ROOF General Note

GENERAL NOTES
CARBOLINEUM WOOD PRESERVER Factory painted 0.6mm Chromadek IBR profile roof sheeting @ 9 Degrees on 50x76mm S.A. pine purlins fixed to rafters
All exposed structural timber is to receive two @ 750 mm c/c spacings, on prefabricated timber trusses @ max. of 1200mm c/c spacing on 38x114 S.A. pine timber A. Consultant / Structural Notes
5 4 2 1 D C B A coats carbolineum. Timber must be dry and wall-plates in long lengths, half lapped & spiked at joints with gang-nail plates, bedded on cement mortar & levelled before THIS DRAWING IS TO BE READ IN CONJUNCTION WITH ALL
carbolineum applied to the entire overhanging tying down to walls with 1,6 mm thick galvanised hoop iron, 32mm wide into min. Aluminium Foil light duty fire retarded 1. All Structural, Electrical, Civil And Landscaping RELEVANT ARCHITECT'S AND ENGINEER'S DRAWING.
roof member sections before the application of insulation membrane , underlay over trusses and under purlins carrying the SANS 1381-4 Class accreditation. of 5
Queries Are To Be Referred To The Relevant
Windows:
Window type E2, 1022 x 645mm double
ROOF
Factory painted 0.6mm Chromadek IBR profile
roof sheets. courses into brickwork & tied around tie-beam, rafter or additional purlin as convenient, and fixed with four galvanised
Consultants Drawings, Specifications And Details ALL DIMENSIONS, LEVELS, ETC ARE TO BE CHECKED BEFORE
nails, 40 mm long. NOTE: Roof construction to be done by specialist as per truss designer's specification & approval. On-
top hung GMS window with 0,6 Arctic
Snow frosted Safety Glass . BOE Header
roof sheeting @ 9 Degrees on 50x76mm S.A.
pine purlins fixed to rafters @ 750 mm c/c
Fascia & Barge :
12 x 225mm Fascia and barge boards,
GUTTER / DOWNPIPE
150 x 100 x 0,5mm thick pre-coated zincalume site the roof trusses must be placed on evenly laid pallets, covered & protected against weather. Hurricane Clips fixed ANY WORK IS COMMENCED AND ANY DICREPANCIES NOTED TO
Coarse & BOE Slightly projected FB cills
@30o
spacings to fabricator / specialists detail including galvanised steel H-profile joiners seamless gutter, including matching rivet-fixed mitres
with per-mix nails or bolts through pre-drilled holes at covered verandah/ tank stand area must be provided for. 2. All Plumbing Queries Are To Be Referred To The BE BROUGHT TO THE ARCHITECT'S ATTENTION.
Relevant Specialist Consultants Drawings, Specifications
Fascia & Barge : ROOF
height of vp Facebrick :
Corobrik FBX main brick facing brick (To
12 x 225mm Fascia and barge boards, 430
420
410
height of vp
229 x 152mm Clay Terracotta
Factory painted 0.6mm Chromadek IBR profile roof 430
420
410
Fascia & Barge : And Details ONLY FIGURED DIMENSIONS TO BE USED, SCALING OF
roof apex Match Existing School) pointing with 10 x
including galvanised steel H-profile joiners 400
390
380
370
roof apex vermin proof air brick.
sheeting @ 9 Degrees on 50x76mm S.A. pine purlins
fixed to rafters @ 750 mm c/c spacings to fabricator /
400
390
380
370
A B C 12 x 225mm Fascia and barge boards, DRAWINGS IS NOT ADVISABLE.
6mm recessed Joints : in English bond 360
350 specialists detail 360
350 including galvanised steel H-profile joiners, 3. All Concrete, Columns And Structural Queries Are To
complying with SANS 2001 - CM1 - 340 340
Plaster the interior walls of the pit ENVIRO-LOO UNITS : medium density plain fibre-cement fascial Be Referred To Pr. Structural Engineer's Drawings, ALL RIGHTS RESERVED. NO PART OF THIS DESIGN SHALL BE
330 330
Construction works , masonry walling 229 x 152mm Clay Terracotta 320 Facebrick : 320

vermin proof air brick.

310
200 Corobrik FBX main brick facing brick (To
310
200 completely to ensure a water tight seal, Collect from store, transport and delivered to site, and barge boards to receive paint
u/s wall plate
290
u/s wall plate av
290
Specifications And Details
REPRODUCED, USED ELSEWHERE AND/ OR IN ANY WAY
280 280
av av av av Match Existing School) pointing with 10 x
SABS Approved 5500 Litre
270
260
250 6mm recessed Joints : in English bond facebrick SABS Approved 5500 Litre
270
260
250
paint epoxy coat over the plastered area protect on site and install complete standard
240 240
Polyethylene Horizontal using a black epoxy coat.
u/s wall lintel Polyethylene Low Profile
water storage tank to Rainwater Tank
GUTTER / DOWNPIPE
150 x 100 x 0,5mm thick pre-coated
230
220
210
200
u/s wall lintel complying with SANS 2001 - CM1 -
Construction works , masonry walling Rainwater Tank water storage tank to
230
220
210
200
enviro-loo system type 1040 industrial CER/ABS-
4. All External / Internal Walls Requiring Bracing / WITHOUT PRIOR PERMISSION FROM THE ARCHITECT/
190
Architects Detail 190
V1 (code FG-1040) Windows:
Architects Detail 5000 Litre Low Profile zincalume seamless gutter, including
matching rivet-fixed mitres
180
170
160
150
SABS Approved Hardwood Door on
5000 Litre Low Profile 180
170
160
150
Window type E2, 1022 x 645mm double top hung
Stiffening Are To Be Constructed In Accordance With ENGINEER.
W1 W1 W1 W1 W1 W1 W1 W1 W1 140
130 GMS Frame as per door schedule. SABS Approved PC 140
130
Pr. Structural Engineer's Drawings,Specifications And Details.
height of vp
120 120
110 BOE Facebrick cill Wash Double Trough 110 GMS window with 0,6 Arctic Snow frosted Safety 430
1. ALL CONSTRUCTION WORK AND TEMPORARY WORKS
100 100
SABS FBX 900mm High 90 90
420
facebrick Stormwater Control :
80
SABS FBX 900mm High Stormwater Control :
80
Glass puttied to Standard residential frame with
1 000

Face-brick Plinth to 70 70 410

60 60
400 5. All Specifications With Regard To Fire Regulations, To
ffl 568:30 New cast in-situ re enforced concrete ffl 568:30 Face-brick Plinth to New cast in-situ re enforced concrete
UNDERTAKEN ON SITE WILL COMPLY WITH SANS 10400 NBR -
50 50
Architects detail
stormwater v-drains to Engineers detail
40
30
Architects detail stormwater v-drains to Engineers detail
40
30
roof apex GUTTER / DOWNPIPE steel burglar bars to fixed lights and opening 390
380
ngl 568:00 20
10 ngl 568:00 20
10
sashes. BOE Header Coarse & BOE Slightly 370 Be Referred To Consultants Drawings, Specifications
00 00
150 x 100 x 0,5mm thick pre-coated zincalume 9 Deg
360
NATIONAL BUILDING REGULATIONS, LATEST EDITION.
seamless gutter, including matching rivet-fixed mitres projected FB cills @30o. 15mm x 140mm Fibre 350
340 And Details.
330
and end caps internally sealed using Silicon Mastic, Cement slightly projecting internal cill 320
310

1 020
hung by nail fixed internal aluminium hangers at 500mm
200
290 6. All Design And Construction To Comply With The 2. ALL WORKS UNDERTAKEN WITH REGARDS TO DISABLED
u/s wall plate av
North Elevation West Elevation centres with 100 x 75 x 0,8mm thick rectangular fluted NEW 8 GIRLS GRADE R Dpc
280
270
260
Relevant Sans Regulations.
FACILITIES (EXISTING, REFURBISHMENTS AND/ OR NEW) WILL
Scale 1:100 Scale 1:100 downpipes to 5000L horizontal RWHT Dpc Facebrick : 250
240
WATERBORNE
u/s wall lintel ABLUTIONS
Corobrik FBX main brick facing brick (To 230
220 7. Any Discrepancy In The Drawings, Dimensions & COMPLY WITH SANS 10400 PART S PRESCRIPTS, FACILITIES FOR

654
210
Match Existing School) pointing with 10 x

3 570
200
Pavers : Dpc
SL Epoxy Resin
A : 27m2 6mm recessed Joints : in English bond
190
180
Specifications To Be Brought To The Attention Of The PERSONS WITH DISABILITIES, 2011, 3RD EDITION
1 2 3 4 A B C D FFL : 568.300
complying with SANS 2001 - CM1 -
170
160 Consultant And Architect Prior To Any
REGARDS
60mm "SABS Approved" Concrete Brick 150
Work Being Put In Hand.

2 635
03 140
pavers laid in herringbone pattern to fall JNR Construction works , masonry walling 130
120

1 445
110
1:40 on 25mm thick river sand bed with

1 200
ROOF 100
Factory painted 0.6mm Chromadek IBR profile
Windows:
Window type E2, 1022 x 645mm double top sand and cement mixture swept into joints
90
80
8. Only Figured Dimensions To Be Followed - Scaled
roof sheeting @ 9 Degrees on 50x76mm S.A. hung GMS window with 0,6 Arctic Snow frosted Stormwater Control : 70
Dimensions Of Drawings Will Not Be Permitted
ROOF and hosed down. Brick on Edge , edging 60

820
Fascia & Barge :
pine purlins fixed to rafters @ 750 mm c/c
spacings to fabricator / specialists detail
Safety Glass . BOE Header Coarse & BOE
Slightly projected FB cills @30o
Factory painted 0.6mm Chromadek IBR profile 12 x 225mm Fascia and barge boards, ffl 568:30 Dpm Dpc New cast in-situ re enforced concrete 50
40
30
roof sheeting @ 9 Degrees on 50x76mm S.A.
pine purlins fixed to rafters @ 750 mm c/c
including galvanised steel H-profile joiners
ngl 568:00 stormwater v-drains to Engineers detail 20
10 9. All Drawings Are Intellectual Property Of Simelokuhle
Dpm Dpm
REVISION INFORMATION

200
spacings to fabricator / specialists detail 00
height of vp
Windows: Design Studio. Any Replication And Unauthorised Reuse
height of vp Fascia & Barge : Facebrick : Window type E2, 1022 x 645mm double top 430
Soak-Away + Will Lead To Legal Litigations
430 420
420 hung GMS window with 0,6 Arctic Snow frosted
12 x 225mm Fascia and barge boards, Corobrik FBX main brick facing brick (To 410 410
400 Depth of foundation stipulated by engineer
roof apex including galvanised steel H-profile joiners Match Existing School) pointing with 10 x
400
390 roof apex Safety Glass . BOE Header Coarse & BOE 390
380 Evaporation Area
6mm recessed Joints : in English bond
380
370
360
GUTTER / DOWNPIPE Slightly projected FB cills @30o 370
360 suite site conditions . is the subject of a rational
150 x 100 x 0,5mm thick pre-coated
B. Contractor Notes
350 350
design or a rational assessment REV. NO DATE DESCRIPTION
340 340
complying with SANS 2001 - CM1 -
Construction works , masonry walling
330
320
310
zincalume seamless gutter, including Facebrick : 330
320
310
Surface Bed : Placement of Junior Pan, Sanitary
229 x 152mm Clay Terracotta facebrick matching rivet-fixed mitres Corobrik FBX main brick facing brick (To 200

u/s wall plate vermin proof air brick.

av av
200
290
280 u/s wall plate av Match Existing School) pointing with 10 x
290
280 All floor finishes as indicated on plan and as per finishing schedule on 100mm Fittings & furniture to be dropped
SABS Approved 5500 Litre
270
260 SABS Approved 5500 Litre 6mm recessed Joints : in English bond
270
260
250 thick class U3 steel trowel finished concrete slab ( 20 Mpa ) reinforced with 1. Contractor Shall Reconfirm All Salient Levels With
250
240 Polyethylene Horizontal
240 for ease of access & to 230 Mampara Brick Wall for works below NGL
u/s wall lintel SABS Approved Hardwood Door on Polyethylene Low Profile 230
220 u/s wall lintel complying with SANS 2001 - CM1 - 230
220
mesh Ref 193 set 25mm below top on 250 microns GUNPLAS USB GREEN Municipality Prior To Commencement Of Work.
GMS Frame as per door schedule. Rainwater Tank water storage tank to 210
200
water storage tank to Construction works , masonry walling 210
200 accommodate for Toddlers
BOE Facebrick cill 5000 Litre Low Profile Architects Detail
190
180
170
Architects Detail 190
180
170 waterproofing on 25mm river sand bed on fill compacted to MOD AASHTO
SABS Approved Hardwood Door on 160

SABS Approved PC SABS Approved PC

160
150
140 SABS Approved PC
facebrick GMS Frame as per door schedule.
150
140 95%. oil to be poisoned in accordance with SABS 1165. ( Certificate must be 2. The Contractor Shall Be Responsible For The Coordination
W2 facebrick W2 facebrick W2 130 130

Wash Double Trough Wash Double Trough

120
110
100
Wash Double Trough BOE Facebrick cill 120
110
100
90
provided ) All expansion and movement joints as per ENGINEER'S DETAIL Of All Services.
90
Stormwater Control : SABS FBX 900mm High
80
Stormwater Control :
80
70 AND SPECIFICATION. Engineers details and specifications to take

935
70
60 SABS Approved PC 60
ffl 568:30 New cast in-situ re enforced concrete 50
ffl 568:30 New cast in-situ re enforced concrete wh wh Face-brick Plinth to 50
40
30 stormwater v-drains to Engineers detail
Wash Double Trough 40
30 precedence if applicable. 3. The Contractor Shall Comply With All Local
stormwater v-drains to Engineers detail Architects detail 20
ngl 568:00 20
ngl 568:00 10 10
00 00
Authority Requirements.

Section N3 - N3 4. The Contractor Shall Submit Shop Drawings For

East Elevation Scale 1:75
Mechanical, Electrical And Plumbing Services And
Specialised Items And Incorporate The Ducts To
Scale 1:100
South Elevation Conceal Necessary Pipes, Cables And Conduits, Etc.
For The Consultants Approval Prior To
Scale 1:100
Commencement Of Work.

Window and Door Schedulescale

- 1:50 SANITARY SCHEDULE / BLOCK FINISHES SCHEDULE / BLOCK 5. The Contractor Shall Inspect The Site Prior To Any THE MVULA TRUST APPROVAL
Work Being Put In Hand And Take Into Consideration
ITEM DESCRIPTION QUANTITY ITEM DESCRIPTION QTY All Aspects Of The Works, To Be Carried Out Including
WINDOW 1 W1 WINDOW 2 W2 WINDOW 3 W3 "Kimberly Clark" Height: 385 mm Depth: 140 mm 40mm Untinted Grano screed. Granolithic mix for surface beds, composed of 1 part Surebuild cement
Any Dewatering, If Required. The Costs Of The
Dewatering To Be Submitted Prior To Work Being
Name:..........................................................................
N3

Toilet Roll Holder Width: 135 mm metalic lockable Toilet 3 Roll Holder Primary Floor Finish (Code: CEM I 42,5N) 2 parts sand and 1 part 5mm granite aggregate finished with a steel trowel in Commenced On Site.
1 2 3 4 from Classic White Range. Durable and vandal proof 09 thickness as indicated to surface beds . OPC is to be manufactured in accordance with SANS
533 1022 1511 with Anti-theft bracket available 50197-1.steel trowel grano finish with a 100 mm high monolithic upwards sloping concave skirting 6. Any Discrepancy In The Drawings, Dimensions And Signature:......................................Date:......................

WINDOWS
"Kimberly Clark" Height: 310 mmDepth: 105 mm Skirting 150 mm high monolithic upwards sloping concave skirting, moulded with special tool Specification To Be Brought To The Attention Of The
Soap Despenser Width: 160 mm Liquid Soap Dispenser Classic 03 Consultant And Architect Prior To Work
White Range Flowtex HT Self levelling epoxy resin mortar screeding compound , with Matt seal coat finish. Colour: LIMPOPO DEPT EDUCATION APPROVAL

654

654

654
Being Put In Hand.
Light Stone All surfaces to be clean, sound, laitance and dust free with a maximum moisture content
Paper Towel Dispens "Kimberly Clark" Height: 334mm Depth: 184mm Final Floor Dressing of 5%. Prime surface with one coat Flowprime Solvent Free Epoxy Primer and Basem coat with a 7. All Equipment Shall Be To The Approval Of The Local
2 215 2 589 5 514 2 606 Width: 286mm Lockable Paper Towel Cabinet 03 maximum over coating time of 24 hours. Apply one coat Light Stone Flowtex HT to a minimum 7mm
10 544 2 494 V-DRAINS :
Compact Manual Classic White Range Authorities And Comply With The Occupational Health
13 038
800 x150 in-situ conc. surface v
drain stormwater channel, slopes
thickness with a maximum over coating time of 48 hours.
Facebrick : And Safety Act. Name:..........................................................................
110 110 110 110 110 110 110 inwards 11% & towards discharge Code : E1 Quantity : 09 E7 Quantity : 03 E4 Quantity : 00 Waste Bin "Kimberly Clark" Height: 522mm Depth: 160mm Internal Wall Fcebrick Corobrik FBX main brick facing brick (To Match Existing School) pointing with 10 x 6mm recessed
220 2 000 110 910 910 910 910 910 910 910 910 220 2 494 direction To engineers detail design Width: 365mm Wall mounted Bin . Stainless Steel 03 Joints : in English bond complying with SANS 2001 - CM1 - Construction works , masonry walling 8. All Dimensions And Levels Are To Be Verified On Site
Description: 533 x 654mm hot-dipped galvanized steel 1022 x 654mm hot-dipped galvanized steel 1511 x 654mm hot-dipped galvanized steel
residential top hung unit. Unit code NE1 with residential top hung unit. Unit code NE2 with residential top hung unit. Unit code NE4 with
Range
Prior To Commencing, Setting Out, Workshop Signature:......................................Date:......................
W1 W1 W1 W1 W1 W1 W1 W1 W1 Rwdp 20 x 5mm hot-dipped galvanized flat bar to 20 x 5mm hot-dipped galvanized flat bar to 20 x 5mm hot-dipped galvanized flat bar to
"Kimberly Clark" Capacity: 20 litres Height: 600 mm Internal Brick Dressing Clean down with spirits of salts solution and apply Drawings Or Construction
Rwdp open sections . Preinstalled Flat Burglar bars open sections . Preinstalled Flat Burglar bars open sections . Preinstalled Flat Burglar bars She Bin
Code KB26 SS Dog Leg SABS Approved 5500 Litre Depth: 125mm Width: 420 mm She Bin Stainless 01 two coats silicone-based brick dressing on:
B Rail & Code KB18 Straight
Grab Rail
Polyethylene Low Profile
water storage tank to B Finish: Clean with galvanized iron cleaner. 1 x Clean with galvanized iron cleaner. 1 x Clean with galvanized iron cleaner. 1 x Steel Range C. General Notes
PRINCIPAL AGENT APPROVAL
220

220

galvanized iron primer coat and 2 x coats of galvanized iron primer coat and 2 x coats of galvanized iron primer coat and 2 x coats of
966

966

Architects Detail
approved gloss enamel paint. approved gloss enamel paint. approved gloss enamel paint. Grab Rails Code KB26, 300 x 300 x 300 x 50mm Stainless steel Ceiling NO CEILING : CARBOLINEUM WOOD PRESERVER .All exposed external structural timber is to
1. All Structural Components To Structural Engineer's
1 800

1 800
2 120

2 120

C 01
JNR JNR
02 03
JNR
04
JNR
05
JNR
06
JNR
07
JNR
08
JNR
SABS FBX 900mm High C dog leg side grab rail fixed in position. 01 receive two coats carbolineum. Timber must be dry and carbolineum applied to the entire
Detail And Architect's Approval.
Code KB18, 800 long x 50mm Projecting stainless overhanging roof member sections before the application of roof sheets.
220

Face-brick Plinth to
Ramp to Paraplegic door
STAFF DISA Architects detail Glazing: 6mm SG Opaque Glass with Steel Window Putty 6mm SG Opaque Glass with Steel Window Putty 6mm SG Opaque Glass with Steel Window Putty
steel straight grab rail fixed in position Name:..........................................................................
3 875

3 435

3 435

3 875

SL Epoxy Resin D4 D4 D4 D4 D4 D4 D4 D4 Ironmongery Wall Tiles 150X150 Essence White Gloss (WGI-4-1) Glossy white Wall Tile, fixed to plaster (elsewhere
threshold
A : 7m2
NEW 8 GIRLS GRADE R
Factory Fitted - Standard Brass Fittings Factory Fitted - Standard Brass Fittings Factory Fitted - Standard Brass Fittings 2. All Sewer And Waste Water Points To Connect To
2 682

2 682

FFL : 568.300 1.2m High Privacy Mirrors Stainless steel or equal approved mirror size 350 x measured) with and approved tile adhesive to and pointed with white cement to splash-backs laid in Existing Sewer Lines.
SABS Approved PC WATERBORNE ABLUTIONS screen walls SABS Approved PC
Wash Double Trough 400m plugged to wall with chrome platted screws
04 2 Lines above whb
Fall 1:40

Fall 1:40

Fall 1:40

VERANDA
Signature:......................................Date:......................
SL Epoxy Resin
1 755

1 755

Wash Double Trough

A : 27m2
D3 D1 FFL : 568.300 D1 G1 Grano
A : 4m2
Brick on Edge 7 884 FFL : 568.200
D Lintel Above
G1 D 4. All Timber Used To Be Treated Against Termite And
220

220

W2 W2 W2
Wood Borer Attack, And Against Fugal Decay As DISCIPLINE :
440mm x 440mm
Facebrick Pier
Line of Roof Overhead : PAVERS :
DOOR 1 D1 DOOR 4 D4 DOOR 3 D3 GATE 01 G1 PLUMBING SCHEDULE / BLOCK Per Sans 10005.
ARCHITECTURE
600mm Overhang 60mm Precast Concrete Grey G-
Walkway to Slightly Ramp Max Interlocking Blocks laid in
Gradient 1:12 in compliance with Herringbone pattern
ITEM DESCRIPTION QUANTITY

GRD8
220 1 800 220 877
SANS 10400 Part S
Paving to Ramp 32 813 32
towards Paraplegic +2 125 mm AFFL +2 125 mm AFFL 964 +2 125 mm AFFL 900 LAVATERA WALL HUNG BOWL URINAL PRODUCT CODE 705426/705427
900
220
Ablution Door
2 000 220 7 884 220 2 494
Wall Hung Urinal DESCRIPTION .Vaal Sanitaryware vitreous china wall hung "Lavatera" urinal with top inlet BUILDING CLASSIFICATION
(code 705426) or back inlet (code 705427). Overall size 600 x 385 x 380 mm. Top inlet 00
709 1 022 709 852 7 253 2 492 Signage fittings (code 7054Z1) and back inlet fittings (code 7054Z2) include a 38 mm c.p. domical
884 grating, a spreader (with a 20 mm diameter thread), and two brackets. No Traps Req C3 : PLACE OF INSTRUCTION (SCHOOL)
DOOR SCHEDULE

2 215 8 104 2 606

800
10 544 2 492
Paraplegic Toilet Seat Vaal Code 750200 Protea Paraplegic' or other approved white vitreous china paraplegic type
low level W.C. suite comprising back outlet 'P' trap washdown pedestal pan,heavy duty white NOTES AND SPECIFICATIONS:

2 125

2 125
N3

Handle Satin Stainless steel

1 2 3 4 push plate plastic hinged seat with flap and chromium plated brass bolts, 9 litre white vitreous china
01 GENERAL CLIENT :

1 100
1 200
flushing valve type side inlet cistern complete with chromium plated brass extended lever 1. Use dimensions provided and do not sclae drawing.
8 Grade R Girls + Disabled handle, regulation ball valve ditto
2. All work to comply with SANS, PW371 and SABS. Physical :
Waterborne Ablutions Satin Stainless steel Junior Toilet Seat Vaal Sanitaryware JUNIOR 104° LOW LEVEL SUITE PRODUCT CODE 751358 Pan 3. All dimensions, levels and positions to be Cnr 113 Biccard & 24 Excelsior
TYPICAL FFL TYPICAL FFL TYPICAL FFL TYPICAL FFL
08 Street

100
& Cistern Pan Size 270 Wide , 280 Length & 305 Height. Vaal Sanitaryware vitreous verified on site prior to construction.
8 Junior Seats +1 Std Seat kick plate
china “Junior” 104° outlet washdown pan (code 751300) and matching 6 litre cistern 4. All concrete work to be as per Engineer's details Polokwane, 0700

300
150 Undercut
Floor Layout Plan (code 712034) complete with lid and fitments , and junior seat. Fit pan onto floor using
a 4:1 cement mortar mix. A richer mixture could result in pedestal failure 5. All pits to face North. Tel : 015 290 9301 / 7600
Scale 1:100 Elevation Elevation Elevation Elevation 5. All brickwork have brickforce at every 2nd course in pit lining
Area :41m2 1:100 1:100 1:100 1:100 Jojo Plastic Water Tank 20mm Heavy Duty PVC Tommy Tap & Reducer kit , Postal : Private Bag X9489,
Jojo Tank Tap and 3rd course in superstructure.
FPL :568.00
Item 1 Door Location EXTERNAL ABLUTION DOORS QUANTITY X 2 ALL INTERNAL TOILET CUBICLES DOOR QUANTITY X 8 PARAPLEGIC TOILET DOOR QUANTITY X 1 ENTRANCE GATE QUANTITY X 2 including extension pipe where required. 02 Polokwane, 0700
Paraplegic Tap Cobra (Taps & Mixers) COB-505-21B - Medical Elbow Action - Taps - Pillar Taps - PIT EXCAVATION
Painted mild steel gate consisting of 10x10mm mild steel bars placed at
Door 813mm x 2032mm x 44mm thick heavy duty Saligna Blaco 813mm x 1200mm x 44mm thick heavy duty EXTERIOR QUALITY 912mm x 2032mm x 44mm thick heavy duty Saligna Blaco
100mm centres at a 45° angle, colour to architect's specification. to
ChromeNotes: Elbow action. Square type. ¼ turn ceramic disc. Blue indice. ½"BSP MI SANS 01 1. All stages of pit excavation to be inspected and
Item 2 Framed and Braced Single side swing complete with Z- Bracing hardwood timber door fitted to comply with SABS 545 in pressed steel Framed and Braced Single side swing complete with Z- Bracing 226 TYPE 2 Includes , Pillar tap , Flanged backnut , Ideal for medical, kitchen and installations.
Description hardwood timber door fitted to comply with SABS 545 in pressed steel frame. All painted in accordance with Architect's colour schedule. hardwood timber door fitted to comply with SABS 545 in pressed steel comply with SABS 681, grade 1, and finish with two (2) coats alkyde egg- approved by Engineer and signed off.
frame. All painted in accordance with Architect's colour schedule. Door complete with 100mm Undercut frame. All painted in accordance with Architect's colour schedule. shell paint to comply with SABS 630. COBRA Wall Mounted 85mm projecting Commercial DEMAND BIB TAP - CHROME
Standard Taps 2. All pit lining to be inspected by EnviroLoo Services before
Standard 1.6mm in pressed Galvanised mild steel door frame with prof ile Standard 42mm x 120mm x 1200mm High Hardwood Timber Door Standard 1.6mm mild steel double rebate pressed metal frame Vendor: Cobra | SKU: FBBAN1DT-0GT01 complete with 1 Std male inlet. Diameter 30mm 04 slab casting. PRINCIPAL AGENT : SIST CONSORTIUM
matching wall, to comply with SABS , complete with lugs and fixtures, to Jambs finished with 2 coats gloss enamel paint complying to SABS 1129 complete with lugs and . fixtures 50 X 50mm m.s mm square tube welded to form frame. Spout to Deck Height: 24mm. Including all Plumbing, valves and fittings.
Item 3 Frame accommodate 813 x 2032 door leaf. Single Rebate frame to accommodate Frame profiles to suit wall thickness (115mm, 230mm and 345mm Frame profiles to suit wall thickness (115mm, 230mm and 345mm PHYSICAL :
) Troughs & Drainage 1065 mm x 650 mm x 900 mm outdoor commercial Lion Concrete Wash Trough Double
110mm internal wall as per floor plans as per floor plans BRICKWORK Farm Pal 681 Portion 45
(1065mm) SABS Approved . Inclusive of all waste fittings & finishes. 03 Sub-structure Polokwane, 0699
Washable enamel paint f inish complying with SABS 723 for primer, Washable enamel paint f inish complying with SABS 723 for primer, Washable enamel paint f inish complying with SABS 723 for primer,
Item 4 Frame
X 1coat Zinc Chromate primer
SABS681 for undercoat and SABS 630 type 2 for finish coat. SABS681 for undercoat and SABS 630 type 2 for finish coat. SABS681 for undercoat and SABS 630 type 2 for finish coat.
x2coats gloss enamel (exterior quality) 1. All pit lining / foundation brickwork to be solid NFP clay brick. TEL :
Finish Wash Hand Basin Granite colour: Christy lavatory basin size 570 x 400 x 245mm with one tap hole, with moulded-
Colour to architect's approval Colour to architect's approval Colour to architect's approval
in soap holder, with splashback. Sample to be approved by Architect
01 2. All internal surface of pit lining to be painted with two coats 031 065 1099
Painted mild steel gate consisting of 10x10mm mild steel bars placed at black expoxy paint installing Enviro-Loo units.
Prime with wood primer to comply with SABS , type 2. Paint one (1) Prime with wood primer to comply with SABS , type 2. Paint one (1) Prime with wood primer to comply with SABS , type 2. Paint one (1) EMAIL :
100mm centres at a 45° angle, to comply with SABS 681, grade 1, and
Item 5 Door Finish Universal under coat to comply with SABS 681, grade 1, and finish with Universal under coat to comply with SABS 681, grade 1, and finish + Universal under coat to comply with SABS 681, grade 1, and finish with two
finish with two (2) coats alkyde egg-shell paint to comply with SABS 630. Super-structure Talu@sistengineers.co.za
two (2) coats alkyde egg-shell paint to comply with SABS 630, type 1. two (2) coats alkyde egg-shell paint to comply with SABS 630, type 1. (2) coats alkyde egg-shell paint to comply with SABS 630, type 1.
Colour to architect's specification
Colour to architect's approval Doors to receive 1 prime colour each.Order: Red, Blue, Yellow , Green Colour to architect's approval 1. All external walls / partitions to be of clay face brick to
SABS quality.
NAME OF COMPETENT PERSON: CONT NO:
Item 6 Fan Light NONE NONE NONE NONE 2. All cubicle partition walls to be 3 courses above door height.
3. All brickwork above door openings should have brickforce FIRM REG NO:
75mm Four lever security lockset with satin chromef urniture. Assa Abloy Union Satin Chrome Indicator Bolt SC Plated IMP , ASSA ABLOY DC300DA R&P CLOSER EN 3-6 DA SIL
on evry course at least 3 cources
Prime with wood primer to comply with SABS , type 2. Paint one (1)
Door stop - polished brass floor mounted. 75mm Four lever security lockset with satin chrome f urniture.
Item 7 Ironmongery AL5022-E11AS 150 x 150mm natural anodised Door stop - polished brass Wall mounted.
UNION L-2115-78SS/R E/Profile Cylinder Dead Lock with Roller Latch Universal under coat to comply with SABS 681, grade 1, and finish with
two (2) coats alkyde egg-shell paint to comply with SABS 630, type 1.
4. Air bricks: Standard 230X152mm terra-colts vermin proofed IMPLEMENTING AGENT :
UNION 37651AS Paraplegic Facility Indicator Bolt AS
aluminium indicator plate with engraved f emale symbol Colour to architect's approval lourved air grating to be used above all window openings.
UNION 2X20SCMKD Single Cylinder Prof ile MKD SC
PHD-CF-300-22SS SS BT Handle with Flange
ROOF SHEETING 718 James Crescent, Halfway
Fixing - 300mm Centres 22mm Diameter House, Midrand, 1685, South Africa
1. 0.6mm kliplock chromadek roof sheeting
Item 8 Hinges 3 no. stainless steel medium duty butt hinges. 3 no. stainless steel medium duty butt hinges. 3 SP-DFM-HINGE HEAVY DUTY HINGES BY OTHER
. MANUFACTURERS 3 SP-DFM-HINGE HEAVY DUTY HINGES BY OTHER MANUFACTURERS
Send Us Mail
ROOF TIMBER / CEILING info@themvulatrust.org.za
1. All roof timbers to be machined SABS treated wood with
three coats of approved wood preservative.
Call Us +27 11 403 3425
1800 2. Timber connections (Hurricane Clips) are required all
Enviro-Loo CER/ABS-V1 code FG-1040
DISABLED PERSON' ABLUTION
intercessions between timber rafters and purlins.
590 350 860 3. Sisalation is to be applied interval under all roof surfaces.
INSPECTION & APPROVAL BY ENVIRO- PROJECT NAME

Grab-rails & Roll

FACILITY LOO SPECIALIST / SUPPLIER :
Allow two site visits to be made by the enviro-
METALWORK
1. All metalwork should be primed before installation.
PROPOSED PERMANENT SANITATION
450

loo suppliers to assist/support the contractor 2. All steel window should have 6x20mm flat bar burglar
Holder Window Cill Height Window Cill Height in the installation of the enviro-loo and final
inspection to ascertain the enviro-loo has
proofing.
FACILITIES FOR TISWINGA PRIMARY
Wash Hand back grab-rails) 450
been installed correctly at which time a
certificate of compliance should between the
PLUMBING SCHOOL EMIS 930 350 514
Basin 1. Double concrete wash trough to be used.
end-user department and enviro loo supplier
716

716

Pit Water Side Grab-rail 2. All wash troughs should be connected to the school's
570 water supply system and the waste water should be
Closet Side Wash Hand ENVIRO-LOO UNITS : DRAWING DESCRIPTION
528

528

Collect from store, transport and delivered piped to a soakaway.

1800

380 Grab-rail Basin Wash Hand

BLOCK B
GRD8
A Basin
to site, protect on site and install complete 3. The soakaway should be as per Engineer's detail and
standard enviro-loo system type 1040
1536

1536

position to be determined on site.

D B industrial CER/ABS-V1 (code FG-1040)
4. Only 20mm and galvanised pipework should be used as
GRADE R GIRLS + STAFF P
1200

Grab-rail

590 Roll Holder Back

WATERBORNE ABLUTIONS
297

connection from wall to the discharge points.

Back

350 Grab-rail Enviro-Loo CER/ABS-V1 (code FG-1040)

C Furniture :
820

820
740

- Purpose Made Steel Brackets Fixed to Wall GLAZING

PROJECT STATUS
Pit Water

Pit Water
Closet

- 220 Diameter Extractor vent by enviro-loo 1. 6.28mm obscure safety glass on top nine panes.
443

443

Closet - Moulded polyurethane tank cover with a STAGE 1-3 STAGE 4 STAGE 5-6
manhole access
- Wind-master Extractor Cowl PAINTING
1. All paintwork to comply with SABS and PW371 CONCEPT TENDER CONSTRUCTION
1200 specification.
2. All steel window and door frames including doors and DESCRIPTION: SCALE:
fascia / barge boards to be
WATER AND SANITATION PROGRAMME AS SHOWN
PAGE 2

DRAWN: CHECKED:
SANS 10400 & XA COMPL OTHER APPROVALS WATER SUPPLIER SANITATION SEWER SITE INFORMATION STAGES PROJECT TEAM
NAME OF COMPETENT PERSON: NAME OF COMPETENT PERSON:
Rational Des Standard Cal Mark with X
Environmental Impact Yes No N/A
Yes No MUNICIPALITY NAME Yes No MUNICIPALITY NAME
SIPDM SACAP Mark with X Competent Contact Person CONTACT No. REGISTRATION No. COMPANY NAME
CONDUCTANCE Y N Y N MUNICIPALITY MUNICIPALITY ERF NO. MPENDULO SHANGASE SIYABONGA MANYONI
Assessment (EIA) 0 Architect MPENDULO SHANGASE 078 319 3469 PrArchST 24751103 SIST CONSORTIUM
Rational Des Standard Cal

South African Heritage Yes

Mark with X
No N/A
Yes No WATER USE LICENCE Yes No CAPACITY
1
SOLAR HEAT GAIN Y N Y N BOREHOLE SEPTIC TANKS COVERAGE Q. Surveyor SIPHO NTSHAKALA SIST CONSORTIUM REG NO: PrArchST 24751103 REG NO: PrArch 49324416
Resource Agency (SAHRA) 2
SIGNATURE: SIGNATURE:
GEOGRAPHICAL ZONE Mark with X Yes No 3 1 Struct. Engineer TALU MUDAU SIST CONSORTIUM
Department of Water and Yes No N/A
PRESSURE VIP/ENVIRO LOO VILLAGE NAME 4 2 Civil. Engineer TALU MUDAU SIST CONSORTIUM
NBRs COMPLIANCE Sanitation (DWS) BARS
Mark with X Number TOTAL CAPACITY Yes No
5 3 Mech. Engineer PROJECT NUMBER: DATE:
Yes No South African National Roads Yes No N/A
6 4 ADD17-BATCH06/TMT/LDOE/LP/21/6 CLUSTER 01 25 AUGUST 2023
TANKS PIT LATRINES DISTRICT Elect. Engineer
SITE PLAN Agency (SANRAL)
7 OCCUPANCY CLASSIFICATION: DWG NO:
Mark with X Yes No SPECIFY BELOW Yes No
SPECIFY 5 OHS TSPS- ARCH-200-00
Yes No Yes No N/A 8
OTHER DRAWINGS
Other OTHER STORE OTHER COORDINATES
9 6 Contractor C3 REV NO: 04

GSPublisherVersion
GSPublisherVersion 0.99.100.32500
0.0.100.100