M141-1U-ATX-PFC

Industrial Application
Multi output AC-DC power supply unit

FEATURES
Input voltage Output protections Humidity Limits for harmonic current emission
115 - 230 V • Short circuit protection Operating : 20÷90% RH, • EN 61204-3 - EN 61000-3-2 - class A
(90 ÷ 264 Vac) • Overload protection Non-condensing Voltage fluctation and flicker
Input current • Overtemperature protection Storage : 10÷95% RH, Non-condensing • EN 61204-3 - EN 61000-3-3
2,5 A Max Hold up time Cooling Radio frequency amplitude
Input frequency > 16 ms External ventilation required. modulated electromagnetic field
50-60 Hz Rise Time Dielectric withstand voltage • EN 61204-3 - EN 61000-4-3
(47÷63 Hz) 0,2 ÷ 20 ms • Input - Output = comply with EN Power frequency magnetic field
Efficiency 60950-1 immunity
Start up time
85% (typ.@Pout=nominal) • Input - P.E. = comply with EN 60950-1 • EN 61204-3 - EN 61000-4-8
< 500 ms
Switching operating frequency • Output - P.E. = comply with EN Electrostatic discharge immunity
Output power 60950-1
60KHz typ. Max 140W • EN 61204-3 - EN 61000-4-2 - level 4
Power factor Isolation
Output signals Conducted immunity
=> 0,9 • Input - P.E. > 200 MOhm
• PWR_OK is a "power good" = high • EN 61204-3 - EN 61000-4-6
• Output - P.E. > 200 Mohm
Input protections when all outputs are OK. (Logic Level Electric fast transient immunity
• Fuses for Input Overcurrent Protection high = 2,4 ÷ 5V) Connections
• EN 61204-3 - EN 61000-4-4
• EMI filter • PWR_OK Delay = 0,2 ÷ 20 ms • AC inlet = Standard inlet socket
Surge Immunity
10A/250V, UL/CSA/VDE approved (IEC
• Inrush Current Limitation • PWR_OK Rise Time < 10ms 320 Type) • EN 61204-3 - EN 61000-4-5
• Input Undervoltage Protection • AC loss to PWR_OK > 16ms • JA = Molex 15-24-4048, 4 pins female Voltage dips and immunity
Leakage current to GND Inhibit input connector • EN 61204-3 - EN 61000-4-11
< 3,5mA-rms at 250 Vac, 50 Hz • PS_ON# is an active low. (when the • JB = Tyco 2-106527-0, 20 pins female Safety
See table for signal is pulled to TTL low, the outputs is connector • EN 60950-1
• Output voltages and currents on expect +5 VSB which is always • JC = Tyco 2-106527-4, 4 pins female • UL 60950-1 ed. 2006
enable whenever the AC power is connector
• Line and load regulation present.) • CAN/CSA-C22,2N° 60950-1-03
• Output ripple and noise MTBF • ROHS
Operating temperature
• Capacitive loading • (MIL-HDBK-217F) 150,000 hours of • CE
0 ÷ +70 °C continuous operation at 55° C,
Temperature power derating U.S.A. and CANADA
maximum-output load and nominal AC
2%/°C (50÷70°C) input voltage. • FCC part 15 class B
Storage temperature Comply with:
-20° ÷ +80° C Conducted emissions
• EN 61204-3 - EN 55011
Radiated emissions
• EN 61204-3 - EN 55022

FEATURES TABLE
Ripple & Noise Capacitive
Vout Iout Nominal Imin Imax * Line reg. Load reg.
OUT (0÷20MHz) Load
Volts Ampere Ampere Ampere % Io 20÷100%
mVpp (uF)
A (sw) +3.3 8 0 8 ±0.5 ±5% 50 5000
B (sw) +5 14 0 14 ±0.5 ±5% 50 6000
C (sw) +12 2.7 0 7.5 ±0.5 ±5% 120 2000
D (sr) -5 0.3 0 0.3 ±0.5 ±10% 100 350
E (sr) -12 0.8 0 0.8 ±0.5 ±10% 120 350
F (sw) +5VSB 1.5 0 1.5 ±0.5 ±5% 50 2000

* I max output values can be reached only if total output power is less than the declared Max value.

POWER SUPPLY VIEW BLOCK DIAGRAM SIGNALS DIAGRAM

OUTPUTS

95%
10%
t
T2
T1 : POWER-ON TIME
T2 : RISE TIME
T5 : AC LOSS TO PWR_OK HOLD-UP TIME

DIMENSIONS AND CONNECTIONS

20 10
19 9
18 8
17 7
16 6
15 5
14 4
13 3
12 2
11 1

POWER CONTROL SYSTEMS s.r.l. · 31020 Zoppe' di San Vendemiano (TV) · Italy Sheet: D110621A Rev.: 1D16.05.12 PG05/D 02/07
e-mail: pcs@powercontrolsystems.com Notes: all features are subject to change without notice. Only information not contractual datasheet