Sterrad 100nx
Sterrad 100nx
User’s Guide
Ref 99994
T
AF
R
D
M-99994_03
May 2014
T
AF
R
1-888-STERRAD ASP U.S.A. Professional Services
ASP International 949-581-5799
Please visit www.aspjj.com
D
For warranty information, please visit our website or contact ASP Professional Services.
ASP International Customer Support; call your local ASP Representative
©. 2008-2014 Division of Ethicon. All rights reserved. STERRAD®, CYCLESURE®, SEALSURE®, APTIMAX® and 100NX®
are registered trademarks of Advanced Sterilization Products (ASP). Teflon®, Delrin®, and Tyvek® are registered trademarks of
E.I. du Pont de Nemours and Company. Radel® is a registered trademark of Solvay SA. Kraton® is a registered trademark of
Kraton Polymers LLC. Santoprene™ is a trademark of ExxonMobil Corporation. Ultem® is a registered trademark of SABIC. da
Vinci® is a registered trademark of Intuitive Surgical, Inc. Other products mentioned in this publication are trademarked by their
respective owners. Please note: the screen displays shown in this guide are for reference only. The actual displays on your system
may be slightly different depending on your system’s configuration and software revision. Reproduction, adaptation, or translation
of this publication without prior written permission is prohibited. Printed in the U.S.A.
Chapter 1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
How to Use This Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Intended Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
The STERRAD® Sterilization Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
If You Have Questions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
T
Personal Protective Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Device Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Warnings, Cautions, and Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
AF
Chapter 3. Load Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Load Weight Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Cycles and Materials Processing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Recommended Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Thermoplastics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Thermoplastic Elastomers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Thermosetting Elastomers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
R
Metal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Items Not To Be Processed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Do Not Process in the EXPRESS Cycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Do Not Process in the DUO Cycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Guidelines for Preparing Items to Be Sterilized . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
D
T
Inserting a Cassette . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Cycle in Progress . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Canceling a Cycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Cycle Completed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
AF
Processing a Sterilized Load . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Inspecting Chemical Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Processing Biological Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Chapter 5. Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Running Diagnostics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
System Message Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Temperature Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Messages Not In This Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
R
Call Your ASP Representative . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Sterilizer Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Cassette . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Cassette Disposal Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Touch Screen and Speaker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Chamber . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Printer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Touch Screen Data Entry . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
T
Rebooting the System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Sterilizer Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Set Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Time Zone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Date Format . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Time Format . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Cancel/Done . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
System Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Access Control Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
IMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Vacuum Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Load Data Entry Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Load Removal Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Notepad Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Network Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
T
Cassette Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Dispose Cassette . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Peroxide Clearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Network . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
AF
Diagnostics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Diagnostic Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Service Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
File Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Calibration Files . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Diagnostic Files . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Upload File . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Input/Output Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Product Options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
R
Appendix A. Sterilizer Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Introduction
T
If you are a STERRAD® 100NX® Sterilizer operator, you must read
the “Safety Information, “ the “Introduction,” “Load Preparation,” and
“Operation” chapters prior to operating the sterilizer. This “Introduction”
explains the features and parts of the sterilizer. “Load Preparation” explains
AF how to prepare and package instruments for processing. “Operation” explains
how to operate the sterilizer and obtain optimal results.
If you are a supervisor overseeing the STERRAD® 100NX® Sterilizer, you
should read the entire user’s guide and pay particular attention to the chapter
featuring “Access Levels and Supervisor Level Tasks.” This chapter describes
tasks and options that are only available through “Supervisor Level” access.
Intended Use
R
The STERRAD® 100NX® Sterilization System is a general purpose,
low temperature sterilizer which uses the STERRAD® 100NX® Process to
inactivate microorganisms on a broad range of medical devices and surgical
instruments.
D
T
devices, and can also sterilize instruments that have difficult-to-reach
(diffusion-restricted) spaces, such as hinges on forceps. Refer to the
“Safety Information” chapter for more information on device safety.
AF The sterilizer consistently provides a Sterility Assurance Level (SAL) of 10-6,
as defined by U.S. Food and Drug Administration (FDA) and international
standards, for clinical use on all allowed substrates within the limits of the
claims for materials and geometries when used in accordance with the
directions in this user’s guide.
Safety Information
T
Sterilizer. You must read and understand the safety information in this
chapter before operating the sterilizer. Always pay attention to the
warnings, cautions and notes throughout this user’s guide. This information is
for your safety and to ensure that you receive the most benefit from the safe
AF
Personal Safety and First Aid
operation of your STERRAD® 100NX® Sterilization System.
including paper, cotton, wood, or lubricants. Do not use or store near heat or open
flame. Shoes, clothing, or other combustible material that have come into contact with
hydrogen peroxide must be immediately and thoroughly rinsed with water to avoid a
potential fire hazard. In case of fire, use only water to extinguish.
T
WARNING! CONCENTRATED HYDROGEN PEROXIDE IS TOXIC
Ingestion of hydrogen peroxide may be life-threatening. If swallowed, call a “poison
control” center or physician immediately for treatment advice. Have the person drink
AF
plenty of water if the person is able to swallow. Do not give anything by mouth to an
unconscious person. Do not induce vomiting unless instructed to do so by the poison
control center or physician.
Please note that all STERRAD® Sterilizers should be used and installed in a well-
T
ventilated environment (a minimum of 10 air exchanges per hour).
Device Safety
R
WARNING! RISK OF INJURY OR DAMAGE TO STERILIZER
The STERRAD® 100NX® Sterilizer should not be used stacked with other
equipment.
Metal objects must not come into contact with the chamber walls, the door, or the
electrode. Contact with the walls, door, or electrode could damage the sterilizer or
the metal objects.
T
Improper processing may limit our liability for damage to processed instruments.
Improper processing may also violate your instrument warranty.
RF emissions CISPR 11 Class A The STERRAD® 100NX® Sterilizer is suitable for use
in all establishments other than domestic and those
T
directly connected to the public low-voltage power
supply network that supplies buildings used for
domestic purposes.
IEC 61000-3-3
T
are designed to provide reasonable protection against harmful interference
when the equipment is operated in a commercial environment. This
equipment generates, uses, and can radiate radio frequency energy and, if not
AF installed and used in accordance with the instruction manual, may cause
harmful interference to radio communications. Operation of this equipment in
a residential area is likely to cause harmful interference in which case the user
will be required to correct the interference at his own expense.
This device complies with Industry Canada license-exempt RSS standard(s).
Operation is subject to the following two conditions: (1) this device may not
cause interference, and (2) this device must accept any interference, including
interference that may cause undesired operation of the device.
Le présent appareil est conforme aux CNR d'Industrie Canada applicables aux
appareils radio exempts de licence. L'exploitation est autorisée aux deux
R
conditions suivantes : (1) l'appareil ne doit pas produire de brouillage, et (2)
l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi,
même si le brouillage est susceptible d'en compromettre le fonctionnement.
Notes are printed in italics and have a checkmark in front of the word “Note.”
Notes highlight specific information about the proper use and maintenance of the
sterilizer.
T
AF
R
D
Symbols
Hot surfaces present.
Do not touch without protection.
T
Oxidizing chemical present.
Avoid exposure, contact, or ingestion.
Use personal protective equipment.
AF
WEEE Symbol
I/O On/Off.
Alternating current.
Load Preparation
T
metal and nonmetal medical devices at low temperatures. The STERRAD®
sterilization process is a multiphase sterilization process that utilizes a
combination of exposure to hydrogen peroxide vapor and plasma to safely
sterilize medical instruments and materials without leaving toxic residue.
Because the cycle operates within a dry environment and at low temperatures,
AF it is especially suitable for instruments sensitive to heat and moisture.
CAUTION: KNOW WHAT YOU CAN PROCESS
Before processing items in the sterilizer, make sure you know how the STERRAD®
Sterilization Process will affect the item. When constructing your load, the total
weight of the load to be sterilized should not exceed the load requirements for the
specific cycle. If you have questions, or if you are in doubt about the materials in your
devices, contact the medical device manufacturer or your ASP Customer
Representative for more information.
R
CAUTION: RISK OF VIOLATION OF WARRANTY
Improper processing may limit our liability for damage to processed instruments.
Improper processing may also void your instrument warranty.
The weight of the items to be sterilized must conform to the weights used for
validating the sterilizer processes. These weights are listed in the following
table. The weight of the load depends on the cycle selected and whether one
or both shelves are used.
Cycle Type Weight Shelves
STANDARD Cycle 9.7 kg (21.4 lbs) total weight 1 or 2 shelves
DUO Cycle 6.0 kg (13.2 lbs) total weight 1 or 2 shelves
EXPRESS Cycle 4.9 kg (10.7 lbs) total weight Bottom shelf only
FLEX Cycle 9.7 kg (21.4 lbs) total weight 1 or 2 shelves
Processing Tubing
ASP has validated the processing of non-reusable polyethylene and
T
Teflon® (polytetrafluoroethylene) medical grade tubing with the
dimension and cycles listed below. (These tubing claims have not been
reviewed by the Food and Drug Administration (FDA) as the FDA does
AF not classify tubing as medical devices.):
An inside diameter of 1 mm or larger and a length of 1000 mm or
shorter can be processed in the STERRAD® 100NX® Sterilizer
STANDARD cycle.*
†The validation testing for this lumen size was conducted using a maximum of 10 lumens in the
USA; 40 lumens for markets outside the USA. Your loads should not exceed the validated
maximum number of lumens.
*Sterilize without any additional load. Up to 20 pieces of tubing may be sterilized at one time.
T
materials and dimensions can be processed in the STERRAD® 100NX®
Sterilizer FLEX cycle:
Single channel polyethylene and Teflon® (polytetrafluoroethylene)
flexible endoscope with an inside diameter of 1 mm or larger and length
AF
of 850 mm or shorter.**
Flexible endoscopes without lumens.
**One or two flexible endoscopes can be processed per sterilization cycle. No additional load.
T
you need materials information.
Check the medical device manufacturer’s instructions before loading any
item into the STERRAD® 100NX® Sterilizer.
There is a wide variety of materials and devices that can be sterilized in the
AF STERRAD® 100NX® Sterilizer. For more information contact your local
ASP Representative or visit our website at www.aspjj.com. Information may
also be obtained from the device manufacturer.
R
D
T
AF
R
D
T
AF
R
D
T
AF
R
D
Recommended Materials
There is a wide variety of materials and devices that may be sterilized in the
sterilizer. The materials listed below are commonly found in medical devices
and represent typical classes of materials used to construct medical devices.
The items marked with an asterisk (*) may have limited life after repeated
sterilization.
Please contact your ASP Representative for more information. Information
may also be obtained from the device manufacturer.
Thermoplastics
T
Ethylvinyl Acetate (EVA)
AF Kraton® Polymers
Liquid Crystal Polymer (LCP)
Polyacetal (Delrin® acetal resin)*
Polyamide (Nylon)*
Polycarbonate
Polyetheretherketone (PEEK)
Polyetherimide (ULTEM® Polymers)
Polyethylene
R
Polymethyl methacrylate (PMMA)*
Polyphenylene sulfone (Radel®)*
Polypropylene
Polystyrene
D
Polytetrafluoroethylene (Teflon®)
Thermoplastic Elastomers
Santoprene™
Glass
Glass
T
Metal
Aluminum
Brass
AF
Gold
Stainless steel
Titanium
resterilization.
Liquids and powders.
Items or materials that absorb liquids.
Items made of materials that contain cellulose, such as cotton, paper or
D
T
Items made of Polyurethane cannot be processed in the EXPRESS Cycle.
Items with mated Delrin® surfaces cannot be processed in the EXPRESS
Cycle.
Items with mated anodized aluminum surfaces cannot be processed in the
AF
EXPRESS Cycle.
Items with mated Radel® surfaces cannot be processed in the EXPRESS
Cycle.
Items with mated Ultem® surfaces cannot be processed in the EXPRESS
Cycle.
Items with lumens cannot be processed in the EXPRESS Cycle.
R
Do Not Process in the DUO Cycle
Items with mated anodized aluminum surfaces cannot be processed in the
DUO Cycle.
D
T
Cleaning and sterilization are two separate processes. Proper cleaning of
instruments and devices is a critical and necessary step prior to sterilization.
All items including accessories must be thoroughly cleaned, rinsed, and
AF
dried before loading into the sterilizer.
Carefully inspect all instruments, devices, and accessories for cleanliness
and dryness prior to packaging. If visible soil is present, the item must be
re-cleaned and dried prior to sterilization. If moisture is present, dry the
item thoroughly prior to sterilization.
Carefully inspect all instruments, devices, and accessories for flaws or
damage prior to packaging. Items with flaws or damage should be
replaced or repaired before using.
R
Note: Periodic careful inspection of items after repeated
exposure to disinfectant/cleaner/sterilant is necessary,
due to the potential damaging effects of the chemical
agents.
Cleaning is necessary to remove organic and inorganic soil and debris from
D
equipment. This process also removes many microorganisms from the surface
of the items. Sterilization then inactivates all remaining spores and live
microorganisms.
Clean your devices according to the medical device manufacturers'
instructions. You must remove all blood, tissue, and soil from items using
appropriate detergents, cleansers and/or methods.
Rinse items thoroughly to remove detergent or cleanser residue. Use
treated water that is of a quality that ensures hard water stains do not
occur. Failure to remove all organic materials or detergents may result in
the formation of light-colored residue on the devices. If residue is visible,
you should clean, rinse, dry, and resterilize the device prior to use.
T
when the surface of the load is handled.
Instrument Trays
T
Only STERRAD® Instrument Accessories and APTIMAX® Instrument
Trays, are recommended for use in the STERRAD® 100NX® Sterilizer.
AF These instrument trays are specially designed to allow diffusion of
hydrogen peroxide and plasma around every item in the load.
Tray Mats
Instrument trays should only be padded with STERRAD® Instrument
Mats or polypropylene sterilization wrap. Never use linen, cellulose, or
any materials listed in the “Items Not To Be Processed” section.
Follow the Instructions for Use included with the STERRAD®
Instrument Mats to determine the number of mats that can be used at one
R
time in the chamber. Do not use more than the recommended amount of
mat material in the chamber at any time.
Cycle Name Square Centimeters Square Inches
STANDARD 2250 349
DUO 2774 430
D
Do not use foam pads in instrument trays as they may absorb the
hydrogen peroxide.
Packaging
Use only STERRAD® Sterilizer-compatible polypropylene sterilization
wrap and Tyvek® pouches.Tyvek® Pouches and Rolls with STERRAD®
Chemical Indicators are the only pouches and rolls available on the
market that are validated by ASP. They are the only pouches and rolls
validated by ASP for efficacy and stability.
T
trays within trays. Do not wrap instruments within a wrapped tray.
If you are using rigid containers cleared by the FDA for use in the
STERRAD® 100NX® Sterilizer, follow the Instructions for Use provided
by the rigid container manufacturer. Verify that the rigid containers are
AF cleared for use in each sterilization cycle. Remember the following:
Do not stack instruments inside the containers.
Do not stack containers.
Do not stack containers within containers.
Do not wrap instruments within the containers.
Place STERRAD® Chemical Indicator Strips inside trays and pouches
as needed.
R
Loading
Do not allow any item to touch the walls of the sterilization chamber,
door, or electrode.
D
T
Chemical Indicators
STERRAD® Chemical Indicator Strips and STERRAD® SEALSURE®
AF Chemical Indicator Tape offer a method to verify that the load has been
exposed to hydrogen peroxide in the sterilizer. Chemical indicators are not a
substitute for biological indicators. If you use chemical indicator strips or
chemical indicator tape, follow the Instructions for Use that accompany these
items as you prepare the load.
Place STERRAD® Chemical Indicator Strips inside trays and
Tyvek® pouches or follow your facility’s procedures.
Secure all wraps with STERRAD® SEALSURE® Chemical Indicator
R
Tape.
Do not use chemical indicators or tape designed for other sterilization
processes.
Flexible endoscopes are sensitive and complex medical instruments. Read the
flexible endoscope manufacturer’s instructions for each endoscope before
preparation and loading into the sterilizer. Take special care to confirm that
venting caps are placed according to the manufacturer’s instructions. Venting
caps are intended to prevent damage to scopes that are being exposed to a
vacuum, regardless of the sterilant used.
In addition, if you are processing a flexible endoscope containing a water-
resistant “immersion” cap, you must remove the immersion cap prior to
processing. If the immersion cap is not removed prior to processing, it will
damage the scope due to the inability to properly vent.
T
AF
R
D
Operation
T
Each time you use the STERRAD® 100NX® Sterilizer, follow the
instructions provided in the “Load Preparation” chapter. It is your
responsibility to be familiar with the load preparation and safety
information provided in this user’s guide.
Biological Indicators
D
For the STERRAD® 100NX® DUO cycle in the United States, the
STERRAD® CYCLESURE 24 BI should only be used in a test pack
configuration. Instructions for use are provided in the test pack.
Login
Note: If your sterilizer has been configured not to require
operator login, the login screen will not appear. Skip to
the subsection titled Entering Load Information.
When you touch the “Touch Screen to Start” screen, the sterilizer displays the
T
Operator Login screen.
AF
R
D
T
Items can be typed into the screen or selected from a predefined list of items.
This information is stored and printed on a cycle report. It can also be
AF transferred to a host computer over a network connection.
R
D
1. To enter items not in the database, type the item information in the
“Enter Items Here” field. Touch ENTER to accept the item. Repeat for
additional items always touching ENTER after each item. Touch Done
when the list is complete.
2. An optional barcode scanner can be used to enter load item data. You may
use this feature if your sterilizer is equipped with this option.
T
Cycle Notes AF Note: If your sterilizer has been configured not to require
cycle notes, this screen will not appear.
The Cycle Notes screen allows you to enter information about the cycle.
For example; record information about biological indicators used in the
cycle or other information that should be stored in the cycle history file.
This information is printed on the cycle report, and can be transferred to
a host computer over a network connection.
R
D
1. Touch the Enter Notes for Cycle field. The cursor appears in the field.
T
AF
R
D
1. Open the active chamber door by pressing the Open Door foot pad, or by
touching Open Door on the display, and place your load on the shelves.
T
AF
R
Figure 4. Touch the Foot Pad to Open the door.
T
AF Figure 6. The Load Should NOT Touch the Electrode.
3. Do not allow any part of the load to touch the electrode, the back wall of
the chamber, or the inside of the door.
4. Leave at least 1 inch (25 mm) of free space between the load and the
electrode to allow hydrogen peroxide to diffuse around the load.
R
D
T
Figure 8. Load Correctly Placed for STANDARD Cycle Processing
AF
R
Figure 9. Load Correctly Placed for DUO and FLEX Cycle Processing
D
5. When you are finished loading the chamber, close the door by tapping the
foot pad or pressing the Close Door button on the touch screen.
6. If a message requesting that the door be closed is displayed, the door is
not securely closed. Make certain that nothing is caught in the door seal.
T
AF
Figure 10. Load Correctly Placed for EXPRESS Cycle Processing
R
D
T
AF
Figure 11. Touch the Screen to Start Your Cycle.
R
The screen displays the message “Please Insert New Cassette” if a new
cassette is required, if the cassette in the sterilizer is expired, or if there is
no cassette installed in the sterilizer. Follow the instructions in the next
section to insert a new cassette.
D
Touch your choice of cycle from those displayed and then touch confirm to
start the cycle; the cycle starts.
Cycle Types
STANDARD cycle sterilizes the load in about 47 minutes. This cycle is
installed on all systems.
DUO cycle is for sterilization of flexible endoscopes with their light cords
and cameras.It sterilizes the load in about 60 minutes.
FLEX cycle is specifically designed for flexible endoscopes and sterilizes
T
the load in about 42 minutes.
EXPRESS cycle is for surface sterilization of general medical devices,
rigid and semi-rigid endoscopes without lumens; and sterilization of
mated stainless steel and titanium devices. It sterilizations the load in
AF about 24 minutes.
Functions
Logout is used when the current operator is finished using the sterilizer
and the option is enabled. When Logout is selected, you must re-login to
use the sterilizer.
Cycle History displays the Select Cycle History screen. This screen
allows you to select a cycle history file and view or print it.
R
Utilities are available only to operators with Supervisor-level access.
It displays the Additional Utilities Menu.
Door Open opens the active door.
Door Close closes the active door.
D
Inserting a Cassette
1. Take a new STERRAD® 100NX® Cassette out of the shipping carton.
2. Look at the package carefully before opening it. The indicator strip
should be white. If the indicator strip is red, or if you see droplets
of moisture, do not open the package – it is possible that hydrogen
peroxide has leaked inside the package. Refer to the cassette Instructions
for Use for proper handling instructions.
3. If the indicator strip is white, open the cassette package.
4. Position the cassette so that the arrows are pointing towards the sterilizer.
5. Insert the cassette into the cassette slot until it stops moving. Do not use
force to push the cassette into the machine.
T
AF Figure 12. Inserting the Cassette into the Slot.
6. After a slight pause, the sterilizer pulls the cassette through the slot and
the slot door closes. Cassette loading is now complete.
Cycle in Progress
When you touch the Start Cycle button (after selecting the cycle type), the
sterilizer starts a “countdown clock” and begins the sterilization cycle.
R
D
Canceling a Cycle
There may be occasions when it is necessary to cancel a cycle before
it is completed.
T
To cancel a cycle, do the following:
1. Touch the Cancel Cycle button. The screen displays a
confirmation message.
AF
R
D
2. Touch No to continue with the cycle. Touch Yes to cancel the cycle. Once
the cycle cancellation sequence begins, the screen turns red and the
cancellation sequence cannot be interrupted. The cancellation sequence
may take up to ten minutes to complete.
T
AF
Figure 15. Cycle Cancellation In Progress. Cancellation Has Been Confirmed.
present. Wear chemical resistant latex, PVC (vinyl), or nitrile gloves while removing
the items from the chamber, and while wiping off the items with a damp cloth.
Discard contaminated cloth according to your facility’s procedures.
T
AF
Figure 16. Successful STANDARD Cycle Completed.
1. Touch the View Details button to display the cycle history file for the
just-completed cycle.
R
2. Touch the Done button to proceed.
When you touch the Done button, how the sterilizer responds depends upon
the configuration of your sterilizer.
If login is required before the door can be opened, the Login screen
is displayed. When this occurs, enter your operator identification and
password and touch Enter. The door opens and the load can be removed.
The operator’s name appears on the printout acknowledging the
completion of the cycle.
If no login is required for load removal, the door opens and the load can
be removed.
T
After ensuring that the chemical indicators exhibit the correct color change,
and the cycle printout shows that all the necessary cycle parameters were met,
the sterilized load is ready for immediate use, following your facility’s policy.
If the chemical indicators do not exhibit the correct color change, investigate
AF
Processing Biological Indicators
the cause, repackage, and then reprocess the load.
Remove the biological indicator from the load and process it per its
Instructions for Use. Refer to the flowcharts on the following pages
for additional information.
R
D
T
AF
R
D
T
AF
R
D
Troubleshooting
T
Most sterilizer operating problems are accompanied by a system message.
These messages are useful in determining the source of the problem.
AF In many cases you can take remedial actions to return the sterilizer to
normal operation. Because load related issues are the most frequent cause
of cycle cancellation, the easiest solution is to repackage the load and restart
the sterilizer when a cycle cancels. Be sure to replace biological and chemical
indicators with new ones. In other cases, the problem may be caused by a
component failure that requires adjustment or repair by an ASP Service
Representative. Call your local ASP Representative for service information.
In the following table are messages that are displayed by the system.
The messages are listed in alphabetical order. Some messages do not
require action on your part and are merely statements of the system status.
Other messages require that you insert a cassette, remove the cassette
R
disposal box, or other such action. The display directs you what steps to
take. If the cycle had cancelled, wear chemical resistant latex, PVC (vinyl)
or nitrile gloves when removing the load.
Running Diagnostics
D
If the sterilizer or the information in the following table directs you to run
diagnostics, remove the load and touch Other Tests from the Diagnostics
menu. If you have received a message containing the word “temperature,”
touch Temperature Tests. (See the section on “Access Levels and Supervisor
Tasks” for information on how to navigate to the Diagnostics menu.) If you
run Diagnostics and the tests show that there are errors, contact your ASP
Representative and report the diagnostic results. If the diagnostic tests pass
with no errors, you can run cycles with your normal load.
T
A number of displayed messages concern the temperature of the
system; e.g., doors, vaporizer, electrode, etc. These messages contain
the word “temperature” and require that you run the temperature test in
diagnostics. If the temperature test fails, or if the message is repeated,
call your ASP Representative for further action.
Cannot Eject Cassette, Run Diagnostics The cassette did not eject out the cassette slot. Remove the load
and run diagnostics.
D
Cassette Did Not Index A cassette was unable to advance to the next cell. Remove the
load and run diagnostics.
Cassette Expiry Found During The cassette was found to be expired when the Start Cycle
Start Cycle button was pressed. Dispose of the cassette and insert new
cassette.
Cassette Out Of Date, The cassette has been in the sterilizer for 10 days or the cassette
Disposing Cassette has expired. Insert new cassette.
Cassette Used, Disposing The inserted cassette does not have any unused cells remaining.
Insert a new cassette.
Control Available On Other Side Use the other side of the sterilizer to access the touch screen.
Cycle Canceled By Operator The operator canceled the cycle. Repackage the load. Restart the
cycle after cancellation is complete.
Delivery System Not Ready Delivery system not responding. Remove the load and
run diagnostics.
T
Disposing Cassette No action required.
Door Opened Door open sensor malfunction. Remove the load and
AF run diagnostics.
Door Sensor Fault Door malfunction. Reboot the system. If the message persists,
call your ASP Representative.
Function Available on Other Side Only Control of the sterilizer is on the other side of the unit.
H2O2 Adjustment In Progress The intensity of the UV lamp is being adjusted. Wait 5 minutes
for adjustment to be completed.
H2O2 Monitor Failure H2O2 bulb or detector malfunction. Remove the load and
run diagnostics.
D
H2O2 Rate Constant Too High The load is decomposing the H2O2. Check the load for absorbent
materials. Repackage, and restart the cycle. If the problem
persists, call your ASP Representative.
H2O2 Sensor Fault Reboot the system. If the problem persists, call your
ASP Representative.
High Plasma Power The plasma power is out of specification. Remove the load and
T
run diagnostics.
Invalid Key Code. Please Enter A Press the OK button and reenter a valid key code.
Valid Code AF
Invalid Load Items File Press the Back button and reinsert the USB memory stick.
Less Number of Cells Available, Please The system will automatically move the cassette to the
Dispose the Cassette disposal box.
Wear chemical resistant latex, PVC (vinyl), or nitrile gloves whenever handling
a load after a cycle cancellation. Hydrogen peroxide liquid may be present on
the load or in the chamber.
Low Plasma Power The plasma power is out of specification. Remove the load and
run diagnostics.
Memory Card Full Initiate backup to the memory card or press OK and the system
will delete the oldest file.
Other Door Is Open Close the door on the other side of the sterilizer.
Please Close Door Touch the close door display or the door foot pad to close
the door.
Please Remove Cassette And Verify Wrong cassette type. Confirm that the cassette is a STERRAD®
Cassette Type 100NX® cassette.
T
load after a cycle cancellation. Hydrogen peroxide liquid may be present on the
load or in the chamber.
Power Fail Cancellation A power failure occurred during a cycle. Repackage the
AF load and restart the cycle. If the problem persists, call your
ASP Representative.
Pressure Out Of Range (Low) Vacuum system malfunction. Remove the load and run
diagnostics.
Printer Is Out Of Paper. Please Load A Load paper into the printer.
D
New Roll.
RFID Data Error, Ejecting Cassette, Cassette will automatically eject. Insert a valid cassette
Verify Cassette Orientation
Unable to Open One Second Data File Replace the PCMCIA card with a new one.
UV Path Is Blocked, Open Door And Object is blocking the UV path. Verify that the shelves and/or
Clear Pathway the load are not blocking the path. If the problem persists, call
your ASP Representative.
T
Wear chemical resistant latex, PVC (vinyl), or nitrile gloves whenever handling a
load after a cycle cancellation. Hydrogen peroxide liquid may be present on the
load or in the chamber.
AF
Would You Like to Troubleshoot? Remove the load and run diagnostics. If the problem persists,
call your ASP Representative.
Sterilizer Overview
Sterilizer Cycles
T
The following display shows all the cycles available for the STERRAD®
100NX® Sterilizer. This guide contains detailed instructions for each cycle.
AF Make sure you understand the differences in the cycles and what types of
instruments can be sterilized in each cycle.
R
D
Figure 17. Select Cycle Display Showing All Cycles. Your display
may be different depending on the cycles installed and enabled
for use. Supervisor Access is required to enable installed cycles.
Sterilizer Features
The cassette slot, the cassette drawer, the touch screen, PCMCIA slot (inside
the access panel), the chamber door, the printer, and the foot pad are found on
the input side of the sterilizer (the front of single-door units). On a two door
unit the touch screen, chamber door, foot pad, and printer are found on both
the input and output sides. The main power switch is located on the left (your
left) front side of the sterilizer. The I/O interface is located on the right (your
right) front side of the sterilizer. See the sections on Data Transfer and
Rebooting the System for locations of the power switch and USB port.
T
Cassette
Slot LCD Touch
Screen Display
AF Access
Panel
Door
R
Printer Access
D
Foot Pad
.
Figure 18. The STERRAD® 100NX® Sterilizer.
Not shown: The power switch is at the lower left and
the USB port is at the lower right.
The sterilizer is operated by using the touch screen to begin a cycle, enter
load information, monitor the cycle and perform diagnostics.
A cassette is inserted into the sterilizer through the cassette slot.
T
Cassette
AF The cassette contains sealed capsules of hydrogen peroxide solution. Each
cassette has coded information that provides displayed details on the cassette
expiration date, manufacturer, and cell status including cycle completion
information. The sterilizer pulls the cassette through the slot and moves it into
the machine, keeping it there until the cassette has been used.
R
D
T
AF
Figure 20. Cassette Disposal Box.
R
Touch Screen and Speaker
The sterilizer displays information and allows you to enter commands on the
color touch screen display. By touching buttons displayed on the screen, you
can enter letters and numbers, make selections, and start and stop the
D
sterilizer.
T
Figure 21. Using the Touch Screen.
Chamber
The load is placed in the chamber for sterilization. The chamber walls and
doors contain heaters that keep the chamber interior warm during operation.
When the chamber door(s) are closed, a vacuum-tight seal is created, allowing
the chamber atmosphere to be evacuated during operation.
R
D
Figure 22. The STERRAD® 100NX® Chamber Empty and With a Typical
Standard Cycle Load Correctly Placed.
Printer
The sterilizer has an integrated internal printer located in the front panel.
On two door units, a printer is located in the main panel on each side.
The printer prints cycle reports and other information on a roll of thermal
paper. The printer features easy, drop-in paper loading and requires no ink
cartridges. (The system is also designed to interface to a second, external
printer that is USB-compliant and supports PCL-3 protocol.)
The handle is squeezed and the door is pulled toward you to open the
printer door for printer paper replacement.
The top button advances the paper.
T
AF
R
Figure 23. STERRAD® 100NX® Printer Paper Advance Button.
D
T
AF
Figure 24. Example of a Data Entry Screen.
R
D
Function Buttons
Most screens provide function buttons that display other screens or
select sterilizer functions. Common function buttons are shown in the
following table.
Button Function
Done. Touch this button to indicate that you are finished using
the screen.
T
View. Touch this button to view the selected report or file.
Cancel. Touch this button to cancel the entry you just made.
R
D
Maintenance
T
maintain and repair the STERRAD® 100NX®
Sterilizer. Use of unauthorized parts for maintenance
or repair could cause personal injury, result in costly
damage, or sterilizer malfunction and voids the
Automatic Maintenance
AF warranty.
to complete. The automatic adjustment will take place if the lamp voltage is
below a preset limit.
Manual Maintenance
The following maintenance procedures are performed by the user:
Disposing of cassettes.
Inserting a new cassette disposal box.
Replacing the printer paper roll.
Cleaning the sterilizer exterior.
Cleaning the hydrogen peroxide monitor detector lens.
Replacing the air filter.
T
Replacing the PCMCIA card (if desired).
Disposing of a sterilizer.
AF These tasks are performed when needed. The printer paper is replaced
when the roll is empty. The sterilizer exterior should be cleaned only when
necessary. This chapter provides step-by-step instructions on how to perform
these maintenance tasks. Information on inserting a cassette box follows the
disposal section.
Disposing of Cassettes
When a cassette is empty the sterilizer automatically moves it to the cassette
disposal box. The screen displays a message instructing you which actions to
R
take next. When the cassette disposal box contains 2 cassettes, it is full, and
you must dispose of the full cassette disposal box. For safety reasons, you
must use the cassette disposal box to dispose of cassettes. Never reuse a
cassette disposal box. Once a cassette disposal box has been removed, a
new cassette disposal box must be inserted.
D
1. Open the cassette access door. Pull the tab on the cassette disposal box to
more easily slide it completely out.
T
AF
Figure 25. Open the Access Panel and Remove the Used Cassette Box.
Figure 26. Pinch the Edge of the Lid to Close the Box.
4. Insert a new box making sure the lid is open and not caught in the
opening, and the tab is facing you.
T
Figure 27. Insert the New Cassette Box with the Lid Open
so the Tab is on the Left.
When the printer paper roll is empty, the sterilizer displays a message “Printer
is out of paper. Please load a new roll.”
1. Open the printer by pushing or squeezing up on the handle as shown. The
printer door opens toward you.
R
D
2. The empty paper roll rests on the bottom of the printer door. Remove the
empty roll.
T
Figure 29. Remove the Empty Paper Roll.
3. Insert a new paper roll as shown in the following figure. The paper should
AF feed from the top of the roll.
R
Figure 30. Insert a New Paper Roll.
D
4. Pull a short length of paper over the top of the printer door.
5. Align the paper so that it fits between the two paper guides on the top of
the printer door.
6. Push the door shut making sure the paper stays in place.
T
Figure 31. Make sure the Printer Door Latches Securely
AF and the Paper is in Place.
7. Press the paper advance button. Check the alignment of the paper and
make certain it does not jam or misfeed.
R
D
8. When the paper has advanced normally, tear off the used strip in an
upward direction. Paper replacement is now complete.
The sterilizer exterior can be cleaned with a soft cloth and a mild, nonabrasive
detergent solution if necessary. When cleaning the sterilizer exterior, follow
these guidelines:
1. Turn off the power to the sterilizer before cleaning the exterior.
T
2. Never allow cleaning solution or water to enter the interior or chamber.
Moisten a cloth with nonabrasive detergent solution and use the damp
cloth to clean the surfaces.
3. Do not spray cleaning solution directly on the touch screen. Use a
AF dampened cloth to clean the screen.
4. If you have any questions about proper cleaning techniques, in the U.S.A.
please call your local ASP Representative before proceeding. Failure
to follow these guidelines may result in damage to the sterilizer and may
void the warranty.
R
D
T
AF
Figure 33. Cleaning the Hydrogen Peroxide Monitor Lens.
T
AF
R
Figure 34. Press the Button at the Top of the Card Slot
to Eject the PCMCIA Card.
2. Orient the PCMCIA card so that the side of the card with the label
faces left.
T
AF Figure 35. Insert the PCMCIA Card Correctly.
Figure 36. Insert the Memory Stick into The USB Port.
T
AF Main Circuit
Breaker
Sterilizer Disposal
D
T
AF
R
D
Displayed Reports
T
Users with Operator-level access can display the Cycle History files. Users
with Supervisor-level access can display the Cycle History files, as well as
AF Calibration files and Diagnostic files.
All files that are displayed can be printed by touching the Print button on the
file display screen.
Cycle History
Cycle history data is stored in the sterilizer’s memory. The memory holds data
from the last 200 cycles. After 200 cycles are completed, the oldest cycle
history record is overwritten with new data from the 201st cycle. If your
sterilizer is configured with the optional network connection, cycle history
R
data can be periodically uploaded to a host computer and preserved
permanently if desired.
When you touch the View Cycle History button on any screen where the
button appears, the program displays the Select Cycle History screen. The list
box shows the cycle number, status, completion date and time, and reason
D
for cancellation (if applicable) for all cycle history records currently in the
sterilizer’s memory.
Touch the scroll bars to scroll through the list. Touch the line you wish
to select.
T
AF Figure 38. Select Cycle History File.
Print List prints a list of all cycle history files stored in the sterilizer.
View Cycle displays the selected Cycle History file on the screen.
Print Cycle (Short) prints a short-format report of the selected cycle
history file.
R
Print Cycle (Long) prints a long-format report of the selected cycle
history file.
Parametric Print prints a parameter format report of the selected cycle
history file (external printer required).
Data Transfer – allows you to transfer the cycle information to a USB
D
T
Short Report
The short-format report lists identifying information about the cycle, shows
the cycle status, lists the date and duration of the cycle, and shows operator
AF and load identifying information. The short-format report is useful for record
keeping purposes and providing traceability of sterilized loads.
Parametric Report
The parametric format report shows single-point values for a certain number
of parameters. It is a more confined report than the long printout and contains
a table of all critical parameters and their values. It is only available if an
external printer is attached.
R
Long Report
The long-format report lists detailed information about the cycle, shows the
cycle status, lists the date and duration of the cycle, shows operator and load
D
T
AF
R
D
T
Overview AF Users with Supervisor-level access privileges (see below) are permitted to
perform a set of restricted sterilizer functions. These functions are not used
in daily sterilizer operation and some of them are designed to control access,
manage system records, and perform advanced diagnostic functions.
Access Levels
The STERRAD® 100NX™ Sterilizer can be configured to require that all
users enter a valid operator identification and password before operating the
R
sterilizer. This access control is enabled through the System Configuration
screen and user identifications, passwords, and access levels are assigned
and maintained through the User Administration screens.
There are three levels of access available. Each is associated with a different
subset of permitted operations.
D
T
The Additional Utilities Menu is available only to users with Supervisor-
or Service-level access privileges. If a user with Operator-level privileges
touches an Additional Utilities button on any screen, the Login screen will be
AF displayed with the message: “Supervisor- or Service-Level Login Required.”
The Additional Utilities Menu allows supervisors to configure the sterilizer
and the network connection, set the date and time, set up and maintain
user privileges, view and print files, perform diagnostic tests, and dispose
of cassettes.
R
D
Date & Time allows you to set the date, time, time zone, and formats used for
displaying and printing date and time.
System Config allows you to set sterilizer features.
User Admin allows you to add, delete, or modify operator identifications,
passwords, and access levels.
T
Input/Output door close closes the door on the input or output side.
PCMCIA allows you to safely remove the PCMCIA card. Do not try to
remove the PCMCIA card without using this feature.
Product Options allows you to enable or disable certain feature upgrades.
AF The Back button returns you to the prior screen from which you originally
selected the Additional Utilities Menu screen.
Set Date
Use the MM box to set the month (01-12), the DD box to set the day (01-31),
and the YY box to set the year.
Set Time
Use the HH box to set the hour (01-12 if 12-hour format is selected, 00-23 if
24-hour format is selected). Use the MM box to set the minute (00-59) and the
SS box to set the second (00-59). If 12-hour format is selected, you may only
select hours 01-12, and you must touch the AM or PM buttons to indicate the
correct time.
T
Time Zone
Scroll through the selections until your time zone is displayed.
Date Format
AF
Select the desired format for the date. The formats that include “YYYY”
display a four-digit year.
Time Format
R
Select 12-hour or 24-hour format. If 12-hour format is selected, the AM and
PM buttons on the Set Time line are enabled. If 24-hour format is selected,
the AM and PM buttons are disabled.
Cancel/Done
D
To cancel the date or time setting, touch the Cancel button. When the
date and time settings are correct, touch the Done button to return to the
Additional Utilities menu.
T
AF
Figure 41. System Configuration.
IMS
Enabled causes the system to capture data with an IMS system (optional).
Disabled causes the system to not capture data with an IMS system
(optional).
Vacuum Units
Torr/mTorr expresses vacuum measurements in torr and mtorr.
kPa/Pa expresses vacuum measurements in kilopascals and Pascals.
This is the factory default setting.
T
complete. This is the factory default setting.
Notepad Option AF Enabled causes the Cycle Notes screen to be displayed after login. This is the
factory default setting.
Disabled skips the Cycle Notes screen.
Network Option
Enabled allows the sterilizer to transmit data on a network.
Disabled disables the network connection. This is the factory default setting.
R
Alarm Volume
Touch the + or - buttons to adjust the volume of the alarm loudspeaker.
The factory default setting is in the middle of the scale.
D
Language Selection
Scroll through the list to select the language used in displays and printed
reports. The factory default setting is English.
T
AF
Figure 42. Sterilizer Settings.
Printer Settings
Touch Printer Settings to display the following screen: Touch Done to save
the changes.
T
AF Figure 43. Printer Settings
Internal Printer Input Side allows you to select the printer on the input side.
This is the default.
Internal Printer Output Side allows you to select the printer on the output
side (2 door configuration).
R
External Printer allows you to select an external printer connected to the
USB port.
Short Format instructs the sterilizer to print only the short report when a
cycle is complete. This is the factory default setting.
D
Long Format instructs the sterilizer to print only the long report when a cycle
is complete.
Parametric Format instructs the sterilizer to print only the parametric
report when the cycle is complete. This format is available only when an
external printer is selected.
Graphs of various functions are available for printing if an external printer is
selected. Touch the graph(s) desired.
IMS Printout Enabled prints the IMS information if an external printer is
selected.
IMS Printout Disabled does not print the IMS information.
T
AF
Figure 44. Transfer Settings
R
Cancel/Done
To cancel system configuration (on the System Configuration Menu), touch
the Cancel button. When the system configuration settings are correct, touch
Done. Cancel and Done have the same function on all the other screens you
can access through the System Configuration menu.
D
User Administration
Use the User Administration screen to add, modify, or delete user names,
passwords, and access levels. A button on this screen allows you to upload
user information to a USB memory stick. Supervisor-level access allows you
to add, edit or delete a User or another Supervisor.
T
AF
R
Figure 45. User Administration.
Add User displays the Add User screen. On this screen you can set up a new
D
T
AF
Figure 46. Add User.
1 Enter the user’s operator “identification” in the Operator field. The entry
must be alpha-numeric and no more than 10 characters.
Modify User
Use the Modify User screen to modify an existing user’s identification,
password, and access level.
T
AF
Figure 47. Modify User.
1 Touch the user’s name whose information you wish to edit or delete.
2. Touch Delete User to remove the user from the access list and revoke
access to sterilizer operation.
R
3. Touch Edit User to change the user’s information including access level.
D
T
AF
Figure 48. Edit User.
6. Touch the Done button when you have finished – the Modify User screen
is displayed.
T
Figure 49. Upload User Data.
AF If the user data shown is acceptable, touch Confirm. The following section
contains information on uploading user data.
USERNAME1,PASSWORD1,ACCESS-LEVEL1
USERNAME2,PASSWORD2,ACCESS-LEVEL2
where:
USERNAME must be alpha-numeric, no more than 10 characters
PASSWORD must be alpha-numeric, no more than 10 characters
ACCESS-LEVEL must be either 1, 2 (1=Operator, 2 = Supervisor)
2. Copy users.rec file to a USB memory stick and insert the memory
stick into the sterilizer’s port located on the lower right (your right)
side of the sterilizer.
Cassette Functions
T
WARNING! HYDROGEN PEROXIDE MAY BE PRESENT.
Wear chemical resistant latex, PVC (vinyl), or nitrile gloves whenever handling a
load after a cycle cancellation or when disposing of a cassette. Hydrogen peroxide
liquid may be present on the cassette, the load or in the chamber.
AF This function has two options: Dispose Cassette which is used to remove the
currently loaded cassette from the sterilizer to resolve an error message or to
move a cassette that may be stuck in place; and Peroxide Clearance which is
used to dispose of peroxide remaining in the sterilizer reservoir when the
peroxide has expired. Peroxide in the system expires after 10 days. The
system displays a message indicating that either of these functions need to be
performed.
R
D
Figure 50. Touch Cassette Functions to display this screen. Touch Dispose
Cassette or Peroxide Clearance.
Dispose Cassette
The Dispose Cassette function moves the cassette from inside the sterilizer
to the cassette box. The remaining volume of hydrogen peroxide is displayed
on the screen.
Touch Dispose Cassette to move the cassette into the cassette disposal box.
T
AF
Figure 51. Press Dispose Cassette to Move the Cassette
Into the Cassette Disposal Box.
R
D
T
AF
R
Figure 52. Typical Peroxide Clearance Message
D
Network
STERRAD® 100NX™ Sterilizer can be configured to communicate with a
remote personal computer over a network. If you need to use this feature,
please contact Advanced Sterilization Products for details on performing
this setup.
Diagnostics
The diagnostics function prompts you to select one of two types of tests
T
(either Temperature Test or Other Tests). If Other Tests is selected, the
sterilizer runs ten operator-assisted tests of the sterilizer subsystems. You may
skip one or more tests in the automatic sequence by touching the Cancel
button when a test begins. This causes the program to advance to the next
test in the sequence.
AF The ten tests and the sterilizer elements that are tested are listed in the order in
which they occur in the following table.
Touch the Diagnostics button to start automatic diagnostic testing of the
sterilizer.
Figure 54. Touch Either Button to Run Tests Than Can Help You
Resolve System Messages.
T
Electrode integrity
8
Display Test
Printer Test
AF
H2O2 Sensor Test Ultraviolet lamp and detector
Printer function
20 sec.
20 sec
10 sec.
Service Functions
D
File Management
Use the File Management screen to select and display calibration files or
diagnostic report files.
T
AF
Figure 55. File Management.
Calibration Files
R
Touch the Calibration Files button to display a list of calibration files created
during a sterilizer calibration. Scroll through the list and touch the file name
you wish to view. Touch the View button to display the selected calibration
file. Touch the Back button to return to the Additional Utilities menu.
D
Diagnostic Files
Touch the Diagnostic Files button to display a list of reports created by the
Diagnostics function. Scroll through the list and touch the report you wish to
view. Touch the View button to display the selected report. Touch the Back
button to return to the Additional Utilities menu.
T
AF
Figure 56. Load Items Files
3. Insert the USB memory stick with the file loaditems.txt resident on the
stick into the sterilizer’s USB port located on the lower right side of the
front panel.
4. Select “Upload File” for the Additional Utilities men.
5. Review the database displayed on the screen and press Confirm to accept
the database into the sterilizer or press Back to cancel.
Input/Output Doors
The doors can be opened or closed via the foot pad that you tap with your foot
or by touching the Input or Output Door buttons. If the system has only one
door, only the Input Close Door and Input Open Door buttons are available
for use. Only one door can be opened at a time. For example, if the Input Door
is open, the Output Door cannot be opened at the same time.
The Input Open Door and Input Close Door buttons open and close the
input side of the sterilizer. That is the side where you load your instruments
for processing.
The Output Open Door and Output Close Door buttons open and close the
T
output or clean side of the sterilizer. This is the side, on a two door unit, where
you would remove your sterilized items. When the door is moving, the door
open and close buttons, and the foot pad, are disabled until the door has
AF completed its movement.
Product Options
When you select Product Options from the Additional Utilities Menu, and the
EXPRESS or DUO cycles are installed, the following is displayed after the
installation is complete, and every time you select Product Options after
installation. ENABLED is the default option. This feature is only available
with Supervisor-Level access.
R
D
T
AF
R
D
T
AF
R
D
Sterilizer Specifications
T
at installation.
208V 60 Hz Power: For versions employing 208V, 60 Hz power, the
sterilizer requires a NEMA L21-30 five-wire grounding twist lock outlet
attached to a dedicated 30 Amp 3 phase 208 Volt circuit with separate
AF neutral and ground conductors.
380 - 415V 50/60 Hz Power: The sterilizer requires a five-wire grounding
outlet attached to a dedicated 30 AMP, 3 phase, (200-240VAC, 380-415V)
±10%, 50/60 Hz ±5% circuit with separate neutral and ground conductors.
200V 50/60 Hz Power (Japan): The sterilizer requires a four-wire Delta
configuration to a dedicated 30 AMP circuit.
Dimensions H: 70.5 in. (179.1 cm), W: 30.5 in. (77.5 cm), D: 40 in. (102 cm).
R
Service clearances Front: 39.5 in. (100 cm); Back: 39.5 in (100 cm); Top: 39.5 in. (100 cm)
Left side: 39.5 in. (100 cm); Right side: 39.5 in. (100 cm).
Chamber volume 152 liters.W20.7 in. (51 cm), H16.1 in. (41 cm), D28.93 in. (73.5 cm).
Usable volume: 93.4 liters (3.3 cubic feet)
Chamber shelves Two shelves, W 17 in. (42.5 cm), D 28 in. (70 cm).
Shelf capacity: 55 lb. (25 kg) uniformly distributed.
Both shelves are removable.
T
DUO Cycle - 60 minutes
EXPRESS Cycle - 24 minutes
FLEX Cycle - 42 minutes
Connectors
T
Routine Control Of A Sterilization Process
CAN/CSA C22.2 No. 61010-1.
UL 61010-1.
T
AF
R
D
T
Consumable Products Product Code Description
Thermal Printer Paper Roll-Case 10305 Used with the thermal printer to record
sterilizer information. 12 rolls/case
Cassette Disposal Box - Case 20227 This box is used to collect cassettes for
disposal. 10 boxes/case.
STERRAD® 100NX® Test Pack for 20243 Contains the test vials, pouch, mats, and BI.
STANDARD, FLEX and DUO Cycles
R
STERRAD® CYCLESURE® 24 14324 Used as a standard method for frequent
Biological Indicator monitoring of the STERRAD® Sterilizer
cycles.
STERRAD® SEALSURE® Chemical 14202 Used to seal packaged instruments, the tape
D
STERRAD® Chemical Indicator Strips 14100 Placed inside instrument packages, the
chemical indicator strips change color when
exposed to hydrogen peroxide.
Tyvek® Pouches and Rolls with Contact your ASP Representative for a
complete list of pouches, rolls, instrument
STERRAD® Chemical Indicator
trays and accessories.
Independent Monitoring System (IMS) 10140 For compliance with ISO 14937. The
Independent Monitoring System (IMS) is an
optional feature that may be purchased and
installed on the sterilizer. It is an
independent data collection system that can
be used for system validation or
requalification. All of the sensors are
independent from the system sensors and the
T
data collected from the IMS is identified
separately from the system’s one-second
data
Additional Parts
AF
Compact Flash Card and Adapter
Part Number
04-53004-0-001