SUPtBSElkS MDDLL DaGtiC429-2U
SPECll=lCATl,QN
CUSTOMER PART NO. 26138113
6DltlON iD. DATLD 9.11.65 CUSYDMSR’S NAME & ADDRESS:
SUPERSEDES fDlTlOk k0. i tiAlTE0 8921.64 Herculee Engine &WI.
ENGINE DD-198 FULL LoAD RCM tab0 Ifepp Corprerion
APPLICATION OENEIUTC~I bov. nEQutArlON JL l+ED BYi P. 6. WiSniesbi canton2, Dhio
,,)
NOTE: ALL SPSLDS ARE IN ENGINE RPM UNLESS OTHE~ISS NOTE0 yPm.L”:^A.v$. “‘Aw.-uU
TEST STAND 2:
1. INJ’ECTION LINES %i”I.D.BY 20” LON( : 1. CHECK POINT 1200 38-61 3 34-39
2. TEST OIL TEMPERATURE. 116-llBF. 9. CHECK POINT.. 1800 59-62
3. NOZZLE OPENING PRESSURE 2500 PSI 12SO12 NOZZLES. 10. CHECK POINT..
4. USE ROOSA MiSTER CALIBRATING OIL 11. SET TORQUE SCREW
PUMP OPfNATlNG SPEED.. HAI2 ENGINE SPEED 12. CHECK POINT-PART LOAD.
ENGINE FUEL CONSUMPTION 13. HIGH IDLE (WOT) 1836 13-16
PU”;. ACCESSORIES 14. GOVERNOR CUT.OFF (I/, HI-IDLE DEL.)
Speed Ikoop 15. LOW IDLE.
2. Electric Shut-Off (12V. E.T.R.) 16. TRANSFER PUMP PRESSURE (WOT) 400 20-27
3.
17. TRANSFER PUMP PRESSURE (WOT)
4.
LB. MINIMUM CRANKING SPEED OELIVERV 150 29
PUMP SElTlNGS (t . . . ITEMS APPLY TO SERVICE ONLY)
1: ROLLER To ROLLER DIMENSION 1,982 &0005 l.-_l_L
2. GOVERNOR LINKAGE GAP ,125” TO ,165” 19. NAME PLATE. tepr SIDE VIEWING E.P.
t(USE GAGE NO. 13389) LO. TIMED.. LEFT SIDE VIEWING E.P.
13. OPERATE PUMP AT 1DOO RPM WOT (WIDE OPEN THROTTLE) Zl. TIMED TO CAN @OF relstive, .end of injection)
FOR 10 MINUTES TO BRING TO OPERATING TEMPERATURE ANt L2. GOVERNOR CONTROL COVER TO BE STAMPEOi?.VOLtS.
CLEAR AIR FROM SYSTEM. 13. NUMBER ONE CYLINDER (FROM END PLATE).
4. CHECK FOR MINIMUM 18’ HG TRANSFER PUMP LIFT AT 400 RPM 24. SPECIAL NOTES:
IF EQUIPPEO WITH THE BY PASS SYSTEM. PINCH BY PASS HOSE 8. Electric Shut-Off to be tested and adjusted per XIL-274 or ’
5. ADJUST TRANSFER PUMP PRESSURE (WOT) S./B. 108R3
t6. CHECK FOR MINIMUM CRANKING SPEED DELIVERY (SEE STEPlB: b. pump to be tested with Fitting No. 15830 installed
7. AUTO ADVANCE SPEED RESPONSIVE C. Speed Droop to be set to XL-273 or S./S. 97Rl
1. ADVANCE MOVEMENT d. Assemble Pert No. 12293 Adj. Shut-Off Arm Assembly in RZ-L
position per b/p XL-400
b.
f. 25. SEALING WIRES: PART NO. 10408 5 . . REQUIRED
d. (REFERENCE DRAWING XL545 OR SERVICE BULLETIN 134R)
z”
1 SCREW, low idle -hole plug
1 Wrsmsli,
low idle hole plug
1 SUL, low idle screw
SCAEW, cover bold down 3
.LOGmASHER, cover screw 3 1158’2
15830 1 CONNECTOR ASSY., return line
13321 3 WASHER, cover hold down screw
12108 1 COVER,governor control
CASKET, governor cover 1
SEAL, pilot tube 1 11331 2 SCREW,head locking
SKAL, drive shaft 2 10453
SItAPT. drive 1 16248
12259 1 SCRRW,torq. screw hole plug
10464 1 WASHEX, torq. screw bole plug
SPRING, thrust button 1 15208
WASHER, torq. screw hole 1 10464 10446 1 WING, drive shaft ret.
SCREW, torq. ecr. hole plu8 1 12259
SCREW, name plate 2 10401 15089 1 HOUSING ASSEMBLY
PlATE, name 1 10394 15093 2 BUSHING, throttle shaft
CASKET, timing line cover 2 10574 10429 1 TUBE, pilot
%REW, timingline cover 4 10584
COVER, timing Line 2 10567 11354 1 WASHER,cam locating screw
I I 11507 1 SEAL, head locating screw
11363 1 SCREW,head locating
I 1 10393 1
=
14426 1 HYD.KMD h ROTOR ASSY. *
11056 2 PLUNGBK, rotor (basic)
use 11057 thru11060(Stenderd).
or 11062 thruI1065 (overriwe)
ROLL& can, 2 es indicated on rotor S.BabOR2
SHOE, ten roller 2
CAN RINC- 1 10378
SeAL, hydreulic heed . 1 11304 11437 1 WIRE, vent
SRUNC,leaf 11197 11436 2 SCREW, hydraulic: head plug
S=8W, leaf tipring edj. : 11175 11439 I WIBE, vent orire ret
12216 1 SCREW,hydraulic: head plug
C
‘ ONNxToR, fuel line 4 11338
WWHER, fuel line CO”“CCLOI 16225 11208 RING, rotor retainer
S(xcv, fuel line connector t 11346 Pi212 : RETAINER. x'otor
.* INDENTgDIjTEHS iINGLUDKD
DB.GVCC429.3U
DESCIPTION , F DtscRIPTIoN
1
LUG,
‘ end plate --“,
/-. SEA&end plate sleeve
SPRING, regulating hr .152l4 or 155hl aa required ,-
PISTON, regulating
CAP AND FILTER ELEMEXT ASS
SEAL, filter cap 11408 1. XEEVE, end plate
SEAL, transfer pump
ROLLF’IN,end plate lot.
llM6 1 iPRING,plunger retainer
11h77 1 %&l'E,end
LINER,transfer pump
BLADE, transfer pump 11532 L XREW, end plate
PLUG, end plate Pipe
= =
SPRING, control 1 1560 1 LOD ASSY., control
ARM, governor 1 i691 1 ?IN, control spring
SHAFT, governor arm pivot 1 !214 1 SEAL, control rod guide
1 JASHER,. control rod guide
SEAL, pivot shaft 2 1588 I IEAL, adjusting cap
RUT, pivot shaft retainer 1 !288 1 3P ASSY., adjusting
GUIDE, control rod 1 1532 1 IHIM, metering valve
ARM ASSY.. meterin V8lVe 1 i680 IALVE, metering
1
SLEEVE, governor thrust 1 4483 .. .
1 RETAINER AS%,-&. wei@
WEIGHT, governor 6 1643 1 RET. ASSY.,gov, vt.(basic) .
WASHER, gov. thrust sleeve 1 1620
RING, WV. cage retaining 1 2205
f 3 =
- =
1
. 12051 1 CREW. adj. shut-off ~0s.
12998 1 CREW, adJ. shikut-off ret.
NUT, s..oo arm adj. screw 1 12173 1 ASHER, adJ.s,o. ret. scrb”
11582
SCREW. shut-off arm adj. 1 1 2165
12049 1 ASHER, a'dJ. s-0. ~0s. sCr*"
LEVER, throttle shaft 1 112221 1 RM ASSY. adJ. shut-off
SPACER, throttle shaft lever
’ I’ ~2312 :.% 1 CREW, stop lever fitting
1 QLEU,
‘ shut-off arm adJ.
SEAL, throttle shaft 1 .204C 12 A65
1 NT, 5.0. arm ad& screw
throttle
,_V!?StiER, shaft seal IL4.w 12173
12234 1 ;HAPT ASSEHBLY, shut-off
\FT ASSY., throttle 12012
I, low idle sdj. screw L2173
SCREW, low idle adj. 1 2972 12245 1 !AM, shut-off
LEVER ASSY .,throttlc 1294(
ll901 1 lOOKASSEXBLY., gor. linka@
SPRINc.throttla lever .3003
la60 1 SCREu,gm.link. hookmij.
12362 1 bUSHEft, gov. link. bok odj.
SCREW.throttlc spring 1287s u9ao 1 HOOK, governor unkage
RETAINER,throttle lever 8p1: 13010 12358 1 LIUK ASST., @v. lin!f Adj.
rsg19 1 IPRING, gorelnor linkage
NUT. high idle adJ. 12173
SCREW, high idle a<j. 1297;
w
- =
1476C 2 LOCKNUT,term. contact
12515 2 NUT, term. contact
125oc 2 WASHER, term. insulating
1251: 2 TUBE, term. insulating
16353 1 FRAME ASSYo, solenoid
1248( 1 SPRING, shut-down arm
1247! 1 ARM ASSY.. shut-&w coil
= =
FOR SERVICE USE ONLY FOB ENGINEERI) IC USE ONLY
APPLICABLE SERVICE ASSRMBLIES: -DATE -CHG. NO. EDITION
--
REMARKS
GASKETKIT #13681 4-21.61 1 First Edition
SOLENOIDAND ARM ASSEMBLY #16376 E-20-64 8150 2 Refer to E&N. 18150
5-18-65 8514 3 Refer to E.C.N. X8514
COVERAND SOLENOIDASSEMBLY 616360
4-4
