TOUAREG 2006-2010 – FUSE LAYOUT

Cigar lighter (power outlet) fuses in the Volkswagen Touareg are the fuses
#1, #2, #3 and #5 in the Left Instrument panel fuse box.

Fuse box location

Fuse holder on the left side edge of the instrument panel

Fuse holder on the right side edge of the instrument panel

 TOUAREG 2006-2010 – FUSE LAYOUT

Pre-fuse box, under driver seat

Located near the battery under the driver seat

Relay panel E-Box 1

It is located on left under dash panel near center console

Relay panel E-box 2

It is located on right under dash panel, near right a-pillar (only right-hand drive vehicles)
TOUAREG 2006-2010 – FUSE LAYOUT
Engine compartment fuse box

Fuse box diagrams

Instrument Panel, left

 TOUAREG 2006-2010 – FUSE LAYOUT

Advertisements

Assignment of the fuses in the left-side of the dash panel

№ A Function/component
15
20 (Only auxiliary battery U1 - Cigarette lighter
1
and two battery onboard U9 - Rear cigarette lighter
supply)
J160 - Circulation pump relay (Only auxiliary battery and
5
2 two battery onboard supply)
15
J708 - Residual heat relay (Only auxiliary battery and two
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
battery onboard supply)
R149 - Remote control receiver for auxiliary coolant heater
(Only auxiliary battery and two battery onboard supply)
U18 - 12 V socket 2 (Only one battery onboard supply)
U20 - 12 V socket 4 (Only one battery onboard supply)
15
20 (Only auxiliary battery U5 - 12 V socket
3
and two battery onboard U19 - 12 V socket 3
supply)
4 20 J162 - Heater control unit
U18 - 12 V socket 2 (Only auxiliary battery and two
battery onboard supply)
U19 - 12 V socket 4 (Only auxiliary battery and two
5 20
battery onboard supply)
J807 - Relay for power sockets (Only one battery onboard
supply)
J518 - Entry and start authorisation control unit (Only V10
TDI)
6 15
J708 - Residual heat relay (Only one battery onboard
supply)
T16b - Diagnostic connection
7 5 J515 - Aerial selection control unit
G397 - Rain and light detector sensor
25
8 V - Windscreen wiper motor
30 (From November 2007)
J519 - Onboard supply control unit (windscreen wiper
9 15
pump)
25
10 J388 - Rear left door control unit (window regulator)
30 (From November 2007)
J386 - Driver door control unit (central locking)
11 15
J388 - Rear left door control unit (central locking)
12 10 J519 - Onboard supply control unit (interior light)
13 - Not assigned
25
14 J386 - Driver door control unit (window regulator)
30 (From November 2007)
J393 - Convenience system central control unit (right tail
15 15
light cluster)
16 20 J519 - Onboard supply control unit (fanfare)
17 30 J519 - Onboard supply control unit (left light)
20
18 J39 - Headlight washer system relay
25 (From November 2007)
19 - Not assigned
20 30 J519 - Onboard supply control unit (battery 1)
21 - Not assigned
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
J647 - Axle differential lock control unit
22 30
J605 - Rear lid control unit
23 10 J647 - Axle differential lock control unit
24 5 J502 - Tyre pressure monitor control unit
J352 - Steering column and belt height adjustment control
25 15
unit
F36 - Clutch pedal switch
J... - Engine control units
J234 - Airbag control unit
J285 - Control unit in dash panel insert
26 10 J519 - Onboard supply control unit
K145 - Front passenger side airbag deactivated warning
lamp
N378 - Driver seat belt inertia reel magnet
N379 - Front passenger side seat inertia reel magnet
E183 - Interior monitoring switch
W11 - Rear left reading light
W12 - Rear right reading light
27 5
W14 - Front passenger side illuminated vanity mirror
W20 - Driver side illuminated vanity mirror
W51 - Rear lid light
28 - Not assigned
29 - Not assigned
30 - Not assigned
31 - Not assigned
32 - Not assigned
33 15 J527 - Steering column electronics control unit
G273 - Interior monitoring sensor
G384 - Vehicle inclination sender
34 5
J285 - Control unit in dash panel insert (Only auxiliary
battery and two battery onboard supply)
35 30 J519 - Onboard supply control unit
36 30 E470 - Driver seat adjustment operating unit
37 - Not assigned
38 - Not assigned
J9 - Heated rear window relay
J32 - Air conditioning system relay
J329 - Terminal 15 voltage supply relay
39 5
J755 - Transport mode relay
J807 - Relay for power sockets (Only one battery onboard
supply)
40 5 J285 - Control unit in dash panel insert
41 15 J518 - Entry and start authorisation control unit
42 30 J245 - Sliding sunroof adjustment control unit
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
43 - Not assigned
E470 - Driver seat adjustment operating unit
J136 - Seat and steering column adjustment control unit
44 30
with memory
J810 - Driver seat adjustment control unit
46 - Not assigned
47 10 J647 - Axle differential lock control unit
J769 - Lane change assist control unit
48 5
J770 - Lane change assist control unit 2
49 5 J236 - Servotronic control unit
G266 - Oil level and oil temperature sender
50 10 N79 - Crankcase breather heater element (Only models
with engine codes BHK, BHL)
T16b - Diagnostic connection
F321 - Parking brake contact switch
51 5 G238 - Air quality sensor
G550 - Sensor for automatic distance control
J755 - Transport mode relay
30
52 V12 - Rear window wiper motor
15 (From November 2007)
E1 - Light switch
53 5 J527 - Steering column electronics control unit
J393 - Convenience system central control unit
E102 - Headlight range control regulator (Only models
with halogen headlights)
J667 - Power output module for left headlight (Only
models with cornering light)
54 10
V48 - Left headlight range control motor (Only models
with halogen headlights)
V49 - Right headlight range control motor (Only models
with halogen headlights)
55 15 J486 - Fresh air blower relay for 2nd speed
J32 - Air conditioning system relay
J309 - Solar cell isolation relay
56 40 J486 - Fresh air blower relay, 2nd speed
SB55 - Fuse 55 on fuse holder B
V305 - Motor for front Bitron blower regulation
V306 - Motor for rear Bitron blower regulation (Up to
November 2007)
57 40
J403 - Adaptive suspension compressor relay (From
November 2007)

Advertisements

Instrument Panel, right

 TOUAREG 2006-2010 – FUSE LAYOUT

Assignment of the fuses in the right-side of the dash panel

№ A Function/component
15
1 J345 - Trailer detector control unit
20 (From May 2008)
2 5 J446 - Parking aid control unit
3 15 J345 - Trailer detector control unit
4 5 J412 - Mobile telephone operating electronics control unit
15
5 J345 - Trailer detector control unit
25 (From May 2008)
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
6 30 J104 - ABS control unit
7 5 J646 - Transfer box control unit
8 30 J519 - Onboard supply control unit (right light)
Individualisation
9 10
R190 - Satellite digital radio tuner (Only American markets)
J772 - Reversing camera system control unit
10 5
R78 - TV tuner
J503 - Control unit with display for radio and navigation system
R - Radio
11 20
R - Preparation for radio and navigation system with TV (models
for Japan)
12 30 R12 - Amplifier
13 - Not assigned
14 15 J393 - Convenience system central control unit
25
15 30 (From November J389 - Rear right door control unit (window regulator)
2007)
10
16 5 (From November W3 - Luggage compartment light
2007)
17 - Not assigned
18 30 J9 - Heated rear window relay
19 - Not assigned
U13 - AC./DC converter with socket 12 V - 230 V
20 30 U27 - AC/DC converter with socket 12 V - 115 V (Only
American markets)
21 10 F266 - Bonnet contact switch
22 25 J774 - Heated front seats control unit
23 10 J255 - Climatronic control unit
E471 - Front passenger seat adjustment operating unit
24 30
J521 - Front passenger seat adjustment with memory control unit
E265 - Rear Climatronic operating and display unit
25 5
J301 - Air conditioning system control unit
26 - Not assigned
27 15 J197 - Adaptive suspension control unit
28 - Not assigned
10
29 5 (From November J217 - Automatic gearbox control unit
2007)
30 20 J714 - Power latching system relay
31 15 J393 - Convenience system central control unit
J387 - Front passenger door control unit (central locking)
32 10
J389 - Rear right door control unit (central locking)
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
33 15 Individualisation
25
34 30 (From November J387 - Front passenger side door control unit (window regulator)
2007)
35 30 E471 - Front passenger seat adjustment operating unit
J603 - Vehicle position recognition control unit
36 5
J702 - Roof display unit
37 - Not assigned
38 10 J104 - ABS control unit
J410 - Heated windscreen relay for left side
J411 - Heated windscreen relay for right side
39 5
J745 - Cornering light and headlight range control unit
Individualisation
40 10 J646 - Transfer box control unit
41 10 J345 - Trailer detector control unit
E284 - Garage door operating unit
42 5
J530 - Garage door operation control unit
43 5 F41 - Reversing switch
E94 - Heated driver seat regulator
E95 - Heated front passenger seat regulator
E128 - Heated rear left seat switch with regulator
44 5 E129 - Heated rear right seat switch with regulator
E281 - Operating unit to regulate suspension height
Z20 - Left washer jet heater element
Z21 - Right washer jet heater element
45 - Not assigned
46 - Not assigned
47 10 J668 - Power output module for right headlight
48 10 J197 - Adaptive suspension control unit
49 5 Y7 - Automatic anti-dazzle interior mirror
50 5 E256 - TCS and ESP button
51 15 J217 - Automatic gearbox control unit
F125 - Multifunction switch
52 5 F189 - Tiptronic switch
N380 - Selector lever lock for position P solenoid
53 30 J411 - Heated windscreen relay for right side
54 30 J410 - Heated windscreen relay for left side
55 - Not assigned
56 40 J104 - ABS control unit
57 40 J646 - Transfer box control unit

Engine compartment (2.5L (R5) TDI engine)

 TOUAREG 2006-2010 – FUSE LAYOUT

Assignment of the fuses in the Engine compartment (2.5L (R5) TDI engine)
№ A Function/component
1 60 J293 - Radiator fan control unit
J671 - Radiator fan control unit 2 (Only models for tropical climate zones and
2 30
models with towing coupling)
3 - Not assigned
4 - Not assigned
5 - Not assigned
6 - Not assigned
7 - Not assigned
8 - Not assigned
9 30 J623 - Engine control unit
G65 - High-pressure sender
J17 - Fuel pump relay
J255 - Climatronic control unit
J293 - Radiator fan control unit
J301 - Air conditioning system control unit
J445 - Fuel cooling pump relay
10 10
J496 - Additional coolant pump relay
J671 - Radiator fan control unit 2
N75 - Charge pressure control solenoid valve
N79 - Crankcase breather heater element
N280 - Air conditioner compressor regulating valve
N345 - Exhaust gas recirculation cooler changeover valve
11 - Not assigned
J179 - Automatic glow period control unit
12 10
J496 - Additional coolant pump relay
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
G6 - Fuel system pressurisation pump
G23 - Fuel pump
J17 - Fuel pump relay
13 25
J445 - Fuel cooling pump relay
J715 - Tank circuit pressurisation relay
V166 - Fuel cooling pump
14 - Not assigned
15 - Not assigned
16 - Not assigned
G39 - Lambda probe
17 10
Z19 - Lambda probe heater
18 - Not assigned

Relays
A1 Not assigned
A2 Terminal 30 voltage supply relay -J317- (109)
A3 Automatic glow period control unit -J179- (475)
A4 Fuel pump relay -J17- (53)
A5 Additional coolant pump relay -J496- (404)
A6 Fuel cooling pump relay -J445- (404)
B1 Not assigned
B2 Not assigned
B3 Not assigned
B3 Not assigned
B4 Not assigned
B5 Not assigned
B6 Not assigned
C19 Tank circuit pressurisation relay -J715- (404) (Only auxiliary coolant heater)
C20 Terminal 50 voltage supply relay -J682- (433)

Engine compartment (3.0L (V6) diesel engine)

 TOUAREG 2006-2010 – FUSE LAYOUT

Advertisements

Assignment of the fuses in the Engine compartment (3.0L (V6) diesel engine))
№ A Function/component
60
1 30 (Depends on J293 - Radiator fan control unit
equipment)
2 30 J671 - Radiator fan control unit 2
3 - Not assigned
J360 - High heat output relay (Only models with engine
4 80
code CATA)
J359 - Low heat output relay (Only models with engine
5 40
code CATA)
6 - Not assigned
N276 - Fuel pressure regulating valve
N290 - Fuel metering valve
7 15
J17 - Fuel pump relay (Only models with engine code
CATA)
8 - Not assigned
J248 - Diesel direct injection system control unit
9 30
J623 - Engine control unit
G65 - High-pressure sender
J17 - Fuel pump relay
10 10 J179 - Automatic glow period control unit
J255 - Climatronic control unit
J293 - Radiator fan control unit
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
J301 - Air conditioning system control unit
J338 - Throttle valve module (Only models with engine
code CATA)
J442 - Alternator cut-in relay (Up to May 2007)
J445 - Fuel cooling pump relay
J496 - Additional coolant pump relay
J671 - Radiator fan control unit 2
J724 - Turbocharger 1 control unit
J865 - Control unit for charge air cooler bypass (Only
models with engine code CATA)
N18 - Exhaust gas recirculation valve
N280 - Air conditioner compressor regulating valve
N345 - Exhaust gas recirculation cooler changeover valve
N381 - Exhaust gas recirculation cooler changeover valve
2 (Only models with engine code CATA)
N428 - Valve block 2 in front passenger side rear seat
(Only models with engine code CATA)
V157 - Intake manifold flap motor
V275 - Intake manifold flap 2 motor
V400 - Pump for exhaust gas recirculation cooler (Only
models with engine code CATA)
J445 - Fuel cooling pump relay
15 (Only models with J832 - Relay for supplementary fuel pump
11
engine code CATA) V166 - Fuel cooling pump
V393 - Supplementary fuel pump
12 10 J496 - Additional coolant pump relay
G6 - Fuel system pressurisation pump
G23 - Fuel pump
25 J17 - Fuel pump relay (Only models with engine code
13 20 (Only models with CATA)
engine code CATA) J445 - Fuel cooling pump relay
J715 - Tank circuit pressurisation relay
V166 - Fuel cooling pump
G698 - Evaluation unit for reducing agent level (Only
models with engine code CATA)
N473 - Reversing valve for reducing agent (Only models
with engine code CATA)
14 15
V437 - Reducing agent pump (Only models with engine
code CATA)
Z103 - Heater for reducing agent pump (Only models with
engine code CATA)
J317 - Terminal 30 voltage supply relay
15 10 J623 - Engine control unit (Only models with engine code
CATA)
16 30 J891 - Control unit for reducing agent heater
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
J583 - NOx sensor control unit (Only models with engine
code CATA)
20
J881 - NOx sensor 2 control unit (Only models with
17 15 (Depends on
engine code CATA)
equipment)
G39 - Lambda probe
Z19 - Lambda probe heater
18 - Not assigned

Relays
A1 Not assigned
Terminal 30 voltage supply relay -J317- (219) / (643)
A2
optional installation
Automatic glow period control unit -J179- (475) / (639) /
A3
(647) optional installation
A4 Not assigned
Additional coolant pump relay -J496- (404 / (449)
A5
optional installation
Fuel cooling pump relay -J445- (404) / (449) optional
A6
installation
B1 Not assigned
B2 Fuel pump relay -J17- (53)
B3 Not assigned
B3 High heat output relay -J360- (100)
B4 Low heat output relay -J359- (100)
B5 Not assigned
B6 Supplementary fuel pump relay -J832- (449)
Tank circuit pressurisation relay -J715- (404) (Only
C19
auxiliary coolant heater)
C20 Terminal 50 voltage supply relay -J682- (433)

Advertisements

Engine compartment (5.0L (V10) TDI engine)

 TOUAREG 2006-2010 – FUSE LAYOUT

Assignment of the fuses in the Engine compartment (5.0L (V10) TDI engine))
№ A Function/component
1 60 J293 - Radiator fan control unit
60 (Only models for tropical
climate zones and models with J671 - Radiator fan control unit 2
2
towing coupling) V177 - Radiator fan 2
30
3 - Not assigned
4 - Not assigned
5 - Not assigned
6 60 J701 - Voltage supply relay 1
J708 - Residual heat relay
J496 - Additional coolant pump relay
7 10
J445 - Fuel cooling pump relay
V166 - Fuel cooling pump
8 30 J624 - Engine control unit 2
9 30 J623 - Engine control unit
G65 - High-pressure sender
J17 - Fuel pump relay
J293 - Radiator fan control unit
J671 - Radiator fan control unit 2
N345 - Exhaust gas recirculation cooler
10 10 changeover valve
N381 - Exhaust gas recirculation cooler
changeover valve 2
V336 - Metering pump for post-injection in
particulate filter for cylinder bank 1 (Only
American markets)
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
V337 - Metering pump for post-injection in
particulate filter for cylinder bank 2 (Only
American markets)
F265 - Map-controlled engine cooling system
thermostat
J255 - Climatronic control unit
J724 - Turbocharger 1 control unit
J725 - Turbocharger 2 control unit
N280 - Air conditioner compressor regulating
11 15 valve
V135 - Particulate filter additive pump (Only
American markets)
V157 - Intake manifold flap motor
V275 - Intake manifold flap 2 motor
V280 - Turbocharger 1 control motor
V281 - Turbocharger 2 control motor
J179 - Automatic glow period control unit
J445 - Fuel cooling pump relay
12 5
J496 - Additional coolant pump relay
J703 - Glow period control unit 2
G6 - Fuel system pressurisation pump
G23 - Fuel pump
25 (Not American markets)
13 J17 - Fuel pump relay
30
J715 - Tank circuit pressurisation relay (Not
American markets)
14 - Not assigned
15 10 J317 - Terminal 30 voltage supply relay
16 10 J581 - Battery parallel circuit relay
G39 - Lambda probe
G108 - Lambda probe 2
17 20
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
18 - Not assigned

Relays
A1 Glow period control unit 2 -J703- (475)
A2 Terminal 30 voltage supply relay 2 -J689- (219)
A3 Automatic glow period control unit -J179- (475)
A4 Not assigned
A5 Additional coolant pump relay -J496- (404)
A6 Fuel cooling pump relay -J445- (404)
B1 Terminal 30 voltage supply relay -J317- (219)
B2 Fuel pump relay -J17- (53)
B3 Not assigned
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
B3 Not assigned
Voltage supply relay 1-J701- (100) / (370) optional
B4
installation
B5 Not assigned
B6 Not assigned
Tank circuit pressurisation relay -J715- (404) (Not
C19
for American markets)
C20 Terminal 50 voltage supply relay -J682- (433)

Engine compartment (3.2L (V6) petrol engine)

Advertisements

Assignment of the fuses in the Engine compartment (3.2L (V6) petrol engine)
№ A Function/component
1 60 J293 - Radiator fan control unit
2 30 J671 - Radiator fan control unit 2
3 40 V101 - Secondary air pump motor
4 - Not assigned
5 - Not assigned
6 - Not assigned
N30 - Injector, cylinder 1
7 20 N31 - Injector, cylinder 2
N32 - Injector, cylinder 3
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
N70 - Ignition coil 1 with power output stage
N127 - Ignition coil 2 with power output stage
N291 - Ignition coil 3 with power output stage
N33 - Injector, cylinder 4
N83 - Injector, cylinder 5
N84 - Injector, cylinder 6
8 20
N292 - Ignition coil 4 with power output stage
N323 - Ignition coil 5 with power output stage
N324 - Ignition coil 6 with power output stage
J220 - Motronic control unit
N156 - Variable intake manifold changeover valve
9 30
N205 - Inlet camshaft control valve 1
N318 - Exhaust camshaft control valve 1
G65 - High-pressure sender
J293 - Radiator fan control unit
J569 - Brake servo relay
10 10 J671 - Radiator fan control unit 2
N80 - Activated charcoal filter solenoid valve 1
N115 - Activated charcoal filter solenoid valve 2
V144 - Fuel system diagnostic pump
G266 - Oil level and oil temperature sender
11 15 J255 - Climatronic control unit
N280 - Air conditioner compressor regulating valve
J299 - Secondary air pump relay
12 5
J496 - Additional coolant pump relay
13 15 G23 - Fuel pump
14 15 G6 - Fuel system pressurisation pump
J17 - Fuel pump relay
J49 - Electric fuel pump 2 relay
15 10 J220 - Motronic control unit
J271 - Motronic current supply relay
J670 - Motronic current supply relay 2
16 15 V192 - Vacuum pump for brakes
G39 - Lambda probe
17 15
G108 - Lambda probe 2
G130 - Lambda probe after catalytic converter
18 7.5
G131 - Lambda probe 2 after catalytic converter

Relays
A1 Terminal 30 voltage supply relay 2 -J689- (53)
A2 Not assigned
A3 Terminal 30 voltage supply relay -J317- (167
A4 Secondary air pump relay -J299- (100) / (370) optional installation
A5 Additional coolant pump relay -J496- (404)
A6 Fuel pump relay -J17- (53)
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
B1 Not assigned
B2 Not assigned
B3 Not assigned
B3 Not assigned
B4 Not assigned
B5 Not assigned
B6 Brake servo relay -J569- (404) (Only models with automatic gearbox)
C19 Electric fuel pump 2 relay -J49- (404)
C20 Terminal 50 voltage supply relay -J682- (433)

Advertisements

Engine compartment (3.6L (V6) FSI engine)

Assignment of the fuses in the Engine compartment (3.6L (V6) FSI engine)
№ A Function/component
1 60 J293 - Radiator fan control unit
30 (Only models for tropical
J671 - Radiator fan control unit 2
2 climate zones and models with
V7 - Radiator fan
towing coupling)
3 - Not assigned
4 - Not assigned
5 - Not assigned
6 - Not assigned
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
N70 - Ignition coil 1 with output stage
7 20 N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
N292 - Ignition coil 4 with output stage
8 20 N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
9 30 J623 - Engine control unit
G65 - High-pressure sender
J293 - Radiator fan control unit
J496 - Additional coolant pump relay
10 10 J671 - Radiator fan control unit 2 (Only models for
tropical climate zones and models with towing
coupling)
V144 - Fuel system diagnostic pump
J255 - Climatronic control unit
J301 - Air conditioning system control unit
11 10
J442 - Alternator cut-in relay2)
N280 - Air conditioner compressor regulating valve
N80 - Activated charcoal filter system solenoid
valve 1
12 10 N205 - Inlet camshaft control valve 1
N316 - Intake manifold flap valve
N318 - Exhaust camshaft control valve 1
13 25 J538 - Fuel pump control unit
14 15 N276 - Fuel pressure regulating valve
J623 - Engine control unit
15 10 J271 - Motronic current supply relay
J670 - Motronic current supply relay 2
16 15 J496 - Additional coolant pump relay
G39 - Lambda probe
G108 - Lambda probe 2
17 15
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
Z29 - Lambda probe 1 heater after catalytic
18 7.5
converter
Z30 - Lambda probe 2 heater after catalytic
converter

Relays
A1 Not assigned
A2 Not assigned
A3 Motronic current supply relay -J271- (614)
A4 Not assigned
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
A5 Additional coolant pump relay -J496- (404)
A6 Not assigned
B1 Not assigned
B2 Not assigned
B3 Not assigned
B3 Not assigned
Motronic current supply relay 2 -J670- (614) to
B4
May 2007
B5 Not assigned
B6 Not assigned
C19 Not assigned
C20 Terminal 50 voltage supply relay -J682- (433)

Advertisements

Engine compartment (4.2L (V8) FSI engine)

Assignment of the fuses in the Engine compartment (4.2L (V8) FSI engine)
№ A Function/component
J671 - Radiator fan control unit 2
1 60
V177 - Radiator fan 2
60 (Only models with towing
J293 - Radiator fan control unit
2 coupling)
V7 - Radiator fan
30
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
J299 - Secondary air pump relay V101 - Secondary air
3 40
pump motor
4 - Not assigned
5 - Not assigned
6 - Not assigned
N70 - Ignition coil 1 with output stage
N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
N292 - Ignition coil 4 with output stage
7 20
N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
N325 - Ignition coil 7 with output stage
N326 - Ignition coil 8 with output stage
8 - Not assigned
9 30 J623 - Engine control unit
G70 - Air mass meter
G246 - Air mass meter 2
10 10 J299 - Secondary air pump relay
N80 - Activated charcoal filter solenoid valve 1
V144 - Fuel system diagnostic pump
11 - Not assigned
F265 - Map-controlled engine cooling system
thermostat
G65 - High-pressure sender
J151 - Continued coolant circulation relay
J255 - Climatronic control unit
J301 - Air conditioning system control unit
J293 - Radiator fan control unit
J442 - Alternator cut-in relay (Up to May 2007)
12 20
J671 - Radiator fan control unit 2
N205 - Inlet camshaft control valve 1
N208 - Inlet camshaft control valve 2
N280 - Air conditioner compressor regulating valve
N318 - Exhaust camshaft control valve 1
N319 - Exhaust camshaft control valve 2
V157 - Intake manifold flap motor
V183 - Variable intake manifold motor
13 25 J538 - Fuel pump control unit
N290 - Fuel metering valve
14 10
N402 - Fuel metering valve 2
J271 - Motronic current supply relay
15 10
J623 - Engine control unit
J569 - Brake servo relay
16 15
V192 - Vacuum pump for brakes
G39 - Lambda probe
17 10
G108 - Lambda probe 2
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
G130 - Lambda probe after catalytic converter
18 10
G131 - Lambda probe 2 after catalytic converter

Relays
A1 Not assigned
A2 Not assigned
A3 Automatic glow period control unit -J179- (475)
Secondary air pump relay -J299- (100) / (370) optional
A4
installation
A5 Continued coolant circulation relay -J151- (404)
A6 Not assigned
B1 Not assigned
B2 Not assigned
B3 Not assigned
B3 Not assigned
B4 Engine components current supply relay -J757- (614)
B5 Not assigned
Brake servo relay -J569- (404) (Only models with
B6
automatic gearbox)
C19 Not assigned
C20 Terminal 50 voltage supply relay -J682- (433)

Advertisements

Engine compartment (6.0L (W12) petrol engine)

 TOUAREG 2006-2010 – FUSE LAYOUT
Assignment of the fuses in the Engine compartment (6.0L (W12) petrol engine)
№ A Function/component
J671 - Radiator fan control unit 2
1 60
V177 - Radiator fan 2
60 (Only models with towing
J293 - Radiator fan control unit
2 coupling)
V7 - Radiator fan
30
J299 - Secondary air pump relay
3 40
V101 - Secondary air pump motor
J545 - Secondary air pump relay 2
4 40
V189 - Secondary air pump motor 2
N325 - Ignition coil 7 with output stage
N326 - Ignition coil 8 with output stage
N327 - Ignition coil 9 with output stage
5 30 N328 - Ignition coil 10 with output stage
N329 - Ignition coil 11 with output stage
N330 - Ignition coil 12 with output stage
S7 - Fuse in relay plate fuse holder
N70 - Ignition coil 1 with output stage
N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
6 30 N292 - Ignition coil 4 with output stage
N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
S8 - Fuse in relay plate fuse holder
N85 - Injector, cylinder 7
N86 - Injector, cylinder 8
N299 - Injector, cylinder 9
7 10
N300 - Injector, cylinder 10
N301 - Injector, cylinder 11
N302 - Injector, cylinder 12
N30 - Injector, cylinder 1
N31 - Injector, cylinder 2
N32 - Injector, cylinder 3
8 10
N33 - Injector, cylinder 4
N83 - Injector, cylinder 5
N84 - Injector, cylinder 6
J623 - Engine control unit
9 30
J624 - Engine control unit 2
G65 - High-pressure sender
J255 - Climatronic control unit
J293 - Radiator fan control unit
10 10 J301 - Air conditioning system control unit
J442 - Alternator cut-in relay (Up to May 2007)
J671 - Radiator fan control unit 2
V144 - Fuel system diagnostic pump
N80 - Activated charcoal filter solenoid valve 1
11 15
N205 - Inlet camshaft control valve 1
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
N208 - Inlet camshaft control valve 2
N280 - Air conditioner compressor regulating valve
N318 - Exhaust camshaft control valve 1
N319 - Exhaust camshaft control valve 2
J49 - Electric fuel pump 2 relay
J299 - Secondary air pump relay
12 5
J545 - Secondary air pump relay 2
J624 - Engine control unit 2
G6 - Fuel system pressurisation pump
13 15
J17 - Fuel pump relay
G23 - Fuel pump
14 15
J49 - Electric fuel pump 2 relay
J17 - Fuel pump relay
J271 - Motronic current supply relay
15 10
J623 - Engine control unit
J624 - Engine control unit 2
J496 - Additional coolant pump relay
J569 - Brake servo relay
16 15
V51 - Continued coolant circulation pump
V192 - Vacuum pump for brakes
G39 - Lambda probe
G108 - Lambda probe 2
G285 - Lambda probe 3
G286 - Lambda probe 4
17 30
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
Z62 - Lambda probe heater 3
Z63 - Lambda probe heater 4
G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
G287 - Lambda probe 3 after catalytic converter
G288 - Lambda probe 4 after catalytic converter
18 15
Z29 - Lambda probe 1 heater after catalytic converter
Z30 - Lambda probe 2 heater after catalytic converter
Z64 - Lambda probe 3 heater after catalytic converter
Z65 - Lambda probe 4 heater after catalytic converter

Relays
A1 Not assigned
A2 Not assigned
Motronic current supply relay -J271- (100) / (370)
A3
optional installation
Secondary air pump relay -J299- (100) / (370) optional
A4
installation
A5 Additional coolant pump relay -J496- (404)
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
A6 Electric fuel pump 2 relay -J49- (404)
B1 Not assigned
B2 Not assigned
B3 Not assigned
Secondary air pump relay 2 -J545- (100) / (370)
B3
optional installation
B4 Not assigned
B5 Not assigned
Brake servo relay -J569- (404) (Only models with
B6
automatic gearbox)
C19 Fuel pump relay -J17- (404)
C20 Terminal 50 voltage supply relay -J682- (433)

Pre-fuse box

Pre-fuse box (under driver seat)

№ A Function/component
SD1 150 Left fuse carrier
SD2 150 Right fuse carrier
SD3 60 Right fuse carrier
 TOUAREG 2006-2010 – FUSE LAYOUT

№ A Function/component
60 J701 - Voltage supply relay 2 (Only V10 TDI)
SD4 40 (From November V306 - Motor for rear Bitron blower regulation (From
2007) November 2007)
60
SD5 40 (From November J329 - Terminal 15 voltage supply relay
2007)
SD6 - Not assigned
SD7 250 J713 - Charger relay for second battery
150 (Only V10 TDI)
Left fuse carrier
SD8 60 (Only models with
J701 - Voltage supply relay 1 (Only V10 TDI)
additional battery)
SD9 5 J519 - Onboard supply control unit
10
SD10 J519 - Onboard supply control unit (Only V10 TDI)
5 (From November 2007)
SD11 5 J519 - Onboard supply control unit (Only V10 TDI)
SD12 - Not assigned
J403 - Adaptive suspension compressor relay
SD13 40 V306 - Motor for rear Bitron blower regulation (Only
V10 TDI) (From November 2007)
SD14 - Not assigned

Relays
1 Battery master/isolator switch -E74-
2 Terminal 15 voltage supply relay -J329- (433)
3 Second battery charging circuit relay -J713-

Relay panel E-Box 1

 TOUAREG 2006-2010 – FUSE LAYOUT
Relay panel E-Box 1 (on left under dash panel near center console)
№ Function/component
D1 Servotronic control unit -J236- (476)
D2 Power latching system relay -J714- (404)
D3 Adaptive suspension compressor relay -J403- (373)
D4 Power sockets relay -J807- (404)
D5 Air conditioning system relay -J32- (100) / (370) optional installation
Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning
D6
system
D7 Heated rear window relay -J9- (53)
D8 Circulation pump relay -J160- (404), only VR6 with auxiliary heater
D9 Alternator cut-in relay -J442- (53)
E1 Solar cells isolation relay -J309- (79)
E2 Not assigned
E3 Heated windscreen relay for left side -J410- (53)
E4 Not assigned
E5 Voltage supply relay 2 -J710- (432), only V10 TDI
E6 Not assigned
E7 Headlight washer system relay -J39- (53)
E8 Residual heat relay -J708- (404)
E9 Heated windscreen relay for right side -J411- (53)

Relay panel E-box 2

 TOUAREG 2006-2010 – FUSE LAYOUT
Relay panel E-box 2 (on right under dash panel, near right a-pillar)
№ Function/component
D1 Servotronic control unit -J236- (476)
D2 Power latching system relay -J714- (404)
D3 Adaptive suspension compressor relay -J403- (373)
D4 Power sockets relay -J807- (404)
D5 Air conditioning system relay -J32- (100) / (370) optional installation
Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning
D6
system
D7 Heated rear window relay -J9- (53)
D8 Circulation pump relay -J160- (404), only VR6 with auxiliary heater
D9 Alternator cut-in relay -J442- (53)
E1 Solar cells isolation relay -J309- (79)
E2 Residual heat relay -J708- (404)
E3 Heated windscreen relay for left side -J410- (53)
E4 Voltage supply relay 2 -J710- (432), only V10 TDI
E5 Heated windscreen relay for right side -J411- (53)
E6 Headlight washer system relay -J39- (53)