PCM BX06 INSTALLATION MANUAL
. Cabinet fixation
Before the installation, take down the four wheels from the equipment bottom. The cabinet
will be located according to the design drawing. Mark the connection holes for the cabinet (four
holes). Then move away the cabinet. And Use percussion drill to drill holes according to the
measurement of expansion bolts. you need to clean the dust inside the holes using a vacuum
cleaner. Strike directly on the expansion tube with a rubber hammer until it is completely inserted
into the ground. Put the cabinets to the designed position. Put washers and tighten the bolt. When
the cabinet is fixed, it should be stable and its vertical deviation shall not be larger than 3mm..(if
installing Cabinet on the ESD-Preventive Floor, there must be bracket.)
. Connect the power line
Power supply: -48V(36-72V)
+VBATred power cable; -VBATblack cable; F.G
yellow cable
(1)The ordinary system uses -48V DC power. The diameter of the power line
depends on the load. Usually the transect size should not be less than 1.5mm 2.
(2)Among the three-line port of the power, +VBAT is linked with -48V high
Ground and VBAT with -48V.F.G. stands for Protected Ground connected with the
ground of the room.
(3)The transect size of the ground line should not be less than 10 mm2.
(4)If there are data interfaces, measure the voltage between BX06 system and
the other ground lines of other interface data cables in the room where the
system locates after the ground lines are connected. There should be no DC or
AC voltage.
(5)The ground resistance suggested should be less than 3.Suggested resistance
in the regions with frequent thunders and lightening should be less than 1.
V-
FG
V+
. Connect 2M cable(E1 cable)
(1)E1 cable connecting indication and DDF indication inside the cabinet.
There are 4 subracks in every cabinet. There are 4 E1 in every subrack. Two
of them should be connected with the upstream station. The other two E1 should
be connected with the downstream station. See the following figure for one
cabinet. For example, A(R) and A(L) in the first(upper) subrack are the
transmitting end and the receiving end. They should be connected with the
upstream station. I(R) and I(L) in the first(upper) subrack are the
transmitting end and the receiving end. They should be connected with the
downstream station.
Page 1
See the DDF-32 figure. A to H should be connected with the upstream
station. I to P should be connected with the downstream station.
Page 2
-FPQ
A(R)
CLKOUT
I(L)
CLKOUT
B(R)
CLKIN
CLKIN
J(L)
I(R)
2M-OUT
2M-OUT
J(R)
A(L)
2M-IN
2M-IN
B(L)
CLKOUT
D(R)
C(R)
CLKOUT
K(L)
CLKIN
CLKIN
L(L)
K(R)
2M-OUT
2M-OUT
L(R)
C(L)
2M-IN
2M-IN
D(L)
E(R)
CLKOUT
CLKOUT
F(R)
M(L)
CLKIN
CLKIN
N(L)
M(R)
2M-OUT
2M-OUT
N(R)
E(L)
2M-IN
2M-IN
F(L)
G(R)
CLKOUT
CLKOUT
H(R)
O(L)
CLKIN
CLKIN
P(L)
O(R)
2M-OUT
2M-OUT
P(R)
G(L)
2M-IN
2M-IN
H(L)
DDF-32
A
I
B
J
Page 3
There are 4 subracks in every cabinet. And 2 cells in every subrack. See in
back of the cabinet, the left cell is the first cell, and the right cell is the
second one. There are four coaxial ports on every cell, namely,
CLKOUTCLKIN2MOUT and 2MIN.
2M OUT TM terminal mode 2M output or ADM up and down voice channel
mode2M Output in Direction B
2M IN
TM terminal mode 2M input or ADM up and down voice channel
mode2M input in Direction A
CLK OUT under ADM mode there is a 2M output in Direction A
CLK IN under ADM mode there is a 2M input in Direction B
Usually, the 2M interface is equipped with 75-3 coaxial cable and L9 coaxial
end.
(2) the method of making the coaxial cable connector
measure the cable length from the equipment to the customer DDF. Cut off
the superabundance of the cable. And make the cable as the following figure.
(mm)
15
4
3
inside conductor
insulating
scarfskin
metal
shield
()Sheath the crimple part outside the insulating scarfskin of cable. Put the
shield metal between the crimple part and the buckle cap, and impact the
crimple part and the buckle cap together, screw the crimple part and coaxial
terminal tightly. Solder the inside conductor and the coaxial terminal firm. In
the end screw the cap of the coaxial terminal tightly.
buckle cap
scarfskin
insulatingcrimple
part
shield metal
jointing
terminal
the following figure is the final connector. And it must be passed the
continuity test.
Page 4
coaxial
3test the cable and the coaxial cable connector
After hardware loop of an E1 on the side of DDF, we can use a multimeter to
do the continuity test on the side of equipment.
. Turn on the power
Measure the voltage at the port of the power line with a multimeter. Make
sure the voltage falls into the range of -48V10%,the polarity is correct, and
the protected ground is properly connected with the room ground.
Turn on the power of the equipment and the four indicative lamps on the
power plate are alight. If abnormal phenomena arise, check the system.
When the system begins self-detection, all the indicative lamps on the
DEMUX plate are on and then distinguish one by one. If the system works well,
no warning will arise.
If there is a RLS warning, check if the local 2M cable is correctly
connected.
If there is a AIS warning, check if the opposite system has started, the
opposite 2M cable is properly and reliably connected, and the transmission
equipment works well.
If there is a FLA warning, check if the 2M cable is properly and reliably
connected and the transmission equipment works well.
. PCM id plan (55 sets of PCM cabinets, 4 subracks in every cabinet, 2
cells in every subrack. See in front of the cabinet, the right cell is the
first cell, and the left cell is the second one. As an example of ALGER ESTs
upper subrack, cell address of the right cell is 1. and the cell address of the
left cell is 2.)
Site name
Subrack number
#48
ALGER EST
ALGER EST1(upper-1)
ALGER EST2(second-2)
ALGER EST3(third-3)
ALGER EST4(lower-4)
EI KALA1
EI KALA2
EI KALA3
EI KALA4
EI AOUINET1
EI AOUINET2
EI AOUINET3
EI AOUINET4
GUELMA1
GUELMA2
#1
EI KALA
#2
EI AOUINET
#3
GUELMA
Page 5
Gateway(
network)
address
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Cell(equip
ment)
address
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
remark
#4
TEBESSA
#5
OATHAMANIA
#6
BATNA
#7
DARGUINAH
#8 JIJEL
#9 BBA
#10 SI
MUSTAPHA
#11 BENI
MERED
#12 ARBAA
#13
BEROUAGHIA
GUELMA3
GUELMA4
TEBESSA1
TEBESSA2
TEBESSA3
TEBESSA4
OATHAMANIA1
OATHAMANIA2
OATHAMANIA3
OATHAMANIA4
BATNA1
BATNA2
BATNA3
BATNA4
DARGUINAH1
DARGUINAH2
DARGUINAH3
DARGUINAH4
JIJEL1
JIJEL2
JIJEL3
JIJEL4
BBA1
BBA2
BBA3
BBA4
SI MUSTAPHA1
SI MUSTAPHA2
SI MUSTAPHA3
SI MUSTAPHA4
BENI MERED1
BENI MERED2
BENI MERED3
BENI MERED4
ARBAA1
ARBAA2
ARBAA3
ARBAA4
BEROUAGHIA1
BEROUAGHIA2
BEROUAGHIA3
BEROUAGHIA4
Page 6
1
1
1
1
1
1
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
3
3
3
3
3
3
3
3
3
3
3
3
3
3
3
3
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
#14 BOUIRA
#15 TIZI
OUZOU
#16
MASSCARA
#17 MOST AG
#18 AIN
TEMOCHENT
#19 TLEMCEN
#20 TIARET
#21
TISSEMSLIT
#22 EI
BAYADH
#23 NAAMA
#24 BECHAR
BOUIRA1
BOUIRA2
BOUIRA3
BOUIRA4
TIZI OUZOU1
TIZI OUZOU2
TIZI OUZOU3
TIZI OUZOU4
MASSCARA1
MASSCARA2
MASSCARA3
MASSCARA4
MOST AG1
MOST AG2
MOST AG3
MOST AG4
AIN TEMOCHENT1
AIN TEMOCHENT2
AIN TEMOCHENT3
AIN TEMOCHENT4
TLEMCEN1
TLEMCEN2
TLEMCEN3
TLEMCEN4
TIARET1
TIARET2
TIARET3
TIARET4
TISSEMSLIT1
TISSEMSLIT2
TISSEMSLIT3
TISSEMSLIT4
EI BAYADH1
EI BAYADH2
EI BAYADH3
EI BAYADH4
NAAMA1
NAAMA2
NAAMA3
NAAMA4
BECHAR1
BECHAR2
Page 7
3
3
3
3
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
5
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
#25
TILGHEMT
#26
GHARDAIA
#27 EI OUED
#28 EI KSEUR
#29
GHAZAOUET
#30 KHERBA
#31 OUARGLA
#32 OUED
FAYET
#33 BARIKA
#34 BENI SAF
BECHAR3
BECHAR4
TILGHEMT1
TILGHEMT2
TILGHEMT3
TILGHEMT4
GHARDAIA1
GHARDAIA2
GHARDAIA3
GHARDAIA4
EI OUED1
EI OUED2
EI OUED3
EI OUED4
EI KSEUR1
EI KSEUR2
EI KSEUR3
EI KSEUR4
GHAZAOUET1
GHAZAOUET2
GHAZAOUET3
GHAZAOUET4
KHERBA1
KHERBA2
KHERBA3
KHERBA4
OUARGLA1
OUARGLA2
OUARGLA3
OUARGLA4
OUED FAYET1
OUED FAYET2
OUED FAYET3
OUED FAYET4
BARIKA1
BARIKA2
BARIKA3
BARIKA4
BENI SAF1
BENI SAF2
BENI SAF3
BENI SAF4
Page 8
5
5
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
6
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
7
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
#35 ZAHANA
#36
TOUGGOURT
#37 SKIKDA
#38 EI KHEMIS
#39 SBA
#40 EI HASSI
#41 BISKRA
#42 HASSI
MESSOUD
#43 SAIDA
#44 RELIZANE
#45 MARSAT
ZAHANA1
ZAHANA2
ZAHANA3
ZAHANA4
TOUGGOURT1
TOUGGOURT2
TOUGGOURT3
TOUGGOURT4
8
8
8
8
8
8
8
8
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
SKIKDA1
SKIKDA2
SKIKDA3
SKIKDA4
EI KHEMIS1
EI KHEMIS2
EI KHEMIS3
EI KHEMIS4
SBA1
SBA2
SBA3
SBA4
EI HASSI1
EI HASSI2
EI HASSI3
EI HASSI4
BISKRA1
BISKRA2
BISKRA3
BISKRA4
HASSI MESSOUD1
HASSI MESSOUD2
HASSI MESSOUD3
HASSI MESSOUD4
SAIDA1
SAIDA2
SAIDA3
SAIDA4
RELIZANE1
RELIZANE2
RELIZANE3
RELIZANE4
MARSAT1
MARSAT2
8
8
8
8
8
8
8
8
8
8
8
8
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
9
10
10
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
5/6
7/8
9/10
11/12
13/14
15/16
17/18
19/20
21/22
23/24
25/26
27/28
29/30
31/32
33/34
35/36
37/38
39/40
1/2
3/4
Page 9
MARSAT3
10
5/6
MARSAT4
10
7/8
#46 M SILA
M SILA1
10
9/10
M SILA2
10
11/12
M SILA3
10
13/14
M SILA4
10
15/16
#47 DJELFA
DJELFA1
10
17/18
DJELFA2
10
19/20
DJELFA3
10
21/22
DJELFA4
10
23/24
#49 KOUBA
KOUBA1
10
25/26
KOUBA2
10
27/28
KOUBA3
10
29/30
KOUBA4
10
31/32
#50 AIN BEIDA
AIN BEIDA1
10
33/34
AIN BEIDA2
10
35/36
AIN BEIDA3
10
37/38
AIN BEIDA4
10
39/40
#51 AIN
AIN MLILA1
11
1/2
MLILA
AIN MLILA2
11
3/4
AIN MLILA3
11
5/6
AIN MLILA4
11
7/8
#52 KHROUB
KHROUB1
11
9/10
KHROUB2
11
11/12
KHROUB3
11
13/14
KHROUB4
11
15/16
#53 R DJAMEL
R DJAMEL1
11
17/18
R DJAMEL2
11
19/20
R DJAMEL3
11
21/22
R DJAMEL4
11
23/24
#54 EI
EI HADJAR1
11
25/26
HADJAR
EI HADJAR2
11
27/28
EI HADJAR3
11
29/30
EI HADJAR4
11
31/32
#55 OUED SLY
OUED SLY1
11
33/34
OUED SLY2
11
35/36
OUED SLY3
11
37/38
OUED SLY4
11
39/40
(1)setting method of gateway(network) address(Bx06)
There are two groups of eight jumper blocks in the top right corner of the
Demux board. The lower eight jumper blocks is for gateway(network) address.
The values of the eight jumper blocks are 128, 64, 32, 16, 8, 4, 2, 1 from the
Page 10
top down after their short-circuiting. The summation of the eight jumper
blocks value is the value of gateway address.
(2) setting method of cell(equipment) address(Bx06)
There are two groups of eight jumper blocks in the top right corner of the
Demux board. The upper eight jumper blocks is for cell(equipment) address.
The values of the eight jumper blocks are 128, 64, 32, 16, 8, 4, 2, 1 from the
top down after their short-circuiting. The summation of the eight jumper
blocks value is the value of cell address.
. Connect the user cable
Lay the cable on demand of the subscribers.
Mark the beginning and the end of the cable before laying to avoid confusion.
The cable mustnt be left parallel with the power line by all means when laying. Resort
to protective sleeves when the cable going through walls. Take care not to destroy the
dressing of cable in the process of laying. Remain a little at the distribution frame and
the cabinet.
Cable, which needs to be mounted onto the distribution frame should be locked onto the
distribution frame according to their spectrum. The impending wire pair of each cable
neednt to be tied to the distribution frame so as not to invite confusion (eg. the
blue/white pair of the first 7 channel subscriber cable). Take care about that every path
of the pair should be tied together and its distribution frame should be well marked
Every user cable consists of sixteen audio cables. Each cable provides eight voice
channels. The audio cable is made up of two 30-line cables arranged in color spectrum
order. Plug the user line into the corresponding sockets on the back board.
Plug in SUBLINE/TLINK for phone service. Plug in 2W/4W for 2/4 line audio service.
The audio cable marked with 4WR stands for Four Line Reception whose output line is
connected with the reception port of the user equipment. The audio cable marked with
2W4WT stands for two line audio output or Four Line Transmission whose output
Page 11
line is connected with the transmission port of the user equipment.
.Check the line
With a piece of binding wire, bind the coaxial cable, power line, flexible cable and so on
to inactive frame of the chassis and the cabinet. Its better to lay the power line and the
flexible cable into the groove. Note: the flexible cable is fragile, handle them with
care. Dont fasten it too tightly when fixing the flexible cable.
All the cable should be either horizontal or vertical, and should be fastened and fixed
tightly with nylon grip or gummed tape. Lines should be parallel, no crossover or knot
permitted. At the turning points, it should trace a right angle (90). All cables must share
the same length from the distribution frame.
Check the wire on the line shelf in the same way of ordinary phone service line
checking.
. Appendix
Table of cable output line
Cable in common use
1User cable:
Plug typeDB62 pin-welded linear plug
Cable typeOne-end cable
Cable16-line audio cable 8X2X0.4
Table of output line
Channel
number
Pin number A
of DB62 plug
Color
of the
line
Pin number B
of DB62 plug
Color of the
line
CH1
43
Blue
22
Black circle
in blue
CH2
46
Red
Black circle
in red
CH3
25
Green
Black circle
in green
CH4
47
Brown
27
Black circle
in brown
CH5
49
Grey
Black circle
in grey
CH6
28
Yellow
Black circle
in yellow
Page 12
CH7
51
White
30
Black circle
in white
CH8
53
Pink
Black circle
in pink
Notice The voice channel output line goes out from CH2 and the CH1
keeps disconnected when used for BX06 channel 1-7 and 16-22.
2 E&M cable:
Plug typeDB62 pin-welded linear plug
Cable32-line audio cable 16X2X0.4
Table of output line
Chan
nel
Pin Colo
numb number r of
er
of
the
DB62 line
plug
(1E)
Cable 1
Pin
number
of
DB62
plug
(1M)
Cable 2
Colo Pin Colo
Pin
Colo
r of number r of numbero r of
the
of
the f DB62 the
line DB62 line plug line
plug
(2M)
(2E)
Pin
number
of
DB62
plug
(3E)
Colo Pin Colo
r of number r of
the
of
the
line DB62 line
plug
(3M)
Pin
number
of
DB62
plug
(SG)
Colo Pin Colo
r of number r of
the
of
the
line DB62 line
plug
(SB)
CH1
43
Blue
circ
le
in
whit
e
44
whit
e
circ
le
in
blue
22
Brow
n
circ
le
in
Red
23
Red
circ
le
in
Brow
n
Blue
circ
le
in
whit
e
whit
e
circ
le
in
blue
38
Brow
n
circ
le
in
Red
59
Red
circ
le
in
Brow
n
CH2
45
Oran
ge
circ
le
in
whit
e
46
whit
e
circ
le
in
oran
ge
24
Grey
circ
le
in
Red
25
Red
circ
le
in
Grey
Oran
ge
circ
le
in
whit
e
whit
e
circ
le
in
oran
ge
39
Grey
circ
le
in
Red
60
Red
circ
le
in
Grey
CH3
47
Gree
n
circ
le
in
whit
e
48
whit
e
circ
le
in
gree
n
26
Blue
circ
le
in
Blac
k
27
Blac
k
circ
le
in
Blue
Gree
n
circ
le
in
whit
e
whit
e
circ
le
in
gree
n
40
Blue
circ
le
in
Blac
k
61
Blac
k
circ
le
in
Blue
CH4
49
Brow
n
circ
le
in
whit
50
Whit
e
circ
le
in
Brow
28
Oran
ge
circ
le
in
Blac
29
Blac
k
circ
le
in
Oran
Brow
n
circ
le
in
whit
Whit
e
circ
le
in
Brow
41
Oran
ge
circ
le
in
Blac
62
Blac
k
circ
le
in
Oran
Page 13
ge
ge
CH5
51
Grey
circ
le
in
whit
e
52
Whit
e
circ
le
in
Grey
30
Gree
n
circ
le
in
Blac
k
31
Blac
k
circ
le
in
Gree
n
Grey
circ
le
in
whit
e
10
Whit
e
circ
le
in
Grey
42
Gree
n
circ
le
in
Blac
k
21
Blac
k
circ
le
in
Gree
n
CH6
53
Blue
circ
le
in
red
54
Red
circ
le
in
Blue
32
Brow
n
circ
le
in
Blac
k
33
Blac
k
circ
le
in
Brow
n
11
Blue
circ
le
in
red
12
Red
circ
le
in
Blue
18
Brow
n
circ
le
in
Blac
k
17
Blac
k
circ
le
in
Brow
n
CH7
55
Oran
ge
circ
le
in
red
56
Red
circ
le
in
Oran
ge
34
Grey
circ
le
in
Blac
k
35
Blac
k
circ
le
in
Grey
13
Oran
ge
circ
le
in
red
14
Red
circ
le
in
Oran
ge
20
Grey
circ
le
in
Blac
k
19
Blac
k
circ
le
in
Grey
CH8
57
Gree
n
circ
le
in
red
58
Red
circ
le
in
Gree
n
36
Blue
circ
le
in
Yell
ow
37
Yell
ow
circ
le
in
Blue
15
Gree
n
circ
le
in
red
16
Red
circ
le
in
Gree
n
Blue
circ
le
in
Yell
ow
Notice The voice channel output line goes out from CH2 and the CH1
keeps disconnected when used for BX06 channel 1-7 and 16-22.
3 Audio cable:
Plug typeDB62 pin-welded linear plug
Cable32-line audio cable 16X2X0.4
Table of output line
Channel
number
Pin
numberof
DB62 plug
(2W/4WT)
Color of
the line
Pin
numberof
DB62 plug
(2W/4WT)
Color of
Pin
Color of
Pin
Color of
the line numberof the line numberof the line
DB62 plug
DB62 plug
(4WR)
(4WR)
CH1
43
Blue
circle in
white
44
white
circle in
blue
45
Blue
circle in
white
46
white
circle
in blue
CH2
22
Orange
circle in
23
white
circle in
24
Orange
circle in
25
white
circle
Page 14
Yell
ow
circ
le
in
Blue
white
orange
white
in orange
CH3
Green
circle in
white
white
circle in
green
Green
circle in
white
white
circle
in green
CH4
47
Brown
circle in
white
48
White
circle in
Brown
49
Brown
circle in
white
50
White
circle
in Brown
CH5
26
Grey
circle in
white
27
White
circle in
Grey
28
Grey
circle in
white
29
White
circle
in Grey
CH6
Blue
circle in
red
Red
circle in
Blue
Blue
circle in
red
Red
circle
in Blue
CH7
51
Orange
circle in
red
52
Red
circle in
Orange
53
Orange
circle in
red
54
Red
circle
in Orange
CH8
30
Green
circle in
red
31
Red
circle in
Green
32
Green
circle in
red
33
Red
circle
in Green
CH9
Brown
circle in
Red
10
Red
circle in
Brown
11
Brown
circle in
Red
12
Red
circle
in Brown
CH10
55
Grey
circle in
Red
56
Red
circle in
Grey
57
Grey
circle in
Red
58
Red
circle
in Grey
CH11
34
Blue
circle in
Black
35
Black
circle in
Blue
36
Blue
circle in
Black
37
Black
circle
in Blue
CH12
13
Orange
circle in
Black
14
Black
circle in
Orange
15
Orange
circle in
Black
16
Black
circle
in Orange
CH13
59
Green
circle in
Black
60
Black
circle in
Green
61
Green
circle in
Black
62
Black
circle
in Green
CH14
38
Brown
circle in
Black
39
Black
circle in
Brown
40
Brown
circle in
Black
41
Black
circle
in Brown
CH15
17
Grey
circle in
Black
18
Black
circle in
Grey
19
Grey
circle in
Black
20
Black
circle
in Grey
4NX64K data cable:
Plug typeone DB62 pin-welded linear plug and two M34 hole style plug
Page 15
Cable type: two-end cable, one with two
Cable32-line audio cable 16X2X0.4
Table of output line
No
Pin number of
DB62 plug
Definition
of output
line
Color of the Pin number Color of the Pin number
line
of M34 hole
line
of M34 hole
style plug
style plug
43
DINDTE+
white circle
in blue
22
DINDTE-
Blue circle
in white
SCT+
white circle
in orange
45
SCT-
Orange
circle in
white
AA
24
DODCE+
white
circle in
green
DODCE-
Green circle
in white
47
CKODCE+
White circle
in Brown
26
CKODCE-
Brown circle
in white
CKINDTE+
White circle
in Grey
10
49
CKINDTE-
Grey circle
in white
11
53
GND
Green circle
in Red
12
32
DINDTE+
Red circle
in Brown
13
11
DINDTE-
Brown circle
in Red
14
55
SCT+
Red circle
in Grey
15
34
SCT-
Grey circle
in Red
AA
16
13
DODCE+
Black circle
in Blue
17
57
DODCE-
Blue circle
in Black
Page 16
18
36
CKODCE+
Black circle
in Orange
19
15
CKODCE-
Orange
circle in
Black
20
38
CKINDTE+
Black circle
in Green
21
39
CKINDTE-
Green circle
in Black
22
53
GND
Blue circle
in Yellow
Notice Set C-D and E-F-H of the M34 plug in short circuit.
5V24 data cable:
Plug typeone DB62 pin-welded linear plug and four DB9 hole style plug
Cable type: two-end cable, one with four
Cable4-line data cable
Table of output line
Color
Pin
Color Pin number Color
Pin
Color Pin number
of number of of
of DB9
of number of of
of DB9
the
DB9
the
plug
the
DB9
the
plug
line plug line
line
plug
line
No
Pin
number of
DB62 plug
43
RX1
Red
TX1
Green
24
RX2
Red
47
TX2
Green
RX3
Red
28
TX3
Green
51
RX4
Red
TX4
Green
38
GND
Black
Black
Black
Black
6485 data cable:
Plug typeone DB62 pin-welded linear plug and four DB9 hole style plug
Cable type: two-end cable, one with four
Cable4-line data cable
Table of output line
No
Pin number of DB62 Definition of
plug
the output line
Cable 1
43
RX1+
Blue
22
RX1-
Red
TX1+
Green
45
TX1-
Brown
Page 17
Cable 2
Cable 3
Cable 4
24
RX2+
Blue
RX2-
Red
47
TX2+
Green
26
TX2-
Brown
RX3+
Blue
10
49
RX3-
Red
11
28
TX3+
Green
12
TX3-
Brown
13
51
RX4+
Blue
14
32
RX4-
Red
15
TX4+
Green
16
53
TX4-
Brown
17
38
GND
Black
Black
Black
Black
7G703 data cable:
Plug typeone DB62 pin-welded linear plug
Cable type: one-end cable, one with four
Cable9-line data cable
Table of output line
No
Pin number of DB62 Definition of
plug
the output line
Cable 1
Cable 2
Cable 3
Cable 4
43
INP1
Blue
22
INN1
Red
OUTP1
Green
45
OUTN1
Brown
24
INP2
Blue
INN2
Red
47
OUTP2
Green
26
OUTN2
Brown
INP3
Blue
10
49
INN3
Red
11
28
OUTP3
Green
12
OUTN3
Brown
13
51
INP4
Blue
14
32
INN4
Red
15
OUTP4
Green
16
53
OUTN4
Brown
17
38
GND
Black
Black
Black
8 V35 data cable:
Plug typeone DB62 pin-welded linear plug and four M34 hole style plug
Page 18
Black
Cable type: two-end cable, one with four
Cable32-line audio cable 16X2X0.4
Table of output line
No
Pin number
of DB62
plug
Color of the
line
Pin number
of M34
plug
43
white circle in
blue
22
Blue circle in
white
white circle in
orange
45
Orange circle in
white
24
white circle in
green
Green circle in
white
47
White circle in
Brown
26
Brown circle in
white
White circle in
Grey
10
49
Grey circle in
white
11
28
Red circle in
blue
12
Blue circle in
Red
13
51
Red circle in
Orange
14
30
Orange circle in
Red
15
Red
circle in
Green
16
53
Green circle in
Red
17
32
Red circle in
Brown
18
11
Brown circle in
Red
AA
AA
Page 19
Pin number
of M34
plug
Pin number
of M34
plug
Pin number
of M34
plug
19
55
Red circle in
Grey
20
34
Grey circle in
Red
21
13
Black circle in
Blue
22
57
Blue circle in
Black
AA
AA
23
36
Black circle in
Orange
24
15
Orange circle in
Black
25
38
Black circle in
Green
Notice Set C-D and E-F-H of the M34 plug in short circuit.
Additional data cable
The additional data cable is used to connect the data channel of
the DEMUX board with data functions
Output Plug
Primary group module 1
Primary group module 2
DATA1
DATA2
Additional data cable64K
Plug typeone DB9 hole style plug
Cable type: one-end cable, one with two
Cable9-line data cable
Table of output line
Pin number of DB9
hole style plug
Definition of
output line
Line color
of cable 1
INAP
Blue
INAN
Red
OUTAP
Green
OUTAN
Brown
INBP
Blue
INBN
Red
OUTBP
Green
OUTBN
Brown
GND
Page 20
Black
Line color of
cable 2
Black
Additional data cableV24
Plug typethree DB9 hole style plug
Cable type: two-end cable, one with two
Cable4-line data cable
Table of output line
Pin number of
DB9 hole
style plug on
the side of
BX06
Definit
ion of
output
line
Color
of the
line
Pin
number of
DB9 hole
style
plug
Color of
the line
Pin number
of DB9
hole style
plug
TX1
Green
RX1
Red
TX2
Green
RX2
Red
GND
Black
Black
1Extended NX64K data cable:(used for NX64K data plate of CHU board)
Plug typeone DB62 pin-welded linear plug and four M34 hole style plug
Cable type: two-end cable, one with two
Cable32-line audio cable 16X2X0.4
Table of output line
No
Pin number of
DB62 plug
Definition of
output line
Color of
the line
Pin number of Color of the Pin number of
M34 hole
line
M34 hole style
style plug
plug
45
DINDTE+
white
circle in
blue
46
DINDTE-
Blue circle
in white
24
SCT+
white
circle in
orange
25
SCT-
Orange
circle in
white
AA
Page 21
DODCE+
white
circle in
green
DODCE-
Green
circle in
white
49
CKODCE+
White
circle in
Brown
50
CKODCE-
Brown
circle in
white
28
CKINDTE+
White
circle in
Grey
10
29
CKINDTE-
Grey circle
in white
11
33
GND
Green
circle in
Red
12
11
DINDTE+
Red circle in
Brown
13
12
DINDTE-
Brown circle
in Red
14
57
SCT+
Red circle in
Grey
15
58
SCT-
Grey circle
in Red
AA
16
36
DODCE+
Black circle
in Blue
17
37
DODCE-
Blue circle
in Black
18
15
CKODCE+
Black circle
in Orange
19
16
CKODCE-
Orange circle
in Black
20
61
CKINDTE+
Black circle
in Green
21
62
CKINDTE-
Green circle
in Black
22
33
GND
Blue circle
in Yellow
Notice Set C-D and E-F-H of the M34 plug in short circuit.
Page 22
2 Extended V24 data cable: ( used for V2464K data plate of CHU
board)
Plug typeone DB62 pin-welded linear plug and four DB9 hole style plug
Cable type: two-end cable, one with four
Cable4-line data cable
Table of output line
Color
Pin
Color Pin number Color
Pin
Color Pin number
of number of of
of DB9
of number of of
of DB9
the
DB9
the
plug
the
DB9
the
plug
line plug line
line
plug
line
No
Pin
number of
DB62 plug
45
RX1
Red
24
TX1
Green
RX2
Red
49
TX2
Green
28
RX3
Red
TX3
Green
53
RX4
Red
32
TX4
Green
61
GND
Black
Black
Black
Page 23
Black
3 Extended 485 data cable: (used for 48564K data plate of CHU
board)
Plug typeone DB62 pin-welded linear plug and four DB9 hole style plug
Cable type: two-end cable, one with four
Cable4-line data cable
Table of output line
No
Pin number of DB62 Definition of
Cable
plug
the output line 1(DB9 pin
number)
Cable
2(DB9 pin
number)
Cable
Cable 4(DB9
3(DB9 pin pin number)
number)
45
RX1+
Blue(2)
46
RX1-
Red(3)
24
TX1+
Green(4)
25
TX1-
Brown(5)
RX2+
Blue(2)
RX2-
Red(3)
49
TX2+
Green(4)
50
TX2-
Brown(5)
28
RX3+
Blue(2)
10
29
RX3-
Red(3)
11
TX3+
Green(4)
12
TX3-
Brown(5)
13
53
RX4+
Blue(2)
14
54
RX4-
Red(3)
15
32
TX4+
Green(4)
16
33
TX4-
Brown(5)
17
61
GND
Black
Black
Black
Black
4 Extended G703 data cable: (used for G70364K data plate of CHU
board)
Plug typeone DB62 pin-welded linear plug
Cable type: one-end cable, one with four
Cable8-line data cable
Table of output line
No
Pin number of DB62 Definition of
plug
the output line
Cable 1
Cable 2
45
INP1
Blue
46
INN1
Red
24
OUTP1
Green
25
OUTN1
Brown
INP2
Blue
INN2
Red
49
OUTP2
Green
50
OUTN2
Brown
Page 24
Cable 3
Cable 4
28
INP3
Blue
10
29
INN3
Red
11
OUTP3
Green
12
OUTN3
Brown
13
53
INP4
Blue
14
54
INN4
Red
15
32
OUTP4
Green
16
33
OUTN4
Brown
17
61
GND
Black
Black
Black
Black
5Extended V35 data cable: (used for V3564K data plate of CHU board)
Plug typeone DB62 pin-welded linear plug and four M34 hole style plug
Cable type: two-end cable, one with four
Cable32-line audio cable 16X2X0.4
Table of output line
No
Pin number
of DB62
plug
Color of the
line
Pin number
of M34
plug
Pin number
of M34
plug
Pin number
of M34
plug
45
white circle in
blue
46
Blue circle in
white
24
white circle in
orange
25
Orange circle in
white
white circle in
green
Green circle in
white
49
White circle in
Brown
50
Brown circle in
white
28
White circle in
Grey
10
29
Grey circle in
white
11
Red circle in
blue
12
Blue circle in
Red
13
53
Red circle in
Pin number
of M34
plug
P
Page 25
Orange
14
54
Orange circle in
Red
15
32
Red
circle in
Green
16
33
Green circle in
Red
17
11
Red circle in
Brown
18
12
Brown circle in
Red
AA
AA
19
57
Red circle in
Grey
20
58
Grey circle in
Red
21
36
Black circle in
Blue
22
37
Blue circle in
Black
AA
AA
23
15
Black circle in
Orange
24
16
Orange circle in
Black
25
61
Black circle in
Green
Notice Set C-D and E-F-H of the M34 plug in short circuit.
Page 26
BXO6 INTEGRATED SERVICE ACCESS
EQUIPMENT
INSTRUCTION MANUAL
BEIJING XUNFENG FIBER COMMUNICATION
TECHNOLOGY DEVELOPMENT LIMITED
INCORPORATION
Page 27
Installation for Equipment
Installation conditions
Room conditions:
Long time:
temperature:5-40
humidity:<80%(30)
Short time:
temperature:0-50
humidity:<90%(30)
Power supply:
-48V(36-72V)
Page 28
