DAIHATSU Sportrak EFI CAT
1990 to 1997
Engine & Running Torque Notes &
Fuel Ignition Electrical Capacities
Cooling gear settings Illustrations
DAIP6001602
Automotive
Technical
DATA Click on one of the
buttons above to view
data for this car. To
BOOK return to this screen and
make another choice,
click anywhere on the
data screen.
MENU HELP
Engine and cooling system Sportrak EFI CAT 1990 to 1997
Type HD-E SOHC 16V 70kW
Capacity (cm3) / number of cylinders 1589 / 4
Compression ratio / pressure bar 9.5 / ≥13.7
Oil pressure bar 0.19 [4.4]
Oil temperature ºC 80
Valve clearance - inlet mm 0.25 H
Valve clearance - exhaust mm 0.33 H
Firing order 1-3-4-2
No 1 cylinder position TBE
Thermostat opening temperature ºC 82 to 86
Radiator cap pressure bar 1.0
Fuel system Sportrak EFI CAT 1990 to 1997
Idle speed - manual [auto] rpm 850±50
Fast idle speed - manual [auto] rpm 1400
CO @ idle speed [3000 rpm] - see page VI % ≤0.5 N/A
HC @ idle speed [3000 rpm] - see page VI ppm ≤200
CO2 @ idle speed [3000 rpm] - see page VI % ≥14.0
O2 @ idle speed [3000 rpm] - see page VI % _
Carburettor / fuel injection Nippon Denso
Type / ref EFI
Main jet / needle _
Injection pressure bar 2.5
Pump pressure bar _
Octane rating RON 95[U]
Ignition system Sportrak EFI CAT 1990 to 1997
Type Electronic
Ignition coil Nippon Denso
Primary resistance ohms 1.4 to 1.7
Ballast resistor ohms _
Voltage - Tmnl 15(+) to earth V 12.0
Distributor Nippon Denso
Points gap (air gap) mm [0.20 to 0.40]
Dwell angle º (%) _
Condenser capacity µF _
Rotation Anticlockwise
Ignition timing - basic [static º Crankshaft @ rpm 3±2 BTDC @ 800±50
V = Vacuum NV = No Vacuum NV
Total ignition advance º Crankshaft @ rpm _
º Crankshaft @ rpm _
º Crankshaft @ rpm _
Centrifugal check. º Crankshaft @ rpm 0 @ 600
º Crankshaft @ rpm 9.5 @ 2077
º Crankshaft @ rpm 12.0 @ 3000
Vacuum range check mbar 493 to 587
Maximum vacuum advance º Crankshaft 7
Spark plugs NGK/Champion
Type BKR6E-11 / RC9YC4
Electrode gap mm 1.00 to 1.10
Electrical system Sportrak EFI CAT 1990 to 1997
Battery V / CC / RC 12 / 28Ah
Alternator voltage / full load current / engine rpm 14.2 to 14.8 / 50 / 3000
Starter motor current / voltage - cranking A/V 50 / 11.0
Starter motor current / voltage - locked A/V _
Running gear Sportrak EFI CAT 1990 to 1997
Brakes -
Front (min. friction material thickness) mm 1.0
Rear (min. friction material thickness) mm 1.0
Tyres
Saloon Size _
Estate / Van Size 195x15: 225/70x15
Pressure - front / rear - Saloon bar _
Pressure - front / rear - Estate / Van bar 1.6 / 1.6
Front suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] +1.0 to 4.0
Camber +1°±30’
Castor +2°±30’
King pin inclination +9°30’
Rear suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] _
Camber _
Torque wrench settings Sportrak EFI CAT 1990 to 1997
Cylinder head - stage 1 Nm 60
Cylinder head - stage 2 Nm _
Cylinder head - stage 3 Nm _
Cylinder head - stage 4 Nm _
Big-end bearings Nm 40
Main bearings Nm 49
Clutch cover Nm 19
Flywheel [driveplate] Nm 88
Front hubs Nm 122
Rear hubs Nm WSM
Wheel nuts / bolts Nm 95
Spark plugs Nm 18
Capacities Sportrak EFI CAT 1990 to 1997
Engine oil & filter litres 3.5
Gearbox - 4-speed [5-speed] litres 1.7. Transfer: 1.4
Automatic transmission - refill litres _
Final drive litres Front: 0.9. Rear: 2.0
Cooling system litres 5.1
Fuel tank litres 60
Notes and Illustrations
_
1: Idle speed 2: CO / Mixture
1589 cm3 1589 cm3 EFi, 1589 cm3
