OTB

OILS, MISCELLANEOUS: TURBINE

CAUTIONARY RESPONSE INFORMATION 4. FIRE HAZARDS 7. SHIPPING INFORMATION

4.1 Flash Point: 7.1 Grades of Purity: Solvent refined paraffinic oils;
Common Synonyms Liquid Colorless to light brown Kerosene-like 390–485°F O.C. 98.5+%. Grades vary in viscosity and flash
Steam turbine lube oil odor 4.2 Flammable Limits in Air: Not pertinent point.
Steam turbine oil 7.2 Storage Temperature: Ambient
4.3 Fire Extinguishing Agents: Dry
Turbine oil
Floats on water. chemical, foam, carbon dioxide, water 7.3 Inert Atmosphere: No requirement
fog.
7.4 Venting: Open (flame arrester)
Keep people away. 4.4 Fire Extinguishing Agents Not to Be
Call fire department. Used: Water or foam may cause 7.5 IMO Pollution Category: Currently not available
Notify local health and pollution control agencies. frothing; water may be ineffective. 7.6 Ship Type: Currently not available
Protect water intakes. 4.5 Special Hazards of Combustion 7.7 Barge Hull Type: Currently not available
Products: Not pertinent
Combustible.
Fire Extinguish with dry chemicals, foam or carbon dioxide.
4.6 Behavior in Fire: Not pertinent
8. HAZARD CLASSIFICATIONS
4.7 Auto Ignition Temperature: 700°F
Water may be ineffective on fire. 8.1 49 CFR Category: Not listed
4.8 Electrical Hazards: Not pertinent
8.2 49 CFR Class: Not pertinent
Call for medical aid. 4.9 Burning Rate: (approx.) 4mm/min.
Exposure 4.10 Adiabatic Flame Temperature: Currently
8.3 49 CFR Package Group: Not listed.
VAPOR not available 8.4 Marine Pollutant: No
Irritating to eyes, nose and throat. 4.11 Stoichometric Air to Fuel Ratio: Not 8.5 NFPA Hazard Classification:
Move victim to fresh air. pertinent.
If breathing is difficult, give oxygen. Category Classification
4.12 Flame Temperature: Currently not Health Hazard (Blue).......... 0
LIQUID available Flammability (Red)............. 1
Irritating to skin and eyes. 4.13 Combustion Molar Ratio (Reactant to
Instability (Yellow)............. 0
Harmful if swallowed. Product): Not pertinent.
Remove contaminated clothing and shoes. 4.14 Minimum Oxygen Concentration for 8.6 EPA Reportable Quantity: Not listed.
Flush affected areas with plenty of water. Combustion (MOCC): Not listed 8.7 EPA Pollution Category: Not listed.
IF IN EYES, hold eyelids open and flush with plenty of water.
IF SWALLOWED and victim is CONSCIOUS, have victim drink water 8.8 RCRA Waste Number: Not listed
or milk. 5. CHEMICAL REACTIVITY 8.9 EPA FWPCA List: Not listed
DO NOT INDUCE VOMITING.
5.1 Reactivity with Water: No reaction
Effect of low concentrations on aquatic life is unknown. 5.2 Reactivity with Common Materials: No 9. PHYSICAL & CHEMICAL
Water Fouling to shoreline. reaction PROPERTIES
Pollution May be dangerous if it enters water intakes. 5.3 Stability During Transport: Stable
9.1 Physical State at 15° C and 1 atm: Liquid
Notify local health and wildlife officials. 5.4 Neutralizing Agents for Acids and
Notify operators of nearby water intakes. Caustics: Not pertinent 9.2 Molecular Weight: Not pertinent
5.5 Polymerization: Not pertinent 9.3 Boiling Point at 1 atm: Not pertinent
5.6 Inhibitor of Polymerization: Not pertinent 9.4 Freezing Point: Not pertinent
9.5 Critical Temperature: Not pertinent
1. CORRECTIVE RESPONSE ACTIONS 2. CHEMICAL DESIGNATIONS
Stop discharge 6. WATER POLLUTION 9.6 Critical Pressure: Not pertinent
2.1 CG Compatibility Group: 33;
Contain Miscellaneous hydrocarbon mixture 9.7 Specific Gravity: 0.87 at 20°C (liquid)
6.1 Aquatic Toxicity:
Collection Systems: Skim 2.2 Formula: Not pertinent 9.8 Liquid Surface Tension: 25 dynes/cm =
Currently not available
Clean shore line 2.3 IMO/UN Designation: Not listed 0.025 N/m at 20°C
Salvage waterfowl 6.2 Waterfowl Toxicity: Currently not
2.4 DOT ID No.: Not listed available 9.9 Liquid Water Interfacial Tension: 50
2.5 CAS Registry No.: Currently not available dynes/cm = 0.050 N/m at 20°C
6.3 Biological Oxygen Demand (BOD):
2.6 NAERG Guide No.: Not listed
Currently not available 9.10 Vapor (Gas) Specific Gravity: Not pertinent
2.7 Standard Industrial Trade Classification:
33450 6.4 Food Chain Concentration Potential: 9.11 Ratio of Specific Heats of Vapor (Gas):
None Not pertinent
3. HEALTH HAZARDS 6.5 GESAMP Hazard Profile: Not listed 9.12 Latent Heat of Vaporization: Not pertinent
3.1 Personal Protective Equipment: Goggles or face shield; rubber gloves. 9.13 Heat of Combustion: (est.) –17,600 Btu/lb
3.2 Symptoms Following Exposure: Contact with liquid causes slight irritation of eyes and (on prolonged = –9,800 cal/g = –410 X 105 J/kg
contact) skin. Ingestion causes slight irritation of stomach and bowel, increased frequency of
9.14 Heat of Decomposition: Not pertinent
bowel movement.
3.3 Treatment of Exposure: EYES: wash with copious quantity of water for at least 15 min. SKIN: wipe 9.15 Heat of Solution: Not pertinent
off; wash with soap and water. INGESTION: do NOT induce vomiting; do NOT lavage; 2-4 oz. 9.16 Heat of Polymerization: Not pertinent
olive oil and 1-2 oz. activated charcoal may be given. 9.17 Heat of Fusion: Currently not available
3.4 TLV-TWA: Not listed.
9.18 Limiting Value: Currently not available
3.5 TLV-STEL: Not listed.
9.19 Reid Vapor Pressure: Currently not
3.6 TLV-Ceiling: Not listed.
available
3.7 Toxicity by Ingestion: Grade 0; LD50 > 15 g/kg (rat)
3.8 Toxicity by Inhalation: Currently not available.
NOTES
3.9 Chronic Toxicity: Currently not available
3.10 Vapor (Gas) Irritant Characteristics: Currently not available
3.11 Liquid or Solid Characteristics: Currently not available
3.12 Odor Threshold: Currently not available
3.13 IDLH Value: Not listed.
3.14 OSHA PEL-TWA: Not listed.
3.15 OSHA PEL-STEL: Not listed.
3.16 OSHA PEL-Ceiling: Not listed.
3.17 EPA AEGL: Not listed

JUNE 1999
 OTB
OILS, MISCELLANEOUS: TURBINE

9.20 9.21 9.22 9.23

SATURATED LIQUID DENSITY LIQUID HEAT CAPACITY LIQUID THERMAL CONDUCTIVITY LIQUID VISCOSITY

Temperature Pounds per cubic foot Temperature British thermal unit per Temperature British thermal unit inch Temperature Centipoise
(degrees F) (degrees F) pound-F (degrees F) per hour-square foot-F (degrees F)

42 55.210 52 0.480 35 0.918 N

44 55.140 54 0.480 40 0.917 O
46 55.070 56 0.480 45 0.916 T
48 55.000 58 0.480 50 0.915
50 54.930 60 0.480 55 0.914 P
52 54.860 62 0.480 60 0.913 E
54 54.790 64 0.480 65 0.912 R
56 54.720 66 0.480 70 0.911 T
58 54.650 68 0.480 75 0.909 I
60 54.580 70 0.480 80 0.908 N
62 54.520 72 0.480 85 0.907 E
64 54.450 74 0.480 90 0.906 N
66 54.380 76 0.480 95 0.905 T
68 54.310 78 0.480 100 0.904
70 54.240 80 0.480 105 0.903
72 54.170 82 0.480 110 0.902
74 54.100 84 0.480 115 0.900
76 54.030 86 0.480 120 0.899
78 53.960
80 53.890
82 53.820
84 53.750
86 53.680

9.24 9.25 9.26 9.27

SOLUBILITY IN WATER SATURATED VAPOR PRESSURE SATURATED VAPOR DENSITY IDEAL GAS HEAT CAPACITY

Temperature Pounds per 100 pounds Temperature Pounds per square inch Temperature Pounds per cubic foot Temperature British thermal unit per
(degrees F) of water (degrees F) (degrees F) (degrees F) pound-F

I N N N
N O O O
S T T T
O
L P P P
U E E E
B R R R
L T T T
E I I I
N N N
E E E
N N N
T T T

JUNE 1999