-16 118-E108 GY-16 892-E127 BR-18 68 892-L121 BR-18 602-R2 WH-16 1698669 163-6088 C-C9 START RELAY
HOLD TOGGLE SWITCH 36 708-E122 YL-16 126-E115 RD-14 728-E192 BU-16 9W2035 108-K40 BU-14 150-K60 RD-14 14 150-E160 RD-14 118-E109 GY-16 118-E169 GY-16 113-E196 OR-16 69 113-L87 OR-18 619-R13 GN-18 591-R25 WH-16 A BK-16 GROUND 1552269 118-3534
SEC. STEER PRESS. SW. 37 417-E132 GY-16 202-E145 BK-16 H805-E178 BR-16 200-K51 BK-16 H49 102-K36 RD-16 18 102-E11 RD-16 290-E50 BK-16 70 290-L120 BK-18 A513-R32 PK-16 118-R23 GY-16 B RD-16 +BATTERY E789-C26 PU-16 1 BK-18

CBL-HH1 BK-00
CROSSLOCK SEL. SWITCH 369-E140 PU-16 202-E151 BK-16 E790-E214 PK-16 H23 CIGAR LIGHTER/EEC 115-K97 RD-16 105-K37 RD-16 105-E85 RD-16 123-E93 WH-16 G706-R6 BU-18 590-R24 GY-16 306-C27 GN-16 CBL-LL1 RD-00
38 5 FUSE 1 1 19 C BU-16 OUT 2 BK-18
39 202-E152 BK-16 113-E236 OR-16 177-K58 RD-12 10A 129-K87 RD-16 165-K88 YL-16 308-K61 YL-16 20 308-E246 YL-16 123-E92 WH-16 123-E26 WH-16 605-L112 YL-18 G707-R8 GN-18 R-C6 RR-1 J764-C41 BR-16 304-C46 WH-10 101-C51 RD-4
ENGINE SPEED SENSOR + E964-E45 WH-18 306-E170 GN-16 126-E115 RD-14 RADIO/DOME 115-K18 RD-16 170-K62 RD-16 170-K62 RD-16 170-E240 RD-16 H17 H28 606-L14 GY-18 G708-R7 GY-18 R-C11 417-C23 GY-16 SECONDARY STEER RELAY
40 6 FUSE 2 2 21
1698673
ENGINE SPEED SENSOR - 41 E963-E44 BK-18 307-E141 OR-16 126-E113 RD-14 115-K50 RD-16 115-K97 RD-16 22 611-L11 PU-18 J764-R5 BR-18 3E3387 ANTENA 109-C48 RD-10 C-C8 RESISTOR A 3E-0154
321-E188 BR-16 202-E145 BK-16
10A
HORN 115-K42 RD-16 123-E93 WH-16 124-E75 GN-14
124-E118 GN-14 124-E67 GN-14
CONN 23 511-R26 BR-18 8 1552269 3E-7842
42 7 FUSE 3 3 23 GY/PU RIGHT SPKR +
CONN 17 E-C7 G S BUS BAR

M996-K107 PK-16
M997-K106 PU-16
A513-K104 PK-16
J764-K100 BR-16
K742-K109 OR-16
43 324-E207 BU-16 202-E148 BK-16 114-K93 RD-16 24 200-E94 BK-16 R-C4 200-L24 BK-18 512-R27 GN-18 7 GY/BK,PU/BK RIGHT SPKR - H2 301-C49 BU-16 1

614-K103 PU-16
708-K105 YL-16
10A
9X0145 124-5814

165-K88 YL-16
PARK BRAKE OP. SW.

115-K97 RD-16
200-K51 BK-16
374-E137 PK-16 368-E225 OR-16 202-E150 BK-16 BACKUP ALARM 200-E95 BK-16 7X6222 200-L64 BK-18 200-R28 BK-16 302-C25 OR-16

592-K99 BU-16
374-K98 PK-16
44 FUSE 4 3 BK GROUND 2
PARK BRAKE PRESS SW. 45 419-E165 YL-16 369-E140 PU-16 202-E151 BK-16
8
10A
4
121-K94 RD-16 H17 200-E96 BK-16 200-E94 BK-16 200-E138 BK-16 118-E108 GY-16 1 118-R19 GY-16 H29 614-L19 PU-18 508-R29 PU-18 2 WH/GN LEFT SPKR + H8 304-C28 WH-16 301-C49 BU-16 MTR BAT
SERV. BRAKE PRESS SW. 46 720-E168 PU-16 374-E137 PK-16 202-E152 BK-16 200-E135 BK-14 200-E95 BK-16 200-E146 BK-16 J764-E105 BR-18 2 J764-R5 BR-18 614-L101 PU-18 509-R30 WH-18 1 WH/BK,BN/BK LEFT SPKR - 200-C76 BK-14 CBL-AA1 RD-00 CBL-AA1 RD-00
TOP DRIVE GEAR SWITCH 47 K742-E121 OR-16 406-E166 PU-16 202-E245 BK-16 K-C17 H18 200-E176 BK-12 200-E96 BK-16 200-E147 BK-18 324-E207 BU-16 3 324-R20 BU-18 614-L140 PU-18 592-R31 BU-16 6 RD + BATTERY (12V) 109-C22 RD-16 MOTOR STARTER
48 417-E132 GY-16 306-E170 GN-16 FUSE BLOCK 201-E232 BK-16 602-E25 WH-16 4 602-R2 WH-16 A513-R32 PK-16 5 YL +B MEMORY
OTG LOW OIL PRESS SW 49 994-E100 GY-16 419-E165 YL-16 307-E141 OR-16 9W2035 201-E181 BK-16 200-E201 BK-14 200-E111 BK-16 115-E83 RD-16 5 115-R3 RD-16 105-L103 RD-16 4 12V RADIO NC 6V-0890 MOTOR
F

CBL-PP1 RD-00
F OTG TEMP SW 50 E737-E205 PU-16 426-E36 BR-18
454-E123 GN-18
324-E207 BU-16
369-E140 PU-16 TAIL/DASH LAMPS
202-E145 BK-16
202-E150 BK-16
200-E190 BK-16 200-E161 BK-16
200-E163 BK-16 G706-E84 BU-16
6
G706-R6 BU-18
124-L104 GN-14
129-L111 RD-16 200-L64 BK-18
NOTE E
200-C66 BK-14
200-C53 BK-14 200-C53 BK-14
200-C66 BK-14
SEC STEER MTR
51 5 FUSE 1 1 200-E135
7 117-3915
XMSN OIL TEMP SENSOR 52 K977-E1 PK-18 498-E80 WH-18 374-E137 PK-16 177-K57 RD-12 10A 103-K95 RD-16 202-E151 BK-16 200-E176 BK-14
BK-12 G707-E99 GN-16 8 G707-R8 GN-18 200-L21 BK-18 200-L21 BK-18 200-C67 BK-14 200-C62 BK-14

CBL-KK1 BK-00
C-C5 H-C5

CBL-AF1 BK-4
XMSN OUTPUT SPEED B+ 53 E906-E42 OR-18 708-E122 YL-16 406-E166 PU-16 6 FUSE 2 2 ECPC TRANS CNTL 126-K91 RD-14 202-E152 BK-16 200-E24 BK-14 200-E162 BK-16 320-E134 OR-18 9 320-R4 OR-18 307-L102 OR-16 200-L142 BK-18 200-C74 BK-16 H-C4
1552269 3E3364 1552269

A513-K104 PK-16

M997-K106 PU-16

J764-K100 BR-16
M996-K107 PK-16
K742-K109 OR-16
XMSN FILTER BYPASS SW 54 426-E36 BR-18 720-E168 PU-16 417-E132 GY-16 126-K89 RD-14 126-K90 RD-14 200-E185 BK-14 506-E88 PU-16 10 506-R15 PU-18 308-L100 YL-16 175-C63 RD-14

614-K103 PU-16
708-K105 YL-16
MAIN BREAKER

200-C59 BK-14
20A

200-K51 BK-16
115-K97 RD-16
592-K99 BU-16

374-K98 PK-16
165-K88 YL-16

200-C42 BK-14
CBL-EE1 BK-00
RETARDER SW LO/MED/HI 55 G706-E84 BU-16 728-E192 BU-16 454-E123 GN-18 7 FUSE 3 3 STOP LAMPS 126-K110 RD-16 200-E201 BK-14 502-E73 OR-16 11 502-R9 OR-18 369-L123 PU-18 200-L145 BK-18 9S-4693 C542-C60 GN-16 1 C452-H7 GN-16 C452-H9 GN-16 1 AUX. HEATED
RETARDER SW HIGH 56 G708-E104 GY-16 705-E32 PK-18 498-E80 WH-18 10A 173-K92 RD-16 604-E174 OR-16 201-E181 BK-16 201-E179 BK-16 619-E212 GN-16 12 619-R13 GN-18 H27 430-L134 BU-18 200-L23 BK-18 200-C61 BK-16 2 200-H10 BK-16 200-H11 BK-16 2 MIRROR-ATCH
RETARDER SW MED. 57 G707-E99 GN-16 751-E37 GN-18 708-E122 YL-16 H22 FUSE 4 H21 605-E195 YL-16 201-E3 BK-16 G708-E104 GY-16 13 G708-R7 GY-18 454-L13 GN-18 200-L22 BK-18 101-C54 RD-14 175-C63 RD-14
8 4
KEY SWITCH 58 113-E236 OR-16 752-E38 YL-18 709-E220 OR-16 10A 170-K62 RD-16 606-E198 GY-16 501-E56 GN-16 14 501-R10 GN-18
H34
498-L10 WH-18 605-L112 YL-18 LH TURN IND LAMP
80 20
HOOD BREAKER CONN 33 CBL-PP2 BK-00
T/C OIL OUT TEMP SNSR 59 406-E166 PU-16 754-E57 BU-18 720-E168 PU-16 614-E228 PU-16 306-E167 GN-16 306-E28 GN-16 575-E106 YL-16 15 575-R14 YL-18 515-L105 GY-14
H25
200-L22 BK-18 107-1983 6T-3644 HEATED MIRROR LH
CONN 37
OTG FILTER BYPASS SW 60 J812-E221 PK-16 755-E58 OR-18 892-E63 BR-18 306-E170 GN-16 591-E110 WH-16 16 591-R25 WH-16 517-L108 BU-14 200-L25 BK-18
61 892-E63 BR-18 893-E62 GN-18 114-E112 RD-16 509-E16 WH-16 17 509-R30 WH-18 993-L135 BR-18 109-C48 RD-10 C-C7 TA-C1 H-C6 110-0017 REMOTE START
XMSN LATCH PRES SNSR 62 J823-E48 YL-18 893-E62 GN-18 121-E114 RD-16 310-E21 PU-16 310-E130 PU-16 512-E4 GN-16 18 512-R27 GN-18 A523-L8 PU-16 H420-L9 PU-18 SEC STEER IND LAMP LINK 109-C22 RD-16 1275483 1275484 1552269 RECEPTACLE
XMSN OUTPUT SPEED A- 63 E901-E40 GN-18 900-E31 PU-18 E789-E81 PU-16 K-C7 165-E227 YL-16 H16 310-E131 PU-16 511-E17 BR-16 19 511-R26 BR-18 A524-L7 BR-16 200-L23 BK-18 107-1983 7V9275
80
109-C72 RD-4 109-C72 RD-4 1 C452-H8 GN-16 1 WH-18 PP-C1
3E5178 ALTERNATOR BREAKER ENG BLOCK GND 4N6579
64 921-E55 WH-18 G706-E84 BU-16 TWISTED 102-E193 RD-16 508-E15 PU-16 20 508-R29 PU-18 A525-L6 GN-16 200-H12 BK-16 2 BK-18 STEER MOTOR GROUND
9S-4693

10
11
12
XMSN OUTPUT SPEED A+

1
2
3
4
5
6
7
8
9
65 E900-E41 WH-18 922-E39 BR-18 G707-E99 GN-16 PAIR CONN 18 RC-C1 H18 113-E172 OR-16 605-E195 YL-16 605-E33 YL-16 200-E111 BK-16 21 200-R28 BK-16 C547-L107 OR-14 CONN 32
XMSN OUTPUT SPEED B- 66 E907-E43 GY-18 994-E100 GY-16 G708-E104 GY-16 113-E197 OR-16 605-E200 YL-16 A513-E64 PK-16 22 A513-R32 PK-16 H420-L9 PU-18 498-L10 WH-18 DIFF LOCK IND LAMP 101-C51 RD-4 FRAME GND 2
1698674 200-C59 BK-14 H7 H7 200-C59 BK-14

M996-RC16 PK-16
K742-RC24 OR-16
A323-E224 GY-16 H421-E125 GN-18 118-E109 GY-16 H421-L12 GN-18 H805-L128 BR-18 107-1983 CBL-JJ1 RD-00

M997-RC11 PU-16
67 23

A513-RC4 PK-16

614-RC12 PU-16
708-RC13 YL-16
374-RC14 PK-16
165-RC15 YL-16
J764-RC9 BR-16
200-RC3 BK-16
115-RC5 RD-16
592-RC6 BU-16
68 A958-E222 WH-16 M996-E76 PK-16 200-E190 BK-16 592-E101 BU-16 24 592-R31 BU-16 J764-L129 BR-18 200-C42 BK-14 200-C42 BK-14
69 E737-E205 PU-16 M997-E77 PU-16 H17 317-E202 YL-16 606-E198 GY-16 606-E34 GY-16 H805-L124 BR-18 H805-L127 BR-18 ALTERNATOR 101-C51 RD-4
70 E900-E41 WH-18 320-E134 OR-18 606-E199 GY-16 109-E53 RD-16 H805-L126 BR-18 611-L11 PU-18 HI BEAM IND LAMP 200-2232 CBL-CC1 RD-00
H21 ENG SHUTDOWN SW
E901-E40 GN-18 J764-E105
J764-E136BR-18
BR-16 322-E191 GY-16 118-E169 GY-16 H805-L128 BR-18 200-L24 BK-18 107-1983 4D-1836 ALT
BATTERY+ (24V) 1 126-E159 RD-16 E906-E42 OR-18 H805-E144 BR-18 H20 500-E74 BR-16 614-E23 PU-16 201-L125 BK-18 109-TA12 RD-4 + R
SWITCH GUARD

202-E151 BK-16
201-E120 BK-16
POS NEG

108-E126 BU-14
201-E119 BK-16

201-E181 BK-16
201-E232 BK-16
2 1

200-E135 BK-14
200-E176 BK-12
202-E152 BK-16
202-E150 BK-16
202-E145 BK-16
BATTERY- (GROUND) 2 202-E155 BK-16 E907-E43 GY-18 J764-E175 BR-16 575-E106 YL-16 614-E229 PU-16 614-E230 PU-16 150-E160 RD-14 200-L17 BK-18 998-C57 BR-16 3E-5169

200-E96 BK-16

200-E95 BK-16

200-E94 BK-16
123-E93 WH-16
3
RET. INDICATOR LAMP 3 454-E123 GN-18 E963-E44 BK-18 J764-E206 BR-16 591-E110 WH-16 614-E217 PU-16 173-E90 RD-16 200-L144 BK-18 H421-L12 GN-18 TRANSMISSION IND LAMP
DIFF LOCK LAMP 4 498-E80 WH-18 E964-E45 WH-18 K742-E121 OR-16 610-E13 OR-16 614-E228 PU-16 177-E82 RD-4 200-L146 BK-18 H805-L127 BR-18 107-1983 BATTERY A
5 G704-E98 YL-16 J764-E87 BR-18 200-RC10 BK-16 H63 614-E229 PU-16 200-E163 BK-16 516-L106 GN-14 H2 F716-C65 WH-16 9X-3404

CBL-AG1 BK-4
6 G705-E164 GN-16 619-E14 GN-16 619-E14 GN-16 619-E212 GN-16 201-E232 BK-16 E971-L110 GN-16 F715-C55 PU-16
7 H11 G706-E84 BU-16 201-E3 BK-16 200-RC3 BK-16 H62 H62 661-E51 GN-18 619-E213 GN-16 203-E171 BK-16 454-L13 GN-18 RETARDER IND LAMP
H39 FRONT LH POS LAMP
8 G707-E99 GN-16 432-E2 PK-16 662-E52 YL-18 207-E30 BK-16 200-L92 BK-18 H805-L126 BR-18 107-1983 T-C10 162-5402
9 G708-E104 GY-16 998-E242 BR-16 AIR SEAT E-C3 663-E231 GY-18 727-E54 GN-18 727-E215 GN-16 302-E29 OR-16 200-L91 BK-18 H25 C-C4 TA-C6 TA-C7 TURBO INLET PRESS SENSOR 1552269
H51

H421-E125 GN-18 G725-E241 GN-16 115-RC5 RD-16 213-3173 1552269 727-E54 GN-18 727-E216 GN-16 304-E27 WH-16 200-L90 BK-16 663-L97 GY-18 3E3388 1552264 3E3370 194-6722
10 +24V INPUT 614-T17 PU-16 1 RD-18
11 J812-E221 PK-16 201-E3 BK-16 +24V IGN 165-RC7 YL-16 + BATTERY 1 108-E126 BU-14 998-E203 BR-16 306-E28 GN-16 663-L95 GY-18 663-L96 GY-18 606-L14 GY-18 RH TURN IND LAMP L730-C52 OR-16 1 L730-TA1 OR-16 A OR-18 +BATTERY 200-T19 BK-16 2 BK-18
DRVRS 17-20 SOL RET 12 H805-E86 BR-16 J823-E48 YL-18 432-E2 PK-16 200-RC25 BK-16 165-RC7 YL-16 SHIFT/HOIST LEVER GROUND 2 200-E96 BK-16 F710-E204 BR-16 892-E63 BR-18 308-E234 YL-16 661-L99 GN-18 H26 200-L25 BK-18 107-1983 993-C56 BR-16 2 993-TA2 BR-16 B YL-18 GROUND
GROUND H9
DRVRS 13-16 SOL RET 13 K952-E237 BR-16 J832-E59 YL-18 G725-E241 GN-16 MEMORY A513-RC4 PK-16 151-0836
E-C5 E-C4
892-E128 BR-18 892-E209 BR-16 310-E131 PU-16 662-L98 YL-18 F400-C58 GY-16 3 F400-TA3 GY-16 C GN-18 SIGNAL
FRONT LH TURN LAMP E
E INTERAXLE DIFFLOCK SOL
14
15
K746-E226 PK-16
A323-E224 GY-16
K742-E121 OR-16
K744-E35 BU-18
998-E242 BR-16
202-E183 BK-18 +12V OUTPUT 592-RC6 BU-16
165-RC15 YL-16
SHIFT LEVER SENSOR 3E3363 1552269 H20 124-E118 GN-14
892-E127 BR-18 317-E202 YL-16
322-E191 GY-16 H30
200-L93 BK-18
200-L94 BK-18 430-L134 BU-18 AIR FILTER IND LAMP
403-C21 GN-16
522-C31 WH-14
4
5
403-TA4 GN-16
522-TA5 WH-14
403-TA4 GN-16 T-C8 3E-6466
193-2543 H3 E971-C32 GN-16 TA-C5 ARC SUPPRESSOR 1552269
BACKUP ALARM RELAY 16 321-E188 BR-16 K746-E226 PK-16 368-E225 OR-16 165-RC22 YL-16 HEATED 1 123-E93 WH-16 200-E185 BK-14 893-E62 GN-18 406-E166 PU-16 993-L135 BR-18 107-1983 6 E971-TA6 GN-14 605-T3 YL-16 605-T3 YL-16 1 RD-18
24V TO 12V CONVERTER L-C11 CMS SPEED TACH 1552269 106-8704
HOIST LOWER SOLENOID 17 G704-E98 YL-16 K952-E237 BR-16 419-E165 YL-16 165-RC17 YL-16 1 +V SEAT 2 200-E95 BK-16 515-E69 GY-14 893-E61 GN-18 893-E208 GN-16 417-E132 GY-16 317-C8 YL-16 7 317-TA7 YL-16 200-T1 BK-14 200-T20 BK-16 2 BK-18
18 K977-E1 PK-18 426-E36 BR-18 134-1346 J764-RC18 BR-16 2 GROUND 516-E70 GN-14 893-E180 GN-18 500-E74 BR-16 1698672 125-6806 200-C74 BK-16 8 200-TA8 BK-16 513-TA13 OR-14 1 ENG BLOCK GND 2
19 L910-E79 PK-16 709-E46 OR-18 M997-RC11 PU-16 3 SIGNAL 517-E71 BU-14 893-E247 GN-18 522-E184 WH-14 E707-L73 GN-18 1 OR-18 +V DISPLAY H26 411-L15 PK-18 CMS ACTION LAMP 522-TA14 WH-14 2
20 L911-E78 YL-18 705-E32 PK-18 4 CAL. 522-E184 WH-14 998-E203 BR-16 998-E97 BR-18 604-E174 OR-16 201-L74 BK-18 2 BK-18 GROUND 201-L125 BK-18 107-1983 AC CLUTCH COIL T-C9 LH LOW BEAM HEADLAMP
21 M996-E76 PK-16 751-E37 GN-18 RC-C7 NOTE: CONN. WEDGE = 173-3051 A524-E66 BR-14 998-E242 BR-16 998-E20 BR-16 605-E200 YL-16 E708-L75 PK-18 3 GN-18 CLOCK CONN 29 TA-C4 134-3998 1552269 171-7213
1552269
H52

BATTERY - (GROUND) 22 202-E154 BK-16 M997-E77 PU-16 752-E38 YL-18 1733047 A525-E65 GN-14 998-E211 BR-16 606-E199 GY-16 C413-L76 YL-18 4 WH-18 DATA 619-T18 GN-16 1 WH-18
BATTERY + (24V) 23 126-E115 RD-14 754-E57 BU-18 201-E120 BK-16 C547-E68 OR-14 126-E113 RD-14 614-E230 PU-16 C414-L77 BU-18 5 YL-18 LOAD L-C19 522-TA9 WH-14 1 BK-18 200-T21 BK-16 2 BK-18
RC-C8 1698671 R
HOLD LAMP 24 H421-E125 GN-18 126-E157 RD-16 126-E113 RD-14 755-E58 OR-18 201-E119 BK-16 A523-E129 PU-14 126-E115 RD-14 619-E213 GN-16 6 BU-18 HARNESS CODE 513-TA10 OR-14 2 BK-18
CROSS AXLE LOCK SOL 25 368-E225 OR-16 126-E158 RD-16 900-E31 PU-18 1698672 201-E232 BK-16 202-E145 BK-16 709-E220 OR-16 308-L100 YL-16 1 YL-16
C OFF LH HIGH BEAM HEADLAMP
126-E159 RD-16 202-E245 BK-16 921-E55 WH-18 H39 J764-RC19 BR-16 1 202-E151 BK-16 201-E181 BK-16 202-E148 BK-16 720-E168 PU-16 T-C2

177-C64 RD-4
26 OR 2 PU-16
S ON TA-C3 AC PRESSURE SW 171-7214
27 202-E153 BK-16 202-E148 BK-16 922-E39 BR-18 708-RC13 YL-16 2 BR YL 202-E145 BK-16 200-E135 BK-14 202-E150 BK-16 727-E216 GN-16 307-L102 OR-16 3 OR-16
B ST 1552269
28 202-E154 BK-16 202-E150 BK-16 994-E100 GY-16 200-RC10 BK-16 3 BU 202-E150 BK-16 200-E176 BK-12 113-E236 OR-16 202-E151 BK-16 892-E209 BR-16 105-L103 RD-16 4 BR-16 1552269 114-5333
126-E156 RD-16 611-T14 PU-16 1 WH-18
29 202-E155 BK-16 202-E183 BK-18 A323-E224 GY-16 614-RC12 PU-16 4 202-E152 BK-16 200-E94 BK-16 201-E3 BK-16 202-E152 BK-16 893-E208 GN-16 200-L94 BK-18 KEY START SW 513-TA11 OR-14 1 BK-18
2 3 200-T22 BK-16 2 BK-18
DIFF LOCK SWITCH 30 324-E207 BU-16 709-E46 OR-18 A958-E222 WH-16 K742-RC24 OR-16 5 WH 202-E245 BK-16 374-E137 PK-16 998-E97 BR-18 661-L99 GN-18 110-7887 E971-TA6 GN-14 2 BK-18 1
31 709-E219 OR-16 709-E220 OR-16 E737-E205 PU-16 J764-RC20 BR-16 6 CAB GROUND 2 306-E170 GN-16 708-E122 YL-16 998-E211 BR-16 200-L93 BK-18
32 E789-E81 PU-16 E789-E235 PU-16 RD 307-E141 OR-16 J764-E136 BR-16 E789-E81 PU-16 662-L98 YL-18 T-T1
33 E789-E189 PU-16 E789-E223 PU-16 E789-E223 PU-16 324-E207 BU-16 K742-E121 OR-16 F710-E204 BR-16 614-L101 PU-18 KEY START BACKLITE 322-T23 GY-16 HORN LOW TONE
34 E789-E235 PU-16 E790-E182 PK-16 J764-E87 BR-18 M996-E76 PK-16 G725-E241 GN-16 L-C12 CMS QUAD GAGE 200-L142 BK-18 110-2079 TA-C2 START AID SOL
1698672 166-6938 1552269 200-T25 BK-16 7T-0969
35 E790-E177 PK-16 E790-E177 PK-16 YL 369-E140 PU-16 M997-E77 PU-16 J764-E175 BR-16 CIGAR LIGHTER 3E-6332 T-T2
ON/OFF DRV1-8 SOL RET 36 E789-E189 PU-16 E790-E186 PK-16 E790-E182 PK-16 BU 406-E166 PU-16 J764-E206 BR-16 E707-L78 GN-18 1 OR-18 +V DISPLAY 129-L111 RD-16 9W-0335 317-TA7 YL-16 2 PU-18 200-T26 BK-16
E790-E214 PK-16 E900-E41 WH-18 417-E132 GY-16 H14 201-L79 BK-18 200-L145 BK-18 200-TA8 BK-16
37 2 BK-18 GROUND 1 WH-18 T-T3
38 H805-E178 BR-16 E901-E40 GN-18 J764-RC9 BR-16 432-E2 PK-16 170-E240 RD-16 403-E142 GN-16 E708-L80 PK-18 3 GN-18 CLOCK 322-T2 GY-16 322-T15 GY-16 HORN HIGH TONE
KEY START 39 307-E141 OR-16 H805-E86 BR-16 H805-E144 BR-18 HOIST POSITION SENSOR 454-E123 GN-18 202-E245 BK-16 430-E124 BU-18 C413-L81 YL-18 4 WH-18 DATA 7T-0970
SEC. STEERING RELAY 40 728-E192 BU-16 J764-E175 BR-16 E906-E42 OR-18 193-2544 498-E80 WH-18 308-E246 YL-16 447-E210 PK-16 C414-L82 BU-18 5 YL-18 LOAD T-T4
RET SOL(725,730 ONLY) K744-E35 BU-18 J764-E218 BR-16 E907-E43 GY-18 165-RC22 YL-16 709-E220 OR-16 403-E243 GN-16 501-E56 GN-16 124-L104 GN-14 B
41 1 +V 6 BU-18 HARNESS CODE
42 J764-E60 BR-16 J764-E136 BR-16 922-E238 BR-18 J764-RC23 BR-16 2 GROUND 720-E168 PU-16 403-E142 GN-16 502-E73 OR-16 T-C4 RH LOW BEAM HEADLAMP
6 614-T6 PU-16 171-7213
43 J764-E47 BR-18 E963-E44 BK-18 M996-RC16 PK-16 3 SIGNAL 892-E63 BR-18 403-E244 GN-16 611-E139 PU-16 515-L105 GY-14 1552269
XMSN LATCHING SOL 44 J832-E59 YL-18 J764-E87 BR-18 E964-E45 WH-18 4 CAL. 893-E62 GN-18 993-E91 BR-18 516-L106 GN-14 5
4 C-C20 T-C7 619-T7 GN-16 619-T24 GN-16 1 WH-18
PARK BRAKE SOLENOID 45 A958-E222 WH-16 J764-E103 BR-16 921-E233 WH-18 TWISTED RC-C5 NOTE: CONN. WEDGE = 173-3049 E789-E81 PU-16 430-E124 BU-18 C542-E239 GN-16 C547-L107 OR-14 FAN SPEED SW 200-T13 BK-16 2 BK-18
BATTERY- (GND) 46 202-E153 BK-16 J764-E105 BR-18
J764-E206 BR-16 G704-E98 YL-16 PAIRS G706-E84 BU-16 447-E210 PK-16 E971-E143 GN-16 200-L92 BK-18 517-L108 BU-14 3 1552264 3E3388
1733047 H21 H21 157-0217
D BATTERY+ (24V) 47 126-E158 RD-16 G705-E164 GN-16
RC-C2
G725-E241 GN-16 501-E56 GN-16 H420-E149 PU-18 663-L97 GY-18 2 200-C67 BK-14 1 200-T1 BK-14
RH HIGH BEAM HEADLAMP
D
48 922-E238 BR-18 J764-E218 BR-16 G707-E99 GN-16 502-E73 OR-16 200-L91 BK-18 E528-L109 PU-18 322-C18 GY-16 2 322-T2 GY-16 T-C5
H20

H13
DRVRS 5-8 SOL RETURN 49 922-E39 BR-18 921-E233 WH-18 K744-E35 BU-18 1698671 G708-E104 GY-16 611-E139 PU-16 L-C14 663-L96 GY-18 605-C36 YL-16 3 605-T3 YL-16 1552269 171-7214
50 J764-E47 BR-18 J764-RC21 BR-16 1 H421-E125 GN-18 892-E248 BR-18 8T9834 H4 611-C38 PU-16 4 611-T4 PU-16
1 2 H19 611-T4 PU-16 611-T16 PU-16 1 WH-18
XMSN SOLENOID 5 51 900-E31 PU-18 J812-E221 PK-16 374-RC14 PK-16 2 J764-E105 BR-18 893-E247 GN-18 201-L88 BK-16 C413-L85 YL-18 35 MODULE DATA 200-C76 BK-14 5 200-T5 BK-14 200-T12 BK-16 2 BK-18

H13
DRVRS 1-4 SOL RETURN 52 921-E55 WH-18 J823-E48 YL-18 4 H805-E144 BR-18 993-E91 BR-18 C414-L86 BU-18 15 MODULE LOAD 614-L140 PU-18 FAN SPEED BACKLITE 614-C39 PU-16 6 614-T6 PU-16
J832-E59 YL-18 H24 J764-E175 BR-16 C542-E239 GN-16 E-C24 E-C25 201-L125 BK-18 E707-L83 GN-18 200-L144 BK-18 110-2079 619-C40 GN-16 619-T7 GN-16
53 3 34 CLUSTER +V 7
FRONT RH TURN LAMP
54 K746-E226 PK-16 PARK BRAKE SWITCH H20 998-E242 BR-16 E971-E143 GN-16 1552273 3E3382 E708-L84 PK-18 25 MODULE CLOCK 606-C37 GY-16 8 606-T8 GY-16
L-C16 T-C1 3E-6466
55 K952-E237 BR-16 H23 218-3662 J764-E206 BR-16 H420-E149 PU-18 170-E240 RD-16 1 113-L136 OR-18 1 + BATTERY A/C SELECT SW 1552269
BATTERY- (GND) 56 202-E152 BK-16 K977-E1 PK-18 126-E113 RD-14 202-E245 BK-16 2 3E7996 125-9257
BATTERY + (24V) 57 126-E157 RD-16 H22 H22 126-E115 RD-14 308-E246 YL-16 3 PRODUCT LINK
21
614-L26 PU-18 H8 CONN 31 606-T8 GY-16 606-T8 GY-16 1 RD-18
H22 29 2 BK-18
HOIST RAISE SOLENOID 58 G705-E164 GN-16 L911-E78 YL-18 202-E148 BK-16 403-E244 GN-16 4 28 614-L19 PU-18 A 200-T5 BK-14 200-T11 BK-16
DRVRS 9-12 SOL RETURN 59 E790-E186 PK-16 L910-E79 PK-16 202-E145 BK-16 893-E247 GN-18 5 H35 27 200-L17 BK-18 B H3
H14 FRONT RH POS LAMP
LOCKUP CLUTCH SOL 60 705-E32 PK-18 202-E150 BK-16 892-E248 BR-18 6 26 1 T-C3 162-5402
61 202-E151 BK-16 201-L89 BK-16 2 E528-L109 PU-18 2
2 H6 1552269
H11 H13 GROUND 3
XMSN SOLENOID 3 62 754-E57 BU-18 202-E152 BK-16 32 E971-L110 GN-16 3
XMSN SOLENOID 4 63 755-E58 OR-18
A323-CA51 GY-16 CONN 14 374-E137 PK-16 291-L119 BK-18 33 4 H1 614-T10 PU-16 1 RD-18

XMSN SOLENOID 1 64 751-E37 GN-18

CONN 1 CONN 2 P-C4 CA-C8 E790-CA49 PK-16
200-CA1 BK-14 1 200-E201 BK-14 708-E122 YL-16 TWISTED 290-L120 BK-18 23
CLEAR
5
200-T9 BK-16 2 BK-18

XMSN SOLENOID 2 65 752-E38 YL-18 AC-C1 J-C1 J-C2 P-C1 3E3388 CONN 7 1552264 G704-CA13 YL-16
604-CA2 OR-16 2 604-E174 OR-16 J764-E136 BR-16 PAIR E735-L118 PU-18 18
SERVICE
6 E-C19
G705-CA47 GN-16 H21 OPERATOR SW INPUT L
66 3E3382 1698672 1698672 3E3382 604-P2 OR-16 1 604-CA2 OR-16 605-CA3 YL-16 3 605-E195 YL-16 K742-E121 OR-16 E-TW2 892-L121 BR-18 14 CAT DATA LINK - E971-L18 GN-18 C 1552273 CBL-CC1 RD-00
368-CA52 OR-16 GND
67 200-AC1 BK-14 1 200-J1 BK-14 1 200-P1 BK-14 605-P3 YL-16 2 605-CA3 YL-16 K952-CA53 BR-16 614-CA4 PU-16 4 614-E228 PU-16 M996-E76 PK-16 893-L122 GN-18 5 CAT DATA LINK + 200-L20 BK-18 D 501-E56 GN-16 4 GN-16 MOTOR H
START RELAY 68 306-E170 GN-16 604-AC7 OR-16 2 604-J2 OR-16 2 604-P2 OR-16 606-P6 GY-16 3 606-CA6 GY-16 612-CA5 GY-16 5 612-E187 GY-16 M997-E77 PU-16 410-L133 WH-18 4 ACTION ALARM 200-L27 BK-18 1
BATTERY- (GND) 69 202-E151 BK-16 605-AC10 YL-16 3 605-J3 YL-16 3 605-P3 YL-16 612-P5 GY-16 4 612-CA5 GY-16 606-CA6 GY-16 6 606-E198 GY-16 40 200-E163 BK-16 2 BK-16 T°
H52 200-CA1 BK-14 TWISTED
L-C18
(Dimensions: 39 inches x 24 inches)

BATTERY + (24V) 70 126-E156 RD-16 614-AC11 PU-16 4 614-J4 PU-16 4 614-P4 PU-16 614-P4 PU-16 5 614-CA4 PU-16 201-CA15 BK-16 419-CA7 YL-16 7 419-E165 YL-16 PAIR 37 CNVT TEMP SENSOR TEMP SELECTOR SW 118-E169 GY-16 6 GY-16
B+ P
E-C2 612-AC14 GY-16 5 612-J5 GY-16 5 612-P5 GY-16 A958-P8 WH-16 6 A958-CA8 WH-16 A958-CA8 WH-16 8 A958-E222 WH-16 17 COOL TEMP SENSOR 1698669 500-E74 BR-16 3 BR-16
419-CA7 YL-16 127-4540
J2 1607690 606-AC18 GY-16 6 606-J6 GY-16 6 606-P6 GY-16 E789-P10 PU-16 7 E789-CA10 PU-16 432-CA14 PK-16
9 432-L148 PK-16 20 BRK OIL PRESS A525-L6 GN-16 A RD-14 502-E73 OR-16 5 OR-16
200-P1 BK-14 8 200-CA1 BK-14 604-CA2 OR-16
10 7 ENG OIL PRESS A524-L7 BR-16 B BK-14
FRONT WIPER MOTOR
605-CA3 YL-16 L911-CA21 YL-18 11 L911-E78 YL-18 447-L132 PK-18 9 FUEL LEVEL SENSOR A523-L8 PU-16 C BR-14
147-7985 HEATED MIRROR RH
AC-C8 J-C3 J-C4 P-C2 P-C3 CA-C10 L910-CA22 PK-18 12 L910-E79 PK-16 24 +8V SENSOR SUPPLY H-C2 110-0017
419-AC20
3E3376
YL-16 1
1698671 1698671
419-J7 YL-16 1
3E3376
419-P7 YL-16
1552264
J764-P9 BR-16 1
3E3388
J764-CA61 BR-16
606-CA6 GY-16
612-CA5 GY-16 E790-CA23 PK-18
921-CA24 WH-18
13
14
E790-E182 PK-16
921-E55 WH-18
OPERATOR STATION 403-L131 GN-18
36
30
HYD OIL LEVEL
ALTERNATOR
STOP LAMP PRESS SW
E-C20 172-7071
1552269
C542-H3 GN-16 1 WH-18
H53 614-CA4 PU-16 K744-E35 BU-18 1552269
A958-AC21 WH-16 2 A958-J8 WH-16 2 A958-P8 WH-16 419-P7 YL-16 2 419-CA7 YL-16 994-CA19 GY-16 K744-CA25 BU-18 15 39 200-H4 BK-16 2 BK-18
J764-AC19 BR-16 3 J764-J9 BR-16 3 J764-P9 BR-16 201-P14 BK-16 5 201-CA15 BK-16 A958-CA8 WH-16 922-CA26 BR-18 16 922-E39 BR-18 38 TRANS FILTER 173-E90 RD-16 1 BK-18
E789-AC22 PU-16 4 E789-J10 PU-16 4 E789-P10 PU-16 432-P15 PK-16 6 432-CA14 PK-16 E737-CA18 PU-16 705-CA27 PK-18 17 705-E32 PK-18 411-L15 PK-18 13 ACTION LAMP 614-L141 PU-18 TEMP SEL BACKLITE 604-E174 OR-16 2 BK-18
J812-P17 PK-16 J812-CA20 PK-16 426-CA28 BR-18 18 426-E36 BR-18 H19 200-L146 BK-18 110-2079
C CONN 3 CONN 4
3
E789-CA10 PU-16
202-CA29 BK-18 202-E183 BK-18
19
C
RENR3489-04

HITCH J764-P20 BR-16 4 J764-CA62 BR-16 J764-CA61 BR-16

19 11
994-P19 GY-16 7 994-CA19 GY-16 J764-CA62 BR-16 J764-CA9 BR-16 709-CA30 OR-18 20 709-E46 OR-18 201-L72 BK-18 10 L-C32

C542-H6 GN-16
E737-P18 PU-16 8 E737-CA18 PU-16 J764-CA31 BR-18 21 J764-E47 BR-18 8 3E7996 SYMBOL DESCRIPTION

200-H5 BK-16
J812-CA20 PK-16 SERVICE BRAKE PRESS SW
K977-CA32 PK-18 22 K977-E1 PK-18 275-L71 BK-18 6 HARNESS CODE 5
J832-CA33 YL-18 J832-E59 YL-18 274-L70 BK-18 614-L115 PU-18
614-L26 PU-18 E-C21 172-7071
CONN 6 23 16 HARNESS CODE 4 A
1552269
NOTE B CONN 13 751-CA34 GN-18 24 751-E37 GN-18 H23 273-L69 BK-18 22 HARNESS CODE 3 200-L27 BK-18 B CONN 36 CIRCUIT CONNECTED
NOTE B E789-CA35 PU-18 25 E789-E235 PU-16 272-L68 BK-18 12 HARNESS CODE 2 200-L113 BK-18 1 J764-E175 BR-16 1 BK-18
U-C3 E900-CA36 WH-18 26 E900-E41 WH-18 271-L67 BK-18 3 HARNESS CODE 1 J764-L129 BR-18 2
2
720-E168 PU-16 2 BK-18 C-C19 C-C21
AC-C9 XMSN T/C OUTPUT SPD SNSR 1552269 U-C1 CA-C7 3 1552269 3E3364 H-C3
8N1513 8N1514 E901-CA37 GN-18 27 E901-E40 GN-18 270-L66 BK-18 31 HARNESS CODE 0 369-L123
113-L136 PU-18
OR-18 3
1552267 189-5746 BK-18 1 L911-U3 YL-18 E906-CA38 OR-18 28 E906-E42 OR-18 4 C542-C71 GN-16 1 C542-H1 GN-16 1552269 CIRCUIT NOT CONNECTED
1 CAT MON SYS 5
BK-16 A J764-AC19 BR-16 WH-18 2 L910-U4 PK-18
2
921-CA17 WH-18 29 921-E233 WH-18 Relay Panel 160-6567 113-L87 OR-18 5
6
200-C73 BK-16 2 200-H2 BK-16 1 AUX. HEATED
RD-16 B 419-AC20 YL-16 922-CA48 BR-18 30 922-E238 BR-18 L-C15 X-C1 730 ONLY A324-L114 PK-18 6 150-C11 RD-14 H-C1 2 MIRROR-ATCH ELECTRICAL CONNECTION TO
RETARDER SOL U-C4 L911-U3 YL-18 3 L911-CA21 YL-18 CA TW4 3E3387 1698673 H5
BU-16 C TWISTED PAIR 752-CA40 YL-18 31 752-E38 YL-18 A324-L114 PK-18 C 308-C14 YL-16 3E3364 MACHINE STRUCTURE
173-2056 1552269 L910-U4 PK-18 4 L910-CA22 PK-18 754-CA41 BU-18 32 754-E57 BU-18 270-L66 BK-18 1 XA-C1 200-L113 BK-18 D 310-C6 PU-16 C-C18 T/C TEMP SNSR
PARK BRAKE PRESS SW E790-U5 PK-18 5 E790-CA23 PK-18 H24 201-X1 BK-18 1698673 H1 1552267
213-6947 1 K744-U7 BU-18 755-CA42 OR-18 33 755-E58 OR-18 271-L67 BK-18 2 200-L116 BK-18 430-C12 BU-18 118-7226 INTERNAL ELECTRICAL CONNECTION

113-L136 OR-18
H53 SEC STEER RELAY BACKUP ALARM RELAY INT WIPER RELAY HORN RELAY HEADLAMP RELAY START AID RELAY

614-L115 PU-18
921-U6 WH-18 921-CA24 WH-18

614-L141 PU-18
6
2 E790-U5 PK-18 900-CA43 PU-18 34 900-E31 PU-18 272-L68 BK-18 3 1 201-XA1 BK-18 892-C10 BR-16 709-C35 OR-16 A RD-18 +V

200-L116 BK-18
411-L15 PK-18
K744-U7 BU-18 7 K744-CA25 BU-18 3E-5239 3E-5239 3E-5239 3E-5239 3E-5239 3E-5239 201-X2 BK-18 TO SURFACE OF COMPONENT

113-L87 OR-18
J823-CA44 YL-18 35 J823-E48 YL-18 273-L69 BK-18 4 2
CROSS AXLE LOCK SW 893-C9 GN-16 J764-C70 BR-16 B BK-18 GROUND
AC-C7 922-U8 BR-18 8 922-CA26 BR-18 J764-CA9 BR-16 36 J764-E218 BR-16 274-L70 BK-18 5 3 201-XA2 BK-18 993-C13 BR-18 406-C34 PU-16 C SIGNAL
FILTER BYPASS SW U-C17 170-1330 YL-18

87a

87a

87a

87a

87a

87a
1552269 705-U9 PK-18 9 705-CA27 PK-18 E789-CA10 PU-16 E789-E223 PU-16 275-L71 BK-18 201-X3
201-X4BK-18
164-7577 37 6 4
1552269 426-U10 BR-18 426-CA28 BR-18 BK-18 CONNECTOR

30

30

30

30

30

30
10

87

87

87

87

87

87
BK-18 1 A958-AC21 WH-16 E964-CA45 WH-18 38 E964-E45 WH-18 201-L72 BK-18 7 5 201-XA3 BK-18 F710-C4 BR-16
426-U10 BR-18 202-U11 BK-18 11 202-CA29 BK-18 TWISTED E963-CA46 BK-18 E963-E44 BK-18
BK-18 2 E789-AC22 PU-16 BK-18 1 39 8 6 201-XA4 BK-18 118-E169 GY-16 A700-C3 OR-18 FUEL LEVEL SENDER
709-U12 OR-18 709-CA30 OR-18
86

86

86

86

86

86
85

85

85

85

85

85
12 201-XA5 BK-18 A-C2
BK-18 2 202-U11 BK-18 432-CA14 PK-16 40 432-E2 PK-16 7 173-E90 RD-16 998-C16 BR-16 192-4315 H#
J764-U13 BR-18 13 J764-CA31 BR-18 1552269 CIRCUIT GROUPING DESIGNATION
PARK BRAKE SOL 201-CA15 BK-16 41 201-E3 BK-16 CONN 26 8 200-E163 BK-16 F702-C1 GN-18

87A
K977-U14 PK-18 K977-CA32 PK-18
30
85
86
87

30
85
86
87

30
85
86
87

30
85
86
87

30
85
86
87

30
85
86
87
14
152-8340 E907-CA39 GY-18 42 E907-E43 GY-18 500-E74 BR-16 G834-C69 PU-16 447-A1 PK-16 1 PK-18
LOCK UP CLUTCH SOL U-C5 J832-U15 YL-18 15 J832-CA33 YL-18 43 AE-C4 AE-C5 AE-C6 AE-C7 AE-C8 AE-C9 501-E56 GN-16 G835-C75 OR-16 201-A5 BK-16 2 BK-18
160-8408 1552269 751-U16 GN-18 16 751-CA34 GN-18 44 9X1054 9X1054 3E5519 9X1054 9X1054 9X1054 502-E73 OR-16 727-C19 GN-16 H6 ATCH WIRE, CABLE, COMPONENT
G835-P13 OR-16
G834-P16 PU-16

102-AE28 RD-14
E789-U17 PU-18 E789-CA35 PU-18

RD-16
RD-16
17

998-AE32 BR-16
705-U9 PK-18 CA TW3
E790-AE4 PK-16

BR-16

591-AE10 WH-16
200-AE11 BK-16
500-AE13 BR-16

OR-16
GY-16

610-AE27 OR-16
200-AE26 BK-16
619-AE29 GN-14
1 45 CMS OPERATOR SW 604-E174 OR-16 H420-C20 PU-18

F710-AE31 BR-16
L-C17
728-AE3 BU-16
727-AE2 GN-16

RD-16
BR-16
GY-16

575-AE9 YL-16

317-AE30 YL-16

165-AE33 YL-16
E900-U18 WH-18 18 E900-CA36 WH-18

118-AE12 GY-16
921-U38 WH-18 G705-CA47 GN-16 G705-E164 GN-16 112-6171 H10 720-E168 PU-16
113-AE1 OR-16

2 46 3E7996
E901-U19 GN-18 19 E901-CA37 GN-18 PAIRS G704-CA13 YL-16 47 G704-E98 YL-16 614-L115 PU-18 J764-E175 BR-16 317-C8 YL-16 HOOD LOCKING SW SPLICE
XMSN CLUTCH SOL 1 U-C8 921-U28 WH-18 E906-U20 OR-18 20 E906-CA38 OR-18 E790-CA49 PK-16 48 E790-E177 PK-16 614-L141 PU-18 A CONN 28 403-C21 GN-16 A-C3 146-0240
160-8408 E907-U21 GY-18 E907-CA39 GY-18 H3

114-AE15
1552269 CA TW2

114-AE21
21 E-C14 C-C10 1552267
921-U6 WH-18 368-CA52 OR-16 368-E225 OR-16

H805-AE6

320-AE16
322-AE17
49 200-L116 BK-18 B 522-C31 WH-14

121-AE5
321-AE7
612-AE8
1 751-U16 GN-18 22
A323-CA51 GY-16 50 A323-E224 GY-16 1 1275484 1275483 E971-C32 GN-16 175-A7 RD-14 B RD-18 BLADE, SPADE, RING OR SCREW
752-U23 YL-18 23 752-CA40 YL-18 2 1 2
2 921-U40 WH-18 51 K746-E226 PK-16 E735-L118 PU-18 2 177-E82 RD-4 1 177-C64 RD-4 109-C22 RD-16 200-C74 BK-16 A301-A8 WH-18 A BK-18 TERMINAL
754-U24 BU-18 24 754-CA41 BU-18 K952-CA53 BR-16 52 K952-E237 BR-16 201-L117 BK-18 3
3
150-C11 RD-14 A300-A9 GN-18 C WH-18
3
201-P14 BK-16
432-P15 PK-16

XMSNCLUTCH SOL 5 755-U25 OR-18 755-CA42 OR-18

B P-C6 160-8408
U-C12
1552269 900-U26 PU-18
25
26 900-CA43 PU-18
53 G725-E241 GN-16
998-E242 BR-16
4 E-C18
1698670
THROTTLE SENSOR
160-2443
201-C17 BK-16 322-C18 GY-16 B
3E3364
54 5 203-C29 BK-16 605-C36 YL-16 175-A3 RD-14
1 900-U26 PU-18 J823-U27 YL-18 27 J823-CA44 YL-18 994-CA19 GY-16 55 994-E100 GY-16 CONN 21 6 F702-E173 GN-18 A RD-18 +V 207-C30 BK-16 606-C37 GY-16 A-C4
CONN 5 921-U39 WH-18 921-U28 WH-18 28 921-CA17 WH-18 E737-CA18 PU-16 E737-E205 PU-16 H4 1552273
1
2

W-C2
2 56 C 998-E97 BR-18 B BK-18 GROUND 302-C25 OR-16 611-C38 PU-16
922-U29 BR-18 29 922-CA48 BR-18 J812-CA20 PK-16 57 J812-E221 PK-16 E-C11 AE-C1 D A700-E133 OR-18 C YL-18 SIGNAL 304-C28 WH-16 614-C39 PU-16 397-A10 OR-14 1 OR-14 MOTOR LOWER
1552269 XMSN CLUTCH SOL 2 U-C9 E964-U30 WH-18 30 E964-CA45 WH-18 3E5179 1552252 306-C27 GN-16 619-C40 GN-16
CA TW1
58 E-C15 C-C1 A300-A9 GN-18 2 GN-18 LOWER HOOD
160-8408 1552269 E963-U31 BK-18 31 E963-CA46 BK-18 59 612-E187 GY-16 8 612-AE8 GY-16 200-L116 BK-18 9X1343 9X0141 CONN 27 308-C14 YL-16 200-C76 BK-14 200-A6 BK-14 200-A6 BK-14 3 BK-14 GROUND
G835-W2 OR-16
G834-W1 PU-16

REVERSE LAMP B(RH) 1 752-U23 YL-18 32 60 728-E192 BU-16 3 728-AE3 BU-16 614-L141 PU-18 H10 310-C6 PU-16 200-C67 BK-14 398-A11 BU-14 4 BU-14 MOTOR RAISE
172-9973 2 922-U41 BR-18 33 61 E790-E214 PK-16 4 E790-AE4 PK-16 614-L115 PU-18 F702-E173 GN-18 1 F702-C1 GN-18 317-C8 YL-16 175-A12 RD-14 5 RD-14 +28V
AC-C6 34 IDENT PART NO. CHG LOC DESCRIPTION
62 H805-E178 BR-16 6 H805-AE6 BR-16 113-L136 OR-18 TWISTED PAIR 2 322-C18 GY-16 200-C67 BK-14 A301-A8 WH-18 6 WH-18 RAISE HOOD
1552269 XMSN CLUTCH SOL 3 U-C10 35 63 321-E188 BR-16 7 321-AE7 BR-16 411-L15 PK-18 A700-E133 OR-18 3 A700-C3 OR-18 403-C21 GN-16 200-C76 BK-14
WH-18 160-8408 1552269 36 HOOD RELAY CONTROL HARNESS AS.
1 612-AC16 GY-16 64 500-E74 BR-16 1 500-AE13 BR-16 113-L87 OR-18 F710-E204 BR-16 4 F710-C4 BR-16 406-C34 PU-16 200-C74 BK-16
BK-18 2 200-AC4 BK-16 P-C7
1552267
1
2
754-U24 BU-18
922-U42 BR-18 922-U8 BR-18
37 65
66
727-E54 GN-18
121-E114 RD-16
2
5
727-AE2 GN-16
121-AE5 RD-16
OPERATOR STATION 310-E131 PU-16
5
6 310-C6 PU-16
417-C23 GY-16
430-C12 BU-18
109-C22 RD-16
302-C25 OR-16
149-2612 A
AC
173-4006
158-8860
01
01
B-2
C-15
RH CHASSIS
REAR CHASSIS
922-U29 BR-18 67 575-E106 YL-16 9 575-AE9 YL-16 H9 H9 447-E210 PK-16 7 447-C7 PK-16 447-C7 PK-16 304-C28 WH-16 H8 A-C5 HOOD ACTUATOR AS AE 162-0106 03 B-9 RELAY
W-C1 XMSN CLUTCH SOL 4 U-C11 AE-C3 1297164 C 214-5023 00 F-3 LH CHASSIS
68 591-E110 WH-16 10 591-AE10 WH-16 317-E202 YL-16 8 317-C8 YL-16 522-C31 WH-14 306-C27 GN-16 161-4007
A
B
C

1552269 160-8408 1552269 CA-C9 1552273 CA 224-8819 00 C-12 TRANSMISSION

69 E-C16 102-E193 RD-16 11 102-AE28 RD-14 893-E208 GN-16 9 893-C9 GN-16 605-C36 YL-16 417-C23 GY-16 397-A10 OR-14 1 RD
RH STOP TAIL TURN LAMP 9X4391 1030213 E 204-9925 02 F-9 MAIN CAB
BK-16
RD-16
BU-16

755-U25 OR-18
1
2

1 70 118-E109 GY-16 12 118-AE12 GY-16 200-AE25 BK-16 1 GROUND CONTROL BOARD AS WATER VALVE ACTUATOR 892-E209 BR-16 10 892-C10 BR-16 606-C37 GY-16 E789-C26 PU-16
149-5534 2 922-U43 BR-18 H20 614-AE22 PU-16 2 LIGHTS HVAC G-C6 149-8217 G-C5 G-C2 150-E160 RD-14 11 150-C11 RD-14 611-C38 PU-16 F 162-9347 02 H-13 CAB ROOF
AC-C4 9G3676 9G3670 9G3676 149-8195 FA 162-9349 02 H-13 HEADLINER
GN-18
GN-18

XMSN LATCH SOL 113-AE23 OR-16 3 + BATTERY 430-E124 BU-18 12 430-C12 BU-18 614-C39 PU-16 175-C63 RD-14 MOTOR
1552272 U-C7 CONN 20 A-C6 G 157-2500 00 A-6 AIR CONDITIONER
S RD-16 1 604-AC8 OR-16
200-8215 3E3364 WIRE GROUP COLOR DESCRIPTIONS 200-AE11 BK-16
200-AE26 BK-16
662-AE18 YL-16
661-AE19 GN-16
4
5
SPEEDOMETER LAMP
TACHOMETER LAMP
124-G1 GN-14
200-G11 BK-14
1
2
GN-14
BK-14
PK-14
BU-14
1
2
A526-G16
A527-G17
PK-14
BU-14
1
2
PK-18
BU-18
MOTOR
MOTOR
993-E91 BR-18
308-E234 YL-16
13
14
993-C13 BR-18
308-C14 YL-16
619-C40 GN-16
709-C35 OR-16
200-C68 BK-14
J764-C24 BR-16
200-C66 BK-14
J764-C41 BR-16 1297163 H
J
208-4540
174-9971
00
00
X-X
C-15
HEATED MIRRORS
HITCH
T WH-16 2 614-AC12 PU-16 GN-18 1 J832-U15 YL-18 E-C12 AE-C2 663-AE20 GY-16 6 GAGE LAMP A523-G14 PU-14 3 PU-14 YL-14 3 A528-G18 YL-14 3 YL-18 FEEDBACK POT. (+) G725-E241 GN-16 15 727-C19 GN-16 C542-C60 GN-16 398-A11 BU-14 1 BK
606-AC18 GY-16 H51 LOW BRAKE OIL PRESS SW E789-U17 PU-18 GROUND CIRCUIT 1552252 3E5179 A525-G13 GN-14 A529-G19 WH-14 K 204-9926 01 G-11 BREAKER PANEL
T BR-16 3 GN-18 2
CAT MON SYS DIMMER
4 BR-14 WH-14 4 4 WH-18 FEEDBACK POT. WIPER 998-E211 BR-16 16 998-C16 BR-16 L 162-7263 03 F-6 INSTRUMENT PANEL
BK-16 4 200-AC2 BK-16 213-6947 200-E190 BK-16 1 200-AE24 BK-16 A524-G7 BR-14 5 GN-14 5 A530-G20 OR-14 5 OR-18 FEEDBACK POT. (-) 201-E232 BK-16 17 201-C17 BK-16 892-C10 BR-16 200-C73 BK-16 203-A4 BK-16 CBL-CC1 RD-00
20 Page,

HYD FAN SOL OR-14

103-5526 M 171-1108 04 H-2 ENIGNE
1 2

163-3318 U-C14 TWISTED PAIR WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF 113-E172 OR-16 2 113-AE1 OR-16 CONN 24 6 6 6 322-E191 GY-16 18 322-C18 GY-16 893-C9 GN-16 J764-C70 BR-16 207-A2 BK-16 N 4P-9537 07 G-3 FUEL INJECTORS
XMSN OUT SPEED SNSR A 1552269 320-E134 OR-18 3 320-AE16 OR-16 7 7 7 727-E216 GN-16 19 727-C19 GN-16 C542-C33 GN-16 C542-C71 GN-16 P 224-8820 00 C-14 RH CHASSIS
OTG FILTER BYPASS SW WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON 322-E191 GY-16 4 322-AE17 GY-16 E-C13 G-C1 H420-E149 PU-18 20 H420-C20 PU-18 993-C13 BR-18 H5
191-8305 1 E901-U19 GN-18 1552252 3E5179 R 162-9350 03 G-5 FR COMPONENT
116-9846 2 E900-U18 WH-18 114-E112 RD-16 5 114-AE14 RD-16 516-G5 GN-14 403-E142 GN-16 21 403-C21 GN-16 998-C16 BR-16 406-C34 PU-16 RC 162-9348 03 D-11 RH CONSOLE
P-C8 VOLTAGE CONVERTER OUTPUT CIRCUIT 610-E13 OR-16 6 610-AE27 OR-16 124-E118 GN-14 1 124-G1 GN-14 C547-G15 OR-14 109-E53 RD-16 22 109-C22 RD-16 A700-C3 OR-18 709-C35 OR-16
1552269 C-C22 A-C1 T 173-4008 02 D-2 HEADLAMPS
U-C15 TWISTED PAIR 619-E14 GN-16 7 619-AE29 GN-14 515-E69 GY-14 2 515-G2 GY-14 417-E132 GY-16 23 417-C23 GY-16 C542-C33 GN-16 FRAME GROUND TA 174-9970 02 E-3 ALTERNATOR

CBL-GG1 BK-00
BK-18 1 J764-P21 BR-16 XMSN OUT SPEED SNSR B 1552269 STARTING CIRCUIT 614-E229 PU-16 8 614-AE22 PU-16 516-E70 GN-14 3 516-G5 GN-14 J764-E206 BR-16 24 J764-C24 BR-16 E789-C26 PU-16 1552273 3E3382 POS NEG
U 170-8693 05 B-14 ECPC XMSN
BK-18 2 J812-P17 PK-16 191-8305 1 E907-U21 GY-18 113-E197 OR-16 9 113-AE23 OR-16 522-E184 WH-14 4 522-G6 WH-14 517-G12 BU-14 302-E29 OR-16 25 302-C25 OR-16 E971-C32 GN-16 175-C63 RD-14 447-C7 PK-16 1 447-A1 PK-16 W 214-5025 00 B-14 HYD FAN SOL LINK
START AID CIRCUIT 662-E52 YL-18 10 662-AE18 YL-16 A524-E66 BR-14 5 A524-G7 BR-14 E789-E81 PU-16 26 E789-C26 PU-16 F702-C1 GN-18 200-C68 BK-14 207-C30 BK-16 2 207-A2 BK-16 WIRE AS.
A 2 E906-U20 OR-18
661-E51 GN-18 661-AE19 GN-16 200-E185 BK-14 200-G8 BK-14 RESISTOR 306-E28 GN-16 306-C27 GN-16 F710-C4 BR-16 203-C29 BK-16 175-C63 RD-14 175-A3 RD-14 BATTERY B A

CBL-FF1 BK-00
11 6 27 3 AF 105-4728 00 F-2 STARTER ENG GROUND
OTG TEMP SW U-C16 TWISTED PAIR ABL / CHASSIS CONTROL CIRCUIT 663-E231 GY-18 12 663-AE20 GY-16 H19 517-E71 BU-14 7 517-G12 BU-14 125-9740 304-E27 WH-16 28 304-C28 WH-16 207-C30 BK-16 203-C29 BK-16 4 203-A4 BK-16 9X-3404 AG 149-7889 00 E-3 ALTERNATOR GROUND
3E-6449 P-C9 XMSN ENG SPEED SNSR 1552269 200-AE25 BK-16 A525-E65 GN-14 8 A525-G13 GN-14 515-G2 GY-14 515-G3 GY-14 203-E171 BK-16 29 203-C29 BK-16 H420-C20 PU-18 447-C7 PK-16 201-C17 BK-16 5 201-A5 BK-16 AH 200-6844 00 G-2 SEC STER DIODE
1552269 MONITOR CIRCUIT E-C10 AE-C10 A523-E129 PU-14 A523-G14 PU-14 207-E30 BK-16 207-C30 BK-16 J764-C24 BR-16 201-C17 BK-16 200-C68 BK-14 200-A6 BK-14 DISCONNECT SWITCH
193-0421 BK-18 1 E963-U31 BK-18 9 30 6 X 162-7265 02 C-6 CODE PLUG (725)
BK-18 1 E737-P18 PU-16 1552272 3E3376 10 522-E184 WH-14 31 522-C31 WH-14 G834-C69 PU-16 7N-0718 XA 162-7266 02 C-6 CODE PLUG (730)
WH-18 2 E964-U30 WH-18
BK-18 2 J764-P22 BR-16 ENGINE CONTROL CIRCUIT 317-E202 YL-16 1 317-AE30 YL-16 C547-E68 OR-14 11 C547-G15 OR-14 200-G8 BK-14 200-G9 BK-14 E971-E143 GN-16 32 E971-C32 GN-16 G835-C75 OR-16 CONN 30 CABLE AS.
T° J764-P20 BR-16 U-C6 F710-E204 BR-16 2 F710-AE31 BR-16 12
T°
C542-E239 GN-16 33 C542-C33 GN-16 AA 173-1708 01 F-2 STARTER
1552267 HEATER AND AIR CONDITIONER CIRCUIT 165-E227 YL-16 3 165-AE33 YL-16 522-G6 WH-14 406-E166 PU-16 34 406-C34 PU-16 TWISTED PAIR CC 173-1705 01 B-3 BATTERY LINK
+V RD-18 A 709-U32 OR-18 998-E203 BR-16 4 998-AE32 BR-16 TEMPERATURE SW BLOWER MOTOR 709-E220 OR-16 35 709-C35 OR-16 C-TW1 EE 7U-5417 00 F-2 STARTER GROUND
XMSN OIL TEMP SNSR TURN SIGNAL / WIPER WASHER CIRCUIT 3E-5464 G-C11 174-1494 605-E200 YL-16 36 605-C36 YL-16 FF 173-1707 02 A-2 DISCONNECT GROUND
GROUND BK-18 B J764-U33 BR-18 1698668 NOTE A: NORMALLY OPEN BEFORE REFRIGERANT CHARGE
OTG LOW OIL PRESS SW 118-7226 SIGNAL WH-18 C K977-U14 PK-18 CONN 19 606-E199 GY-16 37 606-C37 GY-16 STRAP-MM1 4-GA
NOTE B: CONNECTIONS ARE SEPARATE HARNESS FOR
GG 193-6952 00 A-2 DISCONNECT
3E-7692 CAT DATA LINK 515-G4 GY-14 1 WH/RD-14 MOTOR 611-E139 PU-16 38 611-C38 PU-16 BATTERY HH 173-1706 01 G-2 SEC STER RELAY TO MOTOR
P-C10 U-C13 200-G10 BK-14 2 BK-14 614-E230 PU-16 39 614-C39 PU-16 PILOT MACHINES ONLY(REF.191-5978 & 191-5979) ISOLATOR JJ 173-1709 01 F-2 BATTERY TO BUS BAR
1552269 709-U12 OR-18 NOTE C: NORMALLY CLOSED WHEN DOOR OPEN
3E3370 J764-U13 BR-18 619-E213 GN-16 40 619-C40 GN-16 CAB GROUND FRAME GROUND 2 SWITCH KK 193-6951 00 G-2 SEC STER MOTOR TO GND
BK-18
BK-18
1
2
994-P19 GY-16
J764-P23 BR-16 XMSN LATCH PRESS SNSR
+BATTERY OR-18 A 709-U34 OR-18 OTHER COLOR DESCRIPTIONS P-C11 C-C3
NOTE E: RADIO OPTIONS
3E-6106 (EUROPEAN VERSION - REMOVABLE)
LL
MM
140-8860
7G-1060
00
00
G-2
A-4
SEC STER RELAY TO BUS
CAB TO FRAME GROUND
178-3082
GROUND BK-18 B J764-U35 BR-18 CONN 38 3E3364 1552269 3E-6107 (EUROPEAN VERSION - FIXED) PP 173-2359 01 F-3 START RECEPTACLE
SIGNAL WH-18 C J823-U27 YL-18 HIGHWAYS 173-6532 (AMERICAN VERSION - REMOVABLE) RR 162-7264 01 F-5 RADIO ANTENNA
G835-P13 OR-16 1 G835-C75 OR-16 173-6530 (AMERICAN VERSION - FIXED)
G834-P16 PU-16 2 G834-C69 PU-16

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

THIS SCHEMATIC IS FOR THE 725 AND 730 ARTICULATED TRUCK ELECTRICAL SYSTEM
MEDIA NUMBER: RENR3489-04
SCHEMATIC PART NUMBER: 152-0973, CHANGE: 02, VERSION: -
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.