Technical Data Sheet
Edition 2, 2005
Identification no.
02 07 01 01 001 0 000050
Version no. 0010
Sika® 102
Sika 102
®
Waterplug
Description Sika 102 is a chloride free, ready for use powder When mixed with water, it
becomes a powerful fast-setting permanent waterplug
Construction
Use Ready for use waterplug to stop pressure leaks and seepage through rock and
concrete, as well as through joints between concrete and steel (bolt surroundings,
ducts, sheet piles etc) in subways , culverts, tunnels, dams, basements, pools.
Advantages Easy to use, easy to mix, just add water
No special equipment required
Very fast setting with rapid strength development
Permanent good adhesion to all substrates
Remarkable water-stopping power and hydraulic resistance
No cracking, practically no shrinkage
No corrosion
Mixing/ Hardening Time By weight
Sika 102 1.0 kg
Water 0.25 – 0.30 Kg
Hardening time : 60 – 90 seconds
Instruction for Use
Application Cut concrete or rock in “V” shape around the leaking point. Remove all unsound
and loose particles and clean surface with water prior to application of Sika 102.
Fill freshly prepared Sika 102 into the V-shaped cut, starting outside and work
towards the center off the leak (plug minor leaks first). Hold material in place, and
then strike of flush with surface. If water pressure is very high, it is recommended to
use wooden plug first, which is then covered and secured with Sika 102
Cautions It is recommended to prepare Sika 102 in small quantities at a time. If mixed in
large amounts, hardening may have occurred before it is completely used
Do not mix Sika 102 with other admixtures, cements or sands
Sika 102 is hygroscopic. Seal unused quantity immediately in original container.
Sika 102 is alkaline. Use rubber gloves when working with Sika 102. If Sika102
gets into eyes, clean out immediately with fresh water
1 Sika® 102 1/2
Technical Data
Form Powder
Color Grey
Bulk Density Approx. 1.2 kg/ litre
pH Value >11
Mixing Ratio 1 : 0.25 – 0.30 by weight (Sika 102 : water)
Hardening Time 60 – 90 seconds (30oC)
Shelf life 6 months if stored in unopened original container
Storage Dry, cool, shaded place
Packaging 20 kg pail ( 4 x 5 kg plastic bag)
Handling
Precautions: Avoid contact with skin and eyes
Wear protective gloves and eye protection during work
Construction
If skin contact occurs, wash skin thoroughly
If in eyes, hold eyes open, flood with warm water and seek medical attention
without delay.
Legal Notes The information and in particular the recommendations relating to the application and end-use of Sika
products are given in good faith based on Sika’s current knowledge and experience of the product when
properly stored, handled and applied under normal conditions. In practice, the differences in materials,
substrates and actual site conditions are such that no warranty in respect of merchantability or fitness for a
particular purpose, nor any liability arising out of any legal relationship whatsoever, can be inferred either
from this information, or from any written recommendations, or from any other advice offered. The
proprietary rights of third parties must be observed. All orders are accepted subject to our current terms of
sales and delivery. Users should always refer to the most recent issue of the technical Data Sheet for the
product concerned, copies of which will be supplied on request.
Sub Distributor
PT. Sika Indonesia Branches Bandung, Tel : 022-5423855,5423857, Fax : 022-5423517
Jl. Raya Cibinong- Bekasi km. 20 Surabaya, Denpasar, Tel : 0361-235998 – 235973, Fax : 0361-237053
Limusnunggal- Cileungsi Tel : 031-8690202 Makassar, Tel : 0411- 859147 – 858527, Fax : 0411-858527
Fax : 031-8682123 Balikpapan, Tel : 0542-411258 Fax : 0542-412230
BOGOR 16820- Indonesia Medan, Pekanbaru, Tel : 0761-46993 – 47677, Fax : 0761-45112
Tel. +62 21 8230025 Tel : 061-7941200
Fax : 061-7940822
Duri/Dumai. Tel : 0765-595259 Fax : 0765-91135
Fax +62 21 8230025 Palembang, Tel : 0711-351523 Fax : 0711-369858
Batam,
www.sika.co. id Tel : 0778-424928, Palu, Tel : 0451-454855 – 422122, Fax : 0451-454855
e-mail: marketing@sika.co.id Fax : 0778-426913 Manado, Tel /Fax : (0431) 324069
2 Sika® 102 2/2
