MAXIMUM GVW

324318 kg 715,000 lb
PAYLOAD
177-186 t 195-205 U.S. ton
GROSS HORSEPOWER
1491 kW 2,000 HP

ELECTRIC DRIVE TRUCK

S
SPECIFICATIONS
PECIFICATIONS
ENGINE FRAME

Make and model . . . . . . . . . . . . . . . . . . . . . Komatsu SSA16V159

Fuel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Diesel Advanced technology, full butt-welded box-sectional
Number of cylinders . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 ladder-type frame with integral ROPS supports, integral
Operating cycle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 stroke front bumper, rear tubular cross members, steel castings
*Rated brake power . . . . . . . . . . . 1492 kW 2,000 HP @ 1900 rpm at all critical stress transition zones, rugged continuous
**Flywheel power . . . . . . . . . . . . . 1388 kW 1,860 HP @ 1900 rpm horsecollar.
Weight (wet) . . . . . . . . . . . . . . . . . . . . . . . . . . . 5294 kg 11,670 lb Plate material . . . . . . . . . . . . . . . . . . . . . . . . 482.6 mPa 70,000 psi
NOTE: This engine includes the Engine Monitor System tensile strength steel
*Rated brake power is the output of the engine as installed in this machine, at governed rpm and with engine Casting material . . . . . . . . . . . . . . . . . . . . . . 620.5 mPa 90,000 psi
manufacturer’s approved fuel setting. Accessory losses included are water pump, fuel pump and oil pump.
**Flywheel power is the rated power at the engine flywheel minus the average accessory losses. tensile strength steel
Accessories include fan and charging alternator. Rating(s) represent gross engine performance in
Rail width . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 279 mm 11''
accordance with SAE J1349 conditions.
Rail depth (minimum) . . . . . . . . . . . . . . . . . . . . . . . . . . 813 mm 32''
Top and bottom plate thickness. . . . . . . . . . . . . . . . . . 32 mm 1.25''
ELECTRIC DRIVE Side plate thickness . . . . . . . . . . . . . . . . . . . . . . . . . . 19 mm 0.75''
AC/DC CURRENT Drive axle mounting . . . . . . . . . . . . . . . . . . . . . . . . High-mount ball
Alternator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . G.E. GTA-22 and socket joint at front
Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . Statex III Fuelsaver Drive axle alignment . . . . . . . . . . . . Swing link between frame and axle
*Motorized wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . G.E. 788
**Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26.825:1
Speed (maximum) . . . . . . . . . . . . . . . . . . . 55.7 km/h 34.6 mph BRAKING SYSTEM
*Wheel motor application depends upon gross vehicle weight, haul road grade, haul road length,
rolling resistance and other parameters. Komatsu and G.E. must analyze each job condition to
assure proper application. Service brakes: all-hydraulic actuated
**Optional ratios available. Front. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel speed disc.
Three calipers on a 1168 mm 46.0" O.D. disc.
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . Dual disc armature speed.
TIRES AND RIMS Two 635 mm 25" O.D. discs per side.
Rock service, tubeless, tires One caliper per disc.
*Standard tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37.00 R57 Emergency brakes . . . . . . . . . . . . . . . . . Automatically applied prior
Standard five (5) piece rim to hydraulic system pressure dropping below level
686 mm x 1488 mm x 152 mm 27'' x 57'' x 6'' patented Phase II required to meet secondary stopping requirements.
New Generation rim assembly with patented 152 mm 6'' double Wheel brake locks . . . . . . . . . . . . . . . . . . . . . . . . . Switch activated
forged flanges. Not interchangeable with other manufacturers’ rims
Parking brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Spring-applied,
due to improved design for greater load support and longer fatigue
hydraulically released, with speed application protection.
life. Rated at 827 kPa 120 psi cold inflation pressure.
Electric dynamic retarder (max.) ...........................2759 kW 3,700 hp
*Tires should meet application requirements for tkph/tmph, tread, compound, inflation pressure, ply rating or equivalent, etc. Continuously rated (18 element) blown grids. Two-speed overspeed
retarding. Extended range retarding. Reverse retarding.

BODY SUSPENSION

HYDRAIR® II
All-welded steel flat floor body with horizontal bolsters and full canopy.
Eyebrow, rear wheel rock ejectors, body tilt cable, and rubber mounts Variable rate hydro-pneumatic with integral rebound control.
on frame are standard. Pivot exhaust heating optional. Maximum stroke . . . . . . . . . . . . . . . . . . . . . Front 335 mm 13.2''
Bottom plate . . . . . . . . . . . . 19 mm 0.75'' 1034 mPa 150,000 psi Rear 279 mm 11.0''
tensile strength steel (two-piece) Maximum rear axle oscillation . . . . . . . . . . . . . . . . . . . . . . +9.75º
Front sheet . . . . . . . . . . . . . . 12 mm 0.47'' 690 mPa 100,000 psi
tensile strength steel
Side sheet . . . . . . . . . . . . . . . 9 mm 0.35'' 690 mPa 100,000 psi COOLING SYSTEM
tensile strength steel
Struck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 m3 101 yd3 L&M radiator assembly with sight gauge. Deaeration-type
Standard SAE heaped 2:1 . . . . . . . . . . . . . . . . . . 111 m3 145 yd3 top tank. Dual pass cooling.
Radiator frontal area. . . . . . . . . . . . . . . . . . . . . . . 4.33 m2 46.6 ft2

CAB
SERVICE CAPACITIES
Advanced Operator Environment with integral 4-post ROPS/FOPS
structure (meets J1040 Apr88), adjustable air suspension seat with Cooling system . . . . . . . . . . . . . . . . . . . . . . .409 L . . 108 U.S. gal
lumbar support and arm rests, passenger seat, maximum R-value *Crankcase . . . . . . . . . . . . . . . . . . . . . . . . . .223 L . . . 59 U.S. gal
insulation, tilt and telescoping steering wheel, electric windshield Hydraulic system . . . . . . . . . . . . . . . . . . . . . .731 L . . 193 U.S. gal
wipers with washer, tinted safety glass, power windows, Komatsu Motor gear box . . . . . . . . . . . . . . . . . . . . . . . .40 L . . 10.5 U.S. gal
Payload Weighing System, 55,000 Btu/hr heater and defroster, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3217 L . . 850 U.S. gal
*Includes lube oil filters
21,600 Btu/hr air conditioning (HFC - 134A refrigerant).
 730E
ELECTRIC DRIVE TRUCK

DIMENSIONS

7.54 m 24'9"
8.43 m 27'8" 3.43 m 11'3" 7.25 m 23'9"
12.51 m
41'1"
RAISED

2.08 m
6'10"
5.61 m 6.25 m
18'5" 2.90 m 20'6"
9'6" EMPTY

45°
1.76 m
5'9" 1.14 m 3'9" 4.44 m 14'7"

3.66 m 12'0" 5.89 m 19'4" 3.28 m 10'9" 5.57 m 18'3"

12.83 m 42'1" 6.68 m 21'11"

All dimensions are with 111 m3 145 yd3 body.

7.25 m 23'9"

Bodies Struck 2:1 Heap Loading

6.85 m 22'6"
Height*
Standard 77 m3 101 yd3 111 m3 145 yd3 5.61 m 18'5''
*Exact load height may vary due to tire make, type, and inflation pressure.

HYDRAULIC SYSTEM
2.32 m
7'7"
Steering. . . . . . . . . . . . Accumulator-assisted twin cylinders provide
constant rate steering. Emergency power steering 4.68 m 15'4"
automatically applied by accumulator (meets SAEJ1511) 7.03 m 23' 1"

Turning circle diameter (SAE) . . . . . . . . . . . . . . . . . . . 28.0 m 92 ft

Reservoir. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 731 L 193 U.S. gal
Filtration . . . . . . . . . . . . . . . . . . . . . . . In-line replaceable elements
Suction . . . . . . . . . . . . . . . . . . . . . . . . Single, full-flow, 100 mesh
Hoist and steering . . . . . . . . Dual, full-flow, in-line, high-pressure
β12 = 200 ELECTRICAL SYSTEM
Brake component cabinet . . . . . . . . . Above-deck, easily accessible
with diagnostic test connector. 4 x 8D 1450 CCA, 12 volt batteries, in series/parallel, bumper-
Hoist . . . . . . . . . . . . . . Two 3-stage dual-acting outboard cylinders, mounted with disconnect switch.
internal cushion valve. Alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt, 240 amp
Hoist times Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt
Power-up loaded . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 sec
Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Two 24-volt
Power-down . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 sec
Float-down empty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 sec
Pumps
Hoist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gear-type pump WEIGHT DISTRIBUTION
with output of 513 liters 135.6 gpm
@1900 rpm and 17240 kPa 2500 psi Empty Vehicle kg lb %
Steering and brake . . . . . . . . . . . . . . . . . . . . . . Vane-type pump Front axle . . . . . . . . . . . . . . . . . . . . . . 66160 145,858 47.2
with output of 235 liters 62.0 gpm Rear axle . . . . . . . . . . . . . . . . . . . . . . .72209 159,194 52.8
@1900 rpm and 18960 kPa 2,750 psi Total (wet, 50% fuel) . . . . . . . . . . . . .138369 305,052
System relief pressures
Hoist. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17240 kPa 2,500 psi
Steering and brake . . . . . . . . . . . . . . . . . . . 27580 kPa 4,000 psi Loaded Vehicle at maximum GVW rating
Quick disconnects standard for powering disabled truck Front axle . . . . . . . . . . . . . . . . . . . . . .98941 218,129 33.7
and for system diagnostics. Rear axle . . . . . . . . . . . . . . . . . . . . . .225377 496,871 66.3
Total . . . . . . . . . . . . . . . . . . . . . . . . . .324318 715,000
NOTE: GVW shall not exceed 324 318 kg 715,000 lb including options, liners, fuel and
payload, subject to application approval by Komatsu.

NOTE: Komatsu trucks comply with SAE specifications for cab noise, ROPS, steering and
braking. Cover photos and illustrations may show optional equipment. Materials and
specifications subject to change without notice.
 STANDARD EQUIPMENT

● Air cleaners, dry type SRG ● Exhaust blankets ● Headlight switch

● Alternator (24V/240A) ● Hoist propulsion interlock ● Heater and defroster (heavy-duty)
● Auto lubrication system ● Horns (back-up, front - electric) ● Heater switch
● Batteries (4 x 8D, 1450 CCA 12 volt) ● Maintenance and power lockout ● High beam selector and indicator
● Battery charging cabel and socket ● Parking brakes with warning light and ● Indicator lights (amber): check engine
● Body left-side canopy protector speed application protection w/alarm; circuit breaker tripped; dynamic
● Body over center device ● Power steering w/auto emergency steering retarding; dump body up; hydraulic oil
● Brakes: Wheel speed disc front; rear - ● Protective deck handrails filter; low fuel level; manual back-up
dual disc armature speed ● Pump driveline protector lights; park brakes applied; retard speed
● Electric start ● Radiator fan guard control; service brakes
● Fast-Fill Fuel System (in tank, right side) ● Seat belts (wide, retractable) ● Horn (center of steering wheel)
● FLOC - fast lube oil change ● Skid-resistant coating on walkways ● Independent brake/retarder pedals
● Filters, high pressure hydraulic ● Slippery road brake switch ● RS232 port - Statex III-PLM III
● Gate valves on hydraulic tank ● 24-volt circuit breakers ● Insulation (extra thick) R-12
● Komatsu control cabinet CAB: ● Integral roll-over protection (ROPS)
● Komatsu Payload Weighing System–PLM III ● Operator seat, adjustable w/air
● Air cleaner vacuum gauges
● Mirrors, LH flat and RH rectangular convex suspension, lumbar support and arm rests
● Air conditioner HFC 134A
● Mud flaps ● Panel lighting (adjustable)
● Alarm System warning lights (red)
● Muffled exhaust, deck-mounted - Accumulator pre-charge ● Passenger seat
● On board load box - Coolant low level w/alarm ● Power windows
● Power supply, 24V to 12V DC - Coolant high temperature w/alarm ● Pressurized cab air system
● Quick disconnects (hoist, steering) - Electric drive system cooling blower ● Starter key switch
● Removable power module unit (radiator, w/alarm ● Sunvisor (adjustable)
engine, alternator, blower) - Electric system fault w/alarm ● Tilt and telescoping steering wheel
● Rock ejectors - Hydraulic oil level w/alarm ● Voltmeter (battery output)
● Radiator sight gauge - Hydraulic oil temperature w/alarm ● Wheel brake lock w/drive system
● Retard speed control - Low engine oil pressure w/alarm interlock
● Reverse retarding - Low brake pressure w/alarm ● Windshield wipers, dual, washer (electric)
● Thermostatic fan clutch - Motorized wheel temperature stop ● Windshield (tinted safety plate)
● Two-speed overspeed retarding engine w/alarm
LIGHTING:
● Vari-volt alternator control - Steering pressure w/alarm
● AM/FM cassette radio ● Back-up lights-rear mount (2)
● Vertical ladders
● Engine monitoring system ● Brake and retard lights on top of cab
● Digital tachometer and speedometer ● Clearance lights (amber–front; red–rear)
SAFETY: ● Control cabinet service light
● Dome light
● All hydraulic service brakes with ● Double door seals ● Dynamic retarding, rear (2)
emergency auto apply ● Engine hourmeter, oil pressure gauge, ● Headlights - bumper (4) halogen
● Battery disconnect switch water temperature gauge ● Ladder lights
● Body prop cable ● Engine shutdown w/5 minute delay timer ● Manual back-up light switch and indicator
● Brake lock and drive system interlock ● Floor mat ● Service light in rear axle
● Dynamic retarding with continuous rated ● Fuel gauge in cab and on tank ● Stop and tail lights (2)
18-element grids ● Gauges (backlit) ● Turn signals
● Engine shutdown at ground level ● Under-hood service lights

OPTIONAL EQUIPMENT
(Optional equipment may change operating weight).
● Additional high-mounted headlights ● Exhaust-heated body ● Mufflers between rails
● Air cleaner evacuators ● Filtered air inlet system ● Pressure fueling, LH remote*
● Arctic protection package (suspensions, ● Fire extinguisher ● Radiator shutters
antifreeze/lube below -40º C) ● Fog lights–Halogen (2) lower grille ● Trolley assist package
● Back-up lights, deck mounted ● Hot start (engine oil, coolant, hydraulic tank) ● Service Center
● Body liners* ● Hubometer (miles or kilometers)

*Available factory-installed or non-installed. All other options and accessories listed are available factory installed only.

AESS564-01 ©2001 Komatsu Printed in USA DK11(3M)EH Datakom 11/01 (EV-1)

Komatsu Mining Systems, Inc.

568 Atrium Drive
P.O. Box 8131
Vernon Hills, IL 60061-8131

www.komatsumining.com Materials and specifications are subject to change without notice

is a trademark of Komatsu Ltd. Japan