UNCLASSIFIED

DE&S Secretariat Land Equipment

Ministry DESSEC-PolSec LE-JSC-WPNS@mod.uk

of Defence
Defence Equipment & Support
Maple Oa #2043
MOD Abbey Wood
Bristol BS34 8JH

3-Nov-17 Our Reference:F012017/09738

Thank you for your e-mail dated 9 October 2017, requesting the following information:

As written in your reply, I want to specify the information:

Please have a look within the AESP 2320-D-128-302 and there specific within the ELECTRICAL
section. There must be included wiring-diagrams about the Land Rover Defender, to be more specific,
regarding the wiring of the light switch.

I am treating your correspondence as a request for information under the Freedom of Information Act
2000(FOIA).

A search for the information has now been completed within the Ministry of Defence, and I can confirm that
information in scope of your request is held. The information you have requested can be found attached.

If you have any queries regarding the content of this letter, please contact this office in the first instance.

If you wish to complain about the handling of your request, or the content of this response, you can request
an independent internal review by contacting the Information Rights Compliance team, Ground Floor, MOD
Main Building, Whitehall, SW1A 2HB (e-mail CIO-FOI-IR@mod.uk). Please note that any request for an
internal review should be made within 40 working days of the date of this response.

If you remain dissatisfied following an internal review, you may raise your complaint directly to the
Information Commissioner under the provisions of Section 50 of the Freedom of Information Act. Please note
that the Information Commissioner will not normally investigate your case until the MOD internal review
process has been completed. The Information Commissioner can be contacted at: Information
Commissioner's Office, Wycliffe House, Water Lane, Wilmslow, Cheshire, SK9 5AF. Further details of the
role and powers of the Information Commissioner can be found on the Commissioner's website at
https://ico.org.ukt.

Yours Sincerely

DE&S Secretariat Land Equipment

UNCLASSIFIED
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

CHAPTER 13-1

ELECTRICAL SYSTEMS

CONTENTS

Para

1 Introduction
2 General
3 Electrical systems
4 Engine harness assembly
6 Chassis harness assembly
8 Main cable assembly harness
10 How to use the circuit diagrams
11 Power distribution
12 Headers, splices and centre taps
13 Wire attributes
14 Connectors
15 Earth distribution
16 Line types
18 Components
19 Earth points
20 Fuses and diodes

Fig Page

1 Engine harness layout 11

2 Chassis harness layout 13
3 Main cable assembly harness layout 15
4 Power distribution 16
5 Connectors 17
6 Line types I 17
.1 7
7 Line types ii I /

8 Components 18
9 Earth points 18
10 Fuses and diodes 18
11 Earth distribution I - Non EEGR 19
12 Earth distribution II - Non EEGR 20
13 Header joints - Non EEGR 21
14 Instruments I - Non EEGR 22
15 Instruments II - Non EEGR 23
16 Power distribution 1- Non EEGR 24
17 Power distribution II - Non EEGR 25
18 Power distribution III - Non EEGR 26
19 Splices and centre taps 1- Non EEGR 27
20 Splices and centre taps II - Non EEGR 28
21 Splices and centre taps III - Non EEGR 29
22 Charging and starting 1- Non EEGR 30
23 Charging and starting II - Non EEGR 31
24 Interior illumination - Non EEGR 32
25 Indicators and Hazards 1— Non EEGR 33
26 Indicators and Hazards 11— Non EEGR 34
27 Earth distribution 1- EEGR 35
28 Earth distribution 11- EEGR 36

(continued)

Chap 13-1
Aug 00 (Amdt 1) Page 1
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

CONTENTS (continued)

Fig Page

29 Header joints - EEGR 37

30 Instruments I - EEGR 38
31 Instruments II - EEGR 39
32 Power distribution I - EEGR 40
33 Power distribution II - EEGR 41
34 Power distribution III - EEGR 42
35 Splices and centre taps I - EEGR 43
36 Splices and centre taps II - EEGR 44
37 Splices and centre taps III - EEGR 45
38 Splices and centre taps IV - EEGR 46
39 Charging and starting I - EEGR 47
40 Charging and starting II - EEGR 48
41 Interior illumination - EEGR 49
42 Indicators and Hazards I - EEGR 50
43 Indicators and Hazards II - EEGR 51
44 EEGR 52
45 Brake reverse lamps 53
46 Fog lamps 54
47 Headlamp levelling 55
48 Horn 56
49 Trailer socket 57
50 Head, side and number plate lamps I 58
51 Head, side and number plate lamps II 59
52 Wipers and washers — front 60
53 Heater 61
54 Interior lamps 62

INTRODUCTION

1 This chapter gives a Technical Description for the 24 volt electrical system as fitted to the Truck Utility
Light (TUL) HS, and Truck Utility Medium (TUM) HS.

General

2 The information given is applicable to both LH and RH drive vehicles.

ELECTRICAL SYSTEMS

3 The electrical systems on the TUL and TUM are made up of three main harnesses: Engine harness,
Chassis harness and Main cable assembly harness. In addition, five supplementary harnesses/cables,
covering vehicle battery, inter vehicle socket, convoy lamp, rear body com ponents and fuel system are
fitted. Connected together these harnesses form the vehicle harness, which supplies power to the
instrument panel, switches and controls, interior and exterior lighting. Each harness can be disconnected
and separated individually.

Engine harness assembly

4 The engine harness assembly connects the various electrical components fitted on the engine to the
vehicle batteries and main cable assembly harness (Fig 1).

4.1 When the starter switch is turned to position III, an electrical current is sent from the battery to
the starter motor, which cranks the engine over.

Chap 13-1
Page 2 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

4.2 When the engine is running, the single drive belt at the front of the engine turns the alternator,
which generates electricity to maintain operation of the vehicle and ancillary equipment.

4.3 The engine harness assembly is made up of the following items:

4.3.1 Alternator ECU Feed (FFR).

4.3.2 Twin alternator interlink (FFR).

4.3.3 Reverse switch.

4.3.4 Diff lock switch.

4.3.5 Fuel shut-off switch.

4.3.6 Oil pressure switch.

4.3.7 Water temperature switch.

4.3.8 Alternator connections.

4.4 There are various ancillary leads within the engine bay area that are not part of the engine
harness assembly, but functional to the engine itself. There are also leads supplying other
components within the electrical system, but will be mentioned in this paragraph.

4.5 Earth lead (part of negative earth cable). The earth lead, which connects the engine/gearbox
assembly to the chassis, is fitted to prevent the drive train becoming live and, therefore, prevent
electric shocks.

4.6 Low brake fluid level indicator. The lead runs from the top of the brake fluid reservoir to the main
cable harness and operates the brake warning light in the instrument panel should the fluid level
become low.

4.7 Brake pedal stop switch. The lead runs from the switch mounted on top of the brake pedal box
to the main cable assembly harness. The switch operates the stop lights at the rear of the vehicle
when the brake pedal is depressed.

5 The following list identifies the electrical components location and their harness route within the
engine bay area:

5.1 Water temperature switch lead. Routes from the thermostat housing through the engine
harness to the main cable assembly harness. Colours: Green/blue.

5.2 Engine harness leads (5 off). Routes from the starter solenoid to the main cable assembly
harness. Colours: White/red, Brown (4 off) Brown/light green (FFR).

5.3 Heater plug lead (2 off). Routes from the main cable assembly harness to No.1 heater plug on
the RH side of the cylinder head. Colours: Brown /red.

5.4 Heater plug connecting leads (3 off). Route from No.4 cylinder heater plug to the three other
heater plugs. Colours: Yellow/black.

5.5 Alternator leads (2 off). Route from the rear of the alternator through the engine harness
assembly to the main cable assembly harness. Colours: Brown/yellow, Brown.

5.6 Fuel cut-off solenoid lead. Routes fromt the fuel injection pump through the engine harness
assembly to the main cable assembly harness. Colours: White.

Chap 13-1
Aug 00 (Amdt 1) Page 3
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

5.7 Oil pressure switch lead. Routes from the oil filter housing through the engine harness
assembly to the main cable assembly harness. Colours: White/brown.

5.8 Positive battery cable. Routes from the starter motor to the vehicle battery and inter vehicle
socket. Colour: Red.

5.9 Negative earth cable. Routes from vehicle battery to inter vehicle socket and transfer box
casing via chassis earthing point. Colour: Black.

5.10 Battery link cable. Links both batteries, negative to positive. Colour: Red.

5.11 Low brake fluid level indicator lead (3 off). Route from the brake fluid reservoir to the main
cable assembly harness. Colour: Black/white, Black.

5.12 Brake pedal stop switch leads. Route to / from the pedal box to the main cable assembly
harness. Colour: Green/purple, Green.

Chassis harness assembly

6 The chassis harness (Fig 2) connects the rear lamps and fuel tank to the main cable assembly
harness. The stop lights and number plate lamp are connected directly to the chassis harness but the
side, indicator, fog, and reverse lamps, share supplementary rear body harnesses. The convoy lamp and
fuel tank have separate harnesses.

6.1 The chassis harness assembly is made up to connect to the following items:

6.1.1 Stop lights.

6.1.2 Convoy lamp.

6.1.3 Trailer socket.

6.1.4 Number plate lamp.

6.1.5 Rear lamps.

6.1.6 Rear fuel tank connection, (TUM and Field Ambulance only).

7 The following list identifies the electrical components location and their harness route along the
chassis.

7.1 Stop lights. Route from stop lights to the main cable assembly harness. Colours: Green/purple,
black.

7.2 Convoy lamp harness leads (2 off). One routing from the convoy lamp to the chassis harness 6
way connector, the other to earth. Colours: Red/brown, Black.

7.3 Trailer socket leads (12 off). Route from the rear chassis cross member to the chassis harness
connecting on the inside of the vehicle. Colours: Unipren (yellow) with lettered identification tags to
ensure correct connection to chassis harness leads as follows:

7.3.1 A - Red/brown, B - Green/purple, C - Red/brown, D - Black, E - Red/orange,

F - Red/yellow, H - Red/brown, J - Green/purple, K - Purple, L - Black, M - Green/purple,
N - Green/purple.

7.4 Number plate lamp leads (2 off). Route from the number plate lamp to bullet connectors on the
chassis harness. Colours: Red/orange, black.

Chap 13-1
Page 4 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

7.5 Gearbox earth leads (3 off). Colour: Black.

7.6 Rear tank leads (2 off, TUM only). Route from the fuel tank to the chassis harness via the 6 way
connector. Colours: Green/Black, black.

7.7 Chassis harness main connections. Connects the various electrical components, by way of
moulded connectors, to the main cable assembly.

7.7.1 Plug 1 (black) . Colours: Red/orange, Red/brown, Red/yellow, Green/red,

Green/white, Green/purple.

7.7.2 Plug 2 (white). Green/brown, White/black, Green, Brown/light green, Red/light

green, Purple.

7.8 Rear lamp harnesses. Separate harnesses, for LH and RH lamps, which connect to the chassis
harness assembly via two 6 way connectors. Colours: LH - Red/yellow, Green/red, Red/orange,
Black; RH - Green/brown, Red/yellow, Green/white, Red/orange, Black.

Main cable assembly harness

8 The main cable assembly harness connects to the front lamps, chassis harness, engine harness and
the various instruments, switches and indicators within the vehicle (Fig 3).

8.1 The main cable assembly harness is made up to connect to the following items:

8.1.1 Warning light panel.

8.1.2 Instrument panel.

8.1.3 Windscreen washer pump.

8.1.4 Wiper motor.

8.1.5 Horn/indicator/Dip switch.

8.1.6 ignition switch.

8.1.7 Hazard warning switch.

8.1.8 Rear fog switch.

8.1.9 Heater/blower motor.

8.1.10 Map reading lamp.

8.1.11 Main lighting switch.

8.1.12 Inspection sockets.

8.1.13 Relays.

8.1.14 Headlamp levelling switch.

8.1.15 Headlamps and side lamps.

8.1.16 Headlamp levelling motors.

8.1.17 Indicators.

Chap 13-1
Aug 00 (Amdt 1) Page 5
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

8.1.18 Brake fluid level switch.

8.1.19 Glow plug timer.

8.1.20 Main fuse box.

8.1.21 Side tank connections.

9 The following list identifies the electrical components, their location and harness route within the
vehicle and engine bay area:

9.1 In-line resistors and diodes. Integral within the main cable assembly harness and are
replaceable.

9.1.1 Diode leads (2 off). Colours: Brown/yellow, Yellow/brown.

9.1.2 In-line resistor leads (2 off). Colours: Yellow/blue, Blue/yellow.

9.2 Warning light leads. Grouped into two housings, which are plugged into the rear of the
instrument binnacle and routed, to the main cable assembly harness.

9.3 Plug 1 (natural).

9.3.1 Oil pressure. Colours: White/brown, White, Brown/blue.

9.3.2 Ignition. Colours: Yellow/brown.

9.3.3 Brake circuit. Colours: Black/white.

9.3.4 Direction indicators. RH - Green/white, LH - Green/red.

9.4 Plug 2 (natural).

9.4.1 Trailer. Colours: Light green/purple.

9.4.2 Earth. Colours: Black.

9.4.3 Side lights. Colours: Red/black.

9.4.4 Fog lights. Colours: Red/yellow.

9.4.5 Main beam. Colours: Blue/white, Brown/light green.

9.4.6 Differential lock. Colours: Black/blue, White.

9.4.7 Glow plug. Colours: Yellow/black.

9.5 Wash/wipe switch. Located on the steering column and routed to the main harness assembly.
(6 way moulded connector) Colours: Blue/light green, Light green/black, White/green, Yellow/light
green, Red/light green, Green.

9.6 Horn, directional indicators, Dipswitch. Located on the steering column and routed to the main
harness assembly. (8 way moulded connector) Colours: Blue, Green/white, Light green/brown,
Green/red, Blue/white, Blue/red, Purple, Purple/black.

9.7 Hazard switch. Located on the fascia in the auxiliary switch panel, plugged into the rear of the
panel and routed to the main harness assembly. (8 way black connector) Colours: Black/red, Light
green/Brown, Green/red, Green/white, Light green, Purple, Green/yellow.

Chap 13-1
Page 6 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

9.8 In line resistor (4) 2.7k 0.5 watt. Located behind the fascia and routed into the main harness
assembly. Colours: Yellow blue, Blue yellow.

9.9 Flash. (2 way natural connector) Colours: Green/red, green/white.

9.10 Rear fog switch. (5 way black connector) Located on the fascia in the auxiliary switch panel,
plugged into the rear of the panel and routed to the main harness assembly. Colours: Blue/purple,
Red/yellow.

9.11 Headlight level switch. (5 way natural connector) Located on the fascia in the auxiliary
switch panel and routed to the main harness assembly. Colours: Blue/black, Yellow/blue,
Green/blue.

9.12 Ignition switch. (4 single natural connectors) Located on the steering column and routed to
the main harness assembly. Colours: Brown, Brown, White, White/orange, White/red.

9.13 In line resistor (1) 0.5 watt. Colours: blue/green, green/blue.

9.14 Instruments. Located on the fascia and plugged into the rear of the instrument binnacle.
Routed to the main harness assembly (8 way connector natural connector). Colours: Green/blue,
White/black, Black, Green, Green, Red/orange, Green/black, Purple.

9.15 Heater fan switch. Located on the fascia on the side of the instrument binnacle and plugged
into the rear of the binnacle. Routed to the main harness assembly (3 way black connector).
Colours: Green/slate, Green/yellow, Black.

9.16 Inspection sockets. Located in the centre panel of the fascia and plugged into the rear of
the panel (2 single black connectors). Colours: Black, Brown.

9.17 Wiper motor. Located behind the fascia lower panel and plugged into the wiper motor.
Routed to the main harness assembly (5 way grey connector). Colours: Black, Brown/light green,
Blue/light green, Green, Green, Red/light green.

9.18 Blackout lighting. Located in the fascia centre panel, plugged into the rear of the panel and
routed to the main harness assembly. (2 off 4 way connectors).

9.18.1 Plug 1 (black). Colours: Brown, Brown/white, Green/purple, Green/purple.

9.18.2 Plug 2 (natural). Colours: Red, Blue, Red, Red/brown.

9.19 Map reading light. (2 way natural connector) Located on the fascia in the centre panel,
plugged into the rear of the panel and routed to the main harness assembly. Colours: Purple/white,
Black,

9.20 Map reading light switch. (5 way black connector) Located on the fascia in the centre panel,
plugged into the rear of the panel and routed to the main harness assembly. Colours: Purple/white,
Purple,

9.21 Relays. Located below the fascia behind the fusebox cover. Routed into the main harness
assembly.

9.21.1 Brake check relay (Green). Colours: Black, Black, White/red, White/yellow.

9.21.2 Start relay (Yellow). Colours: White/red, White/red, Black, Brown, Brown.

9.21.3 Ignition cont. relay (Red). Colours: White/yellow, White, Black, Brown/white.

9.21.4 Hazard/DI unit (Black) . Colours: Light green/purple, Light green, Black, Light
green/Brown.

Chap 13-1
Aug 00 (Amdt 1) Page 7
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

9.21.5 Front wipe delay (Black). Colours: White/green, Yellow/light green, Black,
Brown/light green, Light green/black, Green, Green.

9.22 Fusebox (20 way). Located below the fascia under the fusebox cover, routed into the main
harness assembly. Colours: 1 Brown/white; 2 Brown/white; 3 White; 4 White/yellow;
5 White/orange: 6 Red/brown; 7 Brown; 8 Brown; 9 Brown; 10 Blue; 11 Blue/red; 12 Blue/red; 13
Blue/white; 14 Blue/white; 15 Red; 16 Red; 17 Blue/red; 18 Brown; 19 Purple/light green; 20 Purple.

9.23 Brake fluid level. (2 single natural connectors) Located in the engine compartment plugged
into the top of the brake fluid reservoir, and is routed to the main harness assembly. Colours: Black,
Black/white.

9.24 Stop light switch. (2 single natural connectors) Located on the brake pedal box and is
routed to the main harness assembly. Colours: Green/yellow, Green/purple.

9.25 Heater motor. (4 way black connector) Located in the engine compartment local to the
heater motor and routed to the main harness assembly. Colours: Green/ slate, Green/yellow,
Purple/green.

9.26 Wash pump. (2 way natural connector, 2 way black connector) Located under the bonnet
local to the windscreen wash reservoir and routed to the main harness assembly. Colours: Black,
Black/light green, Light green/black.

9.27 Glow plug timer. (6 way black connector) Located under the bonnet on the bulkhead.
Routed to the main harness assembly. Colours: White/red, Yellow/black, White, Black, Brown,
Black/yellow.

9.28 Radio. Located inside the vehicle, routed to the main harness assembly. Colours: Black,
Red.

9.29 Main fuses. Located under the bonnet against the bulkhead. Routed to the main harness
assembly. Colours: Brown, Brown, Brown and Brown.

9.30 L.H Repeater. Located under the L.H wing, routed back to the main cable harness
assembly. Colours: Green/red, Black.

9.31 L.H Sidelamp. (2 way white connector) Located in the L.H wing, plugged into rear of
sidelamp assembly. Routed back to the main harness assembly. Colours: Red/black, Black.

9.32 L.H Headlamp level. (3 way black connector) Located in L.H wing, plugged into rear of
headlamp assembly. Routed back to the main harness assembly. Colours: Blue/yellow, Black,
Blue/green.

9.33 L.H Headlamp. (4 way black connector) Located in L.H wing, plugged into rear of headlight
assembly. Routed back to main harness assembly. Colours: Blue/slate, Blue/pink and Black.

9.34 L.H Indicator. (2 way red connector) Located in L.H wing, plugged into rear of indicator
assembly. Routed back to main harness assembly. Colours: Green/red, Black.

9.35 Horn. (2 single natural connectors) Located behind radiator grille plugged into horn. Routed
back to main harness assembly. Colours: Purple/black, Black.

9.36 Glow plug. (Terminal) Located under the bonnet local to glow plugs. Routed back to the
main harness assembly. Colours: Black/yellow.

9.37 Starter solenoid. (2 way natural connector) Located under the bonnet local to the starter,
motor, routed back to the main harness assembly. Colours: White/red.

Chap 13-1
Page 8 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

9.38 Side Tank connections. (3 way black connector) Located under bonnet local to bulkhead.
Routed to main harness assembly. Colours: Green/black, Black.

9.39 Chassis connections (2 off 6 way). Located under the bonnet local to the bulkhead. Routed
to the main harness assembly.

9.39.1 Plug 1 (6 way black connector) Colours: Red/orange, Red/brown, Red/yellow,

Green/red, Green/white, Green/purple.

9.39.2 Plug 2 (6 way white connector) Colours: Green/brown, White/black, Green,

Brown/light green, Red/Light green, Purple.

9.40 Engine connections. (12 Way black connector). Located under the bonnet local to the
bulkhead. Routed to main harness assembly. Colours: White/brown, Green/blue, Brown/yellow,
White, Green/yellow, Green/brown, Black/blue, Black, Brown/yellow.

9.41 R.H Repeater. Located in the R.H wing routed back to the main harness assembly. Colours:
Green/white, Black.

9.42 R.H Sidelamp. (2 way white connector) Located in the R.H wing plugged into the rear of the
side lamp assembly. Routed back to the main harness assembly. Colours: Red/black, Black.

9.43 R.H Indicator. (2 way red connector) Located in the R.H wing plugged into the rear of the
indicator assembly. Routed back to the main harness assembly. Colours: Green/white, Black.

9.44 R.H Headlamp. (4 way black connector) Located in the R.H wing plugged into the rear of
the headlamp assembly. Routed back to the main harness assembly. Colours: Blue/orange,
Blue/black, Black.

9.45 R.H Headlamp Levelling. (3 way Black connector) Located in the R.H wing plugged into the
rear of the headlamp assembly. Routed back to the main harness assembly. Colours: Blue/yellow,
Black, Blue/green.

Chap 13-1
Aug 00 (Arndt 1) Page 9
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

KEY TO FIG 1

1 Alternator connections 13 Starter solenoid connections (positive)

2 Oil pressure switch connection 14 Differential lock switch connections
3 Water temperature switch connection 15 Reverse switch connection
4 Heater plug harness 16 Earth bonding lead, rack to bodyside
5 Fuel shut off switch connection 17 Earth bonding lead, rear body to chassis
6 Earth bonding lead, door to "A" post 18 Earth bonding lead, rear body to body
7 Earth bonding lead, bonnet to bulkhead 19 Transfer box earth connection
8 Twin alternator link (FFR only) 20 Battery link cable
9 Alternator ECU feed (FFR only) 21 Vehicle batteries
10 Main harness connection 22 Earth bonding lead, door to "A" post
11 Main harness starter solenoid connection 23 Intervehicle starter socket connections
12 Starter solenoid connection 24 Earth bonding lead, toe box to chassis

Chap 13-1
Page 10 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

MIL0367

Fig 1 Engine harness layout

Chap 13-1
Aug 00 (Amdt 1) Page 11
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

KEY TO FIG 2

1 Main harness connection 10 Trailer socket

2 Main harness connection 11 LH body harness connection
3 Main harness connection 12 Number plate light
4 Gearbox earth connection 13 Rear stop light connection (LH)
5 Convoy light harness 14 Reverse light connection
6 Rear body harness 15 Fog light connection
7 Rear stop light connection (RH) 16 Direction indicator light connection
8 Trailer socket connections 17 Tail light connection
9 RH body harness connection 18 Rear fuel tank connections (TUM only)

Chap 13-1
Page 12 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

MIL0368

Fig 2 Chassis harness layout

Chap 13-1
Aug 00 (Amdt 1) Page 13
 2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

KEY TO FIG 3

1 Headlamp connection (RH) 19 Map reading light connectors

2 Headlamp levelling connection (RH) 20 Heater/blower motor connector
3 Indicator connector (RH) 21 Wiper motor connections
4 Side repeater connection (RH) 22 Glow plug timer
5 Side light connector (RH) 23 Earth point
6 Brake fluid level switch connections 24 Engine/Chassis harness connections
7 Brake light switch connections 25 No. 1 glow plug connector
8 Headlamp levelling switch connector 26 Starter solenoid connection
9 Hazard warning switch connector 27 Fuse box connections
10 Rear fog switch connector 28 Relays
11 Warning light panel connections 29 Main fuse box
12 Instrument panel connections 30 Windscreen washer pump connections
13 Horn/indicator/dip switch connections 31 Side light connector (LH)
14 Ignition switch connector 32 Side repeater connection (LH)
15 Inspection sockets 33 Headlamp connection (LH)
16 Main lighting switch 34 Indicator connector (LH)
1 17 Radio connectors 35 Headlamp levelling connection (LH)
18 Side fuel tank connectors (TUL only) 36 Horn connections

Chap 13-1
Page 14 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

MIL0369

Fig 3 Main cable assembly harness

Chap 13-4
Aug 00 (Amdt 1) Page 15
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT HEADER 0285

C0550-4 P1 5 00285-5 CO285-3 R1 0

SWITCH-COLUMN
01042-7 P1 5 CO285-4 00285-7 P,1 0

MIL 01738

Fig 5 Connectors

Earth distribution

15 The ground distribution section comprises a numbero of Headers, Splices and centre taps circuits.
These are used in a similar manner to those in Power distribution; to narrow the search area by checking
for fault symptoms in associated circuits.

Line types

16 Fig 7 means that the wire connects to another circuit.

HEATED REAR SCREEN

RELAY MIL 01743

Fig 6 Line types I

17 The "cup and ball" symbol indicates the male and female halves of the connector (refer to Fig 8).

17.1 Plug on lead, fly lead (Fig 8 (A)), wired directly to the component.

17.2 Connector plugs directly into circuit (Fig 8 (B)).

A 3

PAIL 01742

Fig 7 Line types II

Components

18 The name, or description of the component is shown. A dotted outline indicates that the component is
not shown in its entirety.

Chap 13-1
Aug 00 (Amdt 1) Page17
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

6 OR 7 WAY LIGHTING SWITCH

f == = = == =1 C1085-1
5,-ammi=s
C1082-1 0 C1086-1
krimstis
0 C1087-1
[fc'
0 C1083-1

u C1084-1
u6:Amommim
== == MIL 01739

Fig 8 Components

Earth points

19 Earth points are identified with an eyelet symbol and a connector number, except where components
are grounded through their fixings, when only the eyelet is shown.

C0556-1
Gt

SWITCH-OIL PRESSURE
EARTH VIA
FIXINGS

MIL01740

Fig 9 Earth points

Fuses and diodes

20 Fusible links (refer to Fig 11 (A)) and current fuses (B ), are identified as shown. The direction of the
arrow in a diode symbol (C) indicates the direction of flow. The Zener diode (D) prevents current flow until
a precise voltage is reached.

A LINK FUSE

AMP AMP

C D
MIL 01741

Fig 10 Fuses and diodes

Chap 13-1
Page 18 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

8364
RELAY-STARTER 8360
r C0151 868 0 A366 fl. 1.0 SJ6 BA 0 C0556-1

—
UNIT-DIRECTION INDICATOR/ RELAY-
HAZARD WARNING BRAKE CHECK SOCKET-RADIO CHARGING
C0547-868.05 MAJA 01011-1
805 C1012-85
L

SVVITCHAAAPER DELAY LAM P-MAP

B.20 A228 6.05 01111-2
C0303-4 8.0.5 8.0,5 C1012
2-30

, .
RELAY-IGNITION SOCKET-INSPECTION
— 7' CO218-86 B.05 8.20 01106-1 -

SOCKET-ACCESSORY
SWITCH-BLOWER MOTOR 620 C1031-1
C0058-3 8,1 0

A367 LAMP-SIDE REPEATER

MOTOR-VMPER-WNDSCREEN 6368 -FRONT-R H
4368
C0030-1 B20 5 A370 8 1 5 A369 El 0 5 00012-2

DIFFERENTIAL LOCK UNIT

LAMP-SIDE REPEATER- A372 — —I 00307-1 6 0 5 00192-800448-8 8.1 0 LAMP-SIDE-FRONT-RH
FRONT-LH 4373 HEADLAMP-LH 6.05 00537-2
C0013-2 KO 5 A374 815 C0009-3
UNIT-FUEL TANK
__. HEADLAMP-RH
, 00113-1 8,05 01187-200391-2_ 13 1 0 (90)
9.1 5 00011-
HORN LAMP-DIRECTION
— 00004 1 9,1 0 INDICATOR/HAZARD MOTOR-HEADLAMP LEVELLING-RH
WARNING-FRONT-LH
C0070-2 8,0,5
805

LAMP-SIDE-FRONT-LH
C05382 8,0.5 LAMP-DIRECTION INDICATOR/HAZARD WARNING-FRONT-RH
MOTOR-HEADLAMP C0002-2 B_0 5
LEVELLING-LH GAUGE-COOLANT
805 00071-2 A322 TEMPERATURE
8.1.5 A323 8,0.5 01040-301048-3 8.1.0 3 8.05 01058-1
8373
8.1 5 4376 B15 8,0 5
UNIT-TIMER- WARNING LAMP-HAZAR
GLOW PLUG 01036-18 0 5
SNATCH-BRAKE C1059-
C0189-4 0,0 5
FLUID LEVEL
6.0 5 INSTRUMENT PACK
PUMP-WASHER-NNNDSCREEN CO233-2 B.1.5 GAUGE-FUEL
C0008-1 8,0 5 8.0 5 01057-2

RESISTOR 01006-1
1 01007-1 . TUL
8.0 5
01507-2 01500-2 9.1 0
RESISTOR 8.00 010612. SPEEDOMETER
01960-1 B 05 TUM
8,05 01060-2

Fig 11 Earth distribution I — Non EEGR

Chap 13-1
Aug 00 (Amdt 1) Page 19
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

LAMP-CONVOY-RH
00808-1 B4O5 C1522-2 C1521-2 8.0 75 AS B.20 00557-1

01519-5 C1518-5 B 20
LAMP-DIRECTION INDICATCR/
HAZARD WARNING-R REAR- H
0 10 SJ1 0,075 03928-1

LAMP-TAIL-RH LAMP-FOG GUARD-REAR-RH

-0 C0121-1 8,075 0075 00515-1

LAMP-BRAKE-RH LAMP-REVERSE-RH
120490-1 &075 012 BA 75 8015

LAMP-REAR NUMBER
PLATE-RH
C0138-2 B 0 75

UNIT-FUEL TANK
— C0114-2 8 10 A21 0.2 0 00558.1

C1519-5 C1517-5 8.2 0

I LAMP-DIRECTION INDICATOR!
HAZARD WARNING-REAR-LH
B 10 SJ1 B 0 70 00928-1
LAMP-TAIL-LH
• • • i•
C0121-1 15.0 75
LAMP-FOG GUARD-REAR-LH
B 0 75 (0515-1
LAM P-BRAKE-LH
II 00490-1 8.075 012 8.075

LAMP-REAR NUMBER
PLATE-LH
' 00138 B 0 75 TRAILER PICK-UP
11 C0499-0 B 1 0 C0-561-1

00499-L 810

Fig 12 Earth distribution II — Non EEGR

Chap 13-1
Page 20 Aug 00 (Andt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT HEADER 0285 SOCKET-ACCESSORY

co5ao-4 5,1 5 CO285-0 CO280-3 5.10 51040-851048.8 P0 0 51138-2 -
•

SWITCH-COLUMN SOCKET-ACCESSORY
'1 C1042-7 P15 00285-4 1. 00285-7 P10 51030-1

FUSE BOX-PASSENGER
UNIT-TIMER-GLOW PLUG COMPARTMENT
1.0109-3 W2.0 50285-9 00785-n W2.0 A441 W2.0 50560-5
L: •

INSTRUMENT PACK SWTCH-IGNITION

50233-9 W2.0 CO285-12 W.20 00094-1
i ;gp
y
p 502304 WOO 50286-19 C0036-1 6920

SOLENOID-FUEL
RELAY-IGNITION CUT-OFF
, CO218-85 W20 00285-13 : CO235-16 WOO C0448-4 C0162-4 W20 C0198-1

Fig 13 Header joints—Non EEGR

Chap 13-1
. Aug 00 (Amdt 1) Page 21
2320-0-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY
R.25.0 00192-1 ' C0045-1 5,40.0 EARTH

STARTER MOTOR
C0823-1 - —

HEADER 0285
FUSE BOX-ENGINE COMPARTMENT 00285-17 00285-19 33W2.0.560

LINK 2 ,1 c0570-2 N,6,0 A243 9,60

CO285-11 , 00285-12 44W2.0.560 6
—0A.!
OH

C0632-1 r LINK 1 005701 N30

SENSOR-ENGINE COOLANT
1 57 N.30 01080-1 01018-1 TEMPERATURE (ECT)
C0169-1 GU 0 5
•
N45 SJ3
uE
SWITCH IGNITION UNIT-FUEL TANK
' 00115-1 013.0.5 01187-1 C0379-1 013.0.5 TU L

00028.1 00094-1 W2.0 A441 W.2.0 UNIT-FUEL TANK

• 00114-1 GB 1 0 00393-1 00379. I GB,0 TUM
W2.0

INSTRUMENT PACK
W2.0
6 OR 7 WAY LIGHTING SWITCH G0.5 5J1 G05 C1054-1! 01055-1 09.0 5 01048-7 C10407
01085-1 R.0 5 C1079-1 C1017-1

01082-1 01087-1 905.2 0 01080-20101E12

G05 C1052-1 1320.5 C1048-101040-1 GU.0.5 C0448-2 C0162-2

NV1.12 0 01058.1 805 8.13 R.1 0 01048-3 01040-3 3235 0 5 710

R,0 75 ! 01056-1 0.05

1
SWITCH-WASH/NAPE WINDSCREEN
C1048-4 01040-4 GO 75 00278-6
FUSE BOX-PASSENGER COMPARTMENT
A331 41111=11111111M
•
C0680-5 II FUSE 3 C0580-6 G2.0 A333 GI 0

00580- 291 FUSE 15 ! C0580-30 RR.075 A213 218R9 0 5,1200

C0580-1 I

NW10
SWITCH-COLUMN
HEADER 0285
C0580-3 ! FUSE 2
C0580-4 91.5 CO285-5 !!! CO285-4 s 1.5 01042-7' '`, !! C1042-5 168UW2.0.145
1—C1><OH 7

Fig 14 Instruments I - Non EEGR

Chap 13-1
Page 22 • Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

INSTRUMEN1 PACK
ALTERNATOR/
DIODE GENERATOR
00230-5 YN.0 5 C0118- ' C0118-2 57,0 5 C0446-3 C0162-3 NY.0 75 00185-1
•Lp --r EARTH VIA
FIXINGS

SWITCH-COLUMN
CO230-10 GR 0 5 5316 GR,0 75 C1042,4

SWITCH-HAZARD WARNING
GR,15 C0095-3 =
I
CO230-9 C3VV.0 0310 GVV, 1 5 C0096-4

SWITCH-COLUMN
GVV,0 75 C1042-2

RB,0.5 00233-3

RELAY-HAZARD
WARNING
CO233-1 LGP,O S C0547-30

DIFFERENTIAL
LOCK UNIT
A IA/ 2 0 CO230-4 CO233,8 BU.0 5 00448,7 C0162-7 BUO 5 co3osi

UNIT-TIMER-GLOW PLUG
13 W2.0 00233-9 00233-10 Y0,05 C0189-2

SWITCH-OIL PRESSURE
CO230-3 WN 05 00445.1 00162-1 WN 05 C.0187-1

EART
FIXINGS

SWITCH-FOG GUARD LAMP-REAR

00233-4 07.0 5 00064-3

SWITCH-BRAKE FLUID LEVEL 8373

00230-6 5010 5 C0031 C0026-1 8.05 A376 B.1.5 SJ6 6.40 00556,1

8168 0322
E UW2 0 9189 UW 2 0 00233-5 00233-2 B 15 A323 6. 15

C 6,0.5

Fig 15 Instruments II - Non EEGR

Chap 13-1
Aug 00 (Arndt 1) Page 23
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT

6 OR 7 WAY LIGHTING SWITCH
C1083-1 RNO 5 C1079-4 C1017-4 RN.0 75 00580-11 •• FUSE 0 C0580-12 RN 075 C0376-2 C0390-2 A
BATTERY Cr>"40
R.25.6 C0192-1 F C0045-1 6,40.0 EARTH 1 SWITCH-HAZARD
WARNING
C1082-1 • 1 00580-1 , FUSE 1 C0096-7
N.30 ., C1087-1 NVV.2.0 C1080-2 C1018-2 NV4.2 0 I C0580-2 6.2 0
I •
0>< --H-
NVV.1 0
STARTER MOTOR
02823 C0580-3 I FUSE 2 00580-4 F.1 5
RELAY-IGNITION 40%.<0
•• G0218-1 MAL 0 SWITCH-HAZARD
ALTERNATOR/GENERATOR I
00183-1 N,8.5 C0178-1 WARNING
00218-30 WY: 0 10580- FUSE 4 50580-8 GY 1 5 50091-8
li R,100 00824-1
GY.1 5 C,

FUSE BOX-ENGINE COMPARTMENT (P108)

LINK 1 00570-1 5.3 0 C1018-1 C1090-

C0632-1 50570-2 N 0 0 A243 N20 50580-13 FUSE 7 C0580-14 R MAJA I

C>.(0
N.50 SWITCH-MAP
LAMP
• FUSE 18 C1515-3
N.20 C0580-35 C0580-36 P.0 5

35051 5 700

SWITCH-IGNITION MOTOR-BLOWS R
-FRONT
- C00981 W0.1 0 60580 8 FUSES I 00580.10 10,1 0 50006-3 F. '
fi ID-T-E
N,4.5 M41 1
II0 1
~ C0020-1 VVH 1 0 W2 0 50:18041 F USE 3 1 C Y380-6 C,.3 0

SOCKET-INSPECTION
N.2 0 C1064-1 •
HEADER 0285
W.2.0 CO285-11 ,

RELAY-STARTER W2.0 50288.17

N 30 00151-81 50151-85 F? 1 0 A47

RELAY-BRAKE CHECK
UNIT-11M ER-GLOW PLUG 1.4/5 0 5 5101286
00180-5 C0180-1 WR 0 5

Fig 16 Power distribution I - Non EEGR

Chap 13-1
Page 24 Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

HEADER 0285 SOCKET-ACCESSORY

B 1421 1 5 640 130285-5 CO285-3 P.1 0 01040-8 01048-8 P05 C1138-2

SOCKET-ACCESSORY
CO285-7 P 1 0 C1030-1

SWITCH-COLUMN
CO285-4 P15 C1042-7

SWITCH-BRAKE PEDAL
122GY,1 5 900 C0029-

G8,0 75
'SWITCH-REVERSE LAMP
00448-5 00162-5 GO 5 00167-2

SOCKET-RADIO CHARGING
D 3619 MAJA 4:401853-1

LAMP-CONVOY-RH
A RN,0 75 836 RN 0 75 C1521-1 C1522-1 RN 0 01065-1 t"
iiinimmm•mmmume

TRAILER PICK-UP
Rt4.0 75 A36 RN 075 C1305-2 C1300-2 RN.1 0 C0499-A

85,375 C1305-301306-3 95-1.0 00499-C

RNA] 75 C1305-4 131306-4 RN.1.0 00499-H

E P1.5 00377-6 130391-6 P 2 0 131305-5 01306-0 P.10 130499-K

A331 MOTOR-W PER-WINDSCREEN

G 3336.2 0.190 A333 620 130030-4

SWITCH-WIPER DELAY
G10 00303-8

SWITCH-WASH/WIPE-WINDSCREEN
G10 CO278-6
INSTRUMENT PACK
01054.1 Ci,0 5 521 605 01048 4 claw 4 (3075
F.
C1052-1 00 5
I

Fig 17 Power distribution II - Non EEGR

Chap 13-1
Aug 00 (Amdt 1) Page 25
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT

SWITCH-COLUMN HEADLAMP-RH
C1042-6 UR 2 0 A341 UR.2 0 C0580-21 FUSE 11 C0580-22 UB 2 0 co511-2
•
0><0
HEADLAMP-LH
UR 10 C0580-23 FUSE 12 C0680-24 UK 2 0 C0099-2
LI

I MOTOR-HEADLAMP LEVELLING-RH
UR.1 0 C0580-33 FUSE 17 C0500.34 UG1 0 A378 UGO 5 C0070.3
C›<)-
0
MOTOR-HEADLAMP LEVELLING-LH
UGO 5 C0071-3
I II

A168 HEADLAMP-RH
II 1', 01042-5 UVV2.0 A189 UVV.2 U 01.1580 25 FUSF 13 00580-26 1.70 00011-1
IF
fl

INSTRUMENT PACK HEADLAMP-LH

CO233-5 UW2.0 UVV,2 0 COUBO-27 FUSE 14 C0580-28 U.5.2.0 C0009-1
T.

SWITCH-COLUMN SWITCH-FOG GUARD LAMP-REAR

(r- 01042-1 U.20 A334 U,2 0 C0580-19 FUSE 10 C058020 UP.1 C0064-2
1
.0

6 OR 7 WAY LIGHTING SWITCH INSTRUMENT PACK

C1079-201017-2 U 20 05 0.0231-3

LAMP-SIDE-FRONT-RH
t 01085-1 R.05 01079-1 C1017-1 R,0 75 C0580-29 FUSE 15 C0580-30 ROD 75 A213 80.0 75 00037-1

LAMP-SIDE-FRONT-LH
RR 0 7// C0538-1

TRAILER PICK-UP
01086-1 R05 01070-3 01011-3 R,0 75 CO580-31 FUSE 16 00580-32 R0.1 5 003/0e1 C0390-1 RO 1 0 Al 50.1 0 01305-1 C1306-1 50,1 0 C0499-E

R0.0.5
GAUGE-COOLANT TEMPERATURE LAMP-REAR NUMBER
,r C1059-1 RVVO 5 012 RVV 0 C1048-501040-5 ROD 5 A351
R0.0.75 C1518-4 C1519-4 RO 0 75 All ROO 75 00138-1
PLATE-RH
1,
,*\
SPEEDOMETER
IIIC1060-1 RWO 5
II
11 C106 RVV,0 5
I RO 0 75 C0121-2
LAMP-TAIL-RH

LAMP-TAIL-LI-1
GAUGE-FUEL 50.0.76 0151/-4 01519.4 R0.0.7.5 All ROD 75 C0121-2
C1057-1 RWO 5
II
LAMP-REAR NUMBER
SOCKET-ACCESSORY PLATE-LH
;: 01027-1 ROD 75 RO 0 75 C0138-1

Fig 18 Power distribution III - Non EEGR

Chap 13-1
Page 26 Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

INSTRUMENT PACK
A47 (WR) MAIN h RB,0 5 CO233-3
A213 (RB) MAIN
SWITCH-IGNITION RELAY-STARTER
F C0090-1 WR,1 0 A47 VVR 1 0 00151 85 FUSE BOX-PASSENGER LA MP-SIDE-
COMPARTMENT FRONT-RH
C0580-30 R 6,0 75 A213 RB,0 75 C0537.2
RELAY UNIT-TIMER-
BRAKE CHECK GLOW PLUG
01012-86WR.0.5 WR,0 00189-1
u A316 B316 (GR) MAIN
SWITCH-HAZARD
LAMP-DIRECTION INDICATOR/HAZARD WA RNING-FRONT-LH WARNING
A 168/A189 (UW) MAIN C0001-2 GR,0.75 6316 06,1 5 8316 GR,1.5 00096-3 —

FUSE BOX-PASSENGER
COMPARTMENT 6168 SWITCH-COLUMN INSTRUMENT PACK
C0580-25UW,2 0 A189 UVV,2 0 C1042-5 CO230-10

INSTRUMENT PACK SWITCH-DIRECTION

C0580-27 LJW.2 o UW.2 0 CO233-5 INDICATOR
GR,0 75 0104?-4

UNIT-DIRECTION INDICATOR/
HAZARD WARNING LAMP-SIDE REPEATER-
LGN,1.0 0004/8/ FRONT-LH
A191 (LGN) MAIN GR,0 5 00333-1 00420-1 06.0.75 C0013-1

SWITCH-HAZARD - -
WARNING SWITCH- COLUMN LAMP-DIRECTION INDICATOR/
C0096-2 LGN 1 5 6191 LGN,1 5 C1042-3 HAZARD WARNING-REAR-LH
GR 1 5 00376-4 C0390.4 GR . 1 0 00928-2
II ,
A310 B310 (GW) MAIN
6 OR 7 WAY
LIGHTING SWITCH SWITCH-HAZARD
U,2 0 C1017-201079-2 11, 20 01084-1 LAMP-DIRECTION INDICATOR/HAZARD WA RNING-FRONT-RH WARNING
A334 (U) MAIN - 00002-2 GW 0 75 A310 GW 1 5 6310 GFi 1 5 00096-4

FUSE BOX-PASSENGER INSTRUMENT PACK

COMPARTMENT SWITCH-COLUMN GVV,0 75 CO230-9
0058019 U-2 0 A334 U20 C1042-1

„
SWITCH-DIRECTION
INDICATOR
A341 (UR) MAIN) FUSE BOX-PASSENGER 0W0.75 01042 2
COMPARTMENT
IF2 2 0 C0580-21 '
SWITCH-COLUMN
LAMP-SIDE REPEATER-
01042-6 UR,2 0 A341 UR,1 0 C0580-23 FRONT-RH
C.,W,0 00333-2 C0420-2 OW,0.75 0002-1
UR,1 0 C0580-33

LAMP-DIRECTION INDICATOR/
HAZARD WARNING-REAR-RH
GW,1 5 00376-5 C0390-5 GW,1 0 • C0837

Fig 19 Splices and centre taps I - Non EEGR

Chap 13-1
Dec 13 (Amdt 3) Page 27
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

A331 A333 (G) MAIN SJ1 (G) INSTRUMENT A378 (UG) MAIN

FUSE BOX-PASSENGER MOTOR-WIPE R-

COMPA RTMENT WINDSCREEN FUSE BOX-PASSENGER MOTOR-HEADLAMP
A331
00580-16 G,2.0 A333 G,2 0 C0030-4 COMPARTMENT LEVELLING-RH
00560-34 110,1 0 A378 00,0 5 00070.3
14—
SWITCH-WIPER
DELAY MOTOR-HEADLAMP
-L C0303-8 0,10 G 0 75 C1040-401048-4 G, 05 RESISTOR LEVELLING-LH
- C0036-2 00,1.0 UG,0 5 C0071.3 I
L --J J •
SJ1 GAUGE-COOLANT
SWITCH-WASHNVIPE TEMPERATURE
-WINDSCREEN MOTOR-HEADLAMP
0,0 5 01052.1 — 7
CO278- 6 G,1 0 I. A381 air MAIN 0805 00071
LEVELLING-LH

GAUGE-FUEL
rr~ 7 01054-1 0,0 5 RELAY-IGNITION MOTOR-HEADLAMP
—1141 WARNING LAMP RESISTOR LEVELLING-RH
4 101702-1 G,1 0 01095-30 4 O 00037-2 1180 8381 MO 5 00070-1

A243/A350 (N) MAIN SJ3 (N) MAIN RESISTOR

A384 (GU) MAIN'
GU,1 0 C0038 - 1 —
FUSE BOX-ENGINE FUSE BOX-PASSENGER
COMPARTMENT COMPARTMENT SWITCH-HEADLAMP
A243
00570,2 N,8 0 8350 N.2 0 00580.0 LEVELLING RESISTOR
00093:5 0111 0 5384 GUJ 0 01506-301507 - 3 00,05 01963.1
N,6 0 N10 C0580-17

SWITCH-IGNITION
C0028-1 N,4.5 SJ3 N,2 0 00580-35 -
A441 (GR)MAIN
FUSE BOX-PASSENGER
SOCKET-INSPECTION RELAY-STARTER SWITCH-IGNITION COMPARTMENT
'T ' —74 01064-1 N,2 0 IrlN 30 C0151 87 T : 1 C0094 1 W2 0 6441 W.2 0 00580 - 5
II
-
/
HEADER 0285
1 'I , " CO285 11 W2 0
A351 (RO) MAIN ;1 11 SJ2 (RW) INSTRUMENT '
1 .,
CO285-17 W20
FUSE BOX-PASSENGER HEADER-BULLET
COMPARTMENT 1027
C G — 7 C0580-32 RO 0 5 5351 RO 0 /5 01027-1 r"—
1
A10 (RY) CHASSIS
RO 0 5
SPEEDOMETER
r- ' 4 74, C1060.1 RW,0 5 SJ2 RW1 0 C1048-501040 SWITCH-FOG GUARD LAMP-FOG GUA RD-
GAUGE-FUEL LAMP-REAR REAR-LH
01081.1 RWO 5 RW 0 5 0135/.1 T. ' 00064 3 851 5 00376.3003903 8510 610 681 0 00515 2
lIoo
o

GAUGE-COOLANT LAMP-FOG GUA RD-

TEMPERATURE REAR-RH
RW,0 5 C1059-1 r 85,0 75 00512- 2 -

Fig 20 Splices and centre taps II - Non EEGR

Chap 13-1
Page 28 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

A6 (GP) CHASSIS 1 SJ3 (UB) RESISTOR PACK1

LAMP-TAIL-LH
GP 1 0 A6 GP,1 0 C0490-2 A
SWITCH-HEADLAMP
LEVELLING RESISTOR
LAMP-TAIL-RH 00093-2 UB 1 0 01506-1 C150/-1 UB,05 SJ3 UB.0 5 C1962-2 •
C0390-6 C0376-6 GP,1 5 GP 1 0 00489.2 — •

C1516-3 C1018-3
SWITCH-BRAKE PEDAL RESISTOR
GP 1 0 C1516-4 C1018-4 GP,1 0 C0075-1 •- •••'•• U0 0 5 C1963 2 ••••

Al (RO) CHASSIS
A5 (NW) AMBULANCE INTERFACE
6 OR 7 WAY
FUSE BOX-PASSENGER LAMP-REAR NUMBER HOLDER-FUSE LIGHTING SWITCH
COMPARTMENT PLATE-LH C1875-1 NW 1 0 AS NVV,2 0 01877 7 01080 7 NW,7 0 01087
C0580- 32 R0, 1 5 00376- 1 C0390- 1RO 1 0 Al R0,0 75 C0138- 1'; •

LAMP-TAIL-LH LAMP-TAIL-RH FUSE BOX-PASSENGER

C0121-2 90 1 0 90075 C0125-2 • HOLDER-FUSE COMPARTMENT
C1876-1 NW 1 0 NW.2 0 C1516-2 C1018-2 NW20 00580-

A48 (W) ENGINE

All (PW) AMBULANCE INTERFACE
HEADER 0285 ECU-EGR
CO285-16 W,2.0 C0448-400162.4 W2.0 A48 W,1.0 C0032-3 HOLDER-FUSE RELAY-BEACON
‘1. 01876-7 PW,10 All PW,1 0 01874.30 •• • •.'

SOLENOID-FUEL
CUT-OFF
W,2.0 C0198.1 SWITCH -BEACON
PW 0 5 01869-1 •—•
SJ1 (KB) ENGINE

SENSOR-THROTTLE
ECU-EGR POSITION (TP) A6 A36 (N)AMBULANCE INTERFACE
C0032-1 KB4O.5 SJ1 KB4O.5 C0175 - 1
RELAY-IGNITION
HOLDER-FUSE AS WARNING LAMP
• 01878- 1 N,1 0 A35 N,1 C189566 •
SENSOR-TEMPERATURE
SOLENOID-EGR -EGR
-1 C0191-2 KB4O.5 KB4O.5 C0027-2 •

INSTRUMENT PACK BUZZER

C1743- 1 N 1 0 N,1 0 C0520- 87 —
SJ2 (RB) ENGINE

SENSOR-THROTTLE
ECU-EGR POSITION (TP) -
C1862-2 RB,0.5 SJ2 RB,0 5 00175-3 r ---
11,

SOLENOID-EGR
RB 0 5 001910:

Fig 21 Splices and centre taps III - Non EEGR

Chap 13-1
Dec 13 (Amdt 3) Page 29
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY ALTERNATOR/GENERATOR
R.25.0 C0192-1 1, ;I C0045-1 8,400 EARTH
STARTER MOTOR
N.8.5 C0183-1
C0849-1

C0523-1

R,10.0 C0824-1
EARTH VIA
FIXINGS t•••
00179-1 'i C.0448-3 C0162-3 NY 0 75 C0185-1 1 I " — 14 . •
EARTH VIA
XINGS

DIODE
NY 0 5 00118.2 C0118-1 03YN 0 5 445

FUSE BOX-ENGINE COMPARTMENT

LINK 3 c
0570-3 3N,6 0.460
'D"." -13 t •

C0632-1 - LINK 2 c670-7 N 0 A243 N60 WH 3 0 CO203-1 C0449-1

N,45 SJ3

RELAY-STARTER
N.3 0 C0151-87 , CO151-30 1AR 3 0

A47 0019.1 0 C015185 .•• I C015186 3658.1.0.170 C

SWITCH-IGNITION 75WR.0 5.630 0

00090-1 NOR 1 0
HEADER 0285
C0028-1 C0094 1 W2 N A441 W 2.0 CO28511 CO280.9 29W2 0.860

• ••.^ CO285.12 44W2 0 560

W 2.0 CO285-17 , CO285-19 33W2.0.560

CO285-16 W20

SOLENOID-FUEL CUT-OFF
00448-4 00162-4 W20 C0198-1 `-_---

Fig 22 Charging and starting I - Non EEGR

Chap 13-1
Page 30 Aug 00 (Amdt 1)
'ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

INSTRUMENT PACK
GLOW PLUG 1
C0476-1
EARTH VIA
A YN.0 5 00230-6 • -----

W20 CO230-4
GLOW PLUG 2
YH 0 004// 1
EARTH VIA
r . FIXINGS

F W2.0 CO233-9 00233-10

GLOW PLUG 3
B5.30 00478-1
. EARTH VIA
• --- • FIXINGS
UNIT-TIMER-
GLOW PLUG
WR.0 h C0169-1 P,
i 00189-2 Y8.0.5 GLOW PLUG 4
YH.30 00479-1 •
EARTH VIA
IT FIXINGS
W20 C.:0189-3 00189-6 HY 6 C1039-1

8373
N 60 00189-5 C0189.4 B05 93/6 B 15 0.16 040 00556-1

A364
9365
B 10 A366 B 10

Fig 23 Charging and starting II - Non EEGR

Chap 13-1
Aug 00 (Amdt 1) Page 31
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY
R.250 C0102-1 l C0045-1 8.400 EARTH
l_

STARTER MOTOR
C0823-1

R.10.0 C0824-1 '.'

SPEEDOMETER
A322
SJ2 RW0.5 01060-1 01060-2 8.05 SJ3 B 1 0 01048-3 C1040-3 8.05 A323 8.15 SJ6 0.4 0 60550. 1
•

RVV,0 5 01061 01061-2 8,0.5

FUSE BOX-ENGINE COMPARTMENT

C0632-1 LINK 1 00570-1 N30 01018-101080-1

GAUGE-FUEL
01056-1 B4O.5

RW 0 T C1057-1 01057-2 60 5

N3 0

6 OR 7 WAY LIGHTING SWITCH GAUGE-COOLANT

TEMPERATURE
01086 1 R05 01075 3 01017 3 01055.1 805
C1082-1

1,351013 01058 1 01059 2 80.5

80.76 RW,1.0 C1048-5010405

FUSE BOX-PASSENGER COMPARTMENT (P101)

C0580-31 00580-3? ROOT A3T1 ROOT
0><0

Fig 24 Interior illumination - Non EEGR

Chap 13-1
Page 32 Dec 13 (Amdt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

310GW.1 5.400 A
BATTERY SW1TCH-HAZARD WARNING
R,25.0 C0192 C0045-1 6.400 EARTH 00096-4 GW 1 5 8310 GW1 5 A31D 314GW.0.752120

315GW0 75 1670

STARTER MOTOR GW0.75

C0823-1 "I
GINO 75
R.10.0 C0824-1
u 3166-9.1 5 340

I. C0096-3 GR. 1.5 6316 GR.1 5 A316 320GR,0.75,2240

FUSE BOX-ENGINE COMPARTMENT

321GR,0 75,1790
I INK 7 00-5702 N.6.0 A243 N,6.0
GRO 5

IINK 1 GR 0 75
C0632-1 005701 N.3.0

SWITCH-COLUMN
N,3.0 01080-1 01018-1 C0096-1 8R.0.5

LH C1042-4
N,4 5 SJ3 C0096-2 LGN 1 5 C1042 3
7 RH.: 010422
SWITCH-IGNITION 00006-5 LG1 LGN.10

00006-7 C0096-8

[.
C0028 • C0094-1 08,2.0 A441 W2 0

HEADER 0285
6 OR 7 WAY LIGHTING SWITCH CO285-17 , 00285-13 70.2.0

01082-1 - 01087-1 MAU 0 INSTRUMENT PACK

0.0230-9
11W2 0 010182 01080-2
RELAY-IGNITION
1 00230-10 CO233-2 0,15
WY2 0 0021830 I

FUSE BOX-PASSENGER COMPARTMENT 00218-85

Go580_7 h FUSE 4 C1037-1 01036-1 005
. _
00218-87 I RELAY-HAZARD
00518-86
WARNING
00547-87 00547-30 LGP.0.5 00233-1 I'
C0580-1 I-USE 1 00580-2 P 2.0
00547-85 00547 86 9,05
I' C0580-8 GY.1 5

00580-3 NW2.0
A364
NW 0 A365
8,05 A366 36:13,1.0.220

Fig 25 Indicators and Hazards I — Non EEGR

Chap 13-1
Dec 13 (Amdt 3) Page 33
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

LAMP-DIRECTION INDICATOR/
HAZARD WARNING-FRONT-LH A3/2
A373 0373
E GR.0.76 00001.1 I C0001 2 8,0 5374 8.1.5 A376 8,15

LAMP-SIDE REPEATER-
FRONT-LH
F GR,0 75 00513-1 . C0013-2 8.0 5

LAMP-DIRECTION INDICATOR!
HAZARD WARNING-REAR-LH
GR.0.75 01517-3 01519-3 G0.75 00928-2 00928-1 80.75 521 8,1.0 01519-5 01517-5 B.2.0 A21 B.2.0 C0558-1

LJ GR.1 5 003/6-4 00390-4 GR 1 0 A33

GR,1 o
TRAILER PICK-UP
(0929-1 61260-1 GR 1 0 60499-M

GW,1 0 00929-2 C1260-2 GVV 1 0 60459-N

A GVV.1.5 C0376-5 C0390-5 GW,1 0 516

LAMP-DIRECTION INDICATOR/
GWO75
HAZARD WARNING-REAR-RH
01518-, C1519-3 G075 00928-2 00928,1 8,0./5 SA 8.1.0 01519-5 01718-5 8.20 58 8.20 C0551-

LAMP-SIDE REPEATER-
FRONT-RH A387
A368 5368
C GVV,0.75 06012-1 . 00012-2 8.0 5 A369 5 15 A.370 0,1 5 8J0 0.4 0 00555-1
immommemmin ,

LAMP-DIRECTION INDICATOR/
HAZARD WARNING-FRONT-RH
8 GWO.75 00002-1 C0002-2 B

5322
G 3220.1,5,400 A323 0.1.5

H 3238.0.5.370
I
B,1

Fig 26 Indicators and Hazards II — Non EEGR

Chap 13-1
Page 34 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

RELAY-STARTER A364
5365
00151-86 5,1 0 5366 0.10 0J6 6.4 o 00556.-1
doe
UNIT-DIRECTION INDICATOR/ RELAY- SOCKET-
HAZARD WARNING BRAKE CHECK RADIO CHARGING
C0547 86B4O 5 5,05 C1012-85 5.MAJA 01011-1

SWITCH-WIPER DELAY B 05

13.2.0 A228 0,05

• LAMP-MAP
C1111-2 '----
C0303-4 8,05 C1012-
,

RELAY-IGNITION 8.20 51105-1

SOCKET-INSPECTION
CO218-865,0.5

__u

SWITCH-BLOWER MOTOR SOCKET-ACCESSORY

8,20
1, 00058-3 5,1,0
0.

MOTOR-WIPER-WINDSCREEN LAMP-SIDE REPEATER

• r I; C0030-1 5.2.0 5,1.5
0368
A370 5.1
5367
A368
A369 B.0.5
-FRONT-RH
1.17012-2

LAMP-SIDE REPEATER- ECU-EGR LAMP-SIDE-FRONT-RH

FRONT-LH A3T2
6373 HEADLAMP-LH , 000324 8,10 A33 5.1.0 C0162 8 00448-8 5.1 0
1
.C )
5.0 5
C0013-2 5,05 53/4 0.15 C0009-3

DIFFERENTIAL LOCK UNI HEADLAMP-RH

HORN, LAMP-DIRECTION C0307-1 5,0.5 8,15 C0011-3
C0004-1 5.1 0 INDICATOR/HAZARD
WARNING-FROM-LH UNIT-FUEL TANK MOTOR-HEADLAMP
005 C0001-1 00113-1 8.05 TUL C1187-2 C0391-2 B 10
LEVELLING-RH
LAMP-SIDE-FRONT-LH
1
B05
00010-2

1.
C0538-1 8.05
MOTOR-HEADLAMP LAMP-DIRECTICN INDICATOR/HAZARD WARNING-FRONT-RH
LEVELLING-LH 00002-1 5.0 5
8.05 C0071-2
GAUGE-COOLANT
B373
5.1.5
A322 TEMPERATURE
UNIT-TIMER- 5,15 A3/5 8.15
A323 5,05 01040-3 01048-3 5,1 0 SJ3 8 0 .5 01050-1 '
GLOW PLUG SWITCH-BRAKE WARNING LAMP-HAZARD 8.05
ij 00189-4 B.0
FLUID LEVEL 01036-1 8 0
010592
lj 805 C0026-1 "

PUMP-WASHER-WINDSCREEN INSTRUMENT PACK

8L..
C0008-1 5,0 5
CO233-2 8,1 5 8,1 0 GAUGE-FUEL
005
a--—2,
RESISTOR
_ .
51055 1
C1097-1 8,0.5 TUL
8.05

RESISTOR G1107-2 01506-2

5.0.5 01061-22 SPEEDOMETER
PEEDOMETER
cissai 8 0 5 TUM B05 C1060-2

Fig 27 Earth distribution I - EEGR

Aug 00 (Amdt 1) Chap 13-1

Page 35
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

LAMP-CONVOY-RH
00808.1 5.0.5 01522-2 C1521-2 80..(5 A8 B.2.0 0(Y./h/-1

01519-501518-5 8,20
LAMP-DIRECTION INDICATOR/
HAZARD WARNING-REAR-RH
B.1 0 5.11 B.0 75 00928-1

LAMP-TAIL-RH LAMP-FOG GUARD-REAR-RH

C0121-1 8.075 B 0 75 00515-1

LAMP-BRAKE-RH LAMP-REVERSE-RH
f"--'I 00498-1 5,0./5 912 5,015 /h 0045

LAMP-REAR NUMBER
PLATE-RH
00138-2 80.75

UNIT-FUEL TANK
C0114-2 8.1.0 A21 8.2.0 C0558-1

C1515-50151/-5 5.20
LAMP-DIRECTION INDICATOR/
HAZARD WARNING-REAR-LH
8,1.0 5J1 0.0.75 00928-
LAMP-TAIL-LH
C0121-1 0.0.75
LAMP-FOG GUARD-REAR-LH
B 015 G0f1f/-1
LAMP-BRAKE-LH
C0490-1 0.075 912 B4O 75

LAMP-REAR NUMBER
PLATE-LH
C0138-2 8.075 TRAILER PICK-UP
00499-0 B.1 0 00561-1
1

00499-L 5.10

SCREEN
' ' 1122-SCGCR,MCA 00007-t

Fig 28 Earth distribution II - EEGR

Chap 13-1
Page 36 Aug 00 (Amdt 1)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT HEADER 0285 SOCKET-ACCESSORY

— Ca580-4 P15 CO285-0 C0785-3 P I0 01040-8 C1048-8 P (;1138-2

SWITCH-COLUMN SOCKET-ACCESSORY
01042-7 P I5 00285-4 CO285 7 P 1.0 C1030-1

FUSE BOX-PASSENGER
UNIT-TIMER-GLOW PLUG COMPARTMENT
C0189-3 V1/.2.0 002859 CO285-11 W.2.0 A441 W.2.0 C0680-5
51,

INSTRUMENT PACK SWITCH-IGNITION

CO233-9 W2.0 CO285-12 W2.0 00094.1

CO230.4 W2 0 00285.19 . 00285-1/ W 20

SOLENOID-FUEL
RELAY-IGNITION CUT-OFF
00218-85 W2 0 CO285.13 00285-16 W2 0 004484 C0162-4 A48 W2 0 00198-1

ECU-EGR
w 1.0 C0032-3 :-- •'

Fig 29 Header joints - EEGR

Chap 13-1
Aug 00 (Arndt 1) Page 37
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY
8,25.0 C0192-1 I C0045- 1 0,400 EARTH

STARTER MOTOR
C0823-1

R,10 0 C0824-1

77 L
HEADER 0285
FUSE BOX-ENGINE COMPARTMENT 00285-17 00785-19 33W20.580 A

LINK 2 00570-2 5.60 A243 N.6 0

03285-11 00285-12 44W.20.560

C0632-1 It LINK 1 C0570-1 N 3 0

SENSOR-ENGINE COOLANT
N30 01080-1 C1018-1 TEMPERATURE (ECT)
C0169-1 GUT/5
N.45 SJ3

SWITCH-IGNITION UNIT-FUEL TANK

00115-1 GB 0 5 01187-100379-1 GB 05 TUL
it

C0028-1 C0094-1 W.20 A441 W20 UNIT-FUEL TANK

C0114-1 GB 1 0 C0393-1 C0379-1 GB 0 5 TUM
W20

W20 INSTRUMENT PACK

6 OR 7 WAY LIGHTING SWITCH G05 SJ1 G.05 01054-1 01055-1 013,0 5 01048-701040-7
01079-1 C1017-1
L .
01052-1 C1087.1 NVV.2.0 01080-2 01018-2

00.5 C1052-1
. • 4- t 01053-1 GU.0.5 01048-101040-1 GU 0.5 00448-2 00162-2

NW? 0 C10r8-1 B 00 SJ3 1410 C1040-301040-3 37380 5 710 C.

R.0.75 I C1656-1 E3,0,5

FUSE BOX-PASSENGER COMPARTMENT 01048 4 C1040 4

• A331
00580_5 FUSE 3 1. 00580-6 0333
13.2 0 130 70

00580-75 II FUSE 15 0A2180-30 4B0 75 A713 718011 0 5.1760

0><> LL
C0580-1

NW,10
// HEADER 0285
SWITCH-COLUMN
05580-3 I. FUSE 2 I00580-4 P15 00285-5 „ CO285-4 P15 168U05 2 0.200
t-C1><CH

Fig 30 Instruments I - EEGR

Chap 13-1
Page 38 Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

INSTRUMENT PACK
ALTERNATOR/
DIODE GENERATOR
CO230-5 5505 00118- 1 C0118-2 55.00 C0448-3 C0162-3 NYC) 75 C0185-1 -
, 1.4 EARTHVIA
FIXINGS

SNATCH-COLUMN
CO230.10 UR 0 5 5:15 (35.075

SW TCH-HAZARD WARNING
GR 15 C0096-3 -

00230-0 GW,0 75 Jo GW 1 5 00086.4

SNATCH-COLUMN
GW 0 75 C1047

D RB 0 5 CO233-3
RELAY-HAZARD
WARNING
CO233-1 LGP.0 C0547-30

DIFFERENTIAL
LOCK UNIT
A W.2.0 CO230-4 CO233-8 BU.0.5 C0448-7 C0162.7 BU 0.5 C0306- I

UNIT-TIMER -GLOW PLUG

B W.20 C01:3:1 (0233.10 86.05 00189 2

SWTCH-OIL PRESSURE
00230-3 VVN,0 5 00448-1 00162-1 WN 0 5 00187-1 ,
LAN1N VIA
618)11C,"

SWITCH-FOG GUARD LAMP-REAR

CO233-4 RY.0 5 C0064-3

SWITCH-BRAKE FLUID LEVEL B373

CO230-I3 BM 5 00031-1 rI 00026-1 8.05 A376 6,1 5 036 8.40 00556-I

A168 8122
E UVV.2.0 A109 UVV,2.0 CO233-5 CO233-2 8,1.5 A323 8,1.5 .

C B.0.5

Fig 31 Instruments II - EEGR

Chap 13-1
Page 39
. Aug 00 (Amdt 1)
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT

6 OR 7 WAY LIGHTING SWITCH
C1083-1 RN.0 5 C1079-4 C1017-4 RN 0 75 C0580-11 1 FUSE 6 C0580.12 RN.0.75 C0376-2 C0390-2 A
BATTERY L_(:><0_,
R.25.0 C0192- 1
C0045-1 8,400 EARTH SWITCH-HAZARD
WARNING
N.3.0 C1082- ! C1087-1 NVV.2.0 C1080-2 C1018-2 NW2.0 C0580-1 FUSE 1 C05802 P2.0 C0096-7
0><>
NVV,1 0
STARTER MOTOR
C0823-1 C0580-3 FUSE 2 C0580-4 P
RELAY-IGNITION (>4:0
ALTERNATOR/GENERATOR ' CO218.87 NW 20 SWITCH-HAZARD
C0183-1 N8 5 00849-1 WARNING
7 0O218-30 VVY 2 0 00580-7 FUSE 4 50580-8 GY 1 5 50096-8
100 03824-1 .
GY 1 5

FUSE BOX-ENGINE COMPARTMENT (P108)

LINK 1 03570-1 N 3 0 01018-1 C1080-1

C0632-1 LINK 2 00570-2. N,6.0 FUSE 7

A243 N.2.0 00580-13 c058014 R.MAJA
-CD..110
N00 SWITCH-MA P
LAMP
0 00580-35 FUSE 18 00580-36 PO 5 01515-3
N 0.> 0
Ns 3.590 1 5 705 - ___
--
SWITCH-IGNITION
MOTOR-BLOWER
-FRONT
00090-1 VV0.1 0 c0580-0 FUSE 5 C0580-10 VG 1 0 C0056-3 "

533 N.4.5 C0020-1 1 C0094-1 0.2.0 8441

it

' •• C0090-1 VVR.1.0 W.2.0 co5ao-5 FUSE 3 C05806 G2.0

0><0
SOCKET-INSPECTION
N,20 C1064- HEADER 0285
W20 CO285-11 '"

RELAY-STARTER W2 0 00285-17
N30 50151-87 C0151-85 VVR 1 0 A47 I,

RELAY BRAKE CHECK

UNIT-TIMER-GLOW PLUG VVR.0 5 C1012.86
LINK 3 055703 N00 00189.5 00189 1 VVR 0 5

Fig 32 Power distribution I - EEGR

Chap 13-1
Page 40 Dec 13 (Amdt 3)
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

HEADER 0285 SOCKET-ACCESSORY

B 22P 1 5.640 0285-5 00285-3 P1 0 01040-8 01048-8 P 0.5 01138-2

SOCKET-ACCESSORY
CO285-7 P 1.0 C1030

swicH-COLUMN
CO285-4 P,1.5 01042-7

SWITCH-BRAKE PEDAL
122(37.1 5.900 (0029-1

GY.0 75
7- SWITCH-REVERSE LAMP
II00448-5 C0162-5 G05 00167-2

SOCKET-RADIO CHARGING
361R MAJA.42401853 4. '

LAMP-CONVOY-RH
A RN 0 75 830 RN.0 75 01521-101522-1 RN 05 (1065-1

TRAILER PICK-UP
RN.075 A36 RN0.7.5 01305.201306-2 RNA 0 10499-A
Ammo
RND 75 01305.301306-3 RN, 1 0 00499-0 -

RN 0 75 01305-4 01306-4 RN 1 0 (.0403-H

' E P,1.5 C0377-6 C0391-6 P20 01305-5.01306-5 P.10 00499-K

5331 MOTOR -WIPER -WINDSCREEN

G 333G 2 0.190 A313 020 00030-4

SWITCH-WIPER DELAY
151 0 00303-8 -
(1

SWITCH-WASH/WIPE-WINDSCREEN
G1 0 00278-5 '
INSTRUMENT PACK
01054-1 GO 5 651 GO 5 01045-401040-4 GO 75
•
01002-1 CO 5

Fig 33 Power distribution II - EEGR

Chap 13-1
Aug 00 (Amdt 1)
Page 41
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

FUSE BOX-PASSENGER COMPARTMENT

SWITCH-COLUMN HEADLAMP-RH
A341 UR.2.0 C0580-21 FUSE 11 I, C0580-22 U8.2 0 C0011.2
7 - C1042-6 UR 2 0

II
HEADLAMP-LH
UR.1 0 00680-23 FUSS 12 C0580-24 UK2 0 00009-2

u MOTOR-HEADLAMP LEVELLING-RH
UR.1.0 C0580-33 FUSE 17 03680-34 U01.0 A378 UG.0.5 C0070-3
=

MOTOR-HEADLAMP LEVELLING-LH
11(005 C0071-3

A168 HEADLAMP-RH
C1042-5 UVV.2 0 A189 07020 C0580-25 FUSS 12 CO580-26 00,2 0 00011

INSTRUMENT PACK HEADLAMP-LH

03233-5 UVV2 0 UVV2 0 00580-27 FUSS 14 00580-28 US 2 0 00009-1
J%

SWITCH-COLUMN SWITCH-FOG GUARD LAMP-REAR

C1042-1 U 2 0 9334 U,20 00580-19 FUSE 10 C0580-20 UP.1 5 00064-2
r--0>•<-3
[
6 OR 7 WAY LIGHTING SWITCH INSTRUMENT PACK
n"---101084-1 U20 G10/9-2 tA01/-2 U10 RR 05 00233-3 "

LAMP-SIDE-FRONT-RH
C1085.1 505 01079-1 0101 7-1 9.0 75 00580-29 FUSE 15 !, 00580.30 RB 075 4213 88 0 /5 00537-2
01
-. -
LAMP-SIDE-FRONT-LH
RB.0 75

fl TRAILER PICK-UP
FUSE 16 Al 9010 01305.101306.1 90,10 00499-F
it 01086-1 R 05 01078-3 01017 3 R 0 75 00580-31 03580-32 RO 1 5 00376-100390.1 9010
0› ,(0 om molm7Ino
ROC 5
LAMP-REAR NUMBER
GAUGE-COOLANT TEMPERATURE
, C1059-1 RWO 5 SJ2 RW1 0 C1048-501040-5 ROSS A351
I 50.0 75 01515-401519-4 RU.0 /5 All 80,015
PLATE-RH
C0138-1 '' ..-

II
fl
fl
SPEEDOMETER
01060-1 RWO 5

p C1061-1 RWOS
II,
I R0.0./5
LAMP -TAIL-RH
00121-, 1--

LAMP-TAIL-LH
GAUGE-FUEL RO 0 75 01517 401519 4 50.075 All 90075 C0121.2
C1057-1 RVVO 5
tl
LAMP-RFAR NUMBER
SOCKET-ACCESSORY PLATE-LH
C1027-1 50,0.75 R0,0.75 C0138

Fig 34 Power distribution III - EEGR

Chap 13-1
Page 42 Dec 13 (Arndt 3)
ARMY EQUIPMENT - 2320-D-128-302
SUPPORT PUBLICATION

Al (RO) CHASSIS , All (RO) BODY

FUSE BOX-PASSENGER COMPARTMENT TRAILER PICK-UP

I, '-'''' C0580.32 R0,1 5 C0376-1 C0390-1 RO 1 0 Al RO 1 0 01305-1 01306-1
il RO 1 0 C0499-F
11 il'
II ,_. 11

LAMP-TAIL-LH LAMP-TAIL-RH
17' '' --ii 00121-2 00,0.75 All 00,0.75 01519401517-4 00.0.75 00.0.75 01010-4 01519-4 50,015 All 50.0 00121-2
tl '.

LAMP-REAR NUMBER LAMP-REAR NUMBER

PLATE-LH PLATE-RH
C0138-1 RO 0 75 RO 0 75 03138-1

11,1 A6 + B6 (GP) CHASSIS

SWITCH-BRAKE PEDAL TRAILER PICK-UP

C0075-1 GP.1 0 01018-401080-4 GP 0 5 01080-3 01018-3 GP 1 5 00376-6 C0390-6 GP 1 0 86 GP 10 A6 GP 1 0 00929-3 01260-3 GP 1.0 C0499-9

GP 1.0 00929-4 C1260-4 0P,1.0 00499-J

LAMP-BRAKE-RH
-'" ' • C0490-2 GP.0 75 01519601518-6 GP 0 75
LAMP-BRAKE-LH
000.75 01517-6 C1519-6 GPO 75 00490-2

!i A10 (RY) CHASSIS

LAMP-FOG GUARD-
SWITCH-FOG GUARD LAMP-REAR REAR-OH
00064-3 50.1 5 C0376-3 00390-3 RY 1 0 A10 RY 0 75 01517-201519-2 R0075 00515-2 -

TRAILER PICK-UP
C0490-F RY.1 0 01301:601305-6 8010 LAMP-FOG GUAR D-
REAR-RH
00,0 /5 015152 01519.2 50.0.75 00515-2

Al6 (GW) CHASSIS A310 + B310 (GW) MAIN

LAMP-DIRECTION INDICATOR/
SWITCH-HAZARD WARNING HAZARD WARNING-FRONT-RH
00096-4 OR.1 5 9310 nw 1 5 0310 nvv.o 75

INSTRUMENT PACK
LAMP-SIDE RE PEATER-
ii 00230-9 GW0.75
FRONT-RH
GVVO 75 00012-1

SWITCH-DIRECTION
INDICATOR
C1042-2 GVV 0 70 LAMP-DIRECTION INDICATOR/
HAZARD WARNING-REAR-RH
GVV 1 5 00376-5 00390-5 GW 1 0 A16 000 0 75 01518-3 01519-3 GO 75 00928-2

TRAILER PICK-UP
GVV 1.0 C0929-2 C1260-2 GW 1 0 C0499-N

Fig 35 Splices and centre taps I - EEGR

Chap 13-1
Aug 00 (Amdt 1) Page 43
2320—D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

A33 (GR)CHASSISI: is A316 + 13316 (GR) MAIN

LAMP-DIRECTION INDICATOR/
SWITCH-HAZARD WARNING HAZARD WARNING-FRONT-LH
00096-3 GR.1 5 8316 GR 1 5 A316 GR.() 75 C0001-2

II ;

INSTRUMENT PACK LAMP-SIDE REPEATER-

CO230-10 GR 0 5 FRONT-LH
GR.0 75 C0013-1

SWITCH-DIRECTION 1- -
INDICATOR LAMP-DIRECTION INDICATCR/
J
C1042-4 GR0.75 HAZARD WARNING-REAR-LH
II II" GR,1 5 C0376-4 C0390 4 GR 1 0 GR 0 75 01517-3 C1519 3 00 75 00928-2
L

TRAILER PICK-UP
A36 + B36 (RN) CHASSIS ! GR 1 0 00929-101260-1 GR 1 0

FUSE BOX-PASSENGER
COMPARTMENT TRAILER PICK-UP
u C0580-12 RN 0 75 C0376-2 C0390-2 RN 0 75 B36 RN 075 A36 RN.0 75 01305-2 C1306-2 RNLI 0 C0499-A

RN.0. 75 C1300-3 C1306-3 RN,1.0 00450-0

LAM P-CONVOY-R H
ri r ---- '71(1:1065-1 RN 0 5 01522-1 C1521-1 RN 0 /5 145-0 (11305-4 01306-4 RN 1 0 00450-H
II

A 168/A109 (UW) MAIN

L,447 (WR)MAIN
FUSE BOX-PASSENGER COMPARTMENT
A165 SWITCH-COLUMN
SWITCH-IGNITION RELAY-STARTER I II 00580-25 UN/ 2 0 A185 UW2 0 01042 5
03090-1 WR.1.0 A47 VVR 10 CO151-85 1.
(

00580-27 UVV.2 0 INSTRUMENT PACK

RELAY-BRAKE CHECK UNIT-TIMER-GLOW PLUG UVV2 0 00233'
C1012-86 WR.0.5 VVR,0 5 00189
1';

L A191 (LGN) MAIN

!! A48 (W) ENGINE RELAY-I-rRD
SW TCH-HAZARD WARNING WARNIN
SOLENOID-FUEL
00096-2 LGN.1 5 AI91 LGN 1 5
HEADER 0285 CUT-OFF
00285-16 W 20
0 C0448-4 00162-4 042 0 A40 552 0 C0198-1

SWITCH-COLUMN
IGN 1 9 01042.3
ECU-EGR
W 10 C0032-3
„f 11 A213 (RB)MAIN ,
LAMP-SIDE-
FUSE BOX-PASSENGER COMPARTMENT FRONT-RH
;, 00580-30 RB 075 A213 RB.0 75 00531

INSTRUMENT
: PACK
RB 0 5 CO233-3 1

Fig 36 Splices and centre taps II - EEGR

Chap 13-1
Page 44 Aug 00 (Amdt 1)
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

A243 (N)MAIN SJ3 (N)

A341 (UR) MAIN
FUSE BOX-ENGINE FUSE BOX-PASSENGER FUSE BOX-PASSENGER
COMPARTMENT COMPARTMENT SWITCH-COLUMN COMPARTMENT
1 03570-2 N 6.0 4243 5.20 C0580-13 ' ; 01042-6 U62 0 4141 06.2 0 C058021

N60 UR 1 0 00580-23
SWITCH IGNITION
1- C0028-1 N,4 5 SJ3 N,2 0 03580-35 UR 1.0 00580-33
1
11111

SOCKET-INSPECTION RELAY-STARTER A351 (RO) MAIN SJ2 (RW) INSTRUMENT

01064-1 N2 0 N 30 03151-87

FUSE BOX-PASSENGER COMPARTMENT SOCKET-ACCESSORY

00580-32 50,05 1351 60.075 01027-1

R0,05 01040-5 C1048-5

I A331+ A333 (G) MAIN SJ1 (G) INSTRUMENT SPEEDOMETER 11
01060-1 R-V40 5 SJ2 608.1 0 GAUGE-COOLANT
MOTOR-WIPER-
FUSE BOX-PASSENGER COMPARTMENT TEMPERATURE
4331 WINDSCREEN 01061-1 4/40 5 0-080 0 01050-1
C05806 G20 A333 G20 00030-4

GAUGE-FUEL ,SOCKET-ACCESSORY
SWITCH-WIPER .
SWITCH-VIASHAMPE 01087-i RIN,0 RIA/ 0 F., 01134
DELAY -WINDSCREEN
, 00303-8 01D G1 0 00278-6

A378 (0G) MAIN

G0.75
GAUGE-COOLANT
TEMPERATURE FUSE BOX-PASSENGER MOTOR-HEADLAMP
01040-401048-4 G056.11 00.5 01052-I 7 -- COMPARTMENT LEVELLING-RH
C0580-34 1X01 0 4370 UCi0 5 C0070-3

SOCKET-ACCESSORY GAUGE-FUEL
C1136-3 G05 ilGO 5 C1054 MOTOR-HEADLAMP
r RESISTOR LEVELLING-LH
• C0038-2 UG 1 0 000 5 /1

. d A381 (U Y) MAIN
A334 (U)MAIN MOTOR-HEADLAMP
• RESISTOR LEVELLING-RH
FUSE BOX-PASSENGER COMPARTMENT SWITCH-COLUMN 00037-2 411(0.5 A381 UY.0.5 00070-1
01580-19 U,2 0 A334 1.1 .2 0 01042

MOTOR-HEADLAMP
6 .957 WAY LIGHTING SWITCH LEVELLING-LH
020 C1017-201070-2 U,20 C1084-1 0105 00071-1

Fig 37 Splices and centre taps III - EEGR

Chap 13-1
Dec 13 (Arndt 3) Page 45
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

A.3134 (GU) MAIN ' SJ2 (RB)ENGINC

RESISTOR SENSOR-THROTTLE
SWITCH-HEADLAMP TUM G"-° 5 C1061-1 ECU-EGR POSITION (TP)
LEVELUNG 01862-2 98.05 98,05 C01/5-3
Li 000935 GU 1 0 A384 GU 1 0 01506-301507-3
fr?, RESISTOR
TUL G" 05 C1098 1
RESISTOR SOLENOID-EGR
'71 CC038-1 GU.1 0
RB 0 5 00191-1

fl
4441(W) MAIN
FUSE BOX-PASSENGER
SWITCH-IGNITION COMPARTMENT
00094-1 W2 0 A441 W20 00580-5

a—
HEADER 0285
W20 00285-11 1

W2.0 CO285-17 ,

SJ1 + SJ2 (UB) RESISTOR PACK

RESISTOR
TUL 00,0 5 SJ1 UB05 01095-2
i

SWITCH-HEADLAMP LEVELLING RESISTOR

o-- `- Li 00093-2 US 1 0 01506-1 01507-1 110 0 5 01007-2

RESISTOR
TUM UB 05 SJ2 uB.oS 01961-2

SJ1 (KB) ENGINE

I LAW 0 C1960 2
RESISTOR

SENSOR-THROTTLE
SENSOR-TEMPERATURE-EGR POSITION (TP)
00027-2 KB4O 5 SJ1 KB 0 5 00175-

ECU-EGR SOLENOID-EGR
00032-1 K805 K0,0 5

Fig 38 Splices and centre taps IV - EEGR

Chap 13-1
Page 46 Aug 00 (Amdt 1)
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

I
BATTERY ALTERNATOR/GENERATOR
R.25.0 00192-1 C0045-1 6,400 EARTH
STARTER MOTOR
H C0849-1 r N.6.5 00183-1

C0823-1
• r_.1
R,100 C0824-1
EARTH VIA
FIXINGS
C0179-1 1 (-0448-300162-3 NY.0 C0185-1
FARTH VIA
FIXINGS

DIODE
NY0 5 00118-2 ' 00110-1 030N 0 5 445 A

FUSE BOX-ENGINE COMPARTMENT

r_cf.N. a_.
LINK 3 , 00370-3 3N 6 0 460

C0632-1 LINK 00570-2 N.6.0 A243 N,6.0 0011.3. 0 00203-1 C0449-1

NA 5 0J3

RELAY-STARTER
N 30 C0151-87 , - 00151-30 WR 30

A47 WR 1 0 00151-85 00151-86 3658.10.170 C

SWITCH-IGNITION
rt̀ 14-- "•

75WR,0 5.630

00090-1 VON 10
T HEADER 0285
00028-1 1 00094-1 W20 A441 W20 00285-11 ' 00255-0 2900,2 0 86(1 F

CO285-12 44W20.560
. ..
W20 CO285-17 ' , 00285-10 33002 0 560
' -
CO285-16 W2.0 0)448-4 C0162-4 W.20 A48 W.20 SOLENOID-FUEL CUT-OFF
4'0 coase-i

Fig 39 Charging and starting I - EEGR

Chap 13-1
Aug 00 (Amdt 1) Page 47
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

INSTRUMENT PACK
GLOW PLUG 1
C0476-1
EARTH VIA
•A YN.0 5 CO230-5 FIXINGS

W2.0 UU2,35-4
GLOW PLUG 2
YB.3 0 C0477-1
,._H• • CARTS VIA
FIXINGS

W20 CO233-9 4 CO233-10

GLOW PLUG 3
BY .3 0 C0478-I
EARTH VIA
FIXINGS

UNIT-TIMER-
GLOW PLUG
WR,0 5 00189.1 C0189-2 YB 05 GLOW PLUG 4
YB 3 0 C0479-1 71

C1035-1
-4' t.ierA
r-,,iTH
W, 0 C0189-3 • 1 C0189-6 85.6 0

H373
N,6.0 C0189-5 C0189-4 8.0. 5 A376 B.I.5 SJ6 8,4.0 C0556- I

9384
A365
8.1.0 A366 B.1.0

Fig 40 Charging and starting II - EEGR

Chap 13-1
Page 48 Aug 00 (Amdt 1)
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
R 250 c019, ' 20045 1 B400 030531

STARTER MOTOR
C082,1

R100 COB2.1-1
sPEECOME TER
G11..11 111 ,..10408,.:10.40-3 11 0, „ B40

(7 %NO 8, (:10611 1210610 SoS

^

FUSE BOX-ENGINE COMPARTMENT

uNrct 0,05761 N30 810181 c.

GAUGE-FUEL
C10861 80 8,

R1,NO 8- 8105%1 21051- B.0

1130

6 OR 7 WAY LIGHTING SWITCH GAUGE-COOLANT

TEMPERATURE
N1088-1 R ns C1088-1 B 05

01005 12105E81
•
8.21259-0 B05

r
NO 78 RW10 [1040,,

FUSE BOX-PASSENGER COMPARTMENT

CU.°, '6'6 6 1_0:8032 0008 0051 0005
,._

AMMETER
80010 01021 1 81712 1 ROO 5 01153-1 211532 808 8.12 8103 1 8 20 A228 020
I

Fig 41 Interior illumination - EEGR

Chap 13-1
Dec 13 (Amdt 3)
Page 49
 ARMY EQUIPMENT
2320-D-128:302
SUPPORT PUBLICATION

310GV1/ 1 5 400 A

BATTERY SWITCH-HAZARD WARNING

00045B.400 EARTH 111 00096-4 GVV 1 5 R310 GVV 1 5 A310 31413W 0 75.2120
R,250 C01921 !

3 JJAW0.75.1670

GWO 75
STARTER MOTOR
00823-1 '1--
GW,0 75

R,10.0 00824-1 3 6GR 1 5,340 D

00096-3 GR, 1 5 9316 GR,1 5 A310 320GR,0 75.2240

FUSE BOX-ENGINE COMPARTMENT 32109,075.1790

LINK 2 1 00570-2 N 6 0 A243 N.6 I)

GR.0 5

GR 0 75
C0632-1 LINK 1 1 C0070 N30

SWITCH-COLUMN
N.30 C1080-1 C1018-1 1:0096-1 BR.0 5
N C1042-4
N45 SJ3 ! 00096-2 LGN 1 5 A191 IAN 1 b 121042-3
01042-2
C0096-5 LG1 5
SWITCH-IGN I IION

HEADER 0285 LAN. I5

6 OR 7 WAY •LIGHTING SWITCH CO285-1/ CO285-13 70 20
C0028-1
INSTRUMENT PACK
01082-1 C1087-1 NW2 0 - V

CO230-9

NVV,2.0 G101&201060-2
RELAY-IGNITION
CO230-10 1 CO233-2 8 15 10
1AN.2 0 CO218-30

CO218-05
FUSE BOX-PASSENGER COMPARTMENT
01037 C1036-I 905 H
00580-7 FUSE 4 00218-87 RELAY-HAZARD
CO218-R3 WARNING
17-87
C0, • 1 00547-30 LGP05 00733-1

C0547-85 ! C0547-86 8.0 5

• 1-

C0580-3 NVV.2 0
A364

Ns s.
NW 1 0
B.0.5
A365
A366 3658.1 0.220

Fig 42 Indicators and Hazards I - EEGR

Chap 13-1
Dec 13 (Amdt 3)
Page 50
ARMY EQUIPMENT
SUPPORT PUBLICATION 2320-D-128-302

LAMP-DIRECTION INDICATOR/
HAZARD WARNING-FRONT-LH 0072
GR 0 75 113 ,
(0001 2 00001 1 R05 A014 1115 .170 0.t5

LAMP-SIDE REPEATER-
FRONT-LH
OR 075 ram, 0001, 130 5

LAMP-CIRECTION INDICATOR,
HAZARD WARNINGREAR-LH
67.072,1 00926.1 11 0 15 001 B 10 (I1,17.5 R .0 021 B '2 0 G1,56-.1

D GR I 5 CO.04 C0000-4 IGR 10 A33 III

TRAILER PICK-UP
GR 10 001
720!.1-'00.1 GH

GW10 U19,-2111.00., GIN 0 1.6100-0

A G. l (0770 5 20600 5 GIA/ 10 070 I

LAMP-DIRECTION INDICATOR,
HAZARD WARNING-REAR-AR
c.11.1856.1010, :00202 0110211, 0010. 001 0I0 015100010100 000 A0 020

LAMP-SIDE REPEATE R-
FRONT-RH ,63
G Gv010 7'6 Amie 6'01A
4.001B.1 000122 001, 0160 6 11- 040

LAMP-DIRECTION INDICATOR,
HAZARD WARNING-FRONT-RH
G0002— CIX10..•1 uu5

G A.122
1210.15400

11 ,0510 5 0B

J 010

Fig 43 Indicators and Hazards II - EEGR

Aug 00 (Amdt 1) Chap 13-1

Page 51
 ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

ECU-EGR ALTERNATOR/GENERATOR
C1862,1 008.0 78 C1863-1 I—
I.

MODULATOR-EGR
1 C1721-A G10 CO270-1

01721-B 10 00270-2
BATTERY
8,25.0 00192-1 1 ;' 00345-1 8,400 EARTH

35CR.5CR.1640 00807-1

SOLENOID-EGR
C1862-3 813.0.5 C0191-3 :: C0191-2

STARTER MOTOR 00191-

C0823-1 j

R 10.0 C0824-1
C1862-2 RBO 5 SJ2 80.0 5

80.05

SENSOR-THROTTLE
FUSE BOX-ENGINE COMPARTMENT POSITION (TP)
01862-4 R05 00175-2 r 00175-3
LINK 2
00637-1 00570-? N60 A1,43 N.A
05175.1
dmaraimierair

SENSOR-TEMPERATURE -EGR
N45 SJ3 00032-2 GU.0 5 00027-1 1 00027-2

KR 05
SWI TCH-IGNIIION
00332 I 80,02 5J1

KB 05
00028-1
----- C0094-1 W_20 A441 W.2.0
13360
W I0 C0082-3 00032-4 0.1 0 A33 B 1 0 00102-8 00448-8 B.1 0 8370 0.1 5 0J6 040 00758-1

HEADER 0285
CO285-17 CO285-16 W2 0 00448-4 00162-4 802.0 A48
L -

Fig 44 EEGR

Chap 13-1
Aug 00 (Amdt 1)
Page 52
ARMY EQUIPMENT
SUPPORT PUBLICATION 2320-D-128-302

BATTERY
R.25.0 03192 C0045-1 B.40.0 EARTH

STARTER MOTOR
C0823 "

R,100 00824-1

TRAILER PICK-UP
C0376-6 C0390-6 GP, 1 0 B6 GP.1 0 A6 GP 1.0 C0929-3 C1260-3 GP 1 0
FUSE BOX-ENGINE COMPARTMENT
GP1.0 C0929-4 C1260-4 GP,1.0 00499-2
LINK 2 00.570.2 N60 A243 N.6 0

036321 LINK 1 '

LAMP-BRAKE-LH
C0570.1 14.3.0 01018-1 01080.1
'
GP,075 01517-6015136 GPO C0490-2 C0490-1 B.0 /5 Al2 9.075 SJ1 8,10
N30
10 1 B.? 0 C151/-5 C:1519 ti
N45 SJ3 GPO 75

SWITCH-IGNITION GP 1 5 20 00558-1
C1018-3 C1080-3 GPO 5
, .

HEADER 0285 A8 B20 C0557-1

00028-1 C0094.1 W20 A441 W.20 00285-17 CO285.13

20 01518-501519-5
V LAMP-BRAKE- RH
21518-6 21519-6 GPO 75 20490-2 , : 20490-1 8.075 Al2 B 0 75 SJ1 0.10
60R!WAY LIGHTING SWITCH .

C1082-1 01007-1 NW.2 0

LAMP-REVERSE-RH
GN 075 C0455-2 I C0455-1 B 0 75
NW.2 0 01018-2 C1080-2
RELAY-IGNITION
WY ? 0 CO218-30 !

FUSE-
BOX-PASSENGER COMPARTMENT c62113-85 W 2 0
A364
! NNE 0 CO218-87 6365
CO218-86 805 6366 B10 SJE. B 4 0 50555-1
00580- 7 FUSE 4

C0580-1 SWITCH-BRAKE PEDAL

C0580-8 67 1 5 C0029-1 00()75-1 661 0 010184 01085-4
NW.1.0

00162-5 05448-5 GY.0.75

SWITCH-REVERSE LAMP
GO 5 00167-2 , 00167-1 GN 0 5 00162-600448-6 GN,10 C037/-1 00301-1 GN.1 0 01518-1 01519-1
:

Fig 45 Brake reverse lamps

Dec 13 (Amdt 3) Chap 13-1

Page 53
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY
0,25.0 C0192-1 r I - 00045-1 8.400 EARTH

STARTER MOTOR
03823-1 ° LAMP-FOG GUARD-REAR-LH
RY 0 75 01517-2 01519-2 RY,0 75 00515-2 I, 00515-1 B.075 SJ1 B 10 C1519-501517-5 B.20 A21 B.20 03558-1
R,10.0 00824-1

FUSE BOX-ENGINE COMPARTMENT

TRAILER PICK-UP
03632-1 LINK 1 - C0570-1 N,30 01018.101080-1 A10 RY,1 0 01305-6 01306-6 00,1 0 00490-F

N.3 0
LAMP-FOG GUARD-REAR-RH
07,0 75 C1518-2 01519-2 RY,0 75 00515-2 . • C0515-1 RO 75 SJ1 13.1 0 C1519-5 C1518-5 B 20 A8 0.2 0 00557-I
.10 •1•11k"
6 OR 7 WAY LIGHTING SWITCH

C1082-1 [1 " 01084-1 U.2 0 C1079-2 C1017-2 RY.1 0

U,2.0 A334 U 0

FUSE BOX-PASSENGER COMPARTMENT

SWITCH-FOG GUARD LAMP-REAR
.19
00580 FUSE 10 00580-20 UP 1 5 00064-2 00064-3 RY 1 5 03376-300390-3
. .
INSTRUMENT PACK

A322
RY,0 5 00233-4 1 CO233-2 8.1 5 6323 5.1 5 026 BA 0 Wr66.1

Fig 46 Fog lamps

Chap 13-1
Dec 13 (Amdt 3)
Page 54
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
R.25 0 00192-1 00045-1 6.40 0 EARTH

STARTER MOTOR
00823-1

6 OR 7 WAY LIGHTING SWITCH

FUSE BOX-ENGINE COMPARTMENT SWITCH-COLUMN
LINK 1
CE632-1 00570-1 N 3.0 C1018-1 01080-1 N 30 C1092-1 1 C1084-1 U20 C1079-2 C1017-2 U.2.0 6334 U.20 C1042-1

UR 10 A341 UR.2 0

FUSE BOX-PASSENGER COMPARTMENT

FUSE 17 . C0580-34
MOTOR-HEADLAMP LEVELLING-RH
CO580-33 UG 1 0 A378 0100 5 00070-

A367
A368 0368
UY.0 5 00070-1 C0070-2 B.0 5 A369 0.1 5 A370 B 15 SJ6 0.4 0 03579- 1

SWITCH-HEADLAMP LEVELLING RESISTOR MOTOR-HEADLAMP LEVELLING-LH

'! 000935 Gu.1 0 6384 GU,1.0 Guam 000382 UG1 0 ue,o C00/13

A372
RESISTOR A373 8373
C0093-4 50.1 0 00037-1 00037-2 UY,0 5 A381 U5.05 00071-1 000 /1-2 6.0.7 A374 6.1 5 A376 8.1
. /stassmsossaismr
710093-2 UBT 0
RESISTOR
TUL UE0.5 SJ1 LJB.0 5 C1097-2 C1097-1 0.05 TUL
C 30E6 C1507-1 A322
=MN 01507-2 01506-2 0.1.0 A323 B15
TUM
TUM
RESISTOR
06.0.5 SJ2 U8.0.5 01960-2 :: :' 01960-1 6,0

RESISTOR
TUM GU.0 5 01961-1 '""" - — 0106 US 0 5

G0,10 C1506-3 C1507-3

RESISTOR
TUL GU,0 01098-4 r 01098-2 UB,0

Fig 47 Headlamp levelling

Dec 13 (Arndt 3) Chap 13-1

Page 55
 ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
C0045-1 Fl 40 0 FAR] FI
• “.tH

STARTER MOTOR
C0823-1

R.10.0

FUSE BOX-ENGINE COMPARTMENT

C0632-1 LINK 1 C0510-1 N30 01018-1 C1080-1

N.3,0

6 OR 7 WAY LIGHTING SWITCH

HORN A372
6373 6373
01080-201018-2 PB 10 C0003-1 00004-1 B 10 A375 8,15 A376 B 15 SJ6 B,40 C05 56- 1
C1082-1 '1 C1087-1 NW2 0

NV1.12 0

FUSE BOX-PASSENGER COMPARTMENT

C0580-1

NVV.1.0 SWITCH-COLUMN
HEADER 0285
00590-3 u FUSE 2 C0580.4 CO205-5 00285-4 P.1 5 01042-7 r 01042-0

Fig 48 Horn

Chap 13-1
Dec 13 (Arndt 3)
Page 56
ARMY EQUIPMENT
SUPPORT PUBLICATION 2320-D-128-302

BATTERY
8,25.0 00192-1 C0045-1 B.400 EARTH

STARTER MOTOR
C0823-1
R,10.0 C0524-1
V
FUSE BOX-ENGINE COMPARTMENT
LINK I C0570-1 0.30 C1018-1 C1080-1 N 30
00632-1 . L INK 2 L 00570_2 N,60 A243 N60
N 20 SJ3
6 OR 7 WAY LIGHTING SWITCH

C1082-1' 01086-1 R0.5 01079-3 C1017-3 0.0.75

C1083-1 RN 05 01079401017-4 911.0 75

FUSE BOX-PASSENGER COMPARTMENT

00580-31 FUSE 16 00580-32 R0.1 5 00376-1 00390-1 R0.1 0 Al 80,10 01305 1 01306-1 00,1 0 C0499-E
TRAILER PICK-UP
•
RN,0 75 01305-2 C1306-2 Rut 0 00499-A ,
1
00580-1I "'SI- 6 j 00580-12 RN 075 00376-2 00390-2 RN.0 75 836 RN.0 75 A36 00.0 75 01305-3 01306-3 RN 10 00499-C
imisumniminme.
RN.0 75 C1305-4 C1306-4 RN 1 0 00499-H
00580-35 FUSE 18 00580-36 P1 5 00377-6 00391-6 P 2 0 01300-5C1306-5 P.1 0 00499-K 00499-D 8.1000361-1
SWITCH-FOG GUARD LAMP-REAR C04991 8.1.0
00064-3 127.15 00376-300390.3 RYA 0 A10 RY 10 01305-6 C1306-6 RY 1 0 C0499-1
SWITCH-BRAKE PEDAL
00075-1 GR1 0 01018-4 01080-4 GP.0 5 01080-3 01018-3 GP 1 5 00376-6 00390-6 GP 1 0 06 GP 1.0 06 GR1 0 00929-3 01260-3 GR1 0 00499-6
a
GP 1 0 00029-4 01260-4 GP.1 0 00499-J
SWITCH-COLUMN
0104-4 WO 75 B316 00.1 5 A316 GR.15 C03704 00380-4 GR.1 0 A33 00,1 0 00926-101760-i GR 1 0 00499-M
SWITCH-HAZARD WARNING
C0096-3 GR 1 5
C0096-4 GW1 5 B310 GW1 5 A310 GW 1 5 C0376-500390.5 ON1 0 A16 GW 1 0 00929-201260-2 1376 1 0 00499-N
01042-2 e, GWO 75

Fig 49 Trailer socket

Dec 13 (Amdt 3) Chap 13-1

Page 57
2320-D-128-302 ARMY EQUIPMENT
SUPPORT PUBLICATION

BATTERY
R.250 00192-1 C0045-1 B 400 EARTH
••-t—L • •-•Ht-:

STARTER MOTOR
C0823-1

R.10.0 C0824-1 ;

FUSE BOX-ENGINE COMPARTMENT

FUSE BOX-PASSENGER COMPARTMENT
C0632-1, LINK 1 t; C0570-1 N.3 0 C 1018-1 01080-1
00580-29 h FUSE 10 c0580-30 21499,0.75,2190 A

_ _h N,3 0
RB 0 75 A213 213R9 0 75 1750

6 OR 7 WAY LIGHTING SWITCH 00500-31 FUSE 16 C0580-32 00,1.5 C0376-1 C0390-1 150,1.0,3900
C1085-1 0.05 C1079-1 01017-1 9075
0:><C)

01082- • 01086-1 9,0 5 C1079-3 01017-3 R,0 75

C1083-1 RN.00 C1079-4 C1017-4 RN.0 75 00580-11 1 FUSE 6 C0580-12 RN 075 C0376-2 C0390-2 36RN.0 75.3810
0><C)
-

C1084-1 U.2.0 01079-201017-2

3,2,0 A334 U 2.0

UR,1 00580-23 FUSE 12 06580-34 3905 K,20,2360

SWITCH-COLUMN
C1042-6 UR 2.0 A341 UR 2 0 C0580-21= FUSE 11 ; C0580_22 39255.2 0,2440
C1042-1 n
#."-•

A168
;, 01042 5 11W2 5 A189 1102 0 00580-25 FUSE 13 C0080. 26 3911102 0 2440
of

UW2S 00580-27 FUSE 14 00580.28 389502 0,2360

INSTRUMENT PACK

513 0 5 CO233-3 00233-2 6.15 A322 32213,15,510

mimommomnimm,

U702 0 CO233-5

Fig 50 Head, side and number plate lamps I

Chap 13-1
Page 58 Dec 13 (Arndt 3)
ARMY EQUIPMENT 2320-D-128-302
SUPPORT PUBLICATION

TRAILER PICK-UP
RN,0 75 B36 RN,0 75 A36 RN 0 75 C1305-2 C1306-2 RN.1 0 C0499-A

RN.0.75 C1305-3 C1306-3 RN,1 0 C0499-0

RN,0 75 01305-4 .C1306-4 RN,1 0 C0499-H

RO 10 C1305-1 C1306-1 RO 1 0 C0499-0 ,

LAMP-CONVOY-RH
RN,0 75 C1521-1 01522-1 RN 05 01065-1 , , 00808-1 8 0 5 01522-2 C1521-2 8075

LAMP-REAR NUMBER PLATE-U-1

R0,1.0 0 75 C1517-401519-4 R0,075 All R0075 C0138-1 I, 00138-2 B.0 75 Al2 B4O 75 SJ1 13.1 0 C1519-5 C1517-5 13.2 0 A21 B.20 ODS55- 1
h-- ,, ----0, .wimiiiis d 2

LAMP-TAIL-LH
RO 0 75 001212 C0121-1 B 0 75

LAMP-TAIL-RH
R0.075 C1515-401519.4 RO 0 75 All R0075 C0121-2 ' ", 00121- SO 75 SJ1 810 01519-5 01518-5 5.20 AA 8.20 crf,57. I
, 1
---i4.

LAMP-REAR NUMBER PLATE-RH

,
60,075 00138-1 •d, , 00138-2 0.075 012 13,0.75
11 ,•„„ ....S.
..i
HEADLAMP-RH
A367
:1. • A368 8368
U0 2 0 00011-1 C0011-3 615 A369 B 15 A370 6.1 5 516 BA0 M550. I
Sta=gg

UB 2 0 C0011-2

LAMP-SIDE-FRONT-RH
R8075 00537- C0537-2 8.05
11-

LAMP-SIDE-FRONT-LH A372
A373 8373
A 185,0.75 C0538-1 ; , 00538-2 5,0.5 A374 8,1 5 A376 8,1,5

HEADLAMP-LH
'
H U5.2.0 C0009-1 :00009-3 B,1.5

,
:,
UK 2 0 C0009.2 J,

B.1 5

Fig 51 Head, side and number plate lamps II

Chap 13-1
Aug 00 (Amdt 1)
Page 59
 ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
R,25 0 C0192-1 .1 00045-1 8.400 EARTH
A364
ECU-DELAY-WINDSCREEN WIPER 0365
00303-4 13 0 A366 (3.10 SJ6 6,40 00509.1

STARTER MOTOR
C0823-1
PUMP-WASHER-
!]— WINDSCREEN
R,10.0 C0824-1 6373
, A376 6,1.0
C0303-6 L68.0.5 C0008-2 00008-1 8,0,5

68,0 5
FUSE BOX-ENGINE COMPARTMENT
G,1.0 00303-8 C0303-5 NLG,1.0
LINK 2
C0632-1 , C05/0-2 N6 0 8243 N 6 0
60,303-2 YLG1 0

00303-1 V1G1 0

N 4.5 SJ3
SWITCH-WASH/WIPE-
WINDSCREEN
SWITCH-IGNITION
CO2/8-3

C0028-1 • 00094-1 W.20 8441 W20

00278-4

FUSE BOX-PASSENGER
CO278-2
COMPARTMENT
411
FUSE 3 A331 0027£1,1
C0580-5 0(680-6 G2 0 A333 G.10 CO278-6
00278-5

MOTOR-WI PER-
WINDSCREEN
000305 RLG.1.0

C0030-3 ULG,1.0

C0030-2
6,20 C0030-4 •
SWITCWPARK 000301 8.2.0
WNDSCRE EN

Fig 52 Wipers and washers — front

Chap 13-1
Aug 00 (Amdt 1)
Page 60
ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
R,250 00192-1 00045-1 0.40 0 EARTH

STARTER MOTOR
00823-1 —

5.100 C0824-1

FUSE BOX-ENGINE COMPARTMENT

LINK_
C0632 1 C0570-2 8,60 A243 N60 SJ3 N45

SWITCH-IGNITION

coo.,8-1 c0w9-1 WO 1 0

FUSE BOX-PASSENGER COMPARTMENT MOTOR-BLOWER-FRONT SIMTCH-BLOMR MOTOR

00056-1 GS.1 0 00058-1 .•
C0580-9 , FUSE 5 , 00580-10 PG 1 0 00058-3 010 S16 B40 C0556-1
00058-3 i coot,6-2 GO.1 0 ......,_.;
,itL--0><:0--.4. ;_,

Fig 53 Heater

Chap 13-1
Aug 00 (Amdt 1)
Page 61
 ARMY EQUIPMENT
2320-D-128-302
SUPPORT PUBLICATION

BATTERY
R.25 0 C0192-1 C0045-1 B 40 0 EARTH

STARTER MOTOR
00623-1

R,10.0 C0824-1 4
._

FUSE BOX-ENGNE COMPARTMENT

LINK 2 N60 A243 N.6 0

C0632-1 , 00570-2

—Tscr\4)-
N20 SJ3

FUSE BOX-PASSENGER COMPARTMENT

SWITCH-MAP LAMP LAM P-MAP

C0580-d5 FUSE iS L C.21,80-: PO 5 C1b15-3

,-<..)-- .
---(1 4 -1‘-` ' C1515 2 pwas 011111 C1111-2 B05 A228 8.20 SJ6 0 40 035.56 1
, . . --H

Fig 54 Interior lamps

Chap 13-1
Page 62 Aug 00 (Amdt 1)