harman/kardon HS 350/650DL Service Manual

harman/kardon Service Manual

HS 350/230
+6
Digital Lounge HS 650/230
Integrated Home Theater System controllers


CONTENTS
HS 350 TECHNICAL SPECIFICATIONS 2 HS 350 PACKAGE LIST AND PARTS 15
HS 350 TROUBLESHOOTING GUIDE 3 HS 650 PACKAGE LIST AND PARTS 16
HS 350 FRONT PANEL CONTROLS 5 EXPLODED VIEW AND PARTS 17
HS 350 FRONT PANEL DISPLAY 6 ELECTRICAL PARTS LIST 18
HS 350 REAR PANEL CONNECTIONS 7 SEMICONDUCTOR PINOUTS 33
HS 650 TECHNICAL SPECIFICATIONS 9 PCB DRAWINGS 47
HS 650 TROUBLESHOOTING GUIDE 10 BLOCK DIAGRAM 59
HS 650 FRONT PANEL CONTROLS 12 WIRING DIAGRAM 60
HS 650 FRONT PANEL DISPLAY 13 REVISION HISTORY 61
HS 650 REAR PANEL CONNECTIONS 14 SCHEMATIC DIAGRAMS 62-89

Released EU2008 harman/kardon, Inc. Rev 0, 10/2008

250 Crossways Park Dr.
Woodbury, New York, 11797 Page 1 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 35

harman/kardon HS 350/650DL Service Manual

HS 350 Controller Specifications

ENGLISH
DVD player
Pickup: Semiconductor laser, wavelength 650nm
Signal system: NTSC / PAL
Video signal horizontal resolution: More than 480 lines (DVD)
Video signal-to-noise ratio: More than 60 dB (DVD)
Audio frequency response: DVD (PCM): 20Hz ~ 22kHz (+/- 1.0dB)
(Stereo) CD (PCM): 20Hz ~ 20kHz (+/- 1.0dB)
Audio signal-to-noise ratio: More than 80 dB (PCM)
Total harmonic distortion:: Less than 0.01% (PCM)
Dynamic range: DVD (PCM): More than 85 dB (EIAJ, 2kHz)
CD: More than 85 dB (EIAJ)

FM Tuner
System: PLL quartz-locked digital synthesizer system
Tuning range: 87.50 ~ 108.00 MHz
Antenna terminals: 75 Ohms, unbalanced
Intermediate frequency: 10.7 MHz

Video Outputs HDMI:

Component Video Output: Y: 1 Vp-p/75 Ohms, sync negative polarity
Cr: 0.7 Vp-p/75 Ohms
Cb: 0.7 Vp-p/75 Ohms
CVBS Video: 1 Vp-p 75 Ohms
S-video: Y: 1 Vp-p 75 Ohms
C: PAL 0.3 Vp-p 75 Ohms / NTSC 0.286 Vp-p 75 Ohms

Audio line Outputs

Audio L/R: 2 Vrms, 1 kilohms

General
Power requirements: AC 100-240 V, 50/60 Hz
Max power consumption: 230W
Idle power consumption: Less than 2 W
Dimensions (WxHxD): 357mm x 105mm x 293mm
Weight: 7.5 kg
* Designs and specifications are subject to change without notice.

Depth measurement includes knobs, buttons and terminal connections. Height measurement includes feet and chassis.
All features and specifications are subject to change without notice.
Harman Kardon, The Bridge and Logic 7 are registered trademarks of Harman International Industries, Incorporated.
Dolby, Pro Logic and the double-D symbol are trademarks of Dolby Laboratories, registered in the United States and/or other countries. All rights reserved.
DTS is a trademark of Digital Theater Systems, Inc.
Windows Media® Audio (WMA) is a proprietary file format developed by Microsoft.
DivX is a registered trademark of DivX, Inc.
HDMI, the HDMI logo and High-Definition Multimedia Interface are trademarks or registered trademarks of HDMI Licensing LLC.
Apple and iPod are registered trademarks of Apple Computer, Inc.

Page 2 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 32

harman/kardon HS 350/650DL Service Manual

HS 350

Troubleshooting

If you experience any of the following difficulties There is no sound or volume is very low. No sound is heard from the center speaker.
while using the system, use this troubleshooting • Check that the speakers and components are • Adjust center speaker volume (see pages 20).
guide to help you remedy the problem. connected correctly and securely.
Should any problem persist, consult your • Make sure that you have selected the correct
authorized Harman Kardon dealer. No sound or only very low volume from
source on the system. the rear speakers.
• Press MUTE on the remote control, if the • Adjust the rear speaker volume (see page 20).
No power. words MUTE ON are blinking on the front
• Is the power cord firmly plugged into the panel display.
power outlet? The volume goes down automatically
• The protective circuitry has been activated and can not be increased.
• One of the safety mechanisms may be because of a short circuit. Turn off the system,
operating. In this event, unplug the player from eliminate the short circuit problem and turn on • The internal temperature is too high. Wait
the power outlet briefly and then plug it in the power again. approximately one minute for the amplifier to
again. reach normal working temperature.
• The audio interconnect is damaged. Replace it
with a new one.
No picture. • The system is in pause mode or in slow-motion Radio stations cannot be tuned in.
• Check that the system is connected correctly play mode, or fast forward or fast reverse. • Check that the antenna is connected correctly.
and securely. Press N to return to normal play mode. Adjust the antenna and connect an external
antenna if necessary.
• The video cable may be damaged. Replace it • Check the speaker settings (see page 20).
with a new one. • The signal strength of the stations is too weak
for automatic tuning. Use manual tuning.
• Make sure the system is connected to a video The left and right channels are unbalanced
input on the TV (see page 14). • No stations have been preset.
or reversed.
• Make sure the TV is turned on. • Check that the speakers and components are • The tuner mode is not selected, select the
connected correctly and securely. Radio mode.
• Make sure the correct video input on the TV is
selected for viewing with this system.
Severe hum or noise is heard. The remote does not function.
• Check that the speakers and components are • Remove any obstacles between the remote
Noise (interference) appears in the control and the system.
picture. connected securely.
• Clean the disc. • Check that the connecting cords are away from • Move the remote control closer to the system.
• If video from this system has to go through a transformer or motor and at least 3 meters • Point the remote control at the remote sensor
your VCR to get to your TV, the copy-protection away from fluorescent light. on the front panel.
applied to some DVD programs could affect • Move your TV away from the audio compo- • Replace all the batteries in the remote control
picture quality. If you still experience problems nents. with new ones if they are weak.
after checking your connections, please try • The plugs and jacks are dirty. Wipe them with a
connecting your DVD system directly to your • Check that the batteries are loaded correctly.
cloth slightly moistened with alcohol.
TV’s S-Video input, if your TV is equipped with
this input (see page 14). • Clean the disc.
The disc does not play.
• There is no disc inside. (“NO DISC” appears on
The aspect ratio of the screen is wrong The surround effect is difficult to hear the front panel display and the TV screen.)
(picture vertically expanded) when you when you are playing a Dolby Digital Insert a disc.
play a wide picture even though you set sound track. • Insert the disc correctly with the playback side
“TV DISPLAY” in the SETUP menu to • Check to see if the Dolby Digital mode is facing down on the disc tray.
"16:9". turned on properly, otherwise unload and load
the disc again. • Clean the disc.
• If you connect the system with the SCART
cable, connect directly to the TV. Otherwise the • Check the speaker connections. • The system cannot play CD-ROM's, etc.
autoswitch function of the aspect ratio for the (see page 3).
TV may not work. • Depending on the DVD disc, the output signal
may at times be mono or stereo even if the • DVD with wrong region code
• If the TV is not connected with a SCART cable soundtrack is recorded in Dolby Digital format. (see page 13).
to the HS, or if the autoswitch function does
not work you should turn the TV to "16:9" (if
possible with your TV). The sound comes from the center speaker The system starts playing the DVD
only. automatically.
• Depending on the TV, you may not be able to • The DVD features the auto playback function.
change the aspect ratio. In that case (TV not • Depending on the disc, sound may sometimes
adjustable to 16:9) do not select "16:9" in the come from the center speaker only. This also
TV Display. Then, no change of the aspect ratio applies to mono recordings (from disc or any
Playback stops automatically.
is needed. analog source), when Pro Logic mode is
• Some discs include an auto pause signal. When
selected. This is normal.
playing such a disc, the system stops playback
at the signal.

Page 3 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 33

harman/kardon HS 350/650DL Service Manual

HS 350

Troubleshooting

ENGLISH
Track Skip or direct select with numeric The subtitles cannot be turned off when
buttons, Search, Slow-motion play, repeat you play a DVD.
play or Program play, etc., cannot be done. • Depending on the DVD, you may not be able to
• Depending on the DVD or VCD, some of the turn the subtitles off.
above operations may not be available
(Playback control).
The angles cannot be changed when you
play a DVD.
Messages do not appear on the TV screen • Multi-angles are not recorded on most DVDs.
in the language you want. • Change the angles when the angle mark
• Select the language for Display and Preferred appears on the TV screen.
Subtitle in the SETUP menu (see page 18).
For all messages from the DVD (DVD menu, • Changing the angles is prohibited on some
subtitles) in the proper language the disc must DVDs.
have the language you selected, if not, another
language will be selected.
The system does not operate properly.
• Static electricity, etc., may affect the system’s
The audio language cannot be changed operation.
when you play a DVD. Disconnect the AC power cord, then connect it
• Multilingual sound is not recorded on the DVD. again.
• Changing the language for the sound by the
Audio button on the remote or the Audio line Please also refer to the Troubleshooting
in the Player Menu is prohibited on the DVD. In guide contained in your loudspeaker
that case the audio language must be selected Owners Manual.
by the main menu on the DVD.

The subtitle language cannot be changed

when you play a DVD.
• Multilingual subtitles are not recorded on the
DVD.
• Changing the language for the subtitles by the
Subtitle button on the remote or the Subtitle
line in the Player Menu is prohibited on the
DVD. In that case the subtitle language must
be selected by the main menu on the DVD.

Page 4 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 7

harman/kardon HS 350/650DL Service Manual

HS 350

Front Panel Controls

ENGLISH
 Main Information Display 3 USB On-The-Go Input 6 Slot Loader
1 Power On/Off (Standby) 4 Headphone Jack
2 Open/Close 5 Volume Control

 Main Information Display: This display 3 USB On-The-Go Input: This input may be 4 Headphone Jack: This jack may be used to
delivers messages and status indications to help used to temporarily connect a USB thumb device listen to the system's output through a pair of
you operate the HS 350 Controller. or portable hard disk for direct playback of headphones. Be certain that the headphones
1 Power On/Off (Standby): Press the button audio, image of video files or a USB hub. The have a standard 3.5 mm stereo phone plug.
once to turn the HS 350Controller on, press it USB inputs are designed to power a single USB Note that the main room speakers will
again to put the unit in the Standby mode. device at a time. If additional hard disks are automatically be turned off when the
Note that when the HS 350 Controller is connected through a hub it is necessary that headphone jack is in use.
switched on, the Power Indicator around the additional external power supplies are used to When configuring your system using EzSet/EQ,
button turns white. power the hub and hard disks. the calibration microphone should be plugged
2 Eject: Press this button to release a disc into this jack 4.
from the loader. 5 Volume Control: Turn this knob clockwise
to increase the volume, counterclockwise to
decrease the volume. If the system is muted,
adjusting volume control will automatically
release the unit from the silenced condition.
6 Slot loader: Gently insert a CD or DVD into
this slot, with the printed side of the disc facing
up. Note there is no drawer. Press the Eject
Button 2 to release the disc

Page 5 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 8

harman/kardon HS 350/650DL Service Manual

HS 350

Front Panel Display

A Disc Type Indicators G Source Indicators M Angle Indicator

B Playback-Mode Indicators H Repeat Indicators N Title Indicators
C Progressive Scan Indicator I VCD Playback Control Indicator O Chapter/Track Number Indicators
D Parental Lock Indicator J Random Indicator P Video Output Indicators
E Time Indicators K A-B Repeat Indicator
F Video Format Indicators L Program Indicator

A Disc Type Indicators: The CD or DVD E Time Indicators: These positions in the I VCD Playback Control Indicator: This
indicator will illuminate to show the type of disc indicator will show the running time of a DVD in indicator lights when the playback control
currently being played. play. When a CD is playing, these indicators will function is turned on with VCDs.
show the current track time, time remaining in
B Playback-Mode Indicators: These J Random Indicator: This indicator lights
the current track, or the total remaining time on
indicators light to show the current playback when the unit is in the Random Play mode.
the disc. When an iPod is playing, the display
mode:
will show the elapsed and remaining time on the K A-B Repeat Indicator: This indicator lights
NLights when a disc is playing in the normal top line. The bottom line will scroll information when a specific passage for repeat playback has
mode about the song, title, album and artist. been selected.
H Lights when the disc is in the Fast Search NOTE: The Indicators NOE will also display L Program Indicator: This indicator lights
Forward mode. The on-screen banner display text messages about the DVD’s status, including when the programming functions are in use.
indicates the selected speed (2x, 8x, 16x, 100x). Reading when a disc is loading,
M Angle Indicator: This indicator blinks when
STANDBY when the unit is turned off, and
1 Lights when the disc is paused. alternative viewing angles are available on the
Disc Error when a disc not compatible
DVD currently playing.
G Lights when the disc is in the Fast Search with the DVD is put into the play position.
Reverse mode. The on-screen banner display N Title Indicators: These two positions in the
F Video Format Indicators: These indicators
indicates the selected speed (2x, 8x, 16x, 100x). display will show the current title number when
will represent the video format currently playing.
a DVD disc is playing.
C Progressive Scan Indicator: This indicator
G Source Indicators: These indicators will
lights when the unit sends out a progressive O Chapter/Track Number Indicators: When
light to show which source is currently selected.
scan signal. a DVD disc is playing, these two positions in the
H Repeat Indicators: These indicators light display will show the current chapter. When a
D Parental Lock Indicator: This indicator
when any of the Repeat functions are in use. CD disc is playing they will show the current
lights when the parental-lock system is engaged
track number.
in order to prevent anyone from changing the
rating level without a code. P Video Output Indicators: These indicators
will represent the active video output. .

Page 6 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 9

harman/kardon HS 350/650DL Service Manual

HS 350

Rear Panel Connections

ENGLISH
0 Composite Video Output 8 Coaxial Digital Input G USB On-The-Go Input
1 S-Video Output 9 Optical Digital Input H HDMI Output
2 Component Video Outputs A Analog Audio Outputs I Remote IR Output
3 Scart TV Output B Front Speaker Outputs J Remote IR Input
4 AC Power Cord C Center Speaker Outputs K TV Audio In
5 FM Antenna D Surround Speaker Outputs L DMP Connector
6 Audio In E Coaxial Digital Output
7 Subwoofer Output F Subwoofer Trigger Output

0 Composite Video Output: Connect this 4 AC Power Cord: Connect this plug to an AC B Front Speaker Outputs: Connect these
jack to the video input on a television or video outlet. If the outlet is controlled by a switch, outputs to the matching + or – terminals on your
projector. make certain that it is in the ON position. left and right speakers. In conformance with the
new CEA color code specification, the White
1 S-Video Output: Connect this jack to the 5 FM Antenna: Connect to the supplied FM
terminal is the positive, or "+" terminal that
S-Video input on a television or video projector. antenna.
should be connected to the red (+) terminal on
2 Component Video Outputs: These outputs 6 Audio In: Connect to a line-level analog Front Left speaker with the older color coding,
carry the component video signals for connection audio source: TV, tape player, Minidisc, PC, etc. while the Red terminal is the positive, or "+"
to display monitors with component video inputs. terminal that should be connected to the red (+)
7 Subwoofer Output: Connect to the terminal on Front Right speaker. Connect the
For standard analog TV's or projectors with
SUB/LFE input on the subwoofer. black (–) terminals on the HS to the black (–)
inputs marked Y/Pr/Pb or Y/Cr/Cb, connect these
outputs to the corresponding inputs. If you have 8 Coaxial Digital Input: Connect the coax terminals on the speakers. See page 14 for more
a high-definition television or projector that is digital output from a DVD player, HDTV receiver, information on speaker polarity.
compatible with high scan rate progressive video, LD player, MD player, satellite receiver or CD C Center Speaker Outputs: Connect these
connect these jacks to the “HD Component” player to this jack. The signal may be either a outputs to the matching + and – terminals on
inputs. Note that if you are using a progressive Dolby Digital signal, DTS signal or a standard your center channel speaker. In conformance with
scan display device, then ”Progressive” must be PCM digital source. Do not connect the RF digital the new CEA color code specification, the Green
selected in the Video Set-up Menu in order to output of an LD player to these jacks. Terminal is the positive, or "+" terminal that
take advantage of the progressive scan circuitry.
See page 22 for more information on progressive 9 Optical Digital Input: Connect the optical should be connected to the red (+) terminal on
digital output from a DVD player, HDTV receiver, speakers with the older color coding. Connect
scan video.
LD player, MD player, satellite receiver or CD the black (–) terminal on the HS to the black
IMPORTANT: These jacks should NOT be player to this jack. The signal may be either a negative (–) terminal on your speaker. (See page
connected to standard composite video inputs. Dolby Digital signal, DTS signal or a standard 14 for more information on speaker polarity.)
3 SCART OUT (TV): If your TV has a SCART PCM digital source.
socket, you can connect a SCART cable to your A Analog Audio Outputs: Connect these
TV and to your DVD Player for improved video jacks to the analog audio input on a TV set or
quality. The SCART cable carries both audio and external audio system for analog audio playback
video. You can select Composite Video or RGB or to the RECORD/INPUT jacks of an audio
video for that SCART connector’s video output recorder for recording.
signal.

Page 7 of 89
34252_HS350_Eng:34252_HS350_Eng 28/01/08 12:54 Side 10

harman/kardon HS 350/650DL Service Manual

HS 350

Rear Panel Connections

D Surround Speaker Outputs: Connect G USB On-The-Go Input: This input may be L Digital Media Player (DMP)
these outputs to the matching + and – terminals used to temporarily connect a USB thumb device Connector: With the HS 350 turned off,
on your surround channel speakers. In confor- or portable hard disk for direct playback of connect one end of the optional Harman Kardon
mance with the new CEA color code specifica- audio, image of video files, a digital photo to this proprietary connector, and the
tion, the Blue terminal is the positive, or "+" camera or a USB hub. other to your compatible Apple iPod. When the
terminal that should be connected to the red (+) Digital Media Player source is selected, you may
H HDMI Output: Connect this output to the
terminal on the Surround Left speaker with older view your iPod’s control and navigation
HDMI input of high-definition LCD, Plasma or
color coding, while the Gray terminal should be messages on your video display (if one is
video projector for the best possible picture
connected to the red (+) terminal on the connected to one of the Video Monitor
quality.
Surround Right speaker with the older color Outputs 0123H), and in the Upper
coding. Connect the black (–) terminal on the HS I Remote IR Output: This connection and Lower Display Lines E. You may
to the matching black negative (–) terminals for permits the IR sensor in the receiver to serve navigate the iPod and select tracks for playback
each surround speaker. (See page 14 for more other remote controlled devices. Connect this using the ⁄/¤/‹/› Buttons 9 and the
information on speaker polarity.) jack to the “IR IN” jack on Harman Kardon or Enter Button 6.
Note: You’ll find more details about all other compatible equipment.
Audio/Video connections under Setup and J Remote IR Input: If the HS 350’s front-
Connections on the following pages. panel IR sensor is blocked due to cabinet doors
E Coaxial Digital Output: Connect this jack or other obstructions, an external IR sensor
to the matching digital input connector on a may be used. Connect the output of the sensor
digital recorder such as a CD-R or MiniDisc to this jack.
recorder. K TV Audio Input: If your screen is
F Subwoofer Trigger Output: Connect this connected to the HS by an HDMI, Component,
trigger output to the trigger input of the S-Video or Composite cable, connect the
Harman Kardon subwoofer, so that the analog output of your TV to this input. If you
subwoofer will switch on and off at the same have your TV connected to the HS with a Scart
time as the rest of the system. cable, an audio connection to the TV Input is
not necessary.

Page 8 of 89
 harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Digital Lounge Controller Specifications

ENGLISH
DVD player Pickup: Semiconductor laser, wavelength 650nm
Signal system: NTSC / PAL
Video signal horizontal resolution: More than 480 lines (DVD)
Video signal-to-noise ratio: More than 60 dB (DVD)
Audio frequency response: DVD (PCM): 20 Hz ~ 22 kHz (+/- 1.0 dB)
(Stereo) CD (PCM): 20 Hz ~ 20 kHz (+/- 1.0 dB)
Audio signal-to-noise ratio: More than 80 dB (PCM)
Total harmonic distortion:: Less than 0.01% (PCM)
Dynamic range: DVD (PCM): More than 85 dB (EIAJ, 2 kHz)
CD: More than 85 dB (EIAJ)

Amplifer output Power (per channel): 65 W (6ohms)

Signal-to-noise ratio: > 85 dB
Total Harmonic distortion: < 0.2%

FM Tuner System: PLL quartz-locked digital synthesizer system

Tuning range: 87.50 ~ 108.00 MHz
Antenna terminals: 75 ohms, unbalanced
Intermediate frequency: 10.7 MHz

Video Outputs: HDMI™ Output: Video: 576p, 720p, 1080i

HDMI Version 1.0-compliant
HDCP Version 1.1-compliant
Component Video Output: Y: 1 Vp-p/75 ohms, sync negative polarity
Cr: 0.7 Vp-p/75 ohms
Cb: 0.7 Vp-p/75 ohms
CVBS Video: 1 Vp-p 75 ohms
S-video: Y: 1 Vp-p 75 ohms
C: PAL 0.3 Vp-p 75 ohms / NTSC 0.286 Vp-p 75 ohms

Audio line Outputs Audio L/R: 2 Vrms, 1 kilohms

General Power requirements: AC 230 V, 50 Hz

Max power consumption: 500 W
Idle power consumption: Less than 2 W
Dimensions (WxHxD): 440 mm x 68 mm x 380 mm
Weight: 8.5 kg
* Designs and specifications are subject to change without notice.

Depth measurement includes knobs, buttons and terminal connections. Height measurement includes feet and chassis.
All features and specifications are subject to change without notice.
Harman Kardon The Bridge, and Logic 7 are registered trademarks of Harman International Industries, Incorporated.
Dolby, Pro Logic and the double-D symbol are trademarks of Dolby Laboratories, registered in the United States and/or other countries.
is a trademark of Harman International Industries, Inc.
All rights reserved.
DTS is a trademark of Digital Theater Systems, Inc.
Windows Media® Audio (WMA) is a proprietary file format developed by Microsoft.
DivX is a registered trademark of DivX, Inc.
HDMI, the HDMI logo and High-Definition Multimedia Interface are trademarks or registered trademarks of HDMI Licensing LLC.

Page 9 of 89
 harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Troubleshooting

ENGLISH
For the Controller There is no sound or volume is very low The sound comes from the
• Check that the speakers and components are center speaker only.
If you experience any of the following difficulties
connected correctly and securely. • Depending on the disc, sound may sometimes
while using the system, use this troubleshooting
• Make sure that you have selected the correct come from the center speaker only. This also
guide to help you remedy the problem.
source on the system. applies to mono recordings (from disc or any
Should any problem persist, consult your author-
analog source), when Pro Logic mode is select-
ized Harman Kardon dealer. • Press MUTE on the remote control, if the ed. This is normal.
No power. words MUTE ON are blinking on the front
panel display. No sound is heard from the
• Is the power cord firmly plugged into the
center speaker.
power outlet? • The protective circuitry has been activated • Adjust center speaker volume (see pages 19).
• One of the safety mechanisms may be operat- because of a short circuit. Turn off the system,
eliminate the short circuit problem and turn on No sound or only very low volume
ing. In this event, unplug the player from the
the power again. from the rear speakers.
power outlet briefly and then plug it in again.
• Adjust the rear speaker volume (see page 19).
No picture. • The audio interconnect is damaged. Replace it
with a new one. The volume goes down automatically
• Check that the system is connected correctly
and cannot be increased.
and securely. • The system is in pause mode or in slow-motion
play mode, or fast forward or fast reverse. • The internal temperature is too high. Wait
• The video cable may be damaged. Replace it
Press N to return to normal play mode. approximately one minute for the amplifier to
with a new one.
reach normal working temperature.
• Make sure the system is connected to a video • Check the speaker settings (see page 19).
Radio stations cannot be tuned in.
input on the TV (see page 14). The left and right channels are • Check that the antenna is connected correctly.
• Make sure the TV is turned on. unbalanced or reversed. Adjust the antenna and connect an external
• Check that the speakers and components are antenna if necessary.
• Make sure the correct video input on the TV is
connected correctly and securely.
selected for viewing with this system. • The signal strength of the stations is too weak
Severe hum or noise is heard. for automatic tuning. Use manual tuning.
Noise (interference) appears in
• Check that the speakers and components are
the picture. • No stations have been preset.
connected securely.
• Clean the disc.
• Check that the connecting cords are away from • The tuner mode is not selected, select the
• If video from this system has to go through Radio mode.
a transformer or motor and at least 3 meters
your VCR to get to your TV, the copy-protection
away from fluorescent light. The remote does not function.
applied to some DVD programs could affect
• Move your TV away from the audio compo- • Remove any obstacles between the remote
picture quality. If you still experience problems
nents. control and the system.
after checking your connections, please try con-
necting your DVD system directly to your TV’s • The plugs and jacks are dirty. Wipe them with a • Move the remote control closer to the system.
S-Video input, if your TV is equipped with this cloth slightly moistened with alcohol. • Point the remote control at the remote sensor
input (see page 14). on the front panel.
• Clean the disc.
The aspect ratio of the screen is wrong • Replace all the batteries in the remote control
(picture vertically expanded) when you • Disconnect antenna cables from external
sources (also PC) connected to the screen or with new ones if they are weak.
play a wide picture by the player or an
external source connected to the screen system. If hum disappears use an antenna • Check that the batteries are loaded correctly.
even though you set “TV DISPLAY” in the transfomer between antenna and source. The disc does not play.
SETUP menu to "Auto". • If PC is connected to the system disconnect the • There is no disc inside. (“NO DISC” appears on
• If you connect the system or the external Audio and Video cables. If hum disappears use the front panel display and the TV screen.)
source with the SCART cable, connect directly an audio transformer between PC audio out Insert a disc.
to the TV. Otherwise the autoswitch function of and system input. If hum persists unplug PC • Insert the disc correctly with the playback side
the aspect ratio for the TV may not work. from your system and ask your local dealer for facing down.
• If the TV is not connected with a SCART cable a proper solution (ground loop interrupt).
• Clean the disc.
to the HS (as recommended) or the external The surround effect is difficult to hear
source, or if the autoswitch function does not when you are playing a Dolby Digital • The system cannot play CD-ROM's, etc.
work you should turn the TV to "Fill All". sound track. (see page 3).
• Check to see if the Dolby Digital mode is • DVD with wrong region code
turned on properly, otherwise unload and load (see page 13).
the disc again.
Playback stops automatically.
• Check the speaker connections. • Some discs include an auto pause signal. When
• Depending on the DVD disc, the output signal playing such a disc, the system stops playback
may at times be mono or stereo even if the at the signal.
soundtrack is recorded in Dolby Digital format.

Page 10 of 89
harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Troubleshooting

Track Skip or direct select with numeric The audio language cannot be changed The subtitles cannot be turned off when
buttons, Search, Slow-motion play, repeat when you play a DVD. you play a DVD.
play or Program play, etc., cannot be • Multilingual sound is not recorded on the • Depending on the DVD, you may not be able
done. DVD. to turn the subtitles off.
• Depending on the DVD or VCD, some of the • Changing the language for the sound by the The angles cannot be changed when you
above operations may not be available Audio button on the remote or the Audio line play a DVD.
(Playback control). in the Player Menu is prohibited on the DVD. • Multi-angles are not recorded on most DVDs.
Messages do not appear on the TV screen In that case the audio language must be • Change the angles when the angle mark
in the language you want. selected by the main menu on the DVD. appears on the TV screen.
• Select the language for Display and Preferred The subtitle language cannot be changed
Subtitle in the SETUP menu (see page 18). • Changing the angles is prohibited on some
when you play a DVD. DVDs.
For all messages from the DVD (DVD menu, • Multilingual subtitles are not recorded on the
subtitles) in the proper language, the disc DVD. The system does not operate properly.
must have the language you selected, if not, • Static electricity, etc., may affect the system’s
another language will be selected. • Changing the language for the subtitles by the operation.
Subtitle button on the remote or the Subtitle Disconnect the AC power cord, then connect it
line in the Player Menu is prohibited on the again.
DVD. In that case the subtitle language must
be selected by the main menu on the DVD. Please also refer to the Troubleshooting
guide contained in your loudspeaker
Owners Manual

For the TV
Defect Possible cause Possible remedy

No picture although the mains plug is • Mains switch in position ”0” (OFF). • Shift mains switch to position ”I”.
inserted and the unit is switched on. • Mains plug of unit is not inserted into • Insert the mains cable plug into the
the plug receptacle. plug receptacle.
• The HDMI cable is not properly inserted. • Insert the HDMI cable firmly.
• Defective mains cable. • Call the service hotline.

Screen dark. • Contrast setting too low. • Set the brightness and/or contrast correctly
(see Picture Calibration).
• No input signal, wrong input selected. • Check the connection cable; assign correct
input to source.

Weak or excessive colours. • Colour not correctly set. • Set the colour correctly
(see Picture Calibration).
• Connection cable not correctly connected. • Connect the cable correctly.

The picture is too large or too small. • Picture format set wrongly. • Repeatedly press the Screen Format Button
 until the picture is displayed as full
screen.

The displayed picture is too dark. • The picture quality is not set correctly. • Correct the picture brightness and contrast
(see Picture Calibration)

The picture is displayed, • The sound is switched to mute. • Press the Mute Button A on the remote
but there is no sound. control.
• The Coaxial Digital Audio cable is not properly • Insert the Coaxial Digital Audio cable firmly.
inserted.
• Volume is set to minimum. • Increase the volume.

Horizontal stripes with TV • Signal source is placed in front of the display. • Always place the signal sources on the side of
or video signals. or behind the display.

Page 11 of 89
harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Front Panel Controls

Digital Louge

 Main Information Display 3 USB On-The-Go Input 6 Slot Loader

1 Power On/Off (Standby) 4 Headphone Jack
2 Open/Close 5 Volume Control

 Main Information Display: This display 4 Headphone Jack: This jack may be used to 6 Slot loader: Gently insert a CD or DVD into
delivers messages and status indications to help listen to the system's output through a pair of this slot, with the printed side of the disc facing
you operate the Digital Lounge Controller. headphones. Be certain that the headphones up. Note there is no drawer. Press the Eject
1 Power On/Off (Standby): Press the button have a standard 3.5 mm stereo phone plug. Button 2 to release the disc
once to turn the Digital Lounge Controller on, Note that the main room speakers will
press it again to put the unit in the Standby automatically be turned off when the
mode. headphone jack is in use.
Note that when the Digital Lounge Controller is When configuring your system using EzSet/EQ,
switched on, the Power Indicator around the the calibration microphone should be plugged
button turns blue. into this jack 4.
2 Eject: Press this button to release a disc 5 Volume Control: Turn this knob clockwise
from the loader. to increase the volume, counterclockwise to
3 USB On-The-Go Input: This input may be decrease the volume. If the system is muted,
used to temporarily connect a USB thumb device adjusting volume control will automatically
or portable hard disk for direct playback of release the unit from the silenced condition.
audio, image of video files or a USB hub. The
USB inputs are designed to power a single USB
device at a time. If additional hard disks are
connected through a hub it is necessary that
additional external power supplies are used to
power the hub and hard disks.

Page 12 of 89
 harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Front Panel Display

ENGLISH
A Disc Type Indicators G Source Indicators M Angle Indicator
B Playback-Mode Indicators H Repeat Indicators N Title Indicators
C Progressive Scan Indicator I VCD Playback Control Indicator O Chapter/Track Number Indicators
D Parental Lock Indicator J Random Indicator P Video Output Indicators
E Time Indicators K A-B Repeat Indicator
F Video Format Indicators L Program Indicator

A Disc Type Indicators: The CD or DVD E Time Indicators: These positions in the I VCD Playback Control Indicator: This
indicator will illuminate to show the type of disc indicator will show the running time of a DVD in indicator lights when the playback control
currently being played. play. When a CD is playing, these indicators will function is turned on with VCDs.
show the current track time, time remaining in
B Playback-Mode Indicators: These J Random Indicator: This indicator lights
the current track, or the total remaining time on
indicators light to show the current playback when the unit is in the Random Play mode.
the disc. When an iPod is playing, the display
mode:
will show the elapsed and remaining time on the K A-B Repeat Indicator: This indicator lights
NLights when a disc is playing in the normal top line. The bottom line will scroll information when a specific passage for repeat playback has
mode about the song, title, album and artist. been selected.
H Lights when the disc is in the Fast Search NOTE: The Indicators NOE will also display L Program Indicator: This indicator lights
Forward mode. The on-screen banner display text messages about the DVD’s status, including when the programming functions are in use.
indicates the selected speed (2x, 8x, 16x, 100x). Reading when a disc is loading,
M Angle Indicator: This indicator blinks when
STANDBY when the unit is turned off, and
1 Lights when the disc is paused. alternative viewing angles are available on the
Disc Error when a disc not compatible
DVD currently playing.
G Lights when the disc is in the Fast Search with the DVD is put into the play position.
Reverse mode. The on-screen banner display N Title Indicators: These two positions in the
F Video Format Indicators: These indicators
indicates the selected speed (2x, 8x, 16x, 100x). display will show the current title number when
will represent the video format currently playing.
a DVD disc is playing.
C Progressive Scan Indicator: This indicator
G Source Indicators: These indicators will
lights when the unit sends out a progressive O Chapter/Track Number Indicators: When
light to show which source is currently selected.
scan signal. a DVD disc is playing, these two positions in the
H Repeat Indicators: These indicators light display will show the current chapter. When a
D Parental Lock Indicator: This indicator
when any of the Repeat functions are in use. CD disc is playing they will show the current
lights when the parental-lock system is engaged
track number.
in order to prevent anyone from changing the
rating level without a code. P Video Output Indicators: These indicators
will represent the active video output. .

Page 13 of 89
harman/kardon HS 350/650DL Service Manual

DIGITAL LOUNGE 6XX

Rear Panel Connections

B 7 F 3 2 1 0

4 D E 9 8 G A 6 I H 5

 HDMI Output Subwoofer Output  Coaxial Digital Output

 Remote IR Output Coaxial Digital TV Input  Subwoofer Trigger Output
 Remote IR Input Optical Digital Input  Coaxial Digital Input
 USB On-The-Go Input Analog Audio Outputs  DMP The Bridge Input
 AC Power Cord Front Speaker Outputs  Analog Audio Inputs
 FM Antenna  Center Speaker Outputs
 Audio In  Surround Speaker Outputs

 HDMI Output: Connect this output to the  FM Antenna: Connect to the supplied FM Front Speaker Outputs: Connect these
HDMI input J of the screen, using the supplied antenna. outputs to the matching + or – terminals on
HDMI - SP-DIF - Remote In/Out cable. your left and right speakers. In conformance with
 Audio In: Connect to a line-level analog
the new CEA color code specification, the White
 Remote IR Output: This connection per- audio source: TV, tape player, Minidisc, PC, etc.
terminal is the positive, or "+" terminal that
mits the IR sensor in the receiver to serve other
Subwoofer Output: Connect to the should be connected to the red (+) terminal on
remote controlled devices. Connect this jack to
SUB/LFE input on the subwoofer. Front Left speaker with the older color coding,
the “IR IN” jack on Harman Kardon or other
while the Red terminal is the positive, or "+"
compatible equipment. Note this connection is Coaxial Digital TV Input: Connect the terminal that should be connected to the red (+)
only necessary for optional, additional products Coax Digital TV Output H of the screen to this terminal on Front Right speaker. Connect the
connected to the player. It is not necessary for jack, using the supplied HDMI - SP-DIF - Remote black (–) terminals on the Digital Lounge system
proper control of the Digital Lounge system. In/Out cable. to the black (–) terminals on the speakers. See
 Remote IR Input: Connect this input to the Optical Digital Input: Connect the optical page 15 for more information on speaker polari-
Remote IR Output U of the TV, using the special digital output from a DVD player, HDTV receiver, ty.
HDMI - SP-DIF - Remote In/Out cable. This will LD player, MD player, satellite receiver or CD  Center Speaker Outputs: Connect these
allow you to control all components in your sys- player to this jack. The signal may be either a outputs to the matching + and – terminals on
tem by pointing the remote control to the TV Dolby Digital signal, DTS signal or a standard your center channel speaker. In conformance
only. PCM digital source. with the new CEA color code specification, the
 USB On-The-Go Input: This input may be Analog Audio Outputs: Connect these Green Terminal is the positive, or "+" terminal
used to temporarily connect a USB thumb device jacks to the RECORD/INPUT jacks of an optional that should be connected to the red (+) termi-
or portable hard disk for direct playback of audio recorder for recording. nal on speakers with the older color coding.
audio, image of video files, a digital photo cam- Connect the black (–) terminal on the Digital
era or a USB hub. Lounge system to the black negative (–) terminal
on your speaker. (See page 15 for more informa-
 AC Power Cord: Connect this plug to an tion on speaker polarity.)
AC outlet. If the outlet is controlled by a switch,
make certain that it is in the ON position.

Page 14 of 89
harman/kardon HS 350/650DL Service Manual

HS 350 PACKAGE LIST AND PARTS

19

16

17

18 15
14
13
21
12
11
9
20 8
7
5
6
4
10
3

HS350 EU Packing instruction

Drawing by. : Jenniferzph
May,10'2008

Page 15 of 89
 harman/kardon HS 350/650DL Service Manual

HS 650 PACKAGE LIST AND PARTS

14

12

11

13

16

10
8
15 7
6
5 9
4
3

HS650DL EU Packing instruction

Drawing by. : Jenniferzph
May,10'2008

Page 16 of 89
harman/kardon HS 350/650DL Service Manual

HS 350/230 and HS/DL 650/230 EXPLODED VIEW

Page 17 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List

Location.No. Description Specification P/N
HS350-PT01 Metals Part HS350-chassis 01.00.WJ.TJ.HS350.E001
HS350-PT02 Metals Part HS350-top cover 01.00.WJ.TJ.HS350.E002
HS650DL-PT01 Metals Part HS650DL-rear panel 01.00.WJ.TJ.HS650.E001
HS650DL-U type connect
HS650DL-PT02 Metals Part 01.00.WJ.TJ.HS650.E002
piece
HS350-PT04 Metals Part HS350-PCB bracket 01.00.WJ.TJ.HS350.E003
For S702 on SMPS board Heatsink HS350-PT05 100*55*55 01.00.WJ.TJ.HS350.E004
For S703 on SMPS board Heatsink HS350-PT06 67*53*22 01.00.WJ.TJ.HS350.E005
For S704 on SMPS board Heatsink HS350-PT07 143*53*22 01.00.WJ.TJ.HS350.E006
For S704 and S703 on SMPS board Heatsink HS350-PT08 143*134*2 01.00.WJ.TJ.HS350.E007
HS350-PT09 35*11*48 (Hole
For S701 on SMPS board Heatsink 01.00.WJ.TJ.HS350.E008
height is 18mm)
HS350-PT10 Between AV board and
Hexagonal Nut M3*30 01.00.WJ.JG.E946
Mainboard
For U4 on Mainboard Heatsink 28*28*10mm 01.00.WJ.TJ.E268
HS350-RE01 plastic part HS650-front pannel 01.00.SJ.HS650.E003
HS200-RE02 plastic part HS200-2 in 1 Button 01.00.SJ.HS200.E002
HS200-RE03 plastic part HS200-Open button collar 01.00.SJ.HS200.E003
HS100-RE06 plastic part HS100-Volume Button Collar 01.00.SJ.HS100.E006
HS200-RE04 plastic part HS200-Button Cover Board 01.00.SJ.HS200.E004
HS200-Power Indicator
HS200-RE05 plastic part 01.00.SJ.HS200.E005
lampshade
HS200-RE06 plastic part HS200-pedestal underlay 01.00.SJ.HS200.E006
HS350-RE02 plastic part HS650DL-Large Lens 01.00.SJ.HS650.E001
HS100-RE10 plastic part HS100-Volume Button 01.00.SJ.HS100.E010
HS100-Volume Button
HS100-RE08 plastic part 01.00.SJ.HS100.E008
Lampshade
1000A-IR receiver support
plastic part 01.00.SJ.1000A.E016
5.5mm
Add on Power cord Magnetism annulus M248 01.13.L.H.E020
VFD filter 124.5*33.5*0.5mm 01.00.SJ.QT.E019
AC power Jack WS-044-0 01.40.CON.DCZ.E178
100mm "Harman/Kardon" Thin
Metal logo 01.00.SB.E036
Logo
Dustproof for Disc tray
Black color LTD-1510 01.00.DP.JY.E135
door of Loder
50.6*4.2*1.5mm (with #500
For pedestal underlay HS100-H01 Silica gel gasket 01.00.DP.XJ.E192
glue be single sides glued )
20*10*5MM (with #9448 glue
For VFD (2) sponge 01.00.DP.HM.E117
be double sides glued )
Between volume button and Front Panel
Astigmatism PVC Φ45.5*Φ9.5mm 01.00.FZ.QT.153
Board
φ38.5(Underside Glued)Black
Inside the volume button Mask PVC 01.00.FZ.QT.E253
color, PVC
10*10*7MM (with double sides
For IR receiver sponge 01.00.DP.HM.E364
glued)
paste in front of Disc tray door in the front 124*10*2MM (with Single side
High Soft sponge 01.00.DP.HM.E378
panel glued,Black color)
Between Front Panel Board and Plastic Part electric sponge 20*20*10MM 01.00.DD.PM.E271
Plastic fastener 12CM 01.00.FZ.QT.E122
For Q509 on SMPS board Sil-pad sil-pad 400-3022 01.00.DP.QT.E113
Diathermanous
For Amplifier board 100*8*1mm 01.00.DP.JY.E583
Selenium Rubber
Be buckled above volume button board Insulated PVC HS200-H02 01.00.DP.JY.E249
22.5*10*0.3mm(with Single
For hamulus of front panel Insulated PVC 01.00.DP.JY.E541
side glued)
Insulated PVC HS350-H01 01.00.DP.JY.E134
20*10*8MM(with double sides
Between Tuner and chassis sponge 01.00.DP.HM.E263
glued)
For Front Panel and Left/Right sides of
chassis (4),For Front Panel and Volume Screw 3*6KBTTNI 01.00.WJ.JG.E085
Board(2)
For chassis and pedestal underlay(6) Screw 3*6PWBTTNI 01.00.WJ.JG.E543
For chassis and pedestal underlay(3) Screw 3*6PWMHNI 01.00.WJ.JG.E795
For Front panel board and chassis and
Screw 3*8PWBTTNI 01.00.WJ.JG.E235
pedestal underlay(3)
For Front panel and Front panel board/key(9) Screw 3*8PAHC 01.00.WJ.JG.E166
For Loader and chassis(4),For PCB Bracket
Screw 3*6PWBTTC W=7 01.00.WJ.JG.E091
and chassis(4),For Mainboar and Bracket(2)
For SMPS board and chassis(6),For AV board
and chassis(1),For Mainboard(2),For Amplifier Screw 3*6PWMHC W=7 01.00.WJ.JG.E451
board and Bracket(4)

Page 18 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List

Location.No. Description Specification P/N
For Rear panel and chassis(2),For Top cover
Screw 3*4RBTTNI 01.00.WJ.JG.E252
and the bottom side of chassis(4)
For output jacks(10),For frequency modulation
module(2),For U type connect piece and rear Screw 3*8PAHO 01.00.WJ.JG.E321
panel(3)
For top cover and chassis, top cover and rear
Screw 3*6PWBTTO 01.00.WJ.JG.E403
panel(5)
For AC power socket (2) Screw 3*10 PMHO 01.00.WJ.JG.E502
For IC and Heatsinks on SMPS board (10) Screw 3*6PBTTC 01.00.WJ.JG.E087
Among Heatsinks on SMPS board 3 Screw 3*6PWMTTC W=7 01.00.WJ.JG.E093
For Button cover Board and button Board Screw 1.7*4CAHNI D=3.2 Free-Lead 01.00.WJ.JG.E655
BD701 fixed with Heatsink on SMPS board(1) Screw 3*8PBTTC 01.00.WJ.JG.E417
For power jack(2) Nut M3 01.00.WJ.JG.E119
For uncovered Screw drilled through the
Screw Jacket Ф3*4mm 01.00.FZ.TG.E025
chassis
For Insulated gasket and volume button Board Plastic Rivet MBL3-2.5 01.00.SJ.QT.E104
HDMI Cord 1770261-1(2M) 01.47.CNT.LJX.5.E241
Microphone H03-MCD12TWBKNN-R-A 01.00.SP.E254
WS-002E+WS-019 HO5VV-F
WS-002E+WS-019 HO5VV-F 0.75×2C BK 2M Power Cord 01.47.CNT.ACX.E052
0.75×2C BK 2M
FM-TV-22 (Lead content less
Antenna 01.47.CNT.CTX.E016
than 300PPM)
Loader DL-05MH-H40P 01.15.JX.EDL05MH
IEC Head for FM Connector (NON-Screw FM frequency
TFCF1E806A 01.49.E11
Thread) modulation module
CN701 on SMPS to Power Jack with solder VH-3Y Connector-2Y-
Connect cable 01.47.CNT.LJX.7.E776
one end 240mm(Be same side)
VH-4Y Connector-4Y-4Y-
CN706 on SMPS to CN403 on Amplifier board Connect cable 01.47.CNT.LJX.7.E726
150mm(Be same side)
CN405 on Amplifier board to CN902 on VH-10Y Connector-10Y-10Y-
Connect cable 01.47.CNT.LJX.7.E777
Speaker board 100mm(Be different side)
70mm single-core cable (with
Connect ground beside headphone jack to
Connect cable solder one end and ground 01.47.CNT.LJX.7.E795
SMPS
piece φ4 connect another end)
CN601(A) on Front panel board to CN5(A) on
Flat cable 1.0*22P*80mmA 01.48.BPX.1.E170
Mainboard
CN6(C) on Mainboard to CN704(C) on SMPS
Flat cable 1.25*16P*80mmA(T=0.1mm) 01.48.BPX.1.E171
board
CN9(D) on Mainboard to CN301(D) on AV
board,CN8(E) on Mainboard to CN302(E) on Flat cable 1.0*20P*70mmA 01.48.BPX.1.E172
AV board
CN7(F) on Mainboard to CN303(F) on AV
Flat cable 1.25*18P*70mmA(T=0.1mm) 01.48.BPX.1.E173
board
CN702(G) on SMPS board to CN602(G) on
Flat cable 1.25*14P*110mmA(T=0.1mm) 01.48.BPX.1.E174
Front panel board
CN703(I) on SMPS board to CN402(I) on
Flat cable 1.25*6P*110mmA(T=0.1mm) 01.48.BPX.1.E176
Amplifier board
CN404 on Amplifier to CN901 on Speaker
Flat cable 1.0*8P*50mmA 01.48.BPX.1.E177
board
CN4(B) on Mainboard to CN401 on Amplifier
Flat cable 1.0*16P*80mmA 01.48.BPX.1.E150
board
CN604(J) on Front panel board to CN605(J)
Flat cable 1.0*6P*40mmA 01.48.BPX.1.E154
on Volume board
Loader to CN2 on Mainboard Flat cable 1.0*12P*220mmA 01.48.BPX.1.E156
Loader to CN1 on Mainboard Flat cable 0.5*24P*200mmA 01.48.BPX.1.E028
Tuner to CN304 on AV board Flat cable 1.25*11P*70mmA 01.48.BPX.1.E085
Main Board (semi- HAV07M-5112C01(EU
4-layers 02.11.HAV07M5112C01
manufactured goods) Version+Hitachi Loader)
AV Board (semi-
2-layers HAV07I-5113C01(EU Version) 02.14.HAV07I5113C01
manufactured goods)
Speaker Board (semi-
2-layers HAV07I-5118C01 02.14.HAV07I5118C01
manufactured goods)
Front panel Board
2-layers (semi-manufactured HAV07K-5115C01 02.15.HAV07K5115C01
goods)
Front panel Board
2-layers (semi-manufactured HAV07K-5116C01 02.15.HAV07K5116C01
goods)
Amplifier Board (semi-
4-layers HAV07A-5329C01 02.17.HAV07A5329C01
manufactured goods)
SMPS Board (semi-
2-layers HAV07P-5117C01 02.19.HAV07P5117C01
manufactured goods)

Page 19 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Main Board (5112C01)

Location.No. Description Specification P/N
R4 R9 R45 R49 R50 R174 R202 R205 R207
R215 (R219) R223 R224 R225 R227 R228
Resistor, chip 0603-0Ω ±5% 01.57.R.2.E000J
R229 R230 R231 R233 R238 R239 FB17
FB19
R156 R158 Resistor, chip 0603-10Ω±5% 01.57.R.2.E100J
R42 R43 R61 R62 Resistor, chip 0603-20Ω±5% 01.57.R.2.E200J
R29 R30 (R31) R32 (R33) R34 (R35) R36
Resistor, chip 0603-22Ω±5% 01.57.R.2.E220J
(R37) R38
R2 R47 R124 R125 R126 R127 R142 R145
R146 R147 R149 R150 R151 R153 R155 Resistor, chip 0603-33Ω±5% 01.57.R.2.E330J
R201 (R211)
R6 (R41) (R71) (R120) (R121) R130 R177
Resistor, chip 0603-100Ω±5% 01.57.R.2.E101J
R221
R206 Resistor, chip 0603-150Ω±5% 01.57.R.2.E151J
R8 R235 Resistor, chip 0603-200Ω±5% 01.57.R.2.E201J
R19 Resistor, chip 0603-220Ω±5% 01.57.R.2.E221J
R173 Resistor, chip 0603-270Ω±5% 01.57.R.2.E271J
R167 Resistor, chip 0603-390Ω±5% 01.57.R.2.E391J
R141 Resistor, chip 0603-475Ω±1% 01.57.R.2.E4750F
R26 R77 R58 Resistor, chip 0603-1KΩ±5% 01.57.R.2.E102J
R80 R83 Resistor, chip 0603-1.2KΩ±5% 01.57.R.2.E122J
R79 R86 Resistor, chip 0603-1.5KΩ±5% 01.57.R.2.E152J
R69 R160 R161 Resistor, chip 0603-1.8KΩ±5% 01.57.R.2.E182J
R13 R14 R15 R16 R18 R87 R92 Resistor, chip 0603-2KΩ±5% 01.57.R.2.E202J
R204 Resistor, chip 0603-2.2KΩ±5% 01.57.R.2.E222J
R65 Resistor, chip 0603-3KΩ±5% 01.57.R.2.E302J
(R11) R88 R209 R210 (R232) Resistor, chip 0603-3.3KΩ±5% 01.57.R.2.E332J
R44 R46 R52 Resistor, chip 0603-3.9KΩ±5% 01.57.R.2.E392J
R5 R10 R21 R27 R55 R57 R63 R67 R96
R162 R163 R168 R170 R178 R185 R186 Resistor, chip 0603-4.7KΩ±5% 01.57.R.2.E472J
R190 R191 R192
R89 Resistor, chip 0603-5.1KΩ±5% 01.57.R.2.E512J
R91 Resistor, chip 0603-6.8KΩ±5% 01.57.R.2.E682J
R12 R20 R24 R25 R28 R56 R64 R66 R68
R75 R76 R78 R81 R82 R122 R123 R128 Resistor, chip 0603-10KΩ±5% 01.57.R.2.E103J
R129 R143 R144 R171 R172
R48 (R72) Resistor, chip 0603-12KΩ±1% 01.57.R.2.E123F
R17 Resistor, chip 0603-15KΩ±5% 01.57.R.2.E153J
R84 R85 Resistor, chip 0603-22KΩ±5% 01.57.R.2.E223J
R40 Resistor, chip 0603-24KΩ±5% 01.57.R.2.E243J
R90 Resistor, chip 0603-27KΩ±5% 01.57.R.2.E273J
R53 Resistor, chip 0603-33KΩ±5% 01.57.R.2.E333J
R51 Resistor, chip 0603-39KΩ±5% 01.57.R.2.E393J
R22 R54 R93 R95 R165 Resistor, chip 0603-47KΩ±5% 01.57.R.2.E473J
R73 Resistor, chip 0603-1MΩ±5% 01.57.R.2.E105J
R59 R60 Resistor, chip 0805-2Ω±1% 01.57.R.3.E2R0F
R3 Resistor, chip 1206-2Ω±5% 01.57.R.4.E020J
Resistor, thick film
RN4 0603-10Ω*4 ±5% 01.57.R.8.EP1004
chip network
Resistor, thick film
RN6 RN7 RN8 RN9 RN10 RN11 0603-33Ω*4 ±5% 01.57.R.8.EP3304
chip network
Resistor, thick film
RN3 0603-4.7KΩ*4 ±5% 01.57.R.8.EP4724
chip network
Resistor, thick film
RN1 0603-10KΩ*4 ±5% 01.57.R.8.EP1034
chip network
Thermmal Dependent
PTC1 JK-MSMD050 SMD 01.57.R.R.E050
Resistor, JinKe
Capacitor, multilayer
C192 0603-3.3P NPO±0.25%/50V 01.54.CS.2.E3P3N50V
ceramic, chip
Capacitor, multilayer
(C65) (C64) (C147) (C146) 0603-6.8P NPO±0.25PF/50V 01.54.CS.2.E6P8N50V
ceramic, chip
Capacitor, multilayer
C97 C112 0603-100P NPO±5%/50V 01.54.CS.2.E101N50V
ceramic, chip
Capacitor, multilayer
C103 C116 0603-180P NPO±5%/50V 01.54.CS.2.E181N50V
ceramic, chip
Capacitor, multilayer
C84 C87 C115 0603-220P NPO±5%/50V 01.54.CS.2.E221N50V
ceramic, chip
Capacitor, multilayer
C129 0603-390P NPO±5%/50V 01.54.CS.2.E391N50V
ceramic, chip
Capacitor, multilayer
C82 C86 C90 0603-470P X7R±10%/50V 01.54.CS.2.E471X50V
ceramic, chip
Capacitor, multilayer
C105 C106 C108 C111 0603-680P X7R±10%/50V 01.54.CS.2.E681X50V
ceramic, chip

Page 20 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Main Board (5112C01)

Location.No. Description Specification P/N
Capacitor, multilayer
C91 C94 C96 C99 C118 C119 0603-102 X7R±10%/50V 01.54.CS.2.E102X50V
ceramic, chip
Capacitor, multilayer
(C19) 0603-152 X7R±10%/50V 01.54.CS.2.E152X50V
ceramic, chip
Capacitor, multilayer
(C20) 0603-272 X7R±10%/50V 01.54.CS.2.E272X50V
ceramic, chip
Capacitor, multilayer
C113 C114 C120 0603-332 X7R±10%/50V 01.54.CS.2.E332X50V
ceramic, chip
Capacitor, multilayer
C191 0603-392 X7R±10%/50V 01.54.CS.2.E392X50V
ceramic, chip
Capacitor, multilayer
C88 0603-472 X7R±10%/50V 01.54.CS.2.E472X50V
ceramic, chip
Capacitor, multilayer
C6 C8 0603-103 Y5V-20+80%/50V 01.54.CS.2.E103Y50V
ceramic, chip
Capacitor, multilayer
C101 0603-153 Y5V-20+80%/50V 01.54.CS.2.E153Y50V
ceramic, chip
Capacitor, multilayer
C16 C117 C127 C136 0603-223 X7R±10%/50V 01.54.CS.2.E223X50V
ceramic, chip
Capacitor, multilayer
(C107) C121 0603-683 X7R±10%/50V 01.54.CS.2.E683X50V
ceramic, chip
C1 C2 C3 C4 C5 C7 C9 C10 (C11) C12 C13
(C14) (C15) (C17) C18 (C21) (C22) C23 (C24)
C25 (C26) (C27) (C28) (C29) (C30) C31 (C32)
(C33) (C34) (C35) (C36) (C37) (C38) (C39)
C40 C41 C42 (C43) (C44) (C45) (C46) (C47)
(C48) (C49) (C50) (C51) (C52) (C53) (C54)
(C55) (C56) (C57) (C58) (C59) (C60) (C61)
C62 (C63) C66 (C67) (C68) (C69) (C70) (C71) Capacitor, multilayer
0603-104 Y5V-20+80%/50V 01.54.CS.2.E104Y50V
(C72) (C73) (C74) (C75) (C76) (C77) C78 ceramic, chip
(C79) (C80) C81 C83 C85 C89 C92 (C93)
(C95) C98 C102 C104 C109 (C110) C122
C123 C124 (C125) C126 (C128) C130 C131
C132 (C133) (C134) (C135) C148 (C149)
(C150) C151 (C152) (C153) (C154) (C155)
(C156) (C157) (C158) (C159) C163 (C164)
C165
C100 (C194) (C195) (C196) (C197) (C198) Capacitor, multilayer
0603-105 Y5V-20+80%/16V 01.54.CS.2.E105Y16V
(C199) C204 (C206) (C0) ceramic, chip
C166 C168 C169 (C170) (C171) (C172)
(C173) (C174) (C175) (C176) (C177) C178
C179 (C180) (C181) C182 C183 C184 C185
C186 (C187) C188 C189 (C202) C203 (C207)
(C208) (C209) (C210) (C211) (C212) (C213)
Capacitor, multilayer
(C214) C215 (C216) (C217) (C218) (C219) 0603-104 Y5V-20+80%/50V 01.54.CS.2.E104Y50V
ceramic, chip
(C220) C221 (C222) (C223) (C224) C225
C226 (C227) C228 C229 (C230) (C231)
(C232) (C233) (C234) (C235) (C236) (C237)
(C238) (C239) (C240) (C241) (C242) (C243)
(C244) (C245) (C246) (C247) (C248)
Capacitor, multilayer
C193 ECJMFF1A226Z 01.35.CC.E120622U10V
ceramic, chip
Capacitor,
CE4 CE46 CE47 CD288H-10UF/10V 5*11 01.34.CL.D.E10U10VC1
AL.electrolytic
Capacitor,
CE43 CE44 CE45 CD288H-22UF/16V 5*11 01.34.CL.D.E22U16VC1
AL.electrolytic
CE1 CE3 CE5 CE6 CE7 CE8 CE9 CE10
Capacitor,
CE11 CE16 CE17 CE18 CE19 CE22 CE23 KM470M010C110AP 01.34.CL.D.E47U10VC1
AL.electrolytic
CE50 CE52 CE54 CE201 CE202
CE2 CE12 CE13 CE14 CE15 CE20 CE21
Capacitor,
CE24 CE35 CE36 CE48 CE49 CE53 CE56 CD288H-100UF/10V 5*11 01.34.CL.D.EH100U10VC
AL.electrolytic
CE203 CE204
Capacitor,
CE34 CE55 CE205 CD288H-220UF/10V 6*11 01.34.CL.D.E288220U10VC
AL.electrolytic
Capacitor,
CE62 CE66 CD288H-470UF/10V 8*11.5 01.34.CL.D.E470U10VD1
AL.electrolytic
Capacitor,
CE63 CD288H-470UF/25V 10*12 01.34.CL.D.EH470U25VD
AL.electrolytic
Capacitor,
CE51 CE61 CE65 CD288H-1000UF/10V 10*12 01.34.CL.D.E1000U10VD
AL.electrolytic
FB16 FB18 FB20 FB22 FB23 FB24 FB25
FB26 FB27 FB28 FB29 FB30 FB31 FB32 Bead, chip, 0603-50Ω 01.13.L.Z.ESA50
FB33 FB47 (FB48) FB49 FB200

Page 21 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Main Board (5112C01)

Location.No. Description Specification P/N
FB1 FB5 FB7 FB9 FB11 (FB13) FB42 FB43
Bead, chip, 0805-50Ω 01.13.L.Z.ESB50
FB44 FB45 FB46
FB10 FB15 FB53 Bead, chip, QiLiXin PBY160808T-102Y-N 01.13.L.Z.E102YN
Inductor, multilayer
L3 L4 L5 L6 ACM2012-900-2P SMD 01.13.L.L.S.E242
ceramic, chip, TDK
Inductor, SMD,
L7 SPI1048QR-150(15uH/3A) 01.13.L.L.S.E320
DADON
D1 D2 Diode IN5393, DO-15 01.41.D.PD.E5393
D3 Diode B340LA, SMA 01.41.D.PS.EB340LA
D4 D5 D6 D7 D8 Diode LL4148, DO213AA 01.41.D.PS.ELL4148
Q1 Q6 Transistor 2SB1132, SOT89 01.42.Q.S.E1132
MQ1 Mosfet 2SK3018T106, UMT3 01.42.Q.S.E3018
Q2 Q3 Q10 Transistor KTC8550, SOT23 01.42.Q.S.EC8550
Q4 Transistor KTC8050, SOT23 01.42.Q.S.E8050
Y1 Crystal Oscillator, 27.00MHZ 01.00.JZ.E2700C
Y2 Quartyz Crystal Unit 6.000MHZ-49S-6.8P 01.00.JZ.E06000A
IC, ROHM, Dropout
U22 BA33BC0T,TO-220 01.44.IC.D.EBA33B
Voltage Regulator
U23 IC, AAC, LDO AZ1117H-1.8, SOT-223 01.44.IC.S.EA11171V8
U29 IC, AAC, LDO AZ1117H-3.3, SOT-223 01.44.IC.S.EA11173V3
U1 U204 IC, Rohm, LDO BA00HC5FP , T0252-5 01.44.IC.S.EC5FP
D708E001BRFP266, S-PQFP- 01.46.IC.ED708E001BRFP2
U201 IC, TI, DSP
G144 66
KH29LV160CBTC-70G (Can
U9 burn-in decoder firmware U202(burn-in replaced by
IC, KH , FLASH 01.44.IC.S.E29LV160CBTC
DSP code) S29AL016M90TFI02) ,
TSOP48
IS42S16400B-6TL(Can
U7 U8 IC, ISSI , SDRAM replaced by K4S641632K- 01.44.IC.S.E16400BL
UC60), TSOP54
U203 IC, ISSI , SDRAM IS42S16400B-7TL, TSOP54 01.46.IC.E16400B7TL
XC9572XL-10VQG44C,
U5 IC, Xilinx, CPLD 01.44.IC.S.E9572XL
VQFP44
U3 IC, Atmel, EEPROM AT24C64-2.7, SO8 01.44.IC.S.E24C64
IC, Amlogic, A/V
U4 AML3390DTS-G, PQFP256 01.44.IC.S.EAML3390DTS
Processor
IC, FairChild, Low
U10 U14 U28 Dropout Voltage KA78R05CTU, TO-220F-4L 01.44.IC.D.E78R05CTU
Regulator
IC, Amlogic, DVD/CD
U12 AML3501, TSSOP48 01.44.IC.S.E3501
RF Processor
IC, Rohm, Actuator
U11 BA5888FP, HSOP-28 01.44.IC.S.E5888
driver
U6 IC, Rohm,Motor Driver BA6287, SOP8 01.44.IC.S.E6287
IC, Silicon
U21 Image,HDMI SiI9030CTU , TQFP80 01.44.IC.S.E9030
PanelLink Transmitter
IC, ST, Dual
U13 LM358M, SO8 01.44.IC.S.ELM358M
Operational Amplifier
IC, Sharp,
U27 PC817, DIP4 01.44.IC.D.EPC817
Photoelectric Coupler
IC, TDI, USB
U17 TDOTG242LPF, LQFP-64 01.44.IC.S.E242L
Controller
U2 IC, TI, Schmitt Trigger 74HCT14D , SO14 01.46.IC.E7414
IC, NEC, MOS FIELD
U19 EFFECT UPA672T, SC-70 01.44.IC.S.E672T
TRANSISTOR
IC, FairChild,
U18 Multiplexer/Demultiple FSTU3257MTC, TSSOP16 01.44.IC.S.EFSTU3257MTC
xer Bus Switch
IC, Semtech, Low
U16 U24 U25 U26 Capalitance TVS RClamp0514M, MSOP-10L 01.44.IC.S.E0514
Diode Array
IC, MPS, Step-Down
U20 MP1411DH, MSOP-10 01.44.IC.S.EMP1411DH
Converter
IC, TI, 9-BIT BUS-
SN74LVC823APWR, 01.44.IC.S.ESN74LVC823A
U206 INTERFACE FLIP-
TSSOP24 PW
FLOP
JP3 HDMI Jack 1747981-1 SMD 01.40.CON.DCZ.E316
JP6 USB Jack USB-A-05 (ROHS, Mother Set) 01.40.CON.DCZ.E217
JP4 JP5 IR in/out jack CKX-3.5-22 01.40.CON.DCZ.E203

Page 22 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Main Board (5112C01)

Location.No. Description Specification P/N
CN11 CN10 Connector PH-6A 01.40.CON.DPH.E028
FPC-1.0-12P, horizontal type
CN2 FPC Connector, SMD 01.40.CON.S10.FPC1.E015
and up contact
1.0-22P, Horizontal type and
CN5 FPC Connector 01.40.CON.S10.FPC2.E006
dual contact
1.25-16P, Horizontal type and
CN6 FPC Connector 01.40.CON.S13.FPC2.E013
single contact
1.25-18P, Vertical Type and
CN7 FPC Connector 01.40.CON.S13.FPC2.E015
single conact
1.0-20P, Vertical Type and dual
CN8 CN9 FPC Connector 01.40.CON.S10.FPC2.E031
conact

HS650DL Component List for AV Board (5113C01)

Location.No. Description Specification P/N
R385 R393 Resistor, chip 0603-0Ω ±5% 01.57.R.2.E000J
R390 Resistor, chip 0603-10Ω±5% 01.57.R.2.E100J
R340 R378 Resistor, chip 0603-75Ω±5% 01.57.R.2.E750J
R391 R397 Resistor, chip 0603-100Ω±5% 01.57.R.2.E101J
R343 Resistor, chip 0603-110Ω±5% 01.57.R.2.E111J
R342 Resistor, chip 0603-150Ω±5% 01.57.R.2.E151J
R341 R394 R395 R396 R398 Resistor, chip 0603-220Ω±5% 01.57.R.2.E221J
R321 R328 Resistor, chip 0603-330Ω±5% 01.57.R.2.E331J
R379 3R003 Resistor, chip 0603-560Ω±5% 01.57.R.2.E561J
R320 R327 Resistor, chip 0603-680Ω±5% 01.57.R.2.E681J
R319 R329 Resistor, chip 0603-1.78KΩ±1% 01.57.R.2.E1781F
R304 R307 R318 R370 R372 R380 3R004 Resistor, chip 0603-2.2KΩ±5% 01.57.R.2.E222J
R311 R312 R392 R399 Resistor, chip 0603-3KΩ±5% 01.57.R.2.E302J
R364 Resistor, chip 0603-3.3KΩ±5% 01.57.R.2.E332J
R300 R348 R352 R353 R389 R386 R387 Resistor, chip 0603-4.7KΩ±5% 01.57.R.2.E472J
R323 R324 R336 R337 Resistor, chip 0603-4.75KΩ±1% 01.57.R.2.E4751F
R326 R332 Resistor, chip 0603-7.5KΩ±1% 01.57.R.2.E752F
R301 R302 R303 R322 R325 R330 R333
R334 R335 R339 R356 R363 R365 R366 Resistor, chip 0603-10KΩ±5% 01.57.R.2.E103J
R368 R374 R376
R351 Resistor, chip 0603-12KΩ±1% 01.57.R.2.E123F
R354 R355 Resistor, chip 0603-18KΩ±5% 01.57.R.2.E183J
R309 R331 R344 R345 R346 R347 R350
Resistor, chip 0603-47KΩ±5% 01.57.R.2.E473J
R357 R358 R359 R360 R381 R388 3R005
R305 R349 R371 R373 R375 R377 3R002
Resistor, chip 0603-100KΩ±5% 01.57.R.2.E104J
3R006 3R001
R338 Resistor, chip 0603-549KΩ±1% 01.57.R.2.E5493F
R382 Resistor, chip 0805-5.1Ω±5% 01.57.R.3.E5R1J
ESD306 ESD307 ESD308 ESD309 ESD310 Voltage Dependent
AVR-M1608C270MTABB SMD 01.57.R.Y.E270
ESD311 ESD312 Resistor, TDK
Capacitor, multilayer
C339 C340 0603-22P NPO±5%/50V 01.54.CS.2.E220N50V
ceramic, chip
Capacitor, multilayer
C330 C333 0603-33P NPO±5%/50V 01.54.CS.2.E330N50V
ceramic, chip
Capacitor, multilayer
C326 0603-47P NPO±5%/50V 01.54.CS.2.E470N50V
ceramic, chip
Capacitor, multilayer
C306 C314 0805-100P NPO±5%/50V 01.54.CS.3.E101N50V
ceramic, chip
Capacitor, multilayer
C317 C318 0603-100P NPO±5%/50V 01.54.CS.2.E101N50V
ceramic, chip
Capacitor, multilayer
C331 0603-270P NPO±5%/50V 01.54.CS.2.E271N50V
ceramic, chip
Capacitor, multilayer
C341 C342 0603-470P NPO±5%/50V 01.54.CS.2.E471N50V
ceramic, chip
Capacitor, multilayer
C332 0603-560P NPO±5%/50V 01.54.CS.2.E561N50V
ceramic, chip
Capacitor, multilayer
C307 C311 0805-680P NPO±5%/50V 01.54.CS.3.E681N50V
ceramic, chip
Capacitor, multilayer
C305 C310 0805-102 NPO±5%/50V 01.54.CS.3.E102N50V
ceramic, chip
Capacitor, multilayer
C319 C325 C356 C357 0603-103 Y5V-20+80%/50V 01.54.CS.2.E103Y50V
ceramic, chip
Capacitor, multilayer
C334 C335 0603-183 X7R±10%/50V 01.54.CS.2.E183X50V
ceramic, chip
Capacitor, multilayer
C359 0603-223 X7R±10%/50V 01.54.CS.2.E223X50V
ceramic, chip

Page 23 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for AV Board (5113C01)

Location.No. Description Specification P/N
C312 C313 C315 C316 C320 C321 C322
C323 C328 C329 C336 C337 C338 C343 Capacitor, multilayer
0603-104 Y5V-20+80%/50V 01.54.CS.2.E104Y50V
C344 C345 C346 C347 C348 C349 C350 ceramic, chip
C353 C354 C358 C324
Capacitor, multilayer
C327 0805-105 Y5V-20+80%/16V 01.54.CS.3.E105Y16V
ceramic, chip
Capacitor,
CE317 CE319 CE330 CD110-1UF/50V 5*11 01.34.CL.D.E1U50VC
AL.electrolytic
Capacitor,
CE315 CE324 CD110-2.2UF/25V 5*11 01.34.CL.D.E2U225VC
AL.electrolytic
Capacitor,
CE316 CE318 CE320 CE325 CE326 CD110-10UF/10V 5*11 01.34.CL.D.E10U10VC
AL.electrolytic
CE304 CE305 CE306 CE308 CE340 CE341 Capacitor,
CD110-10UF/16V 5*11 01.34.CL.D.E10U16VC
CE342 AL.electrolytic
Capacitor,
CE302 CE303 CE307 CE310 CD110-47UF/16V 5*11 01.34.CL.D.E47U16VC
AL.electrolytic
Capacitor,
CE313 CE314 CE331 CD110-47UF/25V 5*11 01.34.CL.D.E47U25VC1
AL.electrolytic
Capacitor,
CE329 CE322 CD110-100UF/10V 5*12 01.34.CL.D.E100U10VD
AL.electrolytic
Capacitor,
CE321 CE328 CD110-100UF/16V 5*11 01.34.CL.D.E100U16VC
AL.electrolytic
Capacitor,
CE327 CE333 CE338 CD110-100UF/25V 6.3*12 01.34.CL.D.E100U25VD
AL.electrolytic
Capacitor,
CE336 CD110-220UF/10V 5*12 01.34.CL.D.E220U10VD
AL.electrolytic
Capacitor,
CE309 CE311 CE345 CD110-220UF/16V 6.3*12 01.34.CL.D.E220U16VD
AL.electrolytic
Capacitor,
CE312 CE332 CE334 CE339 CD110-220UF/25V 8*12 01.34.CL.D.E220U25VD
AL.electrolytic
Capacitor,
CE343 CD110-470UF/10V 6.3*12 01.34.CL.D.E470U10VD
AL.electrolytic
Capacitor,
CE337 CD110-470UF/25V 8*14 01.34.CL.D.E470U25VE
AL.electrolytic
FB306 FB307 Bead, chip 0603-50Ω 01.13.L.Z.ESA50
FB311 FB312 Bead, chip 0805-50Ω 01.13.L.Z.ESB50
FB308 FB310 FB313 Bead, leaded fixed 50Ω 3.5*6.0*0.8 01.13.L.Z.ED50A
Pulse transformer,
ZZ300 ZZ301 EJ219 01.13.L.R.E068
TOKO
D300 D301 D302 D303 D304 D305 D306
Diode LL4148, DO213AA 01.41.D.PS.ELL4148
D307
Q303 Transistor KTC8050, SOT23 01.42.Q.S.E8050
Q304 Q305 Transistor KTC8550, SOT23 01.42.Q.S.EC8550
Q310 Transistor DTC114EUA, UMT3 01.42.Q.S.E114
Q306 Q307 Q308 Q309 Transistor DTC343TK, SMT3 01.42.Q.S.E343
IC, AKM, Stereo audio
U301 AK4683EQ, LQFP-64 01.46.IC.EAK4683EQ
CODEC
U302 U304 U313 IC, NJRC, Pre-amp NJM2068M, SO8 01.44.IC.S.E2068
IC, Onsemi, Hex
U303 74HCU04, TSSOP14 01.46.IC.E74H04
Inverter
IC, PRINCETON,
U305 PT2579-SN(L), SOP16 01.44.IC.S.EPT2579
RDS Demodulator IC
IC, FairChild, Low
U306 Dropout Voltage KA78R05CTU, TO-220F-4L 01.44.IC.D.E78R05CTU
Regulator
IC, ST, Negative 79L12 (Can replaced by
U307 01.44.IC.D.E79L12
voltage regulators KA79L12AZ,Fairchild ), TO-92
IC, Fairchild, Positive
U308 U310 KA7812, TO-220 01.44.IC.D.EKA7812
Voltage Regulator
IC, Fairchild, Positive
U311 KA7809, TO-220 01.44.IC.D.E7809
Voltage Regulator
IC, NS, Positive
U312 78L05, SOT-89 01.44.IC.S.EL78L05
Voltage Regulator
Y300 Quartyz Crystal Unit 4.332MHz-49S-33P 01.00.JZ.E4332A
Jack, Richcon, Fiber
JP304 JP305 Optic Receiving VSR5G 01.43.E010
Module
1.25-11P, Vertical Type and
CN304 FPC Connector 01.40.CON.S13.FPC2.E014
Single Contact
1.25-18P, Vertical Type and
CN303 FPC Connector 01.40.CON.S13.FPC2.E015
Single Contact
1.0-20P, Vertical Type and
CN301 CN302 FPC Connector 01.40.CON.S10.FPC2.E031
Dual Contact

Page 24 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for AV Board (5113C01)

Location.No. Description Specification P/N
Jack, YuanChang,
JP306 Audio Input/Output AV1-8.4-6G 01.40.CON.DCZ.E123
Jack
Jack, YuanChang,
JP303 Audio Input/Output AV8-8.4-13/PB-31-1 01.40.CON.DCZ.E650
Jack
Connector, JAE, iPod
JP302 DA1R018H91E SMD 01.40.CON.DCZ.E243
Connector

HS650DL Component List for SMPS Board (5117C01)

Location.No. Description Specification P/N
R739 R717 Resistor, chip 0805-2.2Ω±5% 01.57.R.3.E2R2J
R709 R755 Resistor, chip 0805-10Ω±5% 01.57.R.3.E100J
R838 Resistor, chip 0805-15Ω±5% 01.57.R.3.E150J
R720 R723 R738 R769 R776 Resistor, chip 0805-22Ω±5% 01.57.R.3.E220J
R811 R710 Resistor, chip 0805-47Ω±5% 01.57.R.3.E470J
R731 Resistor, chip 0805-100Ω±5% 01.57.R.3.E101J
R837 Resistor, chip 0805-270Ω±5% 01.57.R.3.E271J
R787 R781 Resistor, chip 0805-330Ω±5% 01.57.R.3.E331J
R826 Resistor, chip 0805-470Ω±5% 01.57.R.3.E471J
R724 R736 R742 R752 R763 R806 R808
Resistor, chip 0805-1KΩ±5% 01.57.R.3.E102J
R810 R823 R825 R827 R782 R820 R824
R754 Resistor, chip 0805-1.2KΩ±5% 01.57.R.3.E122J
R822 R747 R761 R783 Resistor, chip 0805-2KΩ±5% 01.57.R.3.E202J
R732 Resistor, chip 0805-2.2KΩ±5% 01.57.R.3.E222J
R771 R793 R829 Resistor, chip 0805-3KΩ±1% 01.57.R.3.E302F
R821 Resistor, chip 0805-3.6KΩ±1% 01.57.R.3.E362F
R784 R828 R830 R835 R836 Resistor, chip 0805-4.7KΩ±5% 01.57.R.3.E472J
R760 Resistor, chip 0805-4.99KΩ±1% 01.57.R.3.E4991F
R713 R819 R722 R748 R749 R751 R756
Resistor, chip 0805-10KΩ±5% 01.57.R.3.E103J
R788 R790 R814 R833 R750 R768
R746 Resistor, chip 0805-13KΩ±1% 01.57.R.3.E133F
R757 R780 Resistor, chip 0805-15KΩ±1% 01.57.R.3.E153F
R791 Resistor, chip 0805-20KΩ±5% 01.57.R.3.E203J
R818 Resistor, chip 0805-27KΩ±5% 01.57.R.3.E273J
R764 Resistor, chip 0805-30KΩ±1% 01.57.R.3.E303F
R719 R743 Resistor, chip 0805-36KΩ±5% 01.57.R.3.E363J
R762 R789 Resistor, chip 0805-47KΩ±5% 01.57.R.3.E473J
R718 Resistor, chip 0805-60.4KΩ±1% 01.57.R.3.E6042F
R729 R770 R774 Resistor, chip 0805-68KΩ±5% 01.57.R.3.E683J
R733 Resistor, chip 0805-100KΩ±5% 01.57.R.3.E104J
R779 Resistor, chip 0805-150KΩ±5% 01.57.R.3.E154J
R817 Resistor, chip 0805-180KΩ±5% 01.57.R.3.E184J
R735 Resistor, chip 0805-412KΩ±1% 01.57.R.3.E4123F
R816 R815 Resistor, chip 1206-0.47Ω±5% 01.57.R.4.ER47J
R792 Resistor, chip 1206-10Ω±5% 01.57.R.4.E100J
R807 Resistor, chip 1206-15Ω±5% 01.57.R.4.E150J
R812 R813 Resistor, chip 1206-39Ω±5% 01.57.R.4.E390J
R707 R708 R714 R715 R727 R728 R734
Resistor, chip 1206-100Ω±5% 01.57.R.4.E101J
R740 R741
R786 Resistor, chip 1206-200Ω±5% 01.57.R.4.E201J
R803 R804 R805 R831 R832 R834 Resistor, chip 1206-330Ω±1% 01.57.R.4.E331F
R711 Resistor, chip 1206-470Ω±5% 01.57.R.4.E471J
R785 Resistor, chip 1206-3KΩ±1% 01.57.R.4.E302F
R745 Resistor, chip 1206-100KΩ±5% 01.57.R.4.E104J
R706 R744 R758 R766 R772 Resistor, chip 1206-150KΩ±1% 01.57.R.4.E154F
R703 R704 R705 R759 R767 R773 Resistor, chip 1206-200KΩ±1% 01.57.R.4.E204F
R801 Resistor, chip 1206-1MΩ±5% 01.57.R.4.E105J
R794 R795 R797 R798 R799 R800 Resistor, chip 1206-2MΩ±5% 01.57.R.4.E205J
R802 Resistor, chip 1206-3MΩ±5% 01.57.R.4.E305J
R796 FIXED CARBON FILM RT1W-68KΩ±5% 01.57.R.C.EF683
R716 R721 R725 R730 FIXED CARBON FILM RT2W-0.1Ω 01.57.R.C.EGR1
R777 R778 R737 FIXED CARBON FILM RT3W-0.22Ω±5% 01.57.R.C.EHR22
R726 R712 shunt resistor 5W-1.6KΩ ±5% DIP 01.57.R.S.EE162
Voltage Dependent
RZ704 10K.471 01.57.R.Y.E10K
Resistor
Thermmal Dependent
RZ702 RZ701 8R210 DIP 01.57.R.R.E8R210
Resistor
Resettable Fuse,
RZ703 JK16 300 01.57.R.R.EJK16300
JinKe
High-Resistance
R809 RI82-0.5W-1MΩ 01.57.R.C.40E105
Cermet Resistor, KOA
High-Resistance
R701 R702 RCR60-1W-11MΩ 01.57.R.C.E60F116
Cermet Resistor, KOA

Page 25 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for SMPS Board (5117C01)

Location.No. Description Specification P/N
Capacitor, multilayer
C708 0805-150P NPO±5%/50V 01.54.CS.3.E151N50V
ceramic, chip
Capacitor, multilayer
C724 C745 0805-330P NPO±5%/50V 01.54.CS.3.E331N50V
ceramic, chip
Capacitor, multilayer
C718 0805-470P NPO±5%/50V 01.54.CS.3.E471N50V
ceramic, chip
Capacitor, multilayer
C721 C720 0805-102 X7R ±10%/50V 01.54.CS.3.E102X50V
ceramic, chip
Capacitor, multilayer
C709 0805-152 X7R±10%/50V 01.54.CS.3.E152X50V
ceramic, chip
Capacitor, multilayer
C732 0805-332 X7R±10%/50V 01.54.CS.3.E332X50V
ceramic, chip
Capacitor, multilayer
C727 C719 0805-103 X7R±10%/50V 01.54.CS.3.E103X50V
ceramic, chip
Capacitor, multilayer
C726 0805-153 X7R±10%/50V 01.54.CS.3.E153X50V
ceramic, chip
Capacitor, multilayer
C744 0805-473 X7R±10%/50V 01.54.CS.3.E473X50V
ceramic, chip
C706 C728 C729 C730 C731 C735 C736
C737 C740 C746 C751 C752 C753 C754 Capacitor, multilayer
0805-104 X7R±10%/50V 01.54.CS.3.E104X50V
C755 C757 C758 C759 C760 C761 C762 ceramic, chip
C764 C765 C766
Capacitor, multilayer
C714 C715 C716 C733 C725 C707 0805-474 Y5V+80-20%/50V 01.54.CS.3.E474Y50V
ceramic, chip
Capacitor, multilayer
C717 C722 C723 C770 0805-105 X7R±10%/25V 01.54.CS.3.E105X25V
ceramic, chip
Capacitor, multilayer
C769 C775 0805-475 X7R±20%/25V 01.54.CS.3.E475X25V
ceramic, chip
Capacitor, multilayer
C773 1808-100P NPO±5%/3KV 01.54.CS.6.E101N3KV
ceramic, chip
High-voltage
C702 C703 C712 C713 metallized polyester 471/1KV 01.00.CD.GY.E4711KV
film
Capacitor, multilayer
C742 1206-102 X7R±10%/200V 01.54.CS.4.E102X200V
ceramic, chip
Capacitor, multilayer
C774 1206-106 X7R±10%/16V 01.54.CS.4.E106X16V
ceramic, chip
Radial Monolithic 104/50V X7R±10% (lead pitch:
C704 C705 01.00.CD.DS.E10450V
Capacitor 5.08mm)
C711 Metallized capacitor 474/630V (lead pitch: 15mm) 01.00.CD.JZ.E474630VA
C701 Metallized capacitor 104/630V 01.00.CD.JZ.E104630V
C767 Metallized capacitor 103/630V (lead pitch: 10mm) 01.00.CD.JZ.E103630VA
C738 Metallized capacitor 472/630V (lead pitch: 10mm) 01.00.CD.JZ.E472630VA
C734 Metallized capacitor 105/450V (lead pitch: 15mm) 01.00.CD.JZ.E105450V
Capacitor, multilayer
C710 103/1KV (lead pitch: 7.5mm) 01.00.CD.CP.E1031KV
ceramic
High-voltage
224/275V X2 (lead pitch:
CX703 CX701 metallized polyester 01.00.CD.GY.E224275V
15mm)
film
High-voltage
334/275V X2 (lead pitch:
CX702 metallized polyester 01.00.CD.GY.E334275V
15mm)
film
High-voltage
102/400V(X1) 250V(Y1) (lead 01.00.CD.GY.E102400V250
CY701 CY705 metallized polyester
pitch: 10mm) V
film
High-voltage
471/400V (X1) 250V (Y1) (lead 01.00.CD.GY.E471400V250
CY702 CY703 metallized polyester
pitch: 10mm) V
film
Capacitor,
CE712 GF4R7M050C110A 01.34.CL.D.E4U750VC1
AL.electrolytic
Capacitor,
CE707 CE711 CE722 CE703 GF470M050E110A 01.34.CL.D.EH47U50VD
AL.electrolytic
Capacitor, 01.34.CL.D.EGF221M025F
CE713 GF221M025F115A
AL.electrolytic 115A
Capacitor,
CE717 CE718 CE725 CE726 CE714 CE715 GF471M025F200A 01.34.CL.D.E288470U25VE
AL.electrolytic
Capacitor, 1000UF/16V 10*20 ±20%
CE719 CE723 CE727 01.34.CL.D.E1000U16V
AL.electrolytic 105
CE704 CE705 CE706 CE708 CE709 CE710 Capacitor,
GF102M063I350A 01.34.CL.D.E1000U63VJ
CE728 CE729 AL.electrolytic
Capacitor,
CE701 HP680V450M360A 01.34.CL.D.E68U450VH
AL.electrolytic
Capacitor,
CE720 CE721 GF222M016I250A 01.34.CL.D.E288220U16VH
AL.electrolytic

Page 26 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for SMPS Board (5117C01)

Location.No. Description Specification P/N
Capacitor,
CE702 HS331V450P420A 01.34.CL.D.E330U450VK1
AL.electrolytic
D703 D706 D710 D712 D705 D709 Bead, hollow HF57 BB3.5*3*1.3 01.13.L.Z.EHF57
FB701 FB703 FB704 FB705 Bead, leaded fixed 100Ω(3.5*6.0*0.8) 01.13.L.Z.ED100A
LF704 LF705 Common Mode Choke LCL-ET2812-01 DIP 01.13.L.L.D.E209

LF703 Common Mode Choke L-200B DIP 01.13.L.L.D.E210

L702 Inductor , leaded fixed L-EE1901(45UH)±10% DIP 01.13.L.L.D.E211
L703 Inductor , leaded fixed L-ER4203(750UH)±10% DIP 01.13.L.L.D.E212
L705 L706 L708 Inductor , leaded fixed LH0608-22UH 01.13.L.L.D.E051
L701 L704 L707 Pulse transformer L0620-050 DIP 01.13.L.L.D.E077
T702 Transformer BCK-PQ3230-04 DIP 01.13.L.R.E142
T701 Transformer BCK-ER4401 DIP 01.13.L.R.E143
D714 D715 Diode 1N4001, DO-41 01.41.D.PD.EIN4001
D719 D720 D722 D735 Diode UF1004, DO-41 01.41.D.PD.EUF1004
D724 Diode FR104, DO-41 01.41.D.PD.EFR104
D713 D716 D717 D718 Diode LL4148 SMD 01.41.D.PS.ELL4148
D704 D707 D711 Diode BAS16, SOT23 01.41.D.PS.EBAS16
D723 D732 Diode B540C, SMC 01.41.D.PS.EB540C
D733 Diode IN4007, DO-41 01.41.D.PD.EIN4007
D708 D734 Diode 1U08, DO-41 01.41.D.PD.E1U08
D721 Diode FR107, DO-41 01.41.D.PD.EFR107
D705 D709 Diode HER208G, DO-15 01.41.D.PD.EHER208G
D725 Diode SBR20100CTF, TO-220 01.41.D.PD.ESBR20100
01.41.D.PD.ESBR20A300C
D703 D706 D710 D712 Diode SBR20A300CTFP, TO-220
TFP
Z706 Zener diode 15V 0.5W 01.41.D.WS.E15V
Z701 Z702 Z703 Z704 Z705 Z707 Z710 Zener diode 18V 0.5W 01.41.D.WS.E18V
Z708 Zener diode 20V 0.5W 01.41.D.WS.E20V
Z709 Zener diode 27V 0.5W 01.41.D.WS.E27V
BD701 Diode D10XB60, 3S 01.41.D.PD.ED10XB60
D702 Diode ISL9R1560PF2, TO-220 01.41.D.PD.E1560
Q701 Transistor KTC8050, SOT23 01.42.Q.S.E8050
Q704 Q705 Q707 Transistor KTC8550, SOT23 01.42.Q.S.EC8550
Q708 Q715 Q716 Q717 Q723 Q724 Transistor 2N3904, SOT23 01.42.Q.S.E2N3904
Q711 Q713 Q714 Q719 Transistor 2N3906, SOT23 01.42.Q.S.E2N3906
Q712 Q721 Q725 Mosfet AF4835, SOP-8 01.44.IC.S.E4835
01.44.MOS.S.EDMN3033LS
Q718 Mosfet DMN3033LSN, SOT23
N
Q706 Q702 Mosfet FDPF18N50, TO-220 01.44.MOS.D.EFDPF18N50

Q703 Mosfet FDPF20N50, TO-220 01.44.MOS.D.EFDPF20N50

Q720 Mosfet FQPF7N80C, TO-220 01.44.MOS.D.E7N80C
IC, Fairchild,Dual
U705 LM358M, SOP-8 01.44.IC.S.ELM358M
Operational Amplifier
IC, Fairchild, Half-
U702 FAN73832, SOP-8 01.44.IC.S.EFAN73832
Bridge Gate-Drive IC
IC, Fairchild, Power
U701 Factor Correction and ML4800CS, SOIC16 01.44.IC.S.E4800
PWM Controller
IC, Fairchild,
U709 FAN7602MX, SOP-8 01.44.IC.S.EFAN7602MX
FAN7602MX
IC, EVERLIGHT,
U704 U707 U711 EL817 DIP 01.44.IC.D.EL817
Photocouple
IC, AAC, Shunt
U703 U706 U712 AZ431AZ-A, TO-92 01.44.IC.D.EAZ431
Regulator
Vertical VH Connector with
CN701 Connector 01.40.CON.DCZ.E129
three holes and two pins
Vertical VH Connector with four
CN706 Connector 01.40.CON.DCZ.E244
holes and four pins
1.25-14P, Vertical Type and
CN702 FPC Connector 01.40.CON.S13.FPC2.E016
Single Contact
1.25-16P, Vertical Type and
CN704 FPC Connector 01.40.CON.S13.FPC2.E018
Single Contact
1.25-6P, Vertical Type and
CN703 FPC Connector 01.40.CON.S13.FPC2.E017
Single Contact
F3.15A/250V(φ3.6*10, In Line
F701 Fuse 01.38.FUSE.D.E3F15A250V
Package)
T6.3AL/250V(φ3.6*10, In Line
F702 Fuse 01.38.FUSE.D.E6A3250V
Package)
G701 G702 G703 G704 3pins grounding piece M4 01.00.WJ.QT.E041

Page 27 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Front panel board (5115C01)

Location.No. Description Specification P/N
(R619) Resistor, chip 0805-10Ω±5% 01.57.R.3.E100J
(R606) (R607) (R630) (R635) (R638) (R641)
Resistor, chip 0805-100Ω±5% 01.57.R.3.E101J
(R656) (R657) (R659)
(R614) (R647) Resistor, chip 0805-200Ω±5% 01.57.R.3.E201J
(R605) Resistor, chip 0805-470Ω±5% 01.57.R.3.E471J
(R615) (R648) Resistor, chip 0805-510Ω±5% 01.57.R.3.E511J
(R631) (R632) (R633) (R626) Resistor, chip 0805-1KΩ±5% 01.57.R.3.E102J
(R608) (R652) Resistor, chip 0805-2KΩ±1% 01.57.R.3.E202F
(R620) (R644) Resistor, chip 0805-2.2KΩ±5% 01.57.R.3.E222J
(R627) Resistor, chip 0805-3.3KΩ±5% 01.57.R.3.E332J
(R601) (R603) (R604) (R609) (R610) (R611)
Resistor, chip 0805-4.7KΩ±5% 01.57.R.3.E472J
(R612) (R613) (R655) (R658)
(R637) Resistor, chip 0805-6.2KΩ±1% 01.57.R.3.E622F
(R628) (R629) (R640) (R642) (R643) (R662)
Resistor, chip 0805-10KΩ±5% 01.57.R.3.E103J
R645
(R602) Resistor, chip 0805-15KΩ±5% 01.57.R.3.E153J
(R636) Resistor, chip 0805-20KΩ±5% 01.57.R.3.E203J
(R661) Resistor, chip 0805-62KΩ±1% 01.57.R.3.E623F
(R634) Resistor, chip 0805-100KΩ±1% 01.57.R.3.E104F
(R654) (R663) Resistor, chip 1206-3.3Ω±5% 01.57.R.4.E3R3J
(R653) Resistor, chip 1206-200Ω±5% 01.57.R.4.E201J
(R649) (R650) (R651) Resistor, chip 1206-300Ω±5% 01.57.R.4.E301J
(R639) (R660) Resistor, chip 1206-10KΩ±5% 01.57.R.4.E103J
R646 Resistor, chip 1210-0Ω±5% 01.57.R.5.E000J
Voltage Dependent
(ESD601) (ESD602) (ESD603) AVR-M1608C270MTABB SMD 01.57.R.Y.E270
Resistor, TDK
Capacitor, multilayer
(C604) (C605) 0805-22P NPO±5%/50V 01.54.CS.3.E220N50V
ceramic, chip
Capacitor, multilayer
(C620) 0805-39P NPO±5%/50V 01.54.CS.3.E390N50V
ceramic, chip
Capacitor, multilayer
(C610) (C616) 0805-47P NPO±5%/50V 01.54.CS.3.E470N50V
ceramic, chip
Capacitor, multilayer
(C611) (C612) 0805-56P NPO±5%/50V 01.54.CS.3.E560N50V
ceramic, chip
Capacitor, multilayer
(C615) 0805-150P NPO±5%/50V 01.54.CS.3.E151N50V
ceramic, chip
Capacitor, multilayer
(C617) 0805-470P NPO±5%/50V 01.54.CS.3.E471N50V
ceramic, chip
Capacitor, multilayer
(C625) 0805-123 X7R±10%/50V 01.54.CS.3.E123X50V
ceramic, chip
Capacitor, multilayer
(C618) (C626) 0805-473 X7R±10%/50V 01.54.CS.3.E473X50V
ceramic, chip
(C606) (C607) (C608) (C609) (C613) (C627)
(C628) (C629) (C630) (C631) (C632) (C633) Capacitor, multilayer
0805-104 Y5V+80-20%/50V 01.54.CS.3.E104Y50V
(C634) (C635) (C638) (C639) (C640) (C641) ceramic, chip
(C642) (C643)
Capacitor, multilayer
(C636) 0805-104 X7R±10%/100V 01.54.CS.3.E104X100V
ceramic, chip
Capacitor, multilayer
(C624) 0805-105 Y5V-20+80%/16V 01.54.CS.3.E105Y16V
ceramic, chip
Capacitor, multilayer
(C603) (C619) 0805-225 Y5V-20+80%/16V 01.54.CS.3.E225Y16V
ceramic, chip
Capacitor, multilayer
C637 C644 1206-105 X7R±10%/50V 01.54.CS.4.E105X50V
ceramic, chip
Capacitor, Tantalum,
(CA601) C-22UF-10V 01.33.CT.EC22U10V
Chip
Capacitor,
CE622 CDV-10UF/6.3V 4*5 01.34.CL.D.E10U6V3A
AL.electrolytic
Capacitor,
CE604 CE616 CD11X-10UF/16V 4*7 01.34.CL.D.E10U16VB
AL.electrolytic
Capacitor,
CE603 CD110-33UF/10V 5*11 01.34.CL.D.E33U10VC
AL.electrolytic
Capacitor,
CE611 CD110-47UF/10V 5*11 01.34.CL.D.E47U10VC
AL.electrolytic
Capacitor,
CE620 CE601 CD11X-47UF/16V 5*7 01.34.CL.D.E47U16VB
AL.electrolytic
Capacitor,
CE612 CE613 CE618 CE619 CD110-47UF/25V 5*11 01.34.CL.D.E47U25VC1
AL.electrolytic
Capacitor,
CE608 CE607 CD110-47UF/50V 6.3*12 01.34.CL.D.E47U50VCD
AL.electrolytic
Capacitor,
CE610 CE617 CE614 CD110-100UF/10V 5*12 01.34.CL.D.E100U10VD
AL.electrolytic

Page 28 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Front panel board (5115C01)

Location.No. Description Specification P/N
Capacitor,
CE602 CD11X-100UF/16V 6.3*7 01.34.CL.D.EX100U16VB
AL.electrolytic
Capacitor,
CE605 CD110-100UF/25V 6.3*12 01.34.CL.D.E100U25VD
AL.electrolytic

Capacitor,
CE606 GF101M063G125A 01.34.CL.D.E100U63VD
AL.electrolytic
Capacitor,
CE621 CD110-220UF/10V 5*12 01.34.CL.D.E220U10VD
AL.electrolytic
Capacitor,
CE609 CD11X-220UF/10V 6.3*7 01.34.CL.D.E220U10VB
AL.electrolytic
Magnetic shielding
L601 THI1009-331(330UH) DIP 01.13.L.L.D.E208
Inductor
Inductor, multilayer
(FB601) 0805-10UH SMD 01.13.L.L.S.E007
ceramic, chip
(FB602) (FB603) Bead, chip 0805-50Ω 01.13.L.Z.ESB50
Y601 Quartyz Crystal Unit 4.000MHZ-49S-22P 01.00.JZ.E04000
(D601) (D602) (D603) (D605) D604 Diode LL4148, DO213AA 01.41.D.PS.ELL4148
(D606) Schottky Rectifier 5819 1A, SS14 01.41.D.PS.E5819
LED, color is orange &
LED601 LED602 HFT503CPB0 01.41.D.FD.E503
blue
(Q603) Transistor KTC8550, SOT23 01.42.Q.S.EC8550
(Q602) Transistor KTC8050, SOT23 01.42.Q.S.E8050
MQ601 Transistor BSS123 SMD 01.42.Q.S.E123
(DZ601) Zener diode 6.2V, 0.4W 01.41.D.WS.E6V2
IC, FairChild, Low
U604 Dropout Voltage KA78R05CTU, TO-220F-4L 01.44.IC.D.E78R05CTU
Regulator
IC, ST, Negative 79L12 (Can replaced by
(U611) 01.44.IC.D.E79L12
voltage regulators KA79L12AZ,Fairchild ), TO-92
IC, Fairchild, Positive
(U610) KA78L12AMTF, SOT-89 01.44.IC.S.EKA78L12AMTF
Voltage Regulator
(U608) IC, AAC, LDO AZ1117H-3.3, SOT-223 01.44.IC.S.EA11173V3
IC, NS, Vacuum
(U607) Fluorescent Display LM9022M, SO8 01.44.IC.S.E9022
Filament Driver
IC, ONSEMI,
MC34063ADG (Can be
Step−Up/Down/
(U609) repalced by MC34063EBD, 01.44.IC.S.EMC34063ADG
Inverting Switching
ST),SO8
Regulators
(U601) IC, ELAN, MCU EM78P156ELM-G, SOIC18 01.46.IC.E78P156G
(U603) IC, NJRC, Pre-amp NJM2068M, SO8 01.44.IC.S.E2068
IR601 IC, IR receiver HL38B17, In Line Package 01.44.IC.D.E38B17
IC, Semtech, Low
(U602) Capalitance TVS RClamp0514M, MSOP-10L 01.44.IC.S.E0514
Diode Array
K603 Relay, HONGFA HFD3/5 DIP 01.00.ZJ.BHQ.E007
1.0-22P, Vertical Type and
CN601 FPC Connector 01.40.CON.S10.FPC2.E026
Dual Contact
1.25-14P, Vertical Type and
CN602 FPC Connector 01.40.CON.S13.FPC2.E016
Single Contact
1.0-6P, Vertical Type and Dual
CN604 FPC Connector 01.40.CON.S10.FPC2.E004
Contact
K602 K601 Touch switch KFC-A06-05, Vertical Type 01.39.SW.QC.EDKFC
JP602 Earphone Jack CKX-3.5-12 01.40.CON.DCZ.E219
JP601 USB Jack USB-A-05 (ROHS, Mother Set) 01.40.CON.DCZ.E217
VFD601 VFD VFD33-1701I 01.16.E1701I
5115C Front panel board 01.37.PCB.2.E5115C

(R617) (R618) (R616) Resistor, chip 0805-4.7KΩ±5% 01.57.R.3.E472J

(R622) (R623) (R624) (R625) Resistor, chip 0805-180Ω±5% 01.57.R.3.E181J
Capacitor, multilayer
(C601) (C602) 0805-820P NPO±5%/50V 01.54.CS.3.E821N50V
ceramic, chip
Capacitor, multilayer
(C614) 0805-104 Y5V+80-20%/50V 01.54.CS.3.E104Y50V
ceramic, chip
(Q601) Transistor KTC8050, SOT23 01.42.Q.S.E8050
(Q604) (Q605) Transistor KTC8550, SOT23 01.42.Q.S.EC8550
LED603 LED604 LED605 LED606 LED HZFBA65018CP Ф5, DIP 01.41.D.FD.EHZFBA65018
1.0-6P Horizontal Type and
CN605 FPC Connector 01.40.CON.S10.FPC2.E036
Dual Contact
Volume encoder,
W601 ED1612-24-24-HC-F20(2) 01.36.VR.E20K
pulse

Page 29 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Amplifier board (5329C01)

Location.No. Description Specification P/N
R584 R1009 R1010 R1011 Resistor, chip 0603-10Ω±5% 01.57.R.2.E100J
R597 Resistor, chip 0603-100Ω±5% 01.57.R.2.E101J
R420 R451 R487 R519 R553 Resistor, chip 0603-300Ω±5% 01.57.R.2.E301J
R585 R404 Resistor, chip 0603-1KΩ±5% 01.57.R.2.E102J
R573 R599 Resistor, chip 0603-1.2KΩ±5% 01.57.R.2.E122J
R591 R595 Resistor, chip 0603-9.1KΩ ±1% 01.57.R.2.E912F
R426 R434 R439 R459 R466 R473 R493
R501 R507 R526 R532 R540 R558 R566 Resistor, chip 0603-4.7KΩ±1% 01.57.R.2.E472F
R571 R590 R594
R427 R435 R460 R467 R494 R502 R527
Resistor, chip 0603-6.2KΩ±1% 01.57.R.2.E622F
R533 R559 R567
R401 R583 R586 R589 R412 R416 Resistor, chip 0603-10KΩ±5% 01.57.R.2.E103J
R402 R405 R407 R409 R410 R413 R414
Resistor, chip 0603-20KΩ±5% 01.57.R.2.E203J
R1003
R436 R468 R503 R534 R568 Resistor, chip 0603-22KΩ±5% 01.57.R.2.E223J
R403 R406 R408 R411 R415 R592 R598 Resistor, chip 0603-47KΩ±5% 01.57.R.2.E473J
R419 R424 R454 R458 R486 R491 R522
Resistor, chip 0805-1Ω±5% 01.57.R.3.E1R0J
R525 R552 R557
R465 R506 R538 Resistor, chip 0805-10Ω±5% 01.57.R.3.E100J
R418 R442 R448 R472 R485 R509 R516
Resistor, chip 0805-30Ω±5% 01.57.R.3.E300J
R539 R551 R574 R588 R596
R445 R479 R513 R546 R577 Resistor, chip 0805-47Ω±5% 01.57.R.3.E470J
R1018 R1022 R1026 Resistor, chip 0805-604Ω±1% 01.57.R.3.E6040F
R444 R478 R512 R545 R576 R1030 Resistor, chip 0805-1KΩ±1% 01.57.R.3.E102F
R446 R480 R514 R547 R578 R1004 R1007 Resistor, chip 0805-1KΩ±5% 01.57.R.3.E102J
R449 R482 R517 R549 R582 Resistor, chip 0805-3.3KΩ±1% 01.57.R.3.E332F
R1019 R1023 Resistor, chip 0805-3.32KΩ±1% 01.57.R.3.E3321F
R443 R476 R510 R543 R580 Resistor, chip 0805-4.7KΩ±1% 01.57.R.3.E472F
R422 R428 R453 R456 R489 R495 R521
Resistor, chip 0805-5.1KΩ±1% 01.57.R.3.E512F
R523 R555 R560
R1027 Resistor, chip 0805-5.11KΩ±1% 01.57.R.3.E5111F
R440 R474 R508 R541 R572 Resistor, chip 0805-5.6KΩ±1% 01.57.R.3.E562F
R447 R481 R515 R548 R579 Resistor, chip 0805-7.87KΩ±1% 01.57.R.3.E7871F
R432 R464 R499 R531 R564 Resistor, chip 0805-10KΩ±1% 01.57.R.3.E103F
R431 R463 R498 R530 R563 Resistor, chip 0805-10KΩ±5% 01.57.R.3.E103J
R1006 Resistor, chip 0805-20KΩ±5% 01.57.R.3.E203J
R421 R452 R488 R520 R554 Resistor, chip 0805-30KΩ±5% 01.57.R.3.E303J
R1028 Resistor, chip 0805-38.3KΩ±1% 01.57.R.3.E3832F
R429 R461 R496 R528 R561 Resistor, chip 0805-46.4KΩ±1% 01.57.R.3.E4642F
R1024 R1020 Resistor, chip 0805-47KΩ±1% 01.57.R.3.E473F
R1012 R1013 R1014 R1015 R1016 Resistor, chip 0805-75KΩ±1% 01.57.R.3.E753F
R433 R438 R470 R471 R500 R505 R536
Resistor, chip 0805-100KΩ±5% 01.57.R.3.E104J
R537 R565 R570 R1005 R1008
R1017 R1021 R1025 Resistor, chip 1206-0.15Ω±1% 01.57.R.4.ER15F
R441 R475 R511 R542 R575 Resistor, chip 1206-1Ω±5% 01.57.R.4.E010J
R417 R450 R483 R518 R550 Resistor, chip 1206-100KΩ±5% 01.57.R.4.E104J
R430 R462 R497 R529 R562 Resistor, chip 1210-1KΩ±1% 01.57.R.5.E102F
R437 R469 R504 R535 R569 Resistor, chip 1210-5.49KΩ±1% 01.57.R.5.E5491F
R425 R455 R492 R544 R581 FIXED CARBON FILM RT2W-10Ω±5% DIP 01.57.R.C.EG100
R600 R601 R602 R603 R604 Resettable Fuse JK60-050 DIP 01.57.R.R.E050A
Thermmal Dependent
R593 JK-MSMD010 SMD 01.57.R.R.E010
Resistor, JinKe
Resistor, thick film
RN401 RN402 0603-10KΩ*4 ±5% 01.57.R.8.EP1034
chip network
Capacitor, multilayer
C421 C443 C467 C493 C517 0603-47P NPO±5%/50V 01.54.CS.2.E470N50V
ceramic, chip
C416 C420 C436 C442 C459 C466 C483 Capacitor, multilayer
0603-470P NPO±5%/50V 01.54.CS.2.E471N50V
C492 C507 C516 C529 C533 ceramic, chip
C410 C411 C432 C433 C456 C460 C481 Capacitor, multilayer
0603-102 X7R±10%/50V 01.54.CS.2.E102X50V
C484 C505 C508 ceramic, chip
C401 C404 C408 C430 C445 C453 C454
Capacitor, multilayer
C458 C474 C478 C479 C491 C501 C503 0603-104 Y5V-20+80%/50V 01.54.CS.2.E104Y50V
ceramic, chip
C506 C519 C527 C532 C537 C540
Capacitor, multilayer
C429 C451 C476 C502 C526 0805-47P NPO±5%/50V 01.54.CS.3.E470N50V
ceramic, chip
Capacitor, multilayer
C412 C434 C461 C485 C509 0805-150P NPO±5%/200V 01.54.CS.3.E151N200V
ceramic, chip
Capacitor, multilayer
C541 0805-102 NPO±5%/50V 01.54.CS.3.E102N50V
ceramic, chip
Capacitor, multilayer
C547 C551 C554 0805-392 X7R±10%/50V 01.54.CS.3.E392X50V
ceramic, chip
C409 C423 C431 C446 C455 C470 C480 Capacitor, multilayer
0805-224 Y5V-20+80%/50V 01.54.CS.3.E224Y50V
C496 C504 C520 C528 C534 ceramic, chip

Page 30 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Amplifier board (5329C01)

Location.No. Description Specification P/N
Capacitor, multilayer
C546 C550 0805-225 Y5V-20+80%/25V 01.54.CS.3.E225YA25V
ceramic, chip
C415 C427 C440 C449 C465 C473 C490 Capacitor, multilayer
1206-104 X7R±10%/100V 01.54.CS.4.E104X100V
C500 C514 C525 ceramic, chip
C414 C422 C439 C444 C468 C489 C494 Capacitor, multilayer
1206-104 X7R±10%/250V 01.54.CS.4.E104X250V
C513 C518 C464 ceramic, chip
Capacitor, multilayer
C403 1206-225 Y5V+80-20%/50V 01.54.CS.4.E225Y50V
ceramic, chip
C413 C424 C435 C447 C457 C471 C488 Capacitor, multilayer
1206-225 X7R±10%/25V 01.54.CS.4.E225X25V
C497 C512 C521 ceramic, chip
Capacitor, multilayer
C402 C407 C548 C549 C552 C553 1206-106 Y5V+80-20%/25V 01.54.CS.4.E106Y25V
ceramic, chip
Capacitor, multilayer
C544 C545 1206-106 Y5V+80-20%/50V 01.54.CS.4.E106Y50V
ceramic, chip
C425 C448 C472 C498 C522 C426 C450
Capacitor, multilayer
C475 C499 C524 C417 C418 C437 C438 1206-106 X7R±10%/16V 01.54.CS.4.E106X16V
ceramic, chip
C462 C463 C486 C487 C510 C511
Capacitor, polyester
C428 C452 C477 CC482 C515 334J/100V DIP 01.00.CD.DL.E334100V
film
Capacitor, polyester
C419 C441 C469 C495 C523 474J/100V DIP 01.00.CD.DL.E474100V
film
High-voltage
C560 C561 C562 C563 C564 metallized polyester 471/1KV 01.00.CD.GY.E4711KV
film
Capacitor,
CE401 CE406 CE414 CE421 CE426 CE427 47UF/35V(Bipolar) 01.34.CL.D.E47U35VW
AL.electrolytic
Capacitor, 220UF/25V 8*12 ±20% 105
CE450 CE451 CE452 01.34.CL.D.E220U25VD1
AL.electrolytic LOW ESR
Capacitor,
CE453 1000UF/10V 8*16 ±20% 105 01.34.CL.D.E1000U10V
AL.electrolytic
CE402 CE403 CE404 CE405 CE407 CE408
CE409 CE410 CE411 CE412 CE413 CE415 Capacitor,
KM470M016C110AP 01.34.CL.D.E47U16V
CE416 CE417 CE418 CE419 CE420 CE422 AL.electrolytic
CE423 CE424 CE425 CE428 CE431 CE432
Capacitor,
CE433 CE434 KM470M025C110AP 01.34.CL.D.EH47U25VD
AL.electrolytic
Capacitor,
CE435 KM101M050F115AP 01.34.CL.D.E288100U50VD
AL.electrolytic
GF471M063J210A (Can be
CE429 CE430 CE436 CE437 CE438 CE439 Capacitor,
replaced by UPW1J471MHD3 01.34.CL.D.E470U63VG
CE440 CE441 CE442 CE443 CE444 CE445 AL.electrolytic
nichicon)
Inductor,DIP,Panasoni
L404 L406 L408 L410 L412 ETQA17B220(22uH) DIP 01.13.L.L.D.E217
c
L401 L405 L407 L409 L411 L413 Bead, chip 0603-750Ω PB 01.13.L.Z.ESA750P
SLF7032T-680MR59-
L402 L403 L414 L415 L416 L417 Inductor,SMD, TDK 01.13.L.L.S.E354
2PF(68UH) SMD
D405 D406 D407 D408 D412 D413 D414
D415 D419 D420 D421 D422 D426 D427
Diode LL4148, DO213AA 01.41.D.PS.ELL4148
D428 D429 D433 D434 D435 D436 D437
D442 D443 D446 D447 D448 D449
D401 D404 D410 D411 D417 D418 D423
Diode 1N4448HWS, SOD-323 01.41.D.PS.E1N4448HWS
D425 D431 D432
D402 D444 D445 D450 Diode B1100, SMA 01.41.D.PS.EB1100
5.1V(Can be replaced by
D403 D409 D416 D424 D430 Zener diode 01.41.D.WS.E5V1
ZMM5V1 DIODES), SOD-80
D438 D441 Diode 1N4001 DIP 01.41.D.PD.EIN4001
Q403 Transistor BSS123, SOT23 01.42.Q.S.E123
Q404 Transistor DTC343TK, SMT3 01.42.Q.S.E343
Q402 Transistor KTC8550, SOT23 01.42.Q.S.EC8550
Q415 Transistor 2SA1037AKR, SOT23 01.42.Q.S.E1037
Q416 Q401 Transistor 2SC5866, SOT23 01.42.Q.S.E5866
Q405 Q406 Q407 Q408 Q409 Q410 Q411
Mosfet, IR IRF6645TRPbF, DirectFET-SJ 01.42.Q.S.EIRF6645TRPBF
Q412 Q413 Q414
U401 IC, Microchip, MCU PIC16F690-I/SS, SSOP20 01.44.IC.S.EPIC16F690
U403 U405 U408 U411 U414 IC, ADI, Pre-amp ADTL082ARZ, SOIC8 01.44.IC.S.EADTL082ARZ
IC, IR, PROTECTED
01.46.IC.EIRS20955STRPB
U404 U406 U409 U412 U415 DIGITAL AUDIO IRS20955STRPbF, SOIC16
F
DRIVER
IC, Wolfson, 24-
U407 U410 U413 bits,High performance WM8740SEDS, SSOP28 01.44.IC.S.E8740
192KHz stereo DAC
U416 IC, AAC, LDO AZ1117H-3.3, SOT-223 01.44.IC.S.EA11173V3
U417 IC, NJRC, Pre-amp NJM2068M, SO8 01.44.IC.S.E2068

Page 31 of 89
harman/kardon HS 350/650DL Service Manual

HS650DL Component List for Amplifier board (5329C01)

Location.No. Description Specification P/N
IC, FairChild, Low
U420 Dropout Voltage KA78R05CTU, TO-220F-4L 01.44.IC.D.E78R05CTU
Regulator
IC, ONSEMI, 1.5 A,
Step-
U421 U422 U423 NCP3063BPG, DIP8 01.44.IC.D.ENCP3063BPG
Up/Down/Inverting
Switching Regulators
Horizontal VH Connector with
CN403 Connector 01.40.CON.DCZ.E298
four holes and four pins
1.0-16P, Vertical Type and
CN401 FPC Connector 01.40.CON.S10.FPC2.E024
Dual Contact
1.0-8P, Vertical Type and Dual
CN404 FPC Connector 01.40.CON.S10.FPC2.E002
Contact
1.25-6P, Vertical Type and
CN402 FPC Connector 01.40.CON.S13.FPC2.E017
Single Contact
J401 Connector TJC3-6A 01.40.CON.DTJ.E012
Horizontal VH Connector with
CN405 Connector 01.40.CON.DCZ.E560
ten holes and ten pins

HS650DL Component List for Speaker board (5118C01)

Location.No. Description Specification P/N
(R903) (R908) (R913) (R918) (R923) Resistor, chip 0805-10KΩ±5% 01.57.R.3.E103J
(R902) (R907) (R912) (R917) (R922) Resistor, chip 0805-30KΩ±5% 01.57.R.3.E303J
(R901) (R904) (R906) (R909) (R911) (R914)
Resistor, chip 0805-47KΩ±5% 01.57.R.3.E473J
(R916) (R919) (R921) (R924)
(R905) (R910) (R915) (R920) (R925) Resistor, chip 0805-100KΩ±5% 01.57.R.3.E104J
Capacitor, multilayer
(C900) 0805-27P NPO±5%/50V 01.54.CS.3.E270N50V
ceramic, chip
Capacitor, multilayer
(C901) 0805-104 Y5V+80-20%/50V 01.54.CS.3.E104Y50V
ceramic, chip
Capacitor, polyester
C902 C903 C904 C905 C906 474J/100V DIP 01.00.CD.DL.E474100V
film
High-voltage
connect the JP903 output pin with ground on
metallized polyester 221/1KV 01.00.CD.GY.E2211KV
speaker board (for EMI)
film
connect the JP903 GND pin with ground on
3pins grounding piece M4 01.00.WJ.QT.E041
speaker board (for EMI)
(D901) (D903) (D905) (D907) (D909) Diode LL4148, DO213AA 01.41.D.PS.ELL4148
(D902) (D904) (D906) (D908) (D910) Zener diode 15V 01.41.D.WS.E15V
(Q901) (Q905) (Q909) (Q913) (Q917) Transistor KTC8550 SMD 01.42.Q.S.EC8550
(Q902) (Q906) (Q910) (Q914) (Q918) Transistor KTC8050 SMD 01.42.Q.S.E8050
(Q903) (Q904) (Q907) (Q908) (Q911) (Q912)
Transistor, Rohm DTC114TUA, UMT3 01.42.Q.S.EDTC114TUA
(Q915) (Q916) (Q919) (Q920)
(MQ901) (MQ902) (MQ903) (MQ904)
Mosfet, IR IRF7341, SO-8 01.44.MOS.S.EIRF7341
(MQ905)
JP901 Earphone Jack CKX-3.5-22 01.40.CON.DCZ.E203
Jack, YuanChang,
JP902 AV1-8.4-6G 01.40.CON.DCZ.E172
SUB Woofer Jack
1.0-8P, Horizontal type and
CN901 FPC Connector 01.40.CON.S10.FPC2.E037
dual contact
JP903 Connector WP10-24-1, DIP 01.40.CON.DCZ.E561
Horizontal VH Connector with
CN902 Connector 01.40.CON.DCZ.E560
ten holes and ten pins

Page 32 of 89
harman/kardon HS 350/650DL Service Manual

AML3390DTS-G;A/V Processor (PQFP256LD)

KH29LV160CBTC-70G;FLASH (TSOP48)

Page 33 of 89
harman/kardon HS 350/650DL Service Manual

D708E001BRFP266;DSP(S-PQFP-G144)

IS42S16400B-6TL;SDRAM(TSSOP-54)

Page 34 of 89
harman/kardon HS 350/650DL Service Manual

BH7868FS; 6ch 75ohm driver(SSOP-A32)

FSTU3257MTC;Multiplexer/Demultiplexer Bus Switch

(TSSOP16)

Page 35 of 89
harman/kardon HS 350/650DL Service Manual

AML3501;DVD/CD RF BA5888FP; Actuator driver

Processor (TSSOP48) (HSOP-28)

XC9572XL-10VQG44C; CPLD (VQFP44)

Page 36 of 89
harman/kardon HS 350/650DL Service Manual

TDOTG242LPF; USB Controller (LQFP-64)

SiI9030CTU; HDMI PanelLink Transmitter (TQFP80)

Page 37 of 89
harman/kardon HS 350/650DL Service Manual

SN74LVC823APWR; 9-BIT BUS-INTERFACE FLIP-FLOP (TSSOP24)

LM358M; Dual Operational AT24C64-2.7; EEPROM (SO8)

Amplifier (SOP8)

74HCT14D; Schmitt Trigger(SO14) BA6287; Motor Driver(SOP8)

Page 38 of 89
harman/kardon HS 350/650DL Service Manual

RClamp0514M; Low Capalitance UPA672T; MOS FIELD EFFECT

TVS Diode Array(MSOP-10L) TRANSISTOR (SC-70)

AK4683EQ; Stereo audio CODEC (LQFP-64)

Page 39 of 89
harman/kardon HS 350/650DL Service Manual

PT2579-SN(L); RDS Demodulator IC NJM2068M; Pre-amp

(SOP16) (SO8)

EM78P156ELM-G; MCU (SOIC18) 74HCU04; Hex Inverter(TSSOP14)

LM9022M; Vacuum Fluorescent PC817; Photoelectric Coupler

Display Filament Driver (SOP8) (DIP4)

Page 40 of 89
harman/kardon HS 350/650DL Service Manual

PIC16F690-I/SS; MCU (SSOP20)

WM8740SEDS; DAC (SSOP28) ADTL082ARZ; Pre-amp(SO8)

IRS20955STRPbF; PROTECTED IRF6645TRPbF; DirectFET

DIGITAL AUDIO DRIVER (SOIC16) (SJ)

Page 41 of 89
harman/kardon HS 350/650DL Service Manual

ML4800CS; Power Factor Correction EL817; Photocouple

and PWM Controller(SOIC16) (DIP4)

IRF7341; Mosfet MP1411DH; Step-Down Converter

(SO-8) (MSOP-10)

MC34063ADG; Step−Up/Down/ NCP3063BPG; Step−Up/Down/

Inverting Switching Regulators Inverting Switching Regulators

(SO-8) (DIP8)

Page 42 of 89
harman/kardon HS 350/650DL Service Manual

AZ1117-1.8V /3.3V; LDO BA33BCO; Dropout Voltage

(SOT-223) Regulator (TO-220)

KA7809/7812; Voltage Regulator 78L05/78L12; Voltage Regulator

(TO-220) (SOT-89)

79L12; Negative voltage regulators KA78R05CTU; Voltage Regulator

(TO-92) (TO-220F-4L)

Page 43 of 89
harman/kardon HS 350/650DL Service Manual

BA00HC5FP;LDO (T0252-5) AZ431AZ-A; Shunt Regulator

(TO -92)

FAN73832; Half-Bridge Gate-Drive IC FAN7602MX; PWM Controller

(SOP8) (SOP8)

*********************************************************************************
2SB1132; Medium Power 2SK3018T106;Small Switching
Transistor (SOT89) (UMT3)

Page 44 of 89
harman/kardon HS 350/650DL Service Manual

KTC8550; PNP Transistor(SOT23) KTC8050; NPN Transistor(SOT23)

2N3906; PNP Transistor(SOT23) 2N3904; NPN Transistor (SOT23)

DTC114EUA; 100mA / 50V DTC343TK; NPN Transistor

Digital transistors (SOT23) (SMT3)

BSS123; N-Channel FET 2SA1037AKR; General Purpose

(SOT23) Transistor (SMT3)

Page 45 of 89
harman/kardon HS 350/650DL Service Manual

2SC5866; Medium Power Transistor AF4835; P-Channel Mosfet(SO8)

(TSMT3)

FQPF13N50C; N-Channel DMN3033LSN; N-Channel

Mosfet (TO-220F) Mosfet (SOT-23)

FDPF18N50; 500V N-Channel FQPF7N80C ;800V N-Channel

MOSFET(TO-220) MOSFET(TO-220)

Page 46 of 89
harman/kardon HS 350/650DL Service Manual

Page 47 of 89
harman/kardon HS 350/650DL Service Manual

Page 48 of 89
harman/kardon HS 350/650DL Service Manual

Page 49 of 89
harman/kardon HS 350/650DL Service Manual

Page 50 of 89
harman/kardon HS 350/650DL Service Manual

Page 51 of 89
harman/kardon HS 350/650DL Service Manual

Page 52 of 89
harman/kardon HS 350/650DL Service Manual

Page 53 of 89
harman/kardon HS 350/650DL Service Manual

Page 54 of 89
harman/kardon HS 350/650DL Service Manual

Page 55 of 89
CAM350 V 8.6 : Wed Apr 09 10:27:29 2008 - (Untitled)
harman/kardon HS 350/650DL Service Manual

Page 56 of 89
CAM350 V 8.6 : Wed Apr 09 10:28:40 2008 - (Untitled)
harman/kardon HS 350/650DL Service Manual

Page 57 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

HS350 HS650DL HTiB System Schematic

D KEY COMPONENTS LIST D

DECODER AML3390DTS-G FLASH MEMORY 16M Bits, Bottom boot

IO EXPANDER XC9572XL-10VQG44C SDRAM MEMORY 64M Bits -6ns * 2 pcs

SERVO RF AML3501 DSP FLASH 16M Bits, Bottom boot

AUDIO CODEC AK4683EQ DSP SDRAM 64M Bits -7ns

AUDIO DSP TMS320DA708 MOTOR DRIVER BA6287F

HDMI TRANSMITTER SiI9030CTU AMPLIFIER HARMAN COOL SOLUTION

C VIDEO DRIVER BU7868FS (NOT FOR HS650DL) RDS DECODER PT2579-SN(L) C

USB CONTROLLER TDOTG242LP CIG VFD VFD33-1701I

TUNER MODULE US: TFCF1E807A

EU: TFCF1E806B LOADER DL-05MH-H40P

INDEX OF SCHEMATIC PAGE

PAGE DESCRIPTION PAGE DESCRIPTION PAGE DESCRIPTION PAGE DESCRIPTION

1 INDEX & KEY COMPONENTS LIST 10 Motor driver and RF-AMP 19 Amplifier Audio DAC 28 HS650 SMPS
B B
2 BLOCK DIAGRAM 11 Video output 20 Audio Sound Processor 29 SMPS Rev history

3 WIRING DIAGRAM 12 USB and IR In/Out 21 L and SL AMP 30 Speaker output

4 Rev history 1 13 HDMI 22 R and SR AMP

5 Rev history 2 14 DSP DA708 23 C AMP

6 Rev history 3 15 SCART and MUTE Logic 24 VFD and MCU

7 Power and connector 16 Audio Codec 25 VFD Power supply and button

8 Decoder 17 Tuner and iPod input 26 Volume Encoder

A
9 Memory 18 Power supply and MCU 27 HS350 SMPS A

*The schematic revision will follow the mainboard revision. Title

Index and key components list 070725

Size Document Number Rev

A3 Index 1.2

Date: Wednesday, March 19, 2008 Sheet 1 of 32

5 4 3 2 1

Page 58 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

Only for HS350

HS350 HS650DL BLOCK DIAGRAM CVBS output

Video Output YPbPr output

Block
D BH7868FS D

S-Video output
Flash SDRAM SDRAM EEPROM
Front
16Mb 4*16Mb 4*16Mb 24C64
USB plug
Scart out
(EU version only)

M2
OTG242
M1 HDMI Block SiI9030 HDMI output

Rear
Coaxial out

D-In/Out
USB plug
Coaxial In

Optical In

C C
MPEG Tuner module
EU/US
Tuner audio input
AML3390DTS-G RDS decoder DIR
PT2579-SN(L)
Motor Driver RF
Buffer iPod input
BA5888FP AML3501

Scart audio in Only for

DSP Block HS350
Audio (EU version only)
Input
ADC
Buffer MIC in

AK4683
TV input
B B

MCU Standby control

Aux input
EM78P156ELM-G

SMPS Board Downmix line output

Audio
2lines output
CIG-VFD Supply power DAC
Functional IR Power for all boards Headphone
Display buttons receiver indicator
Slot in
Loader
Hitachi Subwoofer line output
HOP-1200W
Front Panel Board Harman
WM8740 Amplifier
*3 5 channels output

A A
AC Power cord Sub trigger control Sub Trigger output

IR in Title
HS350 HS650 DIAGRAM 070725
IR In/Out Block
Size Document Number Rev
IR out A3 BLOCK DIAGRAM 1.2

Date: Wednesday, March 19, 2008 Sheet 2 of 32

5 4 3 2 1

Page 59 of 89
 A
B
C
D
TUNER MODULE ALPS

12 pins

200-299
11 pins

CN1

9
8
7
6
5
4
3
2
1
1
2
3
4
5
6
7
8
9

CN2

12
11
10
10
11

24 pins

Slot-in LOADER
CN304
1 GND-LD

5
5

2 LD-DVD
harman/kardon

3 NC

Hitachi HOP-1200W
NC

DO
HFM

GND
GND
GND

SW5
SW3
SW2
SW1
SW4
4

SPIN-
SPIN+

SLED-
LOAD-

SLED+
MD

LOAD+
5

RDS_CS
6 CD-LD

RDS-MPX

DATA/SDA
DVD_VR

TUNER +9V
7

CLOCK/SCL
TUNER_IN_L

Main board DSP Parts: from

TUNER_IN_R
8 CD_VR CN9 CN301
9 NC

Main board 5112C: from 1-199

AV board 5113C: from 300-399

10 E 1 R
11 S5V 2 GND
12 VC_OPU 3 G
13 GND-PD 4 GND
14 F 5 B
15 B 6 GND
16 A 7 CVBS
17 DVDRFP 8 RGB_SWITCH
18 CD_DVD 9 TVFORMAT0
19 10 TVFORMAT1

D
D
20 C 11 RDS_DAT

20 pins
21 TRACK- 12 GND

from 600-699
22 TRACK+ 13 RDS_SCK
23 FOCUS+ 14 GND
24 FOCUS- 15 5VON
16 -12V
17 TUNER_CE
CN3 18 GND
19 TUNER_DO

HS350 HS650 CNT REF NO. ASSIGNMENT

14 SCL2 20 GND
13 EXTA18/ASIC_INT

AMP 5329C: from 400-599

12 EXTA17/ASIC_LINK

SMPS 5117C: from 700-899

CN401 11 RESET_N
10 GND CN8 CN302
9 SDA2

4
4

Front panel board 5115C/5116C:

8 GND 1 GND
7 LRCK_OUT2 2 ALRCK
6 SCLK_OUT2 3 ASCLK
5 GND 4 GND
4 S2DATA2 5 AMCLK

prepare for HS700

3 S2DATA1 6 GND
2 GND 7 ADATA3
1 S2DATA0 8 GND

900-999
9 HW_MUTE_2

14 pins
<2>:AV BOARD (5113C)

10 HW_MUTE
E

CN4 11 ADATA_IN
20 pins

12 GND
<1>: MAIN BOARD(5112C)

16 NC 13 DATA/SDA
15 DSP_MUTE 14 CLOCK/SCL

B
14 MUTE_SUB 15 GND
13 GND 16 COAXIAL_OUT
12 CLOCK/SCL 17 RESET_N
11 DATA/SDA 18 GND
CN405 10 GND 19 SPDIF_IN
9 S1DATA2 20 NC
GND 1 8 S1DATA1

Speaker board 5118C: from

L_CH 2 7 S1DATA0

<3>:AMP BOARD (5329C)

GND 3 6 GND
L

SL_CH 4 5 MCLK_OUT
GND 5 4 GND CN7 CN303
C_CH 6 3 LRCK_OUT1
GND 7 2 SCLK_OUT1 1 iPod_Tx
SR_CH 8 1 GND 2 GND
GND 9 3 iPod_Rx
R_CH 10 4 iPod_Check
CN601 CN5 5 GND
6 HP_L
1 MCU_OFF 7 GND

3
3

2 CLOCK/SCL 8 HP_R
F

CN404 3 DATA/SDA 9 GND

4 VFD_CS 10 MIC_IN
18 pins

+30V/+40V 1 5 NC 11 FPMCU_MUTE
NC 2 6 IR 12 15VON
MUTE_SPKR 3 7 GND 13 GND
M

GND 4 8 FRONT_LED 14 -15V

SUBWOOFER 5 9 IR_IN 15 GND
HS350 HS650DL WIRING DIAGRAM

GND 6 10 16 +5.7V

A
GND
SUB_TRIGGER 7 11 HP_DETECT 17 GND
GND 8 12 MIC_DETECT 18 +15V

22 pins
13 GND
14 MIC_IN
15 DM2
16 DP2
17 GND
-15V

GND
GND
GND
GND
GND
GND

18 FPMCU_MUTE
+15V
+15V

+5.7V
+5.7V
+5.7V
5VON

-15V
USB5V
USB5V
15VON

GND
GND
GND
GND
GND

19 GND
-30V/-40V
+15V

+5.7V

+30V/+40V

20 HP_L
21 GND
1
2
3
4
5
6
7
8
9

6
5
4
3
2
1

4
3
2
1
10
11
12
13
14
15
16

22 HP_R
CN403
CN402
CN6

<4>: FRONT PANEL BOARD(5115C/5116C)

GND
GND

VOL-
A+5V

VOL+

LED_CONTROL
C

CN602

6
5
4
3
2
1
CN604
I

2
2

14 pins

6 pins
CN605

4 pins 6 pins 12 pins 8 pins 10 pins

CN506
CN503
CN504
CN901
CN902

CN502

1 5VON
2 +15V
3 DC_GND
4 -15V
5 GND
Title

Size
A3

Date:

6 USB5V
7 GND
8 USB5V
9 GND
10 +5.7V
11 GND
12 +5.7V
13 GND
14 STANDBY
Document Number
<5>: SMPS(5117C)
AC
AC

HS350 HS650 DIAGRAM

<6>: SPEAKER BOARD(5118C)

Wednesday, March 19, 2008

2
1
CN501

1
1

Sheet
WIRING DIAGRAM

3
070727

of
32
~100-240V
AC Power cord

Rev
HS 350/650DL Service Manual

1.2

Page 60 of 89
A
B
C
D
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

NO. REVISION DATE REV REVISION HISTORY

Mar 20, 2007

1 1.0 1. initial version.

D D
1. change U204 from TPS78601DCQR to BA00HC5FP. 4. add MUTE_AMP circuit for amplifier board. 7. update DSP page, add SN74LVC823APW,
2. add pull-up R11 for TUNER_CE. 5. change ADC from PORTB to PORTA of AK3683. change the Flash to top boot type.
May 5, 2007
2 1.1 3. change I2C2 -> I2C1 on CN4, ASIC_TEST 6. pin2 of U18 change to float in order to improve the
-> SCL2 and EXTA16/ASIC -> SDA2 on CN3. playability.

1. change R240 R241 to N/A, install R655 CE621. 7. change R385->0R, R205->0R, R206->150R, 12. amplifier board: change subwoofer mute circuit, add discharge
2. improve iPod noise issue, related components: Q310, R207->0R, in order to fix amp output noise. circuit for fixing the noise cause by plug out AC cord, change
June 5, 2007 3R007, 3R008, 3R009, 3R010, 3R012, 3R013, FB314, C308, 8. CN402/CN703/CN704/CN702/CN602 -> 180 CN404(5pin-1.0mm -> 8pin-1.0mm), CN401(14pin-1.0mm ->
3 1.2 degree + pin X-turn. 16pin-1.0mm).
C309, C339, C340, C341, C342, C359, C360, CE345, D308,
R307, R309, R311, R312, R318, R340, R348, R366, R368, 9. the power supply for AV board was changed to 13. add R626/CE614 to fix random DC supply when power on,
come from mainboard, that can canel one flat cable change R619 from 1.5k to 10R and R621 to N/A.
R370, R372, R374, R376, R386, R387, R388.
which close to the high-voltage heatsink on SMPS 14. change MUTE_HP_SUB to MUTE_HP on AV board.
3. change R393 in order to fix analog input no sound issue. board, CN7/CN303(12pin-1.0mm -> 18pin-1.25mm), 15. add mute circuit on speaker board.
4. change DSP Flash from top boot type to bottom boot type. CN6(12pin-1.25mm -> 16pin-1.25mm).
5. change MUTE_DSP to DSP_MUTE on mainboard, 10. change MUTE LOGIC CIRCUIT on mainboard,
change front panel MCU_MUTE to FPMCU_MUTE. change CN4(14pin-1.0mm -> 16pin-1.0mm).
6. add FB10/FB15 on I2C which go to CPLD, add 11. add mute circuit on speaker board, change
C FB17(0 ohm)/FB19(0 ohm) on I2C which go to CN8, CN901(5pin-1.0mm -> 8pin-1.0mm). C

they are for avoiding misoperation.

1. change R58 from 0R to 1K to improve EMI issue from pick up. 5. Add Relay K603 to replace FSA2257 to improve 7. Change CE322 ->100UF, add CE343 470UF, to improve
2. R99 68R -> 75R, CE33 10uF->330uF, CE37 -> C249, Heaphone THD, but FSA2257 still left, need to the headphone THD.
4 Jan 31, 2008 1.4 to improve CVBS light noise and gain. improve.
3. Exchange the pin order of CN3 6. Change the coxial 2 from C, D gate to E, F gate, add C324
4. Add C367, C644 to decrease the ripple voltage of +40V. to improve the crosstalk issue bettween coxial 1 and coxial 2.

B B

A A

Title
HS350 HS650 REVISION HISTORY 080131

Size Document Number Rev

A3 1 1.3

Date: Wednesday, March 19, 2008 Sheet 4 of 32

5 4 3 2 1

Page 61 of 89
 5 4 3 2 1

CN6

1 1 +5.7V Power Supply on Main board harman/kardon HS 350/650DL Service Manual CN4 CN5
2 16 22
2
3 3 Come from SMPS board SCLK_OUT1 15 B HP_R
21
22
21
A
4 DGND 14 20
4 LRCK_OUT1 HP_L 20
5 13 +3.3V D5V 19
5 USB5V 19
6 U20 12 18
6 MCLK_OUT FPMCU_MUTE 18
7 MP1411DH 11 17
7 C168 104 EN=open=automatic startup 17
8 8 1 NC1 SS 10 S1DATA0 10 DP2 16 16
C6

4.7K N/A
9 2 9 9 15
C 9
10 10 103 3
BS
NC2
EN
COMP 8 C191 392 R66 10K
S1DATA1
S1DATA2 8
DM2
MIC_IN 14
15
14

4.7K
4.7K
4.7K

4.7K
11 +15V 4 7 R64 10K 7 13
11 IN FB 13

470uF/25V
12 5 6 R40 24K 6 12
12 SW GND DATA/SDA MIC_DETECT 12
D
13 13 GND 11 CLOCK/SCL 5 HP_DETECT 11 11 D

1
14 C83 R69 1.8K 4 10
14 + 104 L7 10
15 15 DC_3.3V MUTE_SUB 3 IR_IN 9 9

R190
R191
R192
R70
16 SPI1048QR-150 15uH/3A 2 8
16 DSP_MUTE FRONT_LED 8

R5
C98 C193 1 7 7
CE63
2 R40=2.587*R64, R64=10K~100K FB16 1 2 50R 6
IR 6
CON16_1.25MM_DIP_2 D3 104 22uF/10V Ceramic R64=10K, R40=25.8K≈26K FB2 1 2 50R N/A 5
B340LA CON16_1.0MM_DIP_2W FB18 50R 5
5VON R64=15K, R40=38.8K≈39K go to Amplifier board VFD_CS
FB20
1 2
50R
4 4

1
-15V DATA/SDA 1 2 3 3
FB22 1 2 50R 2
15VON CLOCK/SCL 2
FB23 1 2 50R 1
MCU_OFF 1
CN3
U1 CON22_1.0MM_DIP_2_B
BA00HC5FP S2DATA0 1
2
1 go to Front Panel board
2
S2DATA1 3 3
DC_3.3V

NC&FIN
5 VCC VO 4 VCC1.2V S2DATA2 4 4 D5V CN8
2 PVCC 5 5

ADJ
1

6 20
SCLK_OUT2 6 20 E

1
+ 7 19
LRCK_OUT2 7 ALRCK 19
CE2 C7 R6 + 8 18
104 8 ASCLK 18
100uF/10V 100R CE3 C8 R178
3
1
SDA2 9 9 17 17
47uF/10V 103 4.7K
2

10 10 AMCLK 16 16

2
RESET_N 11 11 15 15
ASIC_LINK 12 12 ADATA3 14 14
R8 13 13
ASIC_INT 13 13
200R 14 12
SCL2 14 HW_MUTE_2 12
HW_MUTE 11 11
ADATA_IN 10 10
U23 CON14_1.0MM_DIP_2 N/A
C U28 AZ1117-1.8V
prepare for HS700 DATA/SDA FB17 2 1 0R
9
8
9 C
KA78R05TSTU CLOCK/SCL FB19 8
TAB 4 go to Amplifier board 2 1 0R 7 7
+5.7V 1 2 3 2 6
Vin Vout IN OUT VCC1.8 6
ADJ
5
GND

COAXIAL_OUT
Vdis

5
1

RESET_N 4 4
+ 3
CE49 C186 MUTE_SUB 3
1

R67 100uF/10V 104 Mute logic circuit for SPDIF_IN 2 2

3

1 1
4.7K R12 10K
Amplifier board
2
1

104

CE51 +
-12V go to AV board CON20_1.0MM_DIP_2

2
1000uF/10V R68 C166 C
H5V
C165

10K 104 1B Q2
FB3 CN7
2 50R D8 LL4148 8550
2

1 VIDEO5V
U29 FPMCU_MUTE 2 1 E 18
AZ1117H-3.3 FB5
iPod_Tx 18 F

3
17 17
4 50R D9 LL4148 N/A 16
TAB HW_MUTE iPod_Rx 16
3 IN OUT 2 1 2 HDMI3.3V 2 1 5VON iPod_Check 15 15
ADJ

14 14
1

D10 LL4148 N/A R81 R88 13

HW_MUTE_2 HP_L 13
+ 2 1 10K 3.3K 12
C188 C189 CE52 12
1

HP_R 11 11
104 104 47uF/10V 10 10
2

MIC_IN 9 9
FPMCU_MUTE 8 8
U10 7
15VON 7
KA78R05TSTU 6
A+5V FB6 A5V 6
1 Vin Vout 2 1 2 50R FB1 1 2 50R RF5V -15V 5 5
R3 2R 4
GND

OPU5V
Vdis

4
1

B D5V B
104

FB8 1 2 50R 3
D5V +5.7V 3
1

CE61 + M1 M2 M3 2
1000uF/10V CE62 + 2
+15V 1 1
470uF/10V C5 LOCATION-PAD
3

1 1 1
C1

104 CON18_1.25MM_DIP_2
2

R10 4.7K
for the board go to AV board
2

R20 C2
10K 104 VIA1 VIA2 CN9
VIA_PAD4.0 VIA_PAD4.0 20

U22
1 1
R
19
20
19
D
2 2 G 18 18
D1 D2 BA33BC0 3 3 17
1N5393 DIP 1N5393 DIP 17
4 4 B 16 16
1 2 1 2 A+4.3V 1 3 +3.3V FB12 1 2 50R 5 5 15
IN OUT 3.3V 15
FB7 1 2 50R 6 6 14
USB3.3V CVBS 14
1

FB9 1 2 50R 13
GND

FE3.3V RGB_SWITCH 13
CE55 + + FB11 1 2 50R 12
RF3.3V TVFORMAT0 12
220uF/10V C3 CE56 C4 FB13 50R

9
8
7

9
8
7
1 2 AVDD_DAC TVFORMAT1 11 11
104 100uF/10V 104 FB14 1 2 50R 10
Core3.3V RDS_DAT 10
2

+3.3V 9 9
RDS_SCK 8 8
7 7
U14 6
5VON 6
KA78R05TSTU 5
-12V 5
1 2 S+5V FB4 1 2 50R VIA3 VIA4 4
Vin Vout S5V TUNER_CE 4
VIA_PAD4.0 VIA_PAD4.0 3
GND

Vdis

3
1 1 TUNER_DO 2 2
1

1
104

A 2 2 1 1 A
CE65 + CE66 + 3 3
1000uF/10V 470uF/10V C169
3

4 4
C163

104 CON20_1.0MM_DIP_2
R21 4.7K
5 5 go to AV board
2

6 6

R25 C164
10K 104
9
8
7

9
8
7
Title
Power and connector 070726

Size Document Number Rev

A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 7 of 30

5 4 3 2 1

Page 62 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

Power_on
M1_A[0..11] M1_D[0..15] 3.3V
M1_A[0..11] M1_D[0..15]
Core3.3V
Configuration
D5V

2
R13 2K ADATA3
FB49 U3
D5V
1

M1_CAS_N
M1_SCS_N
M1_RAS_N
U2A R14 2K ADATA0 50R AT24C64AN-10SU-2.7

M1_DQM0
M1_DQM1
M1_WE_N
74HCT14D

M1_CLK
+

M1_BA1
M1_BA0
8 VCC A0 1
CE4 R15 2K ADATA1 DATA/SDA

1
5 SDA A1 2
10uF/10V C9 CLOCK/SCL 6
A2 3

M1_A11
M1_A10

M1_D15
M1_D14
M1_D13
M1_D12
M1_D11
M1_D10
ADATA2 SCL

M1_D9
M1_D8
M1_D7
M1_D6
M1_D5
M1_D4
M1_D3
M1_D2
M1_D1
M1_D0
M1_A3
R16 2K
22

M1_A9
M1_A8
M1_A7
M1_A6
M1_A5
M1_A4

M1_A2
M1_A1
M1_A0
1 2 RESET_N Core1.2V Core3.3V 104 4 7
R18 2K ALRCK GND WP
R17 D4
15K LL4148
D D
1

U2C

174
193
190
189
188
187
186
150
173

175
194
180
181
182
183
184
185
198
197
196
195

151
166
167
168
169
170
171
172
149
148
145
144
143
142
141
140

113
139
165
179
219
246

114
138
152
178
220
245

103
115
146
160
177
192
202
214

104
120
147
159
176
191
201
213
U4 74HCT14D C10 104

14
33
72
91

15
32
73
92

44
57
74
89

45
56
75
90
9 8 COAXIAL_OUT
AML3390DTS-G
To be decided. U2D

M1_CLKO

M1_SCS_N
M1_RAS_N
M1_CAS_N
M1_WE_N

VDD_1.2V_1
VDD_1.2V_2
VDD_1.2V_3
VDD_1.2V_4
VDD_1.2V_5
VDD_1.2V_6
VDD_1.2V_7
VDD_1.2V_8
VDD_1.2V_9

VSS_1.2V_1
VSS_1.2V_2
VSS_1.2V_3
VSS_1.2V_4
VSS_1.2V_5
VSS_1.2V_6
VSS_1.2V_7
VSS_1.2V_8
VSS_1.2V_9

VSS_3.3V_1
M1_BA1
M1_BA0

M1_DQM0
M1_DQM1

M1_A_11
M1_A_10
M1_A_9
M1_A_8
M1_A_7
M1_A_6
M1_A_5
M1_A_4
M1_A_3
M1_A_2
M1_A_1
M1_A_0

M1_D_15
M1_D_14
M1_D_13
M1_D_12
M1_D_11
M1_D_10
M1_D_9
M1_D_8
M1_D_7
M1_D_6
M1_D_5
M1_D_4
M1_D_3
M1_D_2
M1_D_1
M1_D_0

VDD_1.2V_10

VSS_1.2V_10

VSS_3.3V_2
VSS_3.3V_3
VSS_3.3V_4
VSS_3.3V_5
VSS_3.3V_6
VSS_3.3V_7
VSS_3.3V_8
VSS_3.3V_9
VSS_3.3V_10
VSS_3.3V_11
VSS_3.3V_12

VDD_3.3V_1
VDD_3.3V_2
VDD_3.3V_3
VDD_3.3V_4
VDD_3.3V_5
VDD_3.3V_6
VDD_3.3V_7
VDD_3.3V_8
VDD_3.3V_9
VDD_3.3V_10
VDD_3.3V_11
VDD_3.3V_12
203 SPDIF_OUT 5 6 74HCT14D
IEC958

AMCLK 204 AMCLK_0 R174 0R

AMCLK
AOCLK 205 ASCLK 11 10
Memory #1 206

Audio
ALRCLK ALRCK
ADATA[0..3] U2E
ADATA[0..3]
POWER 221 ADATA0 74HCT14D
ADATA_0 ADATA1
ECS_N 199 ECS_N ADATA_1 222
EOE_N 200 223 ADATA2
M2_D[0..15] EOE_N ADATA_2 ADATA3
M2_D[0..15] ADATA_3 224 13 12
M2_D0 106 DAC1.2V
M2_D1 M2_D_0 U2F
112 M2_D_1
M2_D2 111 244 74HCT14D
M2_D3 M2_D_2 DVDD_DAC(1.2V)
110 M2_D_3 DVSS_DAC(1.2V) 243
M2_D4 109
M2_D5 M2_D_4
108 M2_D_5 AVDD_DAC(3.3V) 225
M2_D6 107 232 AVDD_DAC
M2_D7 M2_D_6 AVDD_DAC_R(3.3V)
105 M2_D_7 AVDD_DAC_G(3.3V) 235
M2_D8 77 238
M2_D9 M2_D_8 AVDD_DAC_B(3.3V)
83 M2_D_9 AVDD_DAC_X(3.3V) 241
M2_D10 82
M2_D11 M2_D_10 HW_MUTE_1 R4 0R MUTE_IN
76 M2_D_11 AVSS_DAC(3.3V) 226
M2_D12 78 231
M2_D13 M2_D_12 AVSS_DAC_R(3.3V) R7 R9 0R MUTE_OUT
81 M2_D_13 AVSS_DAC_G(3.3V) 234
M2_D14 79 237 C11 0R N/A
M2_D15 M2_D_14 AVSS_DAC_B(3.3V)
84 M2_D_15_A AVSS_DAC_X(3.3V) 240

Video DAC
M2_A[0..11] 104
M2_A[0..11]
M2_A0 88 230
M2_A_0 COMP HW_MUTE
M2_A1 87 229 R19 220R
M2_A2 M2_A_1 RSET
86 M2_A_2 VREF_IN 227
M2_A3 85 228 C12 104
M2_A4 M2_A_3 VREF_OUT HW_MUTE_C
Memory #2

C 100 M2_A_4 3 4 HW_MUTE_2

C
M2_A5 98 233
M2_A_5 IOR R/Cr/Pr

AML3390DTS-G
M2_A6 96 236 U2B
M2_A7 M2_A_6 IOG G/Y/Y
95 239 74HCT14D
M2_A8 M2_A_7 IOB B/Cb/Pb
97 M2_A_8 IOX 242 V_COMP
M2_A9 99
M2_A10 M2_A_9 HD_D_[0..23] DATA/SDA FB10 2
102 M2_A_10 HD_D_[0..23] 1
M2_A11 101 211 HD_D_0 PBY160808T-102Y-N
M2_A_11 HD_D_0 HD_D_1
HD_D_1 210
M2_DQM1 66 209 HD_D_2 CLOCK/SCL FB15 2 1
M2_DQM1 HD_D_2 HD_D_3 PBY160808T-102Y-N
M2_DQM0 70 M2_DQM0 HD_D_3 208
M2_WE_N 80 207 HD_D_4
M2_WE_N HD_D_4 HD_D_5 3.3V
M2_CAS_N 71 M2_CAS_N HD_D_5 164
M2_RAS_N 93 163 HD_D_6
M2_RAS_N HD_D_6 HD_D_7
M2_SCS_N 69 M2_SCS_N HD_D_7 162 3.3V
M2_BA0 68 161 HD_D_8 U5
M2_BA0 HD_D_8 HD_D_9 XC9572XL-10VQG44C

15
35
27MCLK2 M2_BA1 67 M2_BA1 HD_D_9 158
M2_CLK 94 157 HD_D_10
M2_CLKO HD_D_10 HD_D_11 RESET_N
156 2 27

VCC
VCC
HD_D_11 MIC_DETECT HW_MUTE_C I/O I/O
Core3.3V 155 HD_D_12 3 28 GATE_SEL0
HD_D_12 HD_D_13 VD1 I/O I/O
DATA/SDA 116 AICLK_GP0 HD_D_13 154 5 I/O I/O 29 TP9
R177 117 153 HD_D_14 VD7 6 30
CLOCK/SCL AICLK_GP1 HD_D_14 I/O I/O TVFORMAT0
2

DVI
100R 118 55 HD_D_15 7 31 TVFORMAT1
SCLK_XOUT HD_D_15 RDS_SCK I/O I/O
FB48 FB53 2 1 119 54 HD_D_16 8 32 RGB_SWITCH
SCLK_XIN HD_D_16 RDS_DAT I/O I/O
50R PBY160808T-102Y-N 53 HD_D_17 12 37 FRONT_LED
EMI important DVDD AVDD0 HD_D_17 SW3 I/O I/O
8 5 126 52 HD_D_18 13 38 MCU_OFF
VCC OUT DVDD_PLL0 HD_D_18 USB_CS I/O I/O
HD_D_19
1

129 51
CLOCKS & PLL

C14 DVDD_PLL1 HD_D_19 HD_D_20

1 NC GND 4 132 DVDD_PLL2 HD_D_20 50 14 I/O I/O 39 TCLOSE
49 HD_D_21 16 40 TOPEN
AVDD2 AVDD1 HD_D_21 iPod_Check MUTE_IN I/O I/O
104 Y1 127 48 HD_D_22 18 41 LDON
27MHz AVDD_PLL0 HD_D_22 HD_D_23 MUTE_OUT I/O I/O
130 AVDD_PLL1 HD_D_23 47 19 I/O I/O 42 CD/DVD
133 AVDD_PLL2 STBY 20 I/O
46 SPDIF_OUT 21 43
HD_CK HD_CK I/O I/O/GCK1
Core3.3V
125 DVSS_PLL0 TEST FE ANALOG FED GPIO HD_D_DE 216 HD_D_DE SPDIF 22 I/O I/O/GCK2 44
AVDD12VCO

254 AVDD33VCO
EXP_STB
249 AVSS12VCO

253 AVSS33VCO
128 AVSS_PLL0 212 HD_D_HS 23 1

AVDD33AD
HD_D_HS I/O I/O/GCK3

25 AVDD33SV
AVDD12RF

AVSS33AD
27 AVSS33SV
250 AVSS12RF
COMP0SV
COMP1SV
COMP2SV
COMP3SV

131 215 GATE_SEL1 33

137 RESET_N

COMPAD

VSS_PLL1 HD_D_VS HD_D_VS I/O/GSR TP10

SVOREF

REFCSV

REFCRF

MIRROR
TCLOSE
135 TRST_N
136 TEST_N

GPAIN2
SVIREF

GPAIP2

134 217 9 36

TOPEN
GPAO2

GPAO1

RFREF
REF2X

VSS_PLL2 HD_GP0 HD_RESET TDI I/O/GTS1 TP5

LDON
HOLD
EXP_STB
PLCC

STBY
3.3V

LIMIT
218 34
DMO
TEIN

FOO
TDO

TRO
TMS

CEC

SDA
SCK
TP11
SLO
TCK

RFS
SLC

TZC
HD_GP1 I/O/GTS2

VD0
VD1
VD2
VD3
VD4
VD5
VD6
VD7
8
7
6
5

B B
TDI

CE

11
FE

TE
PI

TCK

2
D

RN3 24
TDO

FB47
50R
4.7k
124
122
121
123

247
251
255
256

248
252

10
10
11
12
13
16
17
18
19
20
21
22
23
24
26
28
iPod/I2C_SW 29
30
31

34
35
36
37
38
39
40
41
42
43

65
64
63
62
61
60
59
58
TMS
1
2
3
4
6
7
8

GND
GND
GND
CN10
26
HW_MUTE_1

VCCIO

1
SVOREF

1
2
2
2
REFCRF
1
2
3
4

VD1

VD7
JTAG N/A

17
25
CN11
RFREF

TMS
3.3K

iPod/Servo select C187

4
3
CE_D
CE_C

PLCC

TCK 104 CPLD_TDO

SLC

4 1
SDA1
SCK1
5 TDO TZC iPod/I2C_SW MODE CPLD_TCK 2
FE

TE
TEIN

TDI CPLD_TMS
1
1
1
FE1.2V

6 3
FE1.2VCO

RN4 LOW=0 Servo work CPLD_TDI 4

PI
COMPAD
RFS

CE

SW4
SW1
SLO
TP7

R11

M2_A18
M2_A19
FOO

SPDIF_IN
IN/OUT
10R RESET_N 3.3V
TUNER_CE
TRO

SDEN

ADATA_IN
DMO

IR
LIMIT

DFCT
EMF_RAW
5

MIRROR

RESET_N_AML
CON6_2.0MM_DIP 1 8 FE3.3V HIGH=1 iPod input 6
TUNER_DO
47K

2 7 Core3.3V
VFD_CS
47uF/10V

47uF/10V
223

50R
50R
50R

3 6 U18 D5V
TRST_N
TEST_N

HP_DETECT
1K

4 5 FSTU3257MTC CON6_2.0MM_DIP
TP1 iPod/I2C_SW
1500p

1 S VCC 16
1

FB24
FB25
FB26
2700p

104

104

104

104
C16

2 15 C149
iPod_Tx 1B1 OE
R22

R23 R24 + + 3 14 VD1/VD7 CONNECT CONTROL

HD_D_0 10K N/A 10K TZC 1B2 4B1 104
1 8 4 1A 4B2 13
HD_D_1 SDA
C19

C20

C21

C22

C17

C18

R26
CE23

CE54

2 7 5 12 GATE_SEL0 GATE_SEL1 MODE

HD_D_2 SDA iPod_Rx 2B1 4A
2

3 6 6 2B2 3B1 11 SCK

HD_D_3 4 5 R27 SDA1 7 10 0 0 VD1 -> SW3
4.7K 2A 3B2 SCK1 VD7 -> USB_CS
8 GND 3A 9
RN5 0 1 VD1 -> iPod_Check
Core3.3V RFS
10R N/A R28 VD7 -> don't care
On debug mode, disconnect RN6 and connect 10K 1 0
B/b COMPAD iPod_Rx
RN5 for debugging VFD, disconnect RN5 and iPod_Tx
connect RN6 for debugging HDMI. 1 1 VD1 -> RDS_SCK
RDS_DAT -> VD7

R28 R23 RN4 VCC1.2V FB27 FE1.2VCO VCC1.2V FB28 FE1.2V VCC1.2V FB29 DAC1.2V Core1.2V FB30 DVDD Core1.2V FB31 AVDD0 Core1.2V FB32 AVDD1 Core1.2V FB33 AVDD2
50R 50R 50R 50R 50R 50R 50R
1 2 1 2 1 2 1 2 1 2 1 2 1 2 3.3V
VCC1.2V
1

1
Debug N/A 10K N/A
CE5 + CE6 + C24 CE7 + CE8 + C26 CE9 + C27 CE10 + C28 CE11 + C29
A C23 C25 A

1
104 104

104

104
Normal 10K N/A 10R 47uF/10V 47uF/10V 104 47uF/10V 47uF/10V 104 47uF/10V 104 47uF/10V 104 47uF/10V 104
2

2
+
CE1

C13
47uF/10V
Core3.3V Core3.3V VCC1.2V Core1.2V AVDD_DAC FE3.3V

C15
FB34

2
AVDD_DAC FE3.3V
50R
1 2
1

CE12 + C30 C31 C32 C33 C34 C35 C36 C37 C38 C39 C40 C41 C42 CE13 + C43 C44 C45 C46 C47 C48 C49 C50 C51 C52 C53 CE14 + C54 C55 C56 C57 C58 C59 CE15 + C60 C61 C62 C63

100uF/10V 104 104 104 104 104 104 104 104 104 104 104 104 104 100uF/10V 104 104 104 104 104 104 104 104 104 104 104 100uF/10V 104 104 104 104 104 104 100uF/10V 104 104 104 104
Title
2

DECODER 070511

DGND Size Document Number Rev

C 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 8 of 30

5 4 3 2 1
Page 63 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

M1_A[0..11] M2_A[0..11]
U7 U8
M1_A0 M2_A0 IS42S16400B-6TL IS42S16400B-6TL
M1_A1 M2_A1
M1_A2 M2_A2 M1_A0 23 2 M1_D0 M2_A0 23 2 M2_D0
M1_A3 M2_A3 M1_A1 A0 DQ0 M1_D1 M2_A1 A0 DQ0 M2_D1
24 A1 DQ1 4 24 A1 DQ1 4
M1_A4 M2_A4 M1_A2 25 5 M1_D2 M2_A2 25 5 M2_D2
M1_A5 M2_A5 M1_A3 A2 DQ2 M1_D3 M2_A3 A2 DQ2 M2_D3
26 A3 DQ3 7 26 A3 DQ3 7
M1_A6 M2_A6 M1_A4 29 8 M1_D4 M2_A4 29 8 M2_D4
M1_A7 M2_A7 M1_A5 A4 DQ4 M1_D5 M2_A5 A4 DQ4 M2_D5
30 A5 DQ5 10 30 A5 DQ5 10
M1_A8 M2_A8 M1_A6 31 11 M1_D6 M2_A6 31 11 M2_D6
M1_A9 M2_A9 M1_A7 A6 DQ6 M1_D7 M2_A7 A6 DQ6 M2_D7
D 32 A7 DQ7 13 32 A7 DQ7 13 D
M1_A10 M2_A10 M1_A8 33 42 M1_D8 M2_A8 33 42 M2_D8
M1_A11 M2_A11 M1_A9 A8 DQ8 M1_D9 M2_A9 A8 DQ8 M2_D9
M1_D[0..15] M2_D[0..15] 34 A9 DQ9 44 34 A9 DQ9 44
M1_A10 22 45 M1_D10 M2_A10 22 45 M2_D10
M1_A11 A10/AP DQ10 M1_D11 M2_A11 A10/AP DQ10 M2_D11
35 A11 DQ11 47 35 A11 DQ11 47
M1_D0 M2_D0 Core3.3V M1_BA0 20 48 M1_D12 Core3.3V M2_BA0 20 48 M2_D12
M1_D1 M2_D1 M1_BA1 BA0/A13 DQ12 M1_D13 M2_BA1 BA0/A13 DQ12 M2_D13
21 BA1/A12 DQ13 50 21 BA1/A12 DQ13 50
M1_D2 M2_D2 51 M1_D14 51 M2_D14
M1_D3 M2_D3 M1_CLKB DQ14 M1_D15 M2_CLKB DQ14 M2_D15
38 CLK DQ15 53 38 CLK DQ15 53
M1_D4 M2_D4 37 37
M1_D5 M2_D5 CKE Core3.3V CKE Core3.3V
M1_D6 M2_D6 C64 M1_SCS_NB 19 1 C65 M2_SCS_NB 19 1
M1_D7 M2_D7 6.8pF M1_RAS_NB CS VCC 6.8pF M2_RAS_NB CS VCC
18 RAS VCC 14 18 RAS VCC 14
M1_D8 M2_D8 M1_CAS_NB 17 27 M2_CAS_NB 17 27
M1_D9 M2_D9 M1_WE_NB CAS VCC M2_WE_NB CAS VCC
16 WE 16 WE
M1_D10 M2_D10 3 3
M1_D11 M2_D11 M1_DQM0 VCCQ M2_DQM0 VCCQ
15 DQML VCCQ 9 15 DQML VCCQ 9
M1_D12 M2_D12 M1_DQM1 39 43 M2_DQM1 39 43
M1_D13 M2_D13 DQMH VCCQ DQMH VCCQ
VCCQ 49 VCCQ 49
M1_D14 M2_D14 36 36
M1_D15 M2_D15 NC1 NC1
40 NC2 VSSQ 6 40 NC2 VSSQ 6
VSSQ 12 VSSQ 12
54 VSS VSSQ 46 54 VSS VSSQ 46
M1_BA1 M2_BA1 41 VSS VSSQ 52 41 VSS VSSQ 52
M1_BA0 M2_BA0 28 VSS 28 VSS
M1_DQM0 M2_DQM0
M1_DQM1 M1_CLKB M2_DQM1 M2_CLKB
R29 22R R30 22R
M1_CLK M1_WE_NB M2_CLK M2_WE_NB
R31 22R R32 22R
M1_WE_N M1_CAS_NB M2_WE_N M2_CAS_NB
C R33 22R R34 22R C
M1_CAS_N M1_RAS_NB M2_CAS_N M2_RAS_NB
R35 22R R36 22R
M1_RAS_N M1_SCS_NB M2_RAS_N M2_SCS_NB
R37 22R R38 22R
M1_SCS_N M2_SCS_N
Core3.3V Core3.3V Core3.3V
Place close to SDRAM1
RESET_N ECS_N
Place close to SDRAM2
EOE_N

1
+ +
CE16 CE17
47uF/10V 47uF/10V

2
C66 C67 C68 C69 C70 C71 C72 C73 C74 C75 C76 C77 C78 C79
104 104 104 104 104 104 104 104 104 104 104 104 104 104

U9 SDRAM1
KH29LV160CBTC-70G

M2_A0 25 29 M2_D0
M2_A1 A0 DQ0 M2_D1
M2_A2
24
23
A1 DQ1 31
33 M2_D2 64M bits SDRAM equivalent:
A2 DQ2
M2_A3
M2_A4
22 A3 DQ3 35 M2_D3
M2_D4
1. IS42S16400B-6TL
21 A4 DQ4 38
M2_A5
M2_A6
20 A5 DQ5 40 M2_D5
M2_D6
2. K4S641632K-UC60
19 42
M2_A7 18
A6
A7
DQ6
DQ7 44 M2_D7 3. HY57V641620ETP-6
M2_A8 M2_D8
M2_A9
8
7
A8 DQ8 30
32 M2_D9 4. IS42S16400D-6TL **pending
B M2_A10 A9 DQ9 M2_D10 B
6 A10 DQ10 34
M2_A11 5 36 M2_D11
M2_DQM0 A11 DQ11 M2_D12
4 A12 DQ12 39
M2_DQM1 3 41 M2_D13
M2_RAS_N A13 DQ13 M2_D14
2 A14 DQ14 43
M2_CAS_N 1 45 M2_D15
M2_BA0 A15 DQ15/A-1
48 A16
M2_BA1 17 A17
M2_A18 16 A18
M2_A19 9 A19 NC 10
NC 13
14 Core3.3V
ECS_N NC
26 CE RY/BY 15
EOE_N 28 OE
M2_WE_NB 11 37
RESET_N WE VCC
12 RST
Core3.3V 46 C80
GND1 104
47 BYTE GND2 27

DGND

A
16M bits FLASH equivalent: A
1. KH29LV160CBTC-70G
2. S29AL016M90TFI02
3. S29AL016D70TFI020
4. AM29LV160DB-90EC
Title
5. MBM29LV160BE-70P Memory: SDRAM and FLASH 070616

Size Document Number Rev

A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 9 of 30

5 4 3 2 1

Page 64 of 89
 RF5V
harman/kardon HS 350/650DL Service Manual
Core3.3V

20R

20R
U11
FOO

104
BA5888FP

1
RF5V Core3.3V
FOO R44 3.9k 1 28 + CE18
VINFC STBY STBY

8
7
6
5

C81
47uF/10V
R45 0R COMPAD TRO
2 CFCERR1 BIAS 27

R42

R43
RN1 C82

2
10k 470p C84 220p 3 26 R46 3.9K
CFCERR2 VINTK TRO
R39 R54

3
10K N/A 47K R47 33R VC2 R48 12k 4 25 R49 0R
COMPAD VINSL+ CTKERR1
SW1 C85 C86 Q1 R50 0R

1
2
3
4
1 CDLD
CN2 IN/OUT R51 39k C87 220p DMO 2SB1132
SLO 5 VINSL- CTKERR2 24
12 SLED+ SW3 C90 470p 104 470p
SW4

472

104
SLED- R52 3.9K L1 C91

2
11 6 VOSL VINLD 23 DMO
10 R53 33k 10uH 102
LIMIT SLO
9 7 22 C92
VNFFC PREGND 104 LD-CD

C88
13 8 LOAD+

C89

2
7 LOAD- RF5V S5V
6 SPIN+ S5V
14 5 SPIN- 8 21 D5
VCC PVCC2 LL4148
4 SW3
3 C95 9 20
IN/OUT PVCC1 VNFTK
R56 104

1
2 SW1
1 DGND 10K 10 19 C93 104
SW4 PGND PGND
R63
4.7K Q4 SLED- 11 18 SPIN-
CON12_1.0MM_FPC 8050 VOSL- VOLD- RF5V

2
SPIN+
E
C R55 SLED+ 12 17
B1 4.7K VOSL+ VOLD+
1 CD/DVD
R59 2R 1% R60 2R 1%
B
FOCUS- 13 VOFC- VOTK- 16 TRACK-

104

20R

20R
C E

1
R58 1K Q3 R57
2

3
14 15

GND
GND
DVD_HF FOCUS+ VOFC+ VOTK+ TRACK+
8550 4.7K + CE19

C109
47uF/10V
C94

29
30
102

R61

R62

2
DGND

3
Q6 1 R65 3k
DVDLD
2SB1132

VC_OPU L2 C99

2
CN1 10uH 102
24 TRACK+ LD-DVD
3300p

3300p
23 TRACK-

2
10K

10K
22 FOCUS-
21 FOCUS+
20 D6
DVD_PD
19 Important for playability RF5V LL4148
DVD_HF
18 R71 100R
U12
C113

C114
R75

R76

1
17
16 AML3501 RF5V
LD-DVD
15 LD-CD
14 R41 100R RFS C100 105 SIGO 1 48 C101 153
RFAC BYP C102 104
13 2 VPA DIN 47
25 12 >= 130p C103 180p AIP 3 46 C104 104
CD_PD DVDRFP AIP DIP RF5V
26 11 AIN 4 45
AIN FNP FNP
100p

683

10 C105 680p 5 44
DVDRFP A2 FNN FNN
9 C106 680p 6 43
C/c B2 VNA
8 C108 680p 7 42 R72 12K 1%
B/b C2 RX
C107
C97

7 C111 680p 8 41 R73 1M

A/a D2 SDEN SDEN
6 C112 100p 9 40 R74
D/d CP SDATA SDA
5 10 39 4.7K N/A
E/e_out CN SCLK SCK
4 F/f_out OPU5V D/d 11 D V33 38 RF3.3V

8
3 C/c 12 37 R78 R79
OPU5V C MNTR FE_raw SPIN-
2 B/b 13 36 R77 1K 10K 1.5K 3
VC_OPU B FE TE_raw FE +
1 A/a 14 35 R92 2K 1
A TE TE EMF_RAW
1

SPIN+
104
102

F/f_out R80 1.2K F/f 15 34 R82 10K 2

E/e CD-F PI PI -
100uF/10V

+ E/e_out R83 1.2K 16 33 U13A

CD-E V165 COMPAD
CON24_0.5MM 17 32 LM358
VPB PIO
C110
C96

CE21

C117 223 R84 R85

4
VC_OPU 18 VC MIN 31
C118 102 22K 22K
2

19 VNB MLPF 30 RF5V

20 29 C119 102
DVDLD DVDLD DB
21 28 C120 332
CDLD CDLD MB
22 27 C121 683
DVD_PD DVDPD MP
23 26 R87 2K
CD_PD CDPD DFT DFCT
LDON 24 25 R86
LDON MIRR MIRROR

220p

390p

180p
104
1.5K

C134

C115

C129

C116
U6
S5V BA6287F S5V
Io(max)=1A RF5V

LOAD+ 1 8
OUT1 GND LOAD-
2 VM OUT2 7
3 6 U13B
VCC Vref

8
4 5 LM358 VC_OPU
TCLOSE Fin Rin TOPEN
R89 5.1K 5
COMPAD +
TE TEIN COMPAD 7
R90 27K 6 -
DGND

4
VC_OPU
RF5V RF3.3V C127 223 R93 47K R91 6.8K
RF3.3V
RF5V
S5V
C130
1

R95 C136 104

S5V
1

C128 C131 C132 + CE53 C133 + CE22 C135 + CE24 47K 223
+
CE20 104 104 104 100uF/10V 104 47uF/10V 104 100uF/10V Title
100uF/10V Motor Driver and RF-preamp 080131
2

R96 4.7K
2

C/c CE
C122 C123 C124 C125 C126 Size Document Number Rev
104 104 104 104 104 DGND A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 10 of 30

Page 65 of 89
 1

harman/kardon HS 350/650DL Service Manual

JP1
VIDEO5V U15 DSW-30
BH7868FS
D

VIDEO5V
As close as possible to the U15. Y_OUT 4
D

Y
C190 1 32 C137 104 R102 75R 1% FB37 1 2 50R C_OUT 3 ENTRY SIDE
R/Cr/Pr Vcc1 COUT C
103
R103 R104 2 31 1
75R 1% 75R 1% S1 S-DC OUT GND 5 4
2 GND 3 2
CE28 1 2 100uF/6.3V R97 75R 1% FB35 1 2 50R ESD1 ESD2

+
3 S2 CVOUT 30 5 GND
C167 104 6
C249 CE25 1 GND
2 22uF/6.3V R100 75R 1%

+
4 CIN CVOUT SAG 29 7 GND
104
V_COMP
5 MUTE1 GND 28
R98 R99
75R 1% 75R 1% CE29 1 2 100uF/6.3V R101 75R 1% FB36 1 2 50R

+
6 CVIN YOUT 27
C138 104 JP2
CE26 1 2 22uF/6.3V AV4-8.4-13/PB

+
7 SEL(CV/MIX) YOUT SAG 26
2 1 CE41 RCA-4
1uF/10V
+

G/Y/Y 8 YIN GND 25

R107 R108
BH7868FS 3 1
1 CE40 CE30 1 2 100uF/6.3V

+
2 9 BIAS Py/G OUT 24 6
75R 1% 75R 1% 22uF/10V C160 104 PY_OUT
+

CE27 1 2 22uF/6.3V R106 75R 1% FB39 1 2 50R

+
10 SEL(BIAS/CLAMP) Py/G OUT SAG 23 5
PB_OUT
2 1 CE42 11 Py/G IN GND 22
1uF/10V CVBS_OUT 4 2
+

CE31 1 2 100uF/6.3V

+
12 GND Pb/B OUT 21
C161 104 PR_OUT
1 CE57 CE59 1 2 22uF/6.3V R105 75R 1% FB38 1 2 50R

+
B/Cb/Pb 2 13 Pb/B IN Pb/B OUT SAG 20
1uF/10V

1
+

C R110 R111 14 19 C

75R 1% 75R 1% MUTE2 GND C139 C141 C140 C142

1 CE58 CE32 1 2 100uF/6.3V 20p 20p 20p 20p

+
2 15 Pr/R IN Pr/R OUT 18
1uF/10V C162 104
+

CE60 1 2 22uF/6.3V R109 75R 1% FB40 1 2 50R

+
16 Vcc2 Pr/R OUT SAG 17

R114 75R 1%

R116 75R 1%
VIDEO5V
R117 75R 1%
CVBS
1

C144 104
C143 104

+
CE33
R go to CN9
330uF/10V RGB: pin10=2.15V
B
CVBS: pin10=0V VIDEO5V -12V
2

G
US version, the -12V
RGB_SWITCH should R112 R113
2K 15K
be set to H=1 for ever. 2
C
R115 1B Q7
2K
E
8050
Not use for
2

R118 C
3

1B
HS650DL Version.
4.7K Q8
B
RGB_SWITCH
8050 Macrovision B

E control
3

C145 circuit. FB3 no need for HS650DL

104

DGND

H1
HS650-PT02

A
Only for HS650DL Version, A

close to JP1 connector.

2
1

Title
VIDEO OUTPUT 080131

Size Document Number Rev

A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 11 of 30

1

Page 66 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

USB5V
Only for HS650DL H2
HS650-PT02

Version, close to
D
C146 C147 JP6 connector. D

2
1
3
6.8p 6.8p
U17 1 2
TDOTG242LP
11 Y2
INT 6.00MHz
RESET_N 47 /Reset OSC2 64
30 63 R120 100R
USB_CS /CS OSC1
12 60 R121 100R
M2_WE_N /WR CLKw

1
EOE_N 13 /RD
46 + CE34
VBUS R122 10k C148 220uF/10V
M2_DQM0 27 A12 ENVREG 41 USB3.3V
M2_A11 26 38 VBP R123 10k 104
A11 VBP

7
8
M2_A10

2
25 A10 /EXVBO 37
M2_A9 24

GND
GND
M2_A8 A9 JP6
23 A8 ID 40 4 +5V
M2_A7 22 34 R124 33R DM1 3 USB-A-05
M2_A6 A7 DM1 R125 33R DP1 D-
20 A6 DP1 33 1 D+
M2_A5 19 32 R126 33R 2

GND
GND
M2_A4 A5 DM2 R127 33R GND
18 A4 DP2 31
M2_A3 17 39 PO_n
M2_A2 A3 /PO OC_n
16 A2 /OC 36
M2_A1

5
6
14 A1
42 R128 R129
M2_D15 VREGOUT 10K 10K
M2_A[0..11] 9 D15 VDD2.5 62
M2_D14 8 53
M2_D13 D14 VDD2.5
7 D13 VDD2.5 29
M2_D12 6 10
M2_D11 D12 VDD2.5 USB2.5V
4 D11
C M2_D10 3 45 C
M2_D9 D10 VDD3.3 USB3.3V DM2
2 D9 VDD3.3 43 DM2
M2_D8 1 35 DP2
M2_D7 D8 VDD3.3 DP2
59 D7 VDDw 55
M2_D6 58 21
M2_D5 D6 VDDw
57 D5 VDDw 5
M2_D4 56
M2_D3 D4
52 D3 Vss 54
M2_D2 51 28 U16
M2_D1 D2 Vss RCLAMP0514M
50 D1 Vss 15
M2_D0 49 DP1 1 10 DP1
D0 DM1 Line1 NC1 DM1
AVss 61 2 NC2 Line2 9
M2_D[0..15] 48 TEST AVss 44 3 VCC GND 8
4 Line3 NC3 7
R130 5 6
100R NC4 Line4
USB3.3V USB2.5V

USB3.3V

1
+ CE35 + CE36
100uF/10V 100uF/10V

2
ESD protection for USB port C150 C151 C152 C153 C154
104 104 104 104 104
C155 C156 C157 C158 C159
104 104 104 104 104

B B

JP4
CKX-3.5-22
Q10 3
8550
R167 390R

C
3 2 2

E
1

B
5VON R168 IR SIGNAL OUTPUT
D7 4.7K

1
LL4148
1 2 R169 4.7M N/A
5VON
JP5

1
U27 CKX-3.5-22
R171 R172 + CE50 R170 3 2 3
10K 10K 47uF/10V 4.7K
4 1 R173 270R 2

2
1
IR_IN
PC817 IR SIGNAL INPUT

A A

Title
USB and IR In/Out 070725

Size Document Number Rev

A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 12 of 30

5 4 3 2 1

Page 67 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

VCC1.8

VCC1.8
D D

HD_D_DE
U21 HD3.3V3
HD_D_[0..23] SiI9030CTU <112MHz R141=475R 1%
HD_D_[0..23]
>112MHz R141=422R 1%
80 24 R141 475R 1%
RN6 33R DE EXT_SWING
HD_D_0 FB42 1 2 50R
NOTE: HD_D_1
4
3
5
6
79
78
D0
D1
CVCC18
CVCC18
4
16

1
HD_D_2 2 7 77 45 C170 C171 C172 C173 C174 C197 C198 CE43
AML3278: HD_D_3 1 8 RN7 33R 76
D2
D3
CVCC18
CVCC18 59 + 22UF/10V
HD_D_4 4 5 75 74 104 104 104 104 104 105 105
R[0..7]=HD_D_[16..23]; HD_D_5
HD_D_6
3 6 70
D4
D5
CVCC18

2
2 7 69 73
G[0..7]=HD_D_[8..15]; HD_D_7 1 8 68
D6
D7
SiI9030CTU CGND
CGND 60
RN8 33R 46
CGND
B[0..7]=HD_D_[0..7]; HD_D_8
HD_D_9
4
3
5
6
67
65
D8 CGND 15
3
D9 CGND
SIL9030: HD_D_10 2 7 64 D10
HD3.3V2 FB43 1 2 50R HDMI3.3V

1
HD_D_11 1 8 RN9 33R 63 13
HD_D_12 D11 IOVCC C175 C176 C177 C195 C196 + CE44 C178
R[0..7]=D[16..23]; HD_D_13
4
3
5
6
62
61
D12
D13
IOVCC
IOVCC
48
71
HD_D_14 2 7 58 104 104 104 105 105 22uF/10V 104
G[0..7]=D[8..15]; HD_D_15 D14

2
1 8 57 D15 IOGND 14
RN10 33R 47
B[0..7]=D[0..7]. HD_D_16
HD_D_17
4 5 56 D16
IOGND
IOGND 72 HD3.3V3
FB44 1
3 6 55 D17 2 50R HDMI3.3V

1
HD_D_18 2 7 54 28
C HD_D_19 RN11 33R D18 AVCC C180 C181 C194 + CE45 C179 <112MHz RC = N/A C
1 8 53 D19 AVCC 34
HD_D_20 4 5 52 >112MHz RC = install, ESD/EMI
HD_D_21 D20 104 104 105 22uF/10V 104
3 6 51 D21 AGND 37 components N/A for they may cause
HD_D_22

2
2 7 50 D22 AGND 31 signal integrity problems on the high
HD_D_23 1 8 49 25 FB45 1 2 50R HDMI3.3V
D23 AGND

1
speed TMDS lines, TMDS lines should
R142 33R IDCK 66 23 C182 C199 + CE46 C183 be connected directly from SiI9030 to
HD_CK IDCK PVCC1
R145 33R 2 connecter.
HD_D_VS VSYNC
R146 33R 1 22 104 105 10uF/10V 104
HD_D_HS HSYNC PGND1 HD3.3V1
R147 33R FB46 1 2 50R

12
ASCLK
ALRCK R149 33R 12 38
R2 33R SCK PVCC2 C184 C0 + CE47 JP3
ADATA3 11 WS
ADATA0 R1 33R N/A 39
R150 33R PGND2 104 105 10uF/10V
AMCLK 10 SD0 SHELL2 21
R151 33R L3 1 TX2+

2
SPDIF 9 SD1 TX2+ 36 4 1 D2+ 23 23
R153 33R 8 35 ACM2012-900-2P-T 2
CLOCK/SCL R155 33R SD2 TX2- TX2- D2 Shield
DATA/SDA 7 SD3 2 3 3 D2-
33 L4 1 4 TX1+ 4
HDMI3.3V TX1+ ACM2012-900-2P-T D1+
6 MCLK TX1- 32 5 D1 Shield
5 2 3 TX1- 6
SPDIF L5 1 TX0+ D1-
HDMI3.3V TX0+ 30 4 7 D0+
RST 42 29 ACM2012-900-2P-T 8
RESET# TX0- TX0- D0 Shield
41 CI2CA 2 3 9 D0-
R143 R144 43 27 L6 1 4 TXC+ 10
10K 10K IDCK CSCL TXC+ ACM2012-900-2P-T CK+
44 CSDA TXC- 26 11 CK Shield
17 2 3 TXC- 12
INT R156 10R TX_DDC_SCL CK-
DSCL 20 13 CE Remote
C192 HD3.3V2 R157 4.7K N/A 40 19 R158 10R TX_DDC_SDA 14
NC DSDA NC
2

D 3.3p HD3.3V1 R159 4.7K N/A 21 DDC_SCL 15

B RSVDL HPD DDC_SDA DDC CLK B
HPD 18 16 DDC DATA
HD_RESET 1G MQ1 17 GND
S 2SK3018 R162 R163 18
HD5V +5V
4.7K 4.7K
3

19 HP DET 22 22
R165 20
47K HDMI3.3V SHELL1
H5V PTC1 HD5V HD5V
t

JK-MSMD050 0.5A HD5V

H5V
HDMI connector, TYCO: 1827059-3 or Freeport: 51U019S-301N-A2-B
1

R186 R185 U19

+ 4.7K 4.7K UPA672T R160 R161
CE48 C185 1.8K 1.8K
100uF/10V 104 1
2

2 6
4

5 3

U24 U25 U26

RCLAMP0514M RCLAMP0514M RCLAMP0514M
TX0+ 1 10 TX0+ TX2+ 1 10 TX2+ DDC_SCL 1 10 DDC_SCL
TX0- Line1 NC1 TX0- TX2- Line1 NC1 TX2- DDC_SDA Line1 NC1 DDC_SDA
2 NC2 Line2 9 2 NC2 Line2 9 2 NC2 Line2 9
A 3 VCC GND 8 3 VCC GND 8 3 VCC GND 8 A
TXC+ 4 7 TXC+ TX1+ 4 7 TX1+ HPD 4 7 HPD
TXC- Line3 NC3 TXC- TX1- Line3 NC3 TX1- Line3 NC3
5 NC4 Line4 6 5 NC4 Line4 6 5 NC4 Line4 6

Title
ESD protection for HDMI port HDMI 070725

Size Document Number Rev

A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 13 of 30

5 4 3 2 1

Page 68 of 89
 5 4 3 2 1
FB201
harman/kardon SDA2
HS 350/650DL Service Manual 50R
DSP_3.3V 1 2
SCL2 DC_3.3V
CLOCK/SCL

1
DATA/SDA
+ CE205
S1DATA0
DSP_1.2V 220uF/10V
S1DATA1
U205
S1DATA2

6
R240 0R N/A R220 TPS3106K33DBVR N/A R226

2
ADATA0 U204
R241 0R N/A 10k N/A 10k N/A

VDD
ADATA1 BA00HC5FP
ADATA2
DSP_1.2V 3 1
S2DATA2 MR RSTVDD

NC&FIN
S2DATA1 5 VCC VO 4

0R
0R

0R
0R
2 4 5 RESET_N_DSP R227 0R
S2DATA0 PVCC SENSE RSTSENSE RESET_N_AML

ADJ
D ASCLK D
+

GND
ALRCK
CE201 C204 R221 C206
SCLK_OUT1

R219
R215

R239
R238
47uF/10V 105 100R

3
1
AMCLK
105 R222

2
LRCK_OUT1
DSP_SCL 10k N/A

2
0R N/A
MCLK_OUT
DSP_MUTE
DSP_MUTE

150R
0R
0R

0R
0R
0R
0R

0R

N/A
ASIC_INT DSP_3.3V R235
ASIC_INT ASIC_LINK 200R
ASIC_LINK
TEST POINT

3.3k
3.3k
3.3k
U203

R229
R223
R208
R225
R205
R224
R207

R206

R233

R234
TP231 SDA2 EXTAE1 R202 0R EXTAEN IS42S16400B-7TL

DSP_MUTE
TP230 SCL2 EXTAE0 R203 0R N/A EM_A[11..0] EM_D[15..0]

ASIC_LINK
4Banks*1M*16Bit SDRAM

ASIC_INT

S1DATA2
S1DATA1

S1DATA0
TP229 DSP_MUTE DSP_3.3V

DSP_SDA
EXTAE1
DSP_MUTE
TP228 ASIC_INT

R232
R210
R209
TP227 ASIC_LINK DSP_1.2V EM_A0 23 2 EM_D0
DSP_3.3V EM_A1 A0 DQ0 EM_D1
24 A1 DQ1 4
TP225 SCLK_OUT2 R204 EM_A2 25 5 EM_D2
TP224 LRCK_OUT2 EM_A3 A2 DQ2 EM_D3
2.2k 26 A3 DQ3 7
TP223 S2DATA2 U201 U206 EM_A4 29 8 EM_D4
TP215 S2DATA1 TMS320DA708 SN74LVC823APW EM_A5 A4 DQ4 EM_D5
30 A5 DQ5 10
TP204 S2DATA0 1 24 EM_A6 31 11 EM_D6
OE VCC A6 DQ6
145

144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
TP214 ADATA2 EM_A0 2 23 EXTA12 EM_A7 32 13 EM_D7
TP219 S1DATA2 EM_A1 1D 1Q EXTA13 EM_A8 A7 DQ7 EM_D8
3 2D 2Q 22 33 A8 DQ8 42
TP206 ADATA1 EM_A2 4 21 EXTA14 EM_A9 34 44 EM_D9
POWERPAD

AXR0[9]/AXR1[4]/SPI1_SIMO

SPI0_SIMO
VSS

DVDD

CVDD

CVDD

DVDD
AXR0[15]/AXR2[0]
AXR0[14]/AXR2[1]

AXR0[13]/AXR1[0]
AXR0[12]/AXR1[1]
VSS

AXR0[11]/AXR1[2]
AXR0[10]/AXR1[3]
VSS

VSS
CVDD
AXR0[7]/SPI1_CLK

DVDD

VSS
AFSX0

AFSR0

AXR0[4]
VSS
AXR0[3]
AXR0[2]
AXR0[1]
VSS
AXR0[0]
AHCLKR0/AHCLKR1
ACLKX0

ACLKR0

AXR0[8]/AXR1[5]/SPI1_SOMI

AXR0[6]/SPI1_ENA
AXR0[5]/SPI1_SCS

SPI0_SOMI/I2C0_SDA
TP203 S1DATA1 EM_A3 3D 3Q EXTA15 EM_A10 A9 DQ9 EM_D10
5 4D 4Q 20 22 A10/AP DQ10 45
TP217 ADATA0 DSP_3.3V DSP_1.2V DSP_3.3V EM_A4 6 19 EXTA16 EM_A11 35 47 EM_D11
TP210 S1DATA0 EM_A5 5D 5Q EXTA17 EM_BA0 A11 DQ11 EM_D12
7 6D 6Q 18 20 BA0/A13 DQ12 48
C TP207 SCLK_OUT1 EM_A6 8 17 EXTA18 EM_BA1 21 50 EM_D13 C
TP208 ASCLK DSP_1.2V EM_A7 7D 7Q EXTA19 BA1/A12 DQ13 EM_D14
9 8D 8Q 16 DQ14 51
TP205 LRCK_OUT1 EM_A8 10 15 R211 EM_CLK 38 53 EM_D15
TP211 ALRCK RESET_N_DSP 9D 9Q 33R EXTAEN EM_CKE CLK DQ15
1 VSS SPI0_CLK/I2C0_SCL 108 11 CLR CLKEN 14 37 CKE
TP209 MCLK_OUT 2 107 12 13 DSP_3.3V
TP216 AMCLK EXTAE0 AHCLKX0/AHCLKX2 SPI0_SCS/I2C1_SCL GND CLK EM_CS2_N EM_CS0_N
3 AMUTE0 VSS 106 19 CS VCC 1
TP220 RESET_N_DSP 4 105 EM_RAS_N 18 14
TP213 DSP_3.3V AMUTE1 SPI0_ENA/I2C1_SDA EM_OE_N EM_CAS_N RAS VCC
5 AHCLKX1 EM_OE 104 17 CAS VCC 27
TP222 DSP_1.2V 6 103 EM_WE_N 16
TP218 CLOCK/SCL VSS DVDD WE
7 ACLKX1 EM_RW 102 VCCQ 3
TP212 DATA/SDA 8 101 EM_WE_DQM0_N 15 9
TP221 DGND CVDD CVDD EM_CS2_N EM_WE_DQM1_N 39 DQML VCCQ
9 ACLKR1 EM_CS[2] 100 DQMH VCCQ 43
10 DVDD VSS 99 VCCQ 49
11 98 EM_RAS_N 36
AFSX1 EM_RAS EM_CS0_N NC1
12 AFSR1 EM_CS[0] 97 40 NC2 VSSQ 6
13 96 EM_BA0 12
RESET_N_DSP VSS EM_BA[0] EM_A[11..0] VSSQ
14 RESET VSS 95 54 VSS VSSQ 46
R230 0R 15 94 EM_BA1 41 52
SCLK_OUT2 VSS EM_BA[1] VSS VSSQ
R231 0R 16 93 EM_A10 28
LRCK_OUT2
27MCLK2
R228 0R CLKIN 17
CVDD
CLKIN
TMS320DA708 EM_A[10]
DVDD 92
VSS
18 91 EM_A0
DSP_TMS VSS EM_A[0]
19 TMS CVDD 90
20 89 EM_A1
DSP_TRST_N CVDD EM_A[1] EM_A2
21 TRST EM_A[2] 88
22 87 U202
OSCVSS VSS EM_A3 S29AL016D70TFI020 OR KH29LV160CBTC-70G
23 OSCIN EM_A[3] 86
EM_A[11..0] EM_D[15..0]
FB200
24
25
OSCOUT CVDD 85
84 EM_A4 2M*8Bit Flash, Bottom Boot
DSP_3.3V 50R OSCVDD EM_A[4] EM_A5
26 VSS EM_A[5] 83
B B
2 1 27 82 EM_BA1 25 29 EM_D0
PLLHV VSS A0 DQ0
1

DSP_TDI 28 81 EM_A0 24 31 EM_D1

TDI DVDD A1 DQ1
CE202
47uF/10V

+ DSP_TDO 29 80 EM_A6 EM_A1 23 33 EM_D2

TDO EM_A[6] A2 DQ2
C203
104

30 79 EM_A7 EM_A2 22 35 EM_D3

VSS EM_A[7] EM_A3 A3 DQ3 EM_D4
31 DVDD VSS 78 21 A4 DQ4 38
EMU0_N EM_A4 EM_D5
2

32 EMU[0] CVDD 77 20 A5 DQ5 40

33 76 EM_A8 EM_A5 19 42 EM_D6
DSP_3.3V EMU1_N CVDD EM_A[8] EM_A9 EM_A6 A6 DQ6 EM_D7
34 EMU[1] EM_A[9] 75 18 A7 DQ7 44
DSP_TCK EM_A11 EM_A7
4.7k N/A
4.7k N/A

35 TCK EM_A[11] 74 8 A8 DQ8 30

36 73 EM_A8 7 32
VSS DVDD EM_A9 A9 DQ9
6 34
EM_WE_DQM[0]

EM_WE_DQM[1]

EM_A10 A10 DQ10

Only for JTAG EM_A11
5
4
A11 DQ11 36
39
A12 DQ12
R217
R216

EXTA12 3 41
EM_D[15]
EM_D[14]

EM_D[13]
EM_D[12]

EM_D[11]

EM_D[10]

A13 DQ13
EM_CAS

EM_CKE
EM_CLK
EM_D[7]

EM_D[6]

EM_D[5]
EM_D[4]

EM_D[3]
EM_D[2]

EM_D[1]
EM_D[0]

EM_D[9]

EM_D[8]

CN201 EXTA13
EM_WE

2 A14 DQ14 43
DVDD

CVDD

DVDD

CVDD

CVDD

DVDD

CVDD

DVDD

DA708 JTAG N/A EXTA14 1 45 EM_BA0

VSS

VSS

VSS

VSS

VSS

VSS

DSP_TMS DSP_TRST_N EXTA15 A15 DQ15/A-1

DSP_TDI
1
3
2
4
16M bits FLASH equivalent: EXTA16
48
17
A16
A17
5 6 1. KH29LV160CBTC-70G EXTA17 16
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72

DSP_TDO R218 EXTA18 A18 EXTA19

7 8 9 A19 NC 10
DSP_TCK 9 10 1k N/A DSP_1.2V DSP_3.3V 2. S29AL016M90TFI02 NC 13
11 12 14
EMU0_N 13 14 3. S29AL016D70TFI020 EM_CS2_N 26 CE
NC
RY/BY 15
EM_CKE EM_OE_N 28
4. AM29LV160DB-90EC
EM_D15
EM_D14

EM_D13
EM_D12

EM_D11

EM_D10

OE
EM_D0

EMU1_N
EM_D7

EM_D6

EM_D5
EM_D4

EM_D3
EM_D2

EM_D1

EM_D9

EM_D8

EM_CAS_N R201 EM_CLK

EM_WE_N
EM_WE_DQM0_N
33R EM_WE_DQM1_N
5. MBM29LV160BE-70P EM_WE_N
RESET_N_DSP
11
12
WE VCC 37 DSP_3.3V
DSP_1.2V EM_D[15..0] C201 RST
GND1 46
A
Place close to U201 6.8p N/A 47 27 A
BYTE GND2
1

+ CE203 C230 C231 C232 C233 C234 C235 C236 C237 C238 C239 C240 C241 C242 C243 C244
DSP_3.3V 100uF/10V 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 DSP_3.3V
2

Place close to U201 Place close to U202 and U203

1

+ CE204 C210 C211 C212 C213 C214 C215 C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 C226 C227 C228 C229 C202 C207 C208 C209 C245 C246 C247 C248 Title
HS350 HS650 DSP 070727
100uF/10V 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104 104
Size Document Number Rev
2

DGND A3 5112C 1.4

Date: Thursday, January 31, 2008 Sheet 14 of 30

5 4 3 2 1

Page 69 of 89
harman/kardon HS 350/650DL Service Manual

R361 CE300 JP301

47k 10UF/16V SCART CS101 with Shield

22
+
SCART_IN_R 1 2

NC
CN301
SCART_IN_L 24 GND
1 R R367
1 DGND B 100k
2 2 1 AOR
3 G
3 DGND G
4 4 2 AIR
5 B
5 DGND R ESD300
6 6 3 AOL
7 CVBS
7 RGB_SWITCH CVBS R369
8 8 4 AGND
9 TVFORMAT0 100k
9 TVFORMAT1 D+12V R362 CE301 ESD301
10 10 5 BGND
11 47k 10UF/16V
11 RDS_DAT D+12V

+
12 12 1 2 6 AIL
13 R383 R306
13 RDS_SCK
14 2K 2K FB301 7
14 50R FB300 B
15 15 5VON
16 1 2 50R ESD302 8
16 -12V SWTCH

SCART CONNECTOR
17 17 TUNER_CE 1 2

BACK PANEL VIEW

2
C Q300
18 18 9 GGND
19 4.7K DTC343TK SWITCH
19 TUNER_DO FB302
20 20 10 CLKOUT
R310 B E 50R

3
TVFORMAT1 3.3K C300 1 2 G_OUT 11
D R308 20p G
CON20_1.0MM_DIP_2 1K ESD303 12
R313 C301 DATA
3.3K 104 13 RGND

2
C FB303 14
4.7K 50R DATAGND
CN302 Q301 R_OUT
1 2 15 R//C
20 R315 B E DTC343TK

3
20 TVFORMAT0 3.3K ESD304
19 19 SPDIF_IN 16 BLNK
18 18
17 17 RESET_N 17 VGND
16 R316 C302
16 COAXIAL_OUT
15 3.3K 104 FB305 18
15 50R BLNKGND
14

Not use for

14 CLOCK/SCL
13 A+5V 1 2 CVBS_OUT 19
13 DATA/SDA VOUT//Y
12 12
11 ESD305 20
11 ADATA_IN VIN
10
10
9
8
9
8
HW_MUTE
HW_MUTE_2
HS650DL R384
300R
R314
300R
FB304
21 SHIELD

NC
7 7 ADATA3 25 GND

Version.
6 50R
6 BLNK
5 5 AMCLK 1 2

23
4 4

2
C Q302
3 3 ASCLK
2 4.7K DTC343TK
2 ALRCK
1 C303
1 B E 20p
1

3
DGND R317
E RGB_SWITCH 3.3K RGB TV TV
CON20_1.0MM_DIP_2 SWITCH FORMAT0 FORMAT1 TV FUNCTION PIN8(V) PIN16(V)

C304
104 X 0 1 SCART Inactive (Standby) 0V X
X 0 0 SCART Active Auto Switch to 4:3 Aspect Ratio 12V X
X 1 0 SCART Active Auto Switch to 16:9 Aspect Ratio 6V X
0 X X RGB X 1-3V
1 X X CVBS X 0-0.4V
CN303
18
18
17 17
+15V
Scart video output and audio input,
16
16
15 15
14
+5.7V
only for EU version.
14 -15V
13 A+5V
13
12 12 15VON A+5V
11 11 FPMCU_MUTE
10 10 MIC_IN
9 9
8 R300
8 HP_R MUTE_LR
7 4.7K
7 MUTE_HP
D300 R363
6
5
6
5
HP_L Mute logic circuit LL4148 R301 Mute logic circuit 10K
4 2 1 10K
4
3 3
iPod_Check
iPod_Rx
for main L&R D-12V
for headphone D-12V
2

2
2 C C
2 analog output and subwoofer
2

1 1 iPod_Tx 1B Q303 C 1B Q305

R302 8050 1B Q304 D303 LL4148 8550
10K E 8550 FPMCU_MUTE 2 1 E
F E
3

3
DAC_MUTE
CON18_1.25MM_DIP_2 DGND D304 LL4148
3

D301 HW_MUTE +5VON

2 1
FPMCU_MUTE 2 1 LL4148 R365 R364
D305 LL4148 10K 3.3K
HW_MUTE +5VON HW_MUTE_2
2 1 LL4148 2 1
R303 R304
H301 D302 10K 2.2K
HS650-PT02

Only for Title

HS650DL SCART and MUTE Logic 070725

2
1

Size Document Number Rev

Version.
A3 5113C 1.6

Date: Wednesday, April 02, 2008 Sheet 15 of 30

Page 70 of 89
 harman/kardon HS 350/650DL Service Manual
ADATA3
close to DVDD close to HVDD close to AVDD2 close to AVDD1
CLOCK/SCL
DATA/SDA
DVDD A+5V A+5V A+5V D-12V D+12V
RESET_N
A+5V D-12V D+12V
R385 0R
AMCLK
SPDIF_IN

1
A+5V CE316 + C316 C324 CE322 + CE343 + CE318 + C320 CE320 + C322 CE313 C312 CE314 + C313
100UF/10V 470UF/10V 10UF/10V
+
C326 10UF/10V 104 104 47UF/25V 104 47UF/25V 104
47p 104 104 10UF/10V

2
FB307
50R
DVDD
CE311 2 220UF/16V

+
1 HP_R
CE309 2 220UF/16V

+
1 HP_L
U301
AK4683EQ

17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32

2
R339 C C
10K R334 R335 Q306 4.7K 4.7K Q307

MCKO

XTO

CSN
TVDD
DVSS
DVDD
XTI

TX

PDN
CDTI
CCLK

SDTIB
MCLK2

SDTIA1
SDTIA2
SDTIA3
A+5V 10K 10K DTC343TK DTC343TK
B E B E Analog audio output & input

3
R393 16 33 Red White
0R SDTOA HVDD
15 34
14
BICKA HVSS
35 Red White
ILRCKA HPR JP303
13 OLRCKA HPL 36 Red White
12 37 C327 105 AV8-8.4-13/PB
ADATA_IN SDTOB MUTET Orange Orange
11 38 R319 R320
ASCLK BICKB LOUT2
10 39 1.78k 1% CE303 680R
ALRCK LRCKB ROUT2 VOUTL C305 0805 102 NPO R321 TV_IN_R

+
9 CDTO LOUT1 40 1 2 1 2 11
8 41 C306 0805 100p NPO 330R
DAC_MUTE VOUT ROUT1 CE315 2 2.2UF/10V CE302 47UF/16V TV_IN_L

+
7 INT AK4683EQ VCOM 42 1 12

2
6 43 47UF/16V R322 R324 4.75k 1% R325 C
RX3 AVDD2 C315 104 10K R323 10K Q308 R_IN_1
5 RX2 AVSS2 44 4.7K 8
4 45 4.75K 1% DTC343TK
RX1 LISEL R355 18K R326 U302A B E L_IN_1
3 46 9

3
I2C LOPIN

4
2 47 7.50k 1% NJM2068M R327
R382 5.1R RX0 ROPIN R354 18K R329 680R DOWNMIX_R
A+5V 1 PVDD RISEL 48 2 - 5
1.78k 1% 1 R328

AVDD1
AVSS1
PVSS

Max input level≈2.8V. VOUTR 330R DOWNMIX_L

+
1 2 3 6
RIN6

RIN5

RIN4

RIN3

RIN2

RIN1
LIN6

LIN5

LIN4

LIN3

LIN2

LIN1
+

2
C307 C
R

CE307 0805 680p NPO 4.7K Q309 2

D+12V
47UF/16V R330 CE310 DTC343TK

8
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
R351, clock jitter, 10K R332 U302B B E

+
1 2 3

3
8
import, keep away 7.50k 1% NJM2068M DOWN UP
from digital 5 47UF/16V
A+5V + GND
7 R333
signals. 10K
6 -

10
R351 C311

7
4
1
12K 1% 0805 680p NPO
C310

4
0805 102 NPO D-12V
R336 JP306
4.75K 1% R337 4.75k 1% AV1-8.4-6G

C314 0805 100p NPO

2 SIG
MUTE_HP
MUTE_LR
1 GND
R347 47k CE306 TOP VIEW
2 10UF/16V

+
1
Orange RCA for coaxial output
R350 47k CE308 2 10UF/16V

+
SCART_IN_L 1 jack.
SCART_IN_R
R360 47k R345 47k CE304 2 10UF/16V

+
TUNER_IN_L 1
R359 47k
TUNER_IN_R
CE342 1 10UF/16V R358 47k R346 47k CE305 2 10UF/16V JP305
+

+
IPOD_IN_L 2 1
CE341 2 10UF/16V R357 47k VSR5G
+

IPOD_IN_R 1

100k

100k

100k

100k
CE340 1 R331 47k
+

MIC_IN 2
10UF/16V R344 47k 3 OUT
100k
100k
100k

INPUT
SPDIF
A+5V 2 GND
1 VCC

R377

R375

R373

R371
R352
4.7K
R305
3R001
3R002

4
5
6
U303B U303A R379 C325
74HCU04 74HCU04 560R 103
COAX_IN_1 4 3 2 1 COAXIAL_INPUT_2
U303C JP304
74HCU04 C319 VSR5G
6 5 R380 2.2K 103 ESD306
R381 47K C328 3 OUT

INPUT
SPDIF
R349 A+5V 104
DVDD 100K R378 2 GND
75R R348 1 VCC
U303D U303F U303E 3R003 4.7K
14

74HCU04 74HCU04 74HCU04 560R C357

COAX_IN_2 COAXIAL_INPUT_1 103

4
5
6
8 9 12 13 10 11

C356
3R004 2.2K 103 ESD312
7

3R005 47K C358

3R006 R340 104
100K 75R

OPTICAL_IN_1

OPTICAL_IN_2

COAXIAL_OUT 2 1 COAXIAL_OUTPUT
COAXIAL_OUT
R341 C317 R342 R343 FB306 C318 Title
220R 100p 150R 110R 50R 100p Audio Codec 080402

Size Document Number Rev

A3 5113C 1.6

Date: Wednesday, April 02, 2008 Sheet 16 of 30

Page 71 of 89
 harman/kardon HS 350/650DL Service Manual TUNER_VCC
TUNER_CE
DATA/SDA
CLOCK/SCL
TUNER_DO
ZZ301 C329
TUNER_IN_L

4
EJ219 104
TUNER_IN_R
R397 CN304

+
RDS_SCK 1 2 5 3
100R C335 R394 220R 1
RDS_DAT 1
CE326 2 183 R395 220R 2
C341 470p C339 22p 10uF/10V R392 R396 220R 2
3 3
3K 6 1 R398 220R 4
R386 4.7k R376 10k R388 4
5 5
47k 6 6

7
7 7
ZZ300 8 8

4
EJ219 9
U304A U313A R366 R391 C331 270p R390 10R RDS_MPX 9

+
1 2 5 3 10 10

4
NJM2068M NJM2068M 10k CE317 100R
iPod_Tx 11 11

4
- 2 1 2 IPOD_IN_L1 CE325 2 C334
iPod_Rx
2 R372 2.2k 1 10uF/10V R399 183 CON11_1.25MM_DIP_2

+
-
iPod_Check
1 + 3 3K 6 1
IPOD_IN_L + 3 R318 2.2k 1uF/50V go to Tuner Module
IPOD_IN_R
IPOD_12V C333

7
R309 2 Y300

8
CE345 IPOD_12V 47K CE330 33p 4.332M U305
IPOD_12V A_TRN PT2579-SN(L) JP302

+
1 2 1 2 3
C340 22p 9 8 23

+
IPOD_12V C342 470p 220UF/16V MODE SCOUT 23
10 TEST CIN 7 21 21
R374 10k 1uF/50V C330 1 11 6 C332 19
R387 4.7k DVSS AVSS 560p 19
12 DVDD AVDD 5
33p 13 4 R338 1
OSC1 MUXL 1
1

C359 223 14 3 549K Accessory_Identify 2

OSC2 VREF 2

1
+ U313B 15 2 +12VON 3
CE331 C343 U304B NJM2068M T57 RDDA + iPod_Tx 3
16 RDCL QUAL 1 4 4

4
47UF/25V 104 NJM2068M CE319 CE324 iPod_Rx 5 5
4

IPOD_IN_R1 2.2uF/10V Accessory_Detect

2

- 6 1 2 6 6
R370 2.2k

2
6 7 7

+
-
R368 7
7 + 5 8 8
+ 5 R307 2.2k 10k 1uF/50V R389 ESD308 ESD307 9
4.7K 9
10

TOP VIEW
10

8
RDS5V 11 11
8

12 12
13 13
IPOD_12V 14
IPOD_12V 14
15 15
16 16
A+5V ESD309 ESD310 17 17
18 18

1
20 20
U306 22
KA78R05CTSTU U307 D306 22
24 24
1 2 KA79L12AZ LL4148
+5.7V Vin Vout A+5V
2 3 DA1R018H91E
GND

-15V -12V
Vdis

Vin Vout FB308 1 50R

12
2

GND
D-12V
1

104
104

104

iPod

104
104
+ CE336 + D307

2
CE337 220uF/10V CE333 LL4148
3

4
C348

C354

C321

+
470uF/10V CE338 100uF/25V

C346

C347
+
R353 4.7K 100uF/25V
2

+12VON
104

2
1
10K
R356

C353

U308 R312 R311

1
KA7812E 3K
12VON FB310 3K
15VON 1 Vin Vout 3 2 1 50R +12VON
+
iPod_Check CE321 C323

GND

1
100UF/16V

104
104
Q310 104

2
+ DTC114EUA

2
1

CE332 C
B

C344

C345
+ 2 220uF/25V 1 iPod_Check_IN
CE339

2
220uF/25V
E ESD311
2

FB311
50R

3
2 1 LOCATION-PAD
5VON +5VON
TP300 TP301 TP302

1 1 1

D+12V TUNER_VCC RDS5V

U312
TUNER_VCC
U311 78L05 U310
KA7809 KA7812E VIA300 VIA301 VIA302
1 3 3 1 1 3 FB312 2 1 50R VIA_PAD4.0 VIA_PAD4.0 VIA_PAD4.0
GND

D+12V Vin Vout IN OUT +15V Vin Vout IPOD_12V

FB313 2 1 50R 1 1 1
GND

GND

D+12V
2 2 2
1

3 3 3
1

104

104

+ + +
2

4 4 4
CE327 C336 C337 CE328 C338 CE329 + +
2

5 5 5
100uF/25V 104 104 100uF/16V 104 100uF/10V CE312 CE334 6 6 6
C349

C350

220uF/25V 220uF/25V
2

9
8
7

9
8
7

9
8
7
Title
Tuner and iPod Input 080402

Size Document Number Rev

A3 5113C 1.6

Date: Wednesday, April 02, 2008 Sheet 17 of 30

Page 72 of 89
 5 4 3 2 1

USB5V
harman/kardon HS 350/650DL Service Manual

7
8
CN601 USB5V VFD601
U602

47uF/16V
CON22_1.0MM_DIP_2 VFD33-1701I

GND
GND
RCIamp0514M
1 DM2 1 10 DM2
4
3
+5V CIG-VFD 14COLUMNS × 2LINES 5×7 DOT MATRIX
1 HP_R Line1 NC1 D-

1
DP2 DP2

104
2 2 9 1 1G 2G 3G
2 NC2 Line2 D+ +
3 3 8 2

GND
GND
3 HP_L VCC GND GND
4 4 4 Line3 NC3 7

C633

CE620
5 5 FPMCU_MUTE 5 NC4 Line4 6

2
6 6
4G 5G 6G 7G 8G 9G 10G 11G 12G 13G 14G 15G 16G 17G

5
6
7 7 DP2
8 8 DM2
9 JP601 A A A A A A A A A A A A A A ROW
D A 9
10 10
MIC_IN
USB-A-05 close to USB jack A D
11 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7
11 MIC_DETECT
12 12 HP_DETECT
13 R608 5VON 5VON
13 2K
14 14 IR_IN
15 FRONT_LED B B B B B B B B B B B B B B ROW
15 LED_CONTROL
16 16 B

300R
300R
300R
17 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7 5×7
17 IR

1
104
104
104
18 +
18 CE621 R655 + CE602
19

RESET
19 VFD_CS

VDISP
DGND
LGND
220uF/10V 4.7K 100uF/16V

TEST
20

OSC
VDD
20 DATA/SDA

R649
R650
R651

C635
C607
C608

DO
CS
CP
DA
2
21

F1
F1

F2
F2
21 CLOCK/SCL

2
22 22 MCU_OFF

10
11
CLOCK/SCL 12
DATA/SDA 13
14
15

48
49
1
2

5
6
7
8
9
+40v

22uF/10V
+3.3V

VFD_CS
AC_1 AC_2

RESET
CN602 R626 U610

+3.3V
+40V
CON14_1.25MM_DIP_2 1k KA78L12AMTF
+40V

1
STANDBY +15V

104
+12V C618 C623 N/A C626
1 1 1 STANDBY_1 3 Vin Vout 1
473 + 473
2 2

GND
1

1
2 C622 N/A C636
3 3 3 +5.7V

C628

CA601
+ + CE613 R637 104 100V
4 4 4 CE614 47uF/25V C639 6.2K C621 N/A

2
5 5 5 +5.7V
100uF/10V 104 +5.7V U604

2
G 6 6 6 C620 39P KA78R05CTSTU
2

2
7 7 7 USB5V
close to VDD of close to VDISP
8 8 8 +3.3V
1 Vin Vout 2 A+5V
9 9 9 2 1 VFD601

GND
USB5V

Vdis

100uF/10V
10
C 10 10 C619 2.2uF C
11 -15V
11 11 U611
12
12 12 13

1
104
KA79L12AZ D605 LL4148

4
13 13 +15V -15V
14 2 3 -12V R636 20K + +
14 14 5VON Vin Vout

GND

CE610
DC_GND

104
10K

C609
CE609 C638 R658

2
2

220uF/10V 104 4.7k

CE612 C642
1
+
CN604 47uF/25V 104

R662
C641
CON6_1.0MM_DIP_2
1

1 1 A+5V
2 2
J 3 3 VOL+
4 4 VOL-
5 5 LED_CONTROL
6 6
U608
K603 AZ1117H-3.3
HFD3-005 5VON 4 +3.3V
FSA2257MTCX Switch or Relay A+5V TAB
2 3 IN OUT 2

ADJ
HP_DETECT 3 configuration:

1
HP_L 4 MIC_DETECT=0, Headphone output

LL4148
HP_R R646 0R 7 +
MIC_DETECT=1, Mic input C640 CE611

1
6

15K
47uF/10V

4.7K
4.7K
5 104

2
8
1
2

B B
USB5V

D601

R602
R603
R604
2 1 MQ601
BSS123

1
MIC_DETECT R627 3.3k D604 LL4148 1

R645 10K JP602 U601

VOL+ EM78P156ELM-G
3

6
5 MCU_OFF R659 100R RA2 1 18
USB5V U606 FB601 IR RA3 P52 P51
2 1 10UH 4 R656 100R 2 P53 P50 17
FB602 1 50R
+

14 VCC 1A 1 1 2 2 2 3 TCC OSCI 16

13 2 CE615 220uF/10V N/A C603 2.2uF R605 470R 4 15
R620 2.2k 1S GND FB603 RESET OSCO Y601
12 1B1 1B0 3 3 5 VSS VDD 14
R619 11 4 2 1 7 IR_IN R657 100R RB0 6 13 4.000MHZ
10R VCC 2A 50R VOL- P60/INT P67
10 2S GND 5 2 3 8 7 P61 P66 12 2 1
9 6 9 FPMCU_MUTE R606 100R MUTE 8 11
C613 R621 2B1 2B0 MQ602 R607 100R P62 P65
8 NC NC 7 1 STANDBY_1 9 P63 P64 10
3
ESD601

ESD602

ESD603

104 1.5k N/A BSS123 N/A

5VON
C611 56p

C612 56p

CKX-3.5-12-9P
FSA2257MTCX N/A IR601 C604 C605
1

Need to confirm HL38B17 5VON 5VON 22P 22P

1
10uF/16V
R611 4.7K C606 + CE601
IR G VCC R612 4.7K
47uF/16V

104
4.7K
C615 150p C616 47p R613 4.7K 104

1
1
2
3

2
R628 10k R629 10k +
RA0
-12V
RB6

CE616
A U603A RB5 A

R601

C627
R630 R631 CE604

2
U603B RB4
4

-12V
100uF/10V

100R R632 1k 10uF/16V USB5V +12V

4

47uF/25V

47uF/25V

R633 1k - 2 2 1
104

104

1k
+

- 6 1
1

1
104

MIC_IN 7 + 3
2

+ 5 NJM2068M R634 + +
NJM2068M C617 100k Title
CE622
C643

470p
+
VFD and MCU 080130
8

C631

CE618

C632

CE619

R635
8

100R Size Document Number Rev

1

+12V A3 5115C 1.3

close to U606 close to U603 close to U603
Date: Thursday, January 31, 2008 Sheet 24 of 30

5 4 3 2 1

Page 73 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

VIA601 VIA602 VIA603 VIA606
VIA_PAD3.5 VIA_PAD3.5 VIA_PAD3.5 VIA_PAD3.5
1 1 1 1
2 2 2 2
3 3 3 3
4 4 4 4
5 5 5 5
6 6 6 6

K602
Open/close

9
8
7

9
8
7

9
8
7

9
8
7
D D

2 1 RB6
4 3 RA0
RB4
RB5
STANDBY_1
K601
Standby VIA607 VIA608 VIA609
VIA_PAD3.5 VIA_PAD3.5 VIA_PAD3.5
D602 2 1 LL4148 1 1 1
2 1
4 3 2 2 2
3 3 3
D603 2 1 LL4148 4 4 4
5 5 5
6 6 6

5VON

9
8
7

9
8
7

9
8
7
R609 R610
4.7K 4.7K

Q602 2 Q603

3
E
8050 C 8550
1B 1 B
E C
M601 M602 M603
3

C C

R614 R647 R615 R648

1
200R 200R 510R 510R
2 AMBER1

2 AMBER2
1 BLUE1

1 BLUE2

5VON +15V A+5V A+5V

100uF/25V

33uF/10V
100uF/10V
LED601 LED602
5VON +15V A+5V
HFT503CPB0 HFT503CPB0

1
104

104
104

+ + +

CE605
3

C634

C630

C629

CE603
CE617
2

2
close to U609 close to U607 close to volume board

B B

L601
330UH
A+5V U607 CE608 47uF/50V
U609 LM9022 2 1 AC_1
R653 MC34063ADG/MC34063EBD

+
1 SN VO2 8
200R 2 7
SYS GND
10k

8 DC SWC 1
3 +IN VDD 6 A+5V
R638
7 2 4 5 100R R639
PK SWE -IN VO1 10K
1

R640

DZ601
R654 R663 6 3 D606 1 2
VCC TCAP +40V
3.3R 3.3R C610 1N5819 ss14
+15V
2.2k
10k

10k

47P ZENER 6.2V 0.4W

105
123

5 4 R660
COMP GND 10K
2

R641
100R
C625

C624

CE607 47uF/50V
+40V 2 1 AC_2
R642

R643

R644

+
A A
1

R661
62K 1% + C637 C644
R652 CE606
2K 1% 100uF/63V 1uF/50V 1uF/50V
2

Title
Power and Button 080130

Size Document Number Rev

A3 5115C 1.3

Date: Thursday, January 31, 2008 Sheet 25 of 30

5 4 3 2 1

Page 74 of 89
 5 4 3 2 1

harman/kardon HS 350/650DL Service Manual

D D

A+5V A+5V A+5V

CN605 A+5V C614

CON6_1.0MM_DIP_2W R616 104
4.7k
6 6 A+5V
5 5
J 4 4 VOL+
R617 4.7k
3 3 VOL-
2 2 LED_CONTROL

2
C
1 1 LED_CONTROL 1B Q601

3
E E
8050
DGND E R618 4.7k 1 Q604 1 Q605
8550 8550
B B

3
C C

2
R622 R623 R624 R625
C 180R 180R 180R 180R C

HZFBA65018CP Ф5
HZFBA65018CP Ф5
HZFBA65018CP Ф5
HZFBA65018CP Ф5

1
W601
ED1612-24-24-HC-F20(2)

VOLUME KNOB

2
LED603
LED604
LED605
LED606
VOL+

VOL-

GND

1
2
3

4
5

C601 820P

C602 820P
VOL+

VOL-

B B

A A

Title
Volume Encoder 070322
Size Document Number Rev
A3 5116C 1.3

Date: Thursday, January 31, 2008 Sheet 26 of 30

5 4 3 2 1

Page 75 of 89
 CN902
harman/kardon R+
HS 350/650DL Service Manual
1
2
3 SR+
4
5 C+
6
7 SL+
8
9 L+ JP903
10 WP10-24-1

黑 黑 黑 黑 黑
CON10_3.96MM_DIP_B
L- SL- C- SR- R-

白 蓝 绿 灰 红
+30/+40V +30/+40V
Mute circuit for Mute circuit for L+ SL+ C+ SR+ R+

amplifier right amplifier right suround

SR+
SL+

SR-
SL-

C+

R+
L+

C-

R-
L-
R901 R906
47k channel 47k channel

10
1
2

3
4

5
6

7
8

9
3

3
E E
Q901 Q905
1 8550 R904 1 8550 R909
47k 47k
B B

470pF 1kV

470pF 1kV

470pF 1kV

470pF 1kV

470pF 1kV
C C
R902 R907
2

2
1 2 1 2
30k 30k

15V
100k

100k
D901 D903

15V
LL4148 MQ901 LL4148 MQ902
2

2
IRF7341 IRF7341
2

C902
C C 1 S1 D1 8 C C 1 S1 D1 8
MUTE_SPKR 1B Q902 1 B MUTE_SPKR 1B Q906 1 B

C903
8050 Q903 2 G1 7 8050 Q907 2 G1 7
E E
R905

D902

R910

D904

C904
R903 E DTC114TUA R908 E DTC114TUA

0.47UF/100V
10k 10k
3

0.47UF/100V C905

0.47UF/100V
3

3
3 S2 D2 6 3 S2 D2 6

0.47UF/100V
3

3
4 G2 5 4 G2 5
E E C906
R+ 1 Q904 SR+ 1 Q908 0.47UF/100V
DTC114TUA DTC114TUA
B B
C C
2

2
+30/+40V +30/+40V +30/+40V
Mute circuit for Mute circuit for Mute circuit for
amplifier left amplifier left suround amplifier
R911 R916 R921
47k channel 47k channel 47k center channel
3

3
E E E
Q909 Q913 Q917
1 8550 R914 1 8550 R919 1 8550 R924
47k 47k 47k
B B B
C C C
R912 R917 R922
2

2
1 2 1 2 1 2
30k 30k 30k

15V

15V
15V
100k

100k

100k
D905 D907 D909
LL4148 MQ903 LL4148 MQ904 LL4148 MQ905
2

2
IRF7341 IRF7341 IRF7341
2

2
C C 1 S1 D1 8 C C 1 S1 D1 8 C C 1 S1 D1 8
MUTE_SPKR 1B Q910 1 B MUTE_SPKR 1B Q914 1 B MUTE_SPKR 1B Q918 1 B
8050 Q911 2 G1 7 8050 Q915 2 G1 7 8050 Q919 2 G1 7
E E E
R915

D906

R920

D908

R925

D910
R913 E DTC114TUA R918 E DTC114TUA R923 E DTC114TUA
10k 10k 10k
3

1
3

3
3 S2 D2 6 3 S2 D2 6 3 S2 D2 6
3

3
4 G2 5 4 G2 5 4 G2 5
E E E
L+ 1 Q912 SL+ 1 Q916 C+ 1 Q920
DTC114TUA DTC114TUA DTC114TUA
B B B
C C C
2

2
CN901 JP901
1 1 CKX-3.5-22
1 SUB_TRIGGER SUB_TRIGGER
2 2 2
3 3
4 SUBWOOFER 3
4 C901
5 5
6 MUTE_SPKR 104
6
7 7
8 +30/+40V JP902
8 AV1-8.4-6G

CON8_1.0MM_DIP_2W

SUBWOOFER 2 SIG

1 GND
C900 TOP VIEW
27P

LOCATION-PAD

TP900 TP901 TP902 Title

HS350 HS650 Speaker Board 080131
1 1 1
Size Document Number Rev
A3 5118C 1.3

Date: Thursday, May 08, 2008 Sheet 30 of 30

Page 76 of 89
 5 4 3 2 1

harman/kardon CE701 CE702 C701 R701 R702

HS 350/650DL Service Manual
68U/450V 330U/450V 104/630V 11M/1W 11M/1W
380VDC

R703 R704 R705 R706 F701

C771 200K 1206 1% 200K 1206 1% 200K 1206 1% 150K 1206 1% T3.15A/250V
NC
D702 FB704 CY701 R707 100 C702
ISL9R1560PF2 100 102/250VAC 471/1KV
CE703 CE704 CE705 L701 CE706 CE729
FB703 Q701 47U/50V R709 Q702 D703 1000U/63V 1000U/63V L0620-050 1000U/63V
100 KTC8050 10 FQPF18N50C R708 100 SBR20A300CTFP 1000U/63V
A40V 40V

HER208G
R838 D704 3 D707 Q704 Z701
15 BSA16 1 BSA16 KTC8550 18V C703

D705
2 1 471/1KV AMP
2

2
D 1 3 2 R711 T701 D706 C704 CN706 D

470 TR_ER4401 SBR20A300CTFP R716 104/100V 40V/3.75A

3
1 1

R714 100

R715 100
1 R717 10 0.1/2W 2

2
2.2 5
6 9 VSS1 3
9T

2
C772 R710 R718
3

2
1

3
1 7
8 4 8 13 4
NC 47 60.4K 1% R720 Z703 C706 CE707 D708 C707 R721 -40V/3.75A
35 12T
22 18V 104 47U/50V 1U08 474/100V R719 L702 12 0.1/2W CON4
35T
R722 36K EE19 C705
3
17
18

10K 6 15 104/100V
R713 Z702 Q705 FB705 5 R725 -40V
10K 18V KTC8550 C708 R723 R724 100 9T 0.1/2W
14

HER208G
L-ER4201 750UH

Q703 151 22 1K CE728

4
13 12T

R727 100

R728 100
FQPF20N50C Q706 18 LF703 R730 1000U/63V

D709
L703

C709 FQPF18N50C 20UH 0.1/2W

R729 152 A-40V A40V
8
9

2
68K U701 U702 D711 Q707 Z704 D710
ML4800 FAN73832 2 BSA16 KTC8550 18V SBR20A300CTFP R726 R712
1 16 1 8 1 3 1 CE709 L704 CE710 1K/5W 1K/5W
IEAO VEAO IN VB C712 1000U/63V L0620-050 1000U/63V

2
471/1KV A-40V

3
2 IAC VFB 15 2 GND HO 7
1
3 14 R734 3 6 D712 CE708
Isense VREF 100 DT/SD VS SBR20A300CTFP 1000U/63V
R739

C773

C710

C711
101/1KV

103/2KV

474/630V
R738

3
4 Vrms VCC 13 4 VDD LO 5 2.2 R740 100
R735 22 C713 R731 R748 U703 R749 R750 R751 R732
C714 474/50V

R733 5 12 412K 471/1KV 100 10K AZ431 0.5% 10K 10K 10K 2.2K
100K SS PFC
R741 100
150K 1206

100K 1206

3
6 Vdc PWM 11
R742 R743 R737
1
R744

R745

7 10 R736 1K 36K 0.22/3W

RAMP1 GND
R746 13K

R755 CE711 1K R747 Z705 R754

2
10 8 9 47U/50V 2K 18V R757 1.2K
RAMP2 ILIM 15K/1%
150K 1206

200K 1206

C715 474/50V

R752 A40V
VREF7.5V C724 C726 3 1K U704 R763 R764
R758

R759

R756 331 153 1 EL817 1K 30K/1%

10K 4 1 C770
2 474 U705
3 2 R768 C728 LM358
150K 1206

200K 1206

C716 C717 C718 C719 C720 C721 C722 Z706 C723 R760 C725 R761 C727 R762 Q708 10K 104
474/50V 105 471 103 102 102 105 15V 105 4.99K 1% 474 2K 103 47K 2N3904
R766

R767

3 2 5 6
C C
3 A15V

-
1
R771 GND VCC
150K 1206

200K 1206

C732 R769 D713 R770 U706 3K/1%

2
PWM14V

332 22 1N4148 68K AZ431AZ 0.5%

R772

R773

Q711 C774 C729 1 7 C730 C731

2

2N3906 10UF/16V 104 104 104

1 Q712 VSS1 VSS1
AF4835P

7
R776 22

R777 0.22/3W

R778 0.22/3W

D714 C733 R774

8 7 6 5

3 2 1
IN4001 474 68K CE712
3
2

4.7U/50V
1 +5.7V
D716
D715 R779 1N4148
4
IN4001 Q713 150K R782 R783 R784
3

2N3906 R780 Z707 CE713 R792 1K 2K 4.7K

15K 18V 220U/50V 10 D717
2 Q714 1N4148
C734 R781 1 2N3906 U707
1

105/450V 330 R786 EL817 3 CN702

3 R785 200 1206 1 R789 D718 5VON 1
1 Q715 10K 3 47K 1N4148 +15V
3

4 1 2
FB701 2N3904 2 1 A40V 3
50 R787 2 3 2 Q716 -15V 4
330 2N3904 2 5
1

R788 C735 Q717 R790 Z708 Z709 USB5V 6

10K R793 104 2N3904 10K 20V 27V 7
3K 1% USB5V 8 Front
9
BD701 +5.7V 10
D10XB60 D733 D735 L708 C736 R791 C775 C769 C737 11
AC

AC

1N4007 UF1004 LH0608-22UH 104 20K 475 475 104 +5.7V 12

380VDC 15VON 15V/500mA 13
Standby
2

14
Q725
CE726 CE725 AF4835P CON14
2M 1206 2M 1206

2M 1206

CX702 C767 470U/25V 470U/25V

R794

R795

1 2 3

5 6 7 8
334/275VAC 103/630VDC C739 C738 R796 +15V 15V/500mA
NC 472/630VDC 68K/1W
1

B D719 L705 R827 B

UF1004 LH0608-22UH 1K Q724

R797

2M 1206

LF704 T702 A15V 2N3904 CN704

R798

4
LCL-ET2812 BCK-PQ3230 7 3 15VON 1
1 10T CE714 CE715 R835 1 -15V 2
470U/25V 470U/25V 4.7K 5VON 3
CY702 D721 D720 40T-600UH 8 2 USB5V +15V
2

4
2M 1206

2M 1206

471/250VAC HER208G UF1004 10T D722 L706 Q718 5

R799

R800

3 UF1004 LH0608-22UH DMN3033LSN R819 R836 +15V 6

10K 4.7K -15V -15V/500mA 7

3
CX701 9 USB5V 8
CY703 224/275VAC 10T CE717 CE718 9
1M 1206

3M 1206

471/250VAC 2 470U/25V 470U/25V R808 R806 USB5V 10 MAIN

R801

R802

1
R807 D724 10T 1K 1K 11
R809 15 UF1004 10 VSS +5.7V 12

3
1M 1/2W 13
7T 4 4T CE720 CE721 CE727 Q719 1 R810 +5.7V 14
3

U709 D726 2200U/16V 2200U/16 1000U/16V 2N3906 1K 15

FAN7602 BSA16 D725 +5.7V 16
LF705 6 FYPF2010DN Q721 +5.7V 5.7V/3A

2
1 1 8 8 3 1
2

LCL-ET2812 2 7 2 Q720 12 AF4835P CON16

2 7 FQPF7N80C USB5V
3 6 5V/3A

1 2 3

5 6 7 8
3 6 R812 C742 L707
4 4 5 5 1
39 102/200V L0620-050 CE723 D723 D732 RZ703
2

330 1206

330 1206
330 1206
R811 1000U/16V B540C B540C JL16 300
3

CX703 47 R813

R803

R804

R805
0.47 1206

0.47 1206

224/275VAC 39 R820 CN703

4
1K R821 CE719 1
R815

R816

1 1 C746 CE722 R814 Z710 3.6K/1% D734 R822 1000U/16V +5.7V 2

RZ701 RZ702 104 47U/50V 10K 18V 1U08 2K 3
8R210 t t 8R210 U711 R826 -15V 4 AMP
2 2 EL817 470 5
RZ704 R817 C744 C766 R818 C745 4 1 R823 C751 R824 R837 Q723 +15V 6
10K471 180K 104 104 27K 331 1K 104 1K 270 3 2N3904
3 2 1 Standby CON6
F702
T6.3AL250V R825 2 R830
1K R831 330 1206 4.7K
3
1
U712 R829
R828 AZ431AZ 0.5% 3K/1% R834 330 1206 R833
2
High Voltage! Risk of electric shook!
1
2

A CN701 4.7K 10K A

AC100-240V
R832 330 1206 C740
104
5VON 5V/300mA

c1 c2 c3 c5 c4 c6 c7 D729 CY705 S701 D736 D727 D730 D731

S702 S703 S704 2 11 102/250VAC G704 G702 G703 G701 16*12*51MM 2 11 2 11 2 11 2 11
2 11 2 11 2 11 2 11 2 11
3

3 10 3 3 10 10 3 10 3 10 3 10 15VON +15V -15V +5.7V USB5V

3 10 3 10 3 10 3 10
1

4 9 1 1 2 2 4 4 9 9 4 9 4 9 4 9
3

4 9 4 9 4 9 4 9
3

1 1 2 2 1 1 2 2 1 1 2 2 5 5 8 8 1 1 2 2 1 1 2 2 1 1 2 2 1 1 2 2 5 5 8 8 5 5 8 8 5 5 8 8 5 5 8 8
Title
1

6 6 7 7 6 6 7 7 6 6 7 7 6 6 7 7 6 6 7 7
HS650 POWER SUPPLY 5117C-20080122
3

C752 C753 C754 C755 C757 C758 C759 C760 C761 C762 C764 C765
104 104 104 104 104 104 104 104 104 104 104 104 Size Document Number Rev
A2 xyz V2.0

Date: Thursday, May 08, 2008 Sheet 2 of 3

5 4 3 2 1

Page 77 of 89
 +VP
CN403
harman/kardon HS 350/650DL Service Manual
1 +30/+40V
R1017 L414 2
0R15 1% SLF7032T-680MR59-2PF 3
U421 L415 +8V 4
NCP3063BPG SLF7032T-680MR59-2PF CE430
+15V 8 D441 470uF/63V
nc SWC 1 3.96mm EP horiz. +
7 Ip SWE 2
6 L402
Vc Tc 3 C545 SLF7032T-680MR59-2PF
5 Cmp Gnd 4 IN4001 10uF/50V R1025
+ CE434 U423 L403 12V_BIAS
47uF/25V R1019 3.32K 1% 0R15 1% NCP3063BPG SLF7032T-680MR59-2PF
signal ground - 8
R1020 47K 1% nc SWC 1
power ground 7 Ip SWE 2

2
link 6 Vc Tc 3
C548 C549 5
10uF/25V 10uF/25V + CE450 Cmp Gnd 4
C546 220uF/16V
2.2uF/25V R1018 C547 D444 CE429 R1027 5.11K 1%
604R 1% 3.9nF B1100 SMD 470uF/63V

2
D438 R1028 38.3K 1%
+ C402 C407
10uF/25V 10uF/25V +
C544
IN4001 10uF/50V C554 D402
C403 R1026 3.9nF B1100 SMD CE452

1
R1021 604R 1% 220uF/16V
0R15 1% U422 L416 2.2uF/50V
NCP3063BPG SLF7032T-680MR59-2PF -30/-40V
8 nc SWC 1
7 Ip SWE 2
6 Vc Tc 3
5 -VP
-15V Cmp Gnd 4
1
2 + CE433 +3.3V +3.3V +3.3V
3 47uF/25V R1023 3.32K 1%
R1030
4 1K 1%
5 R1024 47K 1%

1
2
3
4

1
2
3
4

DNE
6
C552 C553
10uF/25V 10uF/25V + CE451 RN401 RN402
C550 C551 220uF/16V 4x10K 4x10K
CN402 2.2uF/25V R1022 3.9nF D445 CN401

R587
1.25mm NonZIP vert. 604R 1% 1 B1100 SMD 1.0mm NonZIP vert.
TP2

8
7
6
5

8
7
6
5
16 TESTPOINT
15 SCLK_OUT1 TP4
SCLK_OUT1
L417 14 LRCK_OUT1 TESTPOINT
LRCK_OUT1
SLF7032T-680MR59-2PF 13 TP1
-8V 12 MCLK_OUT TESTPOINT
MCLK_OUT
11 TP3
10 S1DATA0 TESTPOINT
S1DATA0
+5V 9 S1DATA1
S1DATA1
U420 8 S1DATA2
S1DATA2
KA78R05CTSTU 7
U416 1 2 6 DATA/SDA
+3.3V IN OUT SDA
AZ1117H-3.3TRE1 5 CLOCK/SCL
SCL
4
+5.7V 3 2 4 3 MUTE_SUB
VIN VOUT VDIS MUTE_SUB
1 4 2 DSP_MUTE DSP_MUTE CN405
ADJ VOUT + CE431 1
47uF/10V L413
1
GND

+ + CE428 C540 2
MUTE_IRS# L_CH
CE432 C537 47uF/10V 0.1uF R583 3
47uF/10V 0.1uF 10K HZ0603B751R-10 4
SL_CH
3

3
C_CH 6
1 Q401 7
IRSMCU_MUTE
2SC5866 SR_CH 8
R599 1.2K D446 LL4148 9
Use transistor to

2
R_CH 10
+3.3V +3.1V solve Plop problem.
D450
R584 3.96mm EP horiz.
10R
B1100/B
+ CE453 C404
R412 1000uF/6V 0.1uF
10K +3.3V

IRSMCU_MUTE
CN404
+3.3V
20K
20K
20K
20K
20K
R416 U401 +30/+40V 1
1

J401 10K PIC16F690-I/SS D447 LL4148 2

1 MUTE_SPKR 3
VDD

SPKRMCU_MUTE
PGM DNE

2 DACS_RST# 4
3 R573 1.2K 5
MCU_SYNC_CLK SUBWOOFER
R414
R410
R407
R405
R402
4 19 R1003 6
RA0/AN0/C1IN+ 20K
5 18 RA1/AN1/C12IN- RC7/AN9/SDO 9 SUB_TRIGGER 7
6 DAC1CS# 17 RA2/AN2/T0CKI/INT RC6/AN8/SS 8 8
4 MCLR/VPP/RA3 RC5/CCP1/P1A 5
VOLTAGE_ALERT 3 6 L401 R417 100K
RA4/AN3/T1G/OSC2 RC4/C2OUT/P1B L_CH
2 7 L405 R450 100K 1.0mm NonZIP vert.
+3.1V SPKRMCU_MUTE RA5/T1CKI/OSC1 RC3/AN7/P1C SL_CH
14 L407 R483 100K
RC2/AN6/P1D C_CH
10 15 L409 R518 100K
RB7/TX/CK RC1/AN5/C12IN- SR_CH
11 16 L411 R550 100K
RB6/SCK/SCL RC0/AN4/C2IN+ R_CH
12 HZ0603B751R-10
RB5/AN11/RX/DT
47K
47K
47K
47K
47K

13 C408 C430 C454 C478 C503 HZ0603B751R-10

R401 R404 RB4/AN10/SDI/SDA 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF HZ0603B751R-10
10K 1K HZ0603B751R-10
VSS

ABC PCB S鄏l

R413
20K R409
HZ0603B751R-10
Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz
20K MT3 MT4 MT2 MT1
20

R415
R411
R408
R406
R403

SCK Title
C401
MOSI 5329C audio amp board for HS350 & HS650
0.1uF
D403 D409 D416 D424 D430
SCL Size Document Number Rev
ZMM5V1 ZMM5V1 ZMM5V1 ZMM5V1 ZMM5V1
SDA A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 1 of 6

Page 78 of 89
harman/kardon HS 350/650DL Service Manual
+5V

R1009 Please notice the value difference in DAC

10R +5V R426 4.7K 1% R427 6.2K 1%
R465 circuit between HS350 and HS650DL: R427,

+
CE404 R435, R460, R467, R494, R502, R527, R533,
10R 47uF/10V R559 and R567
+ C416
C458 C453 C445 CE402 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C409
R418 30R 0.22uF Y5V

15
20
+8V

9
U403A 8

DVDD

AVDD

AVDDR
AVDDL
22 U407 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R434 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_FL

+
SCLK_OUT1 3 BITCLK VoutL+ 17 3 +
2 16 2.0 Vrms
S1DATA0 SDATA VoutL- CE405 470pF COG C423
47uF/10V R435 C420 4 0.22uF Y5V

+
MCLK_OUT 5 MCLK VmidL 18
CE403 6.2K 1%
-8V
int. pull-down 4 47uF/10V
int. pull-up MODE8X R442 30R
25 MUTE ZERO 21
int. pull-down 6 DIFFHW
int. pull-down 23 12 R459 4.7K 1% R460 6.2K 1%
CSBIWO VoutR+

+
VoutR- 13
MOSI 26 MISO/DM0 CE407

+
SCK 27 SCK/DM1 VmidR 11
28 CE408 47uF/10V
DAC1CS# CS/I2S 47uF/10V C436

AGNDR
AGNDL
DGND

AGND
int. pull-up 24 470pF COG
MODE C431
R448 30R 0.22uF Y5V
+8V

14
19
10
7
U405A 8
ADTL082ARZ
2 -
R466 4.7K 1% 1 OUT_SL

+
3 + 2.0 Vrms
CE409 470pF COG C446
47uF/10V R467 C442 4 0.22uF Y5V
6.2K 1%
-8V
R472 30R

+5V

R1010
10R +5V R493 4.7K 1% R494 6.2K 1%
R506

+
CE412
10R 47uF/10V
+ C459
C491 C479 C474 CE410 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C455
R485 30R 0.22uF Y5V
15
20

+8V
8

U408A 8
DVDD

AVDD

AVDDR
AVDDL

22 U410 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R501 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_C
SCLK_OUT1 3 17 + 3
BITCLK VoutL+ + 2.0 Vrms
S1DATA1 2 SDATA VoutL- 16
CE413 470pF COG C470
47uF/10V R502 C466 4 0.22uF Y5V
+

MCLK_OUT 5 MCLK VmidL 18

CE411 6.2K 1%
-8V
4 47uF/10V
MODE8X R509 30R
25 MUTE ZERO 21
6 DIFFHW
23 12 R526 4.7K 1% R527 6.2K 1%
CSBIWO VoutR+
+

VoutR- 13
MOSI 26 MISO/DM0 CE415
+

SCK 27 SCK/DM1 VmidR 11

28 CE416 47uF/10V
DAC1CS# CS/I2S 47uF/10V C483
AGNDR
AGNDL
DGND

AGND

24 470pF COG
MODE C480
R516 30R 0.22uF Y5V
+8V
14
19
10
7

U411A 8
ADTL082ARZ
2 -
R532 4.7K 1% 1 OUT_SR
+

3 + 2.0 Vrms
CE417 470pF COG C496
47uF/10V R533 C492 4 0.22uF Y5V
6.2K 1%
-8V ABC PCB S鄏l
R539 30R Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 2 of 6

Page 79 of 89
harman/kardon HS 350/650DL Service Manual

+5V

R1011
Please notice the value difference in DAC
10R +5V R558 4.7K 1% R559 6.2K 1% circuit between HS350 and HS650DL: R427,
R538

+
R435, R460, R467, R494, R502, R527, R533,
CE420 R559 and R567
10R 47uF/10V
+ C507
C519 C506 C501 CE418 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C504
R551 30R 0.22uF Y5V

15
20
+8V

9
U414A 8

DVDD

AVDD

AVDDR
AVDDL
22 U413 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R566 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_FR

+
SCLK_OUT1 3 BITCLK VoutL+ 17 3 +
2 16 2.0 Vrms
S1DATA2 SDATA VoutL- CE422 470pF COG C520
47uF/10V R567 C516 4 0.22uF Y5V

+
MCLK_OUT 5 MCLK VmidL 18
CE419 6.2K 1%
-8V
R477 DNE 4 47uF/10V
+5V MODE8X
R484 DNE 25 21 R574 30R
MUTE ZERO
6 DIFFHW
23 12 R590 4.7K 1% R591 9.1K 1%
CSBIWO VoutR+

+
VoutR- 13
MOSI 26 MISO/DM0 CE423

+
SCK 27 SCK/DM1 VmidR 11
28 CE424 47uF/10V +15V
DAC1CS# CS/I2S 47uF/10V C529
AGNDR
AGNDL
DGND

AGND
24 470pF COG
MODE C528
R588 30R 0.22uF Y5V
+8V
14
19
10
7

U417A 8 CE427
NJM2068M 47uF 35V Bipolar D442
2 - C541 LL4148
R594 4.7K 1% 1 1nF COG
SUBWOOFER

+
3 + R597 100R 2.0 Vrms
CE425 470pF COG C534
47uF/10V R595 C533 4 0.22uF Y5V
9.1K 1% R598 D443
-8V
47K LL4148
R596 30R

-15V C
U417B 4.7K Q404
NJM2068M DTC343TK
6 - B E
7
5 + MUTE_SUB

+5V Q402 R593

8550

t
2 3 1 2 SUB_TRIGGER
JK-MSMD010

C527

1
0.1uF D437 R592 C532
R586 R585 LL4148 47K 0.1uF
10K 1K

3
+3.3V
R589 Q403
1 BSS123

10K

2
ABC PCB S鄏l
Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 3 of 6

Page 80 of 89
 harman/kardon HS 350/650DL Service Manual

R429 46.4K 1% R430 1K

C412 +VP
150pF/200V
C411 .001uF C410 .001uF C414 +VP
+8V R428 5.1K 1% D404 1N4448HWS 0.1uF/200V
R437
5.49K 1% R432
R420 R445 C425 IRS20955STRPbF 10K 1%

1
5
6
7
300R 47R 10uF/25V Y5U U404 R422
5.1K 1% R421 30K C415
C426 Q405 0.1uF 100V X7R
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE436 +
470uF

3
4
2 CSD VB 15
C424 R433
CE401 2.2uF/50V 3 14 C417 100K L404 22uH
47uF 35V Bipolar U403B R446 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 L_CH
R444 1K 1% VSS VS
OUT_FL 6 -

1
7 5 12 C560
NC NC

1
5
6
7
R439 4.7K 1% 5 R600 470pF 1kV
+ JK60-050
6 11
MCU_SYNC_CLK
VREF VCC Q406 R441 t C428
C429 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
C421 R436 22K 47pF OCSET LO

2
47pF

3
4
8 DT COM 9
C418 R1012 R425
D407 D406 D408 R447 D401 75K R438 10R 1% 2W
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 1N4448HWS 100K CE437 +
470uF
R419 1R
C419
0.47uF 100v Poly
R449 R440 C413
3.3K 1% R443 5.6K 1% C427
R431 10K D405 LL4148 4.7K 1% R424 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C422
12V_BIAS 0.1uF/200V -VP

R461 46.4K 1% R462 1K

C434 +VP
150pF/200V
C439 +VP
C433 .001uF C432 .001uF +8V R456 5.1K 1% D411 1N4448HWS 0.1uF/200V
R469
5.49K 1% R464
R479 C448 IRS20955STRPbF 10K 1%

1
5
6
7
R451 47R 10uF/25V Y5U U406 R453
C440
300R 5.1K 1% R452 30K
0.1uF 100V X7R
C450 Q407
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE438 +
470uF

3
4
2 CSD VB 15
C447 R470
CE406 2.2uF/50V 3 14 C437 100K L406 22uH
47uF 35V Bipolar U405B R480 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 SL_CH
R478 1K 1% VSS VS
OUT_SL 6 -

1
7 5 12 C561
NC NC

1
5
6
7
R473 4.7K 1% 5 470pF 1kV
+ R601
6 11
MCU_SYNC_CLK
VREF VCC Q408 R475 JK60-050 t C452
C451 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
C443 R468 22K 47pF OCSET LO

2
47pF

3
4
8 DT COM 9
C438 R1013
D414 D412 D415 R481 D410 75K R471 R455
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 1N4448HWS 100K CE439 + 10R 1% 2W
470uF
R454 1R

C441
R482 R474 C435 C449 0.47uF 100v Poly
3.3K 1% R476 5.6K 1% 0.1uF 100V X7R
R463 10K D413 LL4148 4.7K 1% R458 1R 2.2uF/50V
MUTE_IRS#
C444
12V_BIAS 0.1uF/200V -VP

ABC PCB S鄏l

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 4 of 6

Page 81 of 89
 harman/kardon HS 350/650DL Service Manual

R528 46.4K 1% R529 1K

C485 +VP
150pF/200V
C484 .001uF C481 .001uF C489 +VP
+8V R535 R523 5.1K 1% D425 1N4448HWS 0.1uF/200V
5.49K 1%
R531
R519 R546 C498 IRS20955STRPbF 10K 1%

1
5
6
7
300R 47R 10uF/25V Y5U U412 R521
C490
5.1K 1%
0.1uF 100V X7R
C499 R520 30K Q411
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE440 +
470uF

3
4
2 CSD VB 15
C497 R536
CE421 2.2uF/50V 3 14 C486 100K L410 22uH
47uF 35V Bipolar U411B R547 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 SR_CH
R545 1K 1% VSS VS
OUT_SR 6 -

1
7 5 12 C562
NC NC

1
5
6
7
R540 4.7K 1% 5 470pF 1kV
+ R602
6 11
MCU_SYNC_CLK
VREF VCC Q412 R542 JK60-050 t C482
C502 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R534 22K 47pF OCSET LO

2
C493

3
4
8 DT COM 9
47pF C487 D423 R1014 R544
D428 D427 D429 R548 1N4448HWS 75K R537 10R 1% 2W
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 100K CE441 +
470uF
R522 1R C495
0.47uF 100v Poly

R549 R543 R541 5.6K 1% C488

3.3K 1% 4.7K 1% C500
R530 10K D426 LL4148 R525 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C494
12V_BIAS 0.1uF/200V -VP

R561 46.4K 1% R562 1K

C509 +VP
150pF/200V
C508 .001uF C505 .001uF C513 +VP
R569 R560 5.1K 1% D432 1N4448HWS 0.1uF/200V
+8V 5.49K 1%
R564
R553 C522 IRS20955STRPbF 10K 1%

1
5
6
7
300R R577 10uF/25V Y5U U415 C514
47R R555 0.1uF 100V X7R
5.1K 1% R554 30K Q413
C524 1 16 2 IRF6645TRPbF
10uF/25V Y5U VDD CSH CE442 +
470uF

3
4
2 CSD VB 15
C521 R565
CE426 2.2uF/50V 3 14 C510 100K L412 22uH
47uF 35V Bipolar U414B IN HO 10uF/50V
ADTL082ARZ R578 4 13 R_CH
R576 1K 1% 1K VSS VS
OUT_FR 6 -

1
7 5 12 C563
NC NC

1
5
6
7
R571 4.7K 1% 5 470pF 1kV
+ R603
6 11
MCU_SYNC_CLK C526 VREF VCC Q414 R575 JK60-050 t C515
47pF 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R568 22K OCSET LO

2
C517

3
4
8 DT COM 9
47pF D436 C511 D431 R1015 R581
D435 D434 LL4148 R579 1N4448HWS 75K R570 10R 1% 2W
LL4148 LL4148 7.87K 1% 10uF/50V 100K CE443 +
470uF
R552 1R
C523
0.47uF 100v Poly
R582 R580 R572 5.6K 1% C512
3.3K 1% 4.7K 1% C525
R563 10K D433 LL4148 R557 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C518
12V_BIAS 0.1uF/200V -VP

ABC PCB S鄏l

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 5 of 6

Page 82 of 89
 harman/kardon HS 350/650DL Service Manual

R496 46.4K 1% R497 1K

C461 +VP
150pF/200V
C460 .001uF C456 .001uF C464 +VP
R504 R495 5.1K 1% D418 1N4448HWS 0.1uF/200V
+8V 5.49K 1%
R499
R487 C472 IRS20955STRPbF 10K 1%

1
5
6
7
300R R513 10uF/25V Y5U U409 R489
47R 5.1K 1% C465
R488 30K Q409 0.1uF 100V X7R
C475 1 16 2 IRF6645TRPbF
10uF/25V Y5U VDD CSH CE444 +
470uF

3
4
2 CSD VB 15
C471 R500
CE414 2.2uF/50V 3 14 C462 100K L408 22uH
47uF 35V Bipolar U408B IN HO 10uF/50V
ADTL082ARZ R514 4 13 C_CH
R512 1K 1% 1K VSS VS
OUT_C 6 -

1
7 5 12 C564
NC NC

1
5
6
7
R507 4.7K 1% 5 470pF 1kV
+ R604
6 11
MCU_SYNC_CLK C476 VREF VCC Q410 R511 JK60-050 t C477
47pF 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R503 22K OCSET LO

2
C467

3
4
8 DT COM 9
47pF D422 C463 D417 R1016
D421 D420 LL4148 R515 1N4448HWS 75K R505 R492
LL4148 LL4148 7.87K 1% 10uF/50V 100K CE445 + 10R 1% 2W
470uF
R486 1R
C469
0.47uF 100v Poly
R517 R508 5.6K 1% C457
3.3K 1% R510 C473
R498 10K D419 LL4148 4.7K 1% R491 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C468
0.1uF/200V -VP
12V_BIAS
+VP

R1006 D448
R1004 20K LL4148
1K
D449
R1007
1K
1

Q415
2SA1037AKR LL4148
3 2

+ CE435
R1005 R1008 100uF/50V
3

100K 100K
1

Q416
2SC5866
2

ABC PCB S鄏l

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4

Date: Thursday, May 08, 2008 Sheet 6 of 6

Page 83 of 89
 +VP
harman/kardon CN403 HS 350/650DL Service Manual
1 +30/+40V
R1017 L414 2
0R15 1% SLF7032T-680MR59-2PF 3
U421 L415 +8V 4
NCP3063BPG SLF7032T-680MR59-2PF CE430
+15V 8 D441 470uF/63V
nc SWC 1 3.96mm EP horiz. +
7 Ip SWE 2
6 L402
Vc Tc 3 C545 SLF7032T-680MR59-2PF
5 Cmp Gnd 4 IN4001 10uF/50V R1025
+ CE434 U423 L403 12V_BIAS
47uF/25V R1019 3.32K 1% 0R15 1% NCP3063BPG SLF7032T-680MR59-2PF
signal ground - 8
R1020 47K 1% nc SWC 1
power ground 7 Ip SWE 2

2
link 6 Vc Tc 3
C548 C549 5
10uF/25V 10uF/25V + CE450 Cmp Gnd 4
C546 220uF/16V
2.2uF/25V R1018 C547 D444 CE429 R1027 5.11K 1%
604R 1% 3.9nF B1100 SMD 470uF/63V

2
D438 R1028 38.3K 1%
+ C402 C407
10uF/25V 10uF/25V +
C544
IN4001 10uF/50V C554 D402
C403 R1026 3.9nF B1100 SMD CE452

1
R1021 604R 1% 220uF/16V
0R15 1% U422 L416 2.2uF/50V
NCP3063BPG SLF7032T-680MR59-2PF -30/-40V
8 nc SWC 1
7 Ip SWE 2
6 Vc Tc 3
5 -VP
-15V Cmp Gnd 4
1
2 + CE433 +3.3V +3.3V +3.3V
3 47uF/25V R1023 3.32K 1%
R1030
4 1K 1%
5 R1024 47K 1%

1
2
3
4

1
2
3
4

DNE
6
C552 C553
10uF/25V 10uF/25V + CE451 RN401 RN402
C550 C551 220uF/16V 4x10K 4x10K
CN402 2.2uF/25V R1022 3.9nF D445 CN401

R587
1.25mm NonZIP vert. 604R 1% 1 B1100 SMD 1.0mm NonZIP vert.
TP2

8
7
6
5

8
7
6
5
16 TESTPOINT
15 SCLK_OUT1 TP4
SCLK_OUT1
L417 14 LRCK_OUT1 TESTPOINT
LRCK_OUT1
SLF7032T-680MR59-2PF 13 TP1
-8V 12 MCLK_OUT TESTPOINT
MCLK_OUT
11 TP3
10 S1DATA0 TESTPOINT
S1DATA0
+5V 9 S1DATA1
S1DATA1
U420 8 S1DATA2
S1DATA2
KA78R05CTSTU 7
U416 1 2 6 DATA/SDA
+3.3V IN OUT SDA
AZ1117H-3.3TRE1 5 CLOCK/SCL
SCL
4
+5.7V 3 2 4 3 MUTE_SUB
VIN VOUT VDIS MUTE_SUB
1 4 2 DSP_MUTE DSP_MUTE CN405
ADJ VOUT + CE431 1
47uF/10V L413
1
GND

+ + CE428 C540 2
MUTE_IRS# L_CH
CE432 C537 47uF/10V 0.1uF R583 3

3
47uF/10V 0.1uF 10K HZ0603B751R-10 4
SL_CH
3

5
Q401 6
C_CH
1 BSS123 7
IRSMCU_MUTE
SR_CH 8
R599 1.2K D446 LL4148 9

2
R_CH 10
+3.3V +3.1V
D450
R584 3.96mm EP horiz.
10R
B1100/B
+ CE453 C404
R412 1000uF/6V 0.1uF
10K +3.3V

IRSMCU_MUTE
CN404
+3.3V
20K
20K
20K
20K
20K
R416 U401 +30/+40V 1
1

J401 10K PIC16F690-I/SS D447 LL4148 2

1 MUTE_SPKR 3
VDD

SPKRMCU_MUTE
PGM DNE

2 DACS_RST# 4
3 R573 1.2K 5
MCU_SYNC_CLK SUBWOOFER
R414
R410
R407
R405
R402
4 19 R1003 6
RA0/AN0/C1IN+ 20K
5 18 RA1/AN1/C12IN- RC7/AN9/SDO 9 SUB_TRIGGER 7
6 DAC1CS# 17 RA2/AN2/T0CKI/INT RC6/AN8/SS 8 8
4 MCLR/VPP/RA3 RC5/CCP1/P1A 5
VOLTAGE_ALERT 3 6 L401 R417 100K
RA4/AN3/T1G/OSC2 RC4/C2OUT/P1B L_CH
2 7 L405 R450 100K 1.0mm NonZIP vert.
+3.1V SPKRMCU_MUTE RA5/T1CKI/OSC1 RC3/AN7/P1C SL_CH
14 L407 R483 100K
RC2/AN6/P1D C_CH
10 15 L409 R518 100K
RB7/TX/CK RC1/AN5/C12IN- SR_CH
11 16 L411 R550 100K
RB6/SCK/SCL RC0/AN4/C2IN+ R_CH
12 HZ0603B751R-10
RB5/AN11/RX/DT
47K
47K
47K
47K
47K

13 C408 C430 C454 C478 C503 HZ0603B751R-10

R401 R404 RB4/AN10/SDI/SDA 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF HZ0603B751R-10
10K 1K HZ0603B751R-10
VSS

ABC PCB Sàrl

R413
20K R409
HZ0603B751R-10
Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz
20K MT3 MT4 MT2 MT1
20

R415
R411
R408
R406
R403

SCK Title
C401
MOSI 5329C audio amp board for HS350 & HS650
0.1uF
D403 D409 D416 D424 D430
SCL Size Document Number Rev
SDA
ZMM5V1 ZMM5V1 ZMM5V1 ZMM5V1 ZMM5V1
A3 013_02_200 5329C Page 84 of 89 1.4

Date: Thursday, February 14, 2008 Sheet 1 of 6

harman/kardon HS 350/650DL Service Manual
+5V

R1009
10R +5V R426 4.7K 1% R427 4.7K 1%
R465

+
CE404
10R 47uF/10V
+ C416
C458 C453 C445 CE402 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C409
R418 30R 0.22uF Y5V

15
20
+8V

9
U403A 8

AVDDL
DVDD

AVDD

AVDDR
22 U407 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R434 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_FL

+
SCLK_OUT1 3 BITCLK VoutL+ 17 3 +
2 16 2.0 Vrms
S1DATA0 SDATA VoutL- CE405 470pF COG C423
47uF/10V R435 C420 4 0.22uF Y5V

+
MCLK_OUT 5 MCLK VmidL 18
CE403 4.7K 1%
-8V
int. pull-down 4 47uF/10V
int. pull-up MODE8X R442 30R
25 MUTE ZERO 21
int. pull-down 6 DIFFHW
int. pull-down 23 12 R459 4.7K 1% R460 4.7K 1%
CSBIWO VoutR+

+
VoutR- 13
MOSI 26 MISO/DM0 CE407

+
SCK 27 SCK/DM1 VmidR 11
28 CE408 47uF/10V
DAC1CS# CS/I2S 47uF/10V C436

AGNDR
AGNDL
DGND

AGND
int. pull-up 24 470pF COG
MODE C431
R448 30R 0.22uF Y5V
+8V

14
19
10
7
U405A 8
ADTL082ARZ
2 -
R466 4.7K 1% 1 OUT_SL

+
3 + 2.0 Vrms
CE409 470pF COG C446
47uF/10V R467 C442 4 0.22uF Y5V
4.7K 1%
-8V
R472 30R

+5V

R1010
10R +5V R493 4.7K 1% R494 4.7K 1%
R506

+
CE412
10R 47uF/10V
+ C459
C491 C479 C474 CE410 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C455
R485 30R 0.22uF Y5V
15
20

+8V
8

U408A 8
AVDDL
DVDD

AVDD

AVDDR

22 U410 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R501 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_C
SCLK_OUT1 3 BITCLK VoutL+ 17 + 3 +
2 16 2.0 Vrms
S1DATA1 SDATA VoutL- CE413 470pF COG C470
47uF/10V R502 C466 4 0.22uF Y5V
+

MCLK_OUT 5 MCLK VmidL 18

CE411 4.7K 1%
-8V
4 47uF/10V
MODE8X R509 30R
25 MUTE ZERO 21
6 DIFFHW
23 12 R526 4.7K 1% R527 4.7K 1%
CSBIWO VoutR+
+

VoutR- 13
MOSI 26 MISO/DM0 CE415
+

SCK 27 SCK/DM1 VmidR 11

28 CE416 47uF/10V
DAC1CS# CS/I2S 47uF/10V C483
AGNDR
AGNDL
DGND

AGND

24 470pF COG
MODE C480
R516 30R 0.22uF Y5V
+8V
14
19
10
7

U411A 8
ADTL082ARZ
2 -
R532 4.7K 1% 1 OUT_SR
+

3 + 2.0 Vrms
CE417 470pF COG C496
47uF/10V R533 C492 4 0.22uF Y5V
4.7K 1%
-8V ABC PCB Sàrl
R539 30R Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4
Page 85 of 89
Date: Thursday, February 14, 2008 Sheet 2 of 6
harman/kardon HS 350/650DL Service Manual

+5V

R1011
10R +5V R558 4.7K 1% R559 4.7K 1%
R538

+
CE420
10R 47uF/10V
+ C507
C519 C506 C501 CE418 470pF COG
0.1uF 0.1uF 0.1uF 47uF/10V C504
R551 30R 0.22uF Y5V

15
20
+8V

9
U414A 8

AVDDL
DVDD

AVDD

AVDDR
22 U413 ADTL082ARZ
DACS_RST# RST WM8740SEDS 2 -
1 R566 4.7K 1% 1
LRCK_OUT1 LRCLK OUT_FR

+
SCLK_OUT1 3 BITCLK VoutL+ 17 3 +
2 16 2.0 Vrms
S1DATA2 SDATA VoutL- CE422 470pF COG C520
47uF/10V R567 C516 4 0.22uF Y5V

+
MCLK_OUT 5 MCLK VmidL 18
CE419 4.7K 1%
-8V
R477 DNE 4 47uF/10V
+5V MODE8X
R484 DNE 25 21 R574 30R
MUTE ZERO
6 DIFFHW
23 12 R590 4.7K 1% R591 9.1K 1%
CSBIWO VoutR+

+
VoutR- 13
MOSI 26 MISO/DM0 CE423

+
SCK 27 SCK/DM1 VmidR 11
28 CE424 47uF/10V +15V
DAC1CS# CS/I2S 47uF/10V C529
AGNDR
AGNDL
DGND

AGND
24 470pF COG
MODE C528
R588 30R 0.22uF Y5V
+8V
14
19
10
7

U417A 8 CE427
NJM2068M 47uF 35V Bipolar D442
2 - C541 LL4148
R594 4.7K 1% 1 1nF COG
SUBWOOFER

+
3 + R597 100R 2.0 Vrms
CE425 470pF COG C534
47uF/10V R595 C533 4 0.22uF Y5V
9.1K 1% R598 D443
-8V
47K LL4148
R596 30R

-15V C
U417B 4.7K Q404
NJM2068M DTC343TK
6 - B E
7
5 + MUTE_SUB

+5V Q402 R593

8550

t
2 3 1 2 SUB_TRIGGER
JK-MSMD010

C527

1
0.1uF D437 R592 C532
R586 R585 LL4148 47K 0.1uF
10K 1K

3
+3.3V
R589 Q403
1 BSS123

10K

2 ABC PCB Sàrl

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4
Page 86 of 89
Date: Thursday, February 14, 2008 Sheet 3 of 6
 harman/kardon HS 350/650DL Service Manual

R429 46.4K 1% R430 1K

C412 +VP
150pF/200V
C411 .001uF C410 .001uF C414 +VP
+8V R428 5.1K 1% D404 1N4448HWS 0.1uF/200V
R437
5.49K 1% R432
R420 R445 C425 IRS20955STRPbF 10K 1%

1
5
6
7
300R 47R 10uF/25V Y5U U404 R422
5.1K 1% R421 30K C415
C426 Q405 0.1uF 100V X7R
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE436 +
470uF

3
4
2 CSD VB 15
C424 R433
CE401 2.2uF/50V 3 14 C417 100K L404 22uH
47uF 35V Bipolar U403B R446 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 L_CH
R444 1K 1% VSS VS
OUT_FL 6 -

1
7 5 12 C560
NC NC

1
5
6
7
R439 4.7K 1% 5 R600 470pF 1kV
+ JK60-050
6 11
MCU_SYNC_CLK
VREF VCC Q406 R441 t C428
C429 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
C421 R436 22K 47pF OCSET LO

2
47pF

3
4
8 DT COM 9
C418 R1012 R425
D407 D406 D408 R447 D401 75K R438 10R 1% 2W
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 1N4448HWS 100K CE437 +
470uF
R419 1R
C419
0.47uF 100v Poly
R449 R440 C413
3.3K 1% R443 5.6K 1% C427
R431 10K D405 LL4148 4.7K 1% R424 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C422
12V_BIAS 0.1uF/200V -VP

R461 46.4K 1% R462 1K

C434 +VP
150pF/200V
C439 +VP
C433 .001uF C432 .001uF +8V R456 5.1K 1% D411 1N4448HWS 0.1uF/200V
R469
5.49K 1% R464
R479 C448 IRS20955STRPbF 10K 1%

1
5
6
7
R451 47R 10uF/25V Y5U U406 R453
C440
300R 5.1K 1% R452 30K
0.1uF 100V X7R
C450 Q407
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE438 +
470uF

3
4
2 CSD VB 15
C447 R470
CE406 2.2uF/50V 3 14 C437 100K L406 22uH
47uF 35V Bipolar U405B R480 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 SL_CH
R478 1K 1% VSS VS
OUT_SL 6 -

1
7 5 12 C561
NC NC

1
5
6
7
R473 4.7K 1% 5 470pF 1kV
+ R601
6 11
MCU_SYNC_CLK
VREF VCC Q408 R475 JK60-050 t C452
C451 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
C443 R468 22K 47pF OCSET LO

2
47pF

3
4
8 DT COM 9
C438 R1013
D414 D412 D415 R481 D410 75K R471 R455
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 1N4448HWS 100K CE439 + 10R 1% 2W
470uF
R454 1R

C441
R482 R474 C435 C449 0.47uF 100v Poly
3.3K 1% R476 5.6K 1% 0.1uF 100V X7R
R463 10K D413 LL4148 4.7K 1% R458 1R 2.2uF/50V
MUTE_IRS#
C444
12V_BIAS 0.1uF/200V -VP

ABC PCB Sàrl

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C Page 87 of 89 1.4

Date: Thursday, February 14, 2008 Sheet 4 of 6

 harman/kardon HS 350/650DL Service Manual

R528 46.4K 1% R529 1K

C485 +VP
150pF/200V
C484 .001uF C481 .001uF C489 +VP
+8V R535 R523 5.1K 1% D425 1N4448HWS 0.1uF/200V
5.49K 1%
R531
R519 R546 C498 IRS20955STRPbF 10K 1%

1
5
6
7
300R 47R 10uF/25V Y5U U412 R521
C490
5.1K 1%
0.1uF 100V X7R
C499 R520 30K Q411
10uF/25V Y5U 1 16 2 IRF6645TRPbF
VDD CSH CE440 +
470uF

3
4
2 CSD VB 15
C497 R536
CE421 2.2uF/50V 3 14 C486 100K L410 22uH
47uF 35V Bipolar U411B R547 IN HO 10uF/50V
ADTL082ARZ 1K 4 13 SR_CH
R545 1K 1% VSS VS
OUT_SR 6 -

1
7 5 12 C562
NC NC

1
5
6
7
R540 4.7K 1% 5 470pF 1kV
+ R602
6 11
MCU_SYNC_CLK
VREF VCC Q412 R542 JK60-050 t C482
C502 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R534 22K 47pF OCSET LO

2
C493

3
4
8 DT COM 9
47pF C487 D423 R1014 R544
D428 D427 D429 R548 1N4448HWS 75K R537 10R 1% 2W
LL4148 LL4148 LL4148 7.87K 1% 10uF/50V 100K CE441 +
470uF
R522 1R C495
0.47uF 100v Poly

R549 R543 R541 5.6K 1% C488

3.3K 1% 4.7K 1% C500
R530 10K D426 LL4148 R525 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C494
12V_BIAS 0.1uF/200V -VP

R561 46.4K 1% R562 1K

C509 +VP
150pF/200V
C508 .001uF C505 .001uF C513 +VP
R569 R560 5.1K 1% D432 1N4448HWS 0.1uF/200V
+8V 5.49K 1%
R564
R553 C522 IRS20955STRPbF 10K 1%

1
5
6
7
300R R577 10uF/25V Y5U U415 C514
47R R555 0.1uF 100V X7R
5.1K 1% R554 30K Q413
C524 1 16 2 IRF6645TRPbF
10uF/25V Y5U VDD CSH CE442 +
470uF

3
4
2 CSD VB 15
C521 R565
CE426 2.2uF/50V 3 14 C510 100K L412 22uH
47uF 35V Bipolar U414B IN HO 10uF/50V
ADTL082ARZ R578 4 13 R_CH
R576 1K 1% 1K VSS VS
OUT_FR 6 -

1
7 5 12 C563
NC NC

1
5
6
7
R571 4.7K 1% 5 470pF 1kV
+ R603
6 11
MCU_SYNC_CLK C526 VREF VCC Q414 R575 JK60-050 t C515
47pF 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R568 22K OCSET LO

2
C517

3
4
8 DT COM 9
47pF D436 C511 D431 R1015 R581
D435 D434 LL4148 R579 1N4448HWS 75K R570 10R 1% 2W
LL4148 LL4148 7.87K 1% 10uF/50V 100K CE443 +
470uF
R552 1R
C523
0.47uF 100v Poly
R582 R580 R572 5.6K 1% C512
3.3K 1% 4.7K 1% C525
R563 10K D433 LL4148 R557 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C518
12V_BIAS 0.1uF/200V -VP

ABC PCB Sàrl

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4
Page 88 of 89
Date: Thursday, February 14, 2008 Sheet 5 of 6
 harman/kardon HS 350/650DL Service Manual

R496 46.4K 1% R497 1K

C461 +VP
150pF/200V
C460 .001uF C456 .001uF C464 +VP
R504 R495 5.1K 1% D418 1N4448HWS 0.1uF/200V
+8V 5.49K 1%
R499
R487 C472 IRS20955STRPbF 10K 1%

1
5
6
7
300R R513 10uF/25V Y5U U409 R489
47R 5.1K 1% C465
R488 30K Q409 0.1uF 100V X7R
C475 1 16 2 IRF6645TRPbF
10uF/25V Y5U VDD CSH CE444 +
470uF

3
4
2 CSD VB 15
C471 R500
CE414 2.2uF/50V 3 14 C462 100K L408 22uH
47uF 35V Bipolar U408B IN HO 10uF/50V
ADTL082ARZ R514 4 13 C_CH
R512 1K 1% 1K VSS VS
OUT_C 6 -

1
7 5 12 C564
NC NC

1
5
6
7
R507 4.7K 1% 5 470pF 1kV
+ R604
6 11
MCU_SYNC_CLK C476 VREF VCC Q410 R511 JK60-050 t C477
47pF 7 10 2 IRF6645TRPbF 1R 0.33uF 100v Poly
R503 22K OCSET LO

2
C467

3
4
8 DT COM 9
47pF D422 C463 D417 R1016
D421 D420 LL4148 R515 1N4448HWS 75K R505 R492
LL4148 LL4148 7.87K 1% 10uF/50V 100K CE445 + 10R 1% 2W
470uF
R486 1R
C469
0.47uF 100v Poly
R517 R508 5.6K 1% C457
3.3K 1% R510 C473
R498 10K D419 LL4148 4.7K 1% R491 1R 2.2uF/50V 0.1uF 100V X7R
MUTE_IRS#
C468
0.1uF/200V -VP
12V_BIAS

+VP

R1006 D448
R1004 20K LL4148
1K
D449
R1007
1K
1

Q415
2SA1037AKR LL4148
3 2

+ CE435
R1005 R1008 100uF/50V
3

100K 100K
1

Q416
2SC5866
2

ABC PCB Sàrl

Harman Kardon drawn by Ch. du Saux 17
CH-1131 Tolochenaz

Title
5329C audio amp board for HS350 & HS650

Size Document Number Rev

A3 013_02_200 5329C 1.4
Page 89 of 89
Date: Thursday, February 14, 2008 Sheet 6 of 6