HCD-RG11

SERVICE MANUAL AEP Model

UK Model
Ver 1.0 2002. 06

• HCD-RG11 is the tuner, deck, CD and

amplifier section in MHC-RG11.

Model Name Using Similar Mechanism HCD-RG20

CD
CD Mechanism Type CDM58F-K6
Section
Optical Pick-up Name KSM-213DCP/Z-NP
Tape deck Model Name Using Similar Mechanism HCD-RG20
Section Tape Transport Mechanism Type CWL44FF29

SPECIFICATIONS
Amplifier section Tuner section
DIN power output (rated) 40 + 40 watts FM stereo, FM/AM superheterodyne tuner
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference) FM tuner section
50 + 50 watts (6 ohms at 1
kHz, 10% THD) Tuning range 87.5 – 108.0 MHz
Music power output (reference) Antenna FM lead antenna
95 + 95 watts (6 ohms Antenna terminals 75 ohm unbalanced
at 1 kHz, 10% THD) Intermediate frequency 10.7 MHz
Inputs
GAME (AUDIO) IN (phono jack): AM tuner section
voltage 450 mV, Tuning range 531 – 1,602 kHz (with the
impedance 47 kilohms interval set at 9 kHz)
Outputs Antenna AM loop antenna
PHONES (stereo mini jack): Antenna terminals External antenna terminal
accepts headphones of Intermediate frequency 450 kHz
8 ohms or more
Front speaker: accepts impedance of 6 to
16 ohms General
Power requirements 230 V AC, 50/60 Hz
CD player section Power consumption 85 watts
1.0 watts (at the Power
System Compact disc and digital Saving Mode)
audio system Dimensions (w/h/d) Approx. 280 × 325 × 421 mm
Laser Semiconductor laser Mass Approx. 8.1 kg
(λ=780 nm)
Emission duration:
continuous Design and specifications are subject to change
Frequency response 2 Hz – 20 kHz (±0.5 dB) without notice.
Wavelength 780 – 790 nm
Signal-to-noise ratio More than 90 dB
Dynamic range More than 90 dB

Tape deck section

Recording system 4-track 2-channel stereo
Frequency response 40 – 13,000 Hz (±3 dB),
using Sony TYPE I
cassette

MINI HIFI COMPONENT SYSTEM

9-874-039-01 Sony Corporation
2002F1600-1 Home Audio Company
© 2002.06 Published by Sony Engineering Corporation
HCD-RG11

NOTES ON HANDLING THE OPTICAL PICK-UP TABLE OF CONTENTS

BLOCK OR BASE UNIT 1. GENERAL ·········································································· 3
The laser diode in the optical pick-up block may suffer electrostatic
2. DISASSEMBLY ································································ 5
break-down because of the potential difference generated by the
2-1. Case (Top) ····································································· 5
charged electrostatic load, etc. on clothing and the human body.
2-2. CD Door ········································································ 6
During repair, pay attention to electrostatic break-down and also
2-3. Front Panel Section and
use the procedure in the printed matter which is included in the
CD Mechanism Deck (CDM58F-K6) Section ·············· 6
repair parts.
2-4. Tape Mechanism Deck And PANEL Board ·················· 7
The flexible board is easily damaged and should be handled with
2-5. SUB TRANS Board, VIDEO OUT Board and
care.
TRANS Board ······························································· 7
2-6. MAIN Board and POWER Board ································· 8
NOTES ON LASER DIODE EMISSION CHECK
2-7. Base Unit ······································································· 8
2-8. CD Board, DRIVER Board, MOTOR Board and
The laser beam on this model is concentrated so as to be focused on
ADDRESS SENSOR Board ·········································· 9
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
3. TEST MODE ···································································· 10

Laser component in this product is capable 4. ELECTRICAL ADJUSTMENTS ······························· 12

of emitting radiation exceeding the limit for
Class 1. 5. DIAGRAMS ······································································ 14
5-1. Circuit Board Location ················································ 14
5-2. Block Diagrams ··························································· 15
5-3. Printed Wiring Board – CD Section – ························ 17
5-4. Schematic Diagram – CD Section – ··························· 18
5-5. Printed Wiring Board – MAIN Board – ····················· 19
5-6. Schematic Diagram – MAIN Board (1/4) – ··············· 20
5-7. Schematic Diagram – MAIN Board (2/4) – ··············· 21
5-8. Schematic Diagram – MAIN Board (3/4) – ··············· 22
This appliance is classified as a CLASS 1 LASER product. The 5-9. Schematic Diagram – MAIN Board (4/4) – ··············· 23
CLASS 1 LASER PRODUCT MARKING is located on the rear 5-10. Printed Wiring Board
exterior. – Address Sensor, Driver Motor Section – ·················· 24
5-11. Printed Wiring Board – Panel Section – ····················· 25
CAUTION 5-12. Schematic Diagram – Panel Section – ······················· 26
Use of controls or adjustments or performance of procedures 5-13. Printed Wiring Board – POWER Board – ·················· 27
other than those specified herein may result in hazardous radiation 5-14. Printed Wiring Board – Trans Section – ····················· 28
exposure. 5-15. Schematic Diagram – Trans Section – ······················· 29
5-16. IC Block Diagrams ······················································ 30
Notes on chip component replacement 5-17. IC Pin Function Description ········································ 32
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be 6. EXPLODED VIEWS ······················································ 34
damaged by heat. 6-1. MAIN SECTION ························································ 34
6-2. FRONT PANEL SECTION ········································· 35
Flexible Circuit Board Repairing 6-3. MAIN BOARD SECTION ·········································· 36
• Keep the temperature of soldering iron around 270˚C 6-4. CD MECHANISM DECK SECTION ························ 37
during repairing.
• Do not touch the soldering iron on the same conductor of the 7. ELECTRICAL PARTS LIST ······································· 38
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH

MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.

2
 HCD-RG11
SECTION 1
GENERAL This section is extracted
from instruction manual.

Main unit

1 2 3 45 6 7

wk 8
wj
wh
wg 9
wf
wd
q;

qa
ws
qs

waw;ql qk qj qh qg qf qd

AUDIO jacks wd (19) GAME EQ ql (17, 18, 20) BUTTON DESCRIPTIONS

CD wk (10 – 12, 15) GROOVE 8 (17)
CD SYNC qh (15) MOVIE EQ 7 (17) ?/1 (power) 1
Deck A ws (14) MUSIC EQ 2 (17) Z OPEN/CLOSE 6
Deck B qs (14 – 16) PHONES jack q; Z (deck B) qa
DISC 1 – 3 4 (10, 11) REC PAUSE/START qg (15) M (fast forward) qf
DISC SKIP EX-CHANGE 3 TAPE A/B wh (14, 15) . (go back) qj
(10, 11) TUNER/BAND wj (12, 13, 15) > (go forward) qj
Disc tray 5 (10) VIDEO jack wf (19, 20) X (pause) qj
DISPLAY w; (12) VOLUME control 9 H (play) qj
EFFECT ON/OFF qd x (stop) qj
(17) m (rewind) qk
GAME wg (18 – 20) Z (deck A) wa

3
HCD-RG11

Remote Control

12 3 4

5
6
wa
7
w; 8
ql 9
qk 0
qj qa
qh qs
qg qd

qf

CD ql (10 – 12, 15) ON/OFF qh (17) BUTTON DESCRIPTIONS

CLEAR w; (11) PLAY MODE wa (10, 11)
CLOCK/TIMER SELECT 2 PRESET +/– 5 (13) ?/1 (power) 4
(16, 19) REPEAT 8 (11) M (fast forward) 5
CLOCK/TIMER SET 3 (9, 16, SLEEP 1 (18) . (go back) 5
18) STEREO/MONO 8 (13) > (go forward) 5
DISPLAY 6 (12) SURROUND qa (17) X (pause) 5
D.SKIP 7 (10) TAPE A/B 9 (14, 15) N (play) 5
ENTER qg (9, 11 – 13, 16, 18, TUNER MEMORY qj (12, 13) m (rewind) 5
19) TUNER/BAND qk (12, 13) x (stop) 5
EQ +/– qf (17) TUNING +/– 5 (12, 13)
GAME q; (18 – 20) VOL +/– qs
GROOVE qd (17)

Setting the time

1 Press ?/1 to turn on the system. 6 Press ENTER on the remote.
2 Press CLOCK/TIMER SET on the The minute indication flashes.
remote. 7 Press . or > repeatedly to set the
Proceed to step 5 when “CLOCK” appears minute.
in the display.
8 Press ENTER on the remote.
3 Press . or > repeatedly to select Tip
“SET CLOCK”.
If you made a mistake or want to change the time,
4 Press ENTER on the remote. start over from step 2.

5 Press . or > repeatedly to set the Note

The clock settings are canceled when you disconnect
hour.
the power cord or if a power failure occurs.

4
 HCD-RG11
SECTION 2
DISASSEMBLY
Note : Disassemble the unit in the order as shown below.

SET

CASE (TOP)

CD DOOR

FRONT PANEL SECTION AND CD MECHANISM CD BOARD, DRIVER BOARD, MOTOR BOARD AND
DECK (CDM58F-K6) SECTION BASE UNIT ADDRESS SENSOR BOARD

PANEL BOARD

TAPE MECHANISM DECK AND PANEL BOARD

CD BOARD

SUB TRANS BOARD, VIDEO OUT BOARD AND TRANS BOARD

MAIN BOARD AND POWER BOARD

Note : Follow the disassembly procedure in the numerical order given.

2-1. Case (Top)

9 four screws (+BVTP 3 × 6)

q;

case (Top)

5 two screws (Case 3 TP2) qa

q;
7 two screws
(+BVTP 3 × 10)

case (Side-R)
4
case (Side-L)

6 screw (Case 3 TP2)

3 two screws
(+BVTP 3 × 10)

1 two screws (Case 3 TP2)

2 screw (Case 3 TP2)

5
HCD-RG11

2-2. CD Door
CD door

CD mechanism deck (CDM58F-K6)

1 Turn the pulley to the direction of arrow.

Front panel side

pulley 3

2 Pull-out the disc tray.

2-3. Front Panel Section and CD Mechanism Deck (CDM58F-K6) Section

CD mechanism deck
(CDM58F-K6)
5
q; connector
(CN605)

2 flat type wire (19 core) 1 connector

(CN704)

4 screw (+BVTP 3 × 10)

6 connector (CN201)
7 connector (CN202)
9 screw
(+BVTP 3 × 10)

qd

qs
3 screw
(+BVTP 3 × 10)

8 connector (CN203)

front panel section

qa three screws (+BVTP 3 × 10)

6
 HCD-RG11

2-4. Tape Mechanism Deck And PANEL Board

8 six screws
(+BVTP 2.6 × 8)

9 five screws
(+BVTP 2.6 × 8)

q; eight screws
qa PANEL board (+BVTP 2.6 × 8)

1 flat type wire (17 core)

2 six screws 4 belt (BF)
5 belt (AF)
(+BVTP 2.6 × 8)

6 belt (FR)

7 volume knob
3 tape mechanism deck

2-5. SUB TRANS Board, VIDEO OUT Board and TRANS Board

7 cover (duct)
6
q; screw
(+BVTP 3 × 10)
5 two screws
qg four screws (+BVTP 3 × 10)
(+BVTT 4 × 6)
qa VIDEO OUT board
TRANS board qs five screws
(+BVTP 3 × 10)
1 connector (CN901)
2 connector (CN2)

qf connector (CN915)
3 connector
(CN903)
qh power transformer (T911) 9 SUB TRANS
board qd back panel
4 connector (CN504) 8 two screws
(+BVTP 3 × 10)

7
HCD-RG11

2-6. MAIN Board and POWER Board

9 heat sink
6 three screws (+BVTP 3 × 8)
8 two screws (+BVTP 3 × 8)

MAIN board

3
2
7 POWER board

5 two screws (+BVTP 3 × 16)

4 MAIN board

1 two screws (+BVTP 3 × 10)

2-7. Base Unit

4 Turn the pulley to the direction of arrow.

1 pulley (B), chucking

2 two screws (+PTPWH M2.6)

pulley

3 lever (lifter)

6 screw
(+PTPWH M2.6)
7 holder (BU) assy qf two spring (insulator), coils
qs

Base unit
5 flat type wire (16 core) qd two insulators
qf spring (insulator),
coil
qa screw (DIA. 12)
qd two insulators

9 two stoppers (BU) spring q; two screws

(insulator), (+PTPWH M2.6)
coil

8 two screws (+BVTP 2.6 × 8)

8
 HCD-RG11

2-8. CD Board, DRIVER Board, MOTOR Board and ADDRESS SENSOR Board

q; screw (+PTPWH 2.6 × 8)

8 MOTOR board 4 two screws (+BVTP 2.6 × 8)

6 flat type wire (8 core)

5 Remove two solderings of turn motor (M721).

qs screw (+BVTP 2.6 × 8)
qa tray 7 connector
3 flat type wire qd ADDRESS SENSOR board
(8 core)

2 DRIVER board

1 screw (+BVTP 2.6 × 8)

9 Pull-out the Table.

qf flat type wire (16 core)

qh CD board

qg four screws
(+BVTP 2.6 × 8)

9
HCD-RG11
SECTION 3
TEST MODE
[Cold Reset] 3. Aging mode in Tape Deck section
• The cold reset clears all data including preset data stored in the 1) Operation during aging mode
RAM to initial conditions. Execute this mode when returning • In the agining mode, the program is excuted in the following
the set to the customer. sequence.
Step Operation Display
Procedure: 1 Rewind the TAPE A TAPE AAG-1
1. Press three buttons x , DISPLAY , and ?/1 simultaneously.
2 Rewind the TAPE B TAPE BAG-2
2. The fluorescent indicator tube displays “COLD RESET” and
the set is reset. 3 Play the TAPE A (1 minute) TAPE AAG-2
4 Stop the TAPE A (1 second) TAPE AAG-3
[Aging Mode] 5 Play the TAPE A (3 minutes) TAPE AAG-4
This mode can be used for operation check of CD section and tape 6 Rewind(AMS) the TAPE A TAPE AAG-5
deck section. 7 F.F.(AMS) the TAPE A TAPE AAG-6
• If an error occurred:
8 Play the TAPE B (1 minute) TAPE BAG-2
The aging operation stops and is displayed status.
9 Stop the TAPE B (1 second) TAPE BAG-3
• If no error occurs:
The aging operation continues repeatedly. 10 Record the TAPE B (3 minutes) TAPE BAG-4
11 Rewind(AMS) the TAPE B TAPE BAG-5
1. Operating method of Aging Mode 12 F.F.(AMS) the TAPE B TAPE BAG-6
Turn on the main power and select “CD” of the function.
1) Set three discs in tray. Select ALL DISCS, and REPEAT OFF. 2) Error display
2) Load the tapes recording use into both decks. • If error occurred, the display remains like “TAPE BAG-2”.
3) Press three buttons x , DISPLAY , and
DISC SKIP EX-CHANGE simultaneously. 4. Exiting from the aging mode
4) Aging operations of CD and tape are started at the same time. • Be sure to perform Cold Reset to exit from the aging mode.
5) To exit the aging mode, perform [Cold Reset].

2. Aging mode in CD section

1) Operation during aging mode
• In the agining mode ,the program is excuted in the following
sequence.
(1) The disc tray opens and closes.
(2) The disc tray turns to select a disc 3.
(3) The pickup accesses to the first track, and plays 3 seconds.
(4) The pickup accesses to the last track, and plays 3 seconds.
(5) The disc tray opens and closes.
(6) The disc tray turns to select a disc 1.
(7) The same operation starts like step (3).
(8) After a disc 1 aging operation, a disc 2 is selected.
(9) When an aging operation of a disc 3 is completed, the display
“AGING ∗∗∗∗” value increases.
(10) If no error occurs, the aging operation continues repeatedly.

2) Error display
Disc error
Display Error
E00D01022 Focus error (No disc)
E00D02022 Sub Q error (Focus is good)
E00D02023 TOC reading error
E00D02014 Access error (Unable within regular time)

Mechanism error
Display Error
E00M__E_0 Error during opening tray
E00M__C_2 EX-CHANGE disc error
E00M__D_0 Error during closing tray
E00M__F_3 EX-OPEN error
E00M__D_5 EX-CLOSE error
E00M__C_2 Chuck-up error
E00M__C_3 Unchucking error

10
 HCD-RG11

[FL Tube Test Mode] [VACS ON/OFF Mode]

• All fluorecent segments and LEDs are tested. • This mode is used to switch ON and OFF the VACS (Variable
Attenuation Control System).
Procedure:
1. Press ?/1 button to turn the set ON. Procedure:
2. To enter the test mode, press the three buttons x , DISPLAY 1. Press ?/1 button to turn the set ON.
and GROOVE simultaneously. 2. To enter the test mode, press the three buttons x , DISPLAY
3. Press DISPLAY and DISC SKIP/EX-CHANGE buttons and GROOVE simultaneously.
simultaneously. 3. Press CD SYNC button while pressing DISPLAY button.
4. All segments and LEDs (without STANDBY LED) are turned The message “VACS OFF” or “VACS ON” appears.
on. 4. To exit from this mode, press ?/1 button to turn the set OFF.
5. To exit from this mode, press ?/1 button to turn the set OFF.
[Equalizer Test Mode]
[Version and Destination Display Mode] • This mode is used to test the function of the equalizer.
• The version or destination is displayed.
Procedure:
Procedure: 1. Press ?/1 button to turn the set ON.
1. Press ?/1 button to turn the set ON. 2. To enter the test mode, press the three buttons x , DISPLAY
2. To enter the test mode, press the three buttons x , DISPLAY and GROOVE simultaneously.
and GROOVE simultaneously. 3. Press m – button while pressing DISPLAY button. The message
3. Press DISPLAY and DISC 1 buttons simultaneously. “BASS + 0” is displayed.
4. The version is displayed. 4. The value increases like + 2, + 4 ... if pressing > button
5. Press DISPLAY and DISC 2 buttons simultaneously. while DISPLAY button is still depressed, or it decreases like -
6. The destination is displayed. 2, - 4 ... if pressing . button.
7. To exit from this mode, press ?/1 button to turn the set OFF. 5. Press M + button while pressing DISPLAY button. The message
“TRE + 0” is displayed.
[Key Check Mode] 6. The value increases like + 2, + 4 ... if pressing > button
• Keyboard check. while DISPLAY button is still depressed, or it decreases like
- 2, - 4 ... if pressing . button.
Procedure: 7. To exit from this mode, press ?/1 button to turn the set OFF.
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , DISPLAY [CD Ship Mode (No Memory Clear) ]
and GROOVE simultaneously. • This mode moves the pickup to the position durable to vibra-
3. Press DISPLAY and DISC 3 buttons simultaneously, and the tion. Use this mode when returning the set to the customer after
key check mode is activated. repair.
4. In the key check mode, the fluorecent indicator displays “KEY
0 VOL 0”. Each time a button is pressed, “KEY 0” value Procedure:
increases. However, once a button is pressed, it is no longer 1. Press ?/1 button to turn the set ON.
taken into account. 2. Press CD button and ?/1 button simultaneously.
“VOL 0” value increases like 1, 2, 3 ... if rotating VOLUME 3. The "STANDBY" display blinks instantaneously, and the CD
knob clockwise, or it decreases like 0, 9, 8, ... if rotating counter- ship mode is set.
clockwise.
5. To exit from this mode, press ?/1 button to turn the set OFF.

[CD Service Mode]

• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pickup.

Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. To enter the test mode, press three buttons x , DISPLAY , and
GROOVE simultaneously.
4. Press DISPLAY and OPEN/CLOSE buttons simultaneously.
5. The CD service mode is selected.
6. With the CD in stop status, press M + button to move the pickup
to outside track, or press m
– button to inside track.
7. To exit from this mode, perform as follows:
1) Move the pickup to the most inside track.
2) Press ?/1 button to turn the set OFF.
Note: • Always move the pickup to most inside track when exiting from
this mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can be
chipped.

11
HCD-RG11
SECTION 4
ELECTRICAL ADJUSTMENTS

TUNER SECTION AM IF Adjustment

FM Tuned Level Adjustment

FM RF Signal generator AM RF Signal generator

75 Ω coaxial

set set
Carrier frequency : 98 MHz 30% amplitude
Modulation : AUDIO 1 kHz, 75 kHz modulation by AM ANTENNA terminal
FM ANTENNA terminal
deviation (100%) 400Hz signal (JK101)
(JK101)
Output level : 30 dB (at 75 Ω open) output level : as low as possible

Procedure:
1. Supply a 98 MHz signal at 28 dB from the ANTENNA terminal.
2. Tune the set to 98 MHz. level meter
3. Adjust RV101 to the point (moment) when the TUNED
16 Ω
indicator will change from going off to going on.
set
Adjustment Location: MAIN board

Null Adjustment headphones jack (JK601)

FM RF Signal generator
75 Ω coaxial
Procedure:
1. Set the frequency of the AM RF signal generator to 1000 kHz
(at 10 kHz step) or 999 kHz (at 9 kHz step).
set 2. Tune the set to AM 1000 kHz (at 10 kHz step) or 999 kHz (at 9
Carrier frequency : 98 MHz kHz step).
Modulation : AUDIO 1 kHz, 75 kHz FM ANTENNA terminal 3. Adjust IFT101 so that the reading on level meter becomes in
deviation (100%) (JK101) maximum.
Output level : 60 dB (at 75 Ω open)

Procedure:
1. Supply a 98 MHz signal at 60 dB from the ANTENNA terminal.
2. Tune the set to 98 MHz.
3. Measure voltage between pin 21 and pin 23 of IC 101. Adjust
T101 until the voltage becomes 0 V.

Adjustment Location: MAIN board

[MAIN BOARD] Component side

T101:NULL

RV101:FM TUNED LEVEL

T101

RV101

IFT101 : AM IF

12
 HCD-RG11

CD SECTION
Note :
1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10MΩ impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.

RF Level Check

oscilloscope
CD board

IC751 pin q;
GND

Procedure :
1. Connect oscilloscope to pin q; (IC751).
2. Turned Power switch on.
3. Load a disc (YEDS-18) and playback.
4. Confirm that oscilloscope waveform is clear and check RF signal
level is correct or not.

Note : Clear RF signal waveform means that the shape “ ◊ ” can be clearly
distinguished at the center of the waveform.

RF signal waveform
VOLT/DIV : 200mV
TIME/DIV : 500ns

level : 1.4 to 2.1 Vp-p

Adjustment Location: CD board

[CD BOARD] (Component Side)

CN732

CN731 CN733

TP connected to pin q; (IC751)

C746A

13
HCD-RG11
SECTION 5
DIAGRAMS

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)

Note on Schematic Diagram: Note on Printed Wiring Boards:

• All capacitors are in µF unless otherwise noted. pF: µµF • X : parts extracted from the component side.
50 WV or less are not indicated except for electrolytics • b : Pattern from the side which enables seeing.
and tantalums. • Indication of transistor.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified. C
• f : internal component.
• C : panel designation. These are omitted. Q
B E
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
Q
• A : B+ Line.
• B : B– Line. B C E
• H : adjustment for repair.
• Voltages and waveforms are dc with respect to ground These are omitted.
under no-signal (detuned) conditions.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal produc-
tion tolerances.
no mark : FM
< > : CD
[ ] : TAPE
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal produc-
tion tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
E : PB (DECK A)
d : PB (DECK B)
G : REC (DECK B)
J : CD

5-1. Circuit Board Location

MOTOR board

ADDRESS SENSOR board

VIDEO OUT board

DRIVER board
SPDL board

TRANS board CD board

PANEL board SUB TRANS board

MAIN board

POWER board

14
 HCD-RG11
5-2. Block Diagrams
– Tuner/CD Section –
AM/FM IF MPX
Q101 IC101
CF101 RF IF CF102 L-CH • R-CH is omitted due to same as L-CH
AMP
1 FM IF L OUT 11 A • Signal Path
Q106 MAIN
R OUT 10 R-CH SECTION : FM
Q102 MUTE
+B TU+12V : CD
AM IF IN 18
IFT101
PLL
IC102 DO,CLK
AM MIX OUT 19 AM IF C
10 FM FM/AM IF 12 9 IF OUT
MAIN
FM 7 12 AM/IF FM SD ADJ 3 SECTION
RV101
1 XIN AM OSC 14 24 AM OSC
CX101 FM TUNED
VCO STOP 2 13 VCO STOP LEVEL
JK101 FND1 4.5MHz
24 XOUT IF REQ 8 8 IF REQ MUTE
1 ANT IN IF OUT 7
DI
FM 75Ω OSC OUT 8 15 FM OSC DO 6
DO +6.8V
VT 5 18 VT1 IN DI 4
CLK T101
17 VT1 CL 5
CE NULL
G 19 PD1 CE 3
FMDET 5

AM 20 AM RF IN MASTER CONTROL
RB101 13 14 IC601(1/2)
1 4 11 15 9
22 AM OSC TUNED 6 10 TUNED
5
STEREO 7 9 TU STEREO
3 6 7
23 V REG

77 TUNER MUTE OUT

2 12
DO
95 LC72131 BU2114 DO
DI
96 LC72131 DI
CLK
OPTICAL PICK-UP 97 CLK
BLOCK CE
93 LC72131 CE
(KSM-213-DCP/Z-NP)
ASP DSP
DETECTOR IC731 IC751

VCC +5V
CD-L
VC 58 VR RF SM 41 10 EFMI L CH 37 B
A 9 EFMO MAIN
2 FIN 1 SLI 44 R CH 40 R CH SECTION
B Q771,773
1 FIN 2 DEF 49 1 DEF
D733
C L MUTE 35 MUTE
TES 36 16 TES
D D735
HFL 37 15 HFL
E 3 E 6 CD A MUTE
F 4 F JP+ 33 19 JP+
JP- 32 20 JP- WRQE 53 7 CD WRQ
Q731
SQ0UT 55 99 SQOUT
LD LD CV+ 40 12 CLV+
DRIVER 62 LDD
CV- 39 13 CLV- IC701

CD MOTOR + 73 9 4
GND TOFF 35 17 TOFF MOTOR M721
M TURN
DRIVE MOTOR
CD MOTOR- 74 7 2
SLOF 38 14 VP XI 45
X701
DATA 52 56 COIN 16.9344M
PD XO 44
63 LDS CLK 50 61 4.2M
VR IC711
FCS/TRK COIL CL 51 57 CQCK
SL/SP MOTOR TBL ADDRESS
CE 53 54 RWC CD NUMBER SENSOR 68
DRIVER SENSOR
IC781
F+ TGL 34 18 TGL
1 CH1 OUTA
FOCUS DRF 54 RESET 58 3 CD RESET OUT
CH1 INA 3 16 FD
COIL F
2 CH1 OUTB CD TRAY OPEN SW 70 S701
CH1 INB 4 28 SHUTER IN/OUT OPEN/CLOSE
CD TRAY CLOSE SW 71
T+ 26 D MUTE
27 CH4 OUTA
TRACKING PDO 3
CH4 INA 25 15 TO S711
COIL T 27 LIMIT SW CD PIC UP/DOWN SW 69 BU UP/
26 CH4 OUTB D732 DOWN

98 COIN
100 SQCK
11 CH21 OUTB
2 CD RWC
SLED M CH2 INB 9 29 SLD
MOTOR
12 CH2 OUTA 8 CD DRF

18 CH3 OUTB SL+ 31 5 CD SL+

SPINDLE M CH3 INB 20 27 SPD SL- 30 4 CD SL-
MOTOR
17 CH3 OUTA
MUTE 7

Q775

S01
LIMIT

15 15
HCD-RG11
– Main Section –

AUDIO SOUND
PROCESSOR
IC301
IC501 JK310
TUNER L-CH
SECTION A 7 B1
OUT1 17 1 POWER 6 L
AMP Q308,309 SPEAKER
Q314,315 RL1
CD LOUT OUT2 16 R-CH PROTECT R CH R
SECTION B 5 A1 Q803,804 Q316
12 DETECTOR RELAY
DRIVE
MUTE
MUTE
CONT Q503,504 Q581 Q501 Q311 Q312
TUNER DO,CLK CLK D502 R CH
SECTION C 13 SC MUTE
CONT
MUTE
OVER LOAD
DETECTOR
PROTECT
CONT
PROTECT
SWITCH
JK601
PHONES

JK602 D311
VIDEO
OUT

JK603

VIDEO

GAME INPUT L 9 C1 Q303

SEL1 4
AUDIO
14 SI MN1 1 BUFFER
R R-CH

Q305 Q306
• R-CH is omitted due to same as L-CH
MUTE
MUTE • Signal Path
PB/REQ EQ AMP CONT
DECK-A : PB (DECK A)
IC201

1 CH1/A PRE OUT 5

Q215 : PB (DECK B)
PB
HEAD IC602
MUTE LED602-609
DO : REC (DECK B)
R-CH 1 LED
CLK 16
2 DRIVER
13 : FM
DECK-B
3
2 CH1/B
Q201 : CD

REC/PB MUTE
HEAD
9 REC OUT REC IN 11
R-CH L251 Q207
3
BIAS
MUTE IC302
R-CH
1
Q320,321
BIAS MIX OUT 6 AMS
ERASE
OSC
HEAD
Q214
TAPE A/B 19

Q210,213
BIAS
Q203,205 Q209 SWITCH Q211,212
PLAY/REC PLAY/REC
SWITCH
CONTROL SWITCH
MECHA DECK
A MODE Q911 T911
B MODE -30V MAIN TRANS
-VP
A HALF REG
B HALF
REC(FWD) Q801,802
+5V CD POWER
CD +5V 3 1 D541
A PHOTO REG SWITCH
SENSOR IC804
+B
POWER
B PHOTO AMP
FAN +B -B
SENSOR
JW6
D801-804
28 27 67 26 25 66 65 86 88 91 24 87 79 94 22 76 78 75 92 1 LED +5.6V IC803
Q604,607 +5V
PHOTO SENSOR A

STK MUTE
TAPE FWD REC SW B

BU2114 LATCH

CD ON/OFF
TAPE REC

AMS IN
TAPE BIAS

SPK RELY ON
TAPE A/B
TAPE B HALF
TAPE A HALF
TAPE MODE SW B
TAPE MODE SW A
PHOTO SENSOR B

SPEANA IN L

SYSTEM MUTE OUT

TAPE REC MUTE

TAPE MUTE OUT (PB)

BD3871 DATA/LATCH

TU +B 3 REG 1
A TRIG
A SOL 81 TAPE SOL A
DRIVE 2
D811
Q603,606
B TRIG IC802
B SOL 82 TAPE SOL B TU +12V
DRIVE MASTER CONTROL +12V D543 D542
SFR601 IC601(2/2) TC +12V 3 1
MOTOR H REG
D812-815
M +9V IC801

POWER DOWN IN
Q605,608 D809 -810
MOTOR L
VR ENCODER A
VR ENCODER B

+9V
CD +7V 3
XTAL 6.0MHZ

XTAL 6.0MHZ

CAP MOTOR 1
REG
KEY INPUT0

KEY INPUT1

KEY INPUT2

CAP M+ 80 MECHA VCC

POWER SW

REMOTE IN
POW SAVE

DRIVE
D601
RESET

µCOM +B
VF
P1 P22 1G 10G
16 17 19 20 21 13 14 84 40 45 . 47 50 . 52 63 39 33 83 29 12 11
VF
VF VF T901
X601 D902-905 SUB TRANS JW3
6MHz Q651 Q602 Q601 IC901
1 3 FLD601 D602
FUCTION FUCTION FUCTION LED RESET EVER +5.6V +5.6V AC
VOLUME FLOURESCENT RESET 3 1
KEY KEY KEY DRIVER INDICATOR TUBE SWITCH REG IN
JW1
S601-609 S612-620 S623-629 VR601
LED601 RM601
(POWER)
REMOTE
Q901 RY901
RELAY
DRIVE

16 16
 HCD-RG11
5-3. Printed Wiring Board – CD Section – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6 7 8 9 10 11

A TO

CD BOARD A MAIN BOARD

CN704 SPDL BOARD
(Page 19)

+
14 1
B 10 1 7
6 1 1

IC781 M

SPINDLE 6
E MOTOR
F 15 28 -

TO
+
DRIVER BOARD 1 (LIMIT SW)
CN701
C (Page 24) 2
1
E E E E
2 1 OPTICAL M
PICK-UP
BLOCK SLED
MOTOR -
(KSM-213DCP/
G E
15
Z-NP) 1-682-124- 11

TO 17 16 16
PANEL BOARD
D CN602
19

(Page 25) 1
17 16 32
33 IC731 • Semiconductor
64
Location
1 E
32 Ref. No. Location
IC751 64
33 48 49 D730 C-4
D731 E-7
E D732 F-4
48 49 D733 D-3
D734 F-3
D735 D-3
D736 D-3

IC731 D-6
IC751 E-4
IC781 B-6
F
Q731 E-6
Q771 C-3
Q772 C-3
Q773 C-4
Q774 C-3
Q775 B-7

17 17
HCD-RG11
5-4. Schematic Diagram – CD Section – • See page 30, 31 for IC Block Diagrams. • See page 24 for printed wiring boards of ADDRESS SENSOR, DRIVER and MOTOR boards.

CD BOARD

OPTICAL PICK-UP
BLOCK 0.1

(KSM-213DCP/Z-NP) CN733
0.022

0.022

4.2

0.1
LED DRIVER
4.2
0.022
CN102

0.2
F

0.33

0.01
0.001
CN731
0.1 TO

2.4
2.4
4.8

4.8
4.8
2.4
4.2
2.2
0.9
0.9
PANEL BOARD

0
0

0
0
0.022 0.022

4.8
4.8
4.8
4.8

0
0
0
CN602

2.3
(Page 26)
2.4
0
2.4 2.5
2.5 0
2.4
0
2.4
0.1
2
2.4
IC731 2.5
1.9 IC751 0

0.22
2.4
2.4 ASP
2.4
2.4
0.1 0.001 0.1
0.1
4.8 DSP 1 2
0.1 0 0

0.1 4.8 0.0015

0.033 2.4 1.5 4.7
0 4.5 0.022 0
2.4 CN734
0.33 IC731 0 0.01 2.4 IC751 1.9
0.15 2.4 0
LA9241M 2.3 LC78622NE
2.4 4.8
2.4 0
IC B/D 0 IC B/D 1.9
0.0027 2.4
2.4
0.1
0 4.5 0 A
0.018 0
4.8 4.7 TO
0.015 2.4 0.022 0.1 0 0
4.8 MAIN BOARD (2/4)
2.4 0 CN704
0.1

0 (Page 21)
0.1 0
0 0.0015
0.068 2.4
2.4
2.4
2.4

2.3
2.3
2.4

0
2.3
2.4
2.4

2.4

0.0047 2.4

2.4
2.4

4.8
4.8

0.8
4.8
0
0

0
0
0.022
0.33
0.0033 Q771-774
0.1

MUTE
0.1

0.01

0.47

0.022

IC B/D
IC781 CN735
FCS/TRK COIL
SL/SP MOTOR
DRIVER
3.1
3.1
2.4

2.4

6.9
6.9

3.1
3.1
2.4

CN701
DRIVER BOARD
0.1
3.1
3.1

3.1
3.1
0

2.4
2.4
2.4

IC701 BA6956AN IC B/D

IC781
MM1469XH
IC701

0.1

0.1
6.9
6.9
0

0
3.7
ADDRESS SENSOR BOARD MOTOR BOARD MOTOR DRIVE
0 TURN

SPDL 0.8
BOARD 0.1 0.1
SWITCH

0.1

4.9 SG-264
0.2
A C

K E
CN01 CN732

IC711 CN711 CN722 CN721 CN702

TBL ADDRESS SENSOR

• Waveforms

1 IC751 rf (XOUT)

4.9Vp-p
59 ns

18 18
 HCD-RG11
5-5. Printed Wiring Board – MAIN Board – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
TO
A CD BOARD
A MAIN BOARD CN734
(Page 17)

E
B IC 102

1 E
1 7

E
8 IC 302 1
8 1
C
B IC 804
3 1
TO
PANEL BOARD
CN603
(Page 25) ANTENNA
D E
FM 75
24 13 NULL
IC 301
30
1 12 E E E IC 101
1 E

E E RV101
FM TUNED
D LEVEL AM
TO
PANEL BOARD
CN604 8
(Page 25) AM IF
E

E E E
• Semiconductor Location
E
Ref. No. Location Ref. No. Location
E E E E
DECK-A D103 D-12 Q101 D-12
G PLAYBACK
E
D105 C-11 Q102 B-14
E
L-CH
D111 F-14 Q105 D-8
IC 201 D112 F-14 Q106 D-9
R-CH
E E D202 H-5 Q201 G-5
E E
D203 I-7 Q202 H-5
H E D204 J-7 Q203 F-5
E
E
D205 J-7 Q204 H-5
DECK-B D304 D-7 Q205 G-5
RECORD/PLAYBACK
E D309 I-13 Q206 I-5
L-CH E D310 H-11 Q207 F-6
E
D311 G-12 Q208 H-8
I R-CH D312 D-4 Q209 I-7
IC 801 IC 803 IC 802
3 1 3 1 3 1 SPEAKER
D313 D-4 Q210 I-6
D315 I-14 Q211 I-6
D316 J-14 Q212 J-6
DECK-B
D801 I-11 Q213 J-6
E E E
ERASE D802 I-12 Q214 J-5
J D803 I-11 Q215 F-7
E E E D804 I-12 Q216 H-8
1 13 1 13 D809 H-9 Q303 C-7
E E
D810 H-9 Q304 B-7
D811 I-9 Q305 G-12
D812 I-12 Q306 H-13
K D813 I-12 Q307 G-12
D814 I-12 Q308 G-14
D815 I-12 Q309 G-14
Q311 G-13
IC101 D-13 Q312 G-13
TO TO IC102 B-12 Q313 K-8
L C POWER BOARD E POWER BOARD
IC201 G-6 Q314 G-12
CN503 CN502
(Page 27) (Page 27) IC301 D-7 Q315 G-12
IC302 C-5 Q316 K-9
IC801 I-8 Q320 E-5
IC802 I-10 Q321 D-5
IC803 I-9 Q801 D-10
IC804 C-10 Q802 D-10
Q803 F-9
Q804 F-9

19 19
HCD-RG11
5-6. Schematic Diagram – MAIN Board (1/4) – • See page 30, 31 for IC Block Diagrams.

470p
680p

IC B/D

IC B/D
• Waveforms

0.022

0.022
2 IC102 wf (XOUT)
2

3.2Vp-p
222 µs

23

20 20
 HCD-RG11
5-7. Schematic Diagram – MAIN Board (2/4) – • See page 31 for IC Block Diagram.

(Page 18) (Page 22)

IC B/D

(Page 23)

• Waveforms

3 L251

14.1Vp-p
16.6 µs
(60.1 kHz)

21 21
HCD-RG11
5-8. Schematic Diagram – MAIN Board (3/4) – • See page 30 for IC Block Diagram.

(Page 26)

(Page 29)

(Page 20)

(Page 21)

IC B/D

(Page 23) (Page 23)

22 22
 HCD-RG11
5-9. Schematic Diagram – MAIN Board (4/4) –

(Page 22) (Page 20) (Page 22)

(Page 26)

(Page 21)

(Page 29)

23 23
HCD-RG11
5-10. Printed Wiring Board – Address Sensor, Driver Motor Section – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6

C712

1
71
IC
4

14
C 14
14
14

IC701

F 14
14

F
CD
G CN735
(Page 17)
24 24
 HCD-RG11
5-11. Printed Wiring Board – Panel Section – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

A TO
PANEL BOARD G CD BOARD
CN733
(Page 17)

(POWER)

1 45
B
CN602 RM 601
51 50 E

31 3 1 CD
(FLUORESCENT INDICATOR TUBE)
1 IC 601 30
C 80
81
18 10
IC 602
100 1 1 9 TUNER/BAND

B
D TO TAPE A/B
MAIN BOARD
CN603
(Page 19)
GAME

30 E

3 1
E CN604

8
E
E E VIDEO OUT BOARD
VIDEO
D E 1
VIDEO
OUT
E 2
TO
MAIN BOARD
F CN305
1 E E

(Page 19)
L

16 2 1
2

17 1 R
CN601
G

AUDIO
PHONES
TO
JK601 TAPE MECHANISM DECK GAME • Semiconductor Location
H 1 S601-609,S612-620 DESCRIPTIONS OF PANEL SWITCHES
INPUT Ref. No. Location Ref. No. Location
7 2 S623-629
S601 REC PAUSE/START S608 S617
GAME S626
DISC 2
8 5 D601 D-10 LED601 B-12
CD SYNC TAPE A/B DISC 1
4 S602 S609 S618 S627 D602 D-10 LED602 C-12
3 TUNER/BAND
S603 + S612 MOVIE EQ S619 S628 DISC SKIP EX-CHAGE D603 E-10 LED603 C-12
S604 S613 EFFECT ON/OFF S620
CD
RV601 VOLUME D604 E-10 LED604 D-12
GAME EQ GROOVE D605 B-11 LED605 D-12
I S605 S614 S623
OPEN/CLOSE
D606 B-11 LED606 D-12
S606 S615 MUSIC EQ S624
D607 B-10 LED607 D-12
DISPLAY DISC 3
S607 S616 S625 D608 B-10 LED608 E-12
D609 B-11 LED609 E-12
D610 F-10
D611 F-11 Q601 E-10
D615 B-6 Q602 E-10
Q603 E-11
IC601 C-7 Q604 E-11
IC602 C-12 Q605 F-11
Q606 E-12
Q607 E-11
Q608 F-12
Q651 B-11

RM601 B-10

25 25
HCD-RG11
5-12. Schematic Diagram – Panel Section – • See page 31 for IC Block Diagram. • See page 32 for IC Pin Function Description.

TO TO
MAIN BOARD (3/4)
B CN603
(Page 22)
D
MAIN BOARD (4/4)
CN305
(Page 23)

CN603 CN604 VIDEO OUT BOARD

PANEL BOARD
JK602
CN615 CN605
JK601 VIDEO OUT

PHONES

NJL64H400A-1

JK603
VIDEO

INPUT GAME
AUDIO

VOLUME
RESET
0 5

4.9
RESET SWITCH
0 0

OPEN/ DISC SKIP

GROOVE DISC 3 DISC 2 DISC 1
CLOSE EX-CHANGE

EFFECT DISPLAY GAME TUNER CD

MOVIE EQ GAME EQ MUSIC EQ TAPE A/B BAND
ON/OFF
0.1 <4.7>
0 <0.9>
4.4 <0>
-23.4

0 <4.8>

0 <4.8> REC
PAUSE/
2.2
2.2
0.1
0.1
0.1

4.9

4.9

START CD SYNC
5
5
5
5
0

5
5
5

0
0
5

5
5

0 <4.8>
-23.4
-23.4 0

-23.4 0 GAME
CD TUNER/BAND TAPE A/B
-23.4 0

-23.4 4 5.1
LTL77HKYTNN LTL77HKYTNN LTL77HKYTNN LTL77HKYTNN
-23.4 0

-23.4 IC601 0 LTL77HKYTNN LTL77HKYTNN LTL77HKYTNN LTL77HKYTNN

-23.4 MASTER CONTROL 0

-23.4 0

-16.7 IC601 4.9

-21.7 LC866540A_5V62 4.9

2.6 <0.1>

1.1 [0.1]
-16

0.1
5.5

2.6
0
-25
IC B/D
-22 4.6
-22 0 -E2 IC602
4.9
LED DRIVER
-22 0

0.1

5.5
0
0
-22 4.8
0 <4.8> [4.8]

-10 0 [0.7]
-19 0 [0.7]

-25
-10.1

-13.1
-13.1

-10.1

0 [4.7]
-7.1

-7.1

4.9

4.8
4.8

4.8
4.7
5.3
-25
-16

-22
-25
-25
-16

0.2
5
5

0
0
1.3 <1.7> [1.1]
5 [0]

9 0
Q603,606 FM : No mark
B TRIG DRIVE
9 [8.7] 9 [8.7]
CD : < >
0 [0.7]

0
TAPE : [ ]
0 [0.7]
3.7
1SS133T-77 9 0 LED DRIVER
LTL-77HKETNN
Q604,607
A TRIG DRIVE ( )
9 [8.7] 9 [8.7]
0 [0.7]

0 [0.7]

9 [8.7] 0 [8.7] • Waveforms

Q605,608
CAP MOTOR DRIVE
9 [0.8]
0 [1.5]
9 [8]
4 IC601 qj (XTAL 6.0MHz)
0 [0.7]

CN602 CN601
FLUORESCENT INDICATOR TUBE

4.8Vp-p
TO
TAPE 167 ns
MECHANISM
TO
DECK
F CD BOARD
CN733
(Page 18)

26 26
 HCD-RG11
5-13. Printed Wiring Board – POWER Board – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6 7 8 9 10 11 12 13

A POWER BOARD IC 501

• Semiconductor
Location
Ref. No. Location
D501 D-9
D502 D-7
D541 F-9
B D542 B-4
D543 B-4
D551 D-7

IC501 A-8

E Q501 C-9
E Q503 D-9
C Q504 D-8
E Q551 C-7
Q581 C-8

E
D TO
MAIN BOARD
CN402 E
E
(Page 19)

+ _
F
C H
TO
TO TRANS BOARD
MAIN BOARD CN915
CN403 (Page 28)
(Page 19)
G

27 27
HCD-RG11
5-14. Printed Wiring Board – Trans Section – • See page 14 for Circuit Boards Location.

1 2 3 4 5 6 7 8 9 10 11 12 13 14

A
TRANS BOARD [TRANS BOARD]
• Semiconductor
Location
Ref. No. Location
D911 D-10
B 1 D912 D-11
D913 E-12

Q911 E-12

H
D TO
POWER BOARD
CN501
(Page 27)

E E

F
AC
IN
SUB TRANS BOARD
G

2 1

H
[SUB TRANS BOARD]
1 • Semiconductor
Location
Ref. No. Location
I
D901 G-6
D902 J-4
D903 J-4
E D904 I-4
D905 J-4

J IC901 K-5

Q901 I-5

IC 901

28 28
 HCD-RG11
5-15. Schematic Diagram – Trans Section –

POWER BOARD TRANS BOARD

T6.3AL/250V T6.3AL/250V
22u 50V
IC501 T2AL/250V
POWER AMP
37.5
0.1 39.5 C542
2200u 50V
(1/2)
STK402-070S
R510
0.22 2W
0.1 0
0 C592
R508
-37.5 0.22 2W 2200u
0 50V

OVER LOAD
2.2k 39.5 0
DETECTOR
38.8

MUTE CONT 0
-37.5
39.5 11.5
MUTE
-36.8
-25 -30V REG -37.5
0.1
-37.5 MUTE CONT

0.6
-25.6
MTZJ-T-
77-6.5B

MTZJ-T-
77-27B

11.5

2.2k 0
SUB TRANS BOARD
0
22u 50V OVER LOAD DETECTOR

IC901
0 +5.6V REG

0.1 -39.5 RELAY DRIVE

0.2

(2/2) 0.8
9.4
STK402-070S

0 5.7
0.1 0
R558
0.22 2W

R560
0.22 2W

TO TO
C MAIN BOARD (3/4) E MAIN BOARD (4/4)
CN403 CN402
(Page 22) (Page 23)

29 29
HCD-RG11

5-16. IC Block Diagrams IC781 MN1469XH (CD BOARD)

IC731 LA9241M (CD BOARD)

CH3 OUT-B
CH4 OUT-A

CH4 OUT-B

CH3 OUT-A
VCC1

VCC2

CH4 IN-A

CH4 IN-B

CH3 IN-B

CH3 IN-A
SUBGND
REFI
LDD

BIAS-IN
LDS

DRF

DAT

CLK
FSS

DEF

OP IN +
BHI

PHI

LF2

OP IN -
VR

CE

CL

Vcc

Vcc
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 28 27 26 25 24 23 22 21 20 19 18 17 16 15

APC REF Vcc Vcc

RF DET 48 NC

+
-
47 TBC

LEVEL SHIFT
LEVEL SHIFT
FIN2 1 VCA 46 FSC
- -
FINI 2 +
I/V
+

+
-
E 3 45 DGND
∝-COM LSC
F 4 BAL VCA INTERFACE 44 SLI
-
+-
+

TB 5 43 SLC

LEVEL SHIFT

LEVEL SHIFT
42 RFS- + +
TE- 6 +- - -
+
- TE
TE 7 41 RFSM
RF AMP
40 CV+
TESI 8 39 CV-
T. SERVO & T. LOGIC
SCI 9 38 SLOF
TH 10 37 HFL
1 2 3 4 5 6 7 8 9 10 11 12 13 14
36 TES

VREG-OUT

CH2 OUT-A

SUBGND

OP OUT
CH1 OUT-B

CH2 IN-B

CH2 IN-A

CH2 OUT-B
CH1 OUT-A

CH1 IN-B

TR-B
CH1 IN-A

MUTE

GND
TA 11 35 TOFF
34 TGL
TD- 12
-+ F. SERVO & F. LOGIC SPINDLE SERVO SLED SERVO 33 JP+
TD 13
JR 14 +- +-
IC101 BA1450 (MAIN BOARD)

FM BAND WIDTH

FM/AM DET OUT

+ +- +
- -

AM OSC OUT

AM MIX OUT

AM MPX IN

FM MPX IN

VCO STOP
AM RF IN

AM IF IN
AM OSC

AM AGC
V . REG
TO 15
FD 16
17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 24 23 22 21 20 19 18 17 16 15 14 13
SPD

SLEQ
SLD

SL-
SL+
JP-
FE
FD-
FA

FA-

FE-
AGND

SP
SPI
SPG
SP-

AM AM AM IF
OSC MIX

VREG SD

IC751 LC78622NE (CD BOARD) AM

AGC
DET 1/2
TEST1
TEST2
TEST3
TEST4
TEST5

SW 1/2
TST11
EFMO

VVDD
VVSS

ISET
PDO

VDD
PCK

VSS
TAI
FR

PD
9 6 4 3 5 7 21 2 59 64 11 32 33 62 23 8

FM FM LED VCO
DRIVER DECODER
DEFI 1 IF DET
Slice level VCO clock oscillator 2k x 8-bit RAM RAM address SD COMP
EFMIN 10 control Clock control generator DET

1 2 3 4 5 6 7 8 9 10 11 12
Synchronization
Interpolation

VCC
FM IN

FM SD ADJ

GND

FM DET

TUNED

STEREO

IN REQ MUTE

IF OUT

R OUT

L OUT

AM/FM
FSEQ 22 detection 30 C2F
EFM demoduration and muting
Bilingual
CLV+ 12 CLV digital
CLV- 13 servo Digital
output 31 DOUT IC301 BD3871FS (MAIN BOARD)
V/P 14
C1 and C2 error detection

BOUT2

BOUT1
and correction Digital

OUT1

OUT2
BNF2

BNF1
TNF1

TNF2
PW 49

VCC
CAP
Flag processing attenuator

SC
SI
SBCK 51 Subcode
separation 24 23 22 21 20 19 18 17 16 15 14 13
SBSY 47 QCRC
8x oversampling
SFSY 50 digital filters
Treble1 Treble1 Bass2 Bass1
Logic
Surround
CS 63 fc=8kHz fc=8kHz fo=80Hz fo=80Hz
WRQ 53 Microprocessor 1-bit DAC
SQOUT 55 interface

CQCK 57 Vcc/2 Vcc/2

COIN 56 L.P.F
Servo General-purpose Crystal oscillator system
RWC 54 command ports Timing generation
0dB-
-87dB Vcc/2
15 16 17 20 19 58 18 34 24 25 26 27 28 29 48 60 61 46 52 45 44 43 39 41 42 40 37 35 38 36 -
HFL
TES
TOFF
JP-
JP+
RES
TGL
PCCL
CONT1
CONT2
CONT3
CONT4
CONT5
EMPH/CONT6
EFLG
16M
4.2M
XVSS
FSX
XIN
XOUT
XVDD
RVSS
RVDD
MUTER/CONT8
RCHO
LCHO
MUTEL/CONT7
LVSS
LVDD

Vcc/2 Vcc/2

50k 50k 50k 50k 50k 50k

1 2 3 4 5 6 7 8 9 10 11 12
VIN1

VIN2

SEL2

SEL1

A1

A2

B1

B2

C1

C2

FILTER

GND
30 30
 HCD-RG11

IC102 LC72130 (MAIN BOARD)

AOUT1
AOUT2
XOUT

AMIN
FMIN
AIN2

AIN1

VDD
VSS

PD2

PD1

I02
24 23 22 21 20 19 18 17 16 15 14 13

SWALLOW COUNTER
1/16.1/17 4bits
POWER
REFERENCE ON 1/2
DIVIDER RESET

SWALLOW COUNTER
1/16.1/17 4bits
REFERENCE
DIVIDER

PHASE DETECTOR
CHARGE PUMP

2
C B DATA SHIFT REGISTER C B
I/F LATCH I/F

1 2 3 4 5 6 7 8 9 10 11 12
XIN

B05

CE

D1

CL

D0

B01

B02

B03

B04

I01

IFIN

IC201 TA8189N (MAIN BOARD) IC701 BA6956AN (DRIVER BOARD)

METAL PRE TAPE A REC REC

CH2/A CH2/B NF OUT OUT /TAPE B VCC CG OUT NF IN ALC

24 23 22 21 20 19 18 17 16 15 14 13 TSD

CH2 –
– +
CH2 CONTROL LOGIC
+

A/B
1 2 3 4 5 6 7 8 9
VREF

OUT2

RNF

OUT1

VM

VCC

FIN

GND

RIN

ALC
VREF1 IREF
VREF2

M/N

CH1 CH1
+ + IC602 BU2114F-E2 (PANEL BOARD)
– –

GND GND 18 VDD

1 2 3 4 5 6 7 8 9 10 11 12 17 O1
CH1/A CH1/B NF METAL PRE MIX GND1 M/H REC NF REC GND
SIN 1 16 O2
OUT OUT OUT OUT IN SHIFT
REGISTER
CK 2 15 O3

LATCH 3 LATCH 14 O4

SOUT 4 13 O5

EN 5 ENABLE 12 O6

RST 6 11 O7

GND 7 10 O8

GND 8 9 GND

31
HCD-RG11

5-17. IC Pin Function Description

• IC601 LC866540A-5V62 (Master Control) (PANEL Board)

Pin No. Pin Name I/O Description

1 CD ON/OFF O CD power on/off control signal output
2 CD RWC O Read/write control signal output
3 CD RESET OUT O CD reset signal output
4 CD SL – O Sled movement control signal output
5 CD SL + O Sled movement control signal output
6 CD A MUTE O CD audio mute signal output
7 CD WRQ I Subcode Q standby signal input
8 CD DRF I RF level detection signal input
9 TU STEREO I Stereo tuning signal input
10 TUNED I Tuning a frequency signal input
11 POWER DOWN IN I Power down signal input
12 RESET – Reset
13 VR ENCODER A I Volume signal input from the rotary encoder
14 VR ENCODER B I Volume signal input from the rotary encoder
15 VSS – Ground
16 XTAL 6.0MHZ – Connection for a crystal resonator
17 XTAL 6.0MHZ – Connection for a crystal resonator
18 VDD – Power supply
19 KEY INPUT 0 I Function key input
20 KEY INPUT 1 I Function key input
21 KEY INPUT 2 I Function key input
22 SPEANA IN L I Spectrum analyzer signal input
23 SPEANA IN R I Spectrum analyzer signal input
24 AMS IN I AMS signal input
25 TAPE A HALF I A deck half detect signal input
26 TAPE B HALF I B deck half detect signal input
27 PHOTO SENSOR A I A deck photo sensor signal input
28 PHOTO SENSOR B I B deck photo sensor signal input
29 REMOTE IN I Data signal input from the remote control sensor
30 - 39 10G - 1G O FL tube grid signal output
40 - 41 P1 - P2 O FL tube grid signal output
42 - 45 P3 - P6 O FL tube segment signal output
46 VDD – Power supply
47 - 50 P7 - P10 O FL tube segment signal output
51 –VPP – FL tube pull-down voltage supply
52 - 63 P11 - P22 O FL tube segment signal output
64 MODE SW IN I Pull-down
65 TAPE MODE SW A I Tape mode switch signal input
66 TAPE MODE SW B I Tape mode switch signal input
67 TAPE FWD REC SW B I Tape B REC switch detect signal input
68 CD NUMBER SENSOR I Table address sensor signal input
69 CD PIC UP/DOWN SW I CD BU up/down switch signal input
70 CD TRAY OPEN SW I CD tray open switch signal input
71 CD TRAY CLOSE SW I CD tray close switch signal input
72 VDD – Power supply
73 CD MOTOR + O CD changer motor control signal output
74 CD MOTOR – O CD changer motor control signal output
75 SPK RELY ON O Speaker relay control signal output
76 SYSTEM MUTE OUT O system mute signal output
77 TUNER MUTE OUT O Tuner mute signal output

32
 HCD-RG11

Pin No. Pin Name I/O Description

78 STK MUTE O Power amplifier mute signal output
79 TAPE MUTE OUT(PB) O Tape mute signal output
80 MECHA VCC O Tape motor control signal output
81 TAPE SOL A O Solenoid control signal output
82 TAPE SOL B O Solenoid control signal output
83 POW SAVE O Standby relay control signal output
84 POWER SW O Power switch LED control signal output
85 A PLAY/B REC – N.C.
86 TAPE REC O Tape REC control signal output
87 TAPE REC MUTE O Tape REC mute signal output
88 TAPE BIAS O Tape bias control signal output
89 VSS – Ground
90 VDD – Power supply
91 TAPE A/B O Deck A/B selection control signal output
92 BU2114 LATCH O LED driver IC latch signal output
93 LC72131 CE O PLL tuner IC chip select signal output
94 BD3871 DATA/LATCH O Sound processor data/latch signal output
95 LC72131 BU2114 DO O Data signal output for PLL synthesizer IC and LED driver IC
96 LC72131 DI I Data signal input from PLL synthesizer IC
97 CLK O Clock signal output for PLL synthesizer IC, sound processor and LED driver IC
98 COIN O CD command data signal output
99 SQOUT I CD subcode Q signal input
100 SQCK O CD command clock signal output

33
HCD-RG11
SECTION 6
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may • The mechanical parts with no reference number
The components identified by mark 0 or
have some differences from the original one. in the exploded views are not supplied.
dotted line with mark 0 are critical for safety.
• Items marked “*” are not stocked since they Replace only with part number specified.
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.

6-1. MAIN SECTION

#2
not
c supplied
4
1 5 #3
#3
c

b
#3
CD mechanism deck 6
1 #3 3 section
7
#3
2
#3

#3

#3 9
1
#3
#3
not
supplied

a
8
#3 1
Front Panel section MAIN board section
a

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1 3-363-099-41 SCREW (CASE 3 TP2) 7 A-4726-772-A SUB TRANS BOARD, COMPLETE
2 4-224-549-21 CASE (SIDE-L) 8 4-224-548-61 CASE (SIDE-R)
3 4-234-702-21 CD DOOR 9 1-791-897-11 WIRE (FLAT TYPE) (19 CORE)
4 4-224-550-41 CASE (TOP) #2 7-685-871-01 SCREW +BVTT 3X6 (S)
5 4-234-701-11 BACK PANEL #3 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S

6 A-4726-511-A VIDEO OUT BOARD, COMPLETE

34
 HCD-RG11

6-2. FRONT PANEL SECTION

65 66 69
62
64
70

61
69 63 68
60 67
69
59
57
58
53
S
69 72
not 75 71
supplied 73

not
supplied
69
57
69 71
51
78
77 69
60
54 74
52
79 76
56
55

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
51 4-235-533-01 CASS WINDOW (L) 66 4-234-708-11 DISC BUTTON
52 4-235-534-01 CASS WINDOW (R) 67 4-234-709-01 FUNCTION BUTTON
53 4-234-704-21 CASS DOOR (L) 68 4-234-710-21 MUSIC BUTTON
54 4-234-705-21 CASS DOOR (R) 69 4-951-620-01 SCREW (2.6X8), +BVTP
55 4-235-535-31 VOLUME KNOB 70 A-4726-769-A PANEL BOARD, COMPLETE

56 4-233-981-01 CASSETTE DOOR SPRING L 71 4-235-777-01 BELT (FR)

57 4-224-104-11 DAMPER 72 4-235-775-01 BELT (BF)
58 4-235-398-01 EMBLEM, SONY 73 4-235-776-01 BELT (AF)
59 4-224-560-01 CAM (L), HEART 74 1-796-122-11 DECK, MECH (CWL44FF29)
60 4-224-803-01 SPRING (PUSH), COMPRESSION 75 1-823-058-11 WIRE (FLAT TYPE) (17 CORE)

61 4-224-562-21 BRACKET (HEART CAM L) 76 4-224-561-01 BRACKET (HEART CAM R)

62 4-234-703-01 DISPLAY WINDOW 77 4-224-559-01 CAM (R), HEART
63 4-234-700-21 FRONT PANEL 78 4-233-982-01 CASSETTE DOOR SPRING R
64 4-234-711-21 CD CONTROL BUTTON 79 4-233-980-01 RUBBER FOOT
65 X-4955-019-1 POWER BUTTON ASSY

35
HCD-RG11

6-3. MAIN BOARD SECTION

T911
103
#5
102 #1
101 #5

#1

not supplied

104
#4

105

not supplied

#3

106

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
101 A-4726-771-A TRANS BOARD, COMPLETE 0 T911 1-437-386-11 TRANSFORMER, POWER
* 102 3-703-244-00 BUSHING (2104), CORD #1 7-685-872-09 SCREW +BVTT 3X8 (S)
0 103 1-777-071-81 CORD, POWER #3 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S
104 A-4726-770-A POWER BOARD, COMPLETE #4 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3
105 4-988-533-01 HOLDER, PWB #5 7-685-880-09 SCREW +BVTT 4X6 (S)

106 A-4440-486-A MAIN BOARD, COMPLETE

The components identified by mark 0 or dotted

line with mark 0 are critical for safety.
Replace only with part number specified.

36
 HCD-RG11

6-4. CD MECHANISM DECK SECTION

156 158 159 151

163 171
182 157
164
174 162

M721
161 not supplied

155 185
not supplied
175 176 158 165
158
154
169

166
160
167
168

186
153 179
170 171
187 183 170
not 188
152 170 supplied
183
183
151 158 184 189

170 171
158 183
184

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
151 4-218-254-21 SCREW (M2.6), +PTPWH 168 X-4953-281-1 HOLDER (BU) ASSY
152 4-231-187-01 CAM (RELAY) 169 4-222-095-01 BELT
153 4-231-177-01 TABLE (NEW) 170 4-227-045-11 SPRING (INSULATOR), COIL
154 4-231-181-01 LEVER (CHANGE) 171 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING
155 4-231-178-01 TRAY 174 4-231-180-01 CAM (CONTROL)

156 4-933-134-51 SCREW (+PTPWH 2.6X8) 175 4-231-182-01 GEAR (U)

157 1-675-910-14 MOTOR BOARD 176 4-231-183-01 PULLEY (S)
158 4-951-620-01 SCREW (2.6X8), +BVTP 179 4-227-899-01 SCREW (DIA. 12), FROATING
159 1-791-983-11 WIRE (FLAT TYPE) (8 CORE) 182 4-222-097-01 SCREW, STEP
160 1-675-911-14 ADDRESS SENSOR BOARD 183 4-227-549-11 INSULATOR

161 1-675-912-14 DRIVER BOARD 184 4-231-151-01 STOPPER (BU)

162 X-4953-283-2 CAM (U/D) ASSY 185 A-4672-826-A MOTOR ASSY
163 4-231-186-01 LEVER (EX) 186 A-4726-775-A CD BOARD, COMPLETE
164 4-231-190-01 LEVER (LIFTER) 187 1-823-059-11 WIRE (FLAT TYPE) (16 CORE)
165 4-231-189-01 PULLEY (B), CHUCKING 0 188 8-820-116-01 OPTICAL PICK-UP KSM-213DCP/Z-NP

166 1-471-035-11 MAGNET ASSY 189 1-682-124-11 SPDL BOARD

167 X-4953-282-1 PULLEY (A) ASSY, CHUCKING M721 1-541-632-11 MOTOR, DC (TURN)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.

37
HCD-RG11
SECTION 7
ADDRESS SENSOR CD ELECTRICAL PARTS LIST

NOTE:
• Due to standardization, replacements in the • CAPACITORS: • SEMICONDUCTORS
parts list may be different from the parts uF: µF In each case, u: µ, for example:
specified in the diagrams or the components • COILS uA...: µA... , uPA... , µPA... ,
used on the set. uH: µH uPB... , µPB... , uPC... , µPC... ,
• -XX, -X mean standardized parts, so they • RESISTORS uPD..., µPD...
may have some difference from the original All resistors are in ohms. When indicating parts by reference number,
one. METAL: metal-film resistor please include the board name.
• Items marked “*” are not stocked since they METAL OXIDE: Metal Oxide-film resistor
are seldom required for routine service. F: nonflammable The components identified by mark 0 or
Some delay should be anticipated when dotted line with mark 0 are critical for safety.
ordering these items. Replace only with part number specified.

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1-675-911-14 ADDRESS SENSOR BOARD C732 1-130-493-00 MYLAR 0.068uF 5% 50V
********************** C734 1-164-159-11 CERAMIC 0.1uF 50V
C735 1-162-286-31 CERAMIC 220PF 10% 50V
< CAPACITOR > C736 1-136-171-00 FILM 0.33uF 5% 50V
C737 1-162-306-11 CERAMIC 0.01uF 20% 16V
C712 1-164-159-11 CERAMIC 0.1uF 50V
C738 1-162-292-31 CERAMIC 680PF 10% 50V
< IC > C739 1-162-600-11 CERAMIC 0.0047uF 10% 16V
C740 1-162-286-31 CERAMIC 220PF 10% 50V
IC711 8-749-014-38 PHOTO INTERRUPTER SG-264 C741 1-126-959-11 ELECT 0.47uF 20% 50V
C742 1-126-947-11 ELECT 47uF 20% 10V
< RESISTOR >
C743 1-126-960-11 ELECT 1uF 20% 50V
R711 1-247-876-11 CARBON 75K 5% 1/4W C744 1-127-870-31 CERAMIC 3300PF 10% 50V
R712 1-249-409-11 CARBON 220 5% 1/4W F C745 1-162-191-31 CERAMIC 2.2PF 10% 50V
R713 1-249-429-11 CARBON 10K 5% 1/4W C746 1-162-306-11 CERAMIC 0.01uF 20% 16V
C747 1-164-159-11 CERAMIC 0.1uF 50V
< SWITCH >
C748 1-162-294-31 CERAMIC 0.001uF 10% 50V
S711 1-771-821-11 SWITCH, PUSH (1 KEY)(UP DOWN SW) C749 1-162-203-31 CERAMIC 15PF 5% 50V
************************************************************ C750 1-126-963-11 ELECT 4.7uF 20% 50V
C751 1-164-159-11 CERAMIC 0.1uF 50V
A-4726-775-A CD BOARD, COMPLETE C752 1-164-159-11 CERAMIC 0.1uF 50V
*******************
C753 1-164-159-11 CERAMIC 0.1uF 50V
< CAPACITOR > C754 1-162-286-31 CERAMIC 220PF 10% 50V
C755 1-161-494-00 CERAMIC 0.022uF 25V
C704 1-164-159-11 CERAMIC 0.1uF 50V C756 1-126-947-11 ELECT 47uF 20% 10V
C705 1-126-947-11 ELECT 47uF 20% 10V C757 1-161-494-00 CERAMIC 0.022uF 25V
C706 1-164-159-21 CERAMIC 0.1uF 50V
C707 1-126-964-11 ELECT 10uF 20% 50V C758 1-126-947-11 ELECT 47uF 20% 10V
C708 1-161-494-00 CERAMIC 0.022uF 25V C759 1-164-159-11 CERAMIC 0.1uF 50V
C760 1-162-284-31 CERAMIC 150PF 10% 50V
C709 1-104-665-11 ELECT 100uF 20% 10V C761 1-162-206-31 CERAMIC 20PF 5% 50V
C710 1-104-665-11 ELECT 100uF 20% 10V C762 1-162-206-31 CERAMIC 20PF 5% 50V
C711 1-162-306-11 CERAMIC 0.01uF 20% 16V
C712 1-126-960-11 ELECT 1uF 20% 50V C763 1-126-947-11 ELECT 47uF 20% 10V
C713 1-136-171-00 FILM 0.33uF 5% 50V C764 1-161-494-00 CERAMIC 0.022uF 25V
C765 1-161-494-00 CERAMIC 0.022uF 25V
C714 1-126-947-11 ELECT 47uF 20% 10V C766 1-161-494-00 CERAMIC 0.022uF 25V
C715 1-162-294-31 CERAMIC 0.001uF 10% 50V C767 1-162-282-31 CERAMIC 100PF 10% 50V
C716 1-126-947-11 ELECT 47uF 20% 10V
C717 1-126-964-11 ELECT 10uF 20% 50V C768 1-162-282-31 CERAMIC 100PF 10% 50V
C718 1-161-494-00 CERAMIC 0.022uF 25V C769 1-162-282-31 CERAMIC 100PF 10% 50V
C770 1-162-282-31 CERAMIC 100PF 10% 50V
C719 1-161-494-00 CERAMIC 0.022uF 25V C771 1-126-964-11 ELECT 10uF 20% 50V
C720 1-104-665-11 ELECT 100uF 20% 10V C772 1-126-964-11 ELECT 10uF 20% 50V
C723 1-126-957-11 ELECT 0.22uF 20% 50V
C724 1-130-489-00 MYLAR 0.033uF 5% 50V C773 1-127-866-11 CERAMIC 1500PF 10% 50V
C725 1-162-288-31 CERAMIC 330PF 10% 50V C774 1-127-866-11 CERAMIC 1500PF 10% 50V
C775 1-162-282-31 CERAMIC 100PF 10% 50V
C726 1-136-171-00 FILM 0.33uF 5% 50V C776 1-162-282-31 CERAMIC 100PF 10% 50V
C727 1-136-167-00 FILM 0.15uF 5% 50V C777 1-126-947-11 ELECT 47uF 20% 10V
C728 1-127-869-11 CERAMIC 2700PF 10% 50V
C730 1-130-485-00 MYLAR 0.015uF 5% 50V C781 1-126-926-11 ELECT 1000uF 20% 10V
C731 1-130-486-00 MYLAR 0.018uF 10% 50V C782 1-164-159-11 CERAMIC 0.1uF 50V

38
 HCD-RG11
CD

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
C786 1-161-494-00 CERAMIC 0.022uF 25V R717 1-249-439-11 CARBON 68K 5% 1/4W
C787 1-104-665-11 ELECT 100uF 20% 10V R718 1-249-436-11 CARBON 39K 5% 1/4W
C788 1-162-290-31 CERAMIC 470PF 10% 50V
R719 1-247-843-11 CARBON 3.3K 5% 1/4W
C789 1-164-159-11 CERAMIC 0.1uF 50V R720 1-249-434-11 CARBON 27K 5% 1/4W
C790 1-164-159-11 CERAMIC 0.1uF 50V R721 1-249-414-11 CARBON 560 5% 1/4W F
C791 1-164-159-11 CERAMIC 0.1uF 50V R722 1-249-431-11 CARBON 15K 5% 1/4W
C792 1-164-159-11 CERAMIC 0.1uF 50V R724 1-249-433-11 CARBON 22K 5% 1/4W
C703A 1-162-282-31 CERAMIC 100PF 10% 50V
R725 1-249-430-11 CARBON 12K 5% 1/4W
C703B 1-162-282-31 CERAMIC 100PF 10% 50V R727 1-249-430-11 CARBON 12K 5% 1/4W
C703C 1-162-282-31 CERAMIC 100PF 10% 50V R728 1-249-435-11 CARBON 33K 5% 1/4W
C746A 1-162-209-31 CERAMIC 27PF 5% 50V R729 1-249-419-11 CARBON 1.5K 5% 1/4W F
R731 1-249-434-11 CARBON 27K 5% 1/4W
< CONNECTOR >
R732 1-247-885-00 CARBON 180K 5% 1/4W
CN731 1-779-553-11 CONNECTOR,FFC(LIF(NON-ZIF))16P R733 1-249-431-11 CARBON 15K 5% 1/4W
* CN732 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P R734 1-249-434-11 CARBON 27K 5% 1/4W
CN733 1-784-780-11 CONNECTOR, FFC 19P R735 1-249-435-11 CARBON 33K 5% 1/4W
CN735 1-785-336-11 PIN, CONNECTOR(LIGHT ANGLE)10P R736 1-249-419-11 CARBON 1.5K 5% 1/4W F

< DIODE > R737 1-249-424-11 CARBON 3.9K 5% 1/4W F

R738 1-247-807-31 CARBON 100 5% 1/4W
D730 8-719-991-33 DIODE 1SS133T-77 R739 1-249-419-11 CARBON 1.5K 5% 1/4W F
D731 8-719-991-33 DIODE 1SS133T-77 R740 1-249-427-11 CARBON 6.8K 5% 1/4W F
D732 8-719-991-33 DIODE 1SS133T-77 R741 1-249-424-11 CARBON 3.9K 5% 1/4W F
D733 8-719-991-33 DIODE 1SS133T-77
D734 8-719-991-33 DIODE 1SS133T-77 R742 1-247-897-11 CARBON 560K 5% 1/4W
R743 1-247-897-11 CARBON 560K 5% 1/4W
D735 8-719-991-33 DIODE 1SS133T-77 R744 1-249-428-11 CARBON 8.2K 5% 1/4W F
D736 8-719-991-33 DIODE 1SS133T-77 R745 1-249-431-11 CARBON 15K 5% 1/4W
R746 1-249-411-11 CARBON 330 5% 1/4W
< IC >
R747 1-249-433-11 CARBON 22K 5% 1/4W
IC731 8-759-498-93 IC LA9241M R748 1-249-437-11 CARBON 47K 5% 1/4W
IC751 6-700-355-01 IC LC78622NE R749 1-249-415-11 CARBON 680 5% 1/4W F
IC781 6-700-304-01 IC MM1469XH R750 1-249-425-11 CARBON 4.7K 5% 1/4W F
R751 1-249-415-11 CARBON 680 5% 1/4W F
< COIL >
R752 1-249-434-11 CARBON 27K 5% 1/4W
L701 1-410-509-11 INDUCTOR 10uH R753 1-249-418-11 CARBON 1.2K 5% 1/4W F
L702 1-410-509-11 INDUCTOR 10uH R754 1-249-435-11 CARBON 33K 5% 1/4W
L703 1-410-521-11 INDUCTOR 100uH R755 1-249-442-11 CARBON 510 5% 1/4W
L704 1-410-509-11 INDUCTOR 10uH R756 1-247-903-00 CARBON 1M 5% 1/4W
L705 1-410-509-11 INDUCTOR 10uH
R757 1-249-437-11 CARBON 47K 5% 1/4W
L733 1-408-080-00 INDUCTOR 100uH R758 1-249-417-11 CARBON 1K 5% 1/4W F
R759 1-249-417-11 CARBON 1K 5% 1/4W F
< TRANSISTOR > R760 1-247-807-31 CARBON 100 5% 1/4W
R761 1-249-417-11 CARBON 1K 5% 1/4W F
Q731 8-729-116-57 TRANSISTOR 2SB1068TP-K
Q771 8-729-119-78 TRANSISTOR 2SC2785TP-HFE R762 1-249-417-11 CARBON 1K 5% 1/4W F
Q772 8-729-119-78 TRANSISTOR 2SC2785TP-HFE R763 1-249-417-11 CARBON 1K 5% 1/4W F
Q773 8-729-119-76 TRANSISTOR 2SA1175TP-HFE R764 1-249-417-11 CARBON 1K 5% 1/4W F
Q774 8-729-119-76 TRANSISTOR 2SA1175TP-HFE R765 1-249-417-11 CARBON 1K 5% 1/4W F
R766 1-247-807-31 CARBON 100 5% 1/4W
Q775 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
R771 1-249-421-11 CARBON 2.2K 5% 1/4W F
< RESISTOR > R772 1-249-421-11 CARBON 2.2K 5% 1/4W F
R773 1-249-429-11 CARBON 10K 5% 1/4W
R704 1-249-393-11 CARBON 10 5% 1/4W F R774 1-249-429-11 CARBON 10K 5% 1/4W
R705 1-247-807-31 CARBON 100 5% 1/4W R775 1-249-429-11 CARBON 10K 5% 1/4W
R707 1-247-807-31 CARBON 100 5% 1/4W
R708 1-249-441-11 CARBON 100K 5% 1/4W R776 1-249-429-11 CARBON 10K 5% 1/4W
R709 1-249-427-11 CARBON 6.8K 5% 1/4W F R777 1-249-421-11 CARBON 2.2K 5% 1/4W F
R778 1-249-421-11 CARBON 2.2K 5% 1/4W F
R710 1-249-421-11 CARBON 2.2K 5% 1/4W F R781 1-249-434-11 CARBON 27K 5% 1/4W
R714 1-249-439-11 CARBON 68K 5% 1/4W R782 1-249-429-11 CARBON 10K 5% 1/4W
R715 1-249-430-11 CARBON 12K 5% 1/4W

39
HCD-RG11
CD DRIVER MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
R784 1-247-807-31 CARBON 100 5% 1/4W C110 1-162-306-11 CERAMIC 0.01uF 30% 16V
R785 1-247-889-00 CARBON 270K 5% 1/4W C111 1-162-306-11 CERAMIC 0.01uF 30% 16V
R788 1-249-417-11 CARBON 1K 5% 1/4W F
R791 1-249-429-11 CARBON 10K 5% 1/4W C112 1-130-487-00 MYLAR 0.022uF 5% 50V
R792 1-249-429-11 CARBON 10K 5% 1/4W C113 1-130-487-00 MYLAR 0.022uF 5% 50V
C114 1-126-957-11 ELECT 0.22uF 20% 50V
R793 1-249-429-11 CARBON 10K 5% 1/4W C115 1-127-884-21 CERAMIC 0.047uF 10% 50V
R794 1-249-429-11 CARBON 10K 5% 1/4W C116 1-126-965-11 ELECT 22uF 20% 50V
R703A 1-247-807-31 CARBON 100 5% 1/4W
R703B 1-247-807-31 CARBON 100 5% 1/4W C117 1-162-290-31 CERAMIC 470PF 10% 50V
R703C 1-247-807-31 CARBON 100 5% 1/4W C119 1-127-884-21 CERAMIC 0.047uF 10% 50V
C121 1-126-960-11 ELECT 1uF 20% 50V
R706A 1-249-437-11 CARBON 47K 5% 1/4W C122 1-126-964-11 ELECT 10uF 20% 50V
R706B 1-249-437-11 CARBON 47K 5% 1/4W C123 1-126-964-11 ELECT 10uF 20% 50V
R706C 1-249-437-11 CARBON 47K 5% 1/4W
R706D 1-249-437-11 CARBON 47K 5% 1/4W C124 1-126-933-11 ELECT 100uF 20% 16V
R706E 1-249-441-11 CARBON 100K 5% 1/4W C125 1-162-292-31 CERAMIC 680PF 10% 50V
C126 1-162-306-11 CERAMIC 0.01uF 30% 16V
R706F 1-249-441-11 CARBON 100K 5% 1/4W C127 1-162-306-11 CERAMIC 0.01uF 30% 16V
R745A 1-249-429-11 CARBON 10K 5% 1/4W C128 1-126-963-11 ELECT 4.7uF 20% 50V

< TEST PIN > C129 1-126-963-11 ELECT 4.7uF 20% 50V
C130 1-162-286-21 CERAMIC 220PF 10% 50V
* TP731 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P C133 1-126-961-11 ELECT 2.2uF 20% 50V
C134 1-126-961-11 ELECT 2.2uF 20% 50V
< VIBRATOR > C136 1-162-194-31 CERAMIC 3.9PF 10% 50V

X701 1-579-280-11 VIBRATOR, CRYSTAL 16.9344MHz C138 1-126-947-11 ELECT 47uF 20% 16V
************************************************************ C139 1-162-306-11 CERAMIC 0.01uF 30% 16V
C140 1-126-959-11 ELECT 0.47uF 20% 50V
1-675-912-14 DRIVER BOARD C141 1-162-306-11 CERAMIC 0.01uF 30% 16V
************* C142 1-128-801-11 CERAMIC 22PF 5% 50V

< CAPACITOR > C143 1-128-803-11 CERAMIC 33PF 5% 50V

C144 1-162-211-31 CERAMIC 33PF 5% 50V
C702 1-126-964-11 ELECT 10uF 20% 50V C145 1-162-286-31 CERAMIC 220PF 10% 50V
C146 1-162-286-31 CERAMIC 220PF 10% 50V
< CONNECTOR > C147 1-126-947-11 ELECT 47uF 20% 16V

CN702 1-785-550-11 CONNECTOR, FFC/FPC 8P C148 1-162-286-31 CERAMIC 220PF 10% 50V
C149 1-162-306-11 CERAMIC 0.01uF 30% 16V
< DIODE > C150 1-126-961-11 ELECT 2.2uF 20% 50V
C151 1-126-947-11 ELECT 47uF 20% 16V
D701 8-719-983-15 DIODE MTZJ-T-77-3.9A C152 1-162-306-11 CERAMIC 0.01uF 30% 16V

< IC > C153 1-162-294-31 CERAMIC 0.001uF 10% 50V

C154 1-162-294-31 CERAMIC 0.001uF 10% 50V
IC701 8-759-598-69 IC BA6956AN C155 1-162-306-11 CERAMIC 0.01uF 30% 16V
C157 1-162-306-11 CERAMIC 0.01uF 30% 16V
< RESISTOR > C201 1-162-292-31 CERAMIC 680PF 10% 50V

R701 1-249-411-11 CARBON 330 5% 1/4W C202 1-162-292-31 CERAMIC 680PF 10% 50V
R702 1-249-401-11 CARBON 47 5% 1/4W F C203 1-162-292-31 CERAMIC 680PF 10% 50V
************************************************************ C204 1-162-292-31 CERAMIC 680PF 10% 50V
C205 1-162-286-31 CERAMIC 220PF 10% 50V
A-4440-486-A MAIN BOARD, COMPLETE C206 1-162-286-31 CERAMIC 220PF 10% 50V
*********************
C207 1-162-286-31 CERAMIC 220PF 10% 50V
< CAPACITOR > C208 1-162-286-31 CERAMIC 220PF 10% 50V
C209 1-126-967-11 ELECT 47uF 20% 50V
C101 1-162-306-11 CERAMIC 0.01uF 30% 16V C210 1-126-967-11 ELECT 47uF 20% 50V
C102 1-162-306-11 CERAMIC 0.01uF 30% 16V C211 1-130-486-00 MYLAR 0.018uF 10% 50V
C104 1-162-306-11 CERAMIC 0.01uF 30% 16V
C105 1-162-306-11 CERAMIC 0.01uF 30% 16V C212 1-130-486-00 MYLAR 0.018uF 10% 50V
C106 1-162-306-11 CERAMIC 0.01uF 30% 16V C213 1-126-960-11 ELECT 1uF 20% 50V
C214 1-126-960-11 ELECT 1uF 20% 50V
C107 1-126-947-11 ELECT 47uF 20% 16V C215 1-127-870-31 CERAMIC 3300PF 10% 50V
C108 1-126-960-11 ELECT 1uF 20% 50V C216 1-127-870-31 CERAMIC 3300PF 10% 50V
C109 1-162-306-11 CERAMIC 0.01uF 30% 16V

40
 HCD-RG11
MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
C217 1-126-947-11 ELECT 47uF 20% 16V C345 1-162-215-31 CERAMIC 47PF 5% 50V
C218 1-104-661-91 ELECT 330uF 20% 16V C346 1-126-956-11 ELECT 0.1uF 20% 50V
C219 1-126-962-11 ELECT 3.3uF 20% 50V
C221 1-126-962-11 ELECT 3.3uF 20% 50V C347 1-126-960-11 ELECT 1uF 20% 50V
C222 1-126-962-11 ELECT 3.3uF 20% 50V C348 1-126-964-11 ELECT 10uF 20% 50V
C349 1-126-947-11 ELECT 47uF 20% 16V
C223 1-162-290-31 CERAMIC 470PF 10% 50V C350 1-107-717-11 ELECT 47uF 20% 50V
C224 1-162-290-31 CERAMIC 470PF 10% 50V C351 1-107-721-11 ELECT 4.7uF 20% 100V
C225 1-127-866-11 CERAMIC 1500PF 10% 50V
C226 1-127-866-11 CERAMIC 1500PF 10% 50V C352 1-107-721-11 ELECT 4.7uF 20% 100V
C227 1-162-286-31 CERAMIC 220PF 10% 50V C353 1-136-165-00 FILM 0.1uF 5% 50V
C354 1-136-165-00 FILM 0.1uF 5% 50V
C228 1-162-286-31 CERAMIC 220PF 10% 50V C355 1-136-165-00 FILM 0.1uF 5% 50V
C229 1-126-933-11 ELECT 100uF 20% 16V C356 1-136-165-00 FILM 0.1uF 5% 50V
C230 1-126-933-11 ELECT 100uF 20% 16V
C231 1-124-252-00 ELECT 0.33uF 20% 50V C357 1-126-961-11 ELECT 2.2uF 20% 50V
C232 1-124-252-00 ELECT 0.33uF 20% 50V C358 1-126-961-11 ELECT 2.2uF 20% 50V
C359 1-126-935-11 ELECT 470uF 20% 16V
C233 1-162-294-31 CERAMIC 0.001uF 10% 50V C360 1-126-964-11 ELECT 10uF 20% 50V
C234 1-162-294-31 CERAMIC 0.001uF 10% 50V C361 1-126-933-11 ELECT 100uF 20% 16V
C235 1-130-491-00 MYLAR 0.047uF 5% 50V
C236 1-130-491-00 MYLAR 0.047uF 5% 50V C362 1-107-698-11 ELECT 10uF 20% 25V
C237 1-161-494-00 CERAMIC 0.022uF 25V C363 1-126-956-11 ELECT 0.1uF 20% 50V
C364 1-126-956-11 ELECT 0.1uF 20% 50V
C238 1-126-961-11 ELECT 2.2uF 20% 50V C366 1-126-947-11 ELECT 47uF 20% 16V
C239 1-130-485-00 MYLAR 0.015uF 5% 50V C367 1-126-947-11 ELECT 47uF 20% 16V
C240 1-126-967-11 ELECT 47uF 20% 50V
C241 1-130-479-00 MYLAR 0.0047uF 5% 50V C369 1-162-294-31 CERAMIC 0.001uF 10% 50V
C242 1-130-485-00 MYLAR 0.015uF 5% 50V C370 1-162-294-31 CERAMIC 0.001uF 10% 50V
C371 1-164-159-11 CERAMIC 0.1uF 50V
C243 1-130-485-00 MYLAR 0.015uF 5% 50V C372 1-164-159-11 CERAMIC 0.1uF 50V
C244 1-126-956-11 ELECT 0.1uF 20% 50V C801 1-136-165-00 FILM 0.1uF 5% 50V
C313 1-127-868-31 CERAMIC 2200PF 10% 50V
C314 1-127-868-31 CERAMIC 2200PF 10% 50V C802 1-136-165-00 FILM 0.1uF 5% 50V
C315 1-127-868-31 CERAMIC 2200PF 10% 50V C805 1-126-768-11 ELECT 2200uF 20% 16V
C806 1-126-943-11 ELECT 2200uF 20% 25V
C316 1-136-169-00 FILM 0.22uF 5% 50V C807 1-126-964-11 ELECT 10uF 20% 50V
C317 1-136-169-00 FILM 0.22uF 5% 50V C808 1-126-916-11 ELECT 1000uF 20% 6.3V
C318 1-136-169-00 FILM 0.22uF 5% 50V
C319 1-126-934-11 ELECT 220uF 20% 16V C809 1-126-964-11 ELECT 10uF 20% 50V
C320 1-136-169-00 FILM 0.22uF 5% 50V C810 1-126-933-11 ELECT 100uF 20% 16V
C811 1-126-964-11 ELECT 10uF 20% 50V
C321 1-126-947-11 ELECT 47uF 20% 16V C812 1-161-494-00 CERAMIC 0.022uF 25V
C323 1-126-947-11 ELECT 47uF 20% 16V C813 1-126-916-11 ELECT 1000uF 20% 6.3V
C324 1-126-961-11 ELECT 2.2uF 20% 50V
C325 1-126-961-11 ELECT 2.2uF 20% 50V C814 1-126-964-11 ELECT 10uF 20% 50V
C326 1-162-199-31 CERAMIC 10PF 5% 50V C815 1-126-933-11 ELECT 100uF 20% 16V
C819 1-161-494-00 CERAMIC 0.022uF 25V
C327 1-162-199-31 CERAMIC 10PF 5% 50V C827 1-130-483-00 MYLAR 0.01uF 5% 50V
C328 1-126-933-11 ELECT 100uF 20% 16V C828 1-130-483-00 MYLAR 0.01uF 5% 50V
C329 1-126-961-11 ELECT 2.2uF 20% 50V
C330 1-126-961-11 ELECT 2.2uF 20% 50V < FILTER >
C331 1-109-953-11 ELECT 2.2uF 20% 50V
CF101 1-579-185-21 FILTER, CERAMIC
C332 1-109-953-11 ELECT 2.2uF 20% 50V CF102 1-579-185-21 FILTER, CERAMIC
C333 1-126-961-11 ELECT 2.2uF 20% 50V
C334 1-126-961-11 ELECT 2.2uF 20% 50V < CONNECTOR >
C335 1-126-960-11 ELECT 1uF 20% 50V
C336 1-126-960-11 ELECT 1uF 20% 50V * CN201 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
CN202 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
C337 1-126-960-11 ELECT 1uF 20% 50V * CN203 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P
C338 1-126-960-11 ELECT 1uF 20% 50V * CN305 1-770-392-11 PIN, CONNECTOR (PC BOARD) 8P
C339 1-126-964-11 ELECT 10uF 20% 50V CN402 1-778-982-21 CONNECTOR, BOARD TO BOARD 13P
C340 1-126-964-11 ELECT 10uF 20% 50V
C341 1-161-494-00 CERAMIC 0.022uF 25V CN403 1-778-982-21 CONNECTOR, BOARD TO BOARD 13P
CN603 1-793-766-11 CONNECTOR, BOARD TO BOARD 30P
C342 1-162-215-31 CERAMIC 47PF 5% 50V * CN704 1-564-709-11 PIN, CONNECTOR (SMALL TYPE) 7P
C343 1-126-933-11 ELECT 100uF 20% 16V
C344 1-126-960-11 ELECT 1uF 20% 50V

41
HCD-RG11
MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
< CRYSTAL VIBRATOR > < COIL >

CX101 1-760-549-31 VIBRATOR, CRYSTAL 4.5MHz L101 1-414-186-31 INDUCTOR 33uH

L102 1-414-177-11 INDUCTOR 1uH
< DIODE > L251 1-424-849-11 COIL, OSCILLATION (BIAS)
L351 1-420-872-00 COIL, AIR-CORE
D103 8-719-109-97 DIODE MTZJ-6.8B L352 1-420-872-00 COIL, AIR-CORE
D105 8-719-991-33 DIODE 1SS133T-77
D111 8-719-991-33 DIODE 1SS133T-77 < TRANSISTOR >
D112 8-719-991-33 DIODE 1SS133T-77
D202 8-719-991-33 DIODE 1SS133T-77 Q101 8-729-015-41 TRANSISTOR 2SC1675-T1
Q102 8-729-422-57 TRANSISTOR BN1A4M-TP
D203 8-719-991-33 DIODE 1SS133T-77 Q105 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
D204 8-719-991-33 DIODE 1SS133T-77 Q106 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
D205 8-719-991-33 DIODE 1SS133T-77 Q201 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D304 8-719-929-15 DIODE MTZJ-9.1B
D309 8-719-991-33 DIODE 1SS133T-77 Q202 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q203 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D310 8-719-991-33 DIODE 1SS133T-77 Q204 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D311 8-719-991-33 DIODE 1SS133T-77 Q205 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D312 8-719-991-33 DIODE 1SS133T-77 Q206 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D313 8-719-991-33 DIODE 1SS133T-77
D315 8-719-200-82 DIODE 11ES2-TB5 Q207 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
Q208 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
D316 8-719-200-82 DIODE 11ES2-TB5 Q209 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
D801 8-719-200-82 DIODE 11ES2-TB5 Q210 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
D802 8-719-200-82 DIODE 11ES2-TB5 Q211 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
D803 8-719-200-82 DIODE 11ES2-TB5
D804 8-719-200-82 DIODE 11ES2-TB5 Q212 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q213 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D809 8-719-200-82 DIODE 11ES2-TB5 Q214 8-729-142-46 TRANSISTOR 2SC2001TP-LK
D810 8-719-200-82 DIODE 11ES2-TB5 Q215 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
D811 8-719-991-33 DIODE 1SS133T-77 Q216 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
D812 8-719-200-82 DIODE 11ES2-TB5
D813 8-719-200-82 DIODE 11ES2-TB5 Q303 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q304 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
D814 8-719-200-82 DIODE 11ES2-TB5 Q305 8-729-900-63 TRANSISTOR BN1F4M-TP
D815 8-719-200-82 DIODE 11ES2-TB5 Q306 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
Q307 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
< FRONT END >
Q308 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
FE103 1-693-496-11 FRONT END (4 GANG) Q309 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q311 8-729-119-76 TRANSISTOR 2SA1175TP-HFE
< TERMINAL > Q312 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q313 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
* GND1 1-537-738-21 TERMINAL, EARTH
Q314 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
< IC > Q315 8-729-900-80 TRANSISTOR BA1A4M-TP
Q316 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
IC101 8-759-652-00 IC BA1450 Q320 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
IC102 8-759-288-54 IC LC72130 Q321 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
IC201 8-759-242-58 IC TA8189N
IC301 6-700-305-01 IC BD3871FS Q801 8-729-900-80 TRANSISTOR BA1A4M-TP
IC302 8-759-505-55 IC NJM4558L Q802 8-729-049-79 TRANSISTOR RT1P137S-TP
Q803 8-729-900-63 TRANSISTOR BN1F4M-TP
IC801 8-759-701-59 IC M5F7809L Q804 8-729-900-80 TRANSISTOR BA1A4M-TP
IC802 8-759-088-08 IC uPC7812AHF
IC803 8-759-039-69 IC uPC7805AHF < RESISTOR >
IC804 8-759-039-69 IC uPC7805AHF
R101 1-249-407-11 CARBON 150 5% 1/4W F
< IFT > R102 1-249-415-11 CARBON 680 5% 1/4W F
R103 1-249-415-11 CARBON 680 5% 1/4W F
IFT101 1-435-295-11 TRANSFORMER, IF R104 1-249-411-11 CARBON 330 5% 1/4W
R105 1-249-419-11 CARBON 1.5K 5% 1/4W F
< TERMINAL BOARD >
R106 1-249-401-11 CARBON 47 5% 1/4W F
JK101 1-694-556-21 TERMINAL BOARD (ANT.PAL)(ANTENNA) R107 1-249-401-11 CARBON 47 5% 1/4W F
JK310 1-694-635-11 TERMINAL BOARD (4P)(SPEAKER) R108 1-249-409-11 CARBON 220 5% 1/4W F
R109 1-249-425-11 CARBON 4.7K 5% 1/4W F

42
 HCD-RG11
MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
R110 1-249-421-11 CARBON 2.2K 5% 1/4W F R229 1-249-422-11 CARBON 2.7K 5% 1/4W F
R230 1-249-422-11 CARBON 2.7K 5% 1/4W F
R111 1-249-429-11 CARBON 10K 5% 1/4W R231 1-249-421-11 CARBON 2.2K 5% 1/4W F
R112 1-249-430-11 CARBON 12K 5% 1/4W R232 1-249-421-11 CARBON 2.2K 5% 1/4W F
R113 1-249-429-11 CARBON 10K 5% 1/4W
R114 1-249-429-11 CARBON 10K 5% 1/4W R233 1-249-409-11 CARBON 220 5% 1/4W F
R115 1-249-429-11 CARBON 10K 5% 1/4W R234 1-247-843-11 CARBON 3.3K 5% 1/4W
R235 1-247-843-11 CARBON 3.3K 5% 1/4W
R116 1-249-441-11 CARBON 100K 5% 1/4W R236 1-249-425-11 CARBON 4.7K 5% 1/4W F
R117 1-247-807-31 CARBON 100 5% 1/4W R237 1-249-425-11 CARBON 4.7K 5% 1/4W F
R118 1-249-425-11 CARBON 4.7K 5% 1/4W F
R119 1-249-429-11 CARBON 10K 5% 1/4W R238 1-249-429-11 CARBON 10K 5% 1/4W
R120 1-249-429-11 CARBON 10K 5% 1/4W R239 1-249-425-11 CARBON 4.7K 5% 1/4W F
R240 1-249-425-11 CARBON 4.7K 5% 1/4W F
R121 1-249-415-11 CARBON 680 5% 1/4W F R241 1-249-421-11 CARBON 2.2K 5% 1/4W F
R122 1-249-425-11 CARBON 4.7K 5% 1/4W F R242 1-249-434-11 CARBON 27K 5% 1/4W
R123 1-249-425-11 CARBON 4.7K 5% 1/4W F
R128 1-249-425-11 CARBON 4.7K 5% 1/4W F R244 1-249-430-11 CARBON 12K 5% 1/4W
R129 1-247-807-31 CARBON 100 5% 1/4W R245 1-249-429-11 CARBON 10K 5% 1/4W
R246 1-249-421-11 CARBON 2.2K 5% 1/4W F
R130 1-249-425-11 CARBON 4.7K 5% 1/4W F R247 1-249-425-11 CARBON 4.7K 5% 1/4W F
R131 1-247-807-31 CARBON 100 5% 1/4W R248 1-249-425-11 CARBON 4.7K 5% 1/4W F
R132 1-249-421-11 CARBON 2.2K 5% 1/4W F
R133 1-249-421-11 CARBON 2.2K 5% 1/4W F R249 1-249-413-11 CARBON 470 5% 1/4W F
R134 1-249-421-11 CARBON 2.2K 5% 1/4W F R250 1-249-393-11 CARBON 10 5% 1/4W F
R251 1-249-434-11 CARBON 27K 5% 1/4W
R135 1-247-843-11 CARBON 3.3K 5% 1/4W R252 1-249-381-11 CARBON 1 5% 1/4W F
R136 1-249-431-11 CARBON 15K 5% 1/4W R253 1-249-425-11 CARBON 4.7K 5% 1/4W F
R137 1-249-429-11 CARBON 10K 5% 1/4W
R138 1-249-429-11 CARBON 10K 5% 1/4W R253 1-249-437-11 CARBON 47K 5% 1/4W
R139 1-249-417-11 CARBON 1K 5% 1/4W F R254 1-249-425-11 CARBON 4.7K 5% 1/4W F
R307 1-249-441-11 CARBON 100K 5% 1/4W
R140 1-249-429-11 CARBON 10K 5% 1/4W R308 1-249-441-11 CARBON 100K 5% 1/4W
R141 1-249-421-11 CARBON 2.2K 5% 1/4W F R314 1-249-426-11 CARBON 5.6K 5% 1/4W
R142 1-249-429-11 CARBON 10K 5% 1/4W
R143 1-249-431-11 CARBON 15K 5% 1/4W R315 1-249-426-11 CARBON 5.6K 5% 1/4W
R201 1-249-393-11 CARBON 10 5% 1/4W F R316 1-247-893-11 CARBON 390K 5% 1/4W
R317 1-247-893-11 CARBON 390K 5% 1/4W
R202 1-249-393-11 CARBON 10 5% 1/4W F R323 1-249-437-11 CARBON 47K 5% 1/4W
R203 1-249-393-11 CARBON 10 5% 1/4W F R325 1-249-437-11 CARBON 47K 5% 1/4W
R204 1-249-393-11 CARBON 10 5% 1/4W F
R205 1-249-401-11 CARBON 47 5% 1/4W F R327 1-249-413-11 CARBON 470 5% 1/4W F
R206 1-249-401-11 CARBON 47 5% 1/4W F R329 1-249-437-11 CARBON 47K 5% 1/4W
R330 1-249-437-11 CARBON 47K 5% 1/4W
R207 1-249-428-11 CARBON 8.2K 5% 1/4W F R331 1-249-429-11 CARBON 10K 5% 1/4W
R208 1-249-428-11 CARBON 8.2K 5% 1/4W F R332 1-249-429-11 CARBON 10K 5% 1/4W
R209 1-247-889-00 CARBON 270K 5% 1/4W
R210 1-247-889-00 CARBON 270K 5% 1/4W R335 1-249-429-11 CARBON 10K 5% 1/4W
R211 1-247-891-00 CARBON 330K 5% 1/4W R336 1-249-429-11 CARBON 10K 5% 1/4W
R337 1-259-880-11 CARBON 2.2M 5% 1/4W
R212 1-247-891-00 CARBON 330K 5% 1/4W R338 1-259-880-11 CARBON 2.2M 5% 1/4W
R213 1-249-425-11 CARBON 4.7K 5% 1/4W F R339 1-249-413-11 CARBON 470 5% 1/4W F
R214 1-249-425-11 CARBON 4.7K 5% 1/4W F
R215 1-247-891-00 CARBON 330K 5% 1/4W R340 1-249-437-11 CARBON 47K 5% 1/4W
R216 1-247-891-00 CARBON 330K 5% 1/4W R341 1-249-437-11 CARBON 47K 5% 1/4W
R342 1-247-807-31 CARBON 100 5% 1/4W
R217 1-249-429-11 CARBON 10K 5% 1/4W R343 1-249-426-11 CARBON 5.6K 5% 1/4W
R219 1-249-437-11 CARBON 47K 5% 1/4W R344 1-249-426-11 CARBON 5.6K 5% 1/4W
R220 1-249-433-11 CARBON 22K 5% 1/4W
R221 1-247-881-00 CARBON 120K 5% 1/4W R345 1-249-425-11 CARBON 4.7K 5% 1/4W F
R222 1-247-881-00 CARBON 120K 5% 1/4W R346 1-249-425-11 CARBON 4.7K 5% 1/4W F
R347 1-249-429-11 CARBON 10K 5% 1/4W
R223 1-247-885-00 CARBON 180K 5% 1/4W R348 1-249-429-11 CARBON 10K 5% 1/4W
R224 1-247-885-00 CARBON 180K 5% 1/4W R349 1-249-429-11 CARBON 10K 5% 1/4W
R225 1-249-433-11 CARBON 22K 5% 1/4W
R226 1-249-433-11 CARBON 22K 5% 1/4W R350 1-249-429-11 CARBON 10K 5% 1/4W
R227 1-247-881-00 CARBON 120K 5% 1/4W R351 1-249-417-11 CARBON 1K 5% 1/4W F
R352 1-249-426-11 CARBON 5.6K 5% 1/4W
R228 1-247-881-00 CARBON 120K 5% 1/4W R353 1-249-417-11 CARBON 1K 5% 1/4W F

43
HCD-RG11
MAIN MOTOR PANEL

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
R354 1-249-417-11 CARBON 1K 5% 1/4W F < TRANSFORMER >

R355 1-249-437-11 CARBON 47K 5% 1/4W T101 1-435-195-31 TRANSFORMER, DISCRIMINATOR

R356 1-249-438-11 CARBON 56K 5% 1/4W T102 1-234-477-11 ENCAPSULATED COMPONENT
R357 1-260-076-11 CARBON 10 5% 1/2W ************************************************************
R358 1-260-076-11 CARBON 10 5% 1/2W
R359 1-249-429-11 CARBON 10K 5% 1/4W 1-675-910-14 MOTOR BOARD
*************
R360 1-249-433-11 CARBON 22K 5% 1/4W
R361 1-249-425-11 CARBON 4.7K 5% 1/4W F < CAPACITOR >
R362 1-249-433-11 CARBON 22K 5% 1/4W
R363 1-249-426-11 CARBON 5.6K 5% 1/4W C721 1-162-306-11 CERAMIC 0.01uF 30% 16V
R364 1-249-429-11 CARBON 10K 5% 1/4W
< CONNECTOR >
R365 1-215-891-11 METAL OXIDE 680 5% 2W
R366 1-215-891-11 METAL OXIDE 680 5% 2W CN721 1-770-516-31 CONNECTOR, FFC 8P
R367 1-249-437-11 CARBON 47K 5% 1/4W CN722 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE)4P
R368 1-249-441-11 CARBON 100K 5% 1/4W
R369 1-249-435-11 CARBON 33K 5% 1/4W < SWITCH >

R370 1-249-429-11 CARBON 10K 5% 1/4W S701 1-771-822-11 SWITCH, LEVER (SLIDE)(OPEN/CLOSE SW)
R371 1-247-885-00 CARBON 180K 5% 1/4W ************************************************************
R372 1-247-899-11 CARBON 680K 5% 1/4W
R373 1-249-429-11 CARBON 10K 5% 1/4W A-4726-769-A PANEL BOARD, COMPLETE
R374 1-249-409-11 CARBON 220 5% 1/4W F **********************

R375 1-249-411-11 CARBON 330 5% 1/4W 1-791-897-11 WIRE (FLAT TYPE) (19 CORE)
R376 1-247-885-00 CARBON 180K 5% 1/4W 1-823-058-11 WIRE (FLAT TYPE) (17 CORE)
R377 1-247-899-11 CARBON 680K 5% 1/4W 4-234-712-01 FL HOLDER
R378 1-249-411-11 CARBON 330 5% 1/4W
R379 1-249-429-11 CARBON 10K 5% 1/4W < CAPACITOR >

R380 1-249-441-11 CARBON 100K 5% 1/4W C601 1-126-916-11 ELECT 1000uF 20% 6.3V
R381 1-249-429-11 CARBON 10K 5% 1/4W C602 1-161-494-00 CERAMIC 0.022uF 25V
R382 1-249-425-11 CARBON 4.7K 5% 1/4W F C603 1-104-665-11 ELECT 100uF 20% 10V
R383 1-249-425-11 CARBON 4.7K 5% 1/4W F C604 1-161-494-00 CERAMIC 0.022uF 25V
R384 1-249-441-11 CARBON 100K 5% 1/4W C605 1-126-947-11 ELECT 47uF 20% 10V

R385 1-249-417-11 CARBON 1K 5% 1/4W F C606 1-126-964-11 ELECT 10uF 20% 50V
R386 1-260-076-11 CARBON 10 5% 1/2W C607 1-161-494-00 CERAMIC 0.022uF 25V
R387 1-260-076-11 CARBON 10 5% 1/2W C608 1-126-961-11 ELECT 2.2uF 20% 50V
R388 1-249-431-11 CARBON 15K 5% 1/4W C609 1-126-960-11 ELECT 1uF 20% 50V
R389 1-249-437-11 CARBON 47K 5% 1/4W C610 1-164-159-11 CERAMIC 0.1uF 50V

R390 1-249-437-11 CARBON 47K 5% 1/4W C611 1-126-947-11 ELECT 47uF 20% 10V
R391 1-249-441-11 CARBON 100K 5% 1/4W C612 1-126-957-11 ELECT 0.22uF 20% 50V
R392 1-249-402-11 CARBON 56 5% 1/4W F C613 1-126-957-11 ELECT 0.22uF 20% 50V
R393 1-249-402-11 CARBON 56 5% 1/4W F C614 1-128-801-11 CERAMIC 22PF 5% 50V
R394 1-249-441-11 CARBON 100K 5% 1/4W C615 1-128-802-11 CERAMIC 27PF 5% 50V

R396 1-249-429-11 CARBON 10K 5% 1/4W C616 1-161-494-00 CERAMIC 0.022uF 25V
R397 1-249-429-11 CARBON 10K 5% 1/4W C617 1-126-964-11 ELECT 10uF 20% 50V
R398 1-249-421-11 CARBON 2.2K 5% 1/4W F C618 1-162-286-31 CERAMIC 220PF 10% 50V
R399 1-249-421-11 CARBON 2.2K 5% 1/4W F C619 1-162-286-31 CERAMIC 220PF 10% 50V
R205A 1-249-409-11 CARBON 220 5% 1/4W F C620 1-162-286-31 CERAMIC 220PF 10% 50V

R206A 1-249-409-11 CARBON 220 5% 1/4W F C621 1-126-964-11 ELECT 10uF 20% 50V
C622 1-162-294-31 CERAMIC 0.001uF 10% 50V
< COMPOSITION CIRCUIT BLOCK > C623 1-110-671-31 CERAMIC 47000PF 50V
C624 1-110-671-31 CERAMIC 47000PF 50V
RB101 1-234-457-11 ENCAPSULATED COMPONENT C625 1-110-671-31 CERAMIC 47000PF 50V

< RELAY > C626 1-110-671-31 CERAMIC 47000PF 50V

C627 1-162-294-31 CERAMIC 0.001uF 10% 50V
RL1 1-755-373-11 RELAY C628 1-162-294-31 CERAMIC 0.001uF 10% 50V
C629 1-164-159-11 CERAMIC 0.1uF 50V
< VARIABLE RESISTOR > C630 1-162-282-31 CERAMIC 100PF 10% 50V

RV101 1-241-765-11 RES, ADJ, CARBON 22K C631 1-162-282-31 CERAMIC 100PF 10% 50V

44
 HCD-RG11
PANEL

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
C632 1-162-282-31 CERAMIC 100PF 10% 50V LED607 8-719-084-19 DIODE LTL77HKYTNN (TAPE A/B)
C633 1-162-282-31 CERAMIC 100PF 10% 50V LED608 8-719-084-19 DIODE LTL77HKYTNN (GAME)
C634 1-162-282-31 CERAMIC 100PF 10% 50V LED609 8-719-084-19 DIODE LTL77HKYTNN (GAME)
C635 1-162-282-31 CERAMIC 100PF 10% 50V
< TRANSISTOR >
C636 1-162-306-11 CERAMIC 0.01uF 30% 16V
C637 1-162-306-11 CERAMIC 0.01uF 30% 16V Q601 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
C638 1-162-294-31 CERAMIC 0.001uF 10% 50V Q602 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
C639 1-162-294-31 CERAMIC 0.001uF 10% 50V Q603 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
C640 1-164-159-11 CERAMIC 0.1uF 50V Q604 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
Q605 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
C641 1-164-159-11 CERAMIC 0.1uF 50V
C644 1-164-159-11 CERAMIC 0.1uF 50V Q606 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
Q607 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
< CONNECTOR > Q608 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
Q651 8-729-900-80 TRANSISTOR BA1A4M-TP
CN601 1-784-739-11 CONNECTOR, FFC 17P
CN602 1-784-741-11 CONNECTOR, FFC 19P < RESISTOR >
CN603 1-793-767-11 CONNECTOR, BOARD TO BOARD 30P
CN604 1-770-401-11 HOUSING, CONNECTOR (PC BOARD)8P R601 1-249-437-11 CARBON 47K 5% 1/4W
R603 1-249-417-11 CARBON 1K 5% 1/4W F
< DIODE > R604 1-249-437-11 CARBON 47K 5% 1/4W
R605 1-249-417-11 CARBON 1K 5% 1/4W F
D601 8-719-200-82 DIODE 11ES2-NTA1B R606 1-249-437-11 CARBON 47K 5% 1/4W
D602 8-719-200-82 DIODE 11ES2-NTA1B
D603 8-719-991-33 DIODE 1SS133T-77 R607 1-249-401-11 CARBON 47 5% 1/4W F
D604 8-719-991-33 DIODE 1SS133T-77 R609 1-247-887-00 CARBON 220K 5% 1/4W
D605 8-719-991-33 DIODE 1SS133T-77 R610 1-247-887-00 CARBON 220K 5% 1/4W
R612 1-249-415-11 CARBON 680 5% 1/4W F
D606 8-719-991-33 DIODE 1SS133T-77 R614 1-249-401-11 CARBON 47 5% 1/4W F
D607 8-719-991-33 DIODE 1SS133T-77
D608 8-719-991-33 DIODE 1SS133T-77 R615 1-249-417-11 CARBON 1K 5% 1/4W F
D609 8-719-991-33 DIODE 1SS133T-77 R617 1-249-417-11 CARBON 1K 5% 1/4W F
D610 8-719-991-33 DIODE 1SS133T-77 R618 1-249-417-11 CARBON 1K 5% 1/4W F
R619 1-249-417-11 CARBON 1K 5% 1/4W F
D611 8-719-991-33 DIODE 1SS133T-77 R620 1-249-429-11 CARBON 10K 5% 1/4W
D615 8-719-991-33 DIODE 1SS133T-77
R621 1-247-807-31 CARBON 100 5% 1/4W
< FERRITE BEAD > R622 1-247-807-31 CARBON 100 5% 1/4W
R623 1-247-807-31 CARBON 100 5% 1/4W
FB601 1-412-473-41 INDUCTOR 0uH R625 1-249-417-11 CARBON 1K 5% 1/4W F
R626 1-249-417-11 CARBON 1K 5% 1/4W F
< FLUORESCENT INDICATOR >
R627 1-249-417-11 CARBON 1K 5% 1/4W F
FLD601 1-518-730-11 TUBE, FLUORESCENT INDICATOR R628 1-249-417-11 CARBON 1K 5% 1/4W F
R629 1-249-417-11 CARBON 1K 5% 1/4W F
< IC > R630 1-247-807-31 CARBON 100 5% 1/4W
R631 1-247-807-31 CARBON 100 5% 1/4W
IC601 6-800-240-02 IC LC866540A-5V62
IC602 8-759-355-22 IC BU2114F-E2 R632 1-247-807-31 CARBON 100 5% 1/4W
R633 1-247-807-31 CARBON 100 5% 1/4W
< JACK > R634 1-247-807-31 CARBON 100 5% 1/4W
R635 1-247-807-31 CARBON 100 5% 1/4W
JK601 1-691-293-21 JACK (PHONES) R636 1-249-421-11 CARBON 2.2K 5% 1/4W F
JK603 1-815-684-11 JACK, PIN 3P (GAME INPUT)
R637 1-249-425-11 CARBON 4.7K 5% 1/4W F
< COIL > R638 1-249-415-11 CARBON 680 5% 1/4W F
R639 1-249-417-11 CARBON 1K 5% 1/4W F
L602 1-414-187-11 INDUCTOR 47uH R640 1-249-421-11 CARBON 2.2K 5% 1/4W F
R641 1-249-425-11 CARBON 4.7K 5% 1/4W F
< LED >
R642 1-249-415-11 CARBON 680 5% 1/4W F
LED601 8-719-084-69 DIODE LTL-77HKETNN (POWER) R643 1-249-417-11 CARBON 1K 5% 1/4W F
LED602 8-719-084-19 DIODE LTL77HKYTNN (CD) R644 1-249-421-11 CARBON 2.2K 5% 1/4W F
LED603 8-719-084-19 DIODE LTL77HKYTNN (CD) R645 1-249-425-11 CARBON 4.7K 5% 1/4W F
LED604 8-719-084-19 DIODE LTL77HKYTNN (TUNER/BAND) R646 1-249-415-11 CARBON 680 5% 1/4W F
LED605 8-719-084-19 DIODE LTL77HKYTNN (TUNER/BAND)
R647 1-249-417-11 CARBON 1K 5% 1/4W F
LED606 8-719-084-19 DIODE LTL77HKYTNN (TAPE A/B) R648 1-249-429-11 CARBON 10K 5% 1/4W

45
HCD-RG11
PANEL POWER

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
R649 1-249-429-11 CARBON 10K 5% 1/4W S603 1-762-196-21 SWITCH, TACT (M+)
R650 1-249-429-11 CARBON 10K 5% 1/4W S604 1-762-196-21 SWITCH, TACT (>)
R651 1-249-429-11 CARBON 10K 5% 1/4W S605 1-762-196-21 SWITCH, TACT (X)

R652 1-249-429-11 CARBON 10K 5% 1/4W S606 1-762-196-21 SWITCH, TACT (H)
R653 1-249-429-11 CARBON 10K 5% 1/4W S607 1-762-196-21 SWITCH, TACT (x)
R654 1-249-437-11 CARBON 47K 5% 1/4W S608 1-762-196-21 SWITCH, TACT (.)
R655 1-247-807-31 CARBON 100 5% 1/4W S609 1-762-196-21 SWITCH, TACT (m-)
R656 1-247-807-31 CARBON 100 5% 1/4W S612 1-762-196-21 SWITCH, TACT (MOVIE EQ)

R657 1-247-807-31 CARBON 100 5% 1/4W S613 1-762-196-21 SWITCH, TACT (EFFECT ON/OFF)
R658 1-247-807-31 CARBON 100 5% 1/4W S614 1-762-196-21 SWITCH, TACT (GAME EQ)
R659 1-247-807-31 CARBON 100 5% 1/4W S615 1-762-196-21 SWITCH, TACT (MUSIC EQ)
R660 1-247-807-31 CARBON 100 5% 1/4W S616 1-762-196-21 SWITCH, TACT (DISPLAY)
R661 1-249-415-11 CARBON 680 5% 1/4W F S617 1-762-196-21 SWITCH, TACT (GAME)

R662 1-249-416-11 CARBON 820 5% 1/4W F S618 1-762-196-21 SWITCH, TACT (TAPE A/B)
R663 1-249-418-11 CARBON 1.2K 5% 1/4W F S619 1-762-196-21 SWITCH, TACT (TUNER/BAND)
R664 1-249-419-11 CARBON 1.5K 5% 1/4W F S620 1-762-196-21 SWITCH, TACT (CD)
R665 1-249-421-11 CARBON 2.2K 5% 1/4W F S623 1-762-196-21 SWITCH, TACT (GROOVE)
R666 1-247-843-11 CARBON 3.3K 5% 1/4W S624 1-762-196-21 SWITCH, TACT (ZOPEN/CLOSE)

R667 1-249-425-11 CARBON 4.7K 5% 1/4W F S625 1-762-196-21 SWITCH, TACT (DISC3)
R668 1-249-428-11 CARBON 8.2K 5% 1/4W F S626 1-762-196-21 SWITCH, TACT (DISC2)
R669 1-249-419-11 CARBON 1.5K 5% 1/4W F S627 1-762-196-21 SWITCH, TACT (DISC1)
R670 1-249-419-11 CARBON 1.5K 5% 1/4W F S628 1-762-196-21 SWITCH, TACT (DISC SKIP EX-CHANGE)
R671 1-249-419-11 CARBON 1.5K 5% 1/4W F S629 1-762-196-21 SWITCH, TACT (?/1)

R672 1-249-418-11 CARBON 1.2K 5% 1/4W F < VARIABLE RESISTOR >

R673 1-249-416-11 CARBON 820 5% 1/4W F
R674 1-249-415-11 CARBON 680 5% 1/4W F SFR601 1-241-762-11 RES, ADJ, CARBON 2.2K
R675 1-249-421-11 CARBON 2.2K 5% 1/4W F
R676 1-247-843-11 CARBON 3.3K 5% 1/4W < ROTARY ENCODER >

R677 1-249-425-11 CARBON 4.7K 5% 1/4W F VR601 1-418-725-11 ENCODER, ROTARY (12 TYPE)(VOLUME)
R678 1-249-428-11 CARBON 8.2K 5% 1/4W F
R679 1-249-434-11 CARBON 27K 5% 1/4W < VIBRATOR >
R680 1-249-434-11 CARBON 27K 5% 1/4W
R681 1-249-415-11 CARBON 680 5% 1/4W F X601 1-795-398-11 VIBRATOR, CRYSTAL 6MHz
************************************************************
R682 1-249-416-11 CARBON 820 5% 1/4W F
R683 1-249-418-11 CARBON 1.2K 5% 1/4W F A-4726-770-A POWER BOARD, COMPLETE
R684 1-249-419-11 CARBON 1.5K 5% 1/4W F ***********************
R685 1-249-421-11 CARBON 2.2K 5% 1/4W F
R686 1-247-843-11 CARBON 3.3K 5% 1/4W < CAPACITOR >

R687 1-249-429-11 CARBON 10K 5% 1/4W C501 1-126-964-11 ELECT 10uF 20% 50V
R688 1-249-429-11 CARBON 10K 5% 1/4W C502 1-162-294-31 CERAMIC 0.001uF 10% 50V
R689 1-249-424-11 CARBON 3.9K 5% 1/4W F C503 1-162-282-31 CERAMIC 100PF 10% 50V
R691 1-247-807-31 CARBON 100 5% 1/4W C504 1-128-551-11 ELECT 22uF 20% 25V
R692 1-249-429-11 CARBON 10K 5% 1/4W C507 1-130-493-00 MYLAR 0.068uF 5% 50V

R693 1-249-429-11 CARBON 10K 5% 1/4W C508 1-130-493-00 MYLAR 0.068uF 5% 50V
R694 1-249-429-11 CARBON 10K 5% 1/4W C509 1-126-965-11 ELECT 22uF 20% 50V
R695 1-249-429-11 CARBON 10K 5% 1/4W C511 1-162-306-11 CERAMIC 0.01uF 30% 16V
R696 1-249-429-11 CARBON 10K 5% 1/4W C512 1-162-294-31 CERAMIC 0.001uF 10% 50V
R697 1-249-429-11 CARBON 10K 5% 1/4W C513 1-164-159-11 CERAMIC 0.1uF 50V

R698 1-249-429-11 CARBON 10K 5% 1/4W C541 1-130-777-00 MYLAR 0.1uF 10% 100V
R699 1-249-429-11 CARBON 10K 5% 1/4W C542 1-135-832-11 ELECT 2200uF 20% 50V
C543 1-164-159-11 CERAMIC 0.1uF 50V
< IC > C544 1-126-942-61 ELECT 1000uF 20% 25V
C545 1-128-549-11 ELECT 3300uF 20% 35V
RM601 8-759-827-70 IC NJL64H400A-1 (g)
C551 1-126-964-11 ELECT 10uF 20% 50V
< SWITCH > C552 1-162-294-31 CERAMIC 0.001uF 10% 50V
C553 1-162-282-31 CERAMIC 100PF 10% 50V
S601 1-762-196-21 SWITCH, TACT (REC PAUSE/START) C554 1-128-551-11 ELECT 22uF 20% 25V
S602 1-762-196-21 SWITCH, TACT (CD SYNC) C557 1-130-493-00 MYLAR 0.068uF 5% 50V

46
 HCD-RG11
POWER SPDL SUB TRANS

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
C558 1-130-493-00 MYLAR 0.068uF 5% 50V R556 1-249-431-11 CARBON 15K 5% 1/4W
C559 1-126-965-11 ELECT 22uF 20% 50V R557 1-249-441-11 CARBON 100K 5% 1/4W
C591 1-130-777-00 MYLAR 0.1uF 10% 100V 0 R558 1-217-151-00 METAL 0.22 10% 2W
C592 1-135-832-11 ELECT 2200uF 20% 50V R559 1-260-076-11 CARBON 10 5% 1/2W
0 R560 1-217-151-00 METAL 0.22 10% 2W
< CONNECTOR >
0 R561 1-212-881-11 FUSIBLE 100 5% 1/4W
CN502 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P R581 1-249-435-11 CARBON 33K 5% 1/4W
CN503 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P R582 1-249-435-11 CARBON 33K 5% 1/4W
R591 1-260-115-11 CARBON 22K 5% 1/2W
< DIODE > ************************************************************

D501 8-719-991-33 DIODE 1SS133T-77 1-682-124-11 SPDL BOARD

D502 8-719-991-33 DIODE 1SS133T-77 ***********
D541 8-719-510-68 DIODE D5SBA204101
D542 8-719-200-82 DIODE 11ES2-NTA1B < CONNECTOR >
D543 8-719-200-82 DIODE 11ES2-NTA1B
CN01 1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P
D551 8-719-991-33 DIODE 1SS133T-77
< SWITCH >
< TERMINAL >
S01 1-771-853-11 SWITCH, DETECTION (LIMIT SW)
* EP501 1-537-738-21 TERMINAL, EARTH ************************************************************
* EP502 1-537-738-21 TERMINAL, EARTH
A-4726-772-A SUB TRANS BOARD, COMPLETE
< IC > **************************

IC501 8-749-016-93 IC STK402-070S < CAPACITOR >

< TRANSISTOR > 0 C901 1-113-925-11 CERAMIC 0.01uF 20% 250V

C902 1-126-936-11 ELECT 3300uF 20% 16V
Q501 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA C903 1-126-933-11 ELECT 100uF 20% 16V
Q503 8-729-140-82 TRANSISTOR 2SA988TP-PAFAEA
Q504 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA < CONNECTOR >
Q551 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA
Q581 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA * CN2 1-564-321-21 PIN, CONNECTOR 2P
CN901 1-564-321-00 PIN, CONNECTOR 2P
< RESISTOR > * CN903 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P

R501 1-249-417-11 CARBON 1K 5% 1/4W F < DIODE >

R502 1-249-438-11 CARBON 56K 5% 1/4W
R503 1-249-421-11 CARBON 2.2K 5% 1/4W F D901 8-719-991-33 DIODE 1SS133T-77
R504 1-249-438-11 CARBON 56K 5% 1/4W D902 8-719-200-82 DIODE 11ES2-NTA1B
R505 1-249-417-11 CARBON 1K 5% 1/4W F D903 8-719-200-82 DIODE 11ES2-NTA1B
D904 8-719-200-82 DIODE 11ES2-NTA1B
R506 1-249-431-11 CARBON 15K 5% 1/4W D905 8-719-200-82 DIODE 11ES2-NTA1B
R507 1-249-441-11 CARBON 100K 5% 1/4W
0 R508 1-217-151-00 METAL 0.22 10% 2W < IC >
R509 1-260-076-11 CARBON 10 5% 1/2W
0 R510 1-217-151-00 METAL 0.22 10% 2W IC901 8-759-158-62 IC TA78057S

0 R511 1-212-881-11 FUSIBLE 100 5% 1/4W < TRANSISTOR >

0 R512 1-202-972-61 FUSIBLE 1 5% 1/4W
R513 1-249-433-11 CARBON 22K 5% 1/4W Q901 8-729-119-78 TRANSISTOR 2SC2785TP-HFE
R514 1-249-421-11 CARBON 2.2K 5% 1/4W F
R515 1-249-433-11 CARBON 22K 5% 1/4W < RESISTOR >

R516 1-249-429-11 CARBON 10K 5% 1/4W R902 1-249-429-11 CARBON 10K 5% 1/4W
R517 1-249-421-11 CARBON 2.2K 5% 1/4W F
R518 1-249-429-11 CARBON 10K 5% 1/4W < RELAY >
R519 1-249-433-11 CARBON 22K 5% 1/4W
R541 1-260-115-11 CARBON 22K 5% 1/2W 0 RY901 1-755-276-11 RELAY, POWER

R551 1-249-417-11 CARBON 1K 5% 1/4W F < TRANSFORMER >

R552 1-249-438-11 CARBON 56K 5% 1/4W
R553 1-249-421-11 CARBON 2.2K 5% 1/4W F 0 T901 1-435-824-21 TRANSFORMER, POWER
R554 1-249-438-11 CARBON 56K 5% 1/4W ************************************************************
R555 1-249-417-11 CARBON 1K 5% 1/4W F

The components identified by mark 0 or dotted

line with mark 0 are critical for safety.
Replace only with part number specified.

47
HCD-RG11
TRANS VIDEO OUT

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
A-4726-771-A TRANS BOARD, COMPLETE MISCELLANEOUS
********************** **************

< CAPACITOR > 9 1-791-897-11 WIRE (FLAT TYPE) (19 CORE)

74 1-796-122-11 DECK, MECH
C911 1-128-553-11 ELECT 220uF 20% 63V 75 1-823-058-11 WIRE (FLAT TYPE) (17 CORE)
C912 1-126-964-11 ELECT 10uF 20% 50V 0 103 1-777-071-81 CORD, POWER
C913 1-126-968-11 ELECT 100uF 20% 50V 159 1-791-983-11 WIRE (FLAT TYPE) (8 CORE)
C915 1-164-159-11 CERAMIC 0.1uF 50V 166 1-471-035-11 MAGNET ASSY

< CONNECTOR > 187 1-823-059-11 WIRE (FLAT TYPE) (16 CORE)
0 188 8-820-116-01 OPTICAL PICK-UP KSM-213DCP/Z-NP
CN915 1-564-528-11 PLUG, CONNECTOR 13P M721 1-541-632-11 MOTOR, DC (TURN)
0 T911 1-437-386-11 TRANSFORMER, POWER
< DIODE >

D911 8-719-200-82 DIODE 11ES2-NTA1B

D912 8-719-982-15 DIODE MTZJ-T-77-27B
D913 8-719-109-89 DIODE MTZJ-T-77-5.6B

< FUSE >

0 F914 1-532-506-31 FUSE 6.3A/250V

0 F917 1-533-468-11 FUSE, GLASS TUBE 2A/250V (DIA. 5)
0 F918 1-533-468-11 FUSE, GLASS TUBE 2A/250V (DIA. 5)

< FUSE HOLDER >

* FH903 1-533-213-31 HOLDER, FUSE

* FH904 1-533-213-31 HOLDER, FUSE
* FH907 1-533-213-31 HOLDER, FUSE
* FH908 1-533-213-31 HOLDER, FUSE
* FH909 1-533-213-31 HOLDER, FUSE

* FH910 1-533-213-31 HOLDER, FUSE

< TRANSISTOR >

Q911 8-729-048-52 TRANSISTOR 2SA1932(TP)

< RESISTOR >

R905 1-249-429-11 CARBON 10K 5% 1/4W

0 R911 1-217-637-00 FUSIBLE 1 5% 1/4W
R912 1-249-417-11 CARBON 1K 5% 1/4W F
R913 1-249-429-11 CARBON 10K 5% 1/4W
R915 1-247-807-31 CARBON 100 5% 1/4W

R916 1-247-807-31 CARBON 100 5% 1/4W

0 R919 1-219-122-91 FUSIBLE 0.33 5% 1/4W
0 R920 1-219-122-91 FUSIBLE 0.33 5% 1/4W
************************************************************

A-4726-511-A VIDEO OUT BOARD, COMPLETE

*************************

< CAPACITOR >

C642 1-162-294-31 CERAMIC 0.001uF 10% 50V

< CONNECTOR >

CN605 1-564-505-11 PLUG, CONNECTOR 2P

< JACK >

JK602 1-774-227-11 JACK, PIN 1P (VIDEO OUT)

************************************************************

The components identified by mark 0 or dotted

line with mark 0 are critical for safety.
Replace only with part number specified.

48
 HCD-RG11

MEMO

49
HCD-RG11

REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.

Ver. Date Description of Revision

1.0 2002.06 New