Doc. No.
: 26071-100-GPP-GHX-00026
Job No. : Job No. : 26071 Rev.00A
RDMP JO Balikpapan
Project
Inspection Report
HYDRAULIC R/T CRANES
RDMP JO CONTROL
NO.
CONTRACTOR:
EQUIPMENT NUMBER: REG#: DATE:
MAKE: MODEL: S/N:
ENGINE: MODEL: S/N:
HOUR METER: ODOMETER:
(S) INSPECTED AND SATISFACTORY (R) PREPAIRED AND OR ADJUSTED (X) REQUIRES RECHECK AND OR REPAIR
OPERATOR’S CAB S R X
Step, Door Handle, Latch
Seat, Seatbelt, Cleanliness
Windshield, Cab Glass
Windshield Wiper, Washer
Fan ( Air Circulation)
Sun Visor
Speedometer
Tachometer
Audio, Visual Alarms
Indicators, Gauges
Switches
Mirrors, Rear, Left, Right
ELECTRICAL SYSTEM S R X
Headlights, Low / High Beam
Signal / Hazard Lights, Front Rear
Tail Lights, Brake Lights
Horn
Back Up Lights / Alarm
Flashing Light, Cab Mounted
Electrical System Wiring
Batteries, Covers, Hold Downs
Battery Terminals, Cables
ENGINE S R X
Oil Leaks
Coolant Leaks
Fuel Leaks
Fan, Guards, Belts
Doc. No. : 26071-100-GPP-GHX-00026
Job No. : Job No. : 26071 Rev.00A
Abnormal Exhaust Smoke
Exhaust System, Leaks, Silencer
Radiator, Leaks, Cap, Gasket
OPERATOR STATION S R X
Throttle Control
Brake Pedal
Transmission Controls
Outrigger Controls
Machine Level Indicator
Boom Hoist Control
Angle / Range Load Chart
Boom Angle indicator
Main Winch Control
Auxiliary Winch Control
Boom Extension Control
Swing & Brake Controls
Cab Swing Safety Lock
360 Degree Swing Lock
Rear Axle Oscillation Stop Locks
DRIVE TRAIN S R X
Front Axle Housing, Mounting Bolts
Steering Knuckles, Hubs, Spindles
Differential Planetaries, Seals, Leaks
Trunnion Bearings, Mounting Bolts
Rear Axle Housing, Mounting Bolts
Steering Knuckles, Hubs, Spindles
Differential Planetaries, Seals, Leaks
Trunnion Bearings, Mounting Bolts
Drives Shafts, Front, Rear
Transmission, Mountings, Seals, Leaks
Transfer Case, Mountings, Seals, Leaks
Torque Converter, Seal, Leaks
Torque Converter Drive Shaft
STEERING SYSTEM S R X
Steering Wheel, Linkage
Orbital Pump, Leaks
Control Valve, Steering Box, Oil Leaks
Follow Up Linkage
Steering Cylinders, Oil Leaks
BRAKE SYSTEM S R X
Air Hydraulic
Brake Chambers, Linings
Rotors, Pads, Calipers
Brake Tubes, Hoses, Front, Rear
Brake Test,
Doc. No. : 26071-100-GPP-GHX-00026
Job No. : Job No. : 26071 Rev.00A
Parking Brake, Test
UPPER STRUCTURE S R X
Boom Pedestal, Mounting bolts
Counterweight Mounting Bolts
Main & Auxiliary Winch Mountings
Swing Drive Motor & Brake, Noise, Leaks
Hydraulic Hoses, Connections, Leaks
Compressed Air Lines, Connections, Leaks
Swing Gear, Bearing & Pinion
BOOM ASSEMBLY S R X
Boom Angle Indicator
Base Section Inspection
Mounting Pins, Locks, Grease Fittings
Intermediate Section Inspections
Tip Section Inspection
Inner Boom slides
Outer Boom Slides
Boom Internal Cables, Chains, sheaves
Hydraulic Hoses, Connections, Leaks
Point sheaves
Load Block sheaves, SWL
Load Block, Hook, Latch, SWL
Wire Rope Condition, Anchorages
Headache Ball, Hook, Latch, SWL
CRANE HYDRAULICS S R X
Boom Lift Cylinders, Leaks
Counterbalance Valves, Leaks
Boom Extension Cylinder, Leaks
Counterbalance Valve, Leaks
Mounting Pins, Locks, Grease Fittings
Hydraulic Tubes, Hoses, Connections, Leaks
Outrigger Cylinders, Rear, Leaks
Outrigger Cylinders, Front, Leaks
Outrigger Counterbalance Valves, Leaks
Mounting Pins, Locks, Grease Fittings
Hydraulic Tubes, Hoses, Connections, Leaks
Main System
Hydraulic Pump, Leaks, Noise
Hydraulic Pump Manual Disconnect
Control Valves, Oil Leaks, Hoses
Hydraulic Tank, Oil Leaks, Cap, Seals
Tank Mountings, Straps
Hoist Motors
Main Hoist Motor, Brakes, Noise, Leaks
Auxiliary Hoist Motor, Brakes, Noise, Leaks
Doc. No. : 26071-100-GPP-GHX-00026
Job No. : Job No. : 26071 Rev.00A
Hydraulic Tubes, Hoses, Connections, Leaks
Friction drive clutch and brakes
Swivel Joint, Leaks
AIR SYSTEM S R X
Compressor, Oil Leaks, Pumping Oil
Air Tanks, Mountings, Safety Valve
Tubes, Hoses, Drain Valves
FUEL TANK S R X
Leaks, Cap, Gasket
Mounting Brackets, Straps
Fuel Lines, Connections, Leaks
SAFETY S R X
Engine Emergency Shutdown Switch
Outrigger Pads
Load Moment Indicator
LMI Manual
Operator’s Manual
Operator’s Daily Log Book
Anti Two Block Alarm / Cut out
Over Boom Alarm / Cut out
Over Hoist Alarm / Cut out
Travel, Swing Audio Alarms
Fire Extinguisher, Capacity, Date Charged
ENVIRONMENTAL S R X
Emergency Spill Kit
ACCESSORIES
Jib Boom S R X
Boom Point Extension
Pendant Lines
TIRES S R X
Front / Rear, Condition,
Front / Rear, matched
Wheels, Rims, Lock Rings
Mounting Nuts, Studs
Doc. No. : 26071-100-GPP-GHX-00026
Job No. : Job No. : 26071 Rev.00A
TIRES SIZE PLY TYPE
PERCENTAGE LEFT
Front Rear
Comments:
Use additional Pages if necessary to describe findings indicated in “X” and “R” check
boxes
Date Inspection Completed:
Contractor Rep:
Badge #:
Comment
INSPECTION STATUS Pass Hold Reject
Inspected by
Inspector 1 Inspector 2 Owner/User
