FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANT OIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING WASHER R-134a
See VESIS for oils

Jetta/Golf w/filter change 02M 01M with trans 02M 1.8 T (AWP/AW- 0.7-0.9L 3.0 L (3.2 qt) 750+50 g Golf/Jetta fr 10/98 w/
GTI 1.8T(AWP/ 2.3L (2.4 qt) New fill: 5.3L New fill: 0.75L (0.80 qt) PIA) (0.74-0.95 qt) Use concentrated (26+1.8 oz) Sandon compressor
Jetta AWPIA) 02J (5.6 qt) See VESIS for filling 5.0L (5.3 qt) use hydraulic ZVW 177 135+15 cc
Wagon Refill: approx. 1.9 (BEW) oil G 002 012 901/903/904/906
4.5L (4.8 qt) 2.0L (2.1 qt) after repairs (4.6+ 0.5 fl. oz)
3.0L (3.2 qt) 6.0L (6.3 qt) Do not use Windshield
1.9 TDI PD with trans 09A/09G new Jetta Golf from 11/98 w/
(BEW) 09A 2.0 (BEV,BBW) ATF washer container
Rear Final Drive Capacity included with also serves rear 525+ 25 g Zexel compressor
4.5L (4.8 qt) New fill: 7.0 L 5.0L (5.3 qt)
02D Automatic Transmission washer on (18.5 + 0.9 oz) 115 + 20 cc
2.0 (7.4 qt) 2.5(BGP/BGQ)
1.0L (1.1 qt) See VESIS for filling wagons (3.9 + 0.7 oz)
2005 (BEV,BBW) 9.0L(9.5 qt)
after repairs See VESIS for PAG
4.2L (4.4 qt) 09G 2.8 (BDF) oils
new 2.5 New fill: 7.0L 9.0L (9.5 qt) new Jetta
Jetta (BGP/BGQ) new Jetta
(7.4 qt) 110 + 10 cc
Approx 5.0L(5.2qt)
See VESIS (3.7 + 0.3 oz)
6.0L(6.3 qt) for filling after w/headlight
2.8 (BDF) repairs washer PAG oil
5.5L (5.8 qt) G 052 200 A2

ENGINE OIL: Approx qty! Use petroleum or synthetic(synthetic specifically for new Jetta)oils meeting VW oil quality standard: VW502 00(a must for 1.8T),
or VW500 00 or VW 501 01, ACEA A2 or A3(A3 for 1.8T), (TDI–PD) Use ONLY VW 505 01, ACEA B3/B4. Use viscosity 5W40 or if not avail 5W30.Don’t overfill!
Overfilling can cause misfire DTC’s to be stored in Engine Control Module (ECM) -J220-. To prevent overfil, add approx.0.5L less than cap, start engine,run til
eng op temperature is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See RM for details. Turbo engines only:
After changing oil and filter, start and run engine at idle til oil pressure light goes out. DON’T rev eng, this could cause damage/ failure of turbocharger.
MANUAL TRANS: 02J:Use mineral oil, SAE 75W90, Part No. G 052 726 A2, 02M: Use synthetic oil SAE 75W90, Part No. G 052 171 A2.
AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2(1 liter container) for 01M trans, G 052 990 A2(1 liter container) for 09A trans, G 055 025 A2 for
09G. Life-time filling, new fill quantity is for reference only. Only replace after repair (i.e. when removing oil pan). See Repair Manual (VESIS) for details.
DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2(1 liter container) . Life-time filling, new fill quantity is for
reference only. Only replace after repair. See Repair Manual (VESIS) for details.
COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW 237 105),GREEN
COLORED.This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must
be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),
the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.
1 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.
 FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANT OIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING WASHER R-134a


New w/filter change 02J 01M 01M 1.8T (AWV/AWP) 0.7-0.9 L 2.0L (2.1 qt) 700 + 50 g 135 cc
Beetle 1.8T (BKF/ 2.0L (2.1 qt) New fill: 5.3L New fill: 0.75L (0.80 qt) 5.0L (5.3 qt) (11.8–15.2 oz) Use concentrated (24.7 + 1.8 oz) (4.6 fl. oz)
2005 (5.6 qt)
BNU) 02M Filled for life. 1.9 (BEW) Use hydraulic ZVW 177
4.2L (4.4 qt) 2.3L (2.4 qt) Filled for life See VESIS for filling 6.0L (6.3 qt) oil G 002 012 901/903/904/906

1.9 TDI PD 09G after repairs 2.0 (BEV) Do not use

(BEW) New fill: ATF
09G 5.0L (5.3 qt)
4.5L (4.8 qt) 7.0L (7.4 qt) Included in trans. fill
2.0 (BEV) Filled for life 02E
4.2L (4.4 qt) 02E N/A
New fill:
6.4L (6.8 qt)
Refill after re-
pairs:
4.5L (4.8 qt)
See VESIS
for filling after
repairs

ENGINE OIL: Approx.quantities! Use petroleum or synthetic based oils meeting VW oil quality standard : VW502 00(a must for 1.8T) or VW 500 00 or VW501
01, ACEA A2 or A3, A3(A3 for 1.8T). TDI–PD Only use VW 505 01, ACEA B3/B4.Use viscosity 5W40 if available, 5W30 if not available. Do not overfill! Overfilling
engine oil can cause misfire DTC’s to be stored in ECM (J220). To prevent overfilling, add approx. 0.5L less than capacity, start engine and let run until engine
operating temp is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines
only: After changing oil & filter, start & run engine at idle till oil pressure light goes out. DON’T rev engine, this could cause damage/ failure of turbocharger.
MANUAL TRANS: 02J:Use mineral oil, SAE 75W90, Part No. G 052 726 A2, 02M: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2.
AUTO.TRANS: Use VW ATF, Part No. G 052 162 A2(1L)for 01M. Life-time filling, new fill quantity is for reference only. Only replace after repair (i.e. when
removing oil pan). See VESIS for details. Use G 055 025 A2 for 09G. Use G 052 182 A2 for 02E Trans.
DIFFERENTIAL AUTO.TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 A2(1L). Life-time fill, new fill qty is for ref. only. Only repl. after repair.
COOLING SYSTEM: Use phosphate-free coolant G 012 A8F A4, PURPLE COLOR. DO NOT INTERCHANGE OR MIX G11(ZVW237 105),GREEN COLOR. This
can result in serious damage to engine. However, it may be mixed with ZVW 237 G12, PINK COLOR. Frost protection is req. down to approx. -25_C (-13_F).
In areas with arctic climates, frost protection is req. down to approx. –35_C (–31_F). The coolant ratio must be a min. of 40%, as frost protection is reduced. The
recommended mixture ratio is 50:50. If greater frost protection req. (very cold climates), the amount of G 012 A8F A4 can be increased, but only up to 60%. This
provides frost protection to approx.-40_C(–40_F).Don’t reduce concentration by adding water, inwarmer seasons/countries,cooling effectiveness will be reduced.
A/C REFRIGERANT OIL: Use PAG oil, Part No. G 052 154 A2 w/Sandon compressor.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.

2 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.
 FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANTOIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING  WASHER
R-134a

New w/filter change 02M 09G Capacity included with 1.8T (AWV) 0.7-0.9L 2.0L (2.2 qt) 700 + 50 g 135 cc
Beetle 1.8T (BKF) 2.3L (2.4qt) Initial fill: 7.0L Automatic Transmission. 2.0 (BGD) (0.74-0.95qt) (24.7 +1.8 oz) (4.6 fl. oz)
Conv. 4.2L (4.4qt) 02J (7.4 qt) See VESIS for fillng after 5.0L (5.3 qt)
Filled for life, repairs
2005 2.0 (BEV) 2.0L (2.1 qt)
no change.
4.0L (4.2 qt)
See VESIS
for filling after
repairs

ENGINE OIL: Approx quantities! Use petroleum or synthetic based oils meeting VW oil quality standard:W502 00(a must for 1.8T) or VW 500 00 or VW 501
01, ACEA A2 or A3(A3 for 1.8T).API service SJ. Use viscosity 5W40 if available, 5W30 if not available. Do not overfill! Overfilling engine oil can cause misfire
DTC’s to be stored in Engine Control Module (ECM) -J220-. To prevent overfilling, add approx. 0.5L less than capacity, start engine and let run until engine operating
temperature is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details.Turbo engines
only: After changing oil & filter, start & run engine at idle till oil pressure light goes out. DON’T rev engine, this could cause damage/ failure of turbocharger.
MANUAL TRANS: 02J:Use mineral oil, SAE 75W90, Part No. G 052 726 A2, 02M: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2.
AUTOMATIC TRANS: Use VW ATF, Part No. G 055 025 A2(1 liter container). Life-time filling, initial fill quantity is for reference only. Only replace after repair
(i.e. when removing oil pan). See Repair Manual (VESIS) for details on filling after repair.
DIFFERENTIAL AUTOMATIC TRANS: Combined with Automatic Transmission. See Repair Manual(VESIS) for details on filling after repair.
COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW 237 105),GREEN
COLORED.This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must
be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),
the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
POWER STEERING: Hydraulic oil G002 000. Do not use ATF.

WINDSHIELD WASHER: Concentrated ZVW 177 901/903/904/906.

A/C REFRIGERANT OIL: Use PAG oil , Part No. G 052 154 A2 with R-134a.
Note:
Convertible top oil is: G002 000. Refer to VESIS for proper usage.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.

3 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.
 FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANT OIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING  WASHER R-134a

Passat w/filter change 012/01W 01V 01V 1.8 (AWM) Approx. 6.2L (6.6 qt) 250 cc
2005 1.8T(AWM) 2.25L (2.4 qt) New fill: 9.0L Front final drive 7.0L (7.4 qt) 1.0 L (1.1 qt) Use 600 + 25 g (8.5 fl. oz)
4.1L (4.3qt) (9.5 qt) New fill: 0.75L (0.80 qt) 2.0 (BHW) concentrated (21 + 0.9 oz)
2.0 TDI–PD Refill: approx. 01V (all-wheel drive) 7.0L (7.4 qt) ZVW 177
2.6-3.0L 901/903/904/906
(BHW) (2.7-3.2 qt) Transfer gearbox 2.8 (ATQ)
3.6L (3.8qt) New fill: 0.8L (0.85 qt) 8.0L (8.5 qt) Windshield

2.8 (ATQ) 01R Rear final drive washer container

6.0L (6.3 qt) New fill: 1.5L (1.6 qt) also serves rear
washer on
wagons

ENGINE OIL: Approximate quantities! Use high quality synthetic based oil meeting VW oil quality standard: VW502 00(a must for 1.8T) or VW 500 00 or
VW 501 01, ACEA A2 or A3(A3 for 1.8T).API service SJ. TDI–PD Only use VW 505 01. Use viscosity 5W40 if available, 5W30 if not available.Do not overfill!
Overfilling engine oil can cause misfire DTC’s to be stored in Engine Control Module (ECM) -J220-. To prevent overfilling, add approx. 0.5L less than capacity,
start engine and let run until engine operating temperature is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX.
See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine,
this could cause damage/failure of the turbocharger.
MANUAL TRANS: Use synthetic oil, SAE 75W90, Part No. G 052 911 A1
AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2(1 liter container). Life-time filling, new fill quantity is for reference only. Only replace after repair
(i.e. when removing oil pan). See Repair Manual (VESIS) for details.
DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2. Life-time filling, new fill quantities are for reference only.
Only replace after repair. See Repair Manual (VESIS) for details.
COOLING SYSTEM: Use only phosphate free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G 11(ZVW 237 105), GREEN
COLORED. This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must
be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),
the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
POWER STEERING: Hydraulic oil G 002 000. Do not use ATF.

A/C REFRIGERANT OIL: Use PAG oil with R-134a, use Part No. G 052 300 A2.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.

4 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.
 FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANT OIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING  WASHER  R-134a
(Rev 11/04)

(Rev 9/04) (Rev 9/04)

Touareg w/filter change N/A 09D OAA BAA/BHX/AXQ Fluid Cap N/A 6.0L (6.3 qt) Dual zone Dual zone
2005 BAA New fill: Front final drive 9.0L (9.5 qt) 700+50 g 200+ 10 cc
6.3L (6.7 qt) 9.0L (9.5 qt) New Fill: 1.0L (1.1 qt) BKW (24.7+1.8 0z) (6.76+ .34 fl oz)
AXQ See VESIS OAD 13.0L (13.7 qt) Four zone Four zone
7.6L (8.0 qt) for filling after Transfer box 1050 + 50g 300 cc (10 oz)
repairs
BKW New fill: 0.85L ( 0.9 qt) (37 + 1.8 oz)
(TDI – PD) OAB/OAC
11.5L (12.0 qt) New fill: 1.0L (1.1 qt)
See VESIS for filling
after repairs

ENGINE OIL: Approximate quantities! Use synthetic based oil meeting VW oil quality standard: VW502 00 or VW 505 01 or VW 500 00 ACEA A2 or A3.
Use VW 505 01 for engine code BKW. Use viscosity 5W40 if available, 5W30 if not available. Do not overfill! Overfilling engine oil can cause misfire DTC’s to
be stored in Engine Control Module (ECM) -J220-. To prevent overfilling, add approx. 0.5L less than capacity, start engine and let run until engine operating temper-
ature is approx. 60_C (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details.Turbo engines only:
After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger.
AUTOMATIC TRANS: Use VW ATF, Part No. G 055 025 A2 (1 liter container). Life-time filling, new fill quantity is for reference only. Only replace after repair
(i.e. when removing oil pan). See Repair Manual VESIS for details.
DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2 (1 liter container), for frt final/final drive. Life-time filling,
new fill quantity is for reference only. Only replace after repair. See Repair Manual VESIS for details, use G 052 162 A2 for transfer box fluid requirements.
COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW237 105),GREEN
COLORED. This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must
be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),
the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
POWER STEERING: Hydraulic oil G002 000. Do not use ATF.
WINDSHIELD WASHER: Concentrated ZVW 177 901/903/904/906.

A/C REFRIGERANT OIL: Use PAG oil, Part No. G 052 300 A2 with R-134a.

NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.

5 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.
 FLUID CAPACITY CHART

MY / ENGINE OIL
MANUAL TRANS. AUTOMATIC DIFFERENTIAL COOLING SYSTEM POWER WINDSHIELD A/C REFRIGERANT A/C REFRIGERANT OIL
VEHICLE TRANS. AUTOMATIC TRANS.  STEERING  WASHER R-134a

Phaeton w/filter change N/A 01L 01L BGJ 0.7–0.9L 6.0L 6.3 qt) 600 + 25g 200 cc + 10 cc
2005 BAP Intial fill Front final drive 9.0L (9.5 qt) (0.74–0.95 qt) Use Concentrated (21 + 0.9 oz) (6.76 + .34 fl oz)
11.8L (12.5 qt) 9.8 (10.4 qt) New fill: 1.3L (1.4 qt) BAP ZVW 177
901/903/904/906
BGH 09L Transfer gear box 17L (18 qt)
7.5L (7.9 qt) Initial fill New fill: 0.8L (0.8 qt)
9.8L (10.4 qt) 01R Rear final drive
New Fill: 1.5L (1.6 qt)
09L
Front final drive
New fill: 1.1L (1.2 qt)
Tansfer gear box
New fill: 0.55L (0.58 qt)
08Y Rear final drive
new fill: 1.1L (1.2 qt)

ENGINE OIL: Approx.quantities! Use synthetic based oil meeting VW oil quality standard: VW502 00 or VW500 00 or VW505 01 ACEA A2 or A3, API Sevice
SJ for all engines. Use oil viscosity 5W40 if avail, or 5W30 if not available. Do not overfill! Overfilling engine oil can cause misfire DTC’s to be stored in Engine Control
Module (ECM) -J220-. To prevent overfilling, add approx. 0.5L less than capacity, start engine and let run until engine operating temperature is approx. 60_C
(140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX.
AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2 (1 liter container). Life-time filling, new fill quantity is for reference only. Only replace after repair
(i.e. when removing oil pan). Use G 055005A for 09L trans. See Repair Manual VESIS for details.
DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 A2 (1 liter container). Life-time filling, new fill quantity is for
reference only. Only replace after repair. See Repair Manual VESIS for details.
COOLING SYSTEM: Use only phosphate-free coolant G 012 A8F A4, PURPLE COLORED. DO NOT INTERCHANGE OR MIX older G11(ZVW237 105),GREEN
COLORED. This can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK COLORED. Frost protection is required down
to approximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately –35_C (–31_F). The anti-freeze ratio must
be a minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates),
the amount of G 012 A8F A4 can be increased, but only up to 60%. This provides frost protection to approx. -40_C (–40_F). Do not reduce the coolant concentration
by adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced.
POWER STEERING: Hydraulic oil G002 000. Do not use ATF.
A/C REFRIGERANT OIL: Use PAG oil, Part No. G 052 300 A2 with R-134a.
NOTE: Part numbers are for reference only. Always check with your Parts Dept. for the latest parts information.

6 of 6
E 2005 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are
reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the

publisher.