Component Identifiers (CID¹) Event Codes For ADEM III ECM

Electrical Schematic Symbols And Definitions

Resistor, Sender and Solenoid Specifications
Module Identifier (MID²) Event Code Condition Part No. Component Description Resistance (Ohms)¹ RENR5135-03
Power Train ECS A-C 2 ±5%
E015 High Engine Coolant Temperature Derate September 2006
125-9740 Resistor: Blower Motor Speed B-C 1 ±5%
(MID No. 027) E017 High Engine Coolant Temperature Warning
C-D .36 ±5%
T
CID Component E025 High Inlet Air Temperature Derate 127-4540 Potentiometer: Temperature Selector Switch 0 - 5000 ±10% Pressure Temperature Level Flow Circuit Breaker
0041 Sensor Power Supply Symbol
E027 High Inlet Air Temperature Warning 134-3998 Coil: A/C Clutch 17.6 ± 0.6 Symbol Symbol Symbol Symbol
0144 Backup Alarm Relay E039 Low Engine Oil Pressure Derate 152-8340 Solenoid: Park Break 32.6 ±1.6
0168 Electrical System Voltage Interaxle Diff Lock
E056 High Fuel Temperature Warning 152-8385 Solenoid: 32.6 ±1.6
Crossaxle Diff Lock
0177 Oil Temp Sensor E094 Axle Protection Derate Full 0-3.5 Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
157-8859 Sender: Fuel Level
Empty 92-98
0190 Engine Speed Sensor E100 Low Engine Oil Pressure Warning
Lockup Clutch
The circle indicates that the component has screw terminals and a wire can be disconnected from it.
0248 CAT Data Link 160-8408 Solenoid: 8.7 ±0.4
E190 Engine Overspeed Warning Xmsn Clutch #1 - #6
191-3005 Solenoid: Fuel Injector #1 - #6 1.06 ± 0.53
Normally closed switch that will open with an increase of a specific condition.
0420 Secondary Steering Relay E272 Inlet Air Restriction Warning
192-6443 Solenoid: Raise Valve 5.0 ± 0.3 No circle indicates that the wire cannot be disconnected from the component.
0444 Start Relay
196-2403 Solenoid: Lower Valve 5.0 ± 0.3
0562 CAT Monitoring System 200-8215 Solenoid: Xmsn Latch 32.6 ± 1.0 This indicates that the component has a wire connected to it that is connected to ground.
Machine Codes
0585 Xmsn Out Speed Sensor (A) 3E-6332 Solenoid: Start Aid 6
Sales Model Machine Code
3E-7842 Resistor: Starter 150 ±5%
0590 ADEM III ECM
735 9 ¹ At room temperature unless otherwise noted.
0627 Parking Brake Pressure Switch This indicates that the component does not have a wire connected to ground. It is grounded by
0672 Xmsn T/C Output Speed Sensor being fastened to the machine.
0673 Xmsn Out Speed Sensor (B)
Monitoring System Mode
Mode Of Operation Mode Number
0674 Xmsn Out Speed Sensor (A) Off Machine Switch Specification
Operator Sequence Mode 0
Part No. Function Actuate Deactuate Contact Position
Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
0681 Parking Brake Solenoid
Harness Code 1 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
0702 Shift Lever Sensor 275 to 1750 kPa¹ -
114-5333 A/C Pressure Switch Normally Open²
Numeric Readout 2 (39.9 to 253.8 psi) -
0704 Service Brake Pressure Switch
Service 3 276 ±28kPa 179 kPa
0709 Lockup Clutch Solenoid 116-9846 Filter Bypass Switch Normally Closed
(40 ±4.1 psi) (26 psi) Sender - A component that is used with a temperature or pressure gauge. The sender measures
Tattletale 4 the temperature or pressure. Its resistance changes to give an indication to the gauge of the
0724 Body Raise Solenoid Stop Lamp Pressure Switch 200 ±50 kPa 140 kPa
172-7071 Normally Open temperature or pressure.

735 Articulated Truck

Units 5 Service Brake Pressure Switch (29 psi ±7 psi) (20.3 psi)
T
0725 Body Lower Solenoid
Calibration (Transmission Control) 6 Park Brake Pressure Switch 13800 kPa MAX 12300 ± 345 kPa Normally Open A-B
0739 Diff Lock Indicator Lamp 172-7073
Low Brake Oil Pressure Switch (2002 psi MAX) (1784 psi ±50 psi) Normally Closed A-C

Electrical System
0773 Hoist Position Sensor
-1.1 ± 0.8°C 2.2 ± 0.8°C Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
Monitoring System Operator Modes 3E-5464 Temperature Switch Normally Closed
0826 T/C Temperature Sensor (30 ± 1.4°F) (36 ± 1.4°F) It has a coil that makes an electromagnet when current flows through it. The electromagnet can
0967 Machine Application Operator Mode Number 38 ±3°C 27 °C open or close the switch part of the relay.
3E-6449 OTG Temperature Switch Normally Closed
Service Meter 0 (100.4 ± 37.4°F) (80.6 °F)
0968 Xmsn Indicator Lamp
1200 kPa 700 ±100kPa Contacts A-B (N.O.)
0971 Interaxle Diff Lock Solenoid Odometer 1 3E-6450 Steering Pressure Switch Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
(174.05 psi) (101.5 ±14.5 psi) Contacts A-C (N.C.)
1100 Crossaxle Diff Lock Solenoid Tachometer 2 makes an electromagnet when current flows through it. The electromagnet can open or close
1227 Retarder Lever Position Sensor Scrolling (Diagnostic) 3 3E-6451
Front Brake Temperature Switch
Rear Brake Temperature Switch
107 ± 3°C
(224.6 ± 37.4°F)
93°C
(199.4°F)
Normally Closed AWR1-624 a valve or move a piece of metal that can do work.
1233 Latch Pressure Sensor 113 kPa 70 ±20kPa
3E-7692 OTG Low Oil Pressure Switch Normally Open
1235 Xmsn Latch Solenoid (16.4 psi) (10.2 ±2.9 psi) Harness And Wire Symbols
Wire Description ¹ With increasing pressure the closed condition can be maintained up to 2800 kPa (406 psi), with decreasing pressure the closed condition can be maintained
1248 Retarder Solenoid
Wire Wire
Description
Wire Wire
Description
down to 170 kPa (25 psi).
Harness identification code * Harness identification letter(s) and a
1326 Location Code Incorrect Number Color Number Color ² Contact position at the contacts of the harness connector This example indicates serializing code. The "C" stands for
1401 Xmsn Clutch Solenoid #1 Power Distribution Circuits Accessory Circuits (continued) wire 135 in harness "AG". connector and the number indicates
101 RD Motor (B+) Term A526 PK Water Valve Actuator Motor Wire, Cable, or Harness which connector in the harness.
1402 Xmsn Clutch Solenoid #2
102 RD Headlamp Pwr A527 BU Water Valve Actuator Motor Assembly Identification
1403 Xmsn Clutch Solenoid #3 * * Part Number For
103 RD Flasher A528 YL Water Valve Actuator Pot (+)
C-C4 AG-C3 AG-C4* L-C12*
1404 Xmsn Clutch Solenoid #4 105 RD Keyswitch Pwr A529 WH Water Valve Actuator
130-6795 130-6795 3E-5179 Connector Assembly
108 BU Airseat Pwr A530 OR Water Valve Actuator Pot (-) Related Electrical Service Manuals 111-7898
1405 Xmsn Clutch Solenoid #5 325-A135 PK-14
109 RD Alt Output (+) Term C542 GN Heated Mirror Power Title Form Number 325-A135 PK-14 1
1586 Retarder Indicator Lamp
110 GN Rear Wiper Pwr C547 OR Blower Motor (Med-Low)
Alternator: 185-5294 Denso HDB SENR4130
Caterpillar Monitoring System 112 PU Main Power Relay Output (Switched B+) E528 PU AC Sw to Fan Speed Sw Socket
113 OR CMS/Auto Sec Steer Pwr Lighting Circuits Starting Motor: 6V-5539 Pin Wire Wire Receptacle
(MID No. 030) Gauge Fuse
114 RD Horn Pwr 602 WH Dome Lamp Consist: 6V-5540 (KE) SENR3536 Color
CID Component 115 RD Radio/Domelamp Pwr 604 OR Stop Lamp
0096 Fuel Level Sender
Consist: 6V-5582 (F8) SENR4975 Single Wire Ground Plug
116 BR Rear Floodlamp Pwr 605 YL Turn Lamp (Left)
Consist: 106-8554 (42MT) SENR3581
Connector Circuit Connection 2 200-L32 BK-14
0100 Engine Oil Pressure Sensor 118 GY Front Wiper Pwr 606 GY Turn Lamp (Right)
Number
121 RD Backup Alarm Pwr 610 OR Head/Tail Lamp Sw CAT Monitoring System RENR3403
0110 Engine Coolant Temperature Sensor Identification
123 WH Diff lock/Heated Mirror Pwr 611 PU Head Lamp (Hi Beam)
ADEM III ECM RENR1285 Pin or Socket
0177 Transmission Oil Temperature Sensor 124 GN HVAC Blower Motor Pwr 612 GY Reverse Lamp 105-9344
126 RD Xmsn Control Pwr 614 PU Park/Tail/Dash Lamp Power Train ECS RENR3442 Number
0248 Data Link
129 RD Cigar Lighter Pwr 619 GN Head Lamp (Low Beam) Typical representation of Component
0263 Sensor Power Supply
136 GN Manual Sec Steer Pwr 624 YL Rear Work Lamp 1 a Deutsch connector. The Typical representation of a Part Number
plug contains all sockets 1 Sure-Seal connector. The plug
0271 Action Alarm 150 RD Engine Control Pwr 661 GN Tach Lamp 2 and the receptacle contains 2 and receptacle contain
0324 Action Lamp 165 YL Start Aid Pwr 662 YL Speedo Lamp all pins. both pins and sockets.
170 RD Product Link 663 GY Gage Lamp
0819 Display Data Link
173 RD Stoplamp Pwr Control Circuits
0821 Display Power Supply 175 RD Hood Motor Pwr 705 PK Xmsn Lockup Clutch Solenoid
ADEM III ECM 177 RD Main Breaker Power (Unswitched B+) 708 YL Xmsn Hold Sw
Ground Circuits 709 OR Sensor Pwr
© 2006 Caterpillar Printed in U.S.A.
(MID No. 036) 200 BK Main Chassis Gnd 720 PU Service Brake Sw All Rights Reserved
CID Component 201 BK CMS Gnd 727 GN Secondary Steering Motor Relay Coil
0001 Fuel Injector Solenoid #1 202 BK Xmsn Control Gnd 728 BU Secondary Steering Relay Coil
203 BK Chassis Diagnostic Gnd 751 GN Xmsn Shift Solenoid 1
0002 Fuel Injector Solenoid #2
207 BK Starter Diagnostic Gnd 752 YL Xmsn Shift Solenoid 2
0003 Fuel Injector Solenoid #3 270 BK CMS Ident Code 0 754 BU Xmsn Shift Solenoid 3
0004 Fuel Injector Solenoid #4 271 BK CMS Ident Code 1 755 OR Xmsn Shift Solenoid 4
272 BK CMS Ident Code 2 A700 OR Digital Sensor Pwr (+8V)
0005 Fuel Injector Solenoid #5
273 BK CMS Ident Code 3 A701 GY Fuel Injector 1
0006 Fuel Injector Solenoid #6 Component Location
274 BK CMS Ident Code 4 A702 PU Fuel Injector 2
0041 ECM 8V DC Supply 275 BK CMS Ident Code 5 A703 BR Fuel Injector 3 Schematic Machine Schematic Machine
Component Component
290 BK CMS Service A704 GN Fuel Injector 4 Location Location Location Location
0091 Throttle Sensor
291 BK CMS Clear A705 BU Fuel Injector 5 Actuator - Water Valve B-5 E Sensor - Oil Temp A-13 22
0094 Fuel Pressure Sensor Basic Machine Circuits A706 GY Fuel Injector 6 Alarm - Action H-13 C Sensor - Shift Lever E-11 D

4 color / 20 page (Dimensions: 39" X 24")

0100 Oil Pressure Sensor 301 BU Starter Motor Output A746 PK Turbo Outlet Pressure Sensor 50 Alarm - Backup I-15 53 Sensor - T/C Temp B-2 32
302 OR Starter Resistor to Diagnostic A747 GY Atmospheric Pressure Snst Alternator D-3 27 Sensor - Throttle C-4 B
0110 Engine Coolant Temperature Sensor 9
304 WH Starter Motor Coil E707 GN CMS Cluster +V Connector Location 3 Assembly - Hood Actuator C-2 16 Sensor - Turbo Inlet Pressure F-3 12
0148 CAT Data Link communications 306 GN Start Relay Coil E708 PK CMS Module Clock Battery - A F-2 3 Sensor - Turbo Out Pressure H-1 20
307 OR Key Switch Start E735 PU CMS Operator Sw In
Schematic Machine
0168 Electrical Power Supply Connector Number 52 13 47 Battery - B F-1 3 Sensor - Xmsn Out Speed A A-13 41
308 YL Main Power Relay Coil E737 PU OTG Temp Sw Location Location 30 46 18
0172 Inlet Air Temperature Sensor 54 27 Breaker - ADEM H-11 C Sensor - Xmsn Out Speed B A-13 41
310 PU Start Aid Switch E789 PU Machine On/Off Drvr Returns 1-8 CONN 1 H-15 36 42 45 58 44
0174 Fuel Temperature Sensor Breaker - Alternator D-3 9 Sensor - Xmsn T/C Output Speed C-13 12
317 YL Start Aid Solenoid E790 PK Machine Solenoid Drvr Returns 9-12 CONN 2 H-13 43 56 B Breaker - Blower H-11 C Socket - 12V Power G-11 C
320 OR Horn Relay Coil F702 GN Digital Sensor Pwr 5 4 22 38
0253 Personality Module mismatch CONN 3 ET Conn I-12 C
321 BR Backup Alarm Relay Coil F710 BR Start Aid Relay 8 7 6 Breaker - Headlamp I-11 C Socket - EEC Worklamp H-11 C
0254 ADEM III ECM CONN 4 Diagnostic Conn H-12 C 10 20 Breaker - Hood E-3 9 Solenoid - A/C Clutch Coil D-3 6
322 GY Horn Relay On F715 PU Engine Shutdown (NO) 39
0261 Engine Speed Sensor CONN 5 H-12 C 36 12 41 Breaker - Key I-11 C Solenoid - Crossaxle Diff Lock B-14 42
324 BU Diff lock Foot Switch F716 WH Engine Shutdown (NC) A 11
368 OR Crossaxle Diff lock Solenoid G704 YL Body Raise Solenoid
CONN 6 H-12 C 21 Breaker - Main E-3 9 Solenoid - Demand Fan F-13 42
0262 5 Volt Sensor Supply 53 25 33
369 PU Crossaxle Lock Switch G705 GN Body Lower Solenoid CONN 7 C-12 34 49 Control - ABL Chassis G-15 E Solenoid - Interaxle Diff Lock F-14 42
0267 Engine Shutdown Switch 34 32 14
374 PK Park Brake Switch G706 BU Retarder Solenoid (Low) CONN 8 C-12 35 24 Control - Board As B-6 15 Solenoid - Lock Up Clutch C-13 58
57 35 19
0268 Check Programmable Parameters 397 OR Hood Motor (Lower) G707 GN Retarder Solenoid (Med) CONN 9 C-12 34 48 2 40 37 Control - CMS Dimmer A-8 E Solenoid - Lower Valve G-13 45

RENR5135-03
0273 Turbo Outlet Pressure Sensor 398 BU Hood Motor (Raise) G708 GY Retarder Solenoid (Hi) CONN 10 C-12 35 C D 29 Control - CMS Monitor C-6 A Solenoid - Park Brake C-15 24
43 55 1
A300 GN Hood Relay (Lower) J700 BR Engine Retarder Solenoid (Med/Hi) 16 17 Control - Engine (ADEM III) I-3 4 Solenoid - Raise Valve G-13 44
0274 Atmospheric Pressure Sensor CONN 11 C-12 34
A301 WH Hood Relay (Raise) J701 GN Engine Retarder Solenoid (Low/Hi) 26
Control - Hood Relay F-3 8 Solenoid - Start Aid D-3 8
0275 Turbo Inlet Pressure Sensor A323 GY IAD Actuate Solenoid J702 BK Engine Retarder Solenoid (Common)
CONN 12 C-12 35 59 E 15 28
51 Control - Int Wiper Delay Mod F-5 B Solenoids - Fuel Injector #1 - #6 G-3,4 21
A324 PK Crossaxle Lock Switch Jumper J764 BR Switch/Sensor Return CONN 13 B-12 2
0283 Air Filter Indicator Lamp Converter - 24V to 12V E-12 55 Solenoids - Retarder #1 - #6 G-2 21
Monitoring Circuits K737 BR Engine Retarder Solenoid (Med/Hi) CONN 14 H-10 E
0296 Unable to communicate with Transmission ECM 23 Diode - Secondary Steering Arc Suppressor C-2 26 Solenoids - Xmsn Clutch #1 - #6 B,C-13 45
403 GN Alternator (R) Term K738 GN Engine Retarder Solenoid (Low/Hi) CONN 15 H-10 E
0320 Crankshaft Position Sensor Flasher H-5 B Suppressor - Arc D-3 6
406 PU Torque Converter Temp Sensor K739 BU Engine Retarder Solenoid (Common) CONN 16 G-10 E
Fuse Block G-12 C Switch - A/C Select D-5 A
0342 Camshaft Position Sensor 410 WH CMS Action Alarm K742 OR Top Gear Sw (Up) CONN 17 F-10 C Gage - Cat Monitor Quad D-6 A Switch - AC Pressure C-3 27
411 PK CMS Action Lamp K746 PK IAD Pressure Solenoid
0545 Start Aid Relay CONN 18 C-10 2 Gage - Cat Monitor Speed Tach E-6 A Switch - Battery Isolator E-3 9
417 GY Steering Press Sw L730 OR Analog Sensor Pwr
1076 Hydraulic Fan Solenoid CONN 19 B-10 2 Horn - High Tone D-1 17 Switch - Clear I-10 C
419 YL Park Brake Press Sw 892 BR Cat Data Link (-)
¹ The CID is a diagnostic code that indicates which component is faulty. 426 BR Filter Bypass Sw 893 GN Cat Data Link (+) CONN 20 A-9 E Horn - Low Tone D-1 18 Switch - CMS Operator C-6 A
430 BU Air Filter Indicator Lamp G828 WH Engine Pressure Sensor CONN 21 B-9 E Lamps - Indicator E-5,F-5 A Switch - Crossaxle Lock C-4 A
² The MID is a diagnostic code that indicates which electronic control
432 PK Low Brake Oil Press Sw G829 GN Engine Pressure Sensor Common CONN 22 B-9 E 49 Lever - Shift/Hoist E-11 31 Switch - Diff Lock G-5 A
module diagnosed the fault. 447 PK Fuel Level Sender G833 PK Engine Temp Sensor Common Motor - Blower A-5 28 Switch - Dome Lamp H-5 52
CONN 23 H-8 B 56
454 GN Retarder Indicator Lamp G834 PU Demand Fan Solenoid Motor - Front Washer I-7 30 Switch - Engine Shutdown D-3 9
CONN 24 F-8 B
498 WH Diff lock Indicator Lamp G835 OR Demand Fan Solenoid Motor - Front Wiper C-7 29 Switch - Fan Speed D-5 A
CONN 25 B-7 E
C413 YL CMS Display Data G856 WH Engine TDC Probe (+) 43 Motor - Hood Actuator C-2 16 Switch - Filter Bypass A-13 59
C414 BU CMS Display Load G857 YL Engine TDC Probe (-) CONN 26 G-6 B
Motor - Rear Washer I-7 30 Switch - Front Brake Temperature C-12 5
Failure Mode Identifiers (FMI)¹ F400 GY Turbo Inlet Press Sensor H805 BR Proportional Driver Return CONN 27 Code Plug C-6 B
F421 BU Fuel Temperature Sensor J812 PK OTG Filter Bypass Sw CONN 28 G-4 50
F Motor - Rear Wiper H-14 45 Switch - Hazard Flasher I-5 A
FMI No. Failure Description A Motor - Secondary Steer C-2 26 Switch - Headlamp Tail H-6 A
0 Data valid but above normal operational range. G485 BU CMS Front Brake Temperature Switch J823 YL Xmsn Latching Pressure Sensor CONN 29 E-4 13 C Motor - Starter F-2 10 Switch - Heated Mirror I-5 A
G486 GN CMS Rear Brake Temp Switch J832 YL Xmsn Latch Solenoid 55 D
1 Data valid but below normal operational range. CONN 30 C-4 46 B 29 Relay - Backup Alarm C-9 E Switch - Hood Locking E-3 9
H420 PU Secondary Steering Indicator Lamp 900 PU Xmsn Shift Solenoid 5 47
CONN 31 C-4 46
2 Data erratic, intermittent, or incorrect.
H421 GN Xmsn Hold Indicator Lamp 901 WH Xmsn Clutch Solenoid 6
54 12 21 46 Relay - Headlamp C-8 E Switch - Horn G-5 F
3 Voltage above normal or shorted high. CONN 32 H-3 47 E 33 8 20 Relay - Horn C-8 E Switch - Key Start E-5 A
Accessory Circuits 921 WH Xmsn Solenoid Return 1 28 4 22
4 Voltage below normal or shorted low. CONN 33 TDC Service Probe H-2 8 Relay - INT Wiper C-8 E Switch - Low Brake Oil Pressure A-14 39
500 BR Front Wiper (Park) 922 BR Xmsn Solenoid Return 2 5 41
48 45 23 7 6
5 Current below normal or open circuit. 501 GN Front Wiper (Low) 993 BR Analog Sensor Return CONN 34 Aux. Start Receptacle E-2 9 44 52 30 Relay - Main I-11 C Switch - OTG Filter Bypass B-14 5
57 58 15 50 11 10 14 27
6 Current above normal or grounded circuit. 502 OR Front Wiper (Hi) 994 GY OTG Low Oil Pressure Sw CONN 35 E-2 38 39 2 40 3 Relay - Secondary Steer C-9 E Switch - OTG Low Oil Pressure A-14 5
53 32 13 19 18
503 BR Rear Wiper (Park) 995 BU Coolant Temperature CONN 36 D-2 37 51 9 Relay - Secondary Steer C-2 26 Switch - OTG Temp B-14 5
7 Mechanical system not responding properly. 17
504 YL Rear Wiper (Low) 998 BR Digital Sensor Return CONN 37 B-2 23 36 34 Relay - Start F-3 8 Switch - Park Brake D-11 31
8 Abnormal frequency, pulse width, or period. 59 35 38
505 BU Rear Wiper (Hi) A958 WH Park Brake Solenoid 24 Relay - Start Aid C-7 E Switch - Park Brake Pressure C-15 24
CONN 38 A-2 51
9 Abnormal update. 506 PU Front Washer C967 BU Inlet Air Temperature 16 37 Resistor B-5 Switch - Rear Flood I-6 A
The connectors shown in this chart are for harness to harness connectors. 28
10 Abnormal rate of change. 507 WH Rear Washer C991 PK Fuel Pressure Sensor 25 1
26 Resistor - A F-3 4 Switch - Rear Brake Temperature B-15 25
Connectors that join a harness to a component are generally located at or near the 42
11 Failure mode not identifiable. 508 PU Radio Speaker (Left) E900 WH ECPC Xmsn Output Speed (+) Sender - Fuel Level A-2 Switch - Rear Wiper I-6 A
component. See the Component Location Chart. 23
12 Bad device or component. 509 WH Radio Speaker (Left Common) E901 GN ECPC Xmsn Output Speed (-)
Sensor - Air Temp G-2 9 Switch - Retarder G-5 F
13 Out of calibration. 511 BR Radio Speaker (Right) E906 OR ECPC Xmsn Output Speed Q (+)
Sensor - Atmospheric Pressure H-1 19 Switch - Secondary Steer H-5 A
512 GN Radio Speaker (Right Common) E907 GY ECPC Xmsn Output Speed Q (-)
14 Parameter failures. Sensor - Cam Speed/Timing H-2 6 Switch - Service I-10 C
513 OR AC Press Sw E963 BK Engine Speed/Timing (A-)
15 Parameter failures. Sensor - Coolant Temp G-1 14 Switch - Service Brake Pressure C-7 33
515 GY Blower Motor (Hi) E964 WH Engine Speed/Timing (A+)
16 Parameter not available. 516 GN Blower Motor (Medium) E965 BU Engine Speed/Timing (B-) Sensor - Crank Speed/Timing H-2 54 Switch - Start Aid H-6 A
17 Module not responding. 517 BU Blower Motor (Low) E966 YL Engine Speed/Timing (B+) Sensor - Engine Speed A-13 1 Switch - Steer Pressure B-2 15
18 Sensor supply fault. 522 WH AC Clutch to Thermostat Sw E971 GN AC High Pressure Sw Sensor - Fuel Pressure H-1 7 Switch - Stop Lamp Pressure C-7 33
19 Condition not met. 537 GN Turn Signal Sw K952 BR Solenoid Return 3 Sensor - Fuel Temp G-1 7 Switch - Temp Selector C-5 A
575 YL Wiper Sw (Park) K977 PK ECPC Xmsn Oil Temp Sensor Sensor - Hoist Position D-11 D Switch - Temperature A-5 A
20 Parameter failures.
590 GY Wiper Sw (Inter) L910 PK Torque Converter Output Speed (+) Sensor - Oil Pressure H-1 6 Switch - Wiper/Washer Turn G-5 F
¹The FMI is a diagnostic code that indicates what type of failure has occurred. 591 WH Wiper Delay Module (Gnd) L911 YL Torque Converter Output Speed (-) Machine locations are repeated for components located close together.
592 BU DC/DC Converter Output L983 WH Injector Common 1 & 2 A = Located on dash of cab. D = Located on right side of cab.
A513
A523
PK
PU
DC/DC Converter Memory
Fan Speed (Sw Pos 1)
L984
L985
OR
YL
Injector Common 3 & 4
Injector Common 5 & 6
Machine Harness Connector And Component Locations B = Located behind dash of cab.
C = Located on cab relay panel.
E = Located behind service panels on right side of cab.
F = Located on the steering column.
A524 BR Fan Speed (Sw Pos 2) M996 PK Hoist Lever Position
A525 GN Fan Speed (Sw Pos 3) M997 PU Shift Lever Position
 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
OPERATOR STATION OPERATOR STATION ADEM-III
LH STOP TAIL TURN LAMP REAR WIPER SW 210-0848
149-5535 A-C1 112-6174 HEATED MIRROR SW
1698671 BREAKER L-C8

TURBO IN. PRESS. SNSR

FILTER LAMP

SHUTDOWN-NC

GND LEVEL SHUTDOWN-NO

ROOF 3E7996

RETARDER(LOW/MED/HI)

ATMOSPHERIC PRESSURE

INTAKE AIR TEMP SENS

FUEL PRESSURE SENSOR

INJECTOR COMMON 1 &2

INJECTOR COMMON 3 &4
INJECTOR COMMON 5 &6
PRESSURE SENSOR +5V
PRESS SENSOR COMMON

RETARDER/IAH COMMON
RETARDER SOL MED/HI
RETARDER SOL LOW/HI

COOLANT TEMP SENSOR

TURBO OUTLET PRESS.

S RD-16 1 604-A9 OR-16 200-K46 BK-16 L-C5 L-C2 614-L48 PU-18 A

RETARDER IND. LAMP

TEMP SENSOR COMMON

TDC SERVICE PROBE+

TDC SERVICE PROBE-

INJECTOR 1 HI-SIDE
INJECTOR 2 HI-SIDE
INJECTOR 3 HI-SIDE
INJECTOR 4 HI-SIDE

INJECTOR 5 HI-SIDE
INJECTOR 6 HI-SIDE
H30 1698673 3E3387 H B B

DIGITAL SNSR RETN

FAN SOL
T WH-16 2 614-A13 PU-16 200-L47 BK-18 B

ANALOG SNSR RETN

DIGITAL SNSR PWR

SWITCH

FUEL TEMP SENSOR

T BR-16 3 605-A10 YL-16 K-C10 308-K47 YL-16 110-L28 GN-16 1 RD-16 200-L16 BK-18 1

ANALOG SNSR PWR

CAT DATA LINK +

CAT DATA LINK -

RELAY

THROTTLE SENSOR
3E3363 E-C22 FRONT WASHER MOTOR 2

RETARDER (MED)
BK-16 4 200-A6 BK-16 7T-8891 2 RD-16 123-L50 WH-18 2

DEMAND FAN(-)
RETARDER (HI)
DEMAND FAN(+)
7T5957 3
BK-16 123-L149 WH-18

OIL PRESSURE
1 3 3
K-C5

SWITCHED B+
9W1951 BK-16 2 506-E88 PU-16 1 505-L29 BU-16 4 WH-16 C542-L49 GN-18 4

CRANK S/T+
CRANK S/T-
L

HYDRAULIC
INLET AIR
START AID
START AID
GND LEVEL

+ BATTERY

+ BATTERY

- BATTERY
- BATTERY
H33 112-K56 PU-12 177-K57 RD-12 200-E162 BK-16 2 MOTOR 504-L30 YL-16 5 YL-16 P W C542-L143 GN-18 5

CAM S/T+
CAM S/T-
LEFT SPEAKER
CONN 3 A 126-K110 RD-16 177-K58 RD-12 506-E88 PU-16 503-L31 BR-16 6 BU-16 6

UNUSED
UNUSED
+ 508-FA7 PU-18 B 202-K1 BK-16 H31 112-K55 PU-12 177-K4 RD-4 SERVICE SWITCH 507-L65 WH-16 7 BR-16 C542-L143 GN-18 C
LH REVERSE LAMP 124-6046 - 509-FA8 WH-18 C 112-K31 PU-16 177-K20 RD-16 103-E22 RD-16 8 200-L16 BK-18 D
6T-6066

H35
ET
I 172-9973 D 893-K2 GN-16 112-K43 PU-14 105-E85 RD-16 I
A-C2
1552269 BEACON
CONNECTOR E
F
892-K3 BR-16 MAIN RLY
167-0138
290-K32 BK-16
103-E22 RD-16
109-E53 RD-16
110-E18 GN-16 L-C4
REAR FLOOD SW
123-5849 HAZARD FLASHER SW
J1 J2
H51 3E7996 M-C1

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70

10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
WH-18 1 612-A17 GY-16 G 109-E53 RD-16 115-E83 RD-16 155-2703 C-C2 1607690

201-K45 BK-16
BK-18 2 200-A5 BK-16 H TWISTED PAIR 177-K6 RD-14 201-K34 BK-16 110-E18 GN-16 116-E12 BR-16 614-L51 PU-18 A L-C9 1607689
F-C7 F-C3 J
10A
113-E107 OR-16 129-E72 RD-16 200-L64 BK-18 B 3E7996

A705-M24 BU-18
A706-M25 GY-18
L730-C52 OR-16
993-C112 BR-18
998-C109 BR-16

F400-C58 GY-16

F716-C65 WH-16

G706-C45 BU-16

F715-C55 PU-16
G708-C47 GY-16

150-C111 RD-14

G707-C46 GN-16
150-C110 RD-14

J702-M40 GY-18

F421-M12 YL-18

PK-18

E964-M22 WH-18
3E3364

J701-M41 GN-18

GY-18
PU-18
BR-18
GN-18

L983-M19 WH-18
L984-M20 OR-18
L985-M21 YL-18
1552269

BU-18

E963-M23 BK-18

E966-M26 YL-18
E965-M27 BU-18
KEY BREAKER 177-K7 RD-14 115-E83 RD-16 136-E19 GN-16 200-L53 BK-18

454-C118 GN-18
1

G834-C41 PU-16

G835-C42 OR-16

200-C5 BK-14
F702-C1 GN-18

892-C10 BR-16

430-C12 BU-18
F710-C4 BR-16

200-C59 BK-14

A700-C3 OR-18

G828-M1 WH-18
G829-M2 GN-18
N944-M3 PU-18

A747-M5 GY-18
C991-M6 PK-18
G833-M7 PK-18

G856-M8 WH-18
J700-M4 BR-18

G857-M9 YL-18
994-M10 GY-18

995-M11 BU-18
412-M39 BU-18
2

308-C14 YL-16
H39
6T-3642 15A

893-C9 GN-16

310-C6 PU-16
1 116-F18 BR-16 HEADLAMP BREAKER 116-E12 BR-16 150-E160 RD-14 REAR WASHER PUMP 2
3
A
2 200-F3 BK-16 K-C6 118-E102 GY-16 170-E249 RD-16 E-C23 116-L32 BR-16 3 B
605-A10 YL-16 3T0204 3T-2662 7T5957 7T-8891 1
123-E92 WH-16 177-E82 RD-4 624-L33 YL-16 4 1
200-A5 BK-16

612-A15 GY-16 2

A746-M18
A701-M14
A702-M15
A703-M16
A704-M17
C967-M13
200-A6 BK-16

1 177-K20 RD-16 126-E113 RD-14 201-E232 BK-16 507-E89 WH-16 1 5 537-L44 GN-18 2
612-A16 GY-16

612-A18 GY-16
604-A9 OR-16

3
2 302-K21 OR-16 CLEAR SWITCH 126-E115 RD-14 202-E245 BK-16 200-E161 BK-16 2 MOTOR 6 605-L43 YL-18 3
REAR WORK LAMP CONN 4 3 203-K22 BK-16 6T-6066 129-E72 RD-16 203-E171 BK-16 C 537-L44 GN-18 4
4
133-6335 F-C5 4 304-K23 WH-16 102-K36 RD-16 136-E19 GN-16 207-E30 BK-16 D
H50 537-L2 GN-18 5
5
1552269 5 105-K24 RD-16 105-K37 RD-16 H40 291-K33 BK-16 173-E90 RD-16 290-E50 BK-16 606-L42 GY-18 6
6
WH-18 1 624-F17 YL-16 K-C3 DIAGNOSTIC 6 306-K25 GN-16 308-K61 YL-16 CONN 14 177-E82 RD-4 291-E49 BK-16 HEADLAMP TAIL SW 614-L48 PU-18 C
BACKUP ALARM BK-18 2 200-F4 BK-16 F-C1 CONNECTOR 7 207-K26 BK-16 200-E24 BK-14 302-E29 OR-16 3E-9317 614-L46 PU-18 D M-C4 ATM PRESS. SNSR
123-6449 A-C4 1698672 H32
3E3381 8 308-K48 YL-16 K-C2 E-C17 202-E148 BK-16 304-E27 WH-16 CONN 23 L-C6 200-L47 BK-18 3E3370 194-6722

A705-M24 BU-18
A702-M15 PU-18
A704-M17 GN-18
A706-M25 GY-18

J702-M40 GY-18
A701-M14 GY-18

J701-M41 GN-18

E963-M23 BK-18
E964-M22 WH-18
E966-M26 YL-18

F421-M12 YL-18
A703-M16 BR-18

L983-M19 WH-18
L985-M21 YL-18

E965-M27 BU-18
L984-M20 OR-18

C967-M13 BU-18

A746-M18 PK-18
1552269 F-C4 F-C6 1275483 1886210

G856-M8 WH-18
3E7996

N944-M3 PU-18

G828-M1 WH-18
412-M39 BU-18

C991-M6 PK-18
G857-M9 YL-18

G833-M7 PK-18
994-M10 GY-18
A747-M5 GY-18
116-F18 BR-16 116-K12 BR-16 109-K28 RD-16 203-E171 BK-16 307-E141 OR-16 200-L45 BK-18

J700-M4 BR-18
G828-M31 WH-18

995-M11 BU-18

G829-M2 GN-18
614-A13 PU-16

L 1 9 A OR-18 +5V
3E3381 1698672 E-C6 L-C3

H59
BK-18 1 200-A3 BK-16 GND 624-F17 YL-16 2 624-K13 YL-16 10 310-K29 PU-16 177-K59 RD-14 150-K60 RD-14 177-K4 RD-4 1 177-E82 RD-4 207-E30 BK-16 308-E9 YL-16 614-L51 PU-18 G829-M32 GN-18 B YL-18 GROUND
BK-18 2 612-A15 GY-16 H MOTOR GN-16 4 504-F19 YL-16 504-F19 YL-16 3 504-K14 YL-16 11 200-K30 BK-16
15A
302-E29 OR-16 308-E234 YL-16 1030213 9X4391 614-L52 PU-18 A A747-M5 GY-18 C GN-18 SIGNAL
200-F14 BK-16 110-F20 GN-16 110-K15 GN-16 112-K31 PU-16 ADEM-III BREAKER H41 304-E27 WH-16 308-E246 YL-16 110-E18 GN-16 110-L28 GN-16 200-L53 BK-18 SEC STER SW
1 4 12 1 B L-C10

998-C109 BR-16

993-C112 BR-18
1 M-C7 TURBO OUT. PRESS. SNSR

150-C110 RD-14
150-C111 RD-14
612-A16 GY-16 T° BK-16 2 200-F5 BK-16 200-F13 BK-16 503-F21 BR-16 5 503-K16 BR-16 13 200-K30 BK-16 6T-3643 306-E167 GN-16 317-E202 YL-16 504-E7 YL-16 2 504-L30 YL-16 102-L34 RD-16 1 3E7996 155-2702
2 3E3370 194-6724
P B+
GY-16 6 110-F20 GN-16 505-F22 BU-16 6 505-K17 BU-16 14 308-K48 YL-16 308-E9 YL-16 320-E134 OR-18 503-E8 BR-16 3 503-L31 BR-16 102-L147 RD-18 2
3
614-L46 PU-18
200-A2 BK-16 BR-16 3 503-F21 BR-16 200-F13 BK-16 15 308-E234 YL-16 322-E191 GY-16 505-E6 BU-16 4 505-L29 BU-16 610-L130 OR-16 3 614-L60 PU-18 A G828-M1 WH-18 G828-M30 WH-18 A OR-18 +5V

J702-M40 GY-18
CONN 5 4

A701-M14 GY-18
L983-M19 WH-18
A702-M15 PU-18
A703-M16 BR-18
L984-M20 OR-18
A704-M17 GN-18
A705-M24 BU-18
L985-M21 YL-18
A706-M25 GY-18
J701-M41 GN-18
200-A4 BK-16 OR-16 5 505-F22 BU-16 200-F14 BK-16 16 112-K43 PU-14 124-K35 GN-14 CONN 15 310-E21 PU-16 324-E207 BU-16 507-E89 WH-16 5 507-L65 WH-16 614-L52 PU-18 4 200-L45 BK-18 B G829-M34 GN-18 B YL-18 GROUND

J700-M4 BR-18
15A 5
REAR WIPER MOTOR 17 410-E10 WH-18 369-E140 PU-16 624-E5 YL-16 6 624-L33 YL-16 H51 614-L54 PU-18 200-L38 BK-18 1
H59 A746-M18 PK-18 C GN-18 SIGNAL
604-A8 OR-16 18 BLOWER BREAKER K-C1 E-C8 503-E8 BR-16 406-E166 PU-16 116-E12 BR-16 7 116-L32 BR-16 103-L35 RD-16 5
6
136-L41 GN-18 2
2
168-8926 6T-3643 9X0141 9X1343 3 M-C12 M-C2 M-C9 OIL PRESS. SNSR
19 504-E7 YL-16 410-E10 WH-18 102-E194 RD-16 8 102-L34 RD-16 103-L1 RD-16 727-L40 GN-18 3
614-A12 PU-16 CONN 2 F-C2 K-C4 20 508-K8 PU-16 1 508-E15 PU-16 505-E6 BU-16 417-E132 GY-16 998-E20 BR-16 9 998-L36 BR-16 614-L54 PU-18 727-L39 GN-18 4 3E3364 1552269 3E3370 194-6725

454-C118 GN-18

G706-C45 BU-16

G707-C46 GN-16
G708-C47 GY-16
G834-C41 PU-16
G835-C42 OR-16

F715-C55 PU-16
F716-C65 WH-16
F400-C58 GY-16
L730-C52 OR-16
H12 TDC

308-C14 YL-16

200-C59 BK-14
200-C5 BK-14
3E3387 1698673 201-K39 BK-16 509-K9 WH-16 509-E16 WH-16 508-E15 PU-16 432-E2 PK-16 310-E130 PU-16 310-L37 PU-16 614-L55 PU-18 CONN 33 G856-M8 WH-18 G828-M29 WH-18

430-C12 BU-18
892-C10 BR-16
A700-C3 OR-18
F710-C4 BR-16
F702-C1 GN-18
2 10 6 5 1 A OR-18 +5V
SERVICE

310-C6 PU-16

893-C9 GN-16
606-A11 GY-16 FA-C1 F-C8 308-K44 YL-16 511-K10 BR-16 3 511-E17 BR-16 509-E16 WH-16 498-E80 WH-18 103-E22 RD-16 11 103-L35 RD-16 614-L56 PU-18 C 6 2 G857-M9 YL-18 G829-M2 GN-18 G829-M33 GN-18 B YL-18 GROUND
FA-C3 1698673 3E3387 PROBE
1 200-K108 BK-16 200-K46 BK-16 H30 512-K11 GN-16 4 512-E4 GN-16 511-E17 BR-16 614-E23 PU-16 12 614-L62 PU-18 614-L140 PU-18 D C 994-M10 GY-18 C GN-18 SIGNAL
606-A11 GY-16

1552269 H34
605-A10 YL-16

508-FA7 PU-18 1 508-F7 PU-16 2 508-K8 PU-16 308-K47 YL-16 624-K13 YL-16 5 624-E5 YL-16 512-E4 GN-16 503-E8 BR-16 200-E138 BK-16 13 200-L63 BK-16 200-L57 BK-18 200-L38 BK-18 D M-C6
200-A1 BK-14

612-A18 GY-16

M-C13
604-A7 OR-16

115-FA11 RD-16 509-FA8 WH-18 509-F8 WH-16 509-K9 WH-16 308-K61 YL-16 505-K17 BU-16 505-E6 BU-16 602-E25 WH-16 505-E6 BU-16 START AID SW 200-L61 BK-18 CRANKSHFT SP SNSR 1552269 M-C11 FUEL PRESS. SNSR
H
RD-18 A 2 3
H35
6 14
L-C7 1552252 3E3370 H
614-A14 PU-16

WH-18 C 602-FA1 WH-16 511-FA9 BR-18 3 511-F9 BR-16 4 511-K10 BR-16 308-K27 YL-16 177-K57 RD-12 H38 504-K14 YL-16 7 504-E7 YL-16 624-E5 YL-16 504-E7 YL-16 15 3E-7160 189-9266 1 E963-M23 BK-18 194-6725

998-C57 BR-16
3E7996 CONN 32

10
12

9
11
1

2
3

4
5
8
6
200-FA3 BK-16 512-FA10 GN-18 512-F10 GN-16 512-K11 GN-16 177-K58 RD-12 503-K16 BR-16 503-E8 BR-16 892-E128 BR-18 508-E15 PU-16 136-E19 GN-16 136-L41 GN-18 E964-M22 WH-18 G828-M28 WH-18

7
BK-18 B 4 5 8 16 N-C14 2 A OR-18 +5V

998-C16 BR-16
150-C11 RD-14

993-C13 BR-18

993-C56 BR-18
CONN 1 RIGHT DOME LAMP
5 115-F11 RD-16 6 115-K18 RD-16 H33 112-K55 PU-12 410-K38 WH-16 9 410-E10 WH-18 893-E61 GN-18 509-E16 WH-16 727-E215 GN-16 17 727-L40 GN-18 H50
A
FLASHER 3E8969 M-C8
G829-M35 GN-18 B YL-18 GROUND
6 602-F12 WH-16 7 602-K19 WH-16 200-K49 BK-14 112-K56 PU-12 602-K19 WH-16 10 602-E25 WH-16 511-E17 BR-16 123-E26 WH-16 18 123-L50 WH-18 B 103-R21 RD-16 C991-M6 PK-18 C GN-18 SIGNAL
8D-6946

A704-N10 GN-16
A705-N12 BU-16
A706-N15 GY-16
K737-N16 BR-16
K738-N17 GN-16
K739-N18 BU-16
L985-N13 YL-16
AC-C5 A-C5 3E-6389 7 200-F13 BK-16 8 200-K108 BK-16 308-K27 YL-16 11 308-E9 YL-16 512-E4 GN-16 C542-E239 GN-16 19 C542-L49 GN-18 1 CAMSHFT SP SNSR 1552269 TWISTED

A701-N1 GY-16
A702-N4 PU-16
A703-N6 BR-16
L984-N8 OR-16
L983-N3 WH-16
1698672 3E3381 8 CONN 6 410-K38 WH-16 H34 200-K49 BK-14 12 200-E24 BK-14 515-E69 GY-14 611-E139 PU-16 20 611-L3 PU-16 998-L36 BR-16 2
2
537-R22 GN-18 188-7513 1 E965-M27 BU-18 PAIRS
RIGHT SPEAKER 3
200-AC1 BK-14 1 + 511-FA9 BR-18 503-K16 BR-16 H32 304-K23 WH-16 13 304-E27 WH-16 516-E70 GN-14 605-E33 YL-16 21 605-L4 YL-16 H49 310-L37 PU-16 3 537-R1 GN-18 2 E966-M26 YL-18
604-AC7 OR-16 124-6046 - 512-FA10 GN-18 504-K14 YL-16 308-K44 YL-16 308-E234 YL-16 517-E71 BU-14

G833-M7 PK-18
2 14 22 4
605-AC10 YL-16 3 505-K17 BU-16 306-K25 GN-16 15 306-E167 GN-16 522-E184 WH-14 606-E34 GY-16 23 606-L5 GY-16 5 602-R2 WH-16 (STD ENG LAYOUT, M-C15 M-C16
614-AC11 PU-16 4 509-K9 WH-16 207-K26 BK-16 16 207-E30 BK-16 575-E106 YL-16 H420-E149 PU-18 24 H420-L9 PU-18 614-L56 PU-18 6 DOME LAMP SWITCH UNUSED THIS MACH.) 3E3364 1552269
612-AC14 GY-16 5 ACTION ALARM 508-K8 PU-16 K-C14 EEC WORKLMP SOCKET 302-K21 OR-16 17 302-E29 OR-16 591-E110 WH-16 498-E80 WH-18 25 498-L10 WH-18 614-L58 PU-18 C 9D-4068 COOLANT FLOW 1 412-M39 BU-18
K-C12 8C3642

H55
606-AC18 GY-16 6 3E-6328 511-K10 BR-16 9R-7941 310-K29 PU-16 18 310-E21 PU-16 114-E112 RD-16 592-E101 BU-16 H805-E221 BR-18 26 H805-L127 BR-18 200-L57 BK-18 D SWITCH RETURN 2 N944-M3 PU-18
1552269 512-K11 GN-16 109-K28 RD-16 19 109-E53 RD-16 121-E114 RD-16 602-E25 WH-16 H421-E125 GN-18 27 H421-L12 GN-18 200-L59 BK-18 115-R3 RD-16
H24
H12

H56
PK-16 1 410-K38 WH-16 602-K19 WH-16 200-K102 BK-16 1 201-K39 BK-16 20 201-E120 BK-16 165-E227 YL-16 610-E13 OR-16 A525-E65 GN-14 28 A525-L6 GN-16 K739-N22 BU-16
H10 BK-16 2 201-K39 BK-16 624-K13 YL-16 129-K5 RD-16 2 203-K22 BK-16 21 203-E171 BK-16 624-E5 YL-16 454-E123 GN-18 29 454-L13 GN-18 K739-N18 BU-16
129-K87 RD-16 103-K95 RD-16 22 103-E22 RD-16 661-E51 GN-18 430-E124 BU-18 30 430-L134 BU-18 614-L60 PU-18 K738-N17 GN-16

K739-N22 BU-16
H11

ABL2 CHASSIS CONT 200-K54 BK-16 K-C13 12V POWER SOCKET 113-K81 OR-16 23 113-E107 OR-16 663-E231 GY-18 A524-E66 BR-14 31 A524-L7 BR-16 R-C1 HORN SW N-C1 K737-N16 BR-16
E-C1 N-C6

K737-N23 BR-16
161-2355 3T4412 117-2311 123-K53 WH-16 24 123-E92 WH-16 662-E52 YL-18 A523-E129 PU-14 32 A523-L8 PU-16 200-L61 BK-18 1552269 2T-3360 7E6513
1471446 7E6513
H10

K737-N19 BR-16
200-K102 BK-16 114-K93 RD-16 114-E112 RD-16 709-E220 OR-16 H805-E144 BR-18 H805-L128 BR-18

K739-N21 BU-16
25 33 1
1 129-K87 RD-16 200-K54 BK-16 1 116-K78 BR-16 26 116-E12 BR-16 369-E140 PU-16 34 369-L123 PU-18 320-R4 OR-18 2 FUEL INJ SOL 1 A701-N1 GY-16 A706-N15 GY-16 FUEL INJ SOL 6

K739-N20 BK-16
HOIST LEVER SENSOR M996-E76 PK-16 H37 592-K101 BU-16 173-K92 RD-16 173-E90 RD-16 A513-E64 PK-16 129-E72 RD-16 129-L111 RD-16 605-L43 YL-18 191-3005 L983-N2 WH-16 L985-N14 YL-16 191-3005

G833-M37 PK-18
2 2 27 35

K738-N17 GN-16

F421-M12 YL-18
R-C5

G833-M36 PK-18
921-E241 WH-18 200-K51 BK-16 165-K83 YL-16 165-E227 YL-16 A523-E129 PU-14 307-E141 OR-16 307-L102 OR-16 606-L42 GY-18

995-M11 BU-18
PWR FEEDBACK #1 3 28 36
H36 1552269 N-C2 N-C5

E790-CA61 PK-16
PWR FEEDBACK #2 4 922-E242 BR-18 110-K15 GN-16 118-K80 GY-16 29 118-E102 GY-16 108-E126 BU-14 H22 A524-E66 BR-14 105-E85 RD-16 37 105-L103 RD-16 123-L149 WH-18 7E6513 7E6513

G833-M38 PK-18
5 115-K18 RD-16 110-K85 GN-16 30 110-E18 GN-16 201-E120 BK-16 A525-E65 GN-14 J764-E205 BR-18 38 J764-L129 BR-18 537-L2 GN-18 123-R33 WH-18 1 WH-16 DIFF LOCK SWITCH

C967-M13 BU-18
6 116-K12 BR-16 126-K90 RD-14 31 126-E113 RD-14 592-E116 BU-16 C547-E68 OR-14 E971-E143 GN-16 39 E971-L110 GN-16 324-R20 BU-18 2 GN-16 147-1380 FUEL INJ SOL 2 A702-N4 PU-16 A705-N12 BU-16 FUEL INJ SOL 5
CAT DATA LINK - 7 892-E63 BR-18 121-K94 RD-16 32 121-E114 RD-16 E789-E81 PU-16 308-E9 YL-16 40 308-L100 YL-16 L-C1 R-C9 191-3005 L983-N5 WH-16 L985-N11 YL-16 191-3005
CAT DATA LINK + 1698673 3E3387

H37
8 893-E62 GN-18 K-C8 126-K91 RD-14 33 126-E115 RD-14 201-E119 BK-16 F710-E204 BR-16 516-E70 GN-14 41 516-L106 GN-14 R-C2 N-C3
INST GROUND RETURN 9 FUSE BLOCK 136-K41 GN-16 34 136-E19 GN-16 G485-E35 BU-16 517-E71 BU-14 42 517-L108 BU-14 103-L1 RD-16 1 103-R21 RD-16 1698672 N-C4
+5V SENSOR SUPPLY 9W2035 7E6513 7E6513
A323-CA51 GY-16

10 TRANSMISSION 116-K12 BR-16 115-K42 RD-16 35 115-E83 RD-16 G486-E87 GN-16 C547-E68 OR-14 43 C547-L107 OR-14 537-L2 GN-18 2 537-R22 GN-18 1 RETARD SOLS 5&6
K952-CA57 BR-16

+8V SENSOR SUPPLY 11 709-E219 OR-16 115-K18 RD-16 36 G834-E251 PU-16 200-E146 BK-16 44 200-L90 BK-16 3 G707-R8 GN-18 2 MED RETARDER SWITCH FUEL INJ SOL 3 A703-N6 BR-16 A704-N10 GN-16 FUEL INJ SOL 4 163-1553 M-C10
191-3005 M-C3
SENSOR GROUND RETURN 12 J764-E103 BR-16 5 FUSE 1 1 REAR FLOOD/BEACON 116-K78 BR-16 37 G835-E252 OR-16 663-E231 GY-18 45 663-L95 GY-18 102-L147 RD-18 4 102-R12 RD-18 G708-R7 GY-18 3 HI 141-0275 L984-N7 OR-16 L984-N9 OR-16 191-3005 RETARD SOLS 1&2 1552269 1552269
+12V SENSOR SUPPLY 13 112-K56 PU-12 116-K52 BR-16 116-K12 BR-16 110-K15 GN-16 108-K40 BU-14 38 108-E126 BU-14 592-E117 BU-16 592-E101 BU-16 H805-E144 BR-18 661-E51 GN-18 46 661-L99 GN-18 123-L149 WH-18 5 123-R33 WH-18 537-R1 GN-18 G706-R6 BU-18 4 LOW/MED/HI TWISTED 163-1553

614-L101 PU-18
10A
H48

614-L19 PU-18
614-L140 PU-18
C-C7 C-C12

1
2
GROUND PAIR

1
2
14 6 FUSE 2 2 DIFF. LOCK/HEATED MIRROR 129-K5 RD-16 39 129-E72 RD-16 H805-E221 BR-18 662-E52 YL-18 47 662-L98 YL-18 611-L3 PU-16 611-L137 PU-16 6 611-R11 PU-18 102-R12 RD-18 5 RETARD SOLS 3&4 M-C5

200-L93 BK-18
200-L94 BK-18

200-L64 BK-18
200-L24 BK-18

OPERATOR STATION
SPOOL POSITION SENSOR 15 T900-E3 GN-18 123-K53 WH-16 129-K87 RD-16 592-K101 BU-16 40 592-E116 BU-16 H421-E125 GN-18 200-E147 BK-18 48 200-L21 BK-18 605-L4 YL-16 605-L138 YL-16 7 605-R17 YL-18 123-R33 WH-18 J764-998-R5 BR-18 6 COMMON 1552269 3E3363 163-1553 1552269
G
10A
G 16 NOTE: 7 FUSE 3 3 FRONT WIPER J764-E205 BR-18 124-E67 GN-14 49 124-L104 GN-14 8 606-R18 GY-18 605-R17 YL-18 E963-C48 BK-18 1 COMPONENT NOT USED THIS HARNESS
G705-CA63 GN-16

H49
E790-CA62 PK-16

WIPER WASHER TURN SW V-C6 V-C7

1
2
E790-CA64 PK-16
TWISTED

G704-CA60 YL-16

G835-CA66 OR-16
G834-CA67 PU-16
17 FUSES 10A 118-K80 GY-16 200-K51 BK-16 126-K110 RD-16 J764-E206 BR-16 515-E69 GY-14 50 515-L105 GY-14 606-L139 GY-16 606-R18 GY-18 R-C3 E964-C49 WH-18 2 T° T°
18 9W-1442(10A)(14) FUSE 4 SEC STER SW K-C11 E-C9 PAIR 993-E91 BR-18 51 993-L152 BR-18 CONN 26 611-R11 PU-18 1698674 213-8477 1552269 3E3364
8 4 7X6222 9X0145 COOLANT TEMP SNSR
19 9W-1446(20A)(1) 10A 136-K41 GN-16 126-K110 RD-16 102-E11 RD-16 610-E13 OR-16 52 610-L130 OR-16 606-L5 GY-16 118-R16 GY-18 502-R9 OR-18 1WIPER HIGH C542-V9 GN-16 1 WH-18 FUEL TEMP SNSR
ECM LOCATION 0 20 202-E145 BK-16 136-K41 GN-16 202-K1 BK-16 1 202-E148 BK-16 102-E193 RD-16 102-E194 RD-16 53 118-R19 GY-16 118-R23 GY-16 102-R12 RD-18 2FLASH TO PASS 200-V10 BK-16 2 BK-18 T° 130-9811 130-9811
ECM LOCATION 1 K-C15 115-K42 RD-16 H31 893-K2 GN-16 893-E61 GN-18 113-E196 OR-16 611-L11 PU-18 115-R3 RD-16 611-R11 PU-18
21 2 54 3HI BEAM INLET AIR TEMP SNSR
ECM LOCATION 2 22 FUSE BLOCK 892-K3 BR-16 3 892-E128 BR-18 102-E11 RD-16 113-E236 OR-16 55 605-L112 YL-18 200-R28 BK-16 619-R13 GN-18 4HEADLAMP/TAIL HEATED MIRROR LH-ATCH
ECM LOCATION 3 23 9W2035 113-K81 OR-16 K742-K109 OR-16 4 K742-E121 OR-16 105-E85 RD-16 113-E107 OR-16 56 606-L14 GY-18 320-R4 OR-18 501-R10 GN-18 5WIPER LOW C-C5 C-C6 V-C5 110-0017 130-9811
24 126-K90 RD-14 614-K103 PU-16 5 614-E217 PU-16 124-E75 GN-14 113-E197 OR-16 57 324-R20 BU-18 575-R14 YL-18 6WIPER PARK 1552269 3E3363 3E3364
CMS/GEAR SW/SEC STER RELAY 121-K94 RD-16 A513-K104 PK-16 6 A513-E64 PK-16 150-E160 RD-14 113-E172 OR-16 501-R10 GN-18 506-R15 PU-18 C542-C60 GN-16 C542-V7 GN-16
25 5 FUSE 1 1 58 7WASH 1 1
SHIFT LEVER SENSOR 26 M997-E77 PU-16 CA-C12 CA-C13 CA-C14 112-K55 PU-12 10A 113-K81 OR-16 114-K93 RD-16 708-K105 YL-16 7 708-E122 YL-16 170-E249 RD-16 G485-E35 BU-16 59 G485-L151 BU-18 502-R9 OR-18 118-R16 GY-18 8WIPER B+ 200-C61 BK-16 2 2 200-V8 BK-16
START AID 165-K83 YL-16 116-K78 BR-16 J764-K100 BR-16 8 J764-E136 BR-16 290-E50 BK-16 118-E109 GY-16 G486-E87 GN-16 G486-L150 GN-18 H46 506-R15 PU-18 605-R17 YL-18
27 1552269 1552269 1552269 6 FUSE 2 2 60 9LEFT TURN
165-K82 YL-16 165-K88 YL-16 118-K80 GY-16 H36 592-K99 BU-16 592-E117 BU-16 291-E49 BK-16 118-E102 GY-16 118-E108 GY-16 432-E2 PK-16 432-L148 PK-16 508-R29 PU-18 537-R1 GN-18

H47
28 CA-C3 10A 9 61 10TURN SW CONN 28
1
2

1
2

1
2
29 1552269 7 FUSE 3 3 AIR SEAT 103-K95 RD-16 M996-K107 PK-16 10 M996-E76 PK-16 308-E246 YL-16 118-E169 GY-16 403-E142 GN-16 62 403-L131 GN-16 509-R30 WH-18 606-R18 GY-18 11RIGHT TURN

H38
30 10A 108-K40 BU-14 173-K92 RD-16 M997-K106 PU-16 11 M997-E77 PU-16 374-E137 PK-16 447-E210 PK-16 63 447-L132 PK-18 511-R26 BR-18 590-R24 GY-16 12 INTER WIPE ANTENNA
V-C8
GN-18
GN-18

GN-18
GN-18

8E-1118
1
2

31 FUSE 4 REAR WIPER 110-K15 GN-16 123-K53 WH-16 374-K98 PK-16 12 374-E137 PK-16 614-E217 PU-16 123-E92 WH-16 123-E26 WH-16 410-E10 WH-18 64 410-L133 WH-18 512-R27 GN-18
R-C10 INTMED WIPER DELAY MOD

GN-18
GN-18
8 4 1552269
CONV OUTPUT SPEED + 32 L910-E79 PK-16 10A 110-K96 GN-16 110-K85 GN-16 165-K83 YL-16 124-K35 GN-14 13 124-E75 GN-14 708-E122 YL-16 123-E93 WH-16 291-E49 BK-16 65 291-L119 BK-18 605-L112 YL-18 575-R14 YL-18
H41 H45 1698669 163-6088
GN-18
GN-18

CONV OUTPUT SPEED - 33 L911-E78 YL-18 126-K91 RD-14 150-K60 RD-14 14 150-E160 RD-14 893-E180 GN-18 66 893-L122 GN-18 606-L14 GY-18 591-R25 WH-16 C542-V11 GN-16 1 AUX.LH
34 K-C16 110-K85 GN-16 291-K33 BK-16 15 291-E49 BK-16 A513-E64 PK-16 124-E75 GN-14 201-E179 BK-16 67 201-L88 BK-16 611-L11 PU-18 592-R31 BU-16 591-R25 WH-16 A BK-16 GROUND C-C16 200-V12 BK-16 2 MIRROR - ATCH
RAISE SOL VALVE LOWER SOL VALVE FUSE BLOCK H39 201-K34 BK-16 201-E119 BK-16 J764-E136 BR-16 124-E118 GN-14 124-E67 GN-14 892-E127 BR-18 892-L121 BR-18 602-R2 WH-16 118-R23 GY-16 1552273
35 16 68 B RD-16 +BATTERY
HOLD TOGGLE SWITCH 36 708-E122 YL-16 192-6443 196-2403 DEMAND FAN SOL 9W2035 108-K40 BU-14 290-K32 BK-16 17 290-E50 BK-16 M996-E76 PK-16 113-E196 OR-16 69 113-L87 OR-18 619-R13 GN-18 590-R24 GY-16 C BU-16 OUT 397-C80 OR-14 1 OR-14 MOTOR LOWER STARTER
SEC STER PRESS. SW G S
37 417-E132 GY-16 (IAD)INTERAXLE DIFF LOCK SOL 163-3318 200-K51 BK-16 H40 102-K36 RD-16 18 102-E11 RD-16 M997-E77 PU-16 200-E94 BK-16 200-E138 BK-16 290-E50 BK-16 70 290-L120 BK-18 200-L24 BK-18 A513-R32 PK-16 A300-C79 GN-18 2 GN-18 LOWER HOOD HOOD RELAY CONTROL 6V-5539
CROSS LOCK SEL SW 38 369-E140 PU-16 152-8385 189-5772 VALVE GP 5 FUSE 1 1 CIGAR LIGHTER/EEC 115-K97 RD-16 105-K37 RD-16 19 105-E85 RD-16 K742-E121 OR-16 200-E95 BK-16 200-E146 BK-16 200-L64 BK-18 G706-R6 BU-18 200-C68 BK-14 3 BK-14 GROUND 149-2612
HARNESS' 177-K58 RD-12 129-K87 RD-16 165-K88 YL-16 308-K61 YL-16 308-E246 YL-16 200-E96 BK-16 200-E147 BK-18 614-L19 PU-18 G707-R8 GN-18 RR-1 398-C81 BU-14 MTR BAT
39 10A 20 4 BU-14 MOTOR RAISE
ENGINE SPEED SENSOR + 40 E964-E45 WH-18 214-6817 DEMAND FAN 6 FUSE 2 2 RADIO/DOME 115-K18 RD-16 170-K62 RD-16 170-K62 RD-16 21 170-E249 RD-16 614-L101 PU-18 G708-R7 GY-18 R-C6 R-C11 175-C82 RD-14 5 RD-14 +28V C-C8 RESISTOR A
ENGINE SPEED SENSOR - 41 E963-E44 BK-18 321-E188 BR-16 214-6818 DEMAND FAN 10A 115-K50 RD-16 115-K97 RD-16 22 200-E201 BK-14 200-E111 BK-16 CONN 24 614-L140 PU-18 J764-998-R5 BR-18 1698673 3E3387 ANTENNA A301-C78 WH-18 6 WH-18 RAISE HOOD 1552269 3E-7842 MOTOR CBL-AA1 RD-00
42 728-E192 BU-16 H17 7 FUSE 3 3 HORN 115-K42 RD-16 CONN 16 23 200-E190 BK-16 200-E161 BK-16 511-R26 BR-18 8 GY/PU RIGHT SPKR + 302-C25 OR-16
E-C7 R-C4

M997-K106 PU-16
1

M996-K107 PK-16
A513-K104 PK-16
K742-K109 OR-16
614-K103 PU-16

J764-K100 BR-16
E790-E214 PK-16 114-K93 RD-16 200-E135 BK-14 200-E163 BK-16 105-L103 RD-16 512-R27 GN-18 RIGHT SPKR -

200-K51 BK-16
43 24 7 GY/BK,PU/BK

708-K105 YL-16
10A
301-C114 BU-16

115-K97 RD-16
165-K88 YL-16
9X0145 7X6222

592-K99 BU-16
2

374-K98 PK-16
PARK BRAKE OPR SW 44 374-E137 PK-16 H805-E178 BR-16 FUSE 4 BACKUP ALARM 124-L104 GN-14 200-R28 BK-16 3 BK GROUND
PARK BRAKE PRESS. SW 419-E165 YL-16 113-E236 OR-16
8 4
121-K94 RD-16 200-E176 BK-12 118-E108 GY-16 118-R19 GY-16 129-L111 RD-16 508-R29 PU-18 2 H54 301-C114 BU-16
45 10A 1 WH/GN LEFT SPKR +
SERV BRAKE PRESS. SW 46 720-E168 PU-16 126-E113 RD-14 123-E93 WH-16 200-E24 BK-14 200-E162 BK-16 998-E105 BR-18 2 J764-998-R5 BR-18 200-L21 BK-18 509-R30 WH-18 1 WH/BK,BN/BK LEFT SPKR - 200-C68 BK-14
TOP DRIVE GEAR SW 47 K742-E121 OR-16 113-E236 OR-16 126-E115 RD-14 K-C17 200-E94 BK-16 200-E185 BK-14 324-E207 BU-16 3 324-R20 BU-18 307-L102 OR-16 592-R31 BU-16 6 RD + BATTERY (12V) 200-C61 BK-16 200-C61 BK-16
126-E115 RD-14 202-E145 BK-16 FUSE BLOCK 200-E95 BK-16 201-E100 BK-16 602-E25 WH-16 602-R2 WH-16 308-L100 YL-16 A513-R32 PK-16 5 +B MEMORY 200-C66 BK-14

CBL-AF1 BK-00
48 4 YL
OTG LOW OIL PRESS SW 49 994-E238 GY-16 202-E145 BK-16 202-E148 BK-16 9W2035 200-E96 BK-16 201-E181 BK-16 201-E179 BK-16 115-E83 RD-16 5 115-R3 RD-16 369-L123 PU-18 4 12V RADIO NC 200-C74 BK-16 200-C74 BK-16
H23
F OTG TEMP SW 50 E737-E240 PU-16 202-E151 BK-16
202-E152 BK-16
202-E150 BK-16
202-E151 BK-16 TAIL/DASH LAMPS
200-E135 BK-14
200-E176 BK-12 306-E167 GN-16 306-E28 GN-16 G706-E84 BU-16
6
G706-R6 BU-18
430-L134 BU-18
454-L13 GN-18 200-L64 BK-18
NOTE A 304-C28 WH-16 101-T51 RD-4 BUS BAR
124-5814
CBL-AA1 RD-00 F
51 5 FUSE 1 1 7
XMSN OIL TEMP SNSR 52 K977-E1 PK-18 306-E170 GN-16 202-E152 BK-16 177-K57 RD-12 103-K95 RD-16 201-E232 BK-16 306-E170 GN-16 G707-E99 GN-16 8 G707-R8 GN-18 498-L10 WH-18 200-L21 BK-18 C-C9 START RELAY

200-C5 BK-14
10A

200-C59 BK-14
CBL-EE1 BK-00
XMSN OUTPUT SPEED B+ 53 E906-E42 OR-18 307-E141 OR-16 202-E245 BK-16 6 FUSE 2 2 ECPC XMSN CONT 126-K91 RD-14 201-E181 BK-16 320-E134 OR-18 9 320-R4 OR-18 515-L105 GY-14 200-L142 BK-18 1552269 118-3534 CBL-PP1 RD-00
XMSN FILTER BYPASS SW H48

A513-K104 PK-16

M997-K106 PU-16

M996-K107 PK-16
K742-K109 OR-16
426-E36 BR-18 321-E188 BR-16 306-E170 GN-16 126-K89 RD-14 126-K90 RD-14 202-E145 BK-16 310-E21 PU-16 310-E130 PU-16 506-E88 PU-16 506-R15 PU-18 516-L106 GN-14 200-L25 BK-18 E789-C26 PU-16

J764-K100 BR-16
54 10 1 BK-18

708-K105 YL-16
20A
H44

CBL-JJ1 RD-00
614-K103 PU-16
RETARDER LOW OPR SW 324-E207 BU-16 307-E141 OR-16 STOP LAMPS 126-K110 RD-16 202-E150 BK-16 310-E131 PU-16 502-E73 OR-16 502-R9 OR-18 517-L108 BU-14 200-L145 BK-18 306-C27 GN-16 CBL-LL1 RD-00

115-K97 RD-16
55 7 FUSE 3 3

592-K99 BU-16
11 2 BK-18

200-K51 BK-16

374-K98 PK-16
165-K88 YL-16
RETARDER MED OPR SW 56 368-E225 OR-16 324-E207 BU-16 10A 173-K92 RD-16 202-E151 BK-16 619-E212 GN-16 12 619-R13 GN-18 H46 A523-L8 PU-16 200-L23 BK-18 L-C24
RETARDER HIGH OPR SW 57 369-E140 PU-16 369-E140 PU-16 8
FUSE 4
4
PRODUCT LINK POWER 202-E152 BK-16 605-E195 YL-16 605-E33 YL-16 G708-E104 GY-16 13 G708-R7 GY-18 A524-L7 BR-16 200-L22 BK-18 1071984
KEY SWITCH 58 113-E236 OR-16 374-E137 PK-16 374-E137 PK-16 10A 170-K62 RD-16 124-E118 GN-14 605-E200 YL-16 501-E56 GN-16 14 501-R10 GN-18 A525-L6 GN-16 605-L112 YL-18 LH TURN IND LAMP 207-C30 BK-16 109-C113 RD-10
TC OIL OUTPUT TEMP SNSR 59 406-E166 PU-16 406-E166 PU-16 406-E166 PU-16 200-E185 BK-14 575-E106 YL-16 15 575-R14 YL-18 C547-L107 OR-14 200-L22 BK-18 107-1983
OTG FILTER BYPASS SW 60 J812-E243 PK-16 417-E132 GY-16 417-E132 GY-16 H19 515-E69 GY-14 606-E198 GY-16 606-E34 GY-16 591-E110 WH-16 16 591-R25 WH-16 E971-L110 GN-16 L-C25 304-C116 WH-10 CBL-CC1 RD-00 CBL-GG1 BK-00
61 419-E165 YL-16 498-E80 WH-18 516-E70 GN-14 606-E199 GY-16 509-E16 WH-16 17 509-R30 WH-18 H420-L9 PU-18 1071984
XMSN LATCH PRESS. SNSR 62 J823-E48 YL-18 426-E36 BR-18 708-E122 YL-16 K-C7 522-E184 WH-14 614-E23 PU-16 512-E4 GN-16 18 512-R27 GN-18 H421-L12 GN-18 H420-L9 PU-18 SEC STEER IND LAMP 200-C5 BK-14 200-C5 BK-14
XMSN OUTPUT SPEED A- 63 E901-E40 GN-18 498-E80 WH-18 709-E220 OR-16 H16 3E5178 A523-E129 PU-14 614-E228 PU-16 614-E230 PU-16 511-E17 BR-16 19 511-R26 BR-18 H805-L127 BR-18 200-L23 BK-18 107-1983 200-C59 BK-14 200-C59 BK-14
64 6734-E86 YL-18 720-E168 PU-16 BREAKER A524-E66 BR-14 614-E229 PU-16 508-E15 PU-16 20 508-R29 PU-18 H805-L128 BR-18 L-C26
TURBO INLET PRESS SNSR
ENG BLOCK
C-C22

10
11
12
XMSN OUTPUT SPEED A+ 1071984

1
2
3
4
5
6
7
8
9
65 E900-E41 WH-18 705-E32 PK-18 892-E63 BR-18 A525-E65 GN-14 614-E217 PU-16 200-E111 BK-16 21 200-R28 BK-16 J764-L129 BR-18 CBL-FF1 BK-00 POS NEG POS NEG
XMSN OUTPUT SPEED B- 66 E907-E43 GY-18 708-E122 YL-16 893-E62 GN-18 CONN 17 RC-C1 C547-E68 OR-14 A513-E64 PK-16 22 A513-R32 PK-16 498-L10 WH-18 DIFF LOCK IND LAMP 3E3369 194-6722
XMSN INTER SPEED - 1698674 107-1983 +BATTERY

M996-RC16 PK-16
K742-RC24 OR-16
720-E168 PU-16 619-E14 GN-16 619-E212 GN-16 993-L152 BR-18 993-L126 BR-18 H805-L128 BR-18 L730-C52 OR-16 207-C30 BK-16

M997-RC11 PU-16
67 517-E71 BU-14 23 A OR-18

A513-RC4 PK-16

614-RC12 PU-16
708-RC13 YL-16
374-RC14 PK-16
165-RC15 YL-16
J764-RC9 BR-16
200-RC3 BK-16
115-RC5 RD-16
592-RC6 BU-16
XMSN INTER SPEED + 68 728-E192 BU-16 E789-E81 PU-16 619-E213 GN-16 592-E101 BU-16 24 592-R31 BU-16 993-L135 BR-18 L-C27 993-C56 BR-18 B YL-18 GROUND FRAME GND2 BATTERY A BATTERY B

H23
69 751-E37 GN-18 H421-E125 GN-18 114-E112 RD-16 1071984 F400-C58 GY-16 C GN-18 SIGNAL 9X-9721 9X-9721
H24 FRAME GROUND

H22
70 752-E38 YL-18 H805-E144 BR-18 121-E114 RD-16 727-E54 GN-18 727-E215 GN-16 201-L125 BK-18 611-L11 PU-18 HI BEAM IND LAMP 101-T51 RD-4
754-E57 BU-18 H805-E221 BR-18 165-E227 YL-16 727-E216 GN-16 109-E53 RD-16 200-L17 BK-18 200-L24 BK-18 107-1983 109-C113 RD-10
BATTERY+ (24V) 1 126-E159 RD-16 755-E58 OR-18 J764-E136 BR-16 102-E193 RD-16 892-E63 BR-18 150-E160 RD-14 200-L144 BK-18 L-C28 CHASSIS BREAKER PANEL
BATTERY- (GROUND) 2 202-E155 BK-16 893-E62 GN-18 J764-E175 BR-16 113-E197 OR-16 892-E128 BR-18 892-E209 BR-16 177-E82 RD-4 200-L146 BK-18 1071984
3 892-E63 BR-18 J764-E206 BR-16 118-E109 GY-16 892-E127 BR-18 201-E232 BK-16 200-L92 BK-18 H421-L12 GN-18 XMSN IND LAMP CBL-PP2 BK-00
DIFF LOCK LAMP 4 498-E80 WH-18 900-E31 PU-18 J764-E205 BR-18 113-E172 OR-16 892-E248 BR-18 203-E171 BK-16 200-L91 BK-18 H805-L127 BR-18 107-1983 DISCONNECT SWITCH CBL-PP1 RD-00
5 901-E233 WH-18 K742-E121 OR-16 200-RC10 BK-16 200-E190 BK-16 893-E61 GN-18 207-E30 BK-16 200-L90 BK-16 663-L97 GY-18 L-C29 H55 7N-0718 FRONT LH POS LAMP

201-E181 BK-16
H44 BATTERY

108-E126 BU-14

201-E232 BK-16
200-E135 BK-14
200-E176 BK-12
202-E152 BK-16
202-E150 BK-16
202-E145 BK-16
6 921-E55 WH-18 M996-E76 PK-16 317-E202 YL-16 893-E62 GN-18 302-E29 OR-16 663-L95 GY-18 663-L96 GY-18 1071984 REMOTE START RECEPTACLE TA-C3 162-5402

201-E119 BK-16
201-E120 BK-16

202-E151 BK-16
ISOLATOR

200-E96 BK-16

200-E94 BK-16
7 922-E39 BR-18 M997-E77 PU-16 200-RC3 BK-16 320-E134 OR-18 893-E208 GN-16 304-E27 WH-16 661-L99 GN-18 454-L13 GN-18 RETARDER IND LAMP PP-C1 1552269
SWITCH CONN 34

200-E95 BK-16
123-E93 WH-16
8 994-E238 GY-16 TWISTED 24V TO 12V CONV 200-RC25 BK-16 322-E191 GY-16 893-E180 GN-18 306-E28 GN-16 662-L98 YL-18 993-L126 BR-18 107-1983 4N6579 614-TA1 PU-16 1 RD-18
9 A323-E224 GY-16 PAIRS 134-1346 500-E74 BR-16 893-E247 GN-18 308-E234 YL-16 200-L93 BK-18 L-C30 CBL-FF1 BK-00 200-TA2 BK-16 2 BK-18
A958-E222 WH-16 432-E2 PK-16 115-RC5 RD-16 H21 575-E106 YL-16 310-E131 PU-16 H47 200-L94 BK-18 1071984 C-C3 TA-C1
10 +24V INPUT H18
11 E737-E240 PU-16 201-E100 BK-16 +24V IGN 165-RC7 YL-16 591-E110 WH-16 998-E97 BR-18 317-E202 YL-16 606-L14 GY-18 RH TURN IND LAMP 203-T5 BK-16 HOOD LOCKING SW 1552267 3E3382
DRVRS 17-20 SOL RETN 12 H805-E182 BR-18 E900-E41 WH-18 G485-E35 BU-16 GROUND 200-RC25 BK-16 165-RC7 YL-16 SHIFT/HOIST QUAD LEVER 610-E13 OR-16 998-E203 BR-16 998-E20 BR-16 322-E191 GY-16 L-C11 CMS SPEED TACH 200-L25 BK-18 107-1983 CONN 29 T-C2 146-0240 614-C50 PU-16 6 614-TA1 PU-16
151-0836 E-C3
DRVRS 13-16 SOL RETN
IAD PRESSURE SOL
13 K952-E237 BR-16 E901-E40 GN-18 G486-E87 GN-16 MEMORY A513-RC4 PK-16 AIR SEAT 1552269 614-E229 PU-16 998-E105 BR-18 406-E166 PU-16 1698672 125-6806 L-C33
C-C30 T-C1
1698669 605-C36 YL-16 3 605-606-TA3 YL-16 FRONT LH TURN LAMP E
E IAD ACTUATE SOL
14
15
K746-E226 PK-16
A323-E224 GY-16
E906-E42 OR-18
E907-E43 GY-18
G834-E251 PU-16
G835-E252 OR-16 +12V OUTPUT 592-RC6 BU-16
165-RC15 YL-16
SHIFT LEVER SENSOR
200-3173
+ BATTERY 1 108-E126 BU-14
619-E14 GN-16
661-E51 GN-18
998-E211 BR-16 417-E132 GY-16
522-E184 WH-14 201-L74 BK-18
E707-L73
201-L74
GN-18
BK-18
1
2
OR-18
BK-18
+V DISPLAY
GROUND 430-L134 BU-18
1071984
AIR FILTER IND LAMP 8N1518 8N1517 175-T7 RD-14
A301-T8 WH-18
B
A
RD-18
BK-18
1 2 619-C87
611-C89
GN-16
PU-16
5
4
619-TA5 GN-16
611-TA7 PU-16
TA-C4
1552269
3E-6466
3
BACKUP ALARM RELAY 16 321-E188 BR-16 E963-E44 BK-18 165-RC22 YL-16 193-2543 GROUND 2 200-E96 BK-16 662-E52 YL-18 173-E90 RD-16 605-E200 YL-16 E708-L75 PK-18 3 GN-18 CLOCK 993-L135 BR-18 107-1983 109-C113 RD-10 1 109-T1 RD-10 A300-T10 GN-18 C WH-18 322-C91 GY-16 2 322-TA9 GY-16 605-606-TA3 YL-16 1 RD-18
HOIST LOWER SOLENOID G704-E98 YL-16 E964-E45 WH-18 165-RC17 YL-16 663-E231 GY-18 500-E74 BR-16 H28 606-E199 GY-16 C413-L76 YL-18 L-C31 998-C57 BR-16 998-T2 BR-16 200-C67 BK-14 200-TA11 BK-16 200-TA4 BK-16
17 1 +V 4 WH-18 DATA 2 1 2 BK-18
DRVRS 21-25 SOL RETN 18 G704-E98 YL-16 201-E100 BK-16 J764-RC18 BR-16 2 GROUND 727-E54 GN-18 720-E168 PU-16 614-E230 PU-16 C414-L77 BU-18 5 YL-18 LOAD 1071984 F716-C65 WH-16 3 F716-T3 WH-16
19 G705-E164 GN-16 432-E2 PK-16 M997-RC11 PU-16 3 SIGNAL 998-E203 BR-16 604-E174 OR-16 619-E213 GN-16 6 BU-18 HARNESS CODE 411-L15 PK-18 CMS ACTION LAMP F715-C55 PU-16 4 F715-T4 PU-16 109-T19 RD-4 CONN 35
H21

20 H421-E125 GN-18 G485-E35 BU-16 4 CAL. F710-E204 BR-16 J764-E175 BR-16 709-E220 OR-16 201-L125 BK-18 107-1983 203-C29 BK-16 5 203-T5 BK-16 109-T1 RD-10
21 J812-E243 PK-16 G486-E87 GN-16 727-E216 GN-16 109-C22 RD-16 6 109-T6 RD-16 109-T6 RD-16 TA-C5 LH LO BEAM HDLAMP
BATTERY - (GROUND) RC-C7 L-C22 L-C20 1552269 171-7213
22 202-E154 BK-16 J823-E48 YL-18 G834-E251 PU-16 1733047 XMSN HOLD 200-E201 BK-14 126-E113 RD-14 892-E209 BR-16 1135183 175-C77 RD-14 7 175-T7 RD-14 175-T9 RD-14
BATTERY + (24V) 23 126-E115 RD-14 J832-E59 YL-18 G835-E252 OR-16 SWITCH A 604-E174 OR-16 126-E115 RD-14 893-E208 GN-16 1135183 L-C19 A301-C78 WH-18 8 A301-T8 WH-18 619-TA5 GN-16 1 WH-18
HOLD LAMP 24 H421-E125 GN-18 K742-E121 OR-16 RC-C8 E-C5 E-C4 605-E195 YL-16 202-E145 BK-16 998-E97 BR-18 200-L94 BK-18 1698671 R
175-C63 RD-14 9 175-T9 RD-14 200-TA6 BK-16 2 BK-18
CROSS AXLE LOCK SOL 25 368-E225 OR-16 K746-E226 PK-16 202-E183 BK-18 1698672 3E3363 1552269 606-E198 GY-16 202-E148 BK-16 H26 998-E211 BR-16 661-L99 GN-18 308-L100 YL-16 1 YL-16 A300-C79 GN-18 10 A300-T10 GN-18
26 K952-E237 BR-16 419-E165 YL-16 J764-RC19 BR-16 1 OR HEATED 1 123-E93 WH-16 614-E228 PU-16 202-E150 BK-16 E789-E81 PU-16 200-L93 BK-18 2 PU-16
C OFF
11
20A
TA-C6 LH HI BEAM HDLAMP
SEAT S ON HOOD BREAKER 1552269 171-7214
27 K977-E1 PK-18 368-E225 OR-16 708-RC13 YL-16 2 BR 2 200-E95 BK-16 202-E151 BK-16 F710-E204 BR-16 662-L98 YL-18 307-L102 OR-16 3 OR-16 12

H20
B ST 6T-3644
28 L911-E78 YL-18 426-E36 BR-18 200-RC10 BK-16 3 YL 113-E236 OR-16 202-E152 BK-16 G834-E251 PU-16 105-L103 RD-16 4 BR-16 13 611-TA7 PU-16 1 WH-18
29 L910-E79 PK-16 6734-E86 YL-18 614-RC12 PU-16 4 BU 201-E100 BK-16 374-E137 PK-16 G835-E252 OR-16 L-C12 CMS QUAD GAGE KEY START SW 14 177-T20 RD-4 101-T54 RD-14 200-TA8 BK-16 2 BK-18
DIFF LOCK SWITCH 30 324-E207 BU-16 M996-E76 PK-16 705-E32 PK-18 K742-RC24 OR-16 5 WH 202-E245 BK-16 708-E122 YL-16 J764-E206 BR-16 1698672 166-6938 110-7887 15
80A

L-C13 MAIN BREAKER

31 M997-E77 PU-16 709-E46 OR-18 J764-RC20 BR-16 6 RD 306-E170 GN-16 E707-L83 GN-18 E707-L78 GN-18 1 OR-18 +V DISPLAY 16
9S-4693 109-T6 RD-16 322-C18 GY-16
32 T900-E3 GN-18 751-E37 GN-18 307-E141 OR-16 201-L79 BK-18 2 BK-18 GROUND 1071984 17 TA-T1
921-E241 WH-18 752-E38 YL-18 TOP GEAR 201-E119 BK-16 201-E232 BK-16 324-E207 BU-16 K742-E121 OR-16 H42 E708-L84 PK-18 E708-L80 PK-18 614-L101 PU-18 KEY START BACKLITE 322-TA9 GY-16 HORN LO TONE
33
SWITCH B
3 GN-18 CLOCK 18
SPOOL POS SNSR CALB 34 6734-E86 YL-18 922-E242 BR-18 754-E57 BU-18 201-E120 BK-16 201-E181 BK-16 369-E140 PU-16 J764-E136 BR-16 C413-L85 YL-18 C413-L81 YL-18 4 WH-18 DATA 200-L142 BK-18 110-2079 109-C72 RD-4 19 109-T19 RD-4 LINK 80A
109-T1 RD-10 614-C39 PU-16 200-TA10 BK-16 7T-0969
35 126-E159 RD-16 755-E58 OR-18 J764-RC18 BR-16 202-E151 BK-16 200-E135 BK-14 406-E166 PU-16 M996-E76 PK-16 C414-L86 BU-18 C414-L82 BU-18 5 YL-18 LOAD 177-C64 RD-4 20 177-T20 RD-4 7V9275 109-T19 RD-4 TA-T2
ON/OFF DRV1-8 SOL RETN 36 E789-E189 PU-16 126-E156 RD-16 900-E31 PU-18 J764-RC20 BR-16 202-E145 BK-16 200-E176 BK-12 417-E132 GY-16 M997-E77 PU-16 6 BU-18 HARNESS CODE CIGAR LIGHTER 21
37 126-E157 RD-16 126-E113 RD-14 901-E233 WH-18 J764-RC19 BR-16 202-E150 BK-16 200-E94 BK-16 432-E2 PK-16 403-E250 GN-16 129-L111 RD-16 22 ALTERNATOR BREAKER 619-C40 GN-16
9W-0335 9S-4693 TA-T3
38 126-E158 RD-16 921-E55 WH-18 J764-RC9 BR-16 202-E152 BK-16 498-E80 WH-18 430-E124 BU-18 L-C21 200-L145 BK-18 23 322-TA12 GY-16 HORN HI TONE
KEY START 39 307-E141 OR-16 202-E245 BK-16 922-E39 BR-18 J764-RC21 BR-16 HOIST POSITION SENSOR CAB GROUND2 709-E220 OR-16 447-E210 PK-16 201-L88 BK-16 L-C14 L-C23 24 101-T51 RD-4 200-TA13 BK-16 7T-0970
1135183
(Dimensions: 39" X 24")

SEC STER RLY 40 728-E192 BU-16 202-E153 BK-16 202-E148 BK-16 994-E238 GY-16 J764-RC23 BR-16 193-2544 GND 720-E168 PU-16 454-E123 GN-18 8T9834 1135183 25
TWISTED B TA-T4
RET SOL(725,730 ONLY) 41 202-E155 BK-16 202-E183 BK-18 A323-E224 GY-16 165-RC22 YL-16 1 +V 892-E63 BR-18 611-E139 PU-16 C413-L85 YL-18 35 MODULE DATA 200-L92 BK-18 124-L104 GN-14 611-C38 PU-16
202-E154 BK-16 202-E150 BK-16 A958-E222 WH-16 J764-RC23 BR-16 893-E62 GN-18 993-E91 BR-18 PAIR C414-L86 BU-18 15 663-L97 GY-18 ENG SHUTDOWN SW TA-C7 RH HI BEAM HDLAMP
42 2 GROUND MODULE LOAD 6 2 1 4D-1836 171-7214
43 709-E46 OR-18 E737-E240 PU-16 M996-RC16 PK-16 3 SIGNAL E789-E81 PU-16 C542-E239 GN-16 E707-L83 GN-18 34 CLUSTER +V 200-L91 BK-18 515-L105 GY-14 998-T2 BR-16 1552269
5 3 SWITCH GUARD

H29
XMSN LATCHING SOL 44 J832-E59 YL-18 709-E219 OR-16 709-E220 OR-16 E789-E223 PU-16 4 CAL. G485-E35 BU-16 E971-E143 GN-16 E708-L84 PK-18 25 MODULE CLOCK 663-L96 GY-18 516-L106 GN-14 611-TA14 PU-16 1 WH-18
PARK BRAKE SOL A958-E222 WH-16 J764-E175 BR-16 E789-E235 PU-16 G486-E87 GN-16 G706-E84 BU-16 113-L136 OR-18 C547-L107 OR-14 4 3E-5169 200-TA15 BK-16
45
RC-C5
1 + BATTERY 3 FAN SPEED SW 2 BK-18
BATTERY- (GND) 46 202-E153 BK-16 J764-E136 BR-16 E790-E177 PK-16 1733047 G834-E251 PU-16 G707-E99 GN-16 21 517-L108 BU-14 157-0217 F716-T3 WH-16 RH LO BEAM HDLAMP
D BATTERY+ (24V) 47 126-E158 RD-16 J764-E60 BR-18 J764-E218 BR-16 E900-E41 WH-18
RC-C2
G835-E252 OR-16 G708-E104 GY-16 G486-L150 GN-18 29 REAR BRAKE TEMP 2 F715-T4 PU-16 TA-C8
1552269 171-7213 D

H45
H28
48 J764-E47 BR-18 E901-E40 GN-18 H421-E125 GN-18 H420-E149 PU-18 28 E528-L109 PU-18 CHAS BREAKER PANEL
DRVRS 5-8 SOL RETN 1698671 C-C4 TA-C2

H57
49 922-E39 BR-18 E906-E42 OR-18 H805-E144 BR-18 27 109-C72 RD-4 H58 619-TA16 GN-16 1 WH-18
50 J764-E103 BR-16 J764-E205 BR-18 E907-E43 GY-18 J764-RC21 BR-16 1 BK-18 H805-E221 BR-18 173-E90 RD-16 E-C26 E-C25 26 L-C34 C-C11 START AID SOL 1552267 3E3382 200-TA17 BK-16 2 BK-18
1 2 1552273 3E3382 1552269
XMSN SOL 5 51 900-E31 PU-18 J764-E206 BR-16 E963-E44 BK-18 374-RC14 PK-16 2 BK-18 J764-E175 BR-16 500-E74 BR-16 201-L89 BK-16 2 GROUND 1071984 3E-6332 ALTERNATOR 614-C100 PU-16 6 614-TA21 PU-16
DRVRS 1-4 SOL RETN 52 921-E55 WH-18 E789-E81 PU-16 E964-E45 WH-18 3 J764-E205 BR-18 604-E174 OR-16 170-E249 RD-16 1 32 614-L140 PU-18 FAN SPEED BACKLITE 317-C8 YL-16 1 WH-18
185-5294 606-C37 GY-16 3 605-606-TA18 GY-16 FRONT RH TURN LAMP
53 G704-E98 YL-16 4 J764-E206 BR-16 720-E168 PU-16 202-E245 BK-16 2 291-L119 BK-18 33 CLEAR 200-L144 BK-18 110-2079 200-C74 BK-16 2 PU-18 619-C95 GN-16 5 619-TA16 GN-16 TA-C9 3E-6466
54 E789-E189 PU-16 E789-E223 PU-16 G705-E164 GN-16 PARK BRAKE SWITCH J764-E175 BR-16 308-E246 YL-16 3 PRODUCT LINK 290-L120 BK-18 23 SERVICE ALT 611-C90 PU-16 4 611-TA14 PU-16 1552269
55 E789-E235 PU-16 J764-E47 BR-18 218-3262 403-E244 GN-16 4 E735-L118 PU-18 18 OPERATOR SW INPUT L-C16 A/C SEL SW C-C28 ARC SUPPRESSOR + R 322-C93 GY-16 2 322-TA12 GY-16 605-606-TA18 GY-16 1 RD-18
BATTERY- (GND) 202-E152 BK-16 J764-E218 BR-16 H16 H16 200-E163 BK-16 893-E247 GN-18 892-L121 BR-18 3E7996 125-9257 1552269 106-8704 GND 200-C76 BK-14 200-TA22 BK-16 200-TA19 BK-16
56
H26
5 14 CAT DATA LINK - 1 2 BK-18
BATTERY + (24V) 57 126-E157 RD-16 E790-E186 PK-16 E790-E177 PK-16 J812-E243 PK-16 118-E169 GY-16 892-E248 BR-18 6 893-L122 GN-18 5 CAT DATA LINK + 614-L26 PU-18 513-C102 OR-14 1
HOIST RAISE SOL G705-E164 GN-16 E790-E214 PK-16 J823-E48 YL-18 H17 126-E113 RD-14 501-E56 GN-16 410-L133 WH-18 4 614-L19 PU-18 522-C31 WH-14 522-C103 WH-14 FRONT RH POS LAMP
58
H27 ACTION ALARM A 2
CONN 36
DRVRS 9-12 SOL RETN E790-E186 PK-16 J832-E59 YL-18 126-E115 RD-14 502-E73 OR-16 TWISTED 200-L17 BK-18 TA-C10 162-5402

CBL-AG1 BK-4
59 40 B
LOCKUP CLUTCH SOL 60 705-E32 PK-18 H805-E178 BR-16 K746-E226 PK-16 H15 H15 202-E145 BK-16 PAIR 37 1 AC CLUTCH COIL 1552269
2 C-C27
XMSN SOLENOID 6 61 901-E233 WH-18 H805-E182 BR-18 H805-E144 BR-18 K952-E237 BR-16 202-E148 BK-16 170-E249 RD-16 17 E528-L109 PU-18 2
3
149-8195 614-TA21 PU-16 1 RD-18
XMSN SOLENOID 3 62 754-E57 BU-18 H805-E221 BR-18 K977-E1 PK-18 202-E150 BK-16 202-E245 BK-16 432-L148 PK-16 20 BRAKE OIL PRESS E971-L110 GN-16 3 1552269 200-TA20 BK-16 2 BK-18
XMSN SOLENOID 4 63 755-E58 OR-18 L910-E79 PK-16 OPERATOR STATION 202-E151 BK-16 308-E246 YL-16 E-C19 L 7 4 513-C105 OR-14 1 BK-18
XMSN SOLENOID 1 64 751-E37 GN-18 L911-E78 YL-18 202-E152 BK-16 1552273 447-L132 PK-18 9 FUEL LEVEL SENSOR 5 522-C104 WH-14 2 BK-18 C-C17 HOOD ACTUATOR AS
XMSN SOLENOID 2 65 752-E38 YL-18 T900-E3 GN-18 CONN 7 CONN 8 TRANSMISSION 374-E137 PK-16 403-E250 GN-16 403-E142 GN-16 501-E56 GN-16 4 GN-16
GND
MOTOR H 24 6 1297164 204-7016 CBL-LL1 RD-00
66 921-E241 WH-18 AC-C1 J-C1 J-C2 CA-C8 REAR CHASSIS 708-E122 YL-16 403-E244 GN-16 1 36 E971-L18 GN-18 C C-C26 AC PRESSURE SW 397-C80 OR-14 1 RD CBL-PP2 BK-00
922-E242 BR-18 3E3381 1698672 1698672 3E3381 J764-E136 BR-16 200-E163 BK-16 T° 403-L131 GN-16 200-L20 BK-18 1552269 114-5333
67 2 BK-16 30 ALTERNATOR D
START RELAY 68 306-E170 GN-16 200-AC1 BK-14 1 200-J1 BK-14 1 200-CA1 BK-14 200-CA1 BK-14 K742-E121 OR-16 430-E124 BU-18 118-E169 GY-16 6 GY-16
B+ P 39 200-L27 BK-18 513-C106 OR-14 1 BK-18
2 3
H10

BATTERY- (GND) 69 202-E151 BK-16 604-AC7 OR-16 2 604-J2 OR-16 2 604-CA2 OR-16 419-CA7 YL-16 M996-E76 PK-16 447-E210 PK-16 500-E74 BR-16 3 BR-16 38 E971-C32 GN-16 2 BK-18 1 MOTOR
BATTERY + (24V) 70 126-E156 RD-16 H11 605-AC10 YL-16 3 605-J3 YL-16 3 605-CA3 YL-16 604-CA2 OR-16 M997-E77 PU-16 454-E123 GN-18 502-E73 OR-16 5 OR-16 411-L15 PK-18 13 L-C18 C-C20
RENR5135-03

ACTION LAMP 1698669 ENG BLOCK GND2 1297163 RD

E-C2 NOTE: WIRE CIRCUITS T900 & 6734 ARE NOT BEING USED, 614-AC11 PU-16 4 614-J4 PU-16 4 614-CA6 PU-16 605-CA3 YL-16 611-E139 PU-16 FRONT WIPER MOTOR G485-L151 BU-18 19 FRONT BRAKE TEMP
HOWEVER, ARE BEING LEFT INPLACE AS SPARES. 612-AC14 GY-16 612-J5 GY-16 612-CA5 GY-16 606-CA4 GY-16 892-E248 BR-18 147-7985 A525-L6 GN-16 403-C21 GN-16 398-C81 BU-14 BK WH
1607690 5 5 11 A RD-14 1

H29
606-AC18 GY-16 606-J6 GY-16 606-CA4 GY-16 612-CA5 GY-16 893-E247 GN-18 A524-L7 BR-16 H55 OR
6 6 10 B BK-14 TEMP SEL SW H57 YL
614-CA6 PU-16 993-E91 BR-18 STOP LAMP PRESS. SW 8 A523-L8 PU-16 C BR-14 127-4540 AH-C1 SEC STER ARC SUPPR DIODE
H11

AC-C2 J-C3 J-C4 CA-C10 E-C20 H56 1552269 PK

OPERATOR STATION C542-E239 GN-16 172-7071 275-L71 BK-18 6
HARNESS CODE 5 106-8704
3E3375 1698671 1698671 3E3375 A958-CA8 WH-16 TRANSMISSION CONN 18 E971-E143 GN-16 1552269 274-L70 BK-18HARNESS CODE 4
16 727-AH1 GN-16 1 BK
419-AC20 YL-16 1 419-J7 YL-16 1 419-CA7 YL-16 E789-CA11 PU-16 G707-E99 GN-16 173-E90 RD-16 1 BK-18 273-L69 BK-18HARNESS CODE 3
22 E-C14 C-C10 CONN 30 200-AH2 BK-16 2
A958-AC21 WH-16 2 A958-J8 WH-16 2 A958-CA8 WH-16 G486-CA9 GN-16 CA-C9 E-C16 G706-E84 BU-16 604-E174 OR-16 2 BK-18 272-L68 BK-18HARNESS CODE 2
12 L-C35 1275484 1275483
J764-AC19 BR-16 3 J764-J9 BR-16 3 J764-CA10 BR-16 G485-CA12 BU-16 9X0141 9X1343 G708-E104 GY-16 271-L67 BK-18HARNESS CODE 1
3 1071984 177-E82 RD-4 1 177-C64 RD-4
E789-AC22 PU-16 4 E789-J10 PU-16 4 E789-CA11 PU-16 200-CA1 BK-14 1 200-E201 BK-14 H420-E149 PU-18 270-L66 BK-18HARNESS CODE 0
31 614-L141 PU-18 TEMP SEL BACKLITE TWISTED 200-AH2 BK-16 GN GREEN
E-C18 BU BLUE
H12

J764-CA25 BR-16 604-CA2 OR-16 604-E174 OR-16 200-L146 BK-18 110-2079 THROTTLE SENSOR PAIR 727-AH1 GN-16
C AC-C9 CONN 9 CONN 10 605-CA3 YL-16
2
3 605-E195 YL-16 H20 SERVICE BRAKE PRESS. SW 201-L72 BK-18
CAT MON SYS
160-6567 1698670 160-2443 C
1698669 AC-C3 J-C5 J-C6 CA-C11 J764-CA25 BR-16 614-CA6 PU-16 4 614-E228 PU-16 E-C21 172-7071 L-C32 F702-E173 GN-18 A BK-18 +V 200-C2 BK-16
J764-AC19 BR-16 H13 3E3363 1552269 1552269 3E3363 J764-CA10 BR-16 612-CA5 GY-16 612-E187 GY-16 H27 1552269 L-C15 X-C1 998-E97 BR-18 150-C11 RD-14 BLADE, SPADE, RING,
BK-16 A 5
CONN 27 3E3387 1698673 3E7996 B OR-18 GROUND OR SCREW TERMINAL
RD-16 B 419-AC20 YL-16 G486-AC23 GN-16 1 G486-J11 GN-16 1 G486-CA9 GN-16 201-CA14 BK-16 606-CA4 GY-16 6 606-E198 GY-16 J764-E175 BR-16 1 BK-18 614-L115 PU-18 A700-E133 OR-18 C WH-18 SIGNAL 308-C14 YL-16
BU-16 C 201-AC24 BK-16 2 201-J12 BK-16 2 201-CA14 BK-16 201-CA15 BK-16 419-CA7 YL-16 7 419-E165 YL-16 720-E168 PU-16 2 BK-18 270-L66 BK-18 1 614-L26 PU-18 A 310-C6 PU-16 CIRCUIT CONNECTED
PARK BRAKE PRESS SW A958-CA8 WH-16 8 A958-E222 WH-16 271-L67 BK-18 2 201-X0 BK-18 200-L27 BK-18 B E-C15 C-C1 430-C12 BU-18 727-C19 GN-16 CIRCUIT NOT CONNECTED
172-7073 H14 CONN 11 CONN 12 J764-CA16 BR-16 J764-CA25 BR-16 9 J764-E218 BR-16 272-L68 BK-18 3 201-X1 BK-18 1 1030213 9X4391 454-C118 GN-18 H420-C20 PU-18

H56
2
H13 U-C3 CA-C5
J764-CA17 BR-16 E789-CA11 PU-16 10 E789-E223 PU-16 RELAY PANEL 273-L69 BK-18 4 J764-L129 BR-18 2
3
F702-E173 GN-18 1 F702-C1 GN-18 109-C22 RD-16 892-C10 BR-16
J764-CA18 BR-16 G486-CA9 GN-16 11 G486-E87 GN-16 START AID RLY 274-L70 BK-18 5 201-X2 BK-18 369-L123 PU-18 3 2 150-C11 RD-14 893-C9 GN-16 CBL-HH1 BK-00 CBL-LL1 RD-00
T-C OUTPUT SP SNSR 1552269 1552269 G485-CA12 BU-16 12 G485-E35 BU-16 SEC STEER RLY BACKUP ALARM RLY INTMED WIPER RLY HORN RELAY HEADLAMP RLY 275-L71 BK-18 6 201-X3 BK-18 113-L136 OR-18 4 A700-E133 OR-18 3 A700-C3 OR-18 201-C17 BK-16 993-C13 BR-18 INTERNAL ELECTRICAL
AC-C7 189-5746 3E-5239 3E-5239 3E-5239 3E-5239 3E-5239 3E-5239 5 CONNECTION TO SU
A323-CA51 GY-16 BK-18 1 L911-U3 YL-18 BK-16 1 G485-CA12 BU-16 201-CA45 BK-16 201-CA13 BK-16 13 201-E100 BK-16 H15 201-L72 BK-18 7 201-X4 BK-18 5
6
F710-E204 BR-16 4 F710-C4 BR-16 203-C29 BK-16 998-C16 BR-16 SEC STER RLY
1552269 E790-CA61 PK-16 WH-18 2 L910-U4 PK-18 BK-16 2 201-CA15 BK-16 L911-CA21 YL-18 14 L911-E78 YL-18 8 A324-L114 PK-18 6 G835-E252 OR-16 5 G835-C42 OR-16 207-C30 BK-16 MOTOR 3E-0154

87a
87a

87a

87a

87a

87a
BK-18 1 A958-AC21 WH-16 G704-CA60 YL-16 201-CA13 BK-16 L910-CA22 PK-18 15 L910-E79 PK-16 L-C17 CMS OPERATOR SW C 310-E131 PU-16 6 310-C6 PU-16 302-C25 OR-16 A700-C3 OR-18 SEC STER MOT

30
T°
LOCK UP CLUTCH SOL TWISTED PAIR

30

30

30

30

30

87
U-C5

87

87

87

87

87
BK-18 2 E789-AC22 PU-16 G705-CA63 GN-16 368-CA50 OR-16 921-CA24 WH-18 16 921-E55 WH-18 3E7996 112-6171 200-L113 BK-18 D 447-E210 PK-16 7 447-C7 PK-16 304-C28 WH-16 F702-C1 GN-18 141-6389 ATCH WIRE, CABLE &
G835-CA66 OR-16 160-8408 1552269 FRONT BRAKE TEMP SW 432-CA54 PK-16 922-CA26 BR-18 17 922-E39 BR-18 614-L141 PU-18 317-E202 YL-16 8 317-C8 YL-16 306-C27 GN-16 F710-C4 BR-16 COMPONENT

86
85

CBL-KK1 BK-00
PARK BRAKE SOL

86

86

86

86

86
85

85

85

85

85
G834-CA67 PU-16 1 705-U9 PK-18 3E-6451 994-CA19 GY-16 705-CA27 PK-18 18 705-E32 PK-18 614-L115 PU-18 A 893-E208 GN-16 9 893-C9 GN-16 308-C14 YL-16 G706-C45 BU-16 CIRCUIT GROUPING
152-8340 H10 H14 H#

113-L136 OR-18
614-L115 PU-18
614-L141 PU-18

200-L116 BK-18
2 921-U38 WH-18 A323-CA51 GY-16 426-CA28 BR-18 19 426-E36 BR-18 200-L116 BK-18 B CROSSAXLE LOCK SW 892-E209 BR-16 10 892-C10 BR-16 310-C6 PU-16 G707-C46 GN-16 HIGHWAY DESIGNATION

87A

411-L15 PK-18
30
85
86
87

113-L87 OR-18
30
85
86
87

30
85
86
87

30
85
86
87

30
85
86
87

30
85
86
87
E790-CA61 PK-16 202-CA29 BK-18 20 202-E183 BK-18 1 170-1330 150-E160 RD-14 11 150-C11 RD-14 317-C8 YL-16 G708-C47 GY-16
REAR BRAKE TEMP SW K952-CA57 BR-16 XMSN CLUTCH SOL 1 U-C8 TRANSMISSION E737-CA20 PU-16 709-CA30 OR-18 21 709-E46 OR-18 AE-C4 AE-C5 AE-C6 AE-C7 AE-C8 AE-C9 E735-L118 PU-18 2
2
430-E124 BU-18 12 430-C12 BU-18 322-C18 GY-16 G834-C41 PU-16
160-8408 9X1054 3

114-AE21 RD-16
1552269 9X1054 9X1054 3E5519 9X1054 9X1054

114-AE15 RD-16
3E-6451 G704-CA60 YL-16 J764-CA31 BR-18 J764-E47 BR-18 201-L117 BK-18 993-E91 BR-18 993-C13 BR-18 403-C21 GN-16 G835-C42 OR-16 IDENT PART NO. CHG LOC DESCRIPTION

320-AE16 OR-16
22 3 13

F710-AE31 BR-16
E790-AE4 PK-16

BR-16

WH-16
BK-16
GY-16
BR-16

322-AE17 GY-16

OR-16
BK-16
GN-14
AC-C10

RD-14
728-AE3 BU-16
727-AE2 GN-16

RD-16
BR-16
GY-16

YL-16

317-AE30 YL-16
998-AE32 BR-16
165-AE33 YL-16
1 751-U16 GN-18 CONN 13 G705-CA63 GN-16 K977-CA32 PK-18 23 K977-E1 PK-18 4 TWISTED 308-E234 YL-16 14 308-C14 YL-16 406-C34 PU-16 109-C22 RD-16

113-AE1 OR-16
1552269 2 921-U40 WH-18 TWISTED G834-CA67 PU-16 J832-CA33 YL-18 24 J832-E59 YL-18 5 PAIR G834-E251 PU-16 15 G834-C41 PU-16 417-C23 GY-16 177-C64 RD-4 HARNESS AS.
190-6299 00 A/I-15 REAR LAMPS(CHASSIS)

H57
BK-16 1 G486-AC23 GN-16 TRANSMISSION U-C1 CA-C7 PAIR G835-CA66 OR-16 751-CA34 GN-18 25 751-E37 GN-18 6 998-E211 BR-16 16 998-C16 BR-16 430-C12 BU-18 203-C29 BK-16 A
BK-16 2 201-AC24 BK-16 XMSN CLUTCH SOL 5 U-C12 921-U28 WH-18 8N1513 8N1514 J812-CA23 PK-16 E789-CA35 PU-18 26 E789-E235 PU-16 C 201-E232 BK-16 17 201-C17 BK-16 447-C7 PK-16 317-C8 YL-16 AC 190-6298 00 C-15 REAR CHASSIS

H805-AE6

591-AE10
200-AE11
118-AE12
500-AE13

610-AE27
200-AE26
619-AE29
CA-C1 CA-C4

102-AE28

H52
121-AE5
321-AE7
612-AE8

575-AE9
T° 160-8408 1552269 921-U6 WH-18 1 K746-CA52 PK-16 E900-CA36 WH-18 27 E900-E41 WH-18 D 322-E191 GY-16 18 322-C18 GY-16 454-C118 GN-18 403-C21 GN-16 CBL-PP2 BK-00 AE 162-0106 03 C-8 RELAY(CAB)
3E3363 1552269 2 K952-CA53 BR-16 E901-CA37 GN-18 28 E901-E40 GN-18 200-L116 BK-18 727-E216 GN-16 19 727-C19 GN-16 522-C31 WH-14 522-C31 WH-14 C 214-4559 00 F-3 LH CHASSIS FRONT
IAD PRESS. NO LONGER USED 2 K746-CA52 PK-16 K746-CA52 PK-16
1 900-U26 PU-18 E906-CA38 OR-18 29 E906-E42 OR-18 614-L115 PU-18 H42 H420-E149 PU-18 20 H420-C20 PU-18 605-C36 YL-16 E971-C32 GN-16 CA 214-4561 00 B-13 TRANSMISSION(CHASSIS)
L911-U3 YL-18 L911-CA21 YL-18

H43
2 921-U39 WH-18 3
1 K952-CA58 BR-16 K952-CA57 BR-16 L910-U4 PK-18 4 L910-CA22 PK-18 E907-CA39 GY-18 30 E907-E43 GY-18 614-L141 PU-18 H43 403-E250 GN-16 21 403-C21 GN-16 606-C37 GY-16 175-C77 RD-14 STER MOT GND E 190-3137 04 F-9 MAIN CAB
K952-CA53 BR-16 XMSN CLUTCH SOL 2 U-C9 5 202-CA29 BK-18 901-CA47 WH-18 31 901-E233 WH-18 411-L15 PK-18 109-E53 RD-16 22 109-C22 RD-16 611-C38 PU-16 175-C63 RD-14 F 162-9347 02 H-13 ROOF(CAB)
CA-C2 160-8408 1552269 426-CA28 BR-18 752-CA40 YL-18 32 752-E38 YL-18 113-L136 OR-18 417-E132 GY-16 23 417-C23 GY-16 614-C39 PU-16 A300-C79 GN-18 C-C18 TC TEMP SNSR FA 162-9349 02 H-13 HEADLINER(CAB)
1552269 921-U6 WH-18 6 921-CA24 WH-18 1698669
1 752-U23 YL-18 7 705-CA27 PK-18 754-CA41 BU-18 33 754-E57 BU-18 H42 113-L87 OR-18 J764-E206 BR-16 24 J764-C24 BR-16 619-C40 GN-16 A301-C78 WH-18 118-7226 G 157-2500 00 A-6 AIR CONDITIONER(CAB)
CROSSAXLE DIFF LOCK GN-18 2 K952-CA56 BR-16 2 922-U41 BR-18 922-U8 BR-18 922-CA26 BR-18 709-CA30 OR-18 755-CA42 OR-18 34 755-E58 OR-18 302-E29 OR-16 25 302-C25 OR-16 709-C35 OR-16 200-C74 BK-16 J764-C70 BR-16 B BK-18 GROUND H 206-7667 00 A-2 TANK-FUEL (CHASSIS)

H25
8 AE-C1
152-8385 368-CA50 OR-16 751-CA34 GN-18 900-CA43 PU-18 900-E31 PU-18 TWISTED E-C11 E789-E81 PU-16 E789-C26 PU-16 727-C19 GN-16 709-C35 OR-16 J 206-6210 00 C-12 HITCH
GN-18 1 705-U9 PK-18 705-CA27 PK-18 35 CONN 22 26 A OR-18 +V
H17

9 1552252
XMSN CLUTCH SOL 3 U-C10 752-CA40 YL-18 J823-CA44 YL-18 36 J823-E48 YL-18 PAIRS 3E5179 HVAC 306-E28 GN-16 27 306-C27 GN-16 892-C10 BR-16 322-C18 GY-16 406-C34 PU-16 C WH-18 SIGNAL K 204-9926 01 G-11 BREAKER PANEL(CAB)
426-U10 BR-18 10 426-CA28 BR-18
B 160-8408
1
1552269
754-U24 BU-18
202-U11 BK-18 11 202-CA29 BK-18 754-CA41 BU-18
755-CA42 OR-18
E964-CA65 WH-18
E963-CA46 BK-18
37
38
E964-E45 WH-18
E963-E44 BK-18
612-E187 GY-16
728-E192 BU-16
8
3
612-AE8 GY-16
728-AE3 BU-16 G-C4 G-C5 G-C2
304-E27 WH-16
203-E171 BK-16
28
29
304-C28 WH-16
203-C29 BK-16
893-C9 GN-16
993-C13 BR-18
605-C36 YL-16
606-C37 GY-16
L
M
190-6049 02
176-0274 05
F-6
H-2
INSTRUMENT PANEL
ENGINE
B
709-U12 OR-18 12 709-CA30 OR-18 9G3676 9G3670 9G3676 H58 C-C13 H-C1
2 922-U42 BR-18 J764-U13 BR-18 J764-CA31 BR-18 900-CA43 PU-18 T900-CA48 GN-18 39 T900-E3 GN-18 E790-E214 PK-16 4 E790-AE4 PK-16 207-E30 BK-16 30 207-C30 BK-16 998-C16 BR-16 611-C38 PU-16 N 122-1486 06 G-3 FUEL INJECT/JAKE BRAKE
3E3382 CONN 37
13
4 COLOR / 20 PAGE

922-U43 BR-18 K977-U14 PK-18 14 K977-CA32 PK-18 901-CA47 WH-18 6734-CA49 YL-18 40 6734-E86 YL-18 H805-E178 BR-16 6 H805-AE6 BR-16 124-G1 GN-14 1 GN-14 PK-14 1 A526-G11 PK-14 1 PK-18 MOTOR 522-E184 WH-14 31 522-C31 WH-14 614-C39 PU-16 1698672 R 162-9350 03 G-5 FR COMPONENT(CAB)
OTG FILTER BYPASS SW XMSN CLUTCH SOL 4 U-C11 922-U8 BR-18 921-CA24 WH-18 321-E188 BR-16 7 321-AE7 BR-16 200-G20 BK-14 2 BK-14 BU-14 2 A527-G12 BU-14 2 BU-18 MOTOR E971-E143 GN-16 32 E971-C32 GN-16 A700-C3 OR-18 619-C40 GN-16 200-C73 BK-16 1 200-H1 BK-16 RC 162-9348 03 D-11 RH CONSOLE(CAB)
CA-C16 160-8408 1552269
15 J832-CA33 YL-18
116-9846 922-U29 BR-18 751-U16 GN-18 16 751-CA34 GN-18 921-CA55 WH-18 500-E74 BR-16 1 500-AE13 BR-16 A523-G9 PU-14 3 PU-14 YL-14 3 A528-G13 YL-14 3 YL-18 FEEDBACK POT. (+) C542-E239 GN-16 33 C542-C33 GN-16 C542-C33 GN-16 200-C76 BK-14 201-C17 BK-16 2 201-H2 BK-16 H53 T 190-6302 00 E-3 CHASSIS FRONT BREAKER
1552269 1 755-U25 OR-18 17 E789-CA35 PU-18 922-CA26 BR-18 CA-C6 E-C24 727-E54 GN-18 2 727-AE2 GN-16 A524-G5 BR-14 4 BR-14 WH-14 4 A529-G14 WH-14 4 WH-18 FEEDBACK POT. WIPER 406-E166 PU-16 34 406-C34 PU-16 E789-C26 PU-16 200-C67 BK-14 417-C23 GY-16 3 417-H3 GY-16 TA 206-6211 01 E-3 LAMPS FRONT(CHASSIS)
J764-CA16 BR-16 922-U43 BR-18 922-CA59 BR-18 7X6222 9X0145 121-E114 RD-16 121-AE5 RD-16 A525-G8 GN-14 A530-G15 OR-14 FEEDBACK POT. (-) 709-E220 OR-16 709-C35 OR-16 E963-C48 BK-18 J764-C107 BR-16 J764-H4 BR-16 U 227-8973 00 B-14 ECPC XMSN

H54
BK-18 2 2 E900-U18 WH-18 18 E900-CA36 WH-18 5 5 GN-14 OR-14 5 5 OR-18 35 4
BK-18 1 J812-CA23 PK-16 E901-U19 GN-18 19 E901-CA37 GN-18 E789-CA35 PU-18 368-CA50 OR-16 1 368-E225 OR-16 575-E106 YL-16 9 575-AE9 YL-16 6 CONTROL BOARD AS 6 6
WATER VALVE ACTUATOR 605-E200 YL-16 36 605-C36 YL-16 E964-C49 WH-18 447-C7 PK-16 5 447-H5 PK-16 V 211-2039 00 A-2 HEATED MIRROR RH-ATCH
XMSN CLUTCH SOL 6 U-C4 E900-CA36 WH-18 A323-CA51 GY-16 2 A323-E224 GY-16 591-E110 WH-16 10 591-AE10 WH-16 E-C13 G-C1 7 7 7 606-E199 GY-16 37 606-C37 GY-16 E971-C32 GN-16 C542-C71 GN-16 6 C542-H6 GN-16 V 211-2039 00 G-3 HEATED MIRROR LH-ATCH
160-8408 1552269 E906-U20 OR-18 20 E906-CA38 OR-18 1552252 3E8969 149-8217 149-8195
E907-U21 GY-18 21 E907-CA39 GY-18 E901-CA37 GN-18 K746-CA52 PK-16 3 K746-E226 PK-16 102-E193 RD-16 11 102-AE28 RD-14 611-E139 PU-16 38 611-C38 PU-16 F702-C1 GN-18 200-C74 BK-16
H14
1 901-U22 WH-18 901-U22 WH-18 22 901-CA47 WH-18 E906-CA38 OR-18 K952-CA53 BR-16 4 K952-E237 BR-16 H18 118-E109 GY-16 12 118-AE12 GY-16 124-E118 GN-14 1 124-G1 GN-14 516-G3 GN-14 614-E230 PU-16 39 614-C39 PU-16 F710-C4 BR-16 207-C30 BK-16 WIRE AS.
2 922-U52 BR-18 752-U23 YL-18 23 752-CA40 YL-18 E907-CA39 GY-18 921-CA55 WH-18 5 921-E241 WH-18 515-E69 GY-14 2 515-G2 GY-14 619-E213 GN-16 40 619-C40 GN-16 G706-C45 BU-16 302-C25 OR-16 X 162-7267 01 C-6 CODE PLUG(735)TIPPER
OTG TEMP SW E963-CA46 BK-18 922-CA59 BR-18 6 922-E242 BR-18 E-C12 AE-C2 200-AE11 BK-16 516-E70 GN-14 3 516-G3 GN-14 C547-G10 OR-14 41 G707-C46 GN-16 304-C28 WH-16 H-C2 STER PRESS. SW AG 4P-7751 00 D-3 ALTERNATOR GROUND
3E-6449 CA-C17 754-U24 BU-18 24 754-CA41 BU-18
E964-CA65 WH-18 994-CA19 GY-16 7 994-E238 GY-16 CONN 21 1552252 3E5179 200-AE26 BK-16 522-E184 WH-14 4 522-G4 WH-14 42 G708-C47 GY-16 306-C27 GN-16 1552267 3E-6450 AH 200-6844 00 C-2 SEC STER ARC SUPPRSR
1552269 755-U25 OR-18 25 755-CA42 OR-18
900-U26 PU-18 26 900-CA43 PU-18 6734-CA49 YL-18 E737-CA20 PU-16 8 E737-E240 PU-16 200-E190 BK-16 1 200-AE24 BK-16 200-AE25 BK-16 A524-E66 BR-14 5 A524-G5 BR-14 517-G7 BU-14 43 G834-C41 PU-16 E789-C26 PU-16 417-H3 GY-16 A BK-16 xx 214-6817 00 F-12 LINK-DEMAND FAN(CAB)
BK-16 1 E737-CA20 PU-16 27 J823-CA44 YL-18 J823-CA44 YL-18 J812-CA23 PK-16 9 J812-E243 PK-16 113-E172 OR-16 2 113-AE1 OR-16 H19 200-E185 BK-14 6 200-G6 BK-14 44 G835-C42 OR-16 E963-C48 BK-18 J764-H4 BR-16 B RD-16 xx 214-6818 00 F-12 LINK-DEMAND FAN(CAB)
BK-16 2 J764-CA17 BR-16 921-U28 WH-18 28 921-CA55 WH-18 J832-CA33 YL-18 G705-CA63 GN-16 10 G705-E164 GN-16 320-E134 OR-18 3 320-AE16 OR-16 517-E71 BU-14 7 517-G7 BU-14 RESISTOR G706-E84 BU-16 45 G706-C45 BU-16 H420-C20 PU-18 E964-C49 WH-18 C BU-16

H53
T° 922-U29 BR-18 29 922-CA59 BR-18 J764-CA31 BR-18 E790-CA61 PK-16 11 E790-E177 PK-16 322-E191 GY-16 4 322-AE17 GY-16 A525-E65 GN-14 8 A525-G8 GN-14 125-9740 G707-E99 GN-16 46 G707-C46 GN-16 J764-C24 BR-16 200-C66 BK-14
U-C14 TWISTED PAIR E964-U30 WH-18 30 E964-CA65 WH-18 K977-CA32 PK-18 G704-CA60 YL-16 12 G704-E98 YL-16 114-E112 RD-16 5 114-AE14 RD-16 A523-E129 PU-14 9 A523-G9 PU-14 G708-E104 GY-16 47 G708-C47 GY-16 A300-C79 GN-18 CABLE AS.
XMSN OUTPUT SPEED SNSR A 1552269 E963-U31 BK-18 31 E963-CA46 BK-18 L910-CA22 PK-18 432-CA54 PK-16 13 432-E2 PK-16 610-E13 OR-16 6 610-AE27 OR-16 10 515-G2 GY-14 515-G16 GY-14 48 E963-C48 BK-18 A301-C78 WH-18 V-C2 V-C3 AA 193-7895 00 B-3 STARTER
191-8304 BK-18 1 E901-U19 GN-18 L911-CA21 YL-18 G834-CA67 PU-16 14 G834-E251 PU-16 619-E14 GN-16 7 619-AE29 GN-14 AE-C3 C547-E68 OR-14 11 C547-G10 OR-14 200-G20 BK-14 49 E964-C49 WH-18 175-C63 RD-14 175-C82 RD-14 1552269 3E3364 AF 131-1449 00 F-2 STARTER ENG GROUND
32 1552273
OTG LOW OIL PRESS SW WH-18 2 E900-U18 WH-18 33 T900-CA48 GN-18 T900-CA48 GN-18 G835-CA66 OR-16 15 G835-E252 OR-16 614-E229 PU-16 8 614-AE22 PU-16 12 200-G6 BK-14 454-E123 GN-18 50 454-C118 GN-18 175-C77 RD-14 C542-V3 GN-16 1 WH-18 CC 206-0154 00 B-3 BATTERY LINK
3E-7692 CA-C18 6734-CA49 YL-18 16 113-E197 OR-16 9 113-AE23 OR-16 200-AE25 BK-16 1 GROUND 200-G18 BK-14 51 200-V4 BK-16 2 BK-18 EE 190-7429 00 B-4 STARTER GROUND
1552269 U-C15 TWISTED PAIR
34
17 662-E52 YL-18 10 662-AE18 YL-16 614-AE22 PU-16 2 LIGHTS
CONN 25 52 397-C80 OR-14 FF 193-7316 00 I-3 DISCONNECT GROUND
BK-18 1 994-CA19 GY-16 XMSN OUTPUT SPEED SNSR B 1552269
35
TWISTED PAIRS 18 CONN 19 661-E51 GN-18 11 661-AE19 GN-16 113-AE23 OR-16 3 + BATTERY CBL-MM1 BK-4 CONN 31 53 398-C81 BU-14 HEATED MIRROR RH GG 190-6300 00 I-3 DISCONNECT
J764-CA18 BR-16 191-8305 E907-U21 GY-18
36
663-E231 GY-18 663-AE20 GY-16 662-AE18 YL-16 C542-C60 GN-16 110-0017 -ATCH HH 193-7892 00 G-2 SEC STER RELAY TO MOTOR
BK-18 2 BK-18 1 37 19 12 4 SPEEDOMETER LAMP T° 54
WH-18 2 E906-U20 OR-18 20 661-AE19 GN-16 5 TACHOMETER LAMP 55 200-C67 BK-14 JJ 192-5877 00 B-3 BATTERY TO BUS BAR
21 E-C10 AE-C10 663-AE20 GY-16 6 GAGE LAMP TEMPERATURE SW 56 200-C76 BK-14 KK 193-7894 00 G-2 SEC STER MOTOR TO GND
U-C16 TWISTED PAIR 1552272 3E-5464
ENG SPEED SNSR 1552269 WIRE GROUP COLOR DESCRIPTIONS 22 3E3376
CAT MON SYS DIMMER
57 200-C66 BK-14 LL 193-7896 00 G-2 SEC STER RELAY TO BUS
RH REVERSE LAMP 23 317-E202 YL-16 1 317-AE30 YL-16 103-5526 522-G4 WH-14 522-G4 WH-14 58 200-C2 BK-16 H-C3 H-C4 PP 193-7317 02 B-3 START RECEPTACLE
172-9973 193-0421 BK-18 1 E963-U31 BK-18 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. 24 F710-E204 BR-16 2 F710-AE31 BR-16 59 200-C73 BK-16 V-C1 RR 162-7264 01 F-5 RADIO ANTENNA COAXIAL
A-C3 LOW BRAKE OIL PRESS SW CA-C19 WH-18 2 E964-U30 WH-18 165-E227 YL-16 3 165-AE33 YL-16 H25 G-C3 FRAME GND 2 CAB GND 60 C542-C60 GN-16 1552269 3E3364 3E3364
1552269 172-7073 1552269 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. 998-E203 BR-16 4 998-AE32 BR-16 1552269 61 C542-C33 GN-16 C542-C71 GN-16 C542-H6 GN-16 1 1 C542-V1 GN-16 STRAP AS.
A WH-18 1 612-A16 GY-16 BK-16 A 432-CA54 PK-16 FILTER BYPASS SW CONN 20 515-G17 GY-14 1 WH/RD-14 BLOWER MOTOR 62 J764-C70 BR-16 200-H1 BK-16 2 2 200-V2 BK-16 MM 7G-1060 00 B-7 CAB TO FRAME GROUND A
BK-18 2 200-A4 BK-16 RD-16 B 201-CA45 BK-16 116-9846 U-C17 VOLTAGE CONVERTER OUTPUT CIRCUIT. RELAY PANEL 200-G19 BK-14 2 BK-14 MOTOR 174-1494 63 J764-C24 BR-16 J764-C107 BR-16
BU-16 C 1552269 64 CONN 38 THIS DIAGRAM IS FOR THE 735 ARTICULATED DUMP
H19
BK-18 1 426-U10 BR-18 STARTING CIRCUIT. 65 398-C81 BU-14 TRUCK (152-0975 CHG 00) RM576
BK-18 2 202-U11 BK-18 66 397-C80 OR-14
GROUND CIRCUIT. 67
H52
RH STOP TAIL TURN LAMP OPERATOR STATION 68 V-C4 AUX. RH
149-5534 OIL TEMP SNSR U-C6 STARTING AID CIRCUIT. 69 201-C17 BK-16 1552269 HEATED-MIRROR
A-C6 118-7226 1552267 70 406-C34 PU-16 C542-V5 GN-16 1 ATCH COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE
1698671 +V OR-18 A 709-U12 OR-18 CATERPILLAR MONITORING CIRCUIT. 417-C23 GY-16 200-V6 BK-16 2 MACHINE WITH THE KEY AND ENGINE OFF, THE XMSN
S RD-16 1 604-A8 OR-16 GROUND BK-18 B J764-U13 BR-18 447-C7 PK-16 SHIFTER IN NEUTRAL AND THE PARK BRAKE SW IN THE
T WH-16 2 614-A12 PU-16 SIGNAL WH-18 C K977-U14 PK-18 ENGINE CONTROL CIRCUIT (MASTER ). 709-C35 OR-16 FUEL LEVEL SENDER OFF POSITION.
T BR-16 3 606-A11 GY-16 H12 727-C19 GN-16 H-C5 157-8859
BK-16 4 200-A2 BK-16 TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT. H420-C20 PU-18 1552269 NOTE A: RADIO OPTIONS
HEATER AND AIR CONDITIONER CIRCUIT. 447-H5 PK-16 1 PK-18 3E-6106 (EUROPEAN VERSION - REMOVABLE)
201-H2 BK-16 2 BK-18 3E-6107 (EUROPEAN VERSION - FIXED)
TURN SIGNAL/WIPER/WASHER CIRCUIT. 173-6532 (AMERICAN VERSION - REMOVABLE)
173-6530 (AMERICAN VERSION - FIXED)

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1