Parts 7-1

Section 7
Parts
NOTE: Refer to Appendix E for information about 400/480 Volt melter
parts.

Using the Illustrated Parts List

The parts lists provided in this section are organized into the following
columns:

Item—Identifies illustrated parts that are available from Nordson

Corporation.

Used—Identifies the melters in which the part is used. A blank entry

indicates that the part is used in all ProBlue melters.

Part—Provides the Nordson Corporation part number for each saleable

part shown in the illustration. A series of dashes in the parts column
(- - - - - -) means the part cannot be ordered separately.
Description—Provides the part name, as well as its dimensions and
other characteristics when appropriate. Bullets in the description,
indicate the relationships between assemblies, subassemblies, and
parts.

Quantity—The quantity required per unit, assembly, or subassembly.

The code AR (As Required) is used if the part number is a bulk item
ordered in quantities or if the quantity per assembly depends on the
product version or model.

NOTE: Illustrations of the model P4 are used throughout this section to

represent all ProBlue melters. Refer to the Used column to determine the
part number associated with your melter.

Fasteners
Fasteners are called out in each illustration using the convention Fx, where
“x” is the fastener number used in the Schedule of Fasteners, which is
located at the end of this section.

 2010 Nordson Corporation Part 1024496D04

7-2 Parts

Tank, Pump, and Manifold Parts List

Figure 7-1 Tanks, pump and manifold

Part 1024496D04  2010 Nordson Corporation

 Parts 7-3

Item Used Part Description Quantity Note

1 ------ Pump, piston, 14:1 1 A, B
2 P4, P7 ------ Manifold assembly, 4-hose, 230 V 1 C
P10 ------ Manifold assembly, 6-hose, 480 V 1 C
P4, P7 ------ Manifold assembly, 6-hose, 230 V 1 C
P10 ------ Manifold assembly, 6-hose, 480 V 1 C
3 P4 1051033 Kit, service, tank, P4, 230V 1 F
P7 1051034 Kit, service, tank, P7, 230V 1 F
P10 1051035 Kit, service, tank, P10, 230V 1 F
4 ------ Heater block, ProBlue 1 F, G
5 1017009 Screw, manifold mounting, M8 3
6 1017060 Screw, pump mounting, M8 3
7 ------ Thermostat, OOR, 500 degree, push-on 1 D
8 1018189 Clip, retaining, RTD 1
9 1017186 Tube, cross-over, tank 1
10 941161  O-ring, Viton, 0.750 x 0.938 x 0.094 in. 2
11 1017189 Tube, cross-over, pump 1
12 940133  O-ring, Viton, 0.426 x 0.070 in. 2
13 P4 1022747 Screen, inlet, pump, P4 1
P7 1025885 Screen, inlet, pump, P7 1
P10 1017892 Screen, inlet, pump, P10 1
14 1028320 Sensor, temperature, RTD 2 E
15 954013 Backup ring, Teflon 2
NS P4 1029997 Insulation, tank, P4 1
P7 1030557 Insulation, tank, P7 1
P10 1030556 Insulation, tank, P10 1

NOTE A: Refer to Pump Assembly Parts Lists

B: Included in service kit P/N 1028303
C: Included in service kit P/N 1064651, 1064652, 1064653, or 1064654. Refer to Service Kits.
D: Included in service kit P/N 1028321
E: Kit P/N 1028320 contains 1 RTD
F: Refer to Appendix E for 400/480 Volt melter parts

 2010 Nordson Corporation Part 1024496D04

7-4 Parts

Manifold Assembly Parts List

Figure 7-2 Manifold assembly

Part 1024496D04  2010 Nordson Corporation

 Parts 7-5

Item Used Part Description Quantity Note

— P4, P7 1022727 Manifold assembly, 4-hose 1
— P10 1018812 Manifold assembly, 6-hose 1
1 P4, P7 ------  Manifold, 4-hose 1
P10 ------  Manifold, 6-hose 1
2 ------  Valve assembly, pressure discharge 1 A
3 1017212  Valve, shut-off 1
4 1017211  Handle, shut-off 1
5 ------  Thermostat, 500 F, 00R 1 B
6 973583  Plug, O-ring, straight thread, 1 5/ -12 2
16
7 1019515  O-ring, Viton, 0.50 x 0.75 x 0.125 in. 3 C
8 942111  O-ring, Viton, 0.812 x 0.062 x 0.125 in. 1 C
9 973574  Plug, O-ring, straight thread, 9/16-18 7
10 942080  O-ring, Viton, 0.625 x 0.875 in. 1 C

NOTE A: Included in service kit P/N 1028308

B: Included in service kit P/N 1028321
C: Included in service kit P/N 1028309

 2010 Nordson Corporation Part 1024496D04

7-6 Parts

Pump Assembly Parts List

Figure 7-3 Standard Double-Acting pump (Part 1)

Part 1024496D04  2010 Nordson Corporation

 Parts 7-7

Figure 7-4 Standard Double-Acting pump (Part 2)

 2010 Nordson Corporation Part 1024496D04

7-8 Parts

Item Part Description Quantity Note

1 1016863 BODY,PUMP−FILTER 1
2 1016339 FRAME,PUMP,MACHINE 1
3 333137 HEAD,CYLINDER,SP,MACHIN 1
4 982147 SCR,HEX,CAP,M6X120,ZN 4
5 983410 WASHER,FLT,M,NARROW,M6,STL,ZN 9
6 1017189 TUBE,CROSSOVER,PUMP 1
7 940133 O RING,VITON,.426ID X .070W,BR,10413 2
8 954013 BACK−UP RING,SINGLE,7/16X9/16 2
9 163039 CUP,PISTON,SP 2
0 983445 WASHER,PISTON SEAL,SP 1
11 983446 WASHER,PISTON CUP,SP 2
12 940172 O RING,VITON,.676ID X .070W,BR 1
13 273139 SEAL,PUMP. 1
14 1024465 SHIFTER ASSEMBLY,G1/8 1 B
15 166880 SERVICE KIT, FORK,MAGNETIC,ASSY 1 A
16 973543 PLUG,O RING,STR THD,7/16−20 3
17 503696 CAGE,BALL,SIPHON 1
18 900001 BALL,440SSTL,.500, 50 1
19 1017320 SEAT,BALL,LOWER 1
20 945037 O RING,VITON,1 TUB 1
21 276024 VALVE ASSY,DRAIN 1
22 1022779 CHUTE,DRAIN,ASSY 1
23 982780 SCR,SKT,M5X10,ZN 2
24 1021955 ADAPTER,FILTER,ASSY 1
27 1028305 FILTER,SATURN,MELTER,100 MESH,W/ O−RING 1 A
945039  O-Ring 1 D
28 1017307 INSULATOR,PUMP 1
29 982237 SCR,HEX,CAP,M6X35,ZN 4
30 1022658 PISTON ASSY,HYDRAULIC,PROBLUE 1 C
31 982135 SCR,HEX,CAP,M6X30,ZN 1
32 940332 O RING,VITON, 2X2.125X.063 2
33 952100 CUP,U,VITON 1
34 986331 RETAINING RING,INT,100,PUSHON 1
35 984092 NUT,HEX,LOCK,TORQUE,M6,CLASS10 1
36 982372 SCR,SKT,M5X12,BL 2
37 1021270 PLATE,FILTER,ANTI ROTATE 1
38 985401 PIN,ROLL,.188X1,STL,ZN 2
39 900493 LUBRICANT,PARKER HI−TEMP,11208 0
40 900344 LUBRICANT,NEVER SEEZ,8OZ CAN 0
NOTE A: Refer to Service Kits for kit contents.
B: See Figure 7-5 for exploded view
C: See Figure 7-6 for exploded view
D: O-ring service kit P/N 1028305

NOTE: Refer to Appendix D, SP Pump Diagnostics and Repair for detailed

information about pump disassembly and maintenance.

Part 1024496D04  2010 Nordson Corporation

 Parts 7-9

This page intentionally left blank.

 2010 Nordson Corporation Part 1024496D04

7-10 Parts

Figure 7-5 Shifter assembly/Standard Double-Acting pump

Part 1024496D04  2010 Nordson Corporation

 Parts 7-11

Item Part Description Quantity Note

1 982028 SCR,SKT,M5X20,BL 4
2 1006027 SERVICE KIT, VALVE ASSY SP 1
3 1021998 MANIFOLD,AIR,G1/8 PORT,PUMP 1
4 333560 SPRING,WAVE,INCONEL,SP PUMP 1
5 155057 DETENT,UPPER,SP 1
6 982059 SCR,SKT,M4X8,BL 2
7 164606 SERVICE KIT, ACTUATOR,MAGNETIC,ASSY,SP 1 A
8 155068 CAN,SP 1
9 155067 DETENT,LOWER ,SP 1
10 986714 RETAINING RING,INT,156,BOWED 1
11 900493 LUBRICANT,PARKER HI−TEMP,11208 0
NOTE A: Refer to Service Kits for kit contents.

 2010 Nordson Corporation Part 1024496D04

7-12 Parts

Figure 7-6 Piston assembly/Standard Double-Acting pump

Item Part Description Quantity Note

1 −−−−−− PISTON,PUMP,15:1 1
2 985302 PIN,ROLL,.125X .500,STL,ZN 1
3 900000 BALL,440SSTL,.375, 50 1
4 503709 SEAT,BALL,PRESSURE 1
5 900470 ADHESIVE,LOCTITE 272,RED,HI TEMP,50ML 0

Part 1024496D04  2010 Nordson Corporation

 Parts 7-13

This page intentionally left blank.

 2010 Nordson Corporation Part 1024496D04

7-14 Parts

Pneumatic Components Parts List

7
8

Figure 7-7 Pneumatic components

Part 1024496D04  2010 Nordson Corporation

 Parts 7-15

Item Used Part Description Quantity Note

1 1023307 Elbow, male, 6 mm tube x G1/8 1
2 1023855 Tubing, PDV-to-pump, 6 mm tube 1
3 1019511 Tee, run, 6 mm tube, G1/8 1
4 1023853 Tubing, regulator-to-PDV, 6 mm tube (yellow) 1
5 1023290 Fitting, bulkhead, 90-degree, 6 mm tube 1
6 1023267 Filter assembly, air, 6 mm BSPP 1
7 1023854 Tubing, filter-to-regulator, 6 mm tube (blue) 1
8 ------ Pneumatic panel assembly 1 A

NOTE A: Included in service kit P/N 1028307

 2010 Nordson Corporation Part 1024496D04

7-16 Parts

Electrical Enclosure Parts List

Figure 7-8 Electrical enclosure

Part 1024496D04  2010 Nordson Corporation

 Parts 7-17

Item Used Part Description Quantity Note

1 ------ Module assembly, power, removable AR A
2 1017223 Frame, blank module AR
3 P4, P7 1042411 Column, rear, electrical enclosure, P4/P7 1
P10 1042414 Column, rear, electrical enclosure, P10 1
4 P4, P7 1042412 Column, side, electrical enclosure, P4/P7 1
P10 1042415 Column, side, electrical enclosure, P10 1
5 P4, P7 1042410 Column, front, electrical enclosure, P4/P7 1
P10 1042413 Column, front, electrical enclosure, P10 1
6 1039649 Frame, machined, upper, keyed 1
7 P4, P7 1020572 Panel, divider, P4/P7 1
P10 1025470 Panel, divider, P10 1
8 1017896 Hinge assembly 2
9 ------ Printed circuit assembly, display/CPU 1 B
10 P4, P7 ------ Panel assembly, front, P4/P7 1 C
P10 ------ Panel assembly, front P10 1 D
11 P4, P7 ------ Mounting plate assembly, main PCA, P4/P7 1 E
P10 ------ Mounting plate assembly, main PCA, P10 1 F, G
12 1039647 Frame, machined, lower, keyed 1

NOTE A: Included in service kit P/N 1028328

B: Included in service kit P/N 1028325
C: Included in service kit P/N 1028326
D: Included in service kit P/N 1028327
E: Included in service kit P/N 1028322
F: Included in service kit P/N 1028323
G: If only the PCA expansion board is required, order service kit P/N 1028324

 2010 Nordson Corporation Part 1024496D04

7-18 Parts

Exterior Panels Parts List

Figure 7-9 Exterior panels

Part 1024496D04  2010 Nordson Corporation

 Parts 7-19

Item Used Part Description Quantity Note

1 P4, P7 1041735 Cover, pump, P4/P7 1
P10 1041741 Cover, pump, P10 1
2 P4 1024464 Lid assembly, P4 1 A
P7, P10 1025579 Lid assembly P7/P10 1 A
3 P4 1041733 Panel assembly, rear, P4 1
P7 1041737 Panel assembly, rear, P7 1
P10 1041740 Panel assembly, rear, P10 1
4 P4 1021346 Panel assembly, end, P4 1
P7 1025591 Panel assembly, end, P7 1
P10 1028495 Panel assembly, end, P10 1
5 P4 1022948 Panel assembly, front, P4 1
P7 1025594 Panel assembly, front, P7 1
P10 1028494 Panel assembly, front, P10 1
6 P4, P7 1041736 Door assembly, filter P4/P7 1
P10 1041739 Door assembly, filter, P10 1
7 P4, P7 1041734 Cover assembly, ebox door, P4/P7 1
P10 1041738 Cover assembly, ebox door, P10 1
8 P4 1041742 Door, graphics, P4 1
P7 1041743 Door, graphics, P7 1
P10 1041745 Door, graphics, P10 1
9 1049528 Replacement hinge pin service kit P4/P7/P10 1

NOTE A: Includes hinge pin P/N 1021345

 2010 Nordson Corporation Part 1024496D04

7-20 Parts

Chassis Components Parts List

3 F24

F6

F7
4
F3 F16

5
1
8

F17

F15

F8
F3
F18
F3

15
9
F16
10

14

11
13
F3

12
16

Figure 7-10 Chassis components

Part 1024496D04  2010 Nordson Corporation

 Parts 7-21

Item Used Part Description Quantity Note

1 ------ Electrical box assembly 1 A
2 1023714 Cover, wireway, electrical enclosure 1
3 P4, P7 1038971 Switch, level, assembly, P4/P7 1 B
P10 1038972 Switch, level, assembly, P10 1 C
4 P4 1022749 Cover, tank, P4 1
P7, P10 1018190 Cover, tank, P7/P10 1
5 P4 1018691 Insulator, tank top, P4 1
P7/P10 1025640 Insulator, tank top , P7/P10 1
6 1022840 Brace, P4/P7/P10 1
7 1021653 Rod, retaining, cover 1 E
8 P4 1021655 Bracket, panel, rear, P4 1
P7 1025642 Bracket, panel, rear, P7 1
P10 1028525 Bracket, panel, rear, P10 1
9 1017603 Spacer, bottom, tank 4
10 P4 1021660 Chassis, P4 1
P7, P10 1018822 Chassis, P7/P10 1
11 1024525 Tray, drip, manifold 1
12 P4 1021661 Sub-base, P4 1
P7, P10 1018819 Sub-base, P7/P10 1
13 ------ Pneumatic assembly 1 D
14 P4 1021656 Bracket, panel, front, P4 1
P7 1025641 Bracket, panel, front, P7 1
P10 1028526 Bracket, panel, front, P10 1
15 1018821 Plate, conduit, chassis 1
16 1017947 Switch, rocker, SPST, 250V, 16A 1

NOTE A: Refer to the Electrical Enclosure Parts List

B: Included in service kit P/N 1038971
C: Included in service kit P/N 1038972
D: Included in service kit P/N 1028307
E: For the tank lid hinge pin, refer to the External Panel parts list

 2010 Nordson Corporation Part 1024496D04

7-22 Parts

Ribbon Cable Parts List

Figure 7-11 Ribbon cables

Part 1024496D04  2010 Nordson Corporation

 Parts 7-23

Item Used Part Description Quantity Note

1 1018283 Cable assembly, ribbon, main 1
2 1018284 Cable assembly, serial port 1 A

NOTE A: Included in service kit P/N 1028326 (P4/P7) and kit P/N 1028327 (P10)

 2010 Nordson Corporation Part 1024496D04

7-24 Parts

Service Kits
Pump Replacement
Part Description Quantity
1028303 Kit, service, pump assembly, P4/P7/P10 —
------  Pump, piston, 14:1 1
------  O-ring, Viton, 0.50 x 0.75 x 0.125 in. 1
------  O-ring, Viton, 0.812 x 0.062 x 0.125 in. 1
------  Elbow, male, 6 mm tube, G 1/8 1
------  Lubricant, Parker, hi-temperature, 1/2 oz. 1

Pump General Service

Part Description Quantity
1028304 Kit, service, pump, P4/P7/P10 —
940133  O-ring, Viton, 0.426 x 0.070 in. 2
940332  O-ring, Viton, 2.00 x 2.125 x 0.063 in. 2
1019515  O-ring, Viton, 0.50 x 0.75 x 0.125 in. 1
942111  O-ring, Viton, 0.812 x 0.062 x 0.125 in. 1
940181  O-ring, Viton, 0.739 x 0.70 in. 4
952100  Cup, U, Viton 1
954013  Backup ring, single, 7/16 x 9/16 2
163039  Cup, piston 2
273139  Seal, pump 1
986331  Retaining ring, internal, 100, push-on 1
984092  Nut, hex, lock, torque, M6 1
982147  Screw, hex, cap, M6 x 120 4
982237  Screw, hex, cap, M6 x 35 4
983410  Washer, flat, M6 8
940172  O-ring, Viton, 0.676 x 0.070 1
------  Lubrication, Parker, 1/2 oz. 1
940261  O-ring, Viton, 1.25 x 1.375 x .063 1
1017849  Backup ring, Teflon, 1.273 x .045 thick 1
945037  O-ring, Viton, 1-inch tube 1
973543  Plug, O-ring, 7/16-20 3
211228 Service kit, SP lubricating oil —

Part 1024496D04  2010 Nordson Corporation

 Parts 7-25

Filter
Part Description Quantity
1028305 Filter, Saturn, 100-mesh —
------  Filter assembly, 100-mesh
945039   O-ring

Pneumatic Panel
Part Description Quantity
1028307 Kit, service, pneumatic panel assembly —
------  Pneumatic panel assembly 1
------  Screw, mounting 2

Pressure Discharge Valve

Part Description Quantity
1028308 Kit, service, pressure discharge valve —
------  Valve assembly, pressure discharge 1
------  Screw, hex, M5 x 50 3
------  Tee, run, 6-mm tube, G1/8 1

Manifold Service Kit

Part Description Quantity
1028309 Kit, service, manifold, P4/P7/P10 —
1019515  O-ring, Viton, 0.050 x. 0.75 x 0.125 in. 3
------  O-ring, Viton, 0.625 x 0.875 in. 1
942111  O-ring, Viton, 0.812 x 0.062 x 0.125 in. 1
------  O-ring, Viton, 0.750 x 0.938 x 0.094 in. 2
------  Lubricant, Parker, 1/2 oz 1

 2010 Nordson Corporation Part 1024496D04

7-26 Parts

RTD
Part Description Quantity
1028320 Kit, service, RTD, P4/P7/P10 —
------  Sensor, temperature, RTD 1
------  Screw, hex, M3 x 20 1
------  Washer, lock, spring, M3 1
------  Terminal block, 380 V 1
1019515  O-ring, Viton, 0.50 x 0.75 x. 0.125 in. 1
942111  O-ring, Viton, 0.812 x 0.062 x 0.125 in 1
------  Compound, thermal, 1 gram 1

Thermostat
Part Description Quantity
1028321 Kit, service, thermostat, melter —
------  Thermostat, OOR, 500 degree, push-on 1
------  Screw, hex, M4 x 6 2
------  Compound, thermal, 1 gram 1

Main Circuit Board

Used Part Description Quantity
P4, P7 1028322 Kit, service, main PCA —
P10 1028323 Kit, service, main PCA —
------  Mounting plate assembly, main PCA 1

Central Processor Unit (CPU)

Part Description Quantity
1028325 Kit, service, central processor unit —
------  PCA, display/CPU 1
------  Stand-off, hex, M3 x 8 mm 6
------  Washer, lock, M3 6

Operator’s Panel
Used Part Description Quantity
P4, P7 1028326 Kit, service, operator’s panel/enclosure, P4/P7 —
P10 1028327 Kit, service, operator’s panel/enclosure, P10 —
------  Panel assembly, front, electrical enclosure 1

Part 1024496D04  2010 Nordson Corporation

 Parts 7-27

Hose/Gun Module
Part Description Quantity
1028328 Kit, service, hose/gun module, P4/P7/P10 —
------  Module assembly, power, removable 1

Main Circuit Board Fuses

Part Description Quantity
1028329 Kit, service, fuse, main circuit board, P4/P7/P10 —
------  Fuse, 15.00, nontime-delay, 250 V 2
------  Cover, fuse, 0.25 x 1.25 in. 2
------  Fuse, time-lag, 2A, 5 x 20 mm, ceramic 2
------  Cover, fuse, 5 x 20 mm 2
NOTE A: Refer to Table 6-2 for fuse types and locations

Hose/Gun Module Fuses

Part Description Quantity
1028331 Kit, service, fuse, hose/gun module, P4/P7/P10 —
------  Fuse, 6.30, fast-acting, 250 V, 5 x 2 4
------  Cover, fuse, 5 x 20 mm 4
NOTE A: Refer to Table 6-4 for fuse types and locations

Basic Spare Parts

Part Description Quantity
1028332 Kit, basic spare parts, P4/P7/P10 —
1028305  Filter, Saturn, melter, 100-mesh 1
1028320  Kit, service, RTD, P4/P7/P10 1
1028321  Kit, service, thermostat, melter 1
1028328  Kit, service, hose/gun module, P4/P7/P10 1
1028329  Kit, service, fuse, main circuit board, P4/P7/P10 1
1028331  Kit, service, fuse, hose/gun module, P4/P7/P10 1

 2010 Nordson Corporation Part 1024496D04

7-28 Parts

Expanded Spare Parts

Part Description Quantity
1028333 Kit, basic expanded parts, P4/P7/P10 —
1028305  Filter, Saturn, melter, 100-mesh 5
1028320  Kit, service, RTD, P4/P7/P10 1
1028321  Kit, service, thermostat, melter 1
1028328  Kit, service, hose/gun module, P4/P7/P10 1
1028329  Kit, service, fuse, main circuit board, P4/P7/P10 1
1028331  Kit, service, fuse, hose/gun module, P4/P7/P10 1
1028304  Kit, service, pump, P4/P7/P10 1
1028309  Kit, service, manifold, P4/P7/P10 1
1023267  Filter assembly, air, 6 mm BSPP 1

Level Switch
Used Part Description Quantity
P4, P7 1038971 Kit, switch, level, P4/P7 —
------  Switch, level, assembly, P4/P7 1
------  Nut, hex, M5 2
P10 1038972 Kit, switch, level, P10 —
------  Switch, level, assembly, P10 1
------  Nut, hex, M5 2

Manifold Guard (P4)

Part Description Quantity
1032154 Kit, manifold guard, P4 —
------  Shield, manifold, snap-on, P4 1

Manifold Guard (P10)

Part Description Quantity
1031871 Kit, manifold guard, 6-hose, P10 —
------  Guard, wire frame, manifold, 6-hose 1
------  Mount, lower, wire guard, 6-hose 2
------  Mount, upper B, wire guard, 6-hose 1
------  Mount, upper A, wire guard, 6-hose 1
------  Screw, socket-head, M5 x 20 3

Part 1024496D04  2010 Nordson Corporation

 Parts 7-29

Vent Guard (P10)

Part Description Quantity
1048884 Guard kit assembly, vent , screen, P10 —
------  Guard, screen, pump cover, P10 1
------  Reference drawing, guard kit, vent, screen, P10 1

Replacement Tank
Part Description Quantity
1051033 Kit, service, tank, P4, 230V 1
1051034 Kit, service, tank, P7, 230V 1
1051035 Kit, service, tank, P10, 230V 1

Tank Lid Hinge Pin

Part Description Quantity
1049528 Replacement hinge pin service kit, P4/P7, P10 —
------  Pin, hinge, lid, P4/P7/P10 1
------  Tube, spacer, pin, hinge, P4/P7/P10 1
------  Spring, compression, .360 x .038 x 1.75 long 1
------  Retaining, ring, external, 18, E-ring 2

Heater-Block 230V
Part Description Quantity
1064649 SVC KIT,HEATER BLOCK,230V,PROBLUE —
------  HEATER BLOCK,PROBLUE,230V 1
------  SCR,SKT,M5X25,BL 2
------  WASHER,LK,M,SPT,M5,STL,ZN 2
------  COMPOUND,HEATSINK,10CC SYRINGE 1

 2010 Nordson Corporation Part 1024496D04

7-30 Parts

Manifold 4 or 6-hose/230V or 480V

Part Description Quantity
1064651 SVC KIT,MANIFOLD 4−H,W/HTR BLOCK,230V,PB —
1064652 SVC KIT,MANIFOLD 4−H,W/HTR BLOCK,480V,PB —
1064653 SVC KIT,MANIFOLD 6−H,W/HTR BLOCK,230V,PB —
1064654 SVC KIT,MANIFOLD 6−H,W/HTR BLOCK,480V,PB —
------  HEATER BLOCK,PROBLUE,230V, or 1
------  HEATER BLOCK,PROBLUE,480V 1
------  MANIFOLD ASSY, 4 HOSE, or 1
------  MANIFOLD ASSY, 6 HOSE 1
------  SCR,SKT,M5X25,BL 2
------  WASHER,LK,M,SPT,M5,STL,ZN 2
------  O RING, VITON, .50 X .75 X .125 2
------  O RING,VITON, .812X1.062X.125 1
------  O RING,VITON, .750X .938X.094 2
------  O RING,VITON,.426ID X .070W,BR,10413 2
------  GREASE,HI−TEMP,.50OZ,SLUBE 884−.50 1
------  COMPOUND,HEATSINK,10CC SYRINGE 1

Part 1024496D04  2010 Nordson Corporation

 Parts 7-31

Option Kits
6-Hose Extension
Part Description Quantity
1028324 Kit, 6-hose extension, board, P10 —
------  PCA, P10, expansion 1
------  Harness, expansion, 6 hose/gun 1
------  Cable assembly, 20 position, ribbon cable 1
------  Screw, machine, pan-head, M3 x 12 4

Input/Output Expansion Card

Part Description Quantity
1036607 Kit, I/O expansion card —
------  PCA, optional I/O 1
------  Terminal block connector, 10 position (1–10) 1
------  Terminal block connector, 10 position (11–20) 1
------  Screw, machine, pan-head, M3 x 6 8

Fill Master
Part Description Quantity
771415 Kit, sensor, P4/P7/P10 A, B
771417 Kit, lid, P7/P10 B
771416 Kit, lid, P4 B
NOTE A: Requires lid kit P/N 771417 or 771416
B: Fill Master system is not included

 2010 Nordson Corporation Part 1024496D04

7-32 Parts

Ethernet Card
Part Description Quantity
1053289 KIT,ETHERNET CARD —
------  PCA,ANYBUS−S,ETHERNET,17MM PINS,PROGRAMM 1
------  MACH SCRM,PAN,REC,M3X6,SEMS 3

Devicenet Card
Part Description Quantity
1053288 KIT,DEVICENET CARD —
------  PCA,ANYBUS−S,DEVICENET,17MM PINS 1
------  MACH SCRM,PAN,REC,M3X6,SEMS 3

Profibus Card
Part Description Quantity
1053300 KIT, PROFIBUS CARD —
------  PCA,ANYBUS−S,PROFIBUS,17MM PINS 1
------  MACH SCRM,PAN,REC,M3X6,SEMS 3

P10 8 H/G Expansion Base

Part Description Quantity
1061030 8 H/G, BASE,EXPANSION —
------  BASE,EXPANSION,8 H/G,P10 1
------  KIT,SHIP WITH,2 H/G BASE,P10 1

Part 1024496D04  2010 Nordson Corporation

 Parts 7-33

Schedule of Fasteners
Number Description
F1 Screw, socket, M6 x 120
F2 Washer, flat, M6
F3 Screw, socket, M5 x 10
F4 Screw, socket, M6 x 35
F5 Screw, socket, M5 x 12
F6 Screw, socket, M5 x 20
F7 Washer, lock, split, M5
F8 Washer, lock, split, M6
F9 Screw, socket, M5 x 10
F10 Nut, hex, 10-32
F11 Washer, flat, 10
F12 Washer, flat, M5
F13 Washer, flat, oversized, M5
F14 Screw, socket, M5 x 50
F15 Nut, hex, M6
F16 Screw, socket, M4 x 10
F17 Nut, hex, M8
F18 Washer, lock, split, M8
F19 Screw, socket, M4 x 8
F20 Washer, flat, M8
F21 Screw, socket, M6 x 16
F22 Screw, socket, M5 x 16
F23 Screw, socket, M4 x 6
F24 Nut, hex, M5, Zn
F25 Screw, socket, M5 x 12
F26 Screw, pan-head, M4 x 12
F27 Screw, pan-head, cross-rec, M5 x 8
F28 Washer, flat, regular, 8
F29 Screw, socket, M5 x 25

 2010 Nordson Corporation Part 1024496D04

7-34 Parts

This page intentionally left blank.

Part 1024496D04  2010 Nordson Corporation