Duracraft Owner's Manual

Models DF-1 DF-2 Series WHISPER MIST COOL MIST HUMIDIFIER

IMPORTANT SAFETY INSTRUCTIONS

READ ALL INSTRUCTIONS BEFORE USING THIS HUMIDIFIER AND SAVE THESE IMPORTANT INSTRUCTIONS FOR EASY REFERENCE. WHEN USING ANY ELECTRICAL APPLIANCE, BASIC SAFETY PRECAUTIONS SHOULD BE FOLLOWED INCLUDING: 1. 2. 3. 4. Always place this humidifier on a firm, flat and level surface. It may not work properly on an uneven surface. Place this humidifier in an area where it is not accessible to children. Do not place the humidifier near any heat sources such as stoves, radiators and heaters. Before using the humidifier, check the power cord for any signs of damage. If the cord is found to be damaged, DO NOT USE and return the humidifier to the manufacturer under the warranty agreement for repair. This product is equipped with a polarized AC-line plug (a plug having one blade wider than the other). This plug will fit into the power outlet only one way. This is

5.

6. 7. 8.

9.

a safety feature. NEVER connect the humidifier to any power source other than a 120V AC polarized outlet. If you are unable to insert the plug fully into the outlet, try reversing the plug. If the plug should still fail to fit, contact an electrician to replace the obsolete outlet. DO NOT defeat the safety purpose of the polarized plug. The humidifier should always be unplugged and emptied when not in operation or while being serviced or cleaned. Never tilt or attempt to move the humidifier while it is operating or filled with water. UNPLUG the humidifier before moving. This humidifier requires regular cleaning. Refer to the CLEANING instructions provided. Never clean the humidifier in any manner other than as instructed in this manual. Turn the humidifier OFF if the relative humidity exceeds 60%, or if you notice moisture on the inside of your windows. For proper humidity readings use a hygrometer which is available in many hardware and department stores, or by ordering one from the manufacturer (see CARE PRODUCTS).

INTRODUCTION
Thank you for purchasing a Duracraft Whisper Mist Cool humidifier manufactured by Honeywell. If you would like more information on our full line of products please visit our website at: www.honeywell.com/yourhome. MODEL DF-1 and DF-2 Your humidifier is made up of three parts (Mode DF-1 shown):

SET UP

NOTE: We recommend that the humidifier be disinfected prior to first use. Please see CLEANING instructions.
o o

Select a firm, level, flat location at least six inches (15 cm) from any wall for proper air flow (Fig. 1). Place the humidifier on a water-resistant surface, as water can damage furniture and some flooring.

Duracraft will not accept responsibility for property damage caused by water spillage.

FILLING
1. 2. Remove the Power Unit by pulling up (Fig. 1). Fill the Base with COOL tap water to the Fill Level indent located on the outside back of the unit. DO NOT USE HOT WATER. Doing so may damage the humidifier.

3. NEVER ADD ANY CHEMICALS OR SOLUTIONS TO THE WATER. NOTE: Water quality and hardness can vary greatly. If you notice white dust accumulating in your room, the quality of your water is most likely hard . In this case it is strongly recommended that only distilled or de-mineralized water be use. 3. Position the Power Unit into the base and push into place. 4. Once the Power Unit has been positioned, do not attempt to move the humidifier. If it has to be moved, unplug the humidifier and empty the Base first. NOTE: DO NOT POUR WATER INTO THE GRILL ON THE TOP OF THE POWER UNIT. DOING SO MAY DAMAGE THE HUMIDIFIER OR CAUSE PERSONAL INJURY.

OPERATION
CAUTION: DO NOT PLUG IN THE HUMIDIFIER WITH WET HANDS AS AN ELECTRIC SHOCK COULD OCCUR. FOR MODEL DF-1:
o o

Plug the filled humidifier into a polarized 120V outlet. DO NOT FORCE THE POLARIZED PLUG INTO THE OUTLET; it will only fit one way. The humidifier will begin to operate and will run continuously as soon as it is plugged in.

FOR MODEL DF-2:

o

With the power switch in the OFF position, plug the filled humidifier into a polarized 120V outlet. DO NOT FORCE THE POLARIZED PLUG INTO THE OUTLET; it will only fit one way. Set the fan speed control to the desired position. HIGH: for fast humidifying LOW: for quieter operation

FOR ALL MODELS:

o o

Turn the humidifier OFF or unplug if the humidity level feels too moist or you notice condensation forming on the walls and/or windows. ALWAYS be sure to discard any unused water in the Base each time you refill the humidifier or finished using it.

CLEANING THE HUMIDIFIER

We recommend cleaning the humidifier once a week, more often if you have hard water, notice a build up of impurities or detect unpleasant odors. Cleaning involves two steps SCALE REMOVAL and DISINFECTING. Be sure to perform these in the proper order to avoid harmful chemical interactions.
o o

Turn off and/or unplug the humidifier. Remove the Power Unit and turn upside down (Fig. 3).

Discard any remaining water from the base. Remove the Impeller Shaft (Fig. 4). Grip the Impeller Shaft with fingers of one hand. With the thumb and index finger of the other hand squeeze a impeller wing and locking tab together until you hear the tab snap free (Fig. 5). Lift the shaft up to remove it from the Power Unit. Set the rest of the Power Unit aside.

STEP ONE: SCALE REMOVAL 1. Fill the Base with either: one cup (8 oz's) of undiluted white vinegar OR use DuraRinse Humidifier Cleaner, part no. AC-816, following bottle instructions 2. Place the Impeller Shaft into the solution in the Base; let stand for 20 minutes. 3. With the vinegar or DuraRinse in the Base clean all interior surfaces with a soft cloth or brush to help remove scales.

4.

Rinse the Base thoroughly with water to remove scale and cleaning solution.

STEP TWO: DISINFECTING 1. Fill the Base with: 1 teaspoon of household bleach 1 gallon of water. Place the Impeller Shaft into the solution in the Base; let stand for 20 minutes Rinse with water until the odor of bleach is gone.

2. 3.

NOTE: THE USE OF OTHER WATER TREATMENT PRODUCT, SOAPS, DETERGENTS OR ABRASIVE CLEANERS NOT RECOMMENDED IN THE MANUAL MAY CAUSE DAMAGE THE HUMIDIFIER; THEREBY, HINDERING THE HUMIDIFIERS EFFECTIVENESS.
o

Reassemble Power Unit Place Impeller Shaft over the Power Unit, lining up the tabs (Fig. 6). Relock the parts by using the index finger to grasp a short wing behind the tab while holding the thumb on the tab. Squeeze together until you hear the tab lock.

END-OF-THE-SEASON CARE AND STORAGE

o o o

Follow weekly CLEANING instructions when the humidifier will not be used for at least one week or more, or at the end of the season. Let the humidifier dry completely before storing. DO NOT store with water inside the base. Pack the unit in its original carton and store in a cool, dry location.

ELECTRICAL RATINGS

This DF-1 and DF-2 are rated 0.35 amps at 120V, 60Hz.

CUSTOMER ASSISTANCE
Mail questions or comments to: Honeywell Consumer Service Center 250 Turnpike Road Southborough, MA 01772 Please be sure to specify model number. Call us toll-free at: 1-800-332-1110 Or visit our website at: www.honeywell.com/yourhome

TROUBLE SHOOTING
Q: A: I hear the Impeller turning, but I dont see any mist. Is my humidifier operating properly? Yes, the Impeller Shaft spins so quickly it breaks apart the water particles into a very fine mist you may not be able to see. You should feel a cool slightly damp mist coming out when you put your hand over the humidifier.

CARE PRODUCTS
If your local dealer is out of stock, Duracraft replacement parts and care products may be ordered directly. You can call 1-800-332-1110 to order with a MasterCard, Visa or Discover or fill out the form below and mail it along with a check or money order (sorry no CODs accepted) to: Honeywell Consumer Service Center 250 Turnpike Road Southborough, MA 01772 Please allow four to six weeks for delivery. Massachusetts residents please add 5% Sales Tax. Item Power Unit for DF-1 Power Unit for DF-12 Power Unit for DF-2 Item CAN Qty. US Price No. Price DF1-1 $8.00 $10.80 DF12-1 8.00 10.80 DF2-1 8.00 10.80 Total

Power Unit for DF-22 Base for DF-1 Base for DF-12 Base for DF-2 Base for DF-22 DuraRinse Humidifier Cleaner (32 oz.) Digital Hygrometer and Thermometer (F/C) Measure room temperature and humidity level.Free standing can be used anywhere in the room.

DF22-1 DF1-2 DF12-2 DF2-2 DF22-2 AC-816 HAC555

8.00 6.00 6.00 7.00 7.00 5.00

10.80 8.10 8.10 9.45 9.45 6.75

19.99

27.00

SUBTOTAL MA Residents add 5% Sales Tax/CAN residents only add 7% GST Shipping and Handling (US residents add $4.95/CAN residents add $7.00) TOTAL ENCLOSED Name Check or Money Order Enclosed Address Credit Card No. Exp. Date Day Time Phone Signature

LIMITED WARRANTY
WHISPERMIST COOLMISTHUMIDIFIER This product has been engineered and crafted with great care for your satisfaction. Please read all instructions before attempting to use this product. Be sure to fill out and return the enclosed card within 7 days of purchase. A.This 3 year limited warranty applies to repair or replacement of product found to be defective in material or workmanship. This warranty does not apply to damage resulting from commercial, abusive, unreasonable use or supplemental damage. Defects that are the result of normal wear and tear will not be considered manufacturing defects under this warranty. THE MANUFACTURER IS NOT LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY NATURE. ANY IMPLIED WARRANTY, INCLUDING MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ON THIS PRODUCT IS LIMITED IN DURATION TO THE DURATION OF THIS WARRANTY. Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages, or limitations on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you also may have other rights which vary from jurisdiction to jurisdiction. This warranty applies only to the original purchaser of this product from the original date of purchase.

At its option, the manufacturer will repair or replace this product if it is found defective in material or workmanship. Defective product should be returned directly to the manufacturer. C. This warranty does not cover damage resulting from any unauthorized attempts to repair or from any use not in accordance with this manual. D. Return defective product to the place of purchase in accordance with store policy or to the following address with a brief description of the problem. Include proof of purchase and a U.S. $7.00/ Can.$9.75 check or money order for handling, return packing and shipping charges. Please include your name, address and a daytime phone number. You must prepay shipping charges. Mark cartonAttention Returns Department. Ship to: In the US: In Canada: Honeywell Honeywell ATTN: Returns Department ATTN.: Returns Department Southpoint Distribution Center 510 Bronte Street 4755 Southpoint Drive Milton, ON L9T 2X6 Memphis, TN 38118, U.S.A. Canada 1-800-332-1110 B. 2000 All rights reserved. Honeywell Inc. HU4018.00 P/N: 000-00000-000